1992 MERCURY COUGAR Recalls, Complaints & Safety

HEADLIGHTS GO OUT UNEXPECTEDLY WHILE DRIVING AT NIGHT, SOMETIMES WILL BLINK BACK ON AND SOMETIMES NOT. VERY DANGEROUS WITH ONCOMING TRAFFIC. MUST PULL OVER AND WAIT EXTENDED PERIODS OF TIME TO CONTINUE DRIVING.

TL* THE CONTACT OWNS A 1992 MERCURY COUGAR. THE CONTACT STATED THAT THE DRIVER SIDE SEAT BELT RETRACTOR WOULD REMAIN STUCK AND THE SEAT BELT WARNING LIGHT ILLUMINATED. THE CONTACT WAS CONCERNED THAT IN THE EVENT OF A CRASH, THE SEAT BELT WOULD FAIL TO SECURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

FAULTY IGNITION SWITCH CAUSING SHORTS AND SPARKS. EFFECTING TURN SIGNALS, BLOWER MOTOR AND OTHER ELC. FORD ADVISED ME THAT MY VEHICLE WAS INVOLVED WITH A 1996 RECALL FOR THE SWITCH AND THAT IT WAS SERVICED AND REPLACED. YEA - REPLACED WITH A FAULTY ONE! FORD REP. SAID THE REPLACEMENT SWITCH IS OUT OF WARRANTY. I AM NOT HAPPY WITH THIS AT ALL! *TR

TL* THE CONTACT OWNS A 1992 MERCURY COUGAR. WHILE DRIVING AT ANY SPEED, THE HEADLIGHTS WOULD FAIL INTERMITTENTLY, FLASHING ON AND OFF. THE CONTACT HAD NOT YET SPOKEN TO THE DEALER AND WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE NOT AVAILABLE.

TL*THE CONTACT OWNS A 1992 MERCURY COUGAR. WHILE DRIVING ANY SPEED AT NIGHT, THE EXTERIOR LIGHTING WILL SPORADICALLY FAIL AND SIGNIFICANTLY REDUCE THE CONTACT'S VISIBILITY. SHE CALLED THE MANUFACTURER IN REFERENCE TO NHTSA CAMPAIGN ID NUMBER 99V275000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH) AND STATED THAT THE VIN WAS EXCLUDED FROM THE RECALL. THE MANUFACTURER WOULD NOT ASSUME ANY RESPONSIBILITY FOR THE REPAIRS. THE CONTACT IS IN THE PROCESS OF HAVING THE VEHICLE REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 139,000.

THE HEADLIGHTS OF THE CONSUMER'S 1992 MERCURY COUGAR WOULD BLINK ON AND OFF. *CC EVENTUALLY THE LIGHTS REMAINED OFF MORE THAN THEY REMAINED ON. THE CONSUMER DID SOME RESEARCH AND FOUND A RECALL WHICH WAS RELATED TO THE PROBLEM HE WAS HAVING WITH HIS VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER ALONG WITH A COPY OF THE RECALL. THE DEALER CHECKED THE VEHICLE'S VIN AND INFORMED THE CONSUMER THAT HIS VEHICLE VIN WAS NOT INCLUDED IN THE RECALL. SINCE THE VEHICLE WAS NOT INCLUDED IN THE RECALL THE CONSUMER WOULD BE RESPONSIBLE FOR THE REPAIRS. THE CONSUMER DECIDED TO REPLACE THE PART HIMSELF. THE DEFECTIVE SWITCH WAS A MOTORCRAFT, E6EB-11654-AA.*NM

TL* - THE CONTACT STATES THAT HER 1992 MERCURY COUGAR'S HEADLIGHTS CONTINUE TO GO OFF AND ON. THE CONTACT STATES THAT SHE COULD BE SITTING, PARKED OR DRIVING, AND LIGHTS ALWAYS TURN OF BUT IF SHE TURNS THE SWITCH OFF AND ON THE LIGHTS TURN ON AGAIN. THE CONTACT STATES THAT THIS STARTED HAPPENING BACK IN JUNE OF THIS YEAR. THE VEHICLE WAS PURCHASED LAST YEAR. THE CONTACT SAID THAT SHE DID FIND THE RECALL ON THIS VEHICLE WHICH WAS ISSUED 10/08/99 FOR EXTERIOR LIGHTING: HEADLIGHTS: SWITCH.

