1991 DODGE CARAVAN

11 recalls, 773 complaints - 41 TSBs

STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS

Defect Description

VEHICLE DESCRIPTION: MINI VANS. THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUST... Read more

Consequence

PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.

Remedy

DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TO... Read more

1,318,189 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES

Defect Description

VEHICLE DESCRIPTION: MINIVANS. THE LEFT HAND WINDSHIELD WIPER PIVOT DRIVE ARM WAS NOT MECHANICALLY STAKED TO THE PIVOT SHAFT.

Consequence

THIS COULD ALLOW THE DRIVE ARM TO DISENGAGE FROM THE SHAFT LEADING TO A LOSS OF WIPER FUNCTION. THE DRIVER'S VISIBILITY WOULD BE IMPAIRED, INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL REPLACE THE LEFT HAND SIDE WINDSHIELD WIPER PIVOT ASSEMBLY.

828,559 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

SEAT BELTS:FRONT:BUCKLE ASSEMBLY

Defect Description

VEHICLE DESCRIPTION: PASSENGER MINI-VANS. COVERS ON THE SOLID STALK MOUNTED SEAT BELT BUCKLES CAN BECOME DISLODGED CAUSING THE RELEASE BUTTON TO STICK INSIDE THE COVER. THE BUCKLE WOULD THEN BE ONLY PARTIALLY LATCHED.

Consequence

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Remedy

DEALERS WILL INSTALL A COVER RETAINING CLIP TO THE STALK MOUNTED BUCKLE COVER TO PREVENT DISLOCATION OF THE BUCKLE COVER.

1,100,000 vehicles affected

Manufacturer: CHRYSLER CORPORATION

SEAT BELTS:FRONT:ANCHORAGE

Defect Description

VEHICLE DESCRIPTION: PASSENGER MINI-VANS. THE CENTER REAR SEAT, RIGHT OUTBOARD SIDE, SAFETY BELT ANCHOR HOOK CAN BECOME UNATTACHED FROM THE BODY ANCHOR POSITION.

Consequence

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Remedy

DEALERS WILL REPLACE THE ANCHOR HOOK RETAINING CLIP WITH A REVISED PROFILE CLIP AND A COVER PLATE.

1,100,000 vehicles affected

Manufacturer: CHRYSLER CORPORATION

STEERING: STEERING WHEEL/HANDLE BAR

Defect Description

THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.

Consequence

IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.

Remedy

DEALERS WILL INSPECT THE STEERING WHEEL FOR ARMATURE CRACKS IN THE CENTER HUB ATTACHMENT AREA. ANY STEERING WHEELS SHOWING CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.

675,000 vehicles affected

Manufacturer: CHRYSLER CORPORATION

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

Defect Description

THE ABS HYDRAULIC CONTROL UNIT CAN EXPERIENCE EXCESSIVE BRAKE ACTUATOR PISTON SEAL WEAR CAUSING PUMP-MOTOR DETERIORATION.

Consequence

IF THIS CONDITION OCCURS, THE ABS FUNCTION COULD BE LOST AND REDUCED POWER ASSIST WOULD BE EXPERIENCED DURING VEHICLE BRAKING INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy

DEALERS WILL TEST THE VEHICLE'S ANTI-LOCK BRAKE SYSTEM AND REPAIR THE VEHICLES IF NECESSARY. ALSO THE WARRANTY ON ALL ABS COMPONENTS WILL BE EXTENDED TO 10 YEARS OR 100,000 MILES (EXCEPT FOR THE BRAKE ACTUATOR PISTON ASSEMBLY AND THE PUMP-MOTOR ASSEMBLY WHICH WILL HAVE A LIFETIME COVERAGE). OWNERS W... Read more

321,000 vehicles affected

Manufacturer: CHRYSLER CORPORATION

LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK

Defect Description

VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER MINIVANS WITHOUT REMOTE RELEASE. THIS IS NOT A SAFETY RECALL. THERE HAS BEEN NO DETERMINATION THAT A SAFETY DEFECT EXISTS WITH THE MINIVAN LATCHES. CHRYSLER IS CONDUCTING A SERVICE CAMPAIGN TO REPLACE THE LIFTGATE LATCH ASSEMBLY OF THE AFFECTED MINIVANS... Read more

Consequence

IF THE LIFTGATE LATCH OPENS, OCCUPANTS CAN BE EJECTED RESULTING IN SIGNIFICANTLY INCREASED RISK OF INJURY OR DEATH.

Remedy

CHRYSLER DEALERS WILL REPLACE THE LIFTGATE LATCH WITH A NEW STRONGER LATCH ASSEMBLY WITHOUT CHARGE. CHRYSLER BEGAN NOTIFYING OWNERS OF THESE VEHICLES IN OCTOBER 1995.

52,719 vehicles affected

Manufacturer: CHRYSLER CORPORATION

LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK

Defect Description

VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER MINIVANS WITH REMOTE RELEASE. THIS IS NOT A SAFETY RECALL. THERE HAS BEEN NO DETERMINATION THAT A SAFETY DEFECT EXISTS WITH THE MINIVAN LATCHES. CHRYSLER IS CONDUCTING A SERVICE CAMPAIGN TO REPLACE THE LIFTGATE LATCH ASSEMBLY OF THE AFFECTED MINIVANS. I... Read more

Consequence

IF THE LIFTGATE LATCH OPENS, OCCUPANTS CAN BE EJECTED RESULTING IN SIGNIFICANTLY INCREASED RISK OF INJURY OR DEATH.

Remedy

CHRYSLER DEALERS WILL REPLACE THE LIFTGATE LATCH WITH A NEW STRONGER LATCH ASSEMBLY WITHOUT CHARGE. CHRYSLER BEGAN NOTIFYING OWNERS OF THESE VEHICLES IN MARCH 1996.

689,656 vehicles affected

Manufacturer: CHRYSLER CORPORATION

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Defect Description

THE ANTI-LOCK BRAKE SYSTEM HIGH PRESSURE PUMP MAY BE POROUS WHICH WILL RESULT IN BRAKE FLUID LEAKAGE.

Consequence

FLUID LEAKAGE EVENTUALLY CAUSES THE LOSS OF BOTH THEANTI-LOCK BRAKE SYSTEM AND HYDRAULIC ASSIST FOR THE BRAKE SYSTEM, RESULTING ININCREASED LIKELIHOOD OF BRAKE LOCKUP AND INCREASED STOPPING DISTANCES, WHICHCOULD RESULT IN A VEHICLE ACCIDENT.

Remedy

REPLACE THE ABS HIGH PRESSURE PUMP AND HIGH PRESSURE HOSE IF THE LAST SIX DIGITS OF THE BAR CODE LABEL ON THE PUMP ARE BETWEEN 052300 AND 059262.

10,492 vehicles affected

Manufacturer: CHRYSLER CORPORATION

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Defect Description

THE ANTI-LOCK BRAKE SYSTEM HIGH PRESSURE HOSE MAY LEAK OR DETACH AT ITS CRIMPED END FITTING RESULTING IN THE DISCHARGE OF HYDRAULIC FLUID.

Consequence

FLUID DISCHARGE EVENTUALLY CAUSES THE LOSS OF BOTH THEANTI-LOCK BRAKE SYSTEM AND HYDRAULIC ASSIST FOR THE BRAKE SYSTEM, RESULTING ININCREASED LIKELIHOOD OF BRAKE LOCKUP AND INCREASED STOPPING DISTANCES, WHICHCOULD RESULT IN A VEHICLE ACCIDENT.

Remedy

REPLACE THE ABS HIGH PRESSURE HOSE WITH A HOSE OF DIFFERENT DESIGN AND CONSTRUCTION.

80,000 vehicles affected

Manufacturer: CHRYSLER CORPORATION

EXTERIOR LIGHTING:TURN SIGNAL:FLASHER UNIT

Defect Description

INCORRECT TURN SIGNAL FLASHER INHIBITS INDICATION OF SIGNAL LAMP OUTAGE.

Consequence

INOPERATIVE TURN SIGNAL LAMPS WOULD NOT INFORM DRIVERTHAT A LAMP WAS OUT, OR WARN OTHER DRIVERS OF INTENT TO TURN, CREATING A RISKOF ACCIDENT; VEHICLE DOES NOT COMPLY WITH FMVSS 108.

Remedy

REPLACE TURN SIGNAL FLASHER WITH PROPER FLASHER.

1,300 vehicles affected

Manufacturer: CHRYSLER CORPORATION

Complaint Statistics

773 total complaints 40 crashes 15 fires 37 injuries 1 deaths

Top Reported Components

Component	Complaints
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	171
SEAT BELTS:FRONT:ANCHORAGE	46
POWER TRAIN:AUTOMATIC TRANSMISSION	43
STRUCTURE:BODY:DOOR	34
SEAT BELTS:FRONT:BUCKLE ASSEMBLY	30
LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK	23
STEERING: STEERING WHEEL/HANDLE BAR	17
STEERING:HYDRAULIC POWER ASSIST:PUMP	15
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS	14
ENGINE AND ENGINE COOLING:ENGINE	14

Incident date: Feb 14, 2017

STARTED MISSING AT FRIST, THEN A NO START. I'VE CHANGED THE TIMING CHAIN, CRANK SENSOR, CAMSHAFT SENSOR, COIL PACK. TRIED A NEW ECM. THERE'S VOLTAGE TO THE COIL PACK, BUT NO SPARK. I'VE CHECKED WIRING CIRCUIT, AND AUTO SHUT DOWN RELAY .

Incident date: Feb 14, 2017

Incident date: Apr 3, 2013

TL* THE CONTACT OWNS A 1991 DODGE CARAVAN. THE CONTACT STATED THAT THE FRONT BRAKE CALIPERS MALFUNCTIONED AND MADE THE VEHICLE DIFFICULT TO MOVE. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE HYDRAULIC CONTROL UNIT THAT HOUSES THE BRAKE ACTUATOR PISTON AND THE PUMP MOTOR ASSEMBLY NEEDE... Read more

Incident date: Apr 3, 2013

Incident date: Apr 20, 2006

1991 DODGE CARAVAN. CONSUMER WRITES IN REGARDS TO ANTI LOCK BRAKE SYSTEM RECALL AND SEEKS REIMBURSEMENT FOR REPAIRS. *SMD THE CONSUMER STATED HE PAID FOR THE REPAIRS ON APRIL 20, 2006 AND WAS CHARGED $376.73, EVEN THOUGH A RECALL HAD BEEN ISSUED. THE CONSUMER EXPERIENCED ABS PROBLEMS AGAIN IN DE... Read more

Incident date: Apr 20, 2006

Incident date: Apr 12, 2008

THE DRIVERS SIDE AIRBAG DEPLOYED WHILE I WAS DRIVING DOWN THE ROAD, MY ARM IS SWOLLEN, BURNED, AND BRUISED. MY NOSE AND HEAD HAVE HURT FOR THE LAST FOUR DAYS. *TR

1 injured

Incident date: Nov 19, 2006

A LOUD CLUNKING NOISE COULD BE HEARD WHEN TRAVELING OVER UNEVEN ROAD SURFACES OR ON RIGHT HAND TURNS. AFTER COMPLETING A RIGHT TURN, THE DRIVER SIDE FRONT WHEEL WAS COMPLETELY DISLODGED AND FOLDED BACKINTO THE WHEEL WELL. THE LOWER CONTROL ARM WAS FRACTURED WHERE THE BALL JOINT WAS SEATED, ALLOWING ... Read more

Incident date: Feb 22, 1994

1991 DODGE CARAVAN WITH ABS FAILURE PROBLEMS**CC A RECALL WAS ISSUED AFTER THE CONSUMER HAD THE FIRST REPAIR DONE. THE CONSUMER IS REQUESTING REIMBURSEMENT. *JB

Incident date: Nov 21, 2006

DT*: THE CONTACT STATED RECALL # 96V099000 FOR THE SERVICE BRAKES: HYDRAULIC: ANTI-LOCK WAS RECEIVED. WHEN THE SERVICE DEALER WAS CALLED TO SCHEDULE THE RECALL REPAIR, THE SERVICE DEALER INFORMED THE CONTACT, THERE WOULD BE CHARGES FOR REPLACING THE ACCUMULATOR PLUS LABOR COSTS. THE MANUFACTURER R... Read more

Incident date: Feb 20, 2006

DT*: THE CONTACT STATED RECALL WORK WAS PERFORMED ON THE VEHICLE PRIOR TO THE CONTACT BEING AWARE OF THE RECALL. THE MANUFACTURER WAS CONTACTED ABOUT REIMBURSEMENT WHICH THEY DENIED BECAUSE THE RECALL WORK WAS NOT PERFORMED AT AN AUTHORIZED DEALERSHIP. THE NHTSA RECALL # 96V099000 CONCERNING THE S... Read more

Incident date: Mar 19, 2006

HELLO BELOW IS A COPY OF TEXT ON YOUR RECALL SITE WITH DETAILS OF THIS RECALL COMMENTS I MAKE ARE BELOW THAT.. MAKE : DODGE MODEL : GRAND CARAVAN YEAR : 1991 MANUFACTURER : CHRYSLER CORPORATION NHTSA CAMPAIGN ID NUMBER : 96V099000 MFG'S REPORT DATE : APR 19, 1996 COMPONENT: SERVICE BRAKES,... Read more

Incident date: Jan 13, 2006

DT*: THE CONTACT STATED THERE IS A VIBRATION IN THE FRONT END AND THE BRAKE PEDAL IS PULSATING. THIS HAS PERSISTED FOR 3 YEARS. THE TIRES WERE REPLACED AND REALIGNED NUMEROUS TIMES TO CORRECT THE VIBRATION, HOWEVER THE PROBLEM STILL OCCURS. THE BRAKES WERE REPLACED 3 TIMES, ALTHOUGH THE PULSATING IS... Read more

Incident date: Jan 13, 2006

Incident date: Nov 10, 2005

DT: THE CONSUMER STATED THAT AFTER SMELLING GAS, HE TOOK THE VEHICLE TO A MECHANIC. THE MECHANIC TOLD THE CONSUMER TO START THE VEHICLE. HE THEN TOLD THE CONSUMER TO SHUT THE VEHICLE OFF. THE MECHANIC SUGGESTED THAT THE VEHICLE WAS NOT SAFE TO DRIVE. THE FUEL RAIL HAD BEEN REPLACED AT THIS TIME... Read more

Incident date: Aug 10, 2005

DT: THE CONTACT STATED THE FUNCTION PRESSURE SWITCH IN THE ABS SYSTEM NEEDED TO BE REPLACED. THE CONTACT STATED THE VEHICLE DID NOT HAVE ANY BRAKING CAPABILITY. THE SERVICE DEALER CLAIMED ABS BRAKES NEEDED TO BE REPLACED. THE SERVICE DEALER ATTEMPTED TO THE REPAIR THE PROBLEM, BUT DID NOT SUC... Read more

Incident date: Aug 13, 2005

DT: THE CONTACT OWNS A 1991 DODGE CARAVAN. THE CONTACT RECEIVED NHTSA RECALL CAMPAIGN 96V229000. HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. WHILE HER HUSBAND WAS DRIVING THE STEERING WHEEL CAME OFF. FORTUNATELY, IT DID NOT RESULT IN AN ACCIDENT. THIS HAPPENED ON AUGUST 1... Read more

Incident date: Apr 11, 2005

1991 DODGE GRAND CARAVAN EXPERIENCED ABS FAILURE.*MR ABS LIGHT ILLUMINATED. THIS WAS THE SECOND TIME THE ABS FAILED. THE VEHICLE WAS TAKEN TO THE DEALER BUT THEY DIDN'T HAVE THE PART TO REPAIR IT YET. *NM

Incident date: Feb 5, 2005

WHILE DRIVING 55 MPH VEHICLE STALLED. DRIVER WAS ABLE TO RESTART VEHICLE, AN DTOOK IT TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT THE TRANSMISSION NEEDED TO BE REPLACED AND REPLACED IT THREE TIMES. *AK

Incident date: Nov 15, 2004

CONSUMER WAS DRIVING 60 MPH AND TRANSMISSION LOCKED INTO LOW, CAUSING DRIVER TO INJURE HIS BACK. CONSUMER HAD TO REPLACE THE TRANSMISSION ON THREE SEPARATE OCCASIONS. CONSUMER WAS VERY UPSET. *AK *TC

1 injured

Incident date: Jul 7, 2004

PROBLEMS WITH THE ANTI LOCK BRAKE EQUIPMENT ON 1991 DODGE CARAVAN.*MR THE VEHICLE ABS LIGHT ILLUMINATED WHILE DRIVING. THE CONSUMER HAS HAD MULTIPLE PROBLEMS WITH THE VEHICLE ABS SYSTEM SINCE 1997. IN MARCH, 2004 THE DEALER REPLACED THE HYDRAULIC SYSTEM. *NM

Incident date: Jan 1, 1901

OFFER MADE TO THE CONSUMER FOR DODGE TO INSPECT HER VEHICLE RELATIVE TO THE ANTI LOCK BRAKING SYSTEM. (NAR) *PH *CB

Incident date: May 3, 2004

THIS VEHICLE HAS THE SAME PROBLEM AS STATED IN NHTSA RECALL 96V099000 CONCERNING ABS BRAKE FAILURE. THE ABS HYDRAULIC CONTROL UNIT CAN EXPERIENCE EXCESSIVE BRAKE ACTUATOR PISTON SEAL WEAR, CAUSING PUMP-MOTOR DETERIORATION. DEALERSHIP INDICATED SORRY THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE ... Read more

Incident date: Jun 15, 2003

PAINT PEELING FROM HORIZONTAL SURFACES.

Incident date: Jan 1, 2004

1991 DODGE CARAVAN 3.3 LITER ENGINE. PROBLEMS CAUSED BY OIL PAN CLEARANCE TO THE GROUND CAUSE POSSIBLE DAMAGE TO THE OIL PAN IN A BOTTOM OUT SITUATION IF THE DAMAGE GOES UNNOTICED IT COULD LEAD TO A POSSIBLE FIRE SITUATION DUE TO OIL DEPOSITS ON THE LOWER SIDE OF THE VAN . POSSIBLE SOLUTION TO THIS ... Read more

Incident date: Jan 1, 2004

1991 DODGE CARAVAN 3.3 LITER ENGINE PROBLEMS CAUSED BY OIL PAN CLEARANCE TO THE GROUND CAUSE POSSIBLE DAMAGE TO THE OIL PAN IN A BOTTOM OUT SITUATION IF THE DAMAGE GOES UNNOTICED IT COULD LEAD TO A POSSABLE FIRE SITUATION DUE TO OIL DEPOSITS ON THE LOWER SIDE OF THE VAN . POSSIBLE SOLUTION TO THIS P... Read more

Incident date: Jan 1, 2004

RECALL 96V099000 CONCERNING ABS BRAKE FAILURE. VEHICLE WAS REPAIRED UNDER THE RECALL. 30,000 MILES LATER BRAKES FAILED AGAIN. DEALER DID A DIAGNOSTIC TEST, AND DETERMINED THAT THE PARTS THAT WERE REPAIRED UNDER THE RECALL FAILED, CAUSING THE VEHICLE TO LOSE BRAKE POWER. DEALER WOULD NOT DO A... Read more

Incident date: Feb 6, 2004

CONSUMER COMPLAINED ABOUT TRANSMISSION PROBLEM. TRANSMISSION STOPPED, AND WOULD NOT PULL OR GO INTO GEAR. CONSUMER HAD VEHICLE TOWED TO A DEALER, WHO REPLACED THE DEFECTIVE TRANSMISSION WITH ANOTHER ONE, WHICH WORKED FINE UNTIL RECENTLY WHEN PROBLEM RECURRED. ALSO, CONSUMER WAS TOLD BY DEALER... Read more

Incident date: Oct 29, 2003

UPON STARTING VEHICLE ANTI LOCK BRAKE LIGHT WOULD ILLUMINATE, AND WOULD STAY ON THE REMAINDER OF THE TIME THAT VEHICLE WOULD BE RUNNING. ALSO, BRAKE FLUID LEAKED. TOOK VEHICLE TO DEALERSHIP, BUT THE PROBLEMS WERE NOT RESOLVED.*AK

Incident date: Oct 29, 2003

Incident date: Sep 10, 2003

TRANSMISSION BEHAVES ERRATICALLY. FIRST SYMPTOMS WERE REVVING AND FAILURE TO GO INTO GEAR IN COOL (BELOW 60) OR RAINY WEATHER. THREE TRIPS TO THE DODGE SERVICE CENTER AND SEVERAL PHONE CALLS TO DAIMLER-CHRYSLER HAVE DONE NO GOOD! ON MY WAY TO WORK THE TRANSMISSION STUCK IN 3RD GEAR AND WOULD NOT... Read more

Incident date: Aug 5, 2003

CONSUMER STATES THAT SLIDING DOOR CAME OFF TRACK WHEN CONSUMER'S 2 YEAR OLD CHILD OPENED THE SLIDING DOOR. DEALER NOTIFIED.*AK

Incident date: Aug 15, 2002

THE DASHBOARD PUSHES FORWARD ALLOWING THE SPEDOMETER TO STICK AND NOT OPERATE. THIS IS DANGEROUS BECAUSE THE DRIVER OF THE VEHICLE DOES NOT KNOW WHAT SPEED HE/SHE IS CRUISING AT AND COULD LEAD TO A CAR ACCIDENT.*AK

Incident date: Aug 15, 2002

Incident date: Jul 21, 2003

CONSUMER STATES FUEL PUMP HAS FAILED. DEALER NOTIFIED. *AK

Incident date: Jul 11, 2003

CONSUMER STATED THAT AUTOMATIC TRANSMISSION IS LEAKING. DEALER NOTIFIED. *AK

WHILE DRIVING THROUGH WATER THE COLD AIR INTAKE TOOK IN WATER THAT WENT STRAIGHT TO THE ENGINE. AS A RESULT THE ENGINE CUT OUT SUDDENLY AND FAILED TO RESTART. *NLM. *AK

THE DEALER REFUSED TO CORRECT RECALL 96 V 099 000 BECAUSE THE CONSUMER WOULD NOT LET THEM REPAIR THE ABS. *NLM

Incident date: Nov 28, 2002

LOST MY BRAKES FOR THE THIRD TIME IN THREE YEARS, DUE TO EVASIVE ACTION I MISSED HITTING A CAR BUT COULD NOT STOP FROM HITTING THE CURB AND SCRAPE A STREET POLE, BROKE AN AXLE AND SUSPENSION PARTS ALL ON THANKSGIVING. *NLM

Crash

Incident date: Jul 1, 2002

I OWN BOTH A 1991 AND A 1995 DODGE CARAVAN... THE 1991 HAS NUMEROUS PROBLEMS, INCLUDING A BACK HATCH THAT WON'T STAY UP BECAUSE THE AREA OF THE FRAME THAT THE SHOCK LATCHES INTO IS BROKEN DUE TO A STRESS CRACK.. THIS MAKES IT REALLY HARD TRYING TO GET THINGS IN AND OUT WHEN YOU HAVE A BABY.. THE DRI... Read more

Incident date: Jul 1, 2002

Showing 50 of 773 complaints.

Technical Service Bulletins, 1991 DODGE CARAVAN

41 manufacturer communications from 39 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
103000 POWER TRAIN:AUTOMATIC TRANSMISSION	7
145000 AIR BAGS:ON-OFF SWITCH ASSEMBLY	4
220000 SEATS	3
110000 ELECTRICAL SYSTEM	3
180000 VEHICLE SPEED CONTROL	3
102000 POWER TRAIN:MANUAL TRANSMISSION	2
140000 AIR BAGS	2
060000 ENGINE AND ENGINE COOLING	1

110000 ELECTRICAL SYSTEM

SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT

110000 ELECTRICAL SYSTEM

SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB

220000 SEATS

SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT

140000 AIR BAGS

SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT

220000 SEATS

SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT

114000 ELECTRICAL SYSTEM:WIRING

THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT

145000 AIR BAGS:ON-OFF SWITCH ASSEMBLY

DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT

162000 STRUCTURE:BODY

SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS

220000 SEATS

INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

THIS BULLETIN ANNOUNCES THE AVAILABILITY AND INSTALLATION OF A RESUABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT

180000 VEHICLE SPEED CONTROL

CONDITIONS WITH INTERMITTENT LOSS OF SPEED CONTROL. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SUBJECT REGARDING REUSABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SERVICE AND PARTS INFORMATION ON 1999 RUNNING CHANGES TO TRANSMISSION RANGE SENSOR (TRS) *TT

145000 AIR BAGS:ON-OFF SWITCH ASSEMBLY

SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC

136300 VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES

A 30 DAY WINDSHIELD WIPER PIVOT SURVEY. *AK

136000 VISIBILITY:WINDSHIELD WIPER/WASHER

A 30 DAY WINDSHIELD WIPER PIVOT SURVEY. *AK

145000 AIR BAGS:ON-OFF SWITCH ASSEMBLY

SUBJECT REGARDING THE AIRBAG ON-OFF SWITCHES. *YC

145000 AIR BAGS:ON-OFF SWITCH ASSEMBLY

DISCUSSION ON AIRBAG ON- OFF SWITCHES FOR SELECTED VEHICLES *AK

106000 POWER TRAIN:AXLE ASSEMBLY

SUBJECT ON DELAYED TRANSAXLE ENGAGEMENT. *AK

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK

140000 AIR BAGS

AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *YC

110000 ELECTRICAL SYSTEM

INFORMATION REGARDING NHTSA AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *NLM

102000 POWER TRAIN:MANUAL TRANSMISSION

INFORMATION ON 41TE/42LE SERVICE INFORMATION. *NLM

062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

VARIOUS CAR OWNER'S HAVE EXPRESSED INTEREST IN USING ENGINE COOLANTS MADE WITH PROPYLENE GLYCOL INSTEAD OF ETHYLENE GLYCOL. *YC

060000 ENGINE AND ENGINE COOLING

CONCERNS WITH ENGINE COOLANT USAGE. *NLM

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

CONCERNS WITH 41TE/42LE TRANSAXLE SHUDDER DURING AN EMCC (ELECTRONICALLY MODULATED CONVERTER CLUTCH) SHIFT. *NLM

103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

VEHICLE SHUDDER DURING TORQUE CONVERTER EMCC (LOCK UP) OPERATION/DIAGNOSTIC TROUBLE CODE 38. *TW

061000 ENGINE AND ENGINE COOLING:ENGINE

VEHICLES WITH 3.0L ENGINES - INTAKE VALVE DEPOSITS - DRIVEWAY DIE OUT, ROUGH IDLE, LACK OF POWER, SAGS OR HESITATION. *TW

161000 STRUCTURE:FRAME AND MEMBERS

DIFFICULT TO CLEAN LIGHT COLORED "CHALKY" RESIDUE FROM PLASTIC BODY COMPONENTS THAT ARE MOLDED IN BLACK. *TW

180000 VEHICLE SPEED CONTROL

BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 08-16-95, DATED APR. 14, 1995. IF THE VEHICLE OPERATOR **REPEATEDLY** PRESSES AND RELEASES THE SET BUTTON WITH THEIR FOOT OFF OF THE ACCELERATOR (A 'LIFT FOOT SET' TO BEGIN SPEED CONTROL OPER

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

UNKNOWN

180000 VEHICLE SPEED CONTROL

CRUISE CONTROL OVERSHOOT/UNDERSHOOT DURING INITIAL SET SPEED SELECTION. *TW

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

EXHAUST NOISE WHEN ACCELERATING OR WHEN VEHICLE IS UNDER MODERATE LOAD. *TW

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

HARSH TRANSAXLE SHIFTS. *T2W

102000 POWER TRAIN:MANUAL TRANSMISSION

MANUAL TRANSAXLE LOCKED IN NEUTRAL OR LOCKED IN REVERSE. *TW

105000 POWER TRAIN:DRIVELINE

HARSH TRANSAXLE SHIFTS. *TW

061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

SERPENTINE BELT COMES OFF PULLEYS. *TW

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

LOW HEATER PERFORMANCE. *TW

116200 ELECTRICAL SYSTEM:IGNITION:MODULE

PCM NOT PROPERLY DISENGAGING A/C CLUTCH VIA THE RELAY ALSO THE PCM MAY NOT ENERGIZE THE A/C CLUTCH RELAY. *TW

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

IMPROVED TRANSMISSION SHIFT QUALITY. *TW

162300 STRUCTURE:BODY:DOOR

REVISED SLIDING DOOR CENTER AND LOWER TRACK OVER-TRAVEL STOPS. *TW

NHTSA Safety Investigations, DODGE CARAVAN

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 1997

REAR SEAT BELT MALFUNCTION

THIS INVESTIGATION WAS OPENED JANUARY 16, 2002, BASED ON SEVEN REPORTS ALLEGING THE THIRD ROW SEAT BELT RETRACTORS FAILED ON CERTAIN 1997 AND 1998 MODEL YEAR CARAVAN AND VOYAGER VEHICLES.THE REPORTS INDICATED A TAR LIKE SUBSTANCE ENTERED THE RETRACTOR MECHANISM, THUS CAUSING THE RETRACTOR TO JAM OR ... Read more

RQ, Open , Model Year: 1991

REAR LIFTGATE SUPPORT

ON MAY 7, 1997, CHRYSLER FILED A DEFECT INFORMATION REPORT TO RECALL 436,000 1992 DODGE CARAVAN/GRAND CARAVAN, PLYMOUTH VOYAGER/GRAND VOYAGER AND CHRYSLER TOWN AND COUNTRY VEHICLES TO REPAIR THE LIFTGATE SUPPORTS; SAFETY RECALL 97V-079.ODI HAD INVESTIGATION THE REAR LIFTGATE SUPPORT PROBLEM FOR 1991... Read more

DP, Closed , Model Year: 1989

AUTOMATIC TRANSMISSION FAILURE

THE PETITION ALLEGES THAT THE CHRYSLER CORPORATION FAILED TO PRODUCE A QUALITY TRANSMISSION IN ITS MODEL YEAR 1989 MINIVANS, WHICH CAN FAIL IMMATURELY

PE, Closed , Model Year: 1994

AIR BAG CIRCUIT/WINDSHIELD WIPER MOTOR