2004 JAYCO GREYHAWK
8 recalls — 2 complaints — 3 TSBs
17V746000 Nov 21, 2017
EQUIPMENT
Defect Description
Jayco, Inc. (Jayco) is recalling various 2002-2016 recreational vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V746-9524.pdf. These extinguishers may be... Read more
Consequence
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy
Jayco will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Jayco customer service at 1-800-283-8267, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and ... Read more
06V095000 Mar 31, 2006
ELECTRICAL SYSTEM:WIRING
Defect Description
CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Consequence
SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Remedy
FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-... Read more
06V082000 Mar 28, 2006
ENGINE AND ENGINE COOLING
Defect Description
ON CERTAIN MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION, COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO C... Read more
Consequence
THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.
Remedy
FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR JAYCO AT 1-800-283-8267.
05V556000 Dec 16, 2005
TRAILER HITCHES
Defect Description
ON CERTAIN MOTOR HOMES, THE HITCH RECEIVER MAY HAVE MISSING REINFORCING PLATES. WHEN A LOAD IS APPLIED TO THE HITCH, IT MAY BECOME PARTIALLY DETACHED FROM THE FRAME IF THESE PLATES ARE MISSING.
Consequence
THIS CONDITION, IF NOT ADDRESSED, COULD RESULT IN A CRASH, PERSONAL INJURY OR DEATH.
Remedy
DEALERS WILL INSPECT AND REPLACE THE REINFORCING PLATES WITH NEW HARDWARE. THE RECALL BEGAN ON JANUARY 10, 2006. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.
05V476000 Oct 14, 2005
EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
Defect Description
CERTAIN MOTOR HOMES BUILT ON CHEVROLET C3500 (EXPRESS) CUTAWAY CHASSIS HAVE A TOWING PIGTAIL THAT WILL NOT SHOW BRAKE LIGHTS ON THE TOWED VEHICLE IF HOOKED TO THE TOWING PIGTAIL.
Consequence
THIS CONDITION COULD RESULT IN A CRASH, INJURY OR DEATH.
Remedy
DEALERS WILL REWIRE THE TOWING PIGTAIL WIRES TO INCLUDE THE BRAKE LIGHT CIRCUIT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 31, 2005. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.
05V354000 Aug 8, 2005
ELECTRICAL SYSTEM:WIRING
Defect Description
ON CERTAIN MOTOR HOMES, THE CABLE TIES, WHICH ATTACH THE MAIN WIRING HARNESS TO THE FRAME RAILS, MAY BREAK AND CAUSE THE WIRE HARNESS TO DROP INTO THE EXHAUST SYSTEM.
Consequence
THIS COULD RESULT IN THE CABLE MELTING AND CREATING AN ELECTRICAL SHORT AND/OR FIRE.
Remedy
DEALERS WILL INSPECT THE MOTOR HOMES AND ATTACH NEW HEAVY DUTY CABLE TIES. THE RECALL BEGAN ON AUGUST 22, 2005. OWNERS MAY CONTACT JAYCO AT 1-574-825-5861.
05V023000 Jan 28, 2005
ELECTRICAL SYSTEM:WIRING
Defect Description
ON CERTAIN MOTOR HOMES, THE 120-VOLT SHORE POWER CORD WAS WIRED WITHOUT A CIRCUIT PROTECTION DEVICE.
Consequence
THIS COULD CAUSE A FIRE.
Remedy
DEALERS WILL INSPECT AND REWIRE THE 120-VOLT SHORE POWER CORD AND INSTALL A CIRCUIT PROTECTION FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 21, 2005. OWNERS MAY CONTACT JAYCO AT 574-825-5861.
03V383000 Oct 9, 2003
EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
Defect Description
ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY K... Read more
Consequence
AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
Remedy
SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN F... Read more
Complaint Statistics
2 total complaints
Top Reported Components
| Component | Complaints |
|---|---|
| FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS | 1 |
| ELECTRICAL SYSTEM | 1 |
ELECTRICAL SYSTEM
Mar 13, 2009
Incident date: Mar 2, 2007
THE BATTERY RAN DOWN ON THE CHASSIS AND WAS RECHARGED. THE WARNING LIGHTS IN THE INSTRUMENT CLUSTER DID NOT COME ON, HOWEVER, THE ENGINE STARTED EASILY. TURNED THE ENGINE OFF RESTARTED IT SEVERAL TIMES BUT THE WARNING LIGHTS DID NOT COME ON. ALL OTHER LIGHTS CAME ON AND THE ILLUMINATION FOR THE IN... Read more
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
May 17, 2005
Incident date: May 15, 2005
WHILE PREPPING MY 2004 JAYCO GRAYHAWK 24SS CLASS C MOTORHOME FOR OUR NEXT TRIP I DISCOVERED THAT THE FUEL LINE FEEDING THE GENERATOR IS LEAKING. IT LEAKS WHILE THE GENERATOR IS RUNNING AND FOR A WHILE AFTERWARD, I GUESS UNTIL VACUUM STOPS IT. WHAT WAS ESPECIALLY SCARY IS THAT THE HOSE RUNS ABOVE AND... Read more
Technical Service Bulletins — 2004 JAYCO GREYHAWK
3 manufacturer communications from 2 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 1 |
| 070000 FUEL SYSTEM, GASOLINE | 1 |
| 350000 EQUIPMENT | 1 |
SRP 22-083
Feb 23, 2023
070000 FUEL SYSTEM, GASOLINE
Standard Repair Procedure: 4K & 5.5K Generator Overheating a?? Fuel Hose Protection. Gas generators overheating while traveling. Adding a heatshield sleeve to the fuel line running from the rear axle to the generator fuel line connection.
SRP 22-083
Feb 23, 2023
350000 EQUIPMENT
Standard Repair Procedure: 4K & 5.5K Generator Overheating a?? Fuel Hose Protection. Gas generators overheating while traveling. Adding a heatshield sleeve to the fuel line running from the rear axle to the generator fuel line connection.
INC 22-067
May 17, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
JAYCO AND ENTEGRA COACH STORAGE TIPS. INSTRUCTIONS FOR STORING JAYCO AND ENTEGRA COACH DIESEL PUSHERS.
JAYCO GREYHAWK — All Years Overview
Complete safety history for the JAYCO GREYHAWK across all model years (2002–2023).
68
Total Recalls
33
Total Complaints
0
Investigations
0
Reported Crashes
3
Reported Fires
0
Reported Deaths
JAYCO GREYHAWK — Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2026 | 0 | 3 | View |
| 2023 | 2 | 0 | View |
| 2022 | 5 | 0 | View |
| 2021 | 3 | 3 | View |
| 2020 | 5 | 2 | View |
| 2019 | 3 | 2 | View |
| 2018 | 2 | 3 | View |
| 2017 | 3 | 6 | View |
| 2016 | 4 | 1 | View |
| 2015 | 1 | 3 | View |
| 2014 | 1 | 1 | View |
| 2013 | 1 | 1 | View |
| 2012 | 1 | 0 | View |
| 2011 | 1 | 0 | View |
| 2010 | 1 | 0 | View |
| 2009 | 1 | 0 | View |
| 2008 | 2 | 1 | View |
| 2007 | 3 | 3 | View |
| 2006 | 4 | 0 | View |
| 2005 | 8 | 0 | View |
| 2004 (current) | 8 | 2 | |
| 2003 | 7 | 0 | View |
| 2002 | 2 | 2 | View |