FRONT END SUSPENSION INCLUDING BALL JOINTS CAUSING FRONT END COLLAPSING. *NM

RECALL 99V275000 CONCERNING HEADLIGHTS. THE HEADLIGHTS WOULD FLICKER ON /OFF WHILE DRIVING AT ANY SPEED AT NIGHT, AND/OR INTERMITTENTLY WOULD GO OFF AND COME BACK ON WHILE DRIVING AT NIGHT. CONSUMER FOUND THIS RECALL NUMBER ON NHTSA WEBSITE, CALLED THE DEALER, WHO INFORMED THE CONSUMER THAT THIS VEHICLE WAS NOT COVERED UNDER THE RECALL DUE TO VIN. *AK

WHILE DRIVING 20 MPH FRONT/REAR DRIVER SIDE TIRES BLEW OUT. THE CONSUMER MANAGED TO PULL OVER AND CHANGED THE TIRES. THE DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. NATIONAL, XT6000, SIZE 21570R15, DOT#DHM37777018. *AK A SECOND TIRE WAS REPLACED DUE TO SEVERE DEFORMITIES THAT CAUSED THE STEERING WHEEL TO WOBBLE ALONG WITH OTHER DIFFICULTIES. (TIRE MAKE/NATIONAL XT6000X) *SC

ON TRIP TO OHIO ONE FRONT TIRE BLEW OUT AND THE SECOND BECAME DEFORMED WHICH WOULD HAVE SHORTLY BLOWN EXCEPT IT WAS ON THE FRONT AND EXIBITED A DEFINITE WOBBLY . THE TIRES HAVE APPROXIMATELY 13,000 MILES ON THEM.MADE IN CANADA BY NATIONAL MODEL XT 6000. *AK

RECALL 99 V275 000/HEADLIGHTS: VEHICLE EXPERIENCED PROBLEM WITH HEADLIGHTS GOING OUT AND COMING BACK ON INTERMITTENTLY. DEALER NOTIFIED, AND INFORMED CONSUMER THAT VEHICLE WAS NOT COVERED UNDER RECALL 99V275 DUE TO VIN. *LA

HEADLIGHTS EXPERIENCED THE SAME DEFECT AS STATED IN RECALL 99V275000; HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN.*AK

THE 1992 MERCURY COUGAR INVOLVED IN THE ACCIDENT BELONGED TO MY FATHER, BUT HAD BEEN LOANED TO ME. MY HUSBAND WAS DRIVING IT AT THE TIME OF THE ACCIDENT. HE PASSED OUT, POSSIBLY FROM LOW BLOOD SUGAR AND RAN THE CAR OFF THE ROAD. IT WAS ESTIMATED THAT HE WAS GOING 50MPH, WHEN HE HIT A DIRT CULVERT THAT WAS ABOUT 5 FT HIGH. THE IMPACT CRUNCHED THE FRONT OF THE CAR AGAINST THE FIREWALL LIKE IT WAS SUPPOSED TO. THE PROBLEM IS THAT THE METAL CROSS BARS IN THE TRUNK, BEHIND THE BACK SEAT SNAPPED, WHICH CAUSED EVERYTHING IN THE TRUNK TO FLY INTO THE PASSENGER COMPARTMENT. LUCKILY NOBODY WAS KILLED IN THE ACCIDENT FROM THE FLYING DEBREE. THE FORCE OF THE CROSS BARS SNAPPING, KNOCKED THE BACKSEAT COMPLETELY OUT OF PLACE. IF A CHILD HAD BEEN IN THE CAR, THEY WOULD NOT HAVE STOOD A CHANCE OF SURVIVAL BECAUSE OF ALL THE ITEMS IN THE TRUNK SLAMMING INTO THE PASSENGER AREA.*AK

