1993 MERCURY VILLAGER Recalls, Complaints & Safety

OWNER NOTICE ENGINE BEGINNING TO DRAG ON THE GROUND, CAR WAS STILL CAPABLE OF OPERATING. TRANSVERSE STRUCTURAL MEMBER BENEATH THE RADIATOR WHICH SUPPORTS THE FRONT END OF THE ENGINE SUPPORT BEAM FAILED AND ALLOWED ENGINE TO TILT FORWARD. ATTACH BRACKET FOR SUPPORT BEAM TORE THROUGH THE STRUCTURAL MEMBER. SERIOUS POTENTIAL FOR SNAGGING THE FRONT END OF THE ENGINE SUPPORT BEAM ON A ROAD HAZARD AND FORCING THE FRONT END OF THE CAR UP IN THE AIR THUS ROLLING THE ENGINE AFT UNDER THE VEHICLE WITH LOSS OF CONTROL. TRANSVERSE BEAM WAS PARTIALLY CORRODED HOWEVER METAL THICKNESS AND STRENGTH OF THIS COMPONENT APPEARS TO BE INADEQUATE. PICTURES AVAILABLE. *TR

TL*THE CONTACT OWNS A 1993 MERCURY VILLAGER. THE CONTACT STATED THAT THE BRAKE LIGHTS HAVE FAILED FOR TWO YEARS AND SEVERAL UNSUCCESSFUL ATTEMPTS HAVE BEEN MADE TO DIAGNOSE AND REPAIR THE VEHICLE. THE MECHANIC REPLACED THE BULBS, FUSE, AND BRAKE LIGHT SWITCH, HOWEVER, THE FAILURE REMAINS. ON SEPTEMBER 14, 2007, THE BRAKE LIGHTS WERE REPLACED, BUT FAILED AGAIN ON SEPTEMBER 17, 2007. THE DEALER STATED THAT THERE WERE NO RECALLS ON HER VEHICLE. THE CONTACT CAN PROVIDE INVOICES. THE FUEL SYSTEM WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000 AND CURRENT MILEAGE WAS 138,000. UPDATED 01/09/08. *LJ UPDATED 12/12/07 *TR

TL* - THE CONTACT CALLED REGARDING THE 1993 MERCURY VILLAGER. THE CONTACT WAS TRAVELING UNDER 30 MPH WHEN THE VEHICLE DECELERATED, IT SEEMED AS THOUGH THE VEHICLE WAS NOT GETTING GAS. THE CONTACT HAD TO KEEP THE VEHICLE IN FIRST GEAR. THE CONTACT SMELLED SOMETHING BURNING AND TURNED OFF THE HEATER. SHE TURNED THE IGNITION OFF, AND SMOKE CAME FROM UNDER THE HOOD. THE FLAMES WERE ON THE PASSENGER'S SIDE NEAR THE ENGINE. THE CONTACT PUT THE FIRE OUT WITH A FIRE EXTINGUISHER. THERE WERE NO INJURIES. THE CONTACT STATED SHE SMELLEDGAS FOR MONTHS. SHE HAD THE EMISSIONS CHECKED, AND THEY DID NOT FIND A PROBLEM. THE CONTACT WILL TAKE PICTURES OF THE VEHICLE. *AK

Fire

I PURCHASED A SET OF ANCO WINTER WIPER BLADES FROM AUTOZONE, FOR A 93 MERCURY VILLAGER. MY WIFE WAS DRIVING MY DAUGHTER TO SCHOOL, AND THE DRIVERS SIDE WIPER BLADE FAILED COMPLETELY, DURING A SERIOUS STORM AND IN HEAVY TRAFFIC. MY WIFE WAS COMPLETELY BLINDED, ALL SHE COULD DO TO MANEUVER TO THE SIDE OF THE ROAD. WIPER BLADES HAD BEEN ON THE CAR LESS THAN A WEEK. RECEIVED NO SATISFACTION FROM AUTOZONE, STORE REPRESENTATIVE REFUSED TO CONSIDER BLATANT DEFECT IN MANUFACTURING. TRIED TO CONVINCE ME THAT MY WIFE MUST HAVE BEEN DRIVING RECKLESSLY OR SOMETHING TO THAT EFFECT. THIS HAD CATASTROPHE WRITTEN ALL OVER IT, ANCO MAKES THESE BLADES IN MEXICO. I DON'T UNDERSTAND HOW A CORPORATION CAN PLACE PROFIT ABOVE THE SAFETY OF FAMILY. *JB

