2004 VOLKSWAGEN TOUAREG
4 recalls — 373 complaints — 360 TSBs
17V583000 Sep 20, 2017
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Defect Description
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2004-2007 Touareg vehicles. These gasoline-powered vehicles have a fuel filter flange that may crack, allowing fuel to leak.
Consequence
A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy
Volkswagen will notify owners, and dealers will inspect the fuel filter flange for cracks, replacing the flange if cracks are found. If no cracks are found, a protective cover will be installed onto the filter flange. These repairs will be performed free of charge. The recall began March 9, 2018.... Read more
04V592000 Dec 15, 2004
SEAT BELTS
Defect Description
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." ALL THREE REAR SEAT POSITIONS AND THE FRONT PASSENGER POSITION ARE EQUIPPED WITH SEAT BELT RETRACTORS THAT HAVE A LOCKING FEATURE WHICH CONVERTS THE RETRACTOR ... Read more
Consequence
WHEN INVOLVED IN A CRASH, THE CHILD RESTRAINTS MAY NOT BE PROPERLY SECURED, INCREASING THE RISK OF INJURIES OR DEATH.
Remedy
DEALERS WILL PERMANENTLY INSTALL A 'CLIP' IN EACH OF THE TWO REAR OUTBOARD SEAT BELTS. THE CLIPS WILL PREVENT UNWANTED DEACTIVATION OF THE ALR MODE WITH CHILD SEAT INSTALLATIONS. THE RECALL BEGAN ON APRIL 11, 2005. OWNERS SHOULD CONTACT VW AT 1-800-822-8987.
04V233000 May 19, 2004
SEAT BELTS:REAR/OTHER
Defect Description
ON CERTAIN SPORT UTILITY VEHICLES, THE REAR SEAT BELT LATCH ATTACHMENT BOLT MAY HAVE BEEN INSUFFICIENTLY RIVETED.
Consequence
IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy
DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE BELT BUCKLE. OWNER NOTIFICATION BEGAN ON JUNE 21, 2004. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
03V266000 Jul 25, 2003
ELECTRICAL SYSTEM:WIRING
Defect Description
ON CERTAIN SPORT UTILITY VEHICLES, THE TIRE PRESSURE MONITORING SYSTEM (TPMS) WIRING HARNESS MAY HAVE BEEN IMPROPERLY ROUTED DURING ASSEMBLY. AN IMPROPERLY ROUTED TPMS WIRING HARNESS MAY CONTACT THE PARKING BRAKE CABLE SPRING.
Consequence
IF THIS HAPPENS, THE TPMS WIRING CIRCUIT COULD BE INTERRUPTED, RESULTING IN AN INOPERATIVE TPMS, AND CAUSING A SHORT-TO-GROUND CONDITION THAT COULD POTENTIALLY RESULT IN A FIRE.
Remedy
DEALERS WILL INSPECT THE TPMS WIRING HARNESS ROUTING AND, IF NECESSARY, CORRECT THE WIRING HARNESS ROUTING. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT VWOA AT 1-800-893-5298.
Complaint Statistics
373 total complaints
16 crashes 12 fires 14 injuries
Top Reported Components
| Component | Complaints |
|---|---|
| ELECTRICAL SYSTEM | 36 |
| POWER TRAIN:AUTOMATIC TRANSMISSION | 26 |
| TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS | 23 |
| FUEL/PROPULSION SYSTEM | 22 |
| AIR BAGS | 20 |
| VEHICLE SPEED CONTROL | 17 |
| STEERING | 13 |
| TIRES | 12 |
| SUSPENSION | 12 |
| POWER TRAIN | 11 |
STEERING
Nov 9, 2025
Incident date: Sep 24, 2025
Steering wheel is sticking at highway speeds. When going around a curve at highway speeds, steering becomes stuck, requiring additional effort to turn and keep vehicle centered in lane. Steering wheel has to be 'broken loose' by pulling it to the direction opposite of the curve. This results in the ... Read more
FUEL/PROPULSION SYSTEM
Sep 4, 2025
Incident date: Sep 3, 2025
Randomly, the car have a delay of approximately 2 seconds when I hit the gas pedal. It happened multiple times, 2-3 times per day. The gas pedal can pe pressed to the floor, it won’t react. After 2 seconds or so it will react and drive normally. I noticed this is happening when the car is in EV mo... Read more
ELECTRICAL SYSTEM
Oct 24, 2024
Incident date: Oct 24, 2024
Dashboard warning lights all light up at once. Flickering on and off. Lights turn on and off inside car, it unlocks and locks car on it’s own. Says key is not close to car when trying to turn on car. Alarm goes off randomly once parked and locked.