Crash 1 injured

THE 1992 MERCURY COUGAR INVOLVED IN THE ACCIDENT BELONGED TO MY FATHER, BUT HAD BEEN LOANED TO ME. MY HUSBAND WAS DRIVING IT AT THE TIME OF THE ACCIDENT. HE PASSED OUT, POSSIBLY FROM LOW BLOOD SUGAR AND RAN THE CAR OFF THE ROAD. IT WAS ESTIMATED THAT HE WAS GOING 50MPH, WHEN HE HIT A DIRT CULVERT THAT WAS ABOUT 5 FT HIGH. THE IMPACT CRUNCHED THE FRONT OF THE CAR AGAINST THE FIREWALL LIKE IT WAS SUPPOSED TO. THE PROBLEM IS THAT THE METAL CROSS BARS IN THE TRUNK, BEHIND THE BACK SEAT SNAPPED, WHICH CAUSED EVERYTHING IN THE TRUNK TO FLY INTO THE PASSENGER COMPARTMENT. LUCKILY NOBODY WAS KILLED IN THE ACCIDENT FROM THE FLYING DEBREE. THE FORCE OF THE CROSS BARS SNAPPING, KNOCKED THE BACKSEAT COMPLETELY OUT OF PLACE. IF A CHILD HAD BEEN IN THE CAR, THEY WOULD NOT HAVE STOOD A CHANCE OF SURVIVAL BECAUSE OF ALL THE ITEMS IN THE TRUNK SLAMMING INTO THE PASSENGER AREA.*AK

Crash 1 injured

HEAD GASKETS BLEW A LEAK DURING VEHICLE INSPECTION AT RAHWAY, NJ INSPECTION STATION. *AK *NLM **DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS*734305

THE HEAD LIGHTS TURNED OFF BY THEMSELVES. *JB

WHILE TRAVELING ABOUT 15MPH ON A ROAD, CABLE GOT STUCK BETWEEN THROTTLE, THE VEHICLE WOULDN'T STOP. CONSUMER HAD THE PEDAL PUSHED ALL THE WAY DOWN TO THE FLOOR. *AKTHE TRANSMISSION BOOST CABLE HAD BOKEN WHICH CAUSED THE THROTTLE TO STICK THEREFORE CONTRIBUTING TO THE ACCIDENT. *JG

HEAD GASKETS BLEW A LEAK DURING VEHICLE INSPECTION AT RAHWAY , NJ VEHICLE INSPECTION STATION. *AK

WHEN I DROVE MY CAR TO WORK IT SEEMED FINE. WHEN I GOT INTO THE CAR AFTER WORK I IDLED REALLY ROUGH I THOUGHT IT WAS THE MORE EXPENSIVE GAS I PUT INTO IT THE NIGHT BEFORE, SO I PROCEEDED TO THE GAS STATION TO LET THEM KNOW. THE CAR DROVE REALLY ROUGH ALL THE WAY THERE. A RED LIGHT CAME ON ON THE DASH JUST BEFORE I GOT TO THE GAS STATION SAYING CHECK GAUGES. THE GAUGE SHOWED THAT THE CAR OVERHEATED. AFTER HAVING MY CAR WORKED ON ABOUT EIGHT MONTHS AGO FOR A OVERHEATING PROBLEM, IT HAD BEEN RUNNING REALLY COOL, SO DIDN'T THINK I WOULD HAVE A OVERHEATING PROBLEM. I TURNED OFF THE CAR, BUT THOUGHT I WOULD CHECK TO MAKE SURE THE FAN WORKED I TURNED THE CAR BACK ON AND OUT OF THE TAIL PIPE CAME A CLOUD OF WHITE SMOKE THAT DISAPATED REALLY FAST AFTER TURNING OFF ENGINE. CHECKED OIL THERE WAS NO WATER IN IT, BUT IT WAS LOW . I ADDED A QUART IN ORDER TO GET IT HOME. IT STILL HAD WHITE SMOKE OR STEAM COMING OUT THE TAIL PIPE. ALSO THE SEATS DO NOT LOCK INTO PLACE. THE AIRCONDITIONER DOES NOT GET COLD. I WOULD LIKE TO KNOW IF THERE IS ANYTHING ELSE THAT I SHOULD BE AWARE OF THAT I NEED TO HAVE FIXED.

WHILE DRIVING AT 25-30 MPH HEAD GASKET BLEWOUT, AND THERE WAS ANTIFREEZE ALL OVER ENGINE ALSO, VEHICLE BECAME INOPERATIVE .CONTACTED DEALER, AND DEALER WAS NOT WILLING TO DO ANYTHING.*AK

HEADLIGHTS INTERMITTENTLY FLICKER OR GO OUT, THERE IS A RECALL, BUT THIS VEHICLE IS NOT AFFECTED DUE TO VIN. *AK CONSUMER STATED THE REPAIRS HAVE BEEN MADE TO HEADLIGHTS.*SLC

WHILE DRIVING, HEADLIGHTS FLICKERED ON AND OFF, CONSUMER HAD TO WIGGLE SWITCH TO MAKE LIGHTS COME BACK ON, AND SOMETIMES THAT DID NOT WORK, LOST ALL LIGHTS, AND SMELLED WIRE BURNING. CONSUMER HAD LIGHT SWITCH REPLACED. *AK CONSUMER STATED EVEN THOUGH THE SWITCH HAS BEEN REPLACED AND THE FLICKERING HAS STOPPED, THERE IS STILL A BURNING SMELL WHEN LIGHTS HAVE BEEN ON FOR AWHILE, CONSUMER ALSO HAD TROUBLE GETTING LIGHTS TO REMAIN ON DUE TO VIBRATION.*SLC

ODOMETER JUST STOPPED WORKING. CONSUMER DOESN'T KNOW CORRECT MILEAGE.*AK *SLC

THIS ENGINE TYPE HAS HAD A HISTORY OF THIS REPORTED PROBLEM (HEAD GASKET FAILURE). I HAVE CONTACTED SEVERAL MECHANICS, AND THEY HAVE ALL REPORTED THAT THE PROBLEMS THAT I AM EXPERIENCING, ARE DUE TO HEAD GASKET FAILURE. I HAVE CONTACTED FORD MO. CO., BUT THEY HAVE PROVIDED NO ANSWERS/ASSISTANCE, EVEN KNOWING OF THIS MAJOR DEFECT WITH THIS ENGINE TYPE. THIS FAILURE IS OBVIOUSLY DUE TO A FACTORY DEFECT, AND I WANT IT TO BE ON RECORD WITH EVERY ORGANIZATION THAT FORD SHOULD BE RESPONSIBLE TO FIX AT THEIR COST. FORD NOT TAKING RESPONSIBILITY FOR THIS ENGINE DEFECT IS COMPLETELY UNACCEPTABLE, AND I EXPECT THAT I WILL BE FILING SUIT WITH THEM UNLESS THEY WILL TAKE RESPONSIBILITY FOR THEIR DESIGN FLAWS. IF YOU AN SUGGEST ANY FURTHER ACTION I CAN TAKE, PLEASE EMAIL ME AT [email protected]. *AK

HEAD GASKETS LEAKAGE WATER INTO CYLINDER, CAUSING PROBLEMS TO ENGINE PROFORMANCE-STALLING, DECREASED EXCELERATION, ETC. *AK

AFTER A SHORT PERIOD OF TIME HEADLIGHTS GO OFF. I AM FORCED TO PULL BACK ON THE TURN SIGNAL LEVER AND DRIVE WITH HIGH BEAMS.*AK

HEADLIGHTS WILL FAIL AS CONSUMER IS DRIVING , SAME DEFECT AS IN RECALL 99V275000. BUT, THIS VEHICLE IS NOT INCLUDED IN RECALL DUE TO VIN. *AK

WHILE DRIVING WITH HEADLIGHTS ON, THEY COULD GO OUT FOR A COUPLE SECONDS JUST LIKE MENTIONED IN RECALL 99 V 275 000/HEADLIGHTS. *AK

HEAD GASKET HAS BLOWN, AND POSSIBLY CAUSED DAMAGE TO ENGINE.*AK *SLC

WHILE TRAVELING GAS PEDAL STUCK, CAUSING CONSUMER TO RUN INTO ANOTHER VEHICLE. PLEASE PROVIDE FURTHER INFORMATION.*AK

Crash

GAS PEDAL STUCK, CAUSING VEHICLE TO ACCELERATE. *AK

WHILE TRAVELING GAS PEDAL BECAME STUCK, CAUSING CONSUMER TO RUN INTO ANOTHER VEHICLE. PLEASE PROVIDE FURTHER INFORMATION. *AK

Crash

LIGHT SWITCH FAILURE, LOST HEADLIGHTS, RECALL FOR THIS PROBLEM DIDN'T COVER MY CAR. WHY?*AK

THE FRONT DISC BRAKES HAVE FAILED SEVERAL TIMES CAUSING VIOLENT VIBRATIONS WHILE BRAKING. NLM

THERE IS A RECALL ON THIS PROBLEM (NHTSA 99V275/FORD NO. 99S30) BUT WHEN CONTACTED THEY SAID THE RECALL WAS VEHICLE SPECIFIC AND MINE WASN'T COVERED ALTHOUGH IT HAD THE EXACT PROBLEM THAT WAS MENTIONED IN THE RECALL. I WAS TOLD THAT THE PROBLEM HAD ONLY OCCURRED IN MODELS EQUIPPED WITH FOG LAMPS. I SPENT THE LAST FIVE MILES ON MY WAY HOME LAST NIGHT WITH MY HEADLIGHTS FLICKERING ON AND OFF, AND CAN TESTIFY THAT THE PROBLEM IS NOT ONLY ON MODELS WITH FOG LAMPS. THE REP. AT THE FORD MOTOR CO. AS MUCH AS ADMITTED THAT ALL THE COUGARS IN THAT YR. AND MODEL ARE EQUIPPED WITH THE SAME HEADLAMP SWITCH, BUT HE "COULD NOT HELP ME" BECAUSE MY VIN NUMBER WASN'T LISTED. IF I HADN'T SEEN THAT THERE IS A RECALL ON THIS OR MY CAR WASN'T WELL MAINTAINED, I WOULD JUST REPAIR IT, BUT WHEN THEY ONLY ACKNOWLEDGE THE PROBLEM ON CERTIAN CARS, DEPENDING ON WHAT THE CAR IS EQUIPPED WITH, EVEN THOUGH IT IS THE SAME SWITCH, I FEEL I'M GETTING TAKEN ADVANTAGE OFF. *AK

THE FRONT DISC BRAKES HAVE FAILED SEVERAL TIMES CAUSING VIOLENT VIBRATIONS WHILE BRAKING. NLM

HEAD GASKET FAILED DURING NORMAL USE-VEHICLE IS WELL MAINTAINED. REPORTED DUE TO UNDERSTANDING OF EPIDEMIC OF COMMON OCCURANCES. *AK

THE 3RD TIME THE GASKET'S YES THATS RIGH BOTH OF THEM HAVE BLOWN AND HOW ODD AT 40K/80K/121K/ GEE THATS 40K FOR EACH HEAD GASKET FORD FIXED FIRST ONE THEN SAID SORRY YOUR UP S*CREEK WITH THE 2ND ONE... AND NOW THE 3RD TIME WHAT NEXT????*AK

HEAD GASKETS BLEW A LEAK DURING VEHICLE INSPECTION AT RAHWAY , NJ VEHICLE INSPECTION STATION

THE GAS PEDAL GOT STUCK WHEN ACCELERATING ONTO THE HIGHWAY CONSUMER HAD TO STAND ON THE BRAKE AND KICK ACCELERATOR PEDAL VERY HARD TO UNSTICK. NLM

THE CAR VIBRATES EXTREMELY BAD WHEN APPLYING THE BRAKES, ROTORS AND BRAKES HAVE BEEN REPLACED TWICE. NLM

THE PASSENGER SIDE WINDOW STOPPED WORKING. NLM

THE SPEEDOMETER GETS STUCK IN WARM WEATHER. NLM

THE RIGHT REAR WHEEL BEARING IS GOING BAD CAUSING THE WHEEL TO ALMOST FALL OFF. NLM

HEAD GASKET BLEW ON MY COUGAR. UPSET THAT THIS IS A WIDESPOREAD ISSUE AND THAT FORD FAILS TO WARRANTY THIS CLEAR DEFECT. THE DEFECT RATE FOR THIS EXACT PROBLEM IS MIND BOGGLING. THE FACT THAT FORD HAS 'CHRREY PICKED' WHICH YEARS / VEHICLES TO COVER UNDER WARRANTY IS ABSURD. THE PROBLEM IS RELATED TO THE 3.8L ENGINE AND THUS ALL SUCH ENGINES SHOULD BE COVERED!*AK