2006 DODGE CARAVAN

6 recalls, 231 complaints - 51 TSBs

EQUIPMENT

Defect Description

CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE... Read more

Consequence

IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.

Remedy

CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.

6,686 vehicles affected

Manufacturer: CURT MFG. INC.

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

Defect Description

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2005-2006 DODGE CARAVAN, GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KANSAS, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISS... Read more

Consequence

IF THE FRONT CRASH SENSORS BECOME INOPERATIVE, THE DRIVER IS IMMEDIATELY ALERTED BY ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE VEHICLE SHOULD BE PROMPTLY SERVICED. UNTIL THE VEHICLE IS REPAIRED, THE AIRBAGS MAY NOT PROVIDE THE ENHANCED PROTECTION IN THE EVENT OF A CRASH.

Remedy

CHRYSLER WILL REPLACE THE FRONT AIRBAG SENSORS WITH A NEW DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY IMPROVEMENT CAMPAIGN WILL BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

308,950 vehicles affected

Manufacturer: CHRYSLER GROUP LLC

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

EAGLE EYES IS RECALLING 11,534 HEADLAMP ASSEMBLIES, P/NOS. CS090-B001L AND CS090-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE LOWER BEAM PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, ... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

EAGLE EYES WILL NOTIFY OWNERS AND OFFER REPLACEMENT HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2008. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.

11,534 vehicles affected

Manufacturer: EAGLE EYES TRAFFIC INDUSTRIAL CO. LTD

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

MAXZONE IS RECALLING 2,520 HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 3341103L-AS AND 334-1103R-AS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 2001-2007 DODGE CARAVAN PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLEC... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JUNE 16, 2008. OWNERS MAY CONTACT MAXZONE AT THE FOLLOWING LOCATIONS: 1-888-286-1188 (WA, OR, CA, ID, NV, AZ, MT, WY, UT, CO, KS, NM, OK, TX, AR, LA, AK, HI) 1-877-253-8930 (ME, NH, VT, MA, CT... Read more

2,520 vehicles affected

Manufacturer: MAXZONE AUTO PARTS CORPORATION

VISIBILITY:GLASS, SIDE/REAR

Defect Description

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDER... Read more

Consequence

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

Remedy

SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER... Read more

1,657 vehicles affected

Manufacturer: SAFELITE FULFILLMENT, INC.

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

Defect Description

ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.

Consequence

DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.

Remedy

DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

268,800 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

Complaint Statistics

231 total complaints 13 crashes 4 fires 21 injuries

Top Reported Components

Component	Complaints
ELECTRICAL SYSTEM	28
STEERING	21
AIR BAGS	21
LATCHES/LOCKS/LINKAGES	15
ENGINE	14
EXTERIOR LIGHTING	14
FUEL/PROPULSION SYSTEM	12
ENGINE AND ENGINE COOLING	8
SERVICE BRAKES, HYDRAULIC	6
POWER TRAIN:AUTOMATIC TRANSMISSION	5

Incident date: Mar 13, 2024

Touchscreen radio delamination issue renders touchscreen unusable to use or control any and all settings, Bluetooth unresponsive, SiriusXM and FM radio random station change with no control, maps and Gps, phone, emergency services alerts, climate control, safety settings, interior and exterior ligh... Read more

Incident date: Mar 13, 2024

The contact owns a 2024 Honda Odyssey. The contact stated that while driving at an undisclosed speed, and while stopped at a red traffic light, the Automatic START/STOP system failed, causing the vehicle to unexpectedly shut off. The vehicle was restarted and drove normally. On another occasion, whi... Read more

Incident date: Aug 21, 2023

Hello My c300 2018 only have 79k and suddenly the engine light on, when I check it show that I need Positive Crankcase ventilation valve replace. it cost $2300. As I know a lot of people who own Merced have the same problem so should have a recall for that Thanks

Incident date: Aug 21, 2023

I have been having problems with my vehicle cutting off and I would jump start. It often gave be a theft code on the dash. Until one day it stops starting all together. Now to find out there is a recall on the electrical system I was told by my mechanic please contact me so I can get this resolved w... Read more

Incident date: Aug 21, 2023

Incident date: Apr 9, 2023

Vehicle failed inspection, AIR BAG LIGHT ON. Driver seat wire harness open left thorax squib must replace entire harness, air bag circuits cannot be repaired due to high resistance splicing causes. Part on Back order until August 2023!! Car cannot be repaired and is out of service, unable to drive, ... Read more

Incident date: Apr 4, 2021

WHEN GAS TANK IS FULL LEAKS FROM THE TOP OF TANK BY FUEL PUMP. FAULTY PUMP CRACKED AT SEAM AND LEAKS.