SERVICE BRAKES
Apr 24, 2023
Incident date: Apr 20, 2023
THE BRAKES ARE REALLY HARD WHEN PRESSING TAKES ALOT OF FORCE AND ALSO TAKES VERY LONG TO STOP NOW MY TRUCK PEDAL IS SOFT AND MY TRUCK IS STUTTERING FROM LOSS OF VACCUUM AND ALSO MADE ME FLY DOWN MY DRIVEWAY WITH NO WAY TO STOP
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Apr 24, 2023
Incident date: Apr 20, 2023
THE BRAKES ARE REALLY HARD WHEN PRESSING TAKES ALOT OF FORCE AND ALSO TAKES VERY LONG TO STOP NOW MY TRUCK PEDAL IS SOFT AND MY TRUCK IS STUTTERING FROM LOSS OF VACCUUM AND ALSO MADE ME FLY DOWN MY DRIVEWAY WITH NO WAY TO STOP
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Jun 14, 2022
Incident date: Jun 14, 2022
The contact owns a 2004 Volkswagen Touareg. The vehicle had previously been serviced at the dealer under NHTSA Campaign Number: 17V583000 (Fuel System, Gasoline) however, the fuel pump failed after the recall repair was performed. The vehicle was taken to the dealer and diagnosed with fuel pump fail... Read more
ENGINE
Nov 25, 2021
Incident date: Apr 1, 2021
Leaking gas caught on fire put it out but now I have no head lights no high beams replaced everything still nothing. All lights on dash go crazy kills battery all the time and had to replace something in the rear end. Overall it has cost me $2500 and I still have no headlights at all and leaking ga... Read more
Fire
1 injured
ELECTRICAL SYSTEM
Nov 25, 2021
Incident date: Apr 1, 2021
Leaking gas caught on fire put it out but now I have no head lights no high beams replaced everything still nothing. All lights on dash go crazy kills battery all the time and had to replace something in the rear end. Overall it has cost me $2500 and I still have no headlights at all and leaking ga... Read more
Fire
1 injured
EXTERIOR LIGHTING
Nov 25, 2021
Incident date: Apr 1, 2021
Leaking gas caught on fire put it out but now I have no head lights no high beams replaced everything still nothing. All lights on dash go crazy kills battery all the time and had to replace something in the rear end. Overall it has cost me $2500 and I still have no headlights at all and leaking ga... Read more
Fire
1 injured
AIR BAGS
Jun 28, 2021
Incident date: Jun 25, 2021
The contact owns a 2004 Volkswagen Touareg. The contact stated while driving approximately 75 mph, the driver’s side curtain air bag deployed inadvertently. Due to the inadvertent air bag deployment, the vehicle failed to restart. The contact had not taken the vehicle to a dealer. The vehicle had ... Read more
EXTERIOR LIGHTING
Nov 17, 2020
Incident date: Nov 15, 2020
LIGHT WENT OUT ON DARK ROAD. NEARLY CRASHED. FOUND INSULATION ON WIRES FOR LIGHTS DETERIORATED. HARNESS WAS MELTED LOWER IN THE FENDER. ONLINE SEARCH FOUND SAME ISSUE IS COMMON AND INCLUDED FIRES.
Fire
ELECTRICAL SYSTEM
Nov 17, 2020
Incident date: Nov 15, 2020
LIGHT WENT OUT ON DARK ROAD. NEARLY CRASHED. FOUND INSULATION ON WIRES FOR LIGHTS DETERIORATED. HARNESS WAS MELTED LOWER IN THE FENDER. ONLINE SEARCH FOUND SAME ISSUE IS COMMON AND INCLUDED FIRES.
Fire
FUEL/PROPULSION SYSTEM
Aug 9, 2020
Incident date: Aug 8, 2020
SUV IS NOT GETTING GAS TO ENGINE
FUEL/PROPULSION SYSTEM
Dec 4, 2019
Incident date: Dec 2, 2019
THERE IS A STRONG SMELL OF GASOLINE OUTSIDE OF THE CAR AFTER THE CAR HAS BEEN DRIVEN (OR WHILE IT'S DRIVING, BUT IT'S NOT OFTEN I'M OUTSIDE OF THE CAR WHILE IT'S RUNNING). THIS IS DUE TO THE PLASTIC HOUSING ON THE FUEL PUMP THAT HAS DEVELOPED A CRACK, AND IS LEAKING GASOLINE. THIS IS SIMILAR TO AN... Read more
SERVICE BRAKES
Aug 20, 2019
Incident date: Aug 20, 2019
LIGHTS ON THE DASH COME ON HILL ASSIST SHUTS ON AND OFF BY ITSELF BRAKE LIGHT COMES ON AND OFF SUNROOF HAS OPEN BY ITSELF AC HAS STOPPED WORKING AND THE NEXT DAY WORKS AGAIN HEATED STEERING WHEEL WORKS WHEN IT WANTS THIS HAPPENED WHILE YOU'RE DRIVING OR SITTING STILL EVERYTHING I HAVE READ ON THE IN... Read more
ELECTRICAL SYSTEM
Aug 20, 2019
Incident date: Aug 20, 2019
LIGHTS ON THE DASH COME ON HILL ASSIST SHUTS ON AND OFF BY ITSELF BRAKE LIGHT COMES ON AND OFF SUNROOF HAS OPEN BY ITSELF AC HAS STOPPED WORKING AND THE NEXT DAY WORKS AGAIN HEATED STEERING WHEEL WORKS WHEN IT WANTS THIS HAPPENED WHILE YOU'RE DRIVING OR SITTING STILL EVERYTHING I HAVE READ ON THE IN... Read more
FUEL/PROPULSION SYSTEM
Jul 8, 2019
Incident date: Jul 1, 2019
FUEL FLANK WAS SEALED BY THE DEALERSHIP. HOWEVER, THERE IS FUEL LEAKING.
FUEL/PROPULSION SYSTEM
Jul 8, 2019
Incident date: May 27, 2019
I WAS DRIVING ON THE HIGHWAY @ 70MPR WHEN ALL OF A SUDDEN WITHOUT WARNING THE CAR STARTS ACTING SLUGGISH FOR A MIN THEN BACK TO NORMAL, AND RANDOMLY FOR THE NEXT HOUR OR SO DOES(I HAD A WAYS TO GO) THIS A FEW MORE TIMES. I GOT TO MY DESTINATION AND LET HER REST FOR THE NIGHT. THE NEXT MORNING IT WAS... Read more
ELECTRONIC STABILITY CONTROL (ESC)
Jul 8, 2019
Incident date: May 27, 2019
I WAS DRIVING ON THE HIGHWAY @ 70MPR WHEN ALL OF A SUDDEN WITHOUT WARNING THE CAR STARTS ACTING SLUGGISH FOR A MIN THEN BACK TO NORMAL, AND RANDOMLY FOR THE NEXT HOUR OR SO DOES(I HAD A WAYS TO GO) THIS A FEW MORE TIMES. I GOT TO MY DESTINATION AND LET HER REST FOR THE NIGHT. THE NEXT MORNING IT WAS... Read more
ENGINE
Jul 8, 2019
Incident date: May 27, 2019
I WAS DRIVING ON THE HIGHWAY @ 70MPR WHEN ALL OF A SUDDEN WITHOUT WARNING THE CAR STARTS ACTING SLUGGISH FOR A MIN THEN BACK TO NORMAL, AND RANDOMLY FOR THE NEXT HOUR OR SO DOES(I HAD A WAYS TO GO) THIS A FEW MORE TIMES. I GOT TO MY DESTINATION AND LET HER REST FOR THE NIGHT. THE NEXT MORNING IT WAS... Read more
SUSPENSION
Mar 29, 2019
Incident date: Mar 26, 2019
TAKATA I WAS DRIVING PERFECTLY FINE AND I CAME UPON A TURNING TO MAKE THE LEFT AND OUT OF NO WHERE MY CAR START SLIDING OUT OF CONTROL I TRIED TO CONTROL IT BECAUSE THERE WAS A DITCH CLOSE BY WHERE I WAS IT WAS SLIDING TO THE RIGHT TRIED TO SPIN THE STEERING TO THE LEFT BUT THE CAR WAS JUST DOING WH... Read more
Crash
WHEELS
Mar 29, 2019
Incident date: Mar 26, 2019
TAKATA I WAS DRIVING PERFECTLY FINE AND I CAME UPON A TURNING TO MAKE THE LEFT AND OUT OF NO WHERE MY CAR START SLIDING OUT OF CONTROL I TRIED TO CONTROL IT BECAUSE THERE WAS A DITCH CLOSE BY WHERE I WAS IT WAS SLIDING TO THE RIGHT TRIED TO SPIN THE STEERING TO THE LEFT BUT THE CAR WAS JUST DOING WH... Read more
Crash
STEERING
Mar 29, 2019
Incident date: Mar 26, 2019
TAKATA I WAS DRIVING PERFECTLY FINE AND I CAME UPON A TURNING TO MAKE THE LEFT AND OUT OF NO WHERE MY CAR START SLIDING OUT OF CONTROL I TRIED TO CONTROL IT BECAUSE THERE WAS A DITCH CLOSE BY WHERE I WAS IT WAS SLIDING TO THE RIGHT TRIED TO SPIN THE STEERING TO THE LEFT BUT THE CAR WAS JUST DOING WH... Read more
Crash
AIR BAGS
Mar 10, 2019
Incident date: Mar 10, 2019
HIT A VERY MASSIVE POTHOLE AND IT CAUSED THE AIRBAG FAULTY STATEMENT TO APPEAR ON THE DASHBOARD. IT APPEARS THE AIRBAG ATTEMPTED TO DISCHARGE UPON HITTING A POTHOLE AND DID NOT DISCHARGE AND THUS THE AIRBAG MECHANISM WAS CONSIDERED FAULTY. A POTHOLE/RUMBLE STRIP SHOULD NOT CAUSE A AIRBAG FAUL... Read more
EXTERIOR LIGHTING
Nov 7, 2018
Incident date: Feb 19, 2017
THE HEADLIGHT ASSEMBLIES ON THIS VEHICLE FAIL DUE TO THE INTERNAL WIRING INSIDE OF THE HOUSING. THIS LEADS TO ZERO VISIBILITY DURING NIGHT TIME. THE HEADLIGHTS WHEN OPERATING CORRECTLY ALSO DO NOT PRODUCE ENOUGH LIGHT OUTPUT TO BE ABLE TO SEE DURING THE NIGHT EVEN WITH A BRAND NEW ASSEMBLY.
ENGINE
Jul 28, 2018
Incident date: Jul 23, 2018
THE TOUAREG MADE SOME RATTLING NOISE WHILE I WAS DRIVING AT 35 MPH. AS SOON I STOPPED AND MADE IT MY DESTINATION AND TURNED OFF THE CAR THE CAR WOULDN'T START UP. I TOOK IT TO THE DEALERSHIP AND THE DEALERSHIP COULDN'T FIGURE OUT WHY THE CAR WOULDN'T START. FINALLY, AFTER A WELL OVER A WEEK, THEY DE... Read more
FUEL/PROPULSION SYSTEM
Jul 28, 2018
Incident date: Jul 23, 2018
THE TOUAREG MADE SOME RATTLING NOISE WHILE I WAS DRIVING AT 35 MPH. AS SOON I STOPPED AND MADE IT MY DESTINATION AND TURNED OFF THE CAR THE CAR WOULDN'T START UP. I TOOK IT TO THE DEALERSHIP AND THE DEALERSHIP COULDN'T FIGURE OUT WHY THE CAR WOULDN'T START. FINALLY, AFTER A WELL OVER A WEEK, THEY DE... Read more
UNKNOWN OR OTHER
Jul 28, 2018
Incident date: Jul 23, 2018
THE TOUAREG MADE SOME RATTLING NOISE WHILE I WAS DRIVING AT 35 MPH. AS SOON I STOPPED AND MADE IT MY DESTINATION AND TURNED OFF THE CAR THE CAR WOULDN'T START UP. I TOOK IT TO THE DEALERSHIP AND THE DEALERSHIP COULDN'T FIGURE OUT WHY THE CAR WOULDN'T START. FINALLY, AFTER A WELL OVER A WEEK, THEY DE... Read more
POWER TRAIN
Jul 4, 2018
Incident date: Jul 6, 2016
( STARTED NOTICING THIS PROBLEM ABOUT 1 TO 2 YEARS AGO)WHILE THE AUTOMATIC TRANSMISSION IS IN 5TH GEAR AND SPEEDS OF UNDER 50 MI./HR, WHEN STEPPING ON THE ACCELERATOR, THE AUTOMATIC DOWN SHIFT OCCURS WITH A VERY HARSH "KICK" TO A POINT THAT THE PASSENGERS FEEL THE JOLT. A FEW YEARS AGO, A SIMILAR P... Read more
WHEELS
Jul 4, 2018
Incident date: Dec 29, 2003
FROM THE DATE OF PURCHASE( IN DECEMBER OF 2003), TPMS HAS BEEN "ON" IN YELLOW/ORANGE COLOR INDICATING THAT THE TIRE PRESSURE IN ALL/VARIOUS LOCATIONS NEED ADJUSTMENT. AFTER INSPECTION BY MYSELF, GAS STATION ATTENDANTS, TIRE SHOP COMPANIES, AND VW DEALERSHIPS, I FINALLY GAVE UP. IN THE BEGINNING, THE... Read more
FUEL/PROPULSION SYSTEM
Jun 3, 2018
Incident date: Apr 25, 2018
I RECEIVED A LETTER FROM VOLKSWAGEN OF AMERICA, IN MARCH OF 2018, STATING THAT THERE IS A SAFETY RECALL 20AI-FUEL PUMP FLANGE FOR MY MAKE AND MODEL OF VEHICLE. I HAD ALREADY HAD THAT REPAIR DONE, DUE TO A SEVERE LEAK IN MY FUEL PUMP (GAS WAS POURING OUT OF THE BOTTOM OF THE VEHICLE AS AS FAST AS ... Read more
EXTERIOR LIGHTING
May 9, 2018
Incident date: May 9, 2018
THE HEADLIGHTS CONTINUOUSLY SHORT OUT AND STOP WORKING. THE WIRES ON THE HEADLIGHTS HAVE NO INSULATION BECAUSE IT HAS FALLEN OFF. THIS PROBLEM HAS BEEN FIXED MULTIPLE TIMES AND STILL CONTINUES TO HAPPEN. I CONTACTED THE LOCAL VW DEALERSHIP AND WAS NOT HELPED. I CONTACTED VW CORPORATE OFFICE AND NO H... Read more
FUEL/PROPULSION SYSTEM
May 1, 2018
Incident date: May 24, 2010
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. WHILE DRIVING APPROXIMATELY 40 MPH, AN ODOR OF FUMES WAS DETECTED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO COACHELLA VALLEY VOLKSWAGEN (79050 VARNER RD, INDIO, CA 92203, 760-200-4000) WHERE THE TECHNICIAN FOUND A FUEL LEAK AND REPLACED THE FILTER FLAN... Read more
FUEL/PROPULSION SYSTEM
Feb 12, 2018
Incident date: Nov 14, 2017
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. WHILE DRIVING VARIOUS SPEEDS, A STRONG FUEL ODOR EMITTED THROUGH THE VENTS OF THE VEHICLE. THE CONTACT ALSO STATED THAT THE FUEL GAUGE FAILED TO PROVIDE THE ACCURATE READING. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V583000 (FUEL ... Read more
FUEL/PROPULSION SYSTEM
Jan 27, 2018
Incident date: Jan 27, 2018
THERE WAS A RECALL ISSUED ON MY VEHICLE BACK ON SEPTEMBER 20TH 2017, I CALLED THE DEALERSHIP ON OCTOBER 23RD 2017 TO FIND OUT A RESOLUTION TO THIS PROBLEM, THEY ADVISED THERE WAS NOT A REMEDY YET BUT WOULD CONTACT ME WHEN THERE WAS. IT HAS NOT BEEN ALMOST 6 MONTHS SINCE THE RECALL WAS ISSUED WITH NO... Read more
FUEL/PROPULSION SYSTEM
Jan 23, 2018
Incident date: Mar 15, 2017
SMELT FUEL COMING FROM REAR BENCH SEAT - - OPENED COVERS TO SEE CRACKS IN BOTH FUEL FILTER CARTRIDGES. HAD THE FUEL FILTERS AND CARTRIDGES ON BOTH SIDES REPLACED AND CHECKED BY VW DEALERSHIP IN FAIRFIELD, CA.
FUEL/PROPULSION SYSTEM
Jan 10, 2018
Incident date: Jun 6, 2017
ONE MORNING IN JUNE 2017 MY HUSBAND STOPPED FOR GAS. AFTER GETTING GAS HE STARTED TO TURN OUT OF THE GAS STATION WHEN OUR CAR (2004 VOLKSWAGEN TOUAREG) STOPPED MOVING AND SHUT DOWN. MY HUSBAND TRIED SEVERAL TIMES TO START AND MOVE THE CAR, BUT TO NO AVAIL.THE CAR HAD TO BE TOWED (AT OUR EXPENSE) TO ... Read more
ENGINE
Dec 26, 2017
Incident date: Apr 1, 2017
DRIVE IT SHORT DISTANCE AND IT WON'T START AGAIN FOR HOURS! HAVE TAKEN IT TO VW TO PUT ON BRAKES AND ASKED THEM TO CHECK IT OUT, FOUND NOTHING! THEY HAVE KNOWN ABOUT THIS RECALL SINCE APRIL 2017 SHOWS AIR BAG LIGHT ON ALL THE TIME !
AIR BAGS
Dec 26, 2017
Incident date: Apr 1, 2017
DRIVE IT SHORT DISTANCE AND IT WON'T START AGAIN FOR HOURS! HAVE TAKEN IT TO VW TO PUT ON BRAKES AND ASKED THEM TO CHECK IT OUT, FOUND NOTHING! THEY HAVE KNOWN ABOUT THIS RECALL SINCE APRIL 2017 SHOWS AIR BAG LIGHT ON ALL THE TIME !
FUEL/PROPULSION SYSTEM
Dec 26, 2017
Incident date: Apr 1, 2017
DRIVE IT SHORT DISTANCE AND IT WON'T START AGAIN FOR HOURS! HAVE TAKEN IT TO VW TO PUT ON BRAKES AND ASKED THEM TO CHECK IT OUT, FOUND NOTHING! THEY HAVE KNOWN ABOUT THIS RECALL SINCE APRIL 2017 SHOWS AIR BAG LIGHT ON ALL THE TIME !
FUEL/PROPULSION SYSTEM
Dec 12, 2017
Incident date: Dec 9, 2017
THIS IS A COMPLAINT REGARDING THE WAY THAT VOLKSWAGEN IS HANDLING THE SAFETY RECALL 20Z4 (FUEL PUMP FLANGE). MY CAR SMELLED LIKE GASOLINE AND I HAD RECEIVED THE SAFETY RECALL LETTER IN THE MAIL, SO TOOK MY CAR INTO VOLKSWAGEN IMMEDIATELY AS DIRECTED. THEY TOLD ME THAT THEY DO NOT YET HAVE THE REPL... Read more
ELECTRICAL SYSTEM
Dec 12, 2017
Incident date: Sep 13, 2017
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WHEN ATTEMPTING TO DRIVE. WHEN THE VEHICLE WAS STARTED, AN ELECTRICAL NOISE WAS HEARD FROM THE DASHBOARD. IN ADDITION, THE ELECTRICAL SYSTEM FAILED AFTER THREE DAYS. THE VEHICLE WAS TAKEN TO DAVID MAU... Read more
FUEL SYSTEM, GASOLINE
Dec 8, 2017
Incident date: Apr 26, 2017
2004 VOLKSWAGEN TOUAREG. CONSUMER WRITES IN REGARDS TO FUEL FILTER FLANGE SAFETY RECALL. *LD THE CONSUMER REQUESTED TO BE REIMBURED FOR THE REPAIRS COVERED IN THE RECALL. UPDATED 12/8/2017*JS
FUEL/PROPULSION SYSTEM
Dec 4, 2017
Incident date: Nov 15, 2017
I RECEIVED A SAFETY RECALL 20AI REGARDING MY VOLKSWAGEN TOUAREG, IT IS A SERIOUS SAFETY RECALL AS IT INVOLVES THE FUEL POSSIBLE LEAKAGE; HOWEVER, THE RECALL REPAIR IS NOT YET AVAILABLE, AND I AM SUPPOSED WATCH OUT FOR FUEL LEAK/SMELL !!! I AM NOW NOT ENJOYING DRIVING MY CAR AND FEELING IT IS SAFE AN... Read more
FUEL SYSTEM, GASOLINE
Nov 28, 2017
Incident date: Oct 30, 2017
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR COMING FROM THE REAR DRIVER SIDE OF THE VEHICLE. THE CONTACT CALLED A LOCAL DEALER (PLATINUM VOLKSWAGEN, 45 NELSON AVE, HICKSVILLE, NY 11801) AND WAS INFORMED THAT THE PARTS WERE ON BACKORDER. THE... Read more
FUEL/PROPULSION SYSTEM
Nov 21, 2017
Incident date: Sep 1, 2017
I SMELL GAS INSIDE THE CAR AND YESTERDAY I GOT MAIL FROM VOLKSWAGEN ABOUT A RECALL BECAUSE OF A CRACKED FUEL PUMP FLANGE.
UNKNOWN OR OTHER
Oct 24, 2017
Incident date: Oct 23, 2017
I WOULD LIKE TO KNOW IF MY CAR IS PART OF THE RECALL CARS
FUEL/PROPULSION SYSTEM
Oct 24, 2017
Incident date: Oct 21, 2017
TAKATA RECALL VEHICLE STARTS LEAKING A LOT OF GAS WHEN I GAS ATTEMPTED TO DRIVE BACK HOME AFTER WORK I HAD TO CALL A TOWN TRUCK BECAUSE I WAS SCARED IT COULD IT EXPLODE WHILE DRIVING VW SHOULD PUT MORE ATTENTION THIS MISTAKES COULD END UP IN FATALITY. FOR EXAMPLE I USE TO SIT MY ... Read more
FUEL/PROPULSION SYSTEM
Oct 10, 2017
Incident date: Jun 7, 2017
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. WHEN THE VEHICLE WAS FUELED UP, A STRONG ODOR OF FUEL EMITTED INTO THE VENTS. THE CONTACT NOTICED A PUDDLE OF FUEL UNDERNEATH THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC TO DETERMINE THE CAUSE OF THE FAILURE. THE VIN... Read more
FUEL/PROPULSION SYSTEM
Oct 6, 2017
Incident date: Sep 14, 2017
SOME WEEKS AGO, THE TV NEWS REPORTED A RECALL FOR MY VEHICLE. I HAVE HAD NO OTHER NOTIFICATION. I HAVE LIVED HERE FOR 51 YEARS AND HAVEN'T CHANGED MY PHONE NUMBER. WHAT IS MOST DISTURBING IS THAT YOUR WEBSITE KNOWS NOTHING ABOUT THIS!!! BESIDES CASHING YOUR PAYCHECK, WHAT ELSE DO YOU DO TO JUSTIFY... Read more
Showing 50 of 373 complaints.
EPA Fuel Economy — 2004 VOLKSWAGEN TOUAREG
| Trim / Engine | City MPG | Highway MPG | Combined MPG | Fuel Type | Annual Fuel Cost |
|---|---|---|---|---|---|
| 3.2L 6-cyl, Automatic (S6) (4-Wheel or All-Wheel Drive) | 13.0 | 19.0 | 15.0 | Premium | $5,450 |
| 4.2L 8-cyl, Automatic (S6) (4-Wheel or All-Wheel Drive) | 12.0 | 17.0 | 14.0 | Premium | $5,850 |
| 5.0L 10-cyl, Automatic (S6) (4-Wheel or All-Wheel Drive) | 15.0 | 22.0 | 18.0 | Diesel | $4,700 |
CO2 Emissions: -1.0 g/mile (Sport Utility Vehicle - 4WD)
Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.
Technical Service Bulletins — 2004 VOLKSWAGEN TOUAREG
360 manufacturer communications from 201 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 36 |
| 110000 ELECTRICAL SYSTEM | 36 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 33 |
| 060000 ENGINE (PWS) | 17 |
| 118000 ELECTRICAL SYSTEM:SOFTWARE | 16 |
| 060000 ENGINE AND ENGINE COOLING | 15 |
| 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER | 14 |
| 980000 UNKNOWN OR OTHER | 12 |
V171901201285565
Aug 21, 2023
060000 ENGINE AND ENGINE COOLING
Update to Volkswagen engine oil standards
V171901201285562
May 30, 2023
061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION
Volkswagen Engine oil quality standards, update to attachments.
V171901201285560
Apr 24, 2023
061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION
Engine oil quality standards, update to attachments.
V941901201152119
Dec 12, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Update model year applicability to include 2023.
V271901201189422
Dec 6, 2022
110000 ELECTRICAL SYSTEM
Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger. Updated to include additional model year applicability.
A002155201173212
Dec 15, 2021
118000 ELECTRICAL SYSTEM:SOFTWARE
This bulletin contains general instructions for software updates.
QT Trailer
Mar 15, 2021
210000 TRAILER HITCHES
Information on the location of trailer brake controller connector and adapter harness creation.
V871806201994714
May 12, 2020
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
Tool number added to table. Removal of Behr Flush Kit. VAS 6337/1A
V941901201152115
Apr 21, 2020
353000 EQUIPMENT:ELECTRICAL
Updated to include additional models and model year applicability.
VOS-20-11
Mar 26, 2020
980000 UNKNOWN OR OTHER
This document outlines updates to the ODIS diagnostic software. Updates include corrected diagnostic test plans for the stated vehicles.
V011812_2014603
Dec 5, 2019
350000 EQUIPMENT
Update model applicability to MY 2020.
V011812_2014603
Dec 5, 2019
110000 ELECTRICAL SYSTEM
Update model applicability to MY 2020.
V171901_2012855
Nov 25, 2019
060000 ENGINE AND ENGINE COOLING
Update to Volkswagen engine oil standards.
V871806_2019947
Nov 7, 2019
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
Include new special tool adapter and 2018 model year Jetta only
V871811_2043893
Nov 4, 2019
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
Update to mode; and model year applicability.
V171901_2012855
Oct 29, 2019
060000 ENGINE (PWS)
Update to Volkswagen engine oil standards.
V171901_2012855
Oct 29, 2019
350000 EQUIPMENT
Update to Volkswagen engine oil standards.
SM 80-2019
Oct 1, 2019
980000 UNKNOWN OR OTHER
Parts are currently blocked from sale at this time.
V171901_2012855
Sep 24, 2019
060000 ENGINE (PWS)
Update to Volkswagen engine oil standards.
V001901_2040590
Sep 10, 2019
350000 EQUIPMENT
Include additional photo's of water ingress. Also includes 2018-2020 Tiguan LWB
VOS-19-24
Sep 4, 2019
118000 ELECTRICAL SYSTEM:SOFTWARE
This document outlines updates to the ODIS diagnostic software. Updates include corrected diagnostic test plans for the stated vehicles.
VOS-19-24
Sep 4, 2019
350000 EQUIPMENT
This document outlines updates to the ODIS diagnostic software. Updates include corrected diagnostic test plans for the stated vehicles.
TT 001202
Aug 23, 2019
350000 EQUIPMENT
TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB
QRUG08212019
Aug 21, 2019
350000 EQUIPMENT
Quick Reference Update Guide.
V171901_2012855
Aug 19, 2019
060000 ENGINE (PWS)
Update to Volkswagen engine oil standards. Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB
V011812_2014603
Jul 29, 2019
110000 ELECTRICAL SYSTEM
Update vehicle metadata to include pull ahead models. Also includes R32 2002-2007 and 2002-2006 Jetta Wagon.
Quicktip 1.2_TB
Jul 26, 2019
114005 ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
Trailer braking information.
V171901_2012855
Jul 16, 2019
060000 ENGINE (PWS)
Engine oil quality standards. Also includes all models for 1997-2003. Also Rabbit from 2006-2009.
171901_2012855
Jun 13, 2019
353000 EQUIPMENT:ELECTRICAL
Remote Key Battery Replacement
171901_2012855
Jun 13, 2019
350000 EQUIPMENT
Remote Key Battery Replacement
V871812-2005566
Jun 12, 2019
356000 EQUIPMENT ADAPTIVE/MOBILITY
Update vehicle metadata.
V871812-2005566
Jun 12, 2019
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
Update vehicle metadata.
SM 33-2019
Mar 27, 2019
350000 EQUIPMENT
The part number listed in the document is to be returned if it meets the criteria provided.
TT 91 19 01
Mar 22, 2019
350000 EQUIPMENT
Alternative method for radio code retrieval.
TT 91 19 01
Mar 22, 2019
110000 ELECTRICAL SYSTEM
Alternative method for radio code retrieval.
V171901-2012855
Mar 12, 2019
060000 ENGINE (PWS)
Engine Oils Which Meet Volkswagen Oil Quality Standards
Gasoline Engine
Feb 27, 2019
060000 ENGINE AND ENGINE COOLING
Gasoline Engine Misfire Diagnosis document
V271901-2011894
Feb 19, 2019
110000 ELECTRICAL SYSTEM
Battery Testing and Charging instruction. Updated to include model year 2019 applicability.
V941901-2011521
Feb 18, 2019
120000 EXTERIOR LIGHTING
Condensation and or water droplets visible on inside of exterior light lenses. TB updated to include model year 2019 applicability.
V871812-2005566
Nov 13, 2018
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
Update vehicle metadata.
A971861 2013504-
Jun 6, 2018
110000 ELECTRICAL SYSTEM
This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts.
TT001703
Nov 10, 2017
118000 ELECTRICAL SYSTEM:SOFTWARE
Tip for Scan tool concerns that may occur duing a test plan
TT 200901
Aug 18, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Update to existing tip for fuel quality checking.
V171701 2012855
Jul 5, 2017
060000 ENGINE AND ENGINE COOLING
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards
Quick Tip - Trai
Jun 29, 2017
114005 ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
Trailer braking information
Quick Tip - Trai
Jun 29, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Trailer towing information
Quick Tip - Trai
Jun 29, 2017
210000 TRAILER HITCHES
Trailer towing information
V1.0
Jun 29, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Trailer towing information
V1.0
Jun 29, 2017
350000 EQUIPMENT
Trailer towing information
V1.0
Jun 29, 2017
114005 ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
Trailer braking information
V1.0
Jun 29, 2017
350000 EQUIPMENT
Trailer towing information
V1.0
Jun 29, 2017
210000 TRAILER HITCHES
Trailer towing information
V1.0
Jun 29, 2017
114005 ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
Trailer braking information
SM 44-2017 EN
Jun 28, 2017
350000 EQUIPMENT
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward.
VHW-17-11
Jun 22, 2017
350000 EQUIPMENT
VAS 6154 Replacement Part Setup Guide
Quick Reference
Mar 13, 2017
118000 ELECTRICAL SYSTEM:SOFTWARE
Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated
1-2017 Update
Feb 1, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi requests.
V691601 2010479
Oct 31, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Update model year applicability to include 2017.
TT 00-16-02
Oct 28, 2016
350000 EQUIPMENT
Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used
V871622 2019947
Oct 24, 2016
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
Update to model year applicability.
V011615 2014815
Oct 20, 2016
060000 ENGINE (PWS)
Update to include additional model year applicability.
V871620 2005566
Oct 12, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Update model and model year applicability.
TT001601
Sep 23, 2016
350000 EQUIPMENT
Contacting the parts helpline
TT001601
Sep 23, 2016
160000 STRUCTURE
Contacting the parts helpline
TT 97-12-02
Sep 23, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Data Link connector pin assignment chart that is applicable to all models. Update model year applicability.
V581601-2039001
Jun 13, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
To update Claim processing statement.
Ref. - Reflash U
May 20, 2016
118000 ELECTRICAL SYSTEM:SOFTWARE
Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles.
TT 97-14-02
Apr 29, 2016
118000 ELECTRICAL SYSTEM:SOFTWARE
TECH TIP DENOTING POTENTIAL FOR DAMAGE OF THE DATA LINK CONNECTOR WHEN USING AFTER MARKET PLUG IN DEVICES OR SCAN TOOLS AND SUBSEQUENT DIAGNOSTIC DIRECTION.
TT 97-14-02
Apr 29, 2016
110000 ELECTRICAL SYSTEM
TECH TIP DENOTING POTENTIAL FOR DAMAGE OF THE DATA LINK CONNECTOR WHEN USING AFTER MARKET PLUG IN DEVICES OR SCAN TOOLS AND SUBSEQUENT DIAGNOSTIC DIRECTION.
V501604 2014370
Mar 28, 2016
162000 STRUCTURE:BODY
Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. The document also have infromation about where to fi
TT 97-14-02ss1
Mar 4, 2016
110000 ELECTRICAL SYSTEM
Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System)
Edition173
Feb 15, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Fuel Additive to Help Prevent Sporadic Misfire Faults
UpdateGuide
Feb 12, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Quick reference update guide.
Update 02122016
Feb 12, 2016
118000 ELECTRICAL SYSTEM:SOFTWARE
Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated
V011602 2014815
Feb 5, 2016
070000 FUEL SYSTEM, GASOLINE
Technical tips on what to do if improper gasoline has been added to the vehicle.
TB011602
Feb 5, 2016
061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
Gasoline quality.
Airbag
Jan 22, 2016
140000 AIR BAGS
Airbag Issues.
V921502 2026253
Jul 22, 2015
130000 VISIBILITY
Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the w
V581501 2039001
Jul 21, 2015
160000 STRUCTURE
Technical Bulletin (Corrosion, Rear Inner Doors in Door Fold Area): Corrosion in the fold of the rear door issue. This document contains information on how to diagnose, and service this issue. This document also gives examples on filling o
V581501 2039001
Jul 21, 2015
350000 EQUIPMENT
Technical Bulletin (Corrosion, Rear Inner Doors in Door Fold Area): Corrosion in the fold of the rear door issue. This document contains information on how to diagnose, and service this issue. This document also gives examples on filling o
V871506 2019947
Jul 7, 2015
060000 ENGINE AND ENGINE COOLING
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon
V871508 2005566
Jul 7, 2015
350000 EQUIPMENT
Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start
V871508 2005566
Jul 7, 2015
060000 ENGINE AND ENGINE COOLING
Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start
V871506 2019947
Jul 7, 2015
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon
TT 01-15-02
Jul 3, 2015
118000 ELECTRICAL SYSTEM:SOFTWARE
Tech Tips (Scan tool lock up/Scan stops at 33%): While performing a GFF scan (with the newer version of ODIS software), the scan tool can lock up at 33%. The document informs how to service this issue
Elsa 6-29-15
Jun 29, 2015
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
Elsa 6-22-15
Jun 22, 2015
350000 EQUIPMENT
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech
Elsa 6-22-15
Jun 22, 2015
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech
TT 64-14-02
May 8, 2015
133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engin
TT 64-14-02
May 8, 2015
132000 VISIBILITY:GLASS, SIDE/REAR
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engin
TT 64-14-02
May 8, 2015
110000 ELECTRICAL SYSTEM
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engin
Touareg Module S
May 6, 2015
110000 ELECTRICAL SYSTEM
VOLKSWAGEN DEALERSHIP COMMUNICATION: Based on dealer feedback of ODIS Service module scan lockups on early Touareg. VOLKSWAGEN created a method for a temporary workaround. The document is its procedure
V941501 2011521
Mar 27, 2015
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document
V941501 2011521
Mar 27, 2015
120000 EXTERIOR LIGHTING
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document
V271503 2016076
Mar 12, 2015
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw
V271501 2011894
Feb 16, 2015
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS Charger
V011503 2014815
Jan 20, 2015
070000 FUEL SYSTEM, GASOLINE
Discusses the issues associated with using contaiminated gasoline. There are recommendations to use top tier gasoline retailers
581402
Dec 16, 2014
162300 STRUCTURE:BODY:DOOR
Corrosion, Rear Inner Doors in Door Fold Area
2039001
Dec 16, 2014
162300 STRUCTURE:BODY:DOOR
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
Edition115
Dec 8, 2014
060000 ENGINE AND ENGINE COOLING
VW Elsa Newsletter
Showing 100 of 360 bulletins.
NHTSA Safety Investigations — VOLKSWAGEN TOUAREG
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE06022
Opened: Jun 19, 2006 — Closed: Oct 30, 2006
SRS WARNING LIGHT ILLUMINATION
MY 2004-05 (TO 11/2004) TOUAREG VEHICLES HAVE A POTENTIALLY FAULTY/LOOSE SIDE AIR BAG WIRING CONNECTOR THAT CAN CAUSE THE WIRING CIRCUIT RESISTANCE TO EXCEED THE DESIGN LIMIT AND ILLUMINATE THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG LIGHT.ON 02/2005, VW ISSUED A TECHNICAL SERVICE BULLETIN (TSB ... Read more
PE05042
Opened: Aug 11, 2005 — Closed: Dec 21, 2005
EXTERIOR DOOR HANDLE MALFUNCTION
VW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) DATED JUNE 10, 2005, DESCRIBING A CONDITION OF EXTERIOR DOOR HANDLE STICKS IN THE OPENED POSITION AFTER THE DOOR IS OPENED.VW DESCRIBED THE CAUSE OF THE PROBLEM TO BE A POTENTIAL FOR INCREASED FRICTION BETWEEN THE DOOR HANDLE AND THE LOCK CYLINDER HOUSING... Read more
VOLKSWAGEN TOUAREG — All Years Overview
Complete safety history for the VOLKSWAGEN TOUAREG across all model years (2004–2017).
30
Total Recalls
945
Total Complaints
2
Investigations
23
Reported Crashes
26
Reported Fires
0
Reported Deaths
VOLKSWAGEN TOUAREG — Year by Year
Compare recalls and complaints across model years. Click any year to see full details.