2000 GMC SIERRA

12 recalls, 557 complaints - 275 TSBs

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

42,540 vehicles affected

Manufacturer: DOPE, INC.

EQUIPMENT:ELECTRICAL

Defect Description

CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

Consequence

IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.

Remedy

ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

175 vehicles affected

Manufacturer: CEQUENT ELECTRICAL PRODUCTS

STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS

Defect Description

CERTAIN PICKUP TRUCKS HAVE GALVANIZED-BRAIDED-STEEL TAILGATE SUPPORT CABLES USED TO SUPPORT THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION. OVER TIME THESE CABLES CAN CORRODE AND FRACTURE WHEN LOADS ARE APPLIED TO THEM.

Consequence

IF ONE CABLE FRACTURES, THE REMAINING CABLE MAY RETAIN THE TAILGATE IN A HORIZONTAL POSITION. IF BOTH CABLES FRACTURE, THE TAILGATE WOULD DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER. IF ANYONE IS SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED, THEY ... Read more

Remedy

DEALERS WILL REPLACE THE GALVANIZED SUPPORT CABLES WITH STAINLESS STEEL SUPPORT CABLES. IN ADDITION, DEALERS ARE TO INSPECT THE TAILGATE HINGE AND REPLACE IT, IF NECESSARY. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

805,368 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

Defect Description

CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAR... Read more

Consequence

THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.

Remedy

DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SI... Read more

1,353,718 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

PARKING BRAKE

Defect Description

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.

Consequence

IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.

Remedy

DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT ... Read more

90,242 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

POWER TRAIN:DRIVELINE:DRIVESHAFT

Defect Description

SOME PICKUP TRUCKS, VANS, AND SPORT UTILITY VEHICLES EQUIPPED WITH A HYDRAULIC PUMP DRIVESHAFT THAT CAN FRACTURE, RESULTING IN IMMEDIATE LOSS OF HYDRAULIC POWER STEERING ASSIST. ON CERTAIN VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, THE SAME CONDITION CAN RESULT IN LOSS OF POWER ASSIST FOR BRA... Read more

Consequence

AN INOPERATIVE PUMP CAN CAUSE INCREASED STEERING EFFORT, AND IN HYDRO-BOOST EQUIPPED VEHICLES ALSO INCREASED BRAKING EFFORT, BUT DOES NOT COMPLETELY ELIMINATE THE ABILITY TO STEER OR SLOW THE VEHICLE.

Remedy

DEALERS WILL REPLACE THE HYDRAULIC PUMP. THE CAMPAIGN BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

98,221 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

EQUIPMENT

Defect Description

AFTERMARKET PICKUP TRUCK OVER-THE-RAIL BEDLINERS MANUFACTURED FOR INSTALLATION ON 1999-2004 CHEVROLET SILVERADO AND GMC SIERRA PICKUP TRUCKS. THE TOGGLE WING ASSEMBLY USED TO ATTACH THE BEDLINER TO THE TRUCK BED IS NOT ENGAGING FULLY IN THE STAKE POCKET OF THE PICKUP TRUCK.

Consequence

THE BEDLINER CAN BECOME DETACHED FROM THE PICKUP WHILE IT IS MOTION, POSSIBLY ENDANGERING FOLLOWING MOTORISTS OR PEDESTRIANS.

Remedy

DURAKON WILL ISSUE A PRESS RELEASE IN ATTEMPT TO NOTIFY CUSTOMERS THAT COULD HAVE PURCHASED THE DEFECTIVE BEDLINER. IF YOU PURCHASED EITHER A DURAKON ALLSTAR OF PATRIOT OVERRAIL BEDLINER SINCE AUGUST 1, 2003, FOR 1999 TO 2004 CHEVROLET SILVERADO OR GMC SIERRA TRUCKS, OR PURCHASED ONE OF THESE P... Read more

8,000 vehicles affected

Manufacturer: DURAKON INDUSTRIES, INC.

STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS

Defect Description

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF TH... Read more

Consequence

ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF T... Read more

Remedy

DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT... Read more

3,662,211 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

Defect Description

ON CERTAIN PICKUP AND UTILITY TRUCKS, SOME OF THESE VEHICLES HAVE AN AIR BAG SENSING DIAGNOSTIC MODULE (SDM) WHICH CONTAINS AN ANOMALY THAT COULD RESULT IN THE DRIVER AND PASSENGER'S AIR BAG FAILING TO DEPLOY DURING CERTAIN FRONTAL CRASHES.