Incident date: Mar 4, 2020

PASSENGER SIDE AIR BAG EXPLODED. LUCKILY NO INJURY. VEHICLE WAS NOT MOVING. I DIDN'T EVEN KNOW IT COULD DO THAT! I'D LIKE THIS FIXED. ALSO, TWO LEAKS IN ENGINE. OIL LEAK/TRANSMISSION LEAK. IS THIS NORMAL? LEAKS ARE ONGOING. ANOTHER THING: NOTICING HEADLIGHTS GETTING SLIGHTLY DIMMER, THEN BRIGHTER, A... Read more

Incident date: Mar 4, 2020

Incident date: Dec 28, 2020

DRIVING DOWN A CROWDED INTERSTATE AND THE DASH CLUSTER STARTED GOING CRAZY THEN STOPPED WORKING. MECHANIC SAID IT WAS A KNIWN WIRING ISSUE WITH THE CLUSTER AND ANTI THEFT DEVICE.

Incident date: Dec 28, 2020

DRIVING DOWN A CROWDED INTERSTATE AND THE DASH CLUSTER STARTED GOING CRAZY THEN STOPPED WORKING. MECHANIC SAID IT WAS A KNIWN WIRING ISSUE WITH THE CLUSTER AND ANTI THEFT DEVICE.

Incident date: Jan 2, 2020

TL* THE CONTACT OWNS A 2006 DODGE CARAVAN. THE CONTACT STATED THAT ON SEVERAL OCCASIONS THE REAR TAIL LAMPS, HEADLAMPS, AND INSTRUMENT PANEL LIGHTS BECAME INOPERABLE. THE CONTACT STATED THAT THE INSTRUMENT PANEL LIGHTS BECAME DIM, THE INDICATOR LIGHTS AND HEADLAMPS FAILED TO OPERATE AS INTENDED. THE... Read more

Incident date: Aug 19, 2019

TL* THE CONTACT OWNS A 2006 DODGE CARAVAN. WHILE DRIVING, THE VEHICLE EXPERIENCED AN ELECTRICAL FAILURE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUSE BOX MALFUNCTIONED AND CAUSED THE VEHICLE'S COMPUTER TO FAIL. PATTERSON CHRYSLER DODGE JEEP RAM TYLER (3120 S SW LOOP 3... Read more

Incident date: Aug 19, 2019

Incident date: Mar 18, 2019

THE SLIDING DOORS OPEN AS YOUR TRAVELING DOWN THE ROAD.

Incident date: Feb 7, 2019

THE SLIDING DOOR LATCH MALFUNCTION WHERE DOOR COMES OPEN WHILE DRIVING THE AUTO LOCK ALSO MALFUNCTIONING. I'M A MASTER MECHANIC AND THIS ISN'T THE FIRST TIME I HEARD OF THIS PROBLEM ON THESE VEHICLES. MOPAR NEEDS TO HAVE THESE VEHICLES RECALLED BEFORE SOMEONE GETS HURT OR THEIR PET FALLS OUT.

Incident date: Feb 1, 2019

FUEL PUMP STARTED TO NOT PERFORM CAUSING IT FOR LAST YEAR REALLY BAD GASOLINE MILEAGE

Incident date: Sep 27, 2018

GAS LEAK ON THE TOP OF THE GAS TANK, WHEN IS ALMOST FULL.

Incident date: Nov 1, 2018

WHEN THE KEY IS OUT OF THE IGNITION,AND THE HEADLIGHT SWITCH IS OFF, THE PARKING LIGHTS COME ON AND GO OFF INTERMITTENTLY.SOMETIMES I WAKE UP TO A DEAD BATTERY.

Incident date: Aug 10, 2018

HEAD LIGHTS DULL & CRACKED. FRONT PASSANGER SEAT CATCHING NOT RETRACTING. REAR WINDOW WIPER JUST STOPS ANY POSISTION

Incident date: Aug 10, 2018

HEAD LIGHTS DULL & CRACKED. FRONT PASSANGER SEAT CATCHING NOT RETRACTING. REAR WINDOW WIPER JUST STOPS ANY POSISTION

Incident date: Aug 10, 2018

HEAD LIGHTS DULL & CRACKED. FRONT PASSANGER SEAT CATCHING NOT RETRACTING. REAR WINDOW WIPER JUST STOPS ANY POSISTION

Incident date: Jan 28, 2018

3 MONTHS AGO, ONE OF THE SLIDING DOORS STOPPED UNLOCKING, AND WILL NOT OPEN. NOW MY PASSENGER SIDE FRONT DOOR IS DOING THE SAME THING. MY AUTISTIC SON GOT STUCK IN THE VAN TODAY BECAUSE OF THIS. THE DOORS JUST WILL NOT UNLOCK.

