2005 VOLKSWAGEN TOUAREG Recalls, Complaints & Safety

The contact owns a 2005 Volkswagen Touareg. The contact stated that while driving approximately 30 MPH, the vehicle stalled. The contact pulled over and attempted to restart the vehicle, but the vehicle failed to restart. The contact stated there was no warning light illuminated. The contact had the vehicle towed to the residence. The contact had not taken the vehicle to a dealer or an independent mechanic. The vehicle was not diagnosed nor repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 17V583000 (Fuel System, Gasoline); however, the VIN was not included. The failure mileage was approximately 99,000.

Due to a leak in either the sunroof or the windshield water continuously drips down every time it rains onto the floorboard of the driver side of this vehicle, creating a sopping wet floor board that has 2 inches of water, which in turn soaks the whole electrical system for this vehicle. I mean the water continuously drips from the time you purchase this vehicle until forever I guarantee that anybody who has a v8 version of the 2005 Volkswagen Touareg has a sopping wet driver, side floor board! The water never has a chance to dry, especially in colder climates Mine went into limp mode due to this electrical system, failing. VW MECHANICS told me I needed a whole new engine w! When I did my research and I found out that this is very common on this model, and if there are some wires that inevitably get corroded from all the water that ruins the electrical system underneath the driver side floor board, and therefore the wires become corroded and severed which creates a real problem for the electrical system to function

The issue explained in Recall Notice 20Ai has reappeared after being 'fixed'. Issue Summary: On certain vehicles, the fuel pump flange may develop fine cracks or fissures, which could result in a fuel leak. Leaking fuel, in the presence of an ignition source, could lead to a fire causing injury and/or damage to property. Date of Recall Repair: 02/25/2019 Date of noticed failure: 08/07/2023 It has not been communicated that this part will continue to be a hazard, and I have now discovered that even when noted that this recall action has been completed, my vehicle has gasoline leaking into the passenger compartment via the same avenue as Recall 20Ai notes. This is highly concerning as all impacted VW Touaregs that were 'recalled' may still be at risk of vehicle fire or ignition.

After doing major research with other owners of like year and model I have discovered that i'm not the only one that is experiencing headlight electronics or headlight electrical system within the headlight assembly frying the electrical wires, cracking the brittle wire coating and exposing many of the electrical wires together within the housing unit of the headlight Assembly. This caused many short circuits Headlights Shutting off at random times but most importantly shutting off at night on a dark highway. Depending on the bumps and bruises of the streets would cause the Wires to touch each other and short circuit. Although this is a 17-year-old vehicle but I've never experienced electrical components being degraded this much For like Like age of any vehicle.

Gas leak (see pics). I started noticing a strong gasoline smell and my car keeps running out of gas almost immediately after filling up. This has not been inspected nor confirmed by a dealer. This is my only source of transportation and needs to be fixed ASAP. There is not a VW dealership where I live, the closest being in Mario, IL, or St. Louis, MO.

My vehicle is leaking gas, I was told there is a recall on my vehicle so I took it into the volkswagen dealership where I was told that the recall only covers the driver side leak but not the passenger side leak which makes absolutely no sense. Because when I drive off of the service lot the problem still exists which means I could be blown up or cause injury of fire. This recall should cover ALL aspects of the fuel leak! Not just one side! Making customers pay for this is disgusting! I am a single mom and don't have an extra $600 to spend on an issue that should have been corrected by the manufacturer.

PASSENGER AIRBAG WARNING LIGHT ON DASH SHOWS AIRBAG WILL NOT DEPLOY IN A CRASH. WATER COMES FROM BEHIND DASHBOARD ONTO DRIVERS AND PASSENGER SIDE FLOOR BOARD WHEN TURNING WHILE DRIVING LIKELY CAUSE BY CLOGGED AC DRAINS BEHIND WHEEL WELLS. FUEL PUMP PREMATURE FAILURE, AFTER REFUELING. HEADLINER FALLING FROM CEILING ON TO DRIVER AND PASSENGERS WHILE DRIVING ON HIGHWAY, WEATHER WAS HOT AND HUMID.

I TOOK MY SUV TO THE DEALERSHIP FOR A FUEL PUMP RECALL, ABOUT 3,000 MILES AFTER MY SUV IS CAUSING PROBLEMS LIKE START BUT TURN OFF WITHIN 40 SECONDS. I TOOK IT TO A LOCAL MECHANIC FOR DIAGNOSIS AND HE SAYS IS THE FUEL PUMP. I CONTACTED THE DEALERSHIP BUT THEY ARE KIND OF UNRESPONSIVE...NO ADVISORS AVAILABLE, NO RETURNED CALLS (VOLKSWAGEN SOUTH COAST SANTA ANA CA).

WHEN I GET GAS FOR MY TOUAREG 2005 I'LL SHUT THE SUV OFF POP OPEN THE FUEL BOX DOOR AND PUT THE GAS IN THEN AS I PUT CAP BACK ON SHUT DOOR GET IN THE SUV I TRY TO START THE SUV BUT IT SEEMS AS IF THE CARS EITHER OUT OF GAS OR BATTERY HAS DIED SO AFTER THE FIRST LIKE SAY 4-6 TIMES OF THIS HAPPENING TO ME I TRIED TO LEAVE THE CAR RUNNING AS I PUT THE GAS IN THE SUV IN HOPES OF IT STILL REMAIN ON AND RUNNING BUT SURE ENOUGH THE SUVS BATTERY LIGHT WILL POP ON AND THE CAR WILL LOSE LIFE BUT THE LIGHTS AND STUFF STILL REMAIN ON BUT NO DRIVING HAPPENING SO I'D HAVE TO TURN THE KEY OFF THEN TRY AND START IT UP AGAIN BUT AS I TURN THE KEY I'LL HAVE TO PUMP THE GAS PEDDLE A BUNCH TO CATCH THE FLOW I GUESS

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN TOUAREG. THE CONTACT STATED THAT EACH TIME IT RAINED, WATER ACCUMULATED ON THE FRONT DRIVER SIDE FLOOR THROUGH THE FRONT DRIVER SIDE DOOR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE WIRES ON THE FRONT DRIVER SIDE FLOOR WERE CORRODED AND NEEDED TO BE REPLACED. THE CONTACT LATER CALLED STONE MOUNTAIN VOLKSWAGEN AT (678) 367-4286 (LOCATED AT 3500 STONE MOUNTAIN HWY, SNELLVILLE, GA 30078) AND WAS INFORMED TO SCHEDULE AN APPOINTMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 104,000.

OVERALL LIFE OF CAR HAVE HAD TO REPLACE THE MAJORITY OF THE HOSES IN THE ENGINE, THE FUEL LINE, THE EMERGENCY BRAKE RELEASE LEAVOR-3 TIMES, THE HORN ON THE PASSENGER AND DRIVERS SIDE. AND WITH THE RECALL THE GAS FLANGE - CRACKING. THE PRODUCT VW USES IN THIS VEHICLE IS INFERIOR- PLASTIC EXPANDS WHEN HOT AND CONTRACTS WHEN COLD= CRACKING. PLEASE RECALL THIS VEHICLE DUE TO THE POTENTIAL OF THE GAS FLANGE OR WHATEVER ELSE IS RELATED TO THE GAS BEFORE ANYONE IN MY FAMILY OR OTHERS DIE. OR MY CAS GOES UP INTO FLAMES CAUSING SEVERE TRAUMA- ESPECIALLY BECAUSE YOU ALREADY KNOW THERE IS A PROBLEM. WE HAVE PAID THOUSANDS OF DOLLARS IN REPAIR COSTS IN THIS VEHICLE THAT VW OF AMERICA WILL NOT HELP - THE ENTIRE ENTERRIER PLASTIC COATING TO THE VEHICLE HAS MELTED - THE DRIVERS SIDE VISITOR HANGS AS THE SPRING ACTION OR WHAT EVER IT'S CALLED IS BROKEN. WE HAVE OWNED MANY CARS, FORDS, TOYOTA'S, HONDA'S AND SEVERAL VWS. THE TOUAREG AND ALL OF PRIMARY SAFETY FEATURES SHOULD ALWAYS FUNCTION SAFELY-THE GAS ISSUE IS A MAJOR ISSUE THAT SHOULD AUTOMATICALLY BE A RECALL TO SAVE LIVES!

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN TOUAREG. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V583000. (FUEL SYSTEM, GASOLINE); HOWEVER, THE PARTS TO DO THE RECALL REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VOLKSWAGEN DEALER (PERRY VOLKSWAGEN, 12200 LOS OSOS VALLEY RD, SAN LUIS OBISPO, CA 93405, 805-544-5200) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

2005 VOLKSWAGEN TOUAREG. CONSUMER WRITES IN REGARDS TO THE FUEL FILTER FLANGE. *LD THE CONSUMER REQUESTED TO BE REIMBURSED FOR THE FUEL FILTER FLANGE RECALL. *JS

IN JUNE 2017, I NOTICED FUEL SMELL INSIDE THE VEHICLE. ON JULY 1, 2017, I INSPECTED THE ISSUE AND DISCOVERED THAT THE FUEL FILTER FLANGE WAS DAMAGED AND LEAKING FUEL (FUMES) CLOSE TO ELECTRICAL COMPONENTS AND UNDER THE SEAT WHERE MY SON SITS. PLEASE SEE THE ATTACHED PHOTO. I ORDERED THE RETAINER RINGS AND GASKETS (BOTH SIDES) FROM A VW DEALERSHIP. ON JULY 14, 2017, I ORDERED TA NEW FUEL FILTER FLANGE FROM A SELLER ON EBAY THAT SPECIALIZES IN NEW VW PARTS. THE FUEL FILTER FLANGE WAS NEW AND MANUFACTURED BY VDO (CONTINENTAL). I INSTALLED ALL THE PARTS TOWARDS THE END OF JULY 2017 AND THIS FIXED THE PROBLEM. I ACTUALLY REPLACED BOTH SIDES (DRIVER & PASSENGER) BECAUSE BOTH SIDES ARE A PROBLEM. PLEASE KEEP IN MIND THAT I WASN'T OR SHOULDN'T HAVE WAITED UNTIL THE RECALL NOTICE. THIS WAS A SERIOUS SAFETY FLAW AND NEEDED TO BE FIXED IMMEDIATELY. I HAVE A GOOD KNOWLEDGE IN MECHANICS AND CAPABLE TO PERFORM MOST REPAIRS. I DIDN'T DRIVE THE CAR UNTIL I RECEIVED THE PARTS AND FIXED THE ISSUE. I SUBMITTED MY RECEIPTS FOR REIMBURSEMENT UNDER THE RECALL. PLEASE SEE THE LETTER FROM VW DENYING ANY REIMBURSEMENT. THEY CLAIM THAT MY PARTS WERE NOT NEW AND NOT VW APPROVED PARTS. THE RETAINER RING & GASKET WAS PURCHASED BY A VW DEALERSHIP AND THE FUEL FILTER FLANGE WAS NEW AND MANUFACTURED BY VDO, WHICH IS THE OE COMPANY THAT MAKES THEM FOR VW. VOLKSWAGEN OF AMERICA IS CLEARLY NOT TAKING THIS ISSUE SERIOUS AND DOESN'T CARE ABOUT THE SAFETY OF ITS CONSUMERS. THEY ARE DENYING CLAIMS FOR REIMBURSEMENT AND DISREGARDING THIS SERIOUS ISSUE. I HAD NO CHOICE AND FIXED THE ISSUE IMMEDIATELY.

VEHICLE CABIN COULD SMELL GAS, FACTORY ISSUED LETTER TO US WITH RECALL AND FREE REPAIR AND REPLACEMENT, BUT AFTER CONTACT VW DEALERSHIP, THE DEALERSHIP REFUSE TO REPAIR IT FOR FREE, QUOTE 480 DOLLARS FOR FIXING THIS RECALL ISSUE.

THE STEERING WHEEL LOCKING DEVICE DOES NOT BLOCK THE STEERING WHEEL ANY MORE AFTER PARKING THE VEHICLE AND REMOVING THE KEY IGNITION LOCK. INSTEAD WHEN TURNING THE STEERING WHEEL THERE IS A PRONOUNCED RATTLING NOISE COMING FROM INSIDE THE STEERING WHEEL. THE WHEEL LOCKING MECHANISM DOES NOT WORK.

GASOLINE LEAKING FROM THE TANK RUNS OVER THE RIGHT-SIDE EXHAUST TUBES TO THE GROUND. THE FLOW OF THE FUEL LEAKAGE IS VERY HIGH AT A DROP-RATE OF MORE THAN ONE DROP PER SECOND WITH THE VEHICLE PARKED AND THE ENGINE RUNNING AT IDLE SPEED. ONCE THE ENGINE IS TURNED OFF THE LEAKAGE STOPS WITHIN SHORT TIME. I GOT AWARE OF THE DEFECT DUE TO THE STRONG GASOLINE SMELL AFTER STOPPING AND GETTING OFF THE VEHICLE. I INVESTIGATED AND SAW GASOLINE DROPPING TO THE GROUND BETWEEN THE REAR WHEELS. THE FACT THAT THE FUEL IS RUNNING OVER THE EXHAUST TUBE MADE ME GROUND THE VEHICLE IMMEDIATELY FOR SAFETY REASONS. ALTHOUGH I NEED THIS VEHICLE I DECIDED TO KEEP IT GROUNDED DUE TO THE HIGH RISK THAT THE GASOLINE GETS IGNITED BY THE HOT EXHAUST TUBE.

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN TOUAREG. WHILE THE VEHICLE WAS PARKED, THERE WAS AN ODOR OF FUEL EMITTED IN AND AROUND THE VEHICLE, MOSTLY ON THE PASSENGER SIDE AND THE REAR OF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 17V151000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL AND DID NOT OFFER FURTHER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

FUEL LEAKING AT FUEL PUMP FLANGE. STRONG FUEL VAPOR ODOR IN THE CABIN WHILE DRIVING AND PARKED.

I WENT IN VACATION AND LEFT MY CAR PARKED IN THE DRIVEWAY WITH THE WINDOWS UP AND DOORS LOCKED.WHEN I CAME BACK TO MY CAR THE ADHESIVE/GLUE MUST HAVE MELTED DUE TO THE HEAT OUTSIDE THE CAR CAUSED THE REAR VIEW MIRROR TO DETACH FROM THE WINDSHIELD AND IT IS NOW DANGLING BY THE WIRES FROM THE INSIDE OF THE CAR/WINDSHIELD

THE TOP OF THE FUEL FILTER HOUSING CRACKED AND WAS LEAKING FUEL. THIS HOUSING IS UNDERNEATH THE REAR SEAT BEHIND THE DRIVER'S SEAT. THE CRACKS WEREN'T RELATED TO USAGE OF THE VEHICLE OR AN ACCIDENT. IT APPEARS TO BE GENERAL DETERIORATION OF THE PLASTIC. THIS IS THE SAME PROBLEM COVERED BY VW RECALL 20Z4 OR NHTSA REFERENCE #17V151000. HOWEVER THOSE ONLY COVER VEHICLES BACK TO 2007.

SMALL CRACKS DEVELOPED IN THE FUEL FILTER FLANGE ON THE FUEL TANK RESULTING IN FUEL LEAKING OUT WHEN THE DRIVERS DOOR WAS OPENED OR WHEN THE CAR WAS RUNNING. THIS RESULTED IN LARGE AMOUNTS OF GASOLINE LEAKING ONTO MY GARAGE FLOOR. THE FLANGE WAS REPLACED. THIS IS AN IDENTICAL PROBLEM THAT IS BEING EXPERIENCED BY THE AUDI Q7 WHICH HAS THE IDENTICAL VW PART NUMBER FOR THE AFFECTED PART. THE NHTSA RECALL NUMBER FOR THAT PROBLEM IS 16V60000 IF YOU HAVE A TOUAREG, PORSCHE CAYENNE, OR AUDI Q7 (THEY ALL HAVE THE SAME PART) AND YOU SMELL GASOLINE, DO NOT OPEN THE DRIVERS DOOR. DOING SO PRIMES THE FUEL SYSTEM PUTTING THE FLANGE UNDER PRESSURE CAUSING LARGE AMOUNTS OF FUEL TO LEAK OUT.

I AM THE OWNER OF A 2005 VW TOUAREG WHICH RECENTLY HAD THE AIR BAG WARNING LIGHT COME ON AND STAY ON. I TOOK THE TOUAREG TO A VOLKSWAGEN DEALER WHERE I WAS CHARGED $104.48 FOR A DIAGNOSTIC TEST. THE DIAGNOSTIC TEST PROVIDED THE STORED FAULT CODE OF 01218, FRONT SIDE PASSENGER AIRBAG IGNITOR UPPER LIMIT EXCEEDED, THUS RECOMMENDING REPLACEMENT OF THE AIRBAG WIRING HARNESS FOR $320.00 ESTIMATE. IT IS MY UNDERSTANDING THAT THIS IS A KNOWN MANUFACTURERS DEFECT THAT VW ADDRESSED WITH THE NHTSA BY A TOUAREG SERVICE PACK/CUSTOMER SATISFACTION CAMPAIGN IN LATE DECEMBER 2006 WHERE VVV REPLACED THE SUBJECT DEFECTIVE HARNESSES AT NO EXPENSE TO TOUAREG OWNERS. THE VW ASSISTANT SERVICE MANAGER INFORMED ME THAT ACCORDING TO THE VEHICLE RECORDS THIS REPLACEMENT WAS NOT PERFORMED ON MY TOUAREG. PLEASE ADVISE WHY THIS DEFECTIVE AIRBAG WIRING HARNESS WAS NOT REPLACED DURING THIS CAMPAIGN. BASED UPON MY CONCERN AS A SAFETY AND HEALTH PROFESSIONAL, AND MY REVIEW OF THE INFORMATION AND FILES AVAILABLE FROM NHTSA CONCERNING THE PREVIOUS INVESTIGATION OF THIS PROBLEM IN 2006, I BELIEVE THAT VWS FAILURE TO CONTINUE TO CORRECT THIS PROBLEM NEEDS TO BE ADDRESSED BY NHTSA FOR CONSIDERATION OF REOPENING OF THIS INVESTIGATION. AS STATED IN THE ODI RESUME FOR INVESTIGATION: PE 06-022, SUBJECT: SRS WARNING LIGHT ILLUMINATION, .THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. I EXPECT NHTSA WILL REQUEST DATA FROM VW ON HOW MANY VW TOUAREGS HAVE REPORTED, OR BEEN DIAGNOSED WITH THIS PROBLEM SINCE 2006, AND HOW MANY OWNERS HAVE PAID VW OR OTHER REPAIR FACILITIES TO REPLACE THESE AIR BAG WIRING HARNESSES AND RELATED EQUIPMENT. THE TOUAREG SERVICE PACK/CUSTOMER SATISFACTION CAMPAIGN IN LATE DECEMBER 2006 WHERE VVV REPLACED THE SUBJECT DEFECTIVE HARNESSES AT NO EXPENSE TO TOUAREG OWNERS WAS AN ACTION TAKEN AT THAT TIME TO AVOID A RECALL. RECONSIDER!

TRIED TO BUCKLE UP ONE OF THE REAR SEAT BELTS AND BUCKLE PLASTIC HOUSING BROKE. THE DEALER FAILED TO ACKNOWLEDGE THAT A SEAT BELT MECHANISM SHOULD NEVER FAIL. INSTEAD, THE DEALER SAID I HAD TO PAY OUT OF POCKET TO HAVE IT REPLACED. I CONTACTED VOLKSWAGEN OF AMERICA TO REPORT THIS CONCERN AND ASKED THEM TO COVER FOR THIS REPAIR. THEY DECLINED TO COVER THIS REPAIR FREE OF CHARGE.

THE VEHICLE HAS AN ANNOYING PROCLIVITY TO HESITATE (SOMETIMES FOR AS LONG AS 3 OR 4 SECONDS) BETWEEN THE TIME THE ACCELERATOR PEDAL IS DEPRESSED AND THE TIME THE ENGINE RESPONDS. UNDER CERTAIN CIRCUMSTANCES (E.G., CROSSING A LANE OF HIGH SPEED TRAFFIC) THE DELAY COULD BE VERY DANGEROUS AND EVEN FATAL. IT HAS BEEN DOING THIS SINCE IT WAS NEW, AND IT HAPPENS ONLY WHEN DECELERATING, NOT COMING TO A COMPLETE STOP, AND THEN ATTEMPTING TO ACCELERATE. WE TRADED IN A 2004 TOUAREG V8 THAT WE HAD PURCHASED USED WITH 30K MILES BECAUSE OF THE IDENTICAL PROBLEM, THINKING THAT THE DEFECT WOULD HAVE CORRECTED ON THE NEWER VEHICLE. THE 2005 TOUAREG V8 WAS PURCHASED NEW FOR $55,000 PLUS TAX AND LICENSE. THE VEHICLE NOW HAS 32,180 MILES ON IT. *TR

BOTH LEFT AND RIGHT HEADLIGHTS FAILED AND WOULD NOT OPERATE IN LOW BEAM MODE. UPON INSPECTION, I NOTED THAT THE INSULATION FOR THE WIRING INSIDE EACH HEADLIGHT UNIT WAS BRITTLE, CRACKED AND IN SOME CASES THE INSULATION HAD FALLEN COMPLETELY OFF. THIS CAUSED BOTH HEADLIGHTS TO GROUND OUT AND FAIL, POTENTIALLY HAZARDOUS DURING VEHICLE OPERATION AND A POTENTIAL FIRE HAZARD. *TR

IT'S NOT LETTING ME SELECT ANY PARTS THERE IS A GLITCH IN THIS WEBSITE. IT IS MY ENTIRE WIRING SYSTEM! HAS COST US 100S OF DOLLARS! *TR

THIS IS A WELL DOCUMENTED PROBLEM ALL OVER THE WEB YET VW AND TO DATE THE NHTSA REFUSE TO ADDRESS THE ISSUE. MAYBE THERE IS A REQUIREMENT THAT AT LEAST 13 PEOPLE DIE (GM) BEFORE ANYONE DOES SOMETHING ABOUT IT. PROBLEM IS WITH TRANSMISSION WHICH CAUSES CAR TO JOLT FORWARD AS IF IT IS GETTING RAMMED IN THE REAR OF THE VEHICLE. CAN CAUSE LOSS OF CONTROL, WHIP LASH, REAR ENDING, ETC... *TR

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN TOUAREG. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE FUEL GAUGE DISPLAYED AN INACCURATE READING. IN ADDITION, THE FUEL TANK LEAKED GASOLINE CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS, WHO RECOMMENDED THAT THE VEHICLE BE INSPECTED BY AN AUTHORIZED DEALER. THE VEHICLE WAS NOT INSPECTED BY AN AUTHORIZED DEALER NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 141,323.

AIR BAG DEFAULT LIGHT CAME ON INDICATING PASSENGER AIR BAG WILL NOT DEPLOY DURING A CRASH. THE OTHER PROBLEM WITH THIS IS IF ONE AIR BAG IS INDICATED NONE OF THE AIR BAGS WILL DEPLOY IN A CRASH. THIS IS A KNOWN PROBLEM WITH THIS VEHICLE WHICH VOLKSWAGEN HAS KNOWN ABOUT, BECAUSE IN 2005 IT WAS FOUND THAT THE AIR BAG CONNECTION PLUG LOCATED UNDER THE PASSENGER SEAT WAS TO SHORT AND WOULD COME DISCONNECTED CAUSING THE DEFAULT AIR BAG WARNING LIGHT TO COME. I BELIEVE IN 2005 A FLASH PROGRAM WAS ISSUED FOR ANOTHER PROBLEM WITH THE AIR BAGS, THE FLASH PROGRAM WAS TO FIX THE PROBLEM WITH WHEN THE KEY WAS PLACED INTO THE IGNITION AND THE PASSENGER SEAT IS MOVED WITHIN 10 SECONDS AFTER THE KEY WAS IN THE IGNITION THIS WOULD CAUSE THE DEFAULT AIR BAG WARNING LIGHT TO COME ON. BEFORE A MASS COMPLAINT COULD COME OUT VOLKSWAGEN DROP THE FLASH PROGRAMMING AND LEFT IT UP TO THE CONSUMER TO DEAL WITH THE PROBLEM. I HAVE BROUGHT THIS UP WITH MY VOLKSWAGEN DEALERSHIP WHOM I BROUGHT THE TRUCK FROM AND CONTINUE TO HAVE ALL MAINTENANCE DONE BY THEM, THE DEALERSHIP TELLS ME THE SENSOR HAS TO BE REPLACED, AND THIS WILL COST BIG BUCKS FOR THE CONSUMER BECAUSE OF A BAD DESIGNED PRODUCT. THIS PROBLEM MANIFESTED AFTER THE ALARM SIREN STARTED TO GO OUT, AND TO FIND OUT LATER THAT THE ALARM SIREN HAS RECHARGEABLE WATCH TYPE BATTERIES, WHICH GOES BAD AND LEAKS ACID THEN CORRODES CAUSING SHORT IN THE ELECTRICAL SYSTEM, BECAUSE THE BATTERIES ARE CHARGED BY THE CARS BATTERY. THIS POOR DESIGN WILL CAUSE YOU THE CONSUMER $2000.00 TO REPLACE AIR BAG SENSOR, ALARM SIREN AND YOUR MAIN CAR BATTERY. THIS IS AN EXPENSIVE VEHICLE AND I LOVE MY TRUCK BUT HATE WHEN PROBLEMS ARISE AND NO ONE HAVE ANY ANSWERS AND WHEN IT COMES TO A SAFETY DEVICES, LIKE "AIR BAGS" THE DEALERSHIP SHOULD JUMP ON A RESOLUTION INSTEAD OF RUNNING AWAY, BECAUSE AIR BAGS KILL MORE PEOPLE THAN A CRASH ITSELF. *TR

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN TOUAREG. THE CONTACT STATED THAT THE DRIVE SHAFT FAILED AND WAS REPAIRED UNDER THE CONTACT'S WARRANTY. THE FAILURE RECURRED RECENTLY AND THE CONTACT STATED THAT THE FAILURE RECURRED LESS THAN 30,000 MILES LATER. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 80,000. THE VIN WAS NOT AVAILABLE. *TR

SIGN CONSISTENTLY APPEARS SAYING "OIL PRESSURE PROBLEM STOP ENGINE NOW" ESPECIALLY WHEN YOU TRY TO EXIT THE FREEWAY. ACCORDING TO VOLKSWAGEN DEALER, THIS COULD DAMAGE THE ENGINE BEYOND REPAIR. THIS IS A FACTORY DEFECT THAT IS HAPPENING TO MANY VOLKSWAGEN BRANDS. THIS IS SOMETHING VOLKSWAGEN KNEW ABOUT AND SHOULD DO SOMETHING ABOUT IT. VOLKSWAGEN CORPORATION SHOULD RECALL ALL VEHICLE WITH THIS PROBLEM AND FIX IT WITHOUT CURRENT OWNERS SUFFERING FOR IT. LET ME ADD THAT I HAVE CHANGED THE SWITCH, FLUSHED ENGINE, CHANGED OIL, CHANGED CATALYTIC CONVERTER, CHANGED OIL PUMP THAT CONNECTS THE OIL PAN WITH THE ENGINE, THE PROBLEM WOULD STOP FOR A WHILE AND COMES BACK AGAIN. *TR

SMELL OF GAS AFTER REFUELING -- APPARENTLY SIMILAR TO MERCEDE BENZ --DEALER REPORTS THE GASKETS AT THE TOP OF THE FUEL TANK HAVE FAILED FOR A REPAIR COST OF $8-900.00: WATER COOLED ALTERNATOR FAILURE REQUIRING $8-900.00

VEHICLE HAS BEEN EMITTING AN ODOR OF GAS FOR SOME TIME. UPON INVESTIGATION, I FOUND THAT THE FUEL FILTER (ACCESSED UNDER THE REAR SEAT BUT PART OF THE FUEL TANK) HAD A 1/8" CRACK IN THE TOP OF THE FILTER ASSEMBLY. THIS CRACK WOULD LEAK GASOLINE WHILE THE ENGINE WAS RUNNING AND EVEN AFTER THE ENGINE STOPPED (LIKELY DUE TO THE FUEL SYSTEM STILL BEING PRESSURIZED). LEAKED GASOLINE WAS FOUND THROUGHOUT THE TOP OF THE GAS TANK OBSERVED THROUGH TWO PORTS UNDER THE REAR BENCH SEAT. I DID SOME RESEARCH ON A POPULAR TOUAREG WEBSITE AND FOUND THAT 1 OR 2 OTHER PEOPLE HAVE EXPERIENCED THE SAME PROBLEM. I SUSPECT THIS IS A FIRE HAZARD GIVEN THE AMOUNT OF FUEL THAT HAS BEEN LEAKED. AND OTHERS HAVE EXPERIENCED A LEAK EMANATING FROM THE SAME LOCATION. *TR

THE STEERING LOCK AND WAS UNABLE TO OPEN OR MOVE. *TR