Consequence

IN A VEHICLE CRASH, FRONT SEAT OCCUPANTS MAY RECEIVE MORE SEVERE INJURIES.

Remedy

DEALERS WILL RECALIBRATE THE SDM ON THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN AUGUST 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC... Read more

525,254 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Defect Description

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES HAVE A CLEARANCE CONDITION BETWEEN THE FRONT RIGHT-HAND BRAKE PIPE AND THE BODY CROSS SILL THAT COULD DECREASE TO THE POINT OF ALLOWING CONTACT DURING THE LIFE OF THE VEHICLE. IF CONTACT OCCURS AND TH... Read more

Consequence

DURING BRAKING, THE PEDAL WILL BE LOWER THAN NORMAL AND STOPPING DISTANCES WILL BE LONGER. IF THIS OCCURS WHEN STOPPING DISTANCE IS LIMITED, A CRASH COULD OCCUR.

Remedy

DEALERS WILL INSPECT THE FRONT RIGHT-HAND BRAKE PIPE FOR WEAR. IF THERE ARE SIGNS OF WEAR, THIS SECTION OF THE BRAKE PIPE WILL BE REPLACED WITH A NEW DESIGNED BRAKE PIPE SECTION. IF THERE ARE NOT SIGNS OF WEAR ON THE BRAKE PIPE, THE DEALER WILL INSTALL A SPACER CLIP TO ENSURE SUFFICIENT CLEARANCE ... Read more

1,383,922 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

Defect Description

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1/2 TON LIGHT DUTY PICKUP TRUCKS. ON CERTAIN TRUCKS, FAILURE TO FOLLOW THE SERVICE PROCEDURE SET FORTH IN THE SERVICE MANUAL FOR REMOVAL OF THE... Read more

Consequence

THIS CONTACT WITH THE WHEEL RIM COULD, IN TIME, CAUSE THE BRAKE HOSE TO BECOME WORN TO THE POINT THAT BRAKE FLUID LEAKAGE COULD OCCUR. IF THIS OCCURRED, LOSS OF FRONT BRAKES IS POSSIBLE.

Remedy

DEALERS WILL ATTACH A NOTICE LABEL TO THE FRONT BRAKE HOSES STATING THAT THE CALIPERS MUST BE SUPPORTED WHEN REMOVED.

777,873 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

Defect Description

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 4-WHEEL DISC BRAKES. SOME OF THESE VEHICLES HAVE AN ANTILOCK BRAKE SYSTEM (ABS) MOTOR CONTAINING AN OUT-OF-SPECIFICATION SPRING CLIP. THIS CLIP COULD ALLOW THE MOTOR BEARING TO BECOME MISALIGNED. IF MISALIGNMENT OCCURS, EVENTUALLY THE ... Read more

Consequence

THE BASE BRAKES WOULD REMAIN FULLY FUNCTIONAL, BUT THE DYNAMIC REAR PROPORTIONING (DRP) SYSTEM, WHICH OPTIMIZES FRONT TO REAR BRAKE BALANCE, WOULD BECOME INOPERATIVE.

Remedy

DEALERS WILL REPLACE THE BRAKE PRESSURE MODULE VALVE ASSEMBLY.

10,674 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

Complaint Statistics

557 total complaints 56 crashes 3 fires 39 injuries 4 deaths

Top Reported Components

Component	Complaints
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	112
SERVICE BRAKES, HYDRAULIC	29
SERVICE BRAKES	28
TIRES	16
STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS	15
POWER TRAIN:AUTOMATIC TRANSMISSION	14
VEHICLE SPEED CONTROL	13
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR	12
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL	12
AIR BAGS:FRONTAL	12

Incident date: Mar 17, 2025

ABS module failed in July 2024 Subsequently, ABS, Electronic Stability Control, and Cruise Control are not operating. BRAKE light also remains lit on dash panel. ABS module is currently not available from Ram. Expected date is continually pushed further and further into the future. Meanwhile, truck ... Read more

Incident date: Mar 17, 2025

Incident date: Nov 2, 2015

MY PICKUP TRUCK WAS IN MOTION WHEN DRIVING ON A CITY STREET I HAD TO SLOW DOWN. THE BRAKE-PETAL WENT ALMOST COMPLETELY TO THE FLOOR. I ALMOST HIT THE VEHICLE IN FRONT OF ME WHILE TRYING TO STOP. AFTER PULLING TO THE SIDE OF STREET I CHECKED UNDER THE TRUCK AND DISCOVERED THAT THE REAR METAL BRAKE... Read more

Incident date: Jun 19, 2015

WHILE TOWING MY BOAT I EXPERIENCED BRAKE FAILURE. THE PEDAL WENT TO THE FLOOR WITH NO PRESSURE. BRAKE WARNING LIGHT DID NOT COME ON. WE WERE ON A DIRT ROAD WITH NO TRAFFIC AND WERE ABLE TO STOP WITHOUT INCIDENT. AFTER INSPECTING THE BRAKE LINES A LEAK WAS FOUND IN ONE OF THE LINES UNDER THE DRIV... Read more

Incident date: Apr 1, 2010

THE BRAKE LINES HAVE ROTTED OUT AND FAILED IN TRAFFIC MULTIPLE TIMES WITHOUT NOTICE. ALSO THE LEAF SPRING HANGERS ROTTED AND BROKE. THE REAR BUMPER IS A RUSTED MESS. THE UNDERCARRIAGE OF THE TRUCK LOOKS LIKE SOMETHING THAT WAS WASHED ASHORE. HEAVY DUTY ROT. THE BODY AND CAB INSIDE STILL LOOK NEW. SO... Read more

Incident date: Jan 26, 2015

BRAKES FAILED UNEXPECTEDLY. THE PEDAL WENT ALL THE WAY TO THE FLOOR AND BARELY SLOWED DOWN THE TRUCK AT ALL. THIS WAS DUE TO A BRAKE LINE THAT RUSTED THROUGH. THE REPAIR WAS $765. HAD I BEEN IN AN AREA WITH HIGHER TRAFFIC THERE WOULD HAVE BEEN AN ACCIDENT. *TR

Incident date: Jan 5, 2015

BRAKE LINE RUSTED THRU CAUSING THE TRUCK TO LOSE BRAKES ENTIRELY. THIS VEHICLE HAS NEVER BEEN OUT OF FLORIDA, AND I AM THE ORIGINAL OWNER SINCE NEW. NEVER DRIVEN ON SALTY WINTER ROADS OR SNOW. *TR

Crash

Incident date: Oct 20, 2014

MY 2000 GMC SIERRA 1500 PICKUP, WHICH HAS SPENT ITS ENTIRE LIFE IN VIRGINIA, LOST ITS BRAKES WHILE I WAS TOWING A DUAL-AXLE TRAILER AND BOAT. THANKS TO GOD'S PROTECTION, THIS HAPPENED RIGHT AS MY MADE MY FINAL STOP RIGHT IN FRONT OF MY HOUSE, SO I WAS BARELY MOVING. HAD THIS HAPPENED JUST MOMENTS EA... Read more

Incident date: Sep 5, 2014

WAS DRIVING WITH 3 OF MY CHILDREN TO A FOOTBALL PRACTICE. WAS ON MO STATE HWY 70 DOING APPROX. 60MPH. AN INCIDENT OCCURRED AHEAD OF ME WHICH RESULTED IN AN IMMEDIATE SLOW DOWN. HIT MY BRAKES HARD(LIKE ALL OTHER VEHICLES AROUND ME) AND BRAKE PEDAL WENT TO FLOOR AND TRUCK LOST AT LEAST 90PCT OF BRAKI... Read more

Incident date: Aug 14, 2014

DROVE MY SON TO FOOTBALL PRACTICE PARK TRUCK IN SCHOOL PARKING LOT ABOUT 1 HR LATER FAN BOWER MOTOTR CAUGHT FIRE BURNED UP THE DASH ,WINSHELD FIRE DEPARTMENT CAME PUT IT OUT. *TR

