2013 INTERNATIONAL PROSTAR
18 recalls, 15 complaints - 642 TSBs
23V353000 May 18, 2023
EXTERIOR LIGHTING:BACK UP LIGHTS
Defect Description
Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 99... Read more
Consequence
Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.
Remedy
Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23514.
15V776000 Nov 20, 2015
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Defect Description
Navistar, Inc. is recalling certain model year 2013-2014 International ProStar and DuraStar trucks manufactured April 26, 2012, to April 4, 2013, WorkStar trucks manufactured April 27, 2012, to March 29, 2013, LoneStar trucks manufactured May 21, 2012, to April 2, 2013, and TranStar trucks manufactu... Read more
Consequence
A high engine idle may make downshifting the transmission difficult and the engine brake may be disabled. These factors may hinder slowing down the truck when descending a long grade, thereby increasing the risk of a crash.
Remedy
Navistar will notify owners, and dealers will recalibrate the electronic control module (ECM) to allow it to recognize that the pedal is at the idle position, free of charge. The recall began on January 19, 2016. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number fo... Read more
15V607000 Sep 29, 2015
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
Defect Description
Navistar, Inc. (Navistar) is recalling certain model year 2011-2014 International ProStar trucks manufactured May 18, 2010, to April 5, 2013, 2012-2014 International LoneStar trucks manufactured September 7, 2011, to March 25, 2013, and 2011-2013 International TranStar trucks manufactured October 18... Read more
Consequence
If the fifth wheel and locking mechanism are sufficiently damaged, the locking mechanism may fail to operate as intended and the trailer may unexpectedly detach from the tractor, increasing the risk of a crash.
Remedy
Navistar will notify owners, and Fontaine dealers will replace the fifth wheel with an Ultra NT model fifth wheel, free of charge. The recall began on November 18, 2015. Owners may contact Navistar customer service at 1-800-448-7825, or Fontaine customer service at 1-844-597-7393.
15V241000 Apr 22, 2015
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
Defect Description
Navistar, Inc. (Navistar) is recalling certain model year 2011-2015 International DuraStar, ProStar, TranStar and WorkStar, 2012-2015 International TerraStar, 2013-2015 International LoneStar and IC Bus HC, and 2014-2015 IC Bus AC vehicles. A vehicle double battery jump start or electrical load dum... Read more
Consequence
If the LPM overheats and fails, there is an increased risk of a fire.
Remedy
Navistar will notify owners, and dealers will replace the LPM with an upgraded one, free of charge. An interim letter was mailed to owners on June 18, 2015. A second notification will mailed when parts become available. The recall began on August 6, 2015. Owners may contact Navistar customer ser... Read more
14V688000 Oct 31, 2014
ELECTRICAL SYSTEM
Defect Description
Navistar, Inc. (Navistar) is recalling certain model year 2010-2015 International Lonestar vehicles manufactured October 12, 2009, to June 16, 2014, and 2009-2015 International ProStar vehicles manufactured December 16, 2008, to June 20, 2014. In the affected vehicles the electrical harness that su... Read more
Consequence
An increase in resistance and heating at the connectors could cause a vehicle fire.
Remedy
Navistar will notify owners, and dealers will replace the 60 amp relay and battery harness with a 150 amp relay and battery harness, free of charge. Navistar issued an interim notification to owners on December 29, 2014. The recall began on March 2, 2015. Owners may contact Navistar customer serv... Read more
14V064000 Feb 20, 2014
SERVICE BRAKES
Defect Description
Navistar Inc., is recalling certain model year 2012-2013 International Lonestar, Paystar, Prostar, Workstar and 9900 trucks, equipped with feature code 0504501, 0504504, or 04EWM Reduced Stopping Distance (RSD) brake linings and with or without feature code 04WCS Greased For Life front air S-cam bra... Read more
Consequence
S-cam bracket fractures may result in an inoperative brake on the affected wheel. This will cause the vehicle to pull to one side unexpectedly during braking and/or increase the stopping distance. Either result may increase the risk of a crash.
Remedy
Navistar will notify owners, and dealers will replace the S-cam brake assemblies with a brake assembly with cast spiders and S-cam tube bracket assemblies with reinforced gussets, free of charge. The recall began on March 27, 2014. Owners may contact Navistar at 1-331-332-1590. Navistar's number ... Read more
13V581000 Nov 20, 2013
FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
Defect Description
Navistar, Inc. is recalling certain model year 2013-2014 International ProStar sleeper cab vehicles manufactured December 12, 2012, through August 8, 2013 and equipped with feature code 16XSA, 16XSB, 16XSC or 16XSD chassis skirts. In the affected vehicles, the rear chassis skirt upper horizontal su... Read more
Consequence
A hole in the tank would allow fuel to leak onto the roadway causing dangerous driving conditions, which could result in a vehicle crash, property damage, personal injury, or death.
Remedy
Navistar will notify owners, and dealers will reinstall the chassis skirt with proper clearance, free of charge. If necessary, the fuel tank will be replaced. The recall began on March 31, 2014. Owners may contact Navistar at 1-800-448-7825. Navistar's recall number is 13517.
13V439000 Sep 18, 2013
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
Defect Description
Navistar, Inc. is recalling certain model year 2008-2013 International LoneStar, ProStar, and TranStar trucks manufactured February 20, 2008, through July 29, 2013 and equipped with an electronic fifth wheel jaw release system (feature code 0595BAW or 0595BAY). Due to an assembly error, the air lin... Read more
Consequence
Because of the improper orientation, in the event of an air leakage at the isolation/vent valve, the 5th wheel jaw may release, unexpectedly releasing the trailer from the tractor, increasing the risk of a vehicle crash.
Remedy
Navistar will notify owners, and dealers will inspect the air line routing. If necessary, the air line routing will be corrected free of charge. The recall began on October 10, 2013. Owners may contact Navistar at 1-331-332-1590. Navistar's recall number is 13514.
13V231000 Jun 4, 2013
SERVICE BRAKES
Defect Description
Navistar is recalling certain model year 2012-2013 International brand ProStar and TranStar commercial trucks, manufactured from August 01, 2011, through July 10, 2012, and equipped with front brake linings listed as feature codes 0504501, 0504504, or 04EWM. The brake S-Cam tube bracket assemblies ... Read more
Consequence
Brake assembly fractures may result in an inoperative brake on the affected wheel. This will cause the vehicle to pull to one side unexpectedly during breaking and/or increase the stopping distance. Either result may increase the risk of a vehicle crash.
Remedy
Navistar has already notified all affected owners about the defect during the course of the 2012 campaign that did not launch due to parts delays. The remedy began on September 12, 2013. Dealers will replace the S-Cam tube bracket assemblies, free of charge. Owners may contact Navistar at 1-800-4... Read more
13V146000 Apr 17, 2013
VISIBILITY
Defect Description
Navistar is recalling certain model year 2011-2012 International Lonestar, model year 2012-2013 International Terrastar and model year 2011-2013 International DuraStar, ProStar, TranStar, and WorkStar commercial trucks manufactured from June 1, 2010, through March 7, 2012 and equipped with day cab c... Read more
Consequence
If the sun shade separates from the cab roof during vehicle operation, the sudden release of the sun shade could distract the driver increasing the risk of a crash.
Remedy
Navistar will notify owners, and dealers will inspect and strengthen the sun shade mounting, free of charge. The safety recall began on September 10, 2013. Owners may contact Navistar at 1-800-448-7825. Navistar's campaign number is 13505.
13V101000 Mar 20, 2013
WHEELS
Defect Description
Navistar is recalling certain model year 2013 International ProStar commercial trucks, manufactured from January 24, 2012, through January 2, 2013, with feature codes 29AEB and 29AEC (Preset Plus hubs). The axle bearing retaining nut lock snap ring may have not been installed or may have been insta... Read more
Consequence
Separation of a wheel hub from an axle may increase the risk of a crash.
Remedy
Navistar will notify owners, and dealers will inspect and replace any missing axle bearing retainer nut lock snap rings, free of charge. The safety recall began on April 24, 2013. Owners may contact Navistar at 1-800-448-7825.
12V546000 Nov 21, 2012
SERVICE BRAKES
Defect Description
Navistar is recalling certain model year 2012-2013 International brand ProStar and TranStar commercial trucks, manufactured from August 01, 2011, through June 12, 2012, and equipped with front brake linings listed as feature codes 0504501 or 0504504. The brake S-Cam tube bracket assemblies on the s... Read more
Consequence
Brake assembly fractures may result in an inoperative brake on the affected wheel. This will cause the vehicle to pull to one side unexpectedly during breaking and/or increase the stopping distance. Either result may increase the risk of a vehicle crash.
Remedy
Navistar will notify owners, and dealers will replace S-Cam tube bracket assemblies free of charge. The safety recall is expected to begin by August 23, 2013. Owners may contact Navistar at 1-800-448-7825.
12V508000 Oct 18, 2012
EQUIPMENT
Defect Description
Navistar is recalling certain model year 2013 International ProStar commercial trucks, manufactured from May 14, 2012, through August 14, 2012, and equipped with tow hook feature code 01570. The tow hooks may not have been heat treated to specification resulting in reduced strength.
Consequence
Improperly heat treated tow hooks may unexpectedly break during vehicle recovery, resulting in the towed vehicle separating from the towing vehicle while in traffic, increasing the risk of a crash without warning with accompanying vehicle damage, injuries or deaths.
Remedy
Navistar will notify owners, and dealers will replace the suspect tow hooks, free of change. The safety recall ibegan on December 18, 2012. Owners may contact Navistar at 1-800-448-7825.
12V507000 Oct 17, 2012
STEERING
Defect Description
Navistar is recalling certain model year 2013 International brand LoneStar, ProStar, and WorkStar commercial trucks, manufactured from April 22, 2012, through October 29, 2012, and equipped with steering wheel feature codes 05CAW, 05CAX, 05CAZ, 05CBA, or 05WBD. The steering wheel may not have been ... Read more
Consequence
A steering wheel with an incomplete weld may separate from the steering wheel mounting hub, leading to a loss of vehicle control and increasing the risk of a crash.
Remedy
Navistar will notify owners, and dealers will inspect and replace affected steering wheels, free of charge. The safety recall began on November 21, 2012. Owners may contact Navistar at 1-800-448-7825.
12V465000 Sep 20, 2012
PARKING BRAKE:DRIVELINE:AIR:CHAMBER
Defect Description
Navistar is recalling certain model year 2013 International 8600, 2012 and 2013 Durastar, 2011-2013 ProStar, and 2012 WorkStar trucks, manufactured from November 23, 2010, through April 02, 2012, and equipped with piston spring brake feature code 04EVP. The piston bore area of the parking brake cha... Read more
Consequence
If the parking brake does not fully release, the service brakes may lock up without warning, increasing the risk of a crash.
Remedy
Navistar will notify owners, and dealers will replace the spring brake chamber free of charge. The safety recall began on November 6, 2012. Owners may contact Navistar at 1-331-332-1590.
12V403000 Aug 14, 2012
SERVICE BRAKES, AIR:DISC
Defect Description
Navistar is recalling certain model year 2011-2013 International vehicles manufactured from November 2, 2010 through May 25, 2012, equipped with Bendix air disc brakes. Bolts that fasten the air disc brake caliper to the caliper mounting plate may not have been tightended to their specified torque.... Read more
Consequence
An unexpected pull condition during braking application or an unexpected increase in stopping distance, increases the risk of a crash, leading to property damage, personal injury, or death.
Remedy
Navistar will notify owners, and dealers will replace any missing caliper mounting bolts and tighten caliper mounting bolts, free of charge. The safety recall began on October 30, 2012. Owners may contact Navistar at 1-331-332-1590.
12V196000 May 2, 2012
ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
Defect Description
NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2010 THROUGH 2013 PAYSTAR, WORKSTAR, TRANSTAR, AND PROSTAR, AND MODEL YEAR 2012 AND 2013 LONESTAR COMMERCIAL TRUCKS MANUFACTURED FROM JUNE 1, 2009, THROUGH APRIL 4, 2012, EQUIPPED WITH A MAXXFORCE 11 OR 13 ENGINE (FEATURE CODE 12UXJ OR 12UXH) AND WITH BOSCH A... Read more
Consequence
AN ELECTRICAL SHORT MAY CAUSE A VEHICLE FIRE POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
Remedy
NAVISTAR WILL INSTALL A STANDOFF BRACKET AND IMPROVE HARNESS ROUTING TO BETTER ROUTE THE ALTERNATOR WIRES AWAY FROM THE POWER STEERING HOSE. THE SAFETY RECALL BEGAN ON JULY 16, 2012. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.
12V052000 Feb 13, 2012
SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE
Defect Description
NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2012-2013 IC BUS CE-C, HC, AND INTERNATIONAL 9400 AND CERTAIN MODEL YEAR 2011 THROUGH 2013 INTERNATIONAL DURASTAR, PAYSTAR, WORKSTAR, TRANSTAR, LONESTAR, PROSTAR, 9200, AND 9800, AND CERTAIN MODEL YEAR 2013 INTERNATIONAL 9900, VEHICLES, MANUFACTURED FROM DEC... Read more
Consequence
UNEXPECTED CONTINUOUS BRAKE APPLICATION CAN CAUSE THE BRAKES TO OVERHEAT AND LEAD TO A FIRE. UNEXPECTED CONTINUOUS BRAKE APPLICATION CAN CAUSE THE DRIVER TO LOSE CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH. ALSO, THE BRAKES MAY BE APPLIED WITHOUT ILLUMINATING THE BRAKE LIGHTS, FAILING ... Read more
Remedy
NAVISTAR WILL NOTIFY OWNERS, AND DEALERS WILL PROVIDE A TEMPORARY REPAIR UNTIL BENDIX DEVELOPS A PERMANENT REMEDY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 10, 2012. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.
Complaint Statistics
15 total complaints
3 fires 6 injuries
Top Reported Components
| Component | Complaints |
|---|---|
| ENGINE | 4 |
| ELECTRICAL SYSTEM | 2 |
| FUEL SYSTEM, DIESEL | 1 |
| ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE | 1 |
| VEHICLE SPEED CONTROL:CRUISE CONTROL | 1 |
| EXTERIOR LIGHTING | 1 |
| VEHICLE SPEED CONTROL | 1 |
| STRUCTURE:BODY | 1 |
| SUSPENSION | 1 |
| WHEELS | 1 |
ENGINE
Apr 10, 2019
Incident date: Apr 3, 2019
LOS INJECTORES TIENEN PROBLEMAS Y EL CAMION TIENE MENOS DE 75K MILLAS , SE PIENZA QUE HAY UN DESGASTE EN EL ARBOL DE LEBA PRODUCTO A AL PROBLEMA DEL INJECTOR , QUE CUESTA EL ORIGINAL 850.00 SEGUN EL DEALER
FUEL/PROPULSION SYSTEM
Apr 10, 2019
Incident date: Apr 3, 2019
LOS INJECTORES TIENEN PROBLEMAS Y EL CAMION TIENE MENOS DE 75K MILLAS , SE PIENZA QUE HAY UN DESGASTE EN EL ARBOL DE LEBA PRODUCTO A AL PROBLEMA DEL INJECTOR , QUE CUESTA EL ORIGINAL 850.00 SEGUN EL DEALER
ENGINE
Nov 29, 2018
Incident date: Nov 27, 2018
MY DRIVER WAS HEADING UP THE 93/95 RENO WHEN THE FRONT SEAL BROKE ON THE NAVISTAR MAXXFORCE ENGINE. MY TRACTOR RELEASED ALL OF THE OIL ONTO THE HIGHWAY. WHICH CAUSES ENGINE TO SHUT DOWN. I WAS TOLD BY THE TECH THAT THIS PROBLEM IS VERY COMMON WITH THIS PARTICULAR ENGINE I'VE ALREADY REPLACED TWO T... Read more
STRUCTURE:BODY
Jul 24, 2017
Incident date: Jul 18, 2017
WHILE IN MOTION THE ALUMINUN HANGARS ON MUD FLAP SPLASH GUARD ASSEMBLY BROKE OFF AT HANGAR SECURMENT AREA WEAKENED IN FRONT OF DUAL TIRES FAILED AT 465;000 MILES BOTH BRAKETS FAILED LEFT AND RIGHT AND FELL OFF ON TO ROAD, HANGAR, MUDFLAP ASSEMBLY DUE TO POOR TENSILE DESIGN OF ALUMINUM SERATED.. I R... Read more
SUSPENSION
Jul 24, 2017
Incident date: Jul 18, 2017
WHILE IN MOTION THE ALUMINUN HANGARS ON MUD FLAP SPLASH GUARD ASSEMBLY BROKE OFF AT HANGAR SECURMENT AREA WEAKENED IN FRONT OF DUAL TIRES FAILED AT 465;000 MILES BOTH BRAKETS FAILED LEFT AND RIGHT AND FELL OFF ON TO ROAD, HANGAR, MUDFLAP ASSEMBLY DUE TO POOR TENSILE DESIGN OF ALUMINUM SERATED.. I R... Read more
WHEELS
Jul 24, 2017
Incident date: Jul 18, 2017
WHILE IN MOTION THE ALUMINUN HANGARS ON MUD FLAP SPLASH GUARD ASSEMBLY BROKE OFF AT HANGAR SECURMENT AREA WEAKENED IN FRONT OF DUAL TIRES FAILED AT 465;000 MILES BOTH BRAKETS FAILED LEFT AND RIGHT AND FELL OFF ON TO ROAD, HANGAR, MUDFLAP ASSEMBLY DUE TO POOR TENSILE DESIGN OF ALUMINUM SERATED.. I R... Read more
ENGINE
Feb 24, 2017
Incident date: Feb 6, 2017
TL* THE CONTACT OWNS A 2013 INTERNATIONAL PROSTAR. WHILE DRIVING VARIOUS SPEEDS AND APPROACHING A STOP, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE RETURNED TO NORMAL AFTER IT WAS RESTARTED. THE FAILURE RECURRED ON VARIOUS OTHER OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOS... Read more
ENGINE
Feb 4, 2016
Incident date: Dec 19, 2015
TL* THE CONTACT OWNS A 2013 INTERNATIONAL PROSTAR. WHEN THE IGNITION WAS TURNED TO THE ON POSITION, THE VEHICLE REVVED WITHOUT WARNING. WHEN THE DRIVER ATTEMPTED TO TURN THE IGNITION OFF, THE VEHICLE FAILED AND THE ENGINE STALLED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALE... Read more
VEHICLE SPEED CONTROL
Feb 4, 2016
Incident date: Dec 19, 2015
TL* THE CONTACT OWNS A 2013 INTERNATIONAL PROSTAR. WHEN THE IGNITION WAS TURNED TO THE ON POSITION, THE VEHICLE REVVED WITHOUT WARNING. WHEN THE DRIVER ATTEMPTED TO TURN THE IGNITION OFF, THE VEHICLE FAILED AND THE ENGINE STALLED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALE... Read more
ELECTRICAL SYSTEM
Feb 19, 2014
Incident date: Feb 12, 2014
TL* THE CONTACT OWNS A 2013 INTERNATIONAL PROSTAR. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE DRIVER'S SIDE HEADLIGHT FAILED. UPON INSPECTION, IT WAS FOUND THAT THERE WAS A WIRING ISSUE. LATER, THE ENGINE COMPARTMENT BECAME ENGULFED IN FLAMES WHILE THE CONTACT WAS ASLEEP IN THE VEHI... Read more
Fire
2 injured
EXTERIOR LIGHTING
Feb 19, 2014
Incident date: Feb 12, 2014
TL* THE CONTACT OWNS A 2013 INTERNATIONAL PROSTAR. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE DRIVER'S SIDE HEADLIGHT FAILED. UPON INSPECTION, IT WAS FOUND THAT THERE WAS A WIRING ISSUE. LATER, THE ENGINE COMPARTMENT BECAME ENGULFED IN FLAMES WHILE THE CONTACT WAS ASLEEP IN THE VEHI... Read more
Fire
2 injured
ELECTRICAL SYSTEM
Feb 19, 2014
Incident date: Feb 17, 2014
TL* THE CONTACT OWNS A 2013 INTERNATIONAL PROSTAR. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE ENGINE COMPARTMENT SUDDENLY BURST INTO FLAMES. THE CONTACT PERSONALLY EXTINGUISHED THE FLAMES. THE FIRE AND POLICE DEPARTMENTS WERE SUMMONED. THE CONTACT AND PASSENGER SUFFERED FROM SMOKE I... Read more
Fire
2 injured
FUEL SYSTEM, DIESEL
Sep 9, 2013
Incident date: Sep 1, 2013
I HAVE A 2013 NAVISTAR PROSTAR THAT I'VE HAD TO TAKE INTO THE DEALER FOR VARIOUS REPAIRS. CURRENTLY, I HAVE EXPERIENCED A PROBLEM WITH THE DIESEL EXHAUST ENTERING THE CAB THAT HAS CAUSED MY EYES TO BURN, A LACK OF STRENGTH AND OTHER HEALTH ISSUES THAT ACCORDING TO MY DOCTOR, I SHOULD NOT BE DRIVIN... Read more
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
Sep 9, 2013
Incident date: Sep 1, 2013
I HAVE A 2013 NAVISTAR PROSTAR THAT I'VE HAD TO TAKE INTO THE DEALER FOR VARIOUS REPAIRS. CURRENTLY, I HAVE EXPERIENCED A PROBLEM WITH THE DIESEL EXHAUST ENTERING THE CAB THAT HAS CAUSED MY EYES TO BURN, A LACK OF STRENGTH AND OTHER HEALTH ISSUES THAT ACCORDING TO MY DOCTOR, I SHOULD NOT BE DRIVIN... Read more
VEHICLE SPEED CONTROL:CRUISE CONTROL
Sep 9, 2013
Incident date: Sep 1, 2013
I HAVE A 2013 NAVISTAR PROSTAR THAT I'VE HAD TO TAKE INTO THE DEALER FOR VARIOUS REPAIRS. CURRENTLY, I HAVE EXPERIENCED A PROBLEM WITH THE DIESEL EXHAUST ENTERING THE CAB THAT HAS CAUSED MY EYES TO BURN, A LACK OF STRENGTH AND OTHER HEALTH ISSUES THAT ACCORDING TO MY DOCTOR, I SHOULD NOT BE DRIVIN... Read more
Technical Service Bulletins, 2013 INTERNATIONAL PROSTAR
642 manufacturer communications from 317 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 110000 ELECTRICAL SYSTEM | 79 |
| 060000 ENGINE AND ENGINE COOLING | 66 |
| 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER | 61 |
| 060000 ENGINE (PWS) | 42 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 38 |
| 350000 EQUIPMENT | 34 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 26 |
| 118000 ELECTRICAL SYSTEM:SOFTWARE | 19 |
IK0400037
Apr 29, 2024
040000 SERVICE BRAKES, AIR
This document is to guide users to eliminate brake pedal rattle noise.
IK08000403
Apr 24, 2024
060000 ENGINE AND ENGINE COOLING
This document details the procedure that must be followed to ensure proper alternator troubleshooting.
IK0800482
Apr 24, 2024
110000 ELECTRICAL SYSTEM
This document covers battery diagnostics, maintenance and storage requirement.
IK0800407
Feb 21, 2024
110000 ELECTRICAL SYSTEM
Starter Diagnostics and warranty claim procedure; all engines EXCLUDING Cummins ISB engine with Allison transmission or PSI engine.
IK0800407
Feb 21, 2024
060000 ENGINE AND ENGINE COOLING
Starter Diagnostics and warranty claim procedure; all engines EXCLUDING Cummins ISB engine with Allison transmission or PSI engine.
IK0200013
Feb 21, 2024
020000 SUSPENSION
Suggested alignment target values when performing a vehicle axle alignment.
IK0200013
Feb 21, 2024
010000 STEERING
Suggested alignment target values when performing a vehicle axle alignment.
IK0800351
Nov 21, 2023
110000 ELECTRICAL SYSTEM
J1939 Data Link Source Address Information
IK1201476
Oct 18, 2023
060000 ENGINE AND ENGINE COOLING
Rebuilding Cylinder Heads on Certain MaxxForce 11/13, N13, and A26 engines; 2010 to present.
IK0300010
Sep 29, 2023
020000 SUSPENSION
Diagnosis of chassis wander complaints.
IK0300010
Sep 29, 2023
010000 STEERING
Diagnosis of chassis wander complaints.
IK0400040
Sep 26, 2023
030000 BRAKES (PWS)
General Wheel Speed Sensor Troubleshooting
IK2600069
Sep 7, 2023
060000 ENGINE AND ENGINE COOLING
How to request a horsepower quote; all International and Cummins engines
IK0800351
Aug 14, 2023
110000 ELECTRICAL SYSTEM
J1939 Data Link Source Address Information
IKo800080
Aug 14, 2023
110000 ELECTRICAL SYSTEM
J1939 Data Link Troubleshooting
IK1201391
Jul 19, 2023
060000 ENGINE AND ENGINE COOLING
Snap-On torque wrench requirement for all big bore engine connecting rod bolts; A26, MaxxForce 13, N13 engines
IK1201466
May 18, 2023
060000 ENGINE AND ENGINE COOLING
New air compressor incorporates an oil feed dowel O-ring. Only models equipped with 2010 and newer MaxxForce 11/13 engines, all N13, and A26 engines
IK1201466
May 18, 2023
040000 SERVICE BRAKES, AIR
New air compressor incorporates an oil feed dowel O-ring. Only models equipped with 2010 and newer MaxxForce 11/13 engines, all N13, and A26 engines
IK1201466
Apr 11, 2023
060000 ENGINE AND ENGINE COOLING
New Air compressor Incorporates an oil feed dowel O-ring; only models built with MaxxForce 11/13, N13, or A26 Engines
IK1201466
Apr 11, 2023
040000 SERVICE BRAKES, AIR
New Air compressor Incorporates an oil feed dowel O-ring; only models built with MaxxForce 11/13, N13, or A26 Engines
IK0800407
Mar 15, 2023
110000 ELECTRICAL SYSTEM
Starter diagnostics and warranty claim procedure for all engines and all chassis EXCLUDING vehicles equipped with PSI engines or Cummins ISB engine with Allison transmissions
IK0800407
Mar 15, 2023
060000 ENGINE AND ENGINE COOLING
Starter diagnostics and warranty claim procedure for all engines and all chassis EXCLUDING vehicles equipped with PSI engines or Cummins ISB engine with Allison transmissions
IK1201476
Mar 15, 2023
060000 ENGINE AND ENGINE COOLING
Rebuilding cylinder heads on certain EPA 2010 MaxxForce 11/13, N13, and A26 Engines
IK1201476
Feb 16, 2023
060000 ENGINE AND ENGINE COOLING
Rebuilding Cylinder Heads on Certain International MaxxForce 11/13 engines and all International N13 and A26 engines
IK0800351
Nov 16, 2022
110000 ELECTRICAL SYSTEM
J1939 Data link source address information
IK1201237
Nov 3, 2022
060000 ENGINE AND ENGINE COOLING
Turbocharger oil supply tube retrofit; only models with 2010 emissions MaxxForce 11 and 13 engines and N13 engines
IK1201472
Sep 29, 2022
060000 ENGINE AND ENGINE COOLING
Pico Scope CCOS (Crankcase Separator Test)
IK0800605
Aug 23, 2022
110000 ELECTRICAL SYSTEM
PicoScope Test 5V & 12V Intermittent Open and Short circuit diagnostics
IK1201469
Aug 23, 2022
060000 ENGINE AND ENGINE COOLING
PicoScope Test One Channel RCT
IK0800611
Aug 23, 2022
110000 ELECTRICAL SYSTEM
PicoScope Wheel Speed Sensor Test
IK0800610
Aug 23, 2022
110000 ELECTRICAL SYSTEM
PicoScope Test Resistance and Ohmmeter
IK0800609
Aug 23, 2022
110000 ELECTRICAL SYSTEM
PicoScope Test for Datalink (CAN) Health Shorts & opens
IK0800607
Aug 23, 2022
110000 ELECTRICAL SYSTEM
PicoScope Test - Battery Loss of Charge - Parasitic Draw Test
IK1600133
May 25, 2022
162200 STRUCTURE:BODY:BUMPERS
Textured surfaces on painted plastic bumpers, chassis side skirts, and fender extendtions
IK1600136
May 25, 2022
160000 STRUCTURE
Primer recommendation for matching textured panels to smooth panels for field repairs
IK1600131
Mar 23, 2022
120000 EXTERIOR LIGHTING
Cab water leak troubleshooting tips; HX with steel cab only
IK1600131
Mar 23, 2022
160000 STRUCTURE
Cab water leak troubleshooting tips; HX with steel cab only
IK2600052
Mar 14, 2022
110000 ELECTRICAL SYSTEM
Calculating pulses per mile (speedometer setting); only models equipped with International engines
IK2600052
Mar 14, 2022
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
Calculating pulses per mile (speedometer setting); only models equipped with International engines
IK0800351
Feb 10, 2022
110000 ELECTRICAL SYSTEM
J1939 Data Link Source Address Information
IK0800351
Feb 10, 2022
350000 EQUIPMENT
J1939 Data Link Source Address Information
IK1201464
Dec 3, 2021
060000 ENGINE AND ENGINE COOLING
High Pressure Fuel Pump external leaks from weep hole. only trucks with 2010 MaxxForce 11/13L, all N13, or A26 engines
IK1201464
Dec 3, 2021
080000 FUEL SYSTEM, DIESEL
High Pressure Fuel Pump external leaks from weep hole. only trucks with 2010 MaxxForce 11/13L, all N13, or A26 engines
IK0800080
Nov 2, 2021
110000 ELECTRICAL SYSTEM
J1939 Data Link Troubleshooting
IK1000003
Nov 2, 2021
010000 STEERING
Power Steering Diagnostics Flow / Pressure Specifications For Power Steering Gears and Power Steering Pumps
IK2600251
Oct 19, 2021
060000 ENGINE AND ENGINE COOLING
How to obtain As built parameter list
IK1201299
Sep 30, 2021
060000 ENGINE AND ENGINE COOLING
Engine Oil Capacities. All International electronic engines 1994 to present and Cummins ISB, ISM, or ISX engines
IK1201299
Sep 30, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
Engine Oil Capacities. All International electronic engines 1994 to present and Cummins ISB, ISM, or ISX engines
IK1201458
Sep 23, 2021
060000 ENGINE AND ENGINE COOLING
Oil leaks at the Bottom of the Oil Filter Module; Only International A26, N13, or 2010 and newer 11 and 13 engines
IK1201458
Sep 23, 2021
350000 EQUIPMENT
Oil leaks at the Bottom of the Oil Filter Module; Only International A26, N13, or 2010 and newer 11 and 13 engines
IK1201458
Sep 23, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
Oil leaks at the Bottom of the Oil Filter Module; Only International A26, N13, or 2010 and newer 11 and 13 engines
21504
Sep 8, 2021
060000 ENGINE AND ENGINE COOLING
This VER will involve reviewing diagnostic codes, inspection of the EGR valve / EGR System, and may include EGR valve replacement. Only models with 2012 model year MaxxForce 13 engines and are registered in California or have California app
21504
Sep 8, 2021
350000 EQUIPMENT
This VER will involve reviewing diagnostic codes, inspection of the EGR valve / EGR System, and may include EGR valve replacement. Only models with 2012 model year MaxxForce 13 engines and are registered in California or have California app
IK1201391
Aug 30, 2021
060000 ENGINE AND ENGINE COOLING
Snap-On torque wrench requirement for all big bore engine connecting rod bolt(s).
IK1600131
Aug 10, 2021
160000 STRUCTURE
Cab water leak troubleshooting tips
IK0400040
Jul 19, 2021
030000 SERVICE BRAKES, HYDRAULIC
General wheel speed sensor troubleshooting
IK0400040
Jul 19, 2021
040000 SERVICE BRAKES, AIR
General wheel speed sensor troubleshooting
IK0700112
Jun 4, 2021
060000 ENGINE AND ENGINE COOLING
Aftertreatment Clamp Corrosion; Single Can Aftertreatment Systems
IK1900259
May 3, 2021
160000 STRUCTURE
Day cab roof air deflector causing loud vibration noise at highway speed
IK0500038
Mar 15, 2021
010000 STEERING
Steering Shake, Shimmy, Shudder, Wobble, Steering Vibration; only models built with 14K weight rated axles or lower
IK0200013
Mar 4, 2021
020000 SUSPENSION
Suggested alignment target values when performing a vehicle axle alignment
IK2600128
Mar 4, 2021
060000 ENGINE AND ENGINE COOLING
A26, N13, and 2010 EPA MaxxForce 11 and 13 engine Auxiliary Programable Parameters
IK2600128
Mar 4, 2021
180000 VEHICLE SPEED CONTROL
A26, N13, and 2010 EPA MaxxForce 11 and 13 engine Auxiliary Programable Parameters
IK1500074
Nov 17, 2020
060000 ENGINE AND ENGINE COOLING
Fuel Filters, Winter Additives, and Blending Fuels for CumminsA? Engines
IK1500074
Nov 17, 2020
080000 FUEL SYSTEM, DIESEL
Fuel Filters, Winter Additives, and Blending Fuels for CumminsA? Engines
IK1500074
Nov 17, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Fuel Filters, Winter Additives, and Blending Fuels for CumminsA? Engines
IK1500074
Nov 17, 2020
092300 FUEL SYSTEM, OTHER:FUEL FILTER
Fuel Filters, Winter Additives, and Blending Fuels for CumminsA? Engines
IK1600233
Oct 9, 2020
160000 STRUCTURE
Cab Lean Concern
IK1600233
Oct 9, 2020
350000 EQUIPMENT
Cab Lean Concern
IK1600233
Oct 9, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
Cab Lean Concern
IK1400005
Aug 25, 2020
350000 EQUIPMENT
Driveline Information Center and Troubleshooting Procedures
IK1400005
Aug 25, 2020
060000 ENGINE (PWS)
Driveline Information Center and Troubleshooting Procedures
IK0800504
Aug 3, 2020
100000 POWER TRAIN
Repair Procedures for Vehicles Struck by Lightning
IK0800504
Aug 3, 2020
110000 ELECTRICAL SYSTEM
Repair Procedures for Vehicles Struck by Lightning
IK0800504
Aug 3, 2020
060000 ENGINE (PWS)
Repair Procedures for Vehicles Struck by Lightning
IK0800284
Jul 28, 2020
060000 ENGINE AND ENGINE COOLING
Ambient Air Temperature (AAT) Sensor Faults/Location/Diagnostics
IK0800284
Jul 28, 2020
110000 ELECTRICAL SYSTEM
Ambient Air Temperature (AAT) Sensor Faults/Location/Diagnostics
IK0800284
Jul 28, 2020
350000 EQUIPMENT
Ambient Air Temperature (AAT) Sensor Faults/Location/Diagnostics
IK0800284
Jul 28, 2020
118000 ELECTRICAL SYSTEM:SOFTWARE
Ambient Air Temperature (AAT) Sensor Faults/Location/Diagnostics
IK1201198
Jul 7, 2020
060000 ENGINE AND ENGINE COOLING
MaxxForce 15L Engine Oil Leaks; an aid in repairing engine oil leaks on the MaxxForce 15L engine.
IK1600186
Jul 6, 2020
060000 ENGINE AND ENGINE COOLING
Cab Odor Service Plan Information; only models equipped with EPA 2010 or later MaxxForce 11 or MaxxForce 13 engines
IK1900022
Jun 18, 2020
061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION
A/C Refrigerant and Oil Capacities
IK1600258
Mar 26, 2020
150000 SEAT BELTS
Cleaning and Disinfecting Trucks and Buses
IK1600258
Mar 26, 2020
170000 LATCHES/LOCKS/LINKAGES
Cleaning and Disinfecting Trucks and Buses
IK1600258
Mar 26, 2020
220000 SEATS
Cleaning and Disinfecting Trucks and Buses
IK1600258
Mar 26, 2020
350000 EQUIPMENT
Cleaning and Disinfecting Trucks and Buses
IK1600258
Mar 26, 2020
980000 UNKNOWN OR OTHER
Cleaning and Disinfecting Trucks and Buses
IK0800080
Feb 27, 2020
110000 ELECTRICAL SYSTEM
J1939 Data Link Troubleshooting
IK0400159
Jan 13, 2020
030000 SERVICE BRAKES, HYDRAULIC
Bendix EC80 Blank Module Replacement Program; This document will guide the user through selecting the correct ABS module when it has been determined a replacement is needed. Only Models with EC-80 ABS Controller
IK1900198
Dec 19, 2019
110000 ELECTRICAL SYSTEM
MaxxPower No Idle Battery-Powered A/C System Diagnostic Guide; Only sleeper cab models with feature code 16UZL
IK0800364
Nov 26, 2019
060000 ENGINE AND ENGINE COOLING
Stand Alone Real Time (SART) Module Diagnostics. Only 2010 and later models equipped with MaxxForceA? 11/13/15 engines or N13 with feature 0508051
IK1500085
Nov 26, 2019
080000 FUEL SYSTEM, DIESEL
LT / ProStar Fuel Tank Unable to Fill; only sleeper models
IK0700097
Oct 29, 2019
060000 ENGINE AND ENGINE COOLING
NEW Ultrasonic DEF Head Unit; All SCR vehicles
IK0800444
Oct 17, 2019
350000 EQUIPMENT
Driver Information Display (VIS/DID) screen fails to boot up.
IK0800444
Oct 17, 2019
110000 ELECTRICAL SYSTEM
Driver Information Display (VIS/DID) screen fails to boot up.
IK1500085
Oct 14, 2019
080000 FUEL SYSTEM, DIESEL
LT / ProStar Fuel Tank Unable to Fill; only sleeper models
IK0800284
Oct 2, 2019
060000 ENGINE AND ENGINE COOLING
Ambient Air Temperature (AAT) Sensor Faults/Location/Diagnostics
IK0500038
Sep 18, 2019
010000 STEERING
Steering Shake, Shimmy, Shudder, Steering Vibration. Only models with14k front weight rated axles and below
IK1201299
Sep 9, 2019
060000 ENGINE AND ENGINE COOLING
Oil Capacities; All Electronic International Engines 1994 - Present. Cummins ISB, ISM & ISX
IK1400023
Jul 15, 2019
020000 SUSPENSION
Suspension Lean Diagnostics; All models
Showing 100 of 642 bulletins.
NHTSA Safety Investigations, INTERNATIONAL PROSTAR
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE15013
Opened: Apr 17, 2015 , Closed: Dec 4, 2015
Accelerator Pedal Fails to Return
The Office of Defects Investigations (ODI) opened Preliminary Evaluation (PE15-013) on 2012-2013 model year (MY) Navistar Prostar vehicles for throttle pedals failing to return to the idle position after being depressed.EWR field reports supplied by Navistar describe the non-returning throttle pedal... Read more
PE14029
Opened: Sep 11, 2014 , Closed: Feb 27, 2015
Headlight failures/fires
This investigation was opened based on a consumer complaint alleging a headlight fire on a MY 2013 International Prostar.A fire cause and origin report accompanied the complaint and placed the origin at the headlight assembly but did not confirm the first material ignited.The complainant reported tw... Read more
EQ13002
Opened: May 28, 2013 , Closed: Jun 18, 2013
Brake S-Cam Tube Bracket Failure
BACKGROUNDIn a letter dated January 15, 2012, Navistar, Inc. (Navistar) notified the NHTSA that it had decided a defect exists in certain Model Year 2012 and 2013 International brand ProStar and TranStar commercial trucks, manufactured from August 1, 2011 through June 12, 2012, and equipped with bra... Read more
INTERNATIONAL PROSTAR - All Years Overview
Complete safety history for the INTERNATIONAL PROSTAR across all model years (2002, 2022).
131
Total Recalls
54
Total Complaints
3
Investigations
3
Reported Crashes
4
Reported Fires
0
Reported Deaths
INTERNATIONAL PROSTAR - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2022 | 1 | 0 | View |
| 2019 | 3 | 0 | View |
| 2018 | 6 | 0 | View |
| 2017 | 9 | 1 | View |
| 2016 | 8 | 0 | View |
| 2015 | 7 | 0 | View |
| 2014 | 10 | 5 | View |
| 2013 (current) | 18 | 15 | |
| 2012 | 18 | 10 | View |
| 2011 | 15 | 6 | View |
| 2010 | 10 | 11 | View |
| 2009 | 9 | 4 | View |
| 2008 | 9 | 2 | View |
| 2007 | 3 | 0 | View |
| 2006 | 1 | 0 | View |
| 2005 | 1 | 0 | View |
| 2004 | 1 | 0 | View |
| 2003 | 1 | 0 | View |
| 2002 | 1 | 0 | View |