THREE EXHAUST MANIFOLD BOLTS ON THE FRONT, AND THREE MORE ON THE REAR ARE BROKEN OFF, WITH A INCREASINGLY MORE LOUD SOUND COMING FROM UNDER THE HOOD. I BELIEVE THEY ARE AWARE OF THIS DEFECT IN THESE VANS, BUT REQUIRE THE OWNER TO SHOULDER THE PAYMENT OF THIS EXPENSIVE REPAIR. THIS PROBLEM IS VERY EVIDENT IN THE 1993 MODEL YEAR OF THE MERCURY VILLAGER AND THE NISSAN QUEST. *NM

1993 MERCURY VILLAGER DEVELOPED PROBLEMS WITH THE TRANSMISSION.***NO ANSWER REQUIRED***. *MR THE CONSUMER'S VEHICLE WAS PARKED AND OFF WHEN IT JUMPED OUT OF GEAR AND ROLLED OVER THE CONSUMER'S LEG CAUSING RESIDUAL NERVE DAMAGE AFTER THE INITIAL COMPOUND FRACTURE TO HER TIBIA BONE. THE CONSUMER CONTACTED THE MANUFACTURER BUT THEY ASSUME NO RESPONSIBILITY. *NM

1 injured

THE MOTORIZED SEATBELTS IN THE PASSENGER AND DRIVER SEATS STOPPED WORKING. THE PASSENGER SEATBELT MOTOR STARTED SMOKING AND WE HAD TO SHUT DOWN THE MOTOR BY TAKING OFF THE PANEL AND UNPLUGGING THE FUSE.

PURCHASED A 1993 MERCURY VILLAGER FROM MZN AUTO SALES ON JANUARY 28, 2005. WAS DRIVING DOWN THE HIGHWAY ON MAY 19TH, HEARD A LOUD NOISE AND PEOPLE WERE YELLING TO PULL OVER THAT MY VAN WAS ON FIRE, BOTH SIDES IN FLAMES. COME TO FIND OUT, THERE WAS A RECALL ON THIS VEHICLE FOR FUEL RELATED FIRES AND WE WERE NOT NOTIFIED BY THE OWNER OF MZN AUTO SALES OF ANY RECALLS. THEY HAVE OUR VAN IN THEIR POSSESSION AT THIS TIME.

Fire

CONSUMER CONCERN ABOUT WHAT TYPE OF ACCIDENT YOU MUST HAVE FOR THE AIR BAGS TO DEPLOY PROPERLY. *BF THE CONSUMER STATED HE WAS INVOLVED IN A HEAD ON COLLISION AND ONLY THE PASSENGER SIDE AIR BAG DEPLOYED. *JB

Crash

1993 FORD MERCURY VILLAGER V6 3.0L SOHC HAVING SEAT BELT GUIDE RAIL PROBLEMS FUNCTION IS IRRADIC AND NOISEY. SPOKE WITH MERCURY CUSTOMER SERVICE DEPT AND AFTER PROVIDING THEM WITH THE RECALL NUMBER (92V133002) WHICH IS PROVIDED BY NHTSA. THEY EXPLN THAT THIS IS NOT A RECALL NUMBER AND THERE IS NO RECALL FOR THIS VEHICLE. I SPOKE WITH MONIQUE AND HER SUPERVISOR AKALYA. *AK

WHILE TURNING AT ANY SPEED CONSUMER HEARD A KNOCKING NOISE COMING FROM THE FRONT END. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

BAD FACTORY DESIGN LEADS TO EXHAUST MANIFOLD STUDS BREAKING. THUS CAUSING EXPENSIVE, UNDUE REPAIRS. FORD IS UNWILLING TO ASSIST CUSTOMERS WHO EXPERIENCE THIS PROBLEM, BUT IT IS A KNOWN DEFECT WITH THE ENGINE. *AK MORE INFORMATION CAN BE FOUND AT: HTTP://WWW.CARTRACKERS.COM/FORUMS/LIVE/MINIVANSENTHUSIASTDISCUSSIONGROUP/169.HTML

EXHAUST MANIFOLD STUDS BREAKING OFF. CHECKED PRIOR TO REPAIR BY CALLING A LOCAL FORD DEALER AND ALSO ON THE INTERNET, TO SEE IF THERE WAS A RECALL ON THIS AS IT IS AN EXTENSIVE REPAIR AND VERY EXPENSIVE TO REPAIR. COULD NOT FIND AN OFFICIAL RECALL FROM FORD, BUT FOUND NUMEROUS WEBSITES AND COMPLAINTS AND CONCERNS FROM OWNERS, NATIONALLY, AS WELL AS INTERNATIONALLY, OF THE 1993 MERCURY VILLAGER WHO HAVE EXPERIENCED THIS EXACT PROBLEM.

STUDS ON EXHAUST MANIFOLD SHEARED OFF. CAUSED EXHAUST FUMES TO ENTER PASSENGER COMPARTMENT SICKING PASSENGERS. ALSO CAUSED A LOUD NOISE LIKE A EXHAUST LEAK. MECHANIC SAID HAD SEEN THIS ON SEVERAL OTHER VILLAGERS.*AK

I AM THE OWNER OF A '93 MERCURY VILLAGER. I HAVE HAD TO HAVE SEVERAL OF MY HEAD BOLTS REPLACED DUE TO BROKEN BOLTS CAUSING MY HEAD GASKET TO LEAK AND CAUSE MY ENGINE TO OVERHEAT. I AM NOT THE ONLY PERSON WITH THIS PARTICULAR PROBLEM, THERE ARE MANY OF US SEEKING AN EXPLANATION. FOR MORE INFORMATION YOU CAN VISIT CARTRACKERS.COM AND YOU WILL FIND MANY UPSET OWNERS OF BOTH NISSAN QUEST AND MERCURY VILLAGERS (SAME MOTORS) WITH SAME PROBLEM.*AK

EXHAUST MANIFOLD BOLTS HAVE BROKEN AND EXHAUST IS BACKING UP INTO THE CABIN. MY MECHANIC OWNS A VILLAGER AND TOLD ME THAT THIS IS A COMMON PROBLEM AND THAT THE DEALER IS THE ONLY ONE WHO CAN FIX IT. I HAVE DONE SOME ON-LINE RESEARCH AND IT APPEARS THAT THIS IS VERY COMMON AND COULD POSSIBLY BE A MANUFACTURING DEFECT. *JB

WHILE DRIVING VEHICLE WAS INVOLVED IN A MINOR COLLISION. THEN, VEHICLE CAUGHT ON FIRE WITHOUT WARNING. *AK

Crash Fire 1 injured

THE TWO OUTSIDE EXHAUST MANIFOLD BOLTS ON THE BOTH THE FRONT AND BACK WERE BROKEN. THIS CAUSED EXHAUST FUMES TO ENTER THE CABIN.*AK

THOUGH OUR VEHICLE IS EXHIBITING THE EXACT SYMPTOMS LISTED UNDER THE RECALL (95C222001), LINCOLN MAINTAINS THAT OUR VEHICLE IS NOT A CANDIDATE FOR THAT RECALL. THE DEFECT SUMMARY SAYS WE WOULD SMELL BURNING ODORS WHEN USING THE HEATER, WHICH WE DO. PH **DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT OVER TO ARTEMIS**770832

THE HEADLIGHT LENS COVERS DEGRADED EXCESSIVELY AND TURNED GRAY/OPAQUE, WHICH MADE IT VERY DIFFICULT TO SEE THE ROAD WHILE TRAVELING AT NIGHT. *JB NISSAN AND FORDS PLASTIC HEADLIGHT, FADE AND TURN AMBER WHICH RESTRICTED THE LIGHT OUTPUT AND HAS TO BE CHANGED EVERY THREE MONTHS. THE CONSUMER REQUESTED GLASS TO ALLEVIATE THE PROBLEM. *SCC

THE PLASTIC HEADLAMP PLASTIC FADED AND REDUCED LIGHT OUTPUT WHICH IS DANGEROUS FOR NIGHT DRIVING. *JB *SCC

THIS IS ABOUT MY 1993 MERCURY VILLAGER. AFTER VIEWING YOUR SITE, IT APPEARS THAT THE PROBLEM WITH MY CAR IS WIDESPREAD. THE BOLTS THAT CONNECT THE MANIFOLD TO THE ENGINE BLOCK SHEARED OFF. I HAD THE REPAIR DONE IN MAY OF 1998 AND ALSO CONTACTED THE LINCOLN MERCURY DIVISION OF FORD. I EVEN SENT THEM TWO OF THE SHEARED BOLTS. SINCE THAT TIME, THE BOLTS ON THE FRONT MANIFOLD HAVE SHEARED. I NEVER EVEN RECEIVED AN ACKNOWLEDGEMENT FROM FORD IN RESPONSE TO MY LETTER. THE ENGINE NOW IS VERY NOISY AND I BROUGHT IT IN TO MY MUFFLER MECHANIC ABOUT 3 WEEKS AGO AND HE NOTED THE SHEARED BOLTS ON THE FRONT OF THE MANIFOLD. I WOULD LIKE TO KNOW WHETHER NHTSA IS DOING ANYTHING ABOUT THIS OR WHETHER YOU ARE AWARE OF ANY SUCCESS WITH FORD IN GETTING THIS PROBLEM TAKEN CARE OF. IT IS POTENTIALLY DANGEROUS.

CONSUMER WAS INVOLVED IN AN ACCIDENT WHERE THE SEAT BELTS FAILED TO RELEASE. IT WAS NOT UNTIL AFTER THE ACCIDENT THAT CONSUMER LEARNED OF THE SEAT BELT RECALL. *JG

Crash 1 injured

THE VEHICLES FRONT CALIPERS ARE LOCKING UP STATES CONSUMER. WHILE DRIVING AT 20 MPH THE RPM'S ARE HIGHER THAN NORMAL. PLEASE PROVIDE ANY FURTHER INFORMATION. TS

CONSUMER STATES THAT VEHICLE'S FUMES WERE ESCAPING INSIDE THE VEHICLE. DEALER STATED THAT EXHAUST MANIFOLD HAS DEVELOPED A LEAK. PLEASE PROVIDE ADDITIONAL INFORMATION. TS

WHILE DRIVING ON EXPRESSWAY, TAIL PIPE CAUGHT ON FIRE, BURNED THROUGH REAR FLOOR OF INTERIOR CABIN AND IGNITED AN UMBRELLA. MR

Fire

THE VEHICLE SUDDENLY BECAME UNSTEERABLE AT SPEED. THIS WAS CAUSED BY THE CRANKSHAFT'S PULLEY WHICH CAME LOOSE DUE TO THE CRANKSHAFT BREAKING . THIS HAS RUINED THE CRANKSHAFT AND REQUIRES A NEW ENGINE INSTALLED TO REPAIR THE VEHICLE. DT

PLEASE ADD DETAILS. TS THE VEHICLE WAS PARKED IN THE PARK POSITION ON A SLIGHT SLOPE. THE CONSUMER WAS INSTALLING A CAR SEAT WHEN HE VEHICLE STARTED ROLLING BACKWARDS. THE CONSUMER WAS THROWN OUT OF THE VEHICLE THEN RUN OVER BY THE BACK TIRE. THE CONSUMERS RIGHT LEG WAS INJURED. CHILD STILL IN THE VAN AS IT CONTINUED TO ROLL. THE CONSUMER NOTICED PLAY IN THE IGNITION AND LOCK ON THE COLUMN. THE CONSUMER STATED THAT THE IGNITION SWITCH EITHER MAY OR MAY NOT CLICK DEPENDING ON HOW FAR THE KEY WAS TURNED. THE CONSUMERS BONE POPPED OUT CAUSING A LOT OF BLEEDING AND CHILDREN ARE STILL SCARRED BY THE ACCIDENT. *TC

2 injured

PLEASE ADD DETAILS. TS THE VEHICLE WAS PARKED IN THE PARK POSITION ON A SLIGHT SLOPE. THE CONSUMER WAS INSTALLING A CAR SEAT WHEN HE VEHICLE STARTED ROLLING BACKWARDS. THE CONSUMER WAS THROWN OUT OF THE VEHICLE THEN RUN OVER BY THE BACK TIRE. THE CONSUMERS RIGHT LEG WAS INJURED. CHILD STILL IN THE VAN AS IT CONTINUED TO ROLL. THE CONSUMER NOTICED PLAY IN THE IGNITION AND LOCK ON THE COLUMN. THE CONSUMER STATED THAT THE IGNITION SWITCH EITHER MAY OR MAY NOT CLICK DEPENDING ON HOW FAR THE KEY WAS TURNED. THE CONSUMERS BONE POPPED OUT CAUSING A LOT OF BLEEDING AND CHILDREN ARE STILL SCARRED BY THE ACCIDENT. *TC

2 injured

4 EXHAUST MANIFOLD STUDS SHEARED OFF, CREATING EXCESSIVE EXHAUST LEAKAGE AND NOISE. CAUSING EXHAUST FUMES TO ENTER VEHICLE. *AK

WHILE DRIVING 30MPH NOTICED THAT SEATBELT BOLT DROPPED THROUGH AND ENDED UP ON TIRE. *AK

EXHAUST MANIFOLD STUDS CONTINUE TO BREAK, ALLOWING EXHAUST FUMES TO ESCAPE CATALYTIC CONVERTER AND ENTER COMPARTMENT. *AKA REPETATIVE PATTERN FAILURE OF THE STUDS SECURING THE EXHAUST MANIFOLD TO THE ENGINE OCCURS REGULARLY. CONSUMER FEELS THE EXHAUST WHICH CAN BE SMELLED INSIDE OF THE VEHICLE IS A HEALTH HAZARD THERE BY AFFECTING THE DRIVERS ABILITY TO MAINTAIN CONTROL OF THE VEHICLE. *JG

MULTIPLE EXHAUST MANIFOLD STUD FAILURE POSSIBLY, ALLOWING NOXIOUS EXHAUST FUMES TO ENTER PASSENGER COMPARTMENT. *AK

ENGINE POWER SURGES, SHOULDER BELT WOULD NOT RELEASE

Crash 1 injured

ENGINE POWER SURGES, SHOULDER BELT WOULD NOT RELEASE

Crash 1 injured

WHILE DRIVING THE INSIDE TEMPERATURE OF THE VEHICLE BECAME COLD, WHILE TRYING TO ADJUST THE HEAT, THE DRIVER NOTICED THICK BLACK SMOKE FROM THE TAILPIPE, THERE WERE NO DASHBOARD INDICATORS THAT THERE WAS A PROBLEM AND AS A RESULT THE VAN LOST ALL COOLANT RUINING THE ENTIRE ENGINE, THE CONSUMER IS REQUESTING REIMBURSEMENT FOR BOTH REPLACED ENGINES. NLM

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

IF THE IGNITION IS LEFT IN A POSITION BETWEEN "LOCK" AND "ON" THE GEAR SHIFT INTERLOCK MECHANISM DOESNT WORK AND THE VECHCLE CAN BE PULLED OUT OF GEAR. NORMALLY, THE SERVICE BRAKE HAS TO BE APPLIED IN ORDER TO SHIFT OUT OF PARK. CONTACTED FORD MOTOR COMPANY APPROX 6 MONTHS AGO VIA EMAIL- NO RESPONSE.*AK

IN OCT0BER OF 2001 CONSUMER HAD FILLER VENT HOSE REPLACED AS PART OF A RECALL, BUT REMEDY DID NOT WORK, AND FUEL WAS LEAKING AGAIN. *AK

MANUFACTURER ADMITTED DESIGN PROBLEM ON NISSAN 3.0 L MOTOR THAT WAS EVEN COVERED UNDER A GOODWILL WARRANTY. BROKEN EXHAUST MANIFOLD STUDS THAT ARE NOW ON THE 4TH REVISION TO THE REPLACEMENT PART. THIS PROBLEM CAUSES EXHAUST FUMES TO LEAK INTO PASSENGER COMPARTMENT. I HAVE FOUND AT LEAST 5 SERVICE BULLETINS ADDRESSING THE ISSUE ON BOTH NISSAN AND MERCURY VEHICLES.*AK

INTERMITTENTLY STEERING IN ANY DIRECTION CAUSES VEHICLE TO STALL. NO INDICATION LIGHTS ILLUMINATE ON DASHBOARD. VEHICLE WILL RESTART AFTER STALLING. THERE IS NO WAY TO DETECT WHEN VEHICLE WILL STALL. DEALER HAS TRIED DIFFERENT REPAIRS, AND PROBLEM STILL EXISTS. *AK *TT

BOLTS CONTINUALLY BREAK ON MANIFOLD EXHAUST SYSTEM. CONTACTED DEALER, AND DEALER INDICATED A PROBLEM WITH BOLTS ON EXHAUST MANIFOLD. TSB # 98-10-14. *AK

THE BRACKET THAT IS WELDED TO THE CHASSIS OF THE VEHICLE, WHICH HOLDS THE RACK AND PINION SECURE BROKE OFF CAUSING THE STEERING TO BE UNSTABLE. *YH

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

WHILE DRIVING SMELL OF INTENSIVE GAS FILLED THE VEHICLE. TOOK TO DEALER. ALSO TOOK TO MECHANIC. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK