2013 CHEVROLET VOLT

The passenger presence sensor is failing or failed because every time someone sit in there the airbag turns on and off repeatedly every 2-3 mins and gives a service airbag warning and if no one is sitting in the passenger seat then it just stays on. Could be really dangerous if a wreck happens while it’s glitching in the off mode and could cause death. Multiple people have had this problem with the volts and there is even a thing you can by to completely bypass the airbag going off which shows how common the problem is if there is a solution to eliminate it in an unsafe/not factory manner

The passenger presence sensor is failing or failed because every time someone sit in there the airbag turns on and off repeatedly every 2-3 mins and gives a service airbag warning and if no one is sitting in the passenger seat then it just stays on. Could be really dangerous if a wreck happens while it’s glitching in the off mode and could cause death. Multiple people have had this problem with the volts and there is even a thing you can by to completely bypass the airbag going off which shows how common the problem is if there is a solution to eliminate it in an unsafe/not factory manner

The passenger presence sensor is failing or failed because every time someone sit in there the airbag turns on and off repeatedly every 2-3 mins and gives a service airbag warning and if no one is sitting in the passenger seat then it just stays on. Could be really dangerous if a wreck happens while it’s glitching in the off mode and could cause death. Multiple people have had this problem with the volts and there is even a thing you can by to completely bypass the airbag going off which shows how common the problem is if there is a solution to eliminate it in an unsafe/not factory manner

I received the "Propulsion Power is Reduced" Alert engine light while driving in "Normal" mode on the freeway at around 60mph with 8-9 miles of Battery capacity, it showed 0 miles of Battery forcing the Gas Engine on and the vehicle hesitated upon applying the accelerator for the remainder of the drive. My safety and that was others was at risk because the acceleration dropped quickly and I was on a busy freeway at the time when the Alert happened causing further hesitation. Upon stopping I could not get the vehicle to take a charge nor would it start up until a mechanic arrived and was able to confirm the problem.

I received the "Propulsion Power is Reduced" Alert engine light while driving in "Normal" mode on the freeway at around 60mph with 8-9 miles of Battery capacity, it showed 0 miles of Battery forcing the Gas Engine on and the vehicle hesitated upon applying the accelerator for the remainder of the drive. My safety and that was others was at risk because the acceleration dropped quickly and I was on a busy freeway at the time when the Alert happened causing further hesitation. Upon stopping I could not get the vehicle to take a charge nor would it start up until a mechanic arrived and was able to confirm the problem.

I received the "Propulsion Power is Reduced" Alert engine light while driving in "Normal" mode on the freeway at around 60mph with 8-9 miles of Battery capacity, it showed 0 miles of Battery forcing the Gas Engine on and the vehicle hesitated upon applying the accelerator for the remainder of the drive. My safety and that was others was at risk because the acceleration dropped quickly and I was on a busy freeway at the time when the Alert happened causing further hesitation. Upon stopping I could not get the vehicle to take a charge nor would it start up until a mechanic arrived and was able to confirm the problem.

The contact owns a 2013 Chevrolet Volt. The contact stated that while driving at approximately 45 MPH, the vehicle stalled. The Check Engine warning light was flashing, and the messages "No Propulsion Power" and "No Power To Engine" were displayed. The contact stated that two individuals pulled over and assisted the contact in pushing the vehicle to the side of the road to prevent a crash. The vehicle was towed to an independent mechanic, who made the contact aware of an unknown NHTSA Campaign Number; however, the VIN was not included. The vehicle was towed to a dealer, but the vehicle was not diagnosed or repaired. The contact requested vehicle rental assistance, but the dealer was unable to provide assistance. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance in initiating a recall. The failure mileage was approximately 141,323.

The contact owns a 2013 Chevrolet Volt. The contact stated that while driving at approximately 45 MPH, the vehicle stalled. The Check Engine warning light was flashing, and the messages "No Propulsion Power" and "No Power To Engine" were displayed. The contact stated that two individuals pulled over and assisted the contact in pushing the vehicle to the side of the road to prevent a crash. The vehicle was towed to an independent mechanic, who made the contact aware of an unknown NHTSA Campaign Number; however, the VIN was not included. The vehicle was towed to a dealer, but the vehicle was not diagnosed or repaired. The contact requested vehicle rental assistance, but the dealer was unable to provide assistance. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance in initiating a recall. The failure mileage was approximately 141,323.

The passenger occupancy sensor gives a false positive. The only way I can get rid of the beeping is plug in the seatbelt. I have read on Reddit forums that this is a very common problem with 2013 volts, but for some reason there isn't a recall. This is a safety issue. Thank you!

Propulsion power reduced error has happened many times but the recall lookup shows that there are no active recalls on our car. There was a recall on this problem in 2018 so I think it may have been done my the last owner but it is still having this problem.

The drivers side front seatbelt pretensioner assembly contains a braided steel cable. The cable, through normal use, has become damaged to the point that individual wires have broken free from the crimped connector. The damaged wires of the cable have penetrated through the plastic sheath covering the cable causing a needle sharp poking hazard when reaching one’s hand toward the seat back adjustment lever. My wife had a minor laceration to her finger and I was also poked when trying to identify the cause. Upon further inspection I found that approximately 80 percent of the diameter of the pretensioner cable had broken free from the crimped connector. In the event of a collision, the cable would likely break free from the seatbelt, possibly causing serious injury to the driver. I tried to obtain a replacement part through the GM dealer parts network, but the part is listed as discontinued and unavailable. This leaves the vehicle unsafe in the event of an accident. The damaged components are available for inspection. The vehicle has not been inspected by anyone but myself. There were no warning lamps or symptoms of the problem prior the the injury. I am the original owner of the vehicle and it has never been involved in a collision. The vehicle has been properly maintained and is used only for personal transportation.

Fuel leaking from fuel tank at filler inlet. Defect in fuel tank assembly. Large puddle of gasoline formed under car after refueling causing buildup of fumes in closed garage. Vehicle has not been inspected by anyone other than owner. There were no warning lamps prior to failure.

Front passenger seat sensor intermittently fails, causing the Passenger Airbag indicator to switch to OFF (even if a passenger is present) with an accompanying "Service Airbag" message on the dashboard and illumination of the service airbag light. This occurs usually driving above 25mph, but can happen stationary, and lasts for anywhere from 5 seconds to a minute (more commonly shorter). The issue appears some weeks more than others, usually activating most days a week but sometimes have a week or two where it does not happen.

Front passenger seat sensor intermittently fails, causing the Passenger Airbag indicator to switch to OFF (even if a passenger is present) with an accompanying "Service Airbag" message on the dashboard and illumination of the service airbag light. This occurs usually driving above 25mph, but can happen stationary, and lasts for anywhere from 5 seconds to a minute (more commonly shorter). The issue appears some weeks more than others, usually activating most days a week but sometimes have a week or two where it does not happen.

The contact owns a 2013 Chevrolet Volt. The contact stated while driving approximately 76-77 MPH, the vehicle experienced reduced power. The message "Low Propulsion" was displayed, and the engine revved significantly. The contact moved over to the far-right lane to pull over to the side of the road as needed. The contact stated that the failure had been recurring temporarily. The contact had researched the failure online and became aware that the release of the accelerator pedal while the failure was occurring could temporarily correct the failure. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 61,000.

The contact owns a 2013 Chevrolet Volt. The contact stated while driving approximately 76-77 MPH, the vehicle experienced reduced power. The message "Low Propulsion" was displayed, and the engine revved significantly. The contact moved over to the far-right lane to pull over to the side of the road as needed. The contact stated that the failure had been recurring temporarily. The contact had researched the failure online and became aware that the release of the accelerator pedal while the failure was occurring could temporarily correct the failure. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 61,000.

Passenger presence does not detect people in it and makes it unsafe for passenger without airbags. This got closed and was state that there was a Chevy program to fix this as cited in the closing . I have called all over Chevy and there is no one who knows anything about this at all. If you know it or if they just started it to make it go away, please tell with with whom I can contact within Chevy to start the process

This is a reoccurring problem that is worsening. It is difficult to replicate (but becoming easier to replicate as the problem worsens). The problem conditions are as follows: -The car is fully charged The following drive conditions are required: - The beginning of a drive, with the car in the fully charged state, is driven in the “L” mode (aggressive regenerative braking), AND the beginning (first mile or two) of the trip includes some conditions that would NORMALLY engage regenerative breaking and redirect energy flow back to the high voltage battery. (E.g.: Beginning a drive by going up a small incline; then proceeding to drive down a decline.) OR - The beginning of a drive, with the car in the fully charged state, is driven in the “D” mode, AND the beginning (first mile or two) of the trip includes almost exclusively conditions that would NORMALLY trigger regenerative breaking and redirect flow back to the high voltage battery. IN BOTH cases: the instrument cluster, during conditions that would reflect regenerative breaking and energy flow back into the high voltage battery, instead reflects suddenly INCREASED electrical OUTPUT despite there being no increased demand for output from the driver. Expected behavior in these conditions would reflect a negative power output while the car is driven in regenerative conditions (e.g.: going down hill). In either of these cases, the final condition is that you fully stop the vehicle (via brake) during the regenerative conditions. DESPITE full depression of the brake, the car jerks forward violently and erratically, attempting to accelerate. Engaging the emergency brake does not cure the condition while the car is still in L or D driving mode, and it will continue to attempt to accelerate while held in place. Shifting in to neutral does stop the behavior. Shifting back to L or D from neutral will cause the vehicle to continue to attempt to accelerate. There are no error codes/lamps and sensors appear normal.

Vehicle went into reduced propulsion mode and then shut-off while driving down the highway. Same issue as recall 18V397000 that was not applied to my VIN number as part of that recall. Please apply recall 18V39000 to my vehicle VIN. Chevy Volt owners also need the NHTSA to issue an edict to GM/ that the reset codes for the ECM/HPCM2 being given to the OBD2 bi-directional scanner companies so owners don't have to pay a ransom to the dealerships and GM to get there cars back up and running.

Repeats constantly..."service airbag". Appears to stop for somewhat variable lengths of time with passenger in front seat. Seems to be related to presence sensor.

Engine shuts off randomly...message "Engine not available". Car shut off on freeway at 60 mph. Got to shoulder, cycled start button...Engine started then resumed driving. Has now happened a few times since. Also code related to reduced propulsion... Used OBDII to clear codes but makes no difference. Sometimes the car starts and drives without problem. Other times, Engine rpm very erratic.

While driving, the car developed a brake malfunction. when the brake pedal is depressed you can feel the pedal pulsating and was not slowing down until you pressed harder then the brakes apply abruptly causing risk of rear ending. Upon pulling over to the hard shoulder the pedal pulsating/drumming continued to happen even though the car is completely stopped and is in parking gear. The symptom is similar to the service bulletin PIC5734A. [XXX] The car was driven to the nearest dealership 'Dublin Chevorlet' in Dublin CA and the car has been there for 4 weeks since GM is unable to help resolve the problem. I have reached out to GM and opened a support case. Case number [XXX] ]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2013 Chevrolet Volt. The contact stated while driving 50 MPH, the vehicle lost motive power with the check engine warning light and low oil pressure warning light illuminated. The vehicle was towed to the dealer where a diagnostic test result was undisclosed; however, the contact was informed that the vehicle needed an ASC high-voltage battery to be replaced. The vehicle was not repaired after the ASC battery was replaced. The contact stated that the propulsion system warning light was illuminated. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

The contact owns a 2013 Chevrolet Volt. The contact stated while driving 50 MPH, the vehicle lost motive power with the check engine warning light and low oil pressure warning light illuminated. The vehicle was towed to the dealer where a diagnostic test result was undisclosed; however, the contact was informed that the vehicle needed an ASC high-voltage battery to be replaced. The vehicle was not repaired after the ASC battery was replaced. The contact stated that the propulsion system warning light was illuminated. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

This report is in general for EV batteries and low propulsion, BMW also. When system moves to low propulsion the break lights do not eliminate so the vehicle slows very fast as if it is breaking but no break lights turn on, this creates a risk for other drivers, this occurs on steep mountain climbs when mountain mode was not engaged. What I want to happen is when low propulsion mode engages the break lights come on so that other drives can keep safe distance as I pull to the side for battery to recharge. This does not happen that often but when it does occur it creates a scary situation. A electric BMW also did this today. Please request a break light adaption for future EV batteries/Gas Powered vehicles. Keep in mind this is generally for electric cars that have a backup gas engine that powers after battery is depleted, they most often have issues on steep mountain climbs at freeway speeds and or in some cases as I witnessed today when behind a BMW cars slowing very quickly without alarms to other drivers. If the system can generate a low propulsion error warning drivers it can turn the break lights on also in if software is coded correctly. System should turn on break lights when this occurs for BMW and or other electric cars

The contact owns a 2013 Chevrolet Volt. The contact stated that while driving at approximately 45 MPH, the vehicle stalled. The vehicle was able to be restarted. There were no warning lights illuminated. The contact stated that the failure persisted, and the propulsion system warning light was illuminated. The vehicle was taken to the dealer who diagnosed and determined that the battery needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 186,000.

When starting the vehicle, which had some charge on the batteries, the engine immediately started and a message appeared on the speedometer screen which stated, "Propulsion Power Reduced,” and another message said, “speed limited to 25mph.” I was in a very busy part of Hollywood running errands for my job when this happened. I felt very unsafe driving under these circumstances as I often need to drive above 25mph to keep up with traffic and cross busy streets to avoid other cars. The vehicle is available for inspection. It has not been taken to a dealership or anywhere else to have the issue looked at. The problem has occurred a few other times. The vehicle has not been inspected by the manufacturer, police, insurance representatives or others. There were no warnings or other symptoms whatsoever prior to this issue occurring.

When starting the vehicle, which had some charge on the batteries, the engine immediately started and a message appeared on the speedometer screen which stated, "Propulsion Power Reduced,” and another message said, “speed limited to 25mph.” I was in a very busy part of Hollywood running errands for my job when this happened. I felt very unsafe driving under these circumstances as I often need to drive above 25mph to keep up with traffic and cross busy streets to avoid other cars. The vehicle is available for inspection. It has not been taken to a dealership or anywhere else to have the issue looked at. The problem has occurred a few other times. The vehicle has not been inspected by the manufacturer, police, insurance representatives or others. There were no warnings or other symptoms whatsoever prior to this issue occurring.

Sudden loss of power. Driving on freeway. Speed decreased by 25 mph. Just about avoided a rear end accident. Have seen that 2016 onwards Volts have experienced this malfunction. Request that it be noted that this is a 2013 model with less than 60,000 miles. Have already had the latest programming done by Chevy.

I have a 2013 Volt. Passenger Presence pad in the passenger front seat caused the "Airbag Service" warning light. It is very common. So many people have suffered from it. It cost over $1000. But it is not a recall.

I have a 2013 Volt. Passenger Presence pad in the passenger front seat caused the "Airbag Service" warning light. It is very common. So many people have suffered from it. It cost over $1000. But it is not a recall.

1)A diagnostic inspection performed by Terry Labonte Chevrolet in Greensboro, N.C., during the week of Feb. 5-9 found that the car’s propulsion system suffered “catastrophic failure” and was a “total loss.” 2)My wife and I were in convoy when we drove off the used-car lot in Pittsboro, N.C., on [XXX], heading for my sister’s home in Greensboro. By the time we reached [XXX], the Volt would not reach highway speeds as heavy traffic sped past. As NHTSA has reported in another Volt investigation, “the problem could pose a safety risk if vehicles can’t move with the flow of surrounding traffic and is more serious if a stalled vehicle is unable to restart.” 3) On Tuesday, [XXX], a Terry Labonte Chevrolet service representative in Greensboro reported that the main battery had experienced “catastrophic” failure and the “major malfunction” represented a “total loss." 4) Factory dealer Terry Labonte Chevrolet in Greensboro performed the diagnostics. 5) An instrument-panel message appeared about 15 minutes after I drove the Volt off the used-car lot in Pittsboro. The message read “propulsion power is reduced.” The owner manual (Page 5-48) read: “The vehicle may be driven at a reduced speed while this message is on, but maximum acceleration and speed may be reduced.” INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The passenger side seat airbag sensor is malfunctioning. A message displaying “Service Airbag” comes up and the airbag light comes on. This happens numerous times during a typical drive (around 20 minutes) The airbag is turned off while the message and light is displayed. This issue has been occurring for about a year or two now. Starting around 90k miles, currently has 111k miles. I’ve done my research on this issue and many other Volt owners have this issue. Which is caused by a defect in the passenger side sensor mat in the seat that can fold over itself with normal use, causing the issue.

The passenger side seat airbag sensor is malfunctioning. A message displaying “Service Airbag” comes up and the airbag light comes on. This happens numerous times during a typical drive (around 20 minutes) The airbag is turned off while the message and light is displayed. This issue has been occurring for about a year or two now. Starting around 90k miles, currently has 111k miles. I’ve done my research on this issue and many other Volt owners have this issue. Which is caused by a defect in the passenger side sensor mat in the seat that can fold over itself with normal use, causing the issue.

The passenger side seat airbag sensor is malfunctioning. A message displaying “Service Airbag” comes up and the airbag light comes on. This happens numerous times during a typical drive (around 20 minutes) The airbag is turned off while the message and light is displayed. This issue has been occurring for about a year or two now. Starting around 90k miles, currently has 111k miles. I’ve done my research on this issue and many other Volt owners have this issue. Which is caused by a defect in the passenger side sensor mat in the seat that can fold over itself with normal use, causing the issue.

My 2013 Volt will not charge or start. This happened suddenly. It has been working fine.

I was driving my plugin hybrid Volt on a highway when the engine stalled and the engine light turned on. I tap the throttle a few times to get it to stay on. It worked, but I had to continue to tap the throttle to keep it going. It also revved up sharply when it was in low gear. The vehicle was out of battery, so it was as running on engine.

My 2013 Volt will not charge or start. This happened suddenly. It has been working fine.

My 2013 Volt will not charge or start. This happened suddenly. It has been working fine.

I was driving my plugin hybrid Volt on a highway when the engine stalled and the engine light turned on. I tap the throttle a few times to get it to stay on. It worked, but I had to continue to tap the throttle to keep it going. It also revved up sharply when it was in low gear. The vehicle was out of battery, so it was as running on engine.

I was driving my plugin hybrid Volt on a highway when the engine stalled and the engine light turned on. I tap the throttle a few times to get it to stay on. It worked, but I had to continue to tap the throttle to keep it going. It also revved up sharply when it was in low gear. The vehicle was out of battery, so it was as running on engine.

Airbag Sensor Service light keeps going off. Passenger side.

I received a notification on the dashboard that the engine is not in service and propulsion has been reduced. The car is available for inspection upon request. The safety and myself has been deeply compromised because the issues cause the car to suddenly not accelerate without warning. The issue happened to me on a freeway and could have caused an accident due to the engine and propulsion systems stop functioning without warning. The vehicle has been inspected. There were no warnings on why the car was doing what it was doing. The only warning I received was that the engine and propulsion system has now stopped functioning.

I received a notification on the dashboard that the engine is not in service and propulsion has been reduced. The car is available for inspection upon request. The safety and myself has been deeply compromised because the issues cause the car to suddenly not accelerate without warning. The issue happened to me on a freeway and could have caused an accident due to the engine and propulsion systems stop functioning without warning. The vehicle has been inspected. There were no warnings on why the car was doing what it was doing. The only warning I received was that the engine and propulsion system has now stopped functioning.

We purchased this car used in January 2023. Several times throughout 2023 we have gotten a Propoulsion Power Reduced warning. When this happens the car’s ability to accelerate drops and we have also had problems getting it to charge. Following one incident, we let the car sit for 4 days. While the car still would not charge using our at home level 2 charger, the warning went away and I was able to drive it to a dealership. They ran a software update which they said should resolve the issue. Three times since then, when turning the car on from parked it in parking lots away from home, it has given the warning. While driving the car to get it home, the warning has spontaneously resolved.

Intermittent warning for front passenger airbag. Module saying service airbag comes on and off when front passenger is occupying seat. Just a quick anecdote just had car inspected warning does not appear while someone is occupying front seat, nor does it appear if someone is occupying rear seats.

The airbag for the passenger seat is faulty and turns off and on, took it to the dealership and they said it was a $1000 to fix it. Said it was a bad wiring harness

The airbag for the passenger seat is faulty and turns off and on, took it to the dealership and they said it was a $1000 to fix it. Said it was a bad wiring harness

High voltage charging system.. changed out the coolant sensor and the bypass coolant value and still getting high charging error.. machanics can’t figure out the issue and now we can use it as an electric car.. light returns after sitting for an hour and a half in the off position.. something is clearly wrong with the design of the electric side of the car

Passenger airbag sensor intermittent error. Says service airbag. Goes off after someone has been sitting in vehicle and exits vehicle. Not reliably reproducible but seems to be happening with greater frequency.