Incident date: Jun 1, 2017

EVERY TIME I PUT ANY AMOUNT OF FUEL IN MY TANK OF MY 2006 DODGE CARAVAN SXT THERE IS A VERY STRONG SMELL OF GAS COMING FROM THE ENGINE COMPARTMENT AND AFTER THE VAN STARTS IT WILL ALWAYS STALL OUT WITHIN A MINUTE OR TWO OF STARTING UP. IT WILL STALL IDLING IN PARK AS WELL AS WHEN IN GEAR AND STARTIN... Read more

Incident date: Dec 3, 2016

TL* THE CONTACT OWNS A 2006 DODGE CARAVAN. ANOTHER VEHICLE CROSSED THE CONTACT'S PATH AND CRASHED INTO THE CONTACT'S VEHICLE. THE CONTACT FAINTED. THE DRIVER SUSTAINED HAND, WRIST, AND NECK PAINS. THE FRONT PASSENGER SUSTAINED NECK AND SPINAL INJURIES. MEDICAL ATTENTION WAS REQUIRED. THE AIR BAGS FA... Read more

Crash 2 injured

Incident date: May 22, 2017

VAN IDLES ROUGHLY AND STALLS IMMEDIATELY FOLLOWING REFUELING. WE DO NOT "TOP OFF" THE TANK BUT THE VAN STALLS WITHIN A MINUTE OF LEAVING THE GAS STATION. STALLING SEEMS TO OCCUR LESS IN COLDER TEMPERATURES BUT THE ROUGH IDLE IS CONSISTANT. THIS SEEMS LIKE THE SAME PROBLEM THAT WAS COVERED FOR 2004... Read more

Incident date: Mar 2, 2017

THE AIRBAG LIGHT IS ON & MECHANIC SAID IT'S THE LEFT SENSOR & SHOULD BE COVERED UNDER RECALL? IS THIS?

Incident date: Mar 8, 2017

EVERY TIME I FILL THE GAS TANK, IT WILL ONLY TAKE A FEW GALLONS BEFORE CLICKING THE PUMP OFF. AFTER FILLING TANK, WHILE DRIVING, THE ENGINE CUTS OFF, THEREBY CUTTING POWER STEERING AND BRAKES. CHECK ENGINE LIGHT COMES ON AND WHEN CHECKED IT SAYS EVAP SYSTEM.

Incident date: Jan 16, 2017

3 YRS AGO, FIRE IN ENGINE COMPARTMENT WHILE I WAS DRIVING. COULD NOT OPEN DOORS WINDOWS OR ENGINE HOOD. I DID HAVE WINDOW DOWN WHEN THIS OCCURRED. JUST LAST WEEK A WOMAN IN A CAR (TYPE NOT KNOWN-) IN SPOKANE WAS TRAPPED AND HAD TO BE RESCUED WHEN HER CAR CAUGHT FIRE AND SHE COULDN'T OPEN DOOR OR WIN... Read more

Fire

Incident date: Jan 16, 2017

Fire

Incident date: Dec 1, 2015

CURRENTLY HAVE ABOUT 86,000 ON THE VEHICLE. THE HEADLIGHTS, MORE AND MORE, ARE DECIDING TO REFUSE TO TURN ON. THERE IS NO DARKNESS INDICATOR, JUST AN OLD-FASHIONED TURN KNOB WITH THREE SETTINGS (OFF, PARKING LIGHTS, HEADLIGHTS). ALSO, THE HEADLIGHTS WHEN WORKING, DECIDE TO NOT SWITCH OFF WHEN THE... Read more

Incident date: Dec 1, 2015

Incident date: Sep 4, 2015

NEARLY EVERY TIME WE FILL THE GAS TANK UP (NOT PUMPING IN EXTRA AFTER IT STOPS TO "TOP IT OFF," JUST STOPPING WHEN IT FIRST CLICKS), THE ENGINE WILL DIE ABOUT 30-60 SECONDS AFTER WE START DRIVING AWAY, ALMOST AS IF THE ENGINE HAS FLOODED OR SOMETHING. IT SEEMS TO HAPPEN MOST FREQUENTLY IF I HAPPEN T... Read more

Incident date: Sep 8, 2015

"TAKATA RECALL" THE AIR BAG LIGHTS ARE ON ALL THE TIME WHEN THE CAR ENGINE IS TURNED ON.

Incident date: Jun 8, 2016

VAN STALLS AFTER REFUELING. SOMETIMES MOVING AND HAVE TO PULL TO THE SIDE OF THE ROAD.

Incident date: Oct 23, 2015

THE AIR BAGS DIDNOT OPEN ON A CAR CRASH AT 40MPH

Crash 1 injured

Incident date: Oct 23, 2015

TL* THE CONTACT OWNS A 2006 DODGE CARAVAN. WHILE THE VEHICLE WAS AT A STOP LIGHT, A SECOND VEHICLE CRASHED INTO THE PASSENGER SIDE. THE CONTACT'S VEHICLE WAS PUSHED INTO A THIRD VEHICLE. DURING THE CRASH, THE FRONT END WAS SEVERELY DAMAGED BUT THE AIR BAGS DID NOT DEPLOY. THE DRIVER SUSTAINED A FRAC... Read more

Crash 1 injured

Incident date: Mar 23, 2016

THE AIR BAGS DIDNOT DEPLOY AND MRI SATES I HAD BROKEN MY BACK IT WAS NOT MY FUALT THE OTHER CAR DIDNOT HAVE INSURECE I AM TRYING TO GET DODGE

Crash

Incident date: Nov 27, 2015

TL* THE CONTACT OWNS A 2006 DODGE CARAVAN. WHILE DRIVING, THE WINDSHIELD WIPERS FAILED TO RESPOND. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 143,268.

Incident date: Oct 12, 2015

TL* THE CONTACT OWNS A 2006 DODGE CARAVAN. WHILE DRIVING AT 40 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED SHOULDER, WRIST, AND FOOT INJURIES THAT DID NOT REQUIRE ... Read more

Crash 3 injured

Incident date: Oct 12, 2015

Crash 3 injured

Incident date: Aug 21, 2015

DRIVING ON THE INTERSTATE WHEN DASH BOARD LIGHTS STARTED TO FLICKER ON AND OFF, THE ENGINE STALLED FOR A FEW SECOND, BUT DID NOT LOSE POWER. WHAT GOING ON, WHY IS THIS HAPPENING.

Incident date: Aug 21, 2015

DRIVING ON THE INTERSTATE WHEN DASH BOARD LIGHTS STARTED TO FLICKER ON AND OFF, THE ENGINE STALLED FOR A FEW SECOND, BUT DID NOT LOSE POWER. WHAT GOING ON, WHY IS THIS HAPPENING.

Incident date: Aug 21, 2015

DRIVING ON THE INTERSTATE WHEN DASH BOARD LIGHTS STARTED TO FLICKER ON AND OFF, THE ENGINE STALLED FOR A FEW SECOND, BUT DID NOT LOSE POWER. WHAT GOING ON, WHY IS THIS HAPPENING.

Incident date: Jul 14, 2015

AFTER REFUELLING IT HAS BEEN STALLING. THIS HAS BEEN IN COLD WEATHER FOR A WHILE. NOW IT IS HAPPENING IN WARM WEATHER.

Incident date: Jul 13, 2015

CAR WILL STALL AFTER PUTTING FUEL IN. IT DOESN'T MATTER HOW MUCH FUEL, CAR WILL STALL WITH NO WARNING. USUALLY WHEN PULLING INTO TRAFFIC. THIS HAS HAPPEN SEVERAL TIMES AT DIFFERENT GAS STATIONS. REAL SAFETY ISSUE SINCE YOU WILL NOT HAVE ANY POWER TO STEER TO A SAFE PLACE. YOU HAVE TO TURN CAR OFF, T... Read more

Incident date: Dec 1, 2014

WHEN I START ENGINE EVERYTHING IS OK BUT AIR BAG LIGHT STAY ON DASHBOARD ALL THE TIME AND I HEAR 2 OR 3 SOUNDS AFTER THAT NO SOUND BUT AIRBAG LIGHT IS ON ALL THE TIME WHEN ENGINE IS RUNNING. I SEE THAT 2006 DODGE CARAVAN HAVE RECALL ON AIR BAG MODULE, I DID NOT RECEIVE ANY MAIL FROM CHRYSLER REGA... Read more

Incident date: Dec 27, 2013

CAR SOMETIMES STALLS ONCE OR TWICE WITHIN A FEW MINUTES OF FILLING UP GAS TANK, ESPECIALLY IN COLD WEATHER. THIS STARTED ABOUT 1 YEAR AGO AND HAPPENS SUDDENLY AND SOMETIMES IN TRAFFIC. AFTER DRIVING FURTHER THE CAR IS OK UNTIL NEXT FILL-UP. A WEB SITE CLAIMS WE MUST REPLACE THE ENTIRE GAS TANK ... Read more

Incident date: Dec 9, 2014

WHEN ATTEMPTING TO FILL THE TANK WITH GAS, EVEN ON NEAR-EMPTY TANK, GAS PUMP CLICKS OFF AND GAS SPILLS OUT AND RUNS DOWN THE BODY OF THE CAR ONTO THE GROUND. DODGE ISSUED A RECALL FOR DURANGO AND OTHER CHRYSLER VEHICLES FOR A FAULTY CHECK VALVE IN THE TANK BUT NOT FOR MY CAR (CARAVAN). I'D LIKE TO... Read more

Showing 50 of 231 complaints.

Technical Service Bulletins, 2006 DODGE CARAVAN

51 manufacturer communications from 40 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
160000 STRUCTURE	7
060000 ENGINE AND ENGINE COOLING	6
350000 EQUIPMENT	6
140000 AIR BAGS	3
103000 POWER TRAIN:AUTOMATIC TRANSMISSION	2
010000 STEERING	2
199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS	2
090000 FUEL SYSTEM, OTHER	2

100000 POWER TRAIN

Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usag

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehi

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

350000 EQUIPMENT

Disinfectant Solution Recommended for COVID-19

160000 STRUCTURE

Disinfectant Solution Recommended for COVID-19

110000 ELECTRICAL SYSTEM

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are nece

350000 EQUIPMENT

160000 STRUCTURE

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

160000 STRUCTURE

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

160000 STRUCTURE

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

350000 EQUIPMENT

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

350000 EQUIPMENT

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

160000 STRUCTURE

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

160000 STRUCTURE

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

350000 EQUIPMENT

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

060000 ENGINE AND ENGINE COOLING

Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. C

060000 ENGINE AND ENGINE COOLING

Valve Body. These may cause over drive cycling.

060000 ENGINE AND ENGINE COOLING

NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~

060000 ENGINE AND ENGINE COOLING

Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a

060000 ENGINE AND ENGINE COOLING

Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with

350000 EQUIPMENT

Part Description: Insulator in Lever Assembly - Valve Body - Trans Issue Description: The manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. If the insulator requires replacement lease order 68253

160000 STRUCTURE

200000 WHEELS

Part Description: Seat Belt - Retaining Button Kits. Issue Description: Do not replace the entire seat belt if the seat belt web stop button is missing or damaged.~Belt Web Button:~ 1D1 - Light Graystone - 05093280AB Belt Web Button~1D5 -

140000 AIR BAGS

050000 PARKING BRAKE

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc

121200 EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

CHRYSLER: THE PARK LAMPS REMAIN ILLUMINATED WHEN BOTH HEADLAMPS ARE ON AND THEN OFF, OR BOTH HEADLIGHTS FAIL TO ILLUMINATE WHILE PARK LAMPS REMAIN ILLUMNATED AFTER SWITCHING ON. MODELS 2005-2006 TOWN & COUNTRY, VOYAGER, GRAND CARAVAN, CARA

121000 EXTERIOR LIGHTING:HEADLIGHTS

121200 EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

DODGE/CHRYSLER: BEHAVIOR OF HEADLAMP SWITCH FUNCTION MAY IMPACT LIGHTING SYSTEMS SUCH AS OVERLOAD SPIKE OF ELECTRICAL SYSTEMS, TURNING OFF OR UNANTICIPATED ILLUMINATION, FLICKERING OR DIMMING OF EXTERIOR AND/OR INTERIOR LIGHT WITH ENGINE

121000 EXTERIOR LIGHTING:HEADLIGHTS

141100 AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

DODGE/CHRYSLER: SUPPLEMENTAL FRONT AIRBAG SENSORS ON ABOUT 310,000 CERTAIN VEHICLES MAY CRACK UNDER CERTAIN CONDITIONS AND ALLOW WATER TO ENTER INTO THE SENSOR. THESE SENSORS WERE ADDED TO ENHANCE THE PERFORMANCE OF THE VEHICLE'S AIRBAG S

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

1-2 AND/OR 2-3 SHIFT HARNESS. ERASING AND REPROGRAMMING THE POWERTRAIN CONTROL MODULE WITH NEW SOFTWARE IS NECESSARY. *KB

162310 STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

POWER SLIDING DOOR ADJUSTMENT AND DIAGNOSIS AID. *KB UPDATED 10/26/07. *NJ

120000 EXTERIOR LIGHTING

EXTERIOR LAMP - LENS FOGGING. *NJ

070000 FUEL SYSTEM, GASOLINE

CLEANING PROCEDURE FOR THE MECHANICAL THROTTLE BODY. *KB

090000 FUEL SYSTEM, OTHER

MIL ILLUMINATION - P0461 FUEL LEVEL SWITCH SENSOR #1 PERFORMANCE. *KB

140000 AIR BAGS

PASSENGER AIR BAG DEACTIVATION. *KB

131000 VISIBILITY:WINDSHIELD

CRACKED WINDSHIELD DUE TO BEING HIT BY A FOREIGN OBJECT LIKE A STONE. *KB

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

TIRE PRESSURE MONITOR SYSTEM INFORMATION. *KB

040000 SERVICE BRAKES, AIR

SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *KB

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

POWERTRAIN CONTROL MODULE INITIALIZATION. *KB

222000 SEATS:MID/REAR ASSEMBLY

3RD ROW SEAT FRONT LEG WILL NOT RETRACT. *TT

034400 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM

SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *TT

090000 FUEL SYSTEM, OTHER

LOOSE FUEL CAP MESSAGE OR MALFUNCTION INDICATOR LAMP ILLUMINATION FOR DIAGNOSTIC TROUBLE CODE P0457 - EVAP SYSTEM - LOOSE FUEL CAP. *TT

140000 AIR BAGS

DAIMLERCHRYSLER CORPORATION IS NOW OFFERING A PASSENGER AIRBAG DEACTIVATION WIRING PACKAGE. TO INCLUDE 2006 CHRYSLER TOWN AND COUNTRY AND 300/TOURING. *TT

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

TIRE PRESSURE MONITOR - SYSTEM INFORMATION. *TT

010000 STEERING

REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC

110000 ELECTRICAL SYSTEM

OIL PRESSURE INDICATOR ILLUMINATED AND DTC P0522 STORED IN PCM. THE CONSUMER MAY DESCRIBE THAT THE OIL PRESSURE INDICATOR IS ON WHILE DRIVING. *SC

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE. VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC

010000 STEERING

RATTLE SOUND FROM STEERING WHEEL AREA. *TT *SC

NHTSA Safety Investigations, DODGE CARAVAN

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 1997

REAR SEAT BELT MALFUNCTION

THIS INVESTIGATION WAS OPENED JANUARY 16, 2002, BASED ON SEVEN REPORTS ALLEGING THE THIRD ROW SEAT BELT RETRACTORS FAILED ON CERTAIN 1997 AND 1998 MODEL YEAR CARAVAN AND VOYAGER VEHICLES.THE REPORTS INDICATED A TAR LIKE SUBSTANCE ENTERED THE RETRACTOR MECHANISM, THUS CAUSING THE RETRACTOR TO JAM OR ... Read more

RQ, Open , Model Year: 1991

REAR LIFTGATE SUPPORT

ON MAY 7, 1997, CHRYSLER FILED A DEFECT INFORMATION REPORT TO RECALL 436,000 1992 DODGE CARAVAN/GRAND CARAVAN, PLYMOUTH VOYAGER/GRAND VOYAGER AND CHRYSLER TOWN AND COUNTRY VEHICLES TO REPAIR THE LIFTGATE SUPPORTS; SAFETY RECALL 97V-079.ODI HAD INVESTIGATION THE REAR LIFTGATE SUPPORT PROBLEM FOR 1991... Read more

DP, Closed , Model Year: 1989

AUTOMATIC TRANSMISSION FAILURE

THE PETITION ALLEGES THAT THE CHRYSLER CORPORATION FAILED TO PRODUCE A QUALITY TRANSMISSION IN ITS MODEL YEAR 1989 MINIVANS, WHICH CAN FAIL IMMATURELY

PE, Closed , Model Year: 1994

AIR BAG CIRCUIT/WINDSHIELD WIPER MOTOR