Fire

Incident date: Jul 8, 2014

TRUCK WAS PARKED. WENT TO PUT IT INTO DRIVE AND STEPPED ON THE BRAKE PEDAL. THE PEDAL WENT TO THE FLOOR. THE STEEL BRAKE LINE BACK BY THE DRIVER REAR WHEEL RUPTURED. ON CLOSER INSPECTION, I WILL HAVE TO REPLACE ALL BRAKE LINES AS THEY ARE SO RUSTY AND CORRODED. IT IS A SAFETY ISSUE. I WAS FORTUNATE ... Read more

Incident date: Jul 1, 2011

PULLED ON TO ROAD WHILE TOWING BOAT AND COULD NOT STOP. BRAKE PEDDLE TO FLOOR. USED EMERGENCY BRAKE TO STOP. REPLACED SOME LINES AND PROBLEM RE-OCCURRED. *JS

Incident date: May 15, 2014

AS I WAS APPROACHING A STOP SIGN AT 30 MPH, I WENT TO APPLY THE BRAKES AND THE BRAKE PEDAL WENT TO THE FLOOR BOARD. I PUMPED THE BRAKES A COUPLE TIMES TO REGAIN PEDAL PRESSURE WITH NO LUCK. I WAS LUCKY THAT NO OTHER CARS WERE AT THE INTERSECTION OR ELSE THERE WOULD HAVE BEEN AN ACCIDENT FOR SURE. ... Read more

Incident date: Oct 28, 2011

WHILE DRIVING IN TOWN I NOTICED MY BRAKE PEDAL WAS FEELING SOFT, THE NEXT TIME I DEPRESSED THE PEDAL, IT WENT ALL THE WAY TO THE FLOOR AND THE VEHICLE WOULD NOT STOP AT ALL. I COASTED INTO A PARKING LOT AND USED THE EMERGENCY BRAKE TO COMPLETE THE STOP. I LOOKED UNDER THE VEHICLE BY THE DRIVERS SIDE... Read more

Incident date: Feb 10, 2014

I OWN A 2000 GMC SIERRA CREW CAB SHORT BOX 4 BY 4. I WAS DRIVING DOWN THE ROAD AND HEARD A GRINDING SOUND, SO I THOUGHT TO LIMP IT HOME. BAD IDEA, I WAS THE TWO BOLTS THAT HOLD YOUR CALIPER ON, SO THAT IS YOUR WHOLE BRAKE SYSTEM, WELL IT MADE MY WHEEL LOCK UP AND CAUSED ME TO LOOSE CONTROL AND HIT T... Read more

Crash

Incident date: Sep 24, 2013

THE BRAKES IN MY GMC PICKUP TRUCK FAILED DUE TO SEVERELY RUSTED STEEL BRAKE LINES. TWO LINES BURST , ONE AFTER THE OTHER , AS I PUMPED THE BRAKE PEDAL TO STOP THE TRUCK. AN INSPECTION REVEALED EXTENSIVE AND PREMATURE RUST THROUGHOUT THE BRAKE LINE SYSTEM, REQUIRING REPLACEMENT OF ALL OF THE BRAKE... Read more

Incident date: Mar 21, 2013

TRAVELLING TO WORK ONE MORNING ON A BUSY, WELL TRAVELED ROAD I WAS APPROACHING A TRAFFIC LIGHT. I WAS DRIVING APPROXIMATELY 40 MPH. THERE WAS A FEW CARS AHEAD OF ME AND WE ALL HAD TO STOP FOR THE RED LIGHT. AS I APPLIED THE BRAKE AND STARTED TO SLOW DOWN SUDDENLY THE BRAKE PEDAL WHEN TO THE FLOOR AN... Read more

Incident date: Aug 2, 2013

BRAKE LINE RUSTED OUT. *TR

Incident date: Aug 3, 2012

BRAKE LINES RUSTED OUT. *TR

Incident date: Jul 30, 2013

WHILE DRIVING WEST ON CENTRAL AVENUE IN PEDAL, I APPLIED THE BRAKE PEDAL TO SLOW THE VEHICLE TO MAKE A RIGHT TURN ONTO STEVENS STREET. I FELT NO RESISTANCE AND LOOKED DOWN TO SEE IF I HAD MISSED THE BRAKE PEDAL SOMEHOW, BUT IT HAD PUSHED WITH NO RESISTANCE TO THE FLOOR. PUMPING THE BRAKES REPEATEDLY... Read more

Incident date: Jul 12, 2013

BRAKE LINE LEAK FROM RUST HOLE IN BRAKE LINE BELOW DRIVERS SIDE DOOR. ALMOST HIT THE VEHICLE AHEAD OF ME. I HAVE GM VEHICLES THAT ARE MUCH OLDER THAN THIS ONE AND NEVER HAD THIS HAPPEN BEFORE. 1977 CHEVY, ETC. I FEEL A RECALL IS IN ORDER, I HAVE READ ON THE INTERNET ABOUT OTHER PEOPLE HAVING THE SAM... Read more

Incident date: Apr 16, 2013

TL* THE CONTACT OWNS A 2000 GMC SIERRA. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE ABS AND HYDRAULIC BRAKES FAILED WITHOUT WARNING. THE CONTACT WAS ABLE TO TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSIS BUT THE DEALER WAS UNABLE TO DIAGNOSE THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED AND THE... Read more

Incident date: Feb 9, 2010

EXHAUST MANIFOLD BOLTS FRONT AND BACK ON BOTH SIDES BROKE OFF , THIS IS COMMON PROBLEM ON THIS TRUCK. *TR

Incident date: Nov 22, 2012

REPEATED BRAKE FAILURES DUE TO CORRODED BRAKE LINES. *TR

Incident date: Oct 11, 2012

AFTER PUTTING THE VEHICLE INTO REVERSE I WENT TO STOP AND THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR INDICATING A LOSS IN BRAKE FLUID PRESSURE. I LOOKED UNDER THE TRUCK TO INVESTIGATE THE MATTER AND FOUND BRAKE FLUID EVERYWHERE AND A HIGHLY CORRODED BRAKE LINE JUST TO THE REAR OF THE ABS HYDRAULI... Read more

Incident date: Sep 14, 2012

DRIVING TRUCK IN TOWN APPLIED BRAKES AT A STOPLIGHT BRAKE PEDAL WENT STRAIGHT TO THE FLOOR. NO BRAKES AT ALL HAD TO GO THRU THE RED LIGHT AND AROUND 3 CARS IN FRONT OF ME, RUBBED THE CURB TO GET THE TRUCK TO STOP. RUST AND CORROSION ON THE STEEL REAR BRAKE LINES CAUSED LINE FAILURE. *TR

Incident date: Sep 14, 2012

Incident date: Sep 2, 2009

THE FIRST INCIDENT I WAS PULLING OUT OF A PARKING SPOT AND NOTICED MY BRAKES WERE GONE. THE PEDAL WENT ALL THE WAY DOWN TO THE FLOOR. GOT OUT OF THE VEHICLE AND THERE WAS BRAKE FLUID LEAKING FROM UNDERNEATH THE TRUCK. TOOK IT TO THE MECHANIC AND WAS TOLD THE BRAKE LINE WAS RUSTED. HAD IT REPAIR... Read more

Incident date: Aug 16, 2012

WHILE BACKING MY TRUCK UP TO ATTACH A TRAILER, I PRESSED ON THE BRAKE PEDAL AND IT WENT TO THE FLOOR. I HAD ABSOLUTELY NO BRAKING ABILITY. MY TRUCK RAN INTO THE TRAILER, CAUSING MINOR DAMAGE. UPON INSPECTION, IT IS EVIDENT THAT THERE IS A FAILURE OF THE BRAKE LINE THAT RUNS TO THE DRIVER'S SIDE R... Read more

Incident date: Aug 12, 2012

BRAKE LINES RUSTED THRU AND HAD COMPLETE BRAKE LOST. THE RUSTED LINES ARE AT THE ANTI-LOCK PART THAT CONTROLS THE ANTI-LOCK BRAKES NEXT TO THE FRAME. I HAVE HAD THIS TRUCK SINCE IT WAS NEW AND KEEP IT IN GREAT SHAPE. *TR

Incident date: Jun 13, 2012

TL* THE CONTACT OWNS A 2000 GMC SIERRA. WHILE DRIVING APPROXIMATELY 15 MPH, THE BRAKES WERE ENGAGED TO MAKE A TURN AND THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD ABNORMALLY. THE CONTACT WAS ABLE TO STOP THE VEHICLE AFTER APPLYING THE BRAKE PEDAL REPEATEDLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEA... Read more

Incident date: Jun 16, 2012

I WAS GOING TO GO TO THE STORE WITH MY TRUCK AND STEPPED ON THE BRAKE PEDAL AND IT WENT TO THE FLOOR. I LOOKED UNDER THE DOOR AND THE BRAKE FLUID WAS RUNNING ONTO THE DRIVEWAY AND THE BRAKE LINE WAS ALL RUSTY AND FAILED. I WAS GOING TO BE DRIVING ON THE HIGHWAY AT 65 MPH AND CON ONLY IMAGINE WHAT WO... Read more

Incident date: Jul 1, 2012

TL* THE CONTACT OWNS A 2000 GMC SIERRA 1500. THE CONTACT STATED THEY WERE TRAVELING 25 MPH AND THE FUEL TANK FAILED AND BEGAN TO LEAK GASOLINE. THE FIRE DEPARTMENT HAD TO COME OUT TO DISPOSE OF THE GASOLINE. THE TANK WAS CUT OFF AND SECURED BY THE FIRE DEPARTMENT. THE VEHICLE WAS DESTROYED BECAUSE... Read more

Incident date: Jul 1, 2012

I WAS DRIVING ALONG AND FELT A DRAGGING SENSATION AND SCRAPING NOISE. I PULLED THE TRUCK OVER, LOOKED UNDERNEATH EXPECTING TO SEE THE MUFFLER DRAGGING. I WAS SOMEWHAT SURPRISED TO SEE THE GAS TANK RESTING ON THE STREET. THERE WAS A SMALL AMOUNT OF GASOLINE LEAKING ONTO THE STREET. I CALLED AAA ... Read more

Incident date: Jun 16, 2012

I GOT INTO MY GMC APPLIED THE BRAKES BEFORE STARTING THE TRUCK AND ALL OF A SUDDEN THE BRAKES WENT TO THE FLOOR. I GOT OUT AND DISCOVERED FLUID DRIPPING FROM UNDER THE TRUCK, ON THE DRIVERS SIDE, ABOUT IN LINE WITH THE BACK OF THE DRIVERS SEAT. *TR

Incident date: Jun 14, 2012

I OWN A 2000 GMC SIERRA 2500 4WD. I BOUGHT THIS TRUCK NEW IN JUNE OF 2000. IN THE PAST YEAR, THE CORROSION ISSUES ARE BECOMING OVERWHELMING. YESTERDAY, A BRAKE LINE BLEW OUT WHILE DRIVING. THE BRAKE PEDAL WENT TO THE FLOOR AS I APPROACHED A STOP SIGN AT AN INTERSECTION WITH A STATE HIGHWAY. LUCKILY,... Read more

Incident date: Jun 14, 2012

Incident date: Jun 10, 2012

WHILE PULLING A SMALL ENCLOSED TRAILER AND GOING DOWN A HILL I EXPERIENCED A COMPLETE BRAKE FAILURE. I HAD ABSOLUTELY NOTHING FOR BRAKES. I ENDED UP GOING THROUGH A REDLIGHT AND MISSED ANY VEHICLES IN THE INTERSECTION, STARTED TO DOWNSHIFT TO SLOW MY SPEED. CROSSED OVER AN INTERSECTION FOR A BIKE TR... Read more

Incident date: May 4, 2012

WHILE POSITIONING MY GMC SIERRA PICKUP TO BACKUP MY UTILITY TRAILER THE BRAKES COMPLETELY FAILED. THE BRAKE PEDAL FELL COMPLETELY TO THE FLOOR WITH NO STOPPING CAPABILITY. BRAKE FLUID WAS FOUND SQUIRTING OUT OF A BURST OPEN METAL BRAKE LINE LOCATED ON A FRAME MEMBER UNDER THE AREA OF THE RADIATOR.... Read more

Incident date: Apr 16, 2012

TL* THE CONTACT OWNS A 2000 GMC SIERRA. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE DOOR HANDLES WERE INOPERABLE. THE CONTACT COULD NOT ENTER THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND NO REPAIRS WERE MADE. THE CURRENT AND FAILURE MILEAGES WERE 200,000.

Incident date: Mar 14, 2012

COMPLETE HYDRAULIC BRAKE FAILURE WITHOUT WARNING. CHECK ENGINE LIGHT ONLY CAME ON AFTER THE VEHICLE WAS STOPPED WITH THE EMERGENCY BRAKE. THE DEALER SAID THAT THE FRONT BRAKE HAD STOPPED WORKING SOMETIME AGO, ONLY THE REAR BRAKE HAD BEEN WORKING. THE DEALER "REPLACED REAR PADS AND ROTORS AND PARKING... Read more

Incident date: Jan 30, 2012

RUSTY, CORRODED BRAKE LINES HAS CAUSED TWO BRAKE FAILURES. *TR

Incident date: Jan 14, 2012

CORRODED HYDRAULIC BRAKE LINE RESULTED IN SUBSTANTIALLY REDUCED BRAKING. THIS FAILURE OCCURRED DURING A STOP WHICH REQUIRED HIGHER PEDAL PRESSURE THAN TYPICAL APPLICATION, CAUSING THE CORRODED LINE TO BURST.

Incident date: Nov 17, 2011

THE FRAME ON THE TRUCK IS CRACKED SEVERAL INCHES IN A COUPLE OF PLACES AND ROTTED. IT IS VERY THIN AND I WAS TOLD THERE WAS NOTHING SOLID TO WELD TO AND REPAIR IT. THEY SAID I WOULD HAVE TO HAVE THE FRAME REPLACED. THE TRUCK HAS JUST TURNED 100000 MILES. I HAVE HAD IT FOR SIX YEARS AND TAKE EXCELLE... Read more

Incident date: Nov 17, 2011

Incident date: Dec 11, 2011

THE LOWER HALF OF THE REAR GAS TANK STRAP HAS ROTTED OUT AND DISLODGED FROM THE UPPER HALF OF THE STRAP. THE FRONT STRAP ALSO HAS VISIBLE CORROSION. A VERY SERIOUS SITUATION. I WAS VERY FORTUNATE TO FIND THE LOWER HALF OF THE STRAP, AS I WAS MOVING FIREWOOD ON MY PROPERTY. I FEEL BLESSED THAT I ... Read more

Incident date: Jun 1, 2011

BRAKE LINE TO THE FRONT PASSENGER WHEEL BLEW APART CAUSING THE BRAKE FLUID TO LEAK OUT, AND DRAMATICALLY DECREASED THE STOPPING ABILITY OF THE VEHICLE. HAD THIS LINE REPLACED BY A LOCAL REPAIR SHOP, AND WAS NOTIFIED BY PERSONNEL THAT ALL OF THE LINES WERE IN BAD CONDITION, AND NEEDED TO BE REPLACED ... Read more

Incident date: Nov 9, 2011

NHTSA SHOULD BE OPENING INVESTAGATIONS CONCERNING THE BRAKE LINE CORROSION INCIDENTS. WE JUST PURCHASED THIS TRUCK LESS THAN A YEAR AGO, AND BRAKE FAILURE CAUSED US TO HAVE THIS IN THE SHOP FOR OVER A MONTH AND STILL HAVE NO TRUCK YET. THERE ARE ENOUGH COMPLAINTS ON THE INTERNET FOR THE NHTSA TO HAV... Read more

Incident date: Oct 22, 2011

I EXPERIENCED SUDDEN BRAKE FAILURE IN MY DRIVEWAY. THERE WAS NO WARNING LIGHT,JUST THE BRAKE PEDAL GOING TO THE FLOOR. MY MECHANIC LOOKED AT THE FAILED LINE AND SAID ALL MY LINES AND ABS UNIT WERE CORRODED AND NEEDED TO BE REPLACED. HE ALSO FOUND MY RIGHT REAR SPRING HANGER WAS RUSTED OFF AND THE SP... Read more

Showing 50 of 557 complaints.

Technical Service Bulletins, 2000 GMC SIERRA

275 manufacturer communications from 247 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
061000 ENGINE AND ENGINE COOLING:ENGINE	29
100000 POWER TRAIN	17
020000 SUSPENSION	12
980000 UNKNOWN OR OTHER	10
103000 POWER TRAIN:AUTOMATIC TRANSMISSION	9
061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	9
110000 ELECTRICAL SYSTEM	9
030000 SERVICE BRAKES, HYDRAULIC	8

022140 SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY

This technical bulletin provides a procedure to lube the rear leaf springs on vehicles with the condition of a squeak noise originating from the rear of the vehicle.

162500 STRUCTURE:BODY:TAILGATE

This Preliminary Information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables. Technician should not replace any parts for this concern. Please communicate to the customer

031000 SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

This Preliminary Information communication advises the technician that the Hydro-Boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.

353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician about vehicles that may have an issue when using Bluetooth voice recognition with an iPhone. Technician should work with the customer to insure the phone cont

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This informational bulletin provides information on Part Restriction and Ordering Process Information for OnStar Vehicle Communication Interface Modules (VCIM) (GMNA Only)

353000 EQUIPMENT:ELECTRICAL

This informational bulletin provides information on Part Restriction and Ordering Process Information for OnStar Vehicle Communication Interface Modules (VCIM) (GMNA Only)

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This informational bulletin provides information on a GM of Canada OnStar? cellular communication upgrade.

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Tech

110000 ELECTRICAL SYSTEM

353000 EQUIPMENT:ELECTRICAL

This informational bulletin provides information on communication with OnStar? module after Canadian cellular upgrade.

353000 EQUIPMENT:ELECTRICAL

This informational bulletin provides information on a GM of Canada OnStar? cellular communication upgrade.

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary Information communication provides information to the technician about vehicles that are travelling from Canada to the United States. While in the United States they are unable to receive Turn-by-Turn directions. Due to the

353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the cu

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

353000 EQUIPMENT:ELECTRICAL

034200 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

CHEVROLET/GMC/CADILLAC: ANYTIME HYDRAULIC BRAKE PIPES ASSEMBLY NEED REPLACING, PRE-FORMED AND PRE-FLARED BRAKE PIPES ARE AVAILABLE, EXCEPT REAR AXLE CROSSOVER PIPE. MODEL 1999-2007 SILVERADO, SIERRA, 2000-2006 ESCALADE MODELS, AVALANCHE,

034100 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

162510 STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS

162500 STRUCTURE:BODY:TAILGATE

131000 VISIBILITY:WINDSHIELD

This Preliminary Information communication provides information to the technician about the percentage of UV protection or tint offered by the windshield or side glass. Technician should be advised Windshield reduces UV rays down to 4% or l

171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

GM: THE FRONT OR REAR DOOR MAY NOT OPEN FROM THE INSIDE OR OUTSIDE HANDLE, THE DOOR WILL NOT UNLOCK WITH ANY METHOD. THE PROBABLY CAUSE AN INCORRECT INSTALLATION OF A HANDLE COMPONENT. *RM UPDATED ON 7/26/2013. ALL 2014 AND PRIOR GM PASS

354000 EQUIPMENT:MECHANICAL

This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp on, engine misfire, and/or engine noise. Technician may find Diagnostic Trouble Code

100000 POWER TRAIN

This Preliminary Information communication provides information to the technician about vehicles that may have a planetary gear whine noise in first and second gear. Technician should compare the noise to a like vehicle. Technician will nee

200000 WHEELS

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

190000 TIRES

030000 BRAKES (PWS)

This Preliminary Information communication advises the technician that the Hydro-Boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.

030000 SERVICE BRAKES, HYDRAULIC

This Preliminary Information communication advises the technician that the Hydro-Boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.

110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that have slip in forward ranges immediately after replacing the input housing. Technician will inspect the 3-4 clutches and the forward clutch

101000 POWER TRAIN:CLUTCH ASSEMBLY

151600 SEAT BELTS:FRONT:WARNING LIGHT/DEVICES

GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. *RM UPDATED 4/

150000 SEAT BELTS

221300 SEATS:FRONT ASSEMBLY:HEAD RESTRAINT

GENERAL MOTORS: INFORMATION PROVIDED BY BULLETIN FOR ALL 2012 AND PRIOR GENERAL MOTOR TRUCKS AND PASSENGER VEHICLES REGARDING THE ADJUSTABLE COMFORