2018 MITSUBISHI OUTLANDER Recalls, Complaints & Safety

See attached document for complaint

1. On hot/warm days when I start my vehicle it will run then die and give me the code for Mass air sensor which I replaced but it keeps doing it; the check engine will stay on for a while then turn off until it does it again. 2. When driving and I go over a speed bump the suspension grinds or does a hard squeaking noise. 3. The USB in the center console stops working at times or when move the charging cord it disconnects for a few seconds. 4. Internal lights work when they want to, I thought the bulbs where burnt out and replaced them but they still come on when they want to not everytime a door is opened.

The contact owns a 2018 Mitsubishi Outlander. The contact stated that while driving approximately 35 MPH over a pothole, the driver's side and passenger side curtain airbags erroneously deployed. The contact stated that no collision had occurred prior to the air bags deployment. The manufacturer and local dealer were not yet notified of the failures. The vehicle was not yet diagnosed or repaired. The failure mileage was 215,000.

The contact owns a 2018 Mitsubishi Outlander. The contact had received notification of NHTSA Campaign Number: 25V507000 (Structure); however, the liftgate gas springs had failed and were replaced prior to the recall. The manufacturer was contacted for reimbursement, and the contact mailed the required documents as requested by the manufacturer. The contact later followed up with the manufacturer, who confirmed that the requested documents had been received and informed the contact that there was no time frame for the reimbursement process. The contact stated that the manufacturer had exceeded a reasonable amount of time to provide reimbursement. The failure mileage was 132,324.

The contact owns a 2018 Mitsubishi Outlander. The contact stated that while the front tires were being replaced, corrosion was found underneath the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that on a separate occasion, while driving over 60 MPH, there was an abnormal sound coming from the engine. In addition, the vehicle vibrated abnormally while driving over 60 MPH. No warning lights were illuminated. The contact stated that the shocks, struts, and lower control arm were replaced due to corrosion. The manufacturer was not made aware of the issue. The failure mileage was unknown.

The contact owns a 2018 Mitsubishi Outlander. The contact stated while driving at an undisclosed speed and turning into a parking area, there was an abnormal snapping sound coming from the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who determined that the exhaust had fractured in half due to excessive corrosion. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V507000 (Structure). The manufacturer was not notified of the failure. The failure mileage was 110,000.

The contact owns a 2018 Mitsubishi Outlander. The contact stated that after opening the liftgate, while reaching into the trunk, the liftgate fell and hit the contact on the head. The contact had not sustained an injury. There was no warning light illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact was informed that the VIN was not included in a recall related to the failure. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 25V507000 (STRUCTURE) as a possible cause for failure; however, the VIN was not included in the recall. The manufacturer was notified of the failure. The approximate failure mileage was 120,000.

The power electric drive seat becomes loose with time. Very dangerous while braking cause the drive seat moves forward fast, driver feels disoriented to extent feeling unstable and could lead to not appropriately having control over vehicle during brake events. This could lead to hitting front vehicle.

Camshaft phaser shattered and is missing a chunk of metal

The contact owns a 2018 Mitsubishi Outlander. The contact stated while attempting to park the vehicle, the contact became aware that the rearview camera was inoperable. The contact stated that the rearview camera failed to function properly, and the camera image appeared blank. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 103,000.

Car will drive on interstate then will be unable to accelerate on interstate warning, “Propulsion power reduced” light turns on and vehicle speed decreases and car does not accelerates and loses speed. I had to stop vehicle multiple times to reset the car per advice on the internet but car continues with drastic decrease in speed on the interstate and message “Propulsion Power Reduced.” Car is serviced as per car dealership recommendations but now car is not safe to drive on the interstate.

My car does not lock. Ive changed the battery in the key fob a few times i cant use my key fob or the actual key to unlock or lock my car. Also while im driving down the road my car lights flicker a lot. Along with all my inside lights. Ive confirmed with my mechanic thats its not the radiator causing the problem. Also my car doeant shift good and sometime jerks when i come to a complete stop and then go.

SRS-Air Bag codes B1476, B1558, B1631 repeated triggering since 2020. History: - 9/30/20 - Dealer read code B1631 (DR Knee ABG Squib Short) & U0154 (OCM CAN Timeout), did not diagnose cause, erased codes - 4/12/21 ~0920 - check airbag light illuminated - 7/30/21 ~0800 & ~0920 - check airbag light illuminated -- called dealer; was informed since light extinguished I would be liable for diagnostic cost if not covered under warranty - 9/30/21 ~0700 twice - check airbag light illuminated - 11/16/21 ~0720 - check airbag light illuminated - 1/5/22 ~0630 - check airbag light illuminated - 1/14/22 ~1319 twice - check airbag light illuminated - 1/18/22 ~1550 & ~1700 - check airbag light illuminated - 1/19/22 ~1052 & ~1059 - check airbag light illuminated - 1/20/22 ~1304 - check airbag light illuminated - 1/25/22 ~1534 - check airbag light illuminated - 2/11/22 ~1000 - check airbag light illuminated - 3/19/22 ~1800 x 2, ~2245 - check airbag light illuminated - 5/16/23 ~1600 - check airbag light illuminated - 6/18/23 ~1426 - check airbag light illuminated - 6/22/23 ~0928 & ~0955 - check airbag light illuminated - 10/22/23 ~1040 - check airbag light illuminated - 6/16/24 - used personal car scan tool and found B1476 (IG1[A] voltage extraordinary low), B1558 (OCSS control unit), B1631 (DR knee ABG squib short) faults *** Original action by dealer in 2020 to simply delete latched codes did not remedy airbag problem...safety complaints at NHTSA indicate airbag failure during collision...this appears to be a serious public safety problem. ***

This is the second time the bushings on the rear motor (i believe they said inverter motor) have needed to be replaced. Currently the motor is being held by two of the three bushing. I was told by Mitsubishi that this is a common issue. If it's a common issue and if all three bushings failed, the rear motor would be displaced and could cause driver to have accident while driving the vehicle. My brakes are better made then these bushings, I have only had to replace my brakes once.

The contact owns a 2018 Mitsubishi Outlander. The contact stated while driving approximately 35 MPH, the air bag warning light began to flash off and on. The failure was a constant failure. The contact had not taken the vehicle to a dealer or independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was 98,330.

2018 Mitishichi Headlights, left, then right stop working. Dealer replaced first one within 6 months. So far I have replaced one or the other 4 or 5 Times. I did complain to NHTSA . These lights have been out more than they have worked. Google indicates a large number of these issues but no recall from NHTSA.

Air bag light comes on when drivers seat put back. When seat moved forward air bag light goes off. When air bag light is on system will not work, not safe to drive. Dealership on first repair did wire repair. They claimed when seat was put back it stretched harness turning on air bag light. Did repair under warranty. Second time they replaced harness due to same problem per Service Advisor. Second repair was not warranty due to being over on mileage. Vehicle is a 2018 with 31754 miles.

The sunroof on our vehicle, self exploded while driving. There was a loud bang, and then we were covered in sunroof glass shards. The fine dust of the sunroof glass went into my right eye which created minor eye irritation. I was able to pull over. Flush out my eye with water and then proceeded to remove the pieces of glass from the sunroof area because I was afraid the pieces would blow off and hit any vehicle that was behind us for the remainder of our drive home. It scared the hell out of us. I am thankful that my daughter was not driving due to seeing her panic reaction from this experience. There were no drivers in front of us. We were not driving under any trees. It was a clear open rural road. Went to our local dealer. They inspected the sunroof & stated they have never seen anything like this happen. Since I was out of the warranty due to mileage(9,000 over)they suggest I go through my insurance company to resolve this matter. My view on this is it wasn’t so much a warranty issue, but a huge safety issue. Never would I imagine a Sunroof self exploding while driving and not causing me to have an accident because of my reaction to it. So with this in mind, I directly called Mitsubishi motors of North America. I had them open up a case number on this issue. The final response back from the manufacture was that I needed to go through my insurance company to deal with having my sunroof replaced. During filing my case to the manufacture directly, they asked me what I would like to have Mitsubishi motors of North America do. I stated to have my sunroof replaced with the right tempered glass. That this was a scary situation and one of great safety concern that no sunroof with all the manufacture testing should ever have this happen. I was very disappointed that they were not willing to take the responsibility of replacing the sunroof properly with the right tempered glass. My insurance company view the photo of the sun roof damage and a claim is in the process.

1 injured

Our car seat is nearly brand new (first used at the end of Sept 2023 upon birth of our daughter) upon placing the car seat in the base, we noticed it wasn’t making the clicking sound indicating a secure lock to base. Upon further investigation it appears the pieces that lock the car seat in place are jammed and not operating properly. If we had gotten in a car accident the car seat would not have been properly secured.

I have a safety recall on my vehicle. Mitsubishi says I will have to dry from oklahoma to Arkansas because they no longer have places in Oklahoma that will fix a recall. But there are many dealerships that are selling Mitsubishis. Those dealerships also tell me I would have to take it to Arkansas. This is a huge problem, I bought this car brand new and unable to get recalls fixed on it unless I drive to another state. This is awful. I’m a nurse and work a lot I don’t have time to dry to Arkansas and have my car worked on. Not only that time, gas and mileage. That’s not fair at all to me. They should have to have a center of some sort in Oklahoma to fix these recalls if they are going to be selling new Mitsubishis here in Oklahoma.

The contact owns a 2018 Mitsubishi Outlander. The contact stated while driving 15 MPH and making a turn, the message "ABS Service Required" was displayed. The contact veered to the side of the road. The contact stated that she turned off and restarted the vehicle, and the warning message was turned off. However, the contact stated that the failure reoccurred several times while driving. The vehicle was taken to an independent mechanic, who informed the contact that the failure was related to Mitsubishi Technical Service Bulletin Numbers: SR-18-008 and SR-18-007. The vehicle was not diagnosed nor repaired. The dealer was notified of the failure and advised the contact to take the vehicle in for diagnostic tests whenever the messages were displayed; however, the contact stated that the failure occurred intermittently, and the dealer required scheduling a service appointment in advance. The manufacturer was notified of the failure, and the contact was awaiting a call back. The vehicle was not diagnosed nor repaired. The failure mileage was approximately 84,000.

The contact owns a 2018 Mitsubishi Outlander. The contact stated that while driving at an undisclosed speed, the passenger’s side headlight failed to operate. No warning lights were illuminated. The vehicle was taken to the dealer where the headlight was replaced; however, the failure recurred. The contact then stated that while driving at an undisclosed speed, the front driver’s side headlight failed to operate as needed. The vehicle was taken back to the dealer where it was diagnosed that the headlight needed to be replaced. The vehicle was repaired; however, the failure recurred. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 32,000.

Throttle/Pedal position sensor switch voltage correlation circuit high input… it has been replaced once at beginning of January and within a week the same issue occurred. The part came from the dealership and pep boys replaced it.

The rear liftgate on this vehicle does not stop if there is an obstruction, i.e., a hand, a head or other body part. Not only does it not stop in case of obstruction, there is no audible sound made to indicate the door is in motion. I was hit in the head hard this morning - hard enough to cause stars and get a nice golf-ball sized bump on my skull. This is dangerous and should be remedied. THIS IS NOT THE FIRST TIME THIS HAS HAPPENED. In the parking lot where this occurred, a man saw the entire episode unfold, yelled out to try and stop it from happening, but I didn't realize he was yelling for me. After the incident he advised me the same thing has happened to him.

I was in a head on collision on 12/13/2022, and the air bag failed to deploy. The failure of the air bag deployment cause my chest to slam into the steering wheel along with my knees on the steering column. I went to the hospital for observation and any unknown injuries. My chest hurts and knees along with consistent visions of my life flashing in my mind due to the trauma of this incident. The police, nurses, family, and friends said that I’m lucky to not have serious injuries from the failure of the air bag deployment. I have pictures, police report, and other supporting documents. My 2018 Outlander air bag deployment failure is a serious issue, and it needs to be looked into due to safety, lives, and failure from the air bag. Police report number is on drivers involved. All other vehicles involved air bags deployed, but my Outlander’s air bag failed to deploy. Dangerous to myself or other air bag failures. The manufacturer of the vehicle need’s notified with a full investigation into this matter.

Crash 1 injured

The contact owns a 2018 Mitsubishi Outlander. The contact stated that the vehicle failed to start up right away. After waiting for a while, the vehicle started as needed. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The contact stated that several warning lights were flickering while starting the vehicle. The contact called and notified the local dealer; however, the vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 17V609000 (Electrical System) however, the VIN was not included. The manufacturer was not contacted. The approximate failure mileage was 65,000.

I believe they said it was the cam broke a part .I was driving on a 4 lane highway going 70 my car made a horrible noise and then my car it just shut down I was in the middle lane and thank God I was not hurt or hit by the semis going around me .then tried to order this part and cannot get it it's on backorder and they have no idea when it would be available and so they checked the motor and I now have to replace the motor because of this breaking this was definitely a safety issue with my car just shutting down while driving it.

I was driving when a woman pulled out In front of me. I was going 49 mph and have the EDR report to prove so. (I was wearing my seatbelt). The front of my car smashed into the rear end of her car and I smashed the right side of my head into the steering wheel. I’ve sustained a traumatic brain injury, long term post concussion syndrome along with a page long list of injuries that I’m still dealing with. It’s been a little over a year and my injuries are just getting worse. Mitsubishi sent a guy out to read my Event Data Recorder with promises of giving me a copy of the report. After 6-7 months of them refusing me the report and telling me the air bags should not have went off i hires a lawyer to subpoena a copy of the report. It says the safety features failed. But here I am left with a car that’s totaled and injuries I will never recover from. I also did research and found out that my car was made in the same plant on the same line as the other 68,000 recalled 2018 outlanders. I can’t understand why mine wasn’t part of the recall?!?! It was made in between the dates as the other 68,000 that was recalled.

1 injured

The contact owns a 2018 Mitsubishi Outlander. The contact stated that the check engine warning light was illuminated. The contact took the vehicle to the dealer who stated that there was a code for leak in the fuel tank however, the mechanic was unable to determine the location of the failure. The vehicle was not repaired. The failure recurred four times. The manufacturer was not made aware of the failure. The approximate failure mileage was 40,000.

The contact owns a 2018 Mitsubishi Outlander. The contact stated that the lower engine heat shield had cracked at the bolt inserts causing the shield to become unsecure. The cause of the failure was not yet determined. The vehicle was taken to the local dealer who diagnosed that the heat shield needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 28,000.

CRUSE CONTROL SHUTS OFF SAYING ACC NOT AVAILABLE DURING ROAD TRIPS. THIS IS ON HIGHWAYS. IT HAPPENED 5 TIMES DURING ROAD TRIP FROM MILWAUKEE, WISCONSIN TO WAUSAU WISCONSIN WHILE IN MOTION.. THIS HAPPENS EVERY TIME I USE THE CRUSE CONTROL. IT HAPPENED ON THE WAY TO WAUSAU AND ON THE WAY HOME ROUND TRIP APX 600 MILES THIS TRIP

VEHICLE HAS HAD EV SYSTEM SERVICE REQUIRED, BSW SERVICE REQUIRED, AND ASC SERVICE REQUIRED WARNING LIGHTS COME ON EVERY FEW DAYS SINCE SEPTEMBER. WHEN THESE COME ON MULTIPLE SAFETY FEATURES OF THE VEHICLE ARE IMMEDIATELY DISABLED. THE DEALER HAS BEEN UNABLE TO FIX THE ISSUE AFTER FIVE VISITS INCLUDING ONE WHERE THEY HAD THE VEHICLE FOR 65 DAYS. PER THE MANU: EV SYSTEM SERVICE REQUIRED: "ONE OR MORE FAILURE IS OCCURRING IN THE PLUG-IN HYBRID EV SYSTEM. HAVE YOUR VEHICLE INSPECTED BY A CERTIFIED MITSUBISHI EV DEALER" ASC SYSTEM SERVICE REQUIRED "THERE IS A FAULT IN THE ACTIVE STABILITY CONTROL. CONTACT A CERTIFIED MITSUBISHI EV DEALER TO HAVE THE SYSTEM CHECKED" BSW SERVICE REQUIRED "THE BLIND SPOT WARNING (BSW) DOES NOT OPERATE NORMALLY BECAUSE THERE THERE ARE SOME MALFUNCTIONS IN THE SENSOR OR THE SYSTEM. IMMEDIATELY HAVE YOUR VEHICLE INSPECTED AT A CERTIFIED MITSUBISHI EV DEALER" WHEN THE WARNING DISPLAY APPEARS THE BSW WILL BE DEACTIVATED.

I'M HAVING TROUBLE WITH MY 4WD LIGHT IS STUCK BLINKING SINCE THE PAST WINTER WEATHER ALSO IT WILL NOT RESET ITSELF FROM SHOWING THE WHEEL IMAGE ON MY ODOMETER SCREEN. PLEASE HELP ME UNDERSTAND WHAT'S GOING ON.

WHILE DRIVING IN A PARKING LOT AND SLOWED DOWN BECAUSE OF A BUMP THE CAR IMMEDIATELY DIED AS SOON AS I PASSED THE BUMP WITH NO ENGINE LIGHT ERRORS. THE BATTERY WAS CAR JUMP AND NOTHING HAPPENED. THE BATTERY WAS TESTED WITH VOLTAGE METER AND SAME ISSUE. WHEN YOU TURN ON THE CAR NOTHING HAPPENS, NO SOUND, NO CRANKS, NO ENGINE LIGHT. I HAD THE CAR TOWED AT HOME. THIS IS A SAFETY ISSUE AND VERY CONCERNING. THE CAR IS 2018 OUTLANDER ES AND HAVE 34K MILES.

THE SUNROOF GLASS EXPLODED OUT OF OUR CAR WHILE WE WERE DRIVING ON THE FREEWAY IN IDAHO. THE SUNROOF WAS CLOSED BECAUSE IT HAD BEEN RAINING AND IT WAS COLD. MITSUBISHI HAD A SIMILAR PROBLEM WITH SUNROOF GLASS DETACHING IN OUTLANDERS FROM 2007-2010. WHEN WE CONTACTED MITSUBISHI THEY INFORMED US THAT THE GLASS FLYING OUT OF OUR SUNROOF WAS NOT A SAFETY PROBLEM OR A MANUFACTURER'S DEFECT EVEN THOUGH IT WAS RULED AS SUCH IN PREVIOUS YEARS.

WITHIN 10,000 MILES OF OWNING MY NEW CAR I NOTICED IT WOULD RANDOMLY STALL SOMETIMES AT THE STOP LIGHT OF AN INTERSECTION. IT DOESN'T TAKE LONG TO START BACK UP. OTHER TIMES MY CAR STRUGGLES TO START ALL TOGETHER. I'LL TURN THE KEY 2-3 TIMES BEFORE IT STARTS. SEVERAL MONTHS WENT BY WHERE THE ISSUE WAS NO LONGER PRESENT BUT OVER THE PAST MONTH IT STARTED AGAIN. LIKELY RELATED TO THE WHETHER NOW THAT WINTER IS NEAR. FINALLY MY EBRAKE HAS NEVER WORKED SINCE I BOUGHT THE CAR IN EARLY 2019 WITH 21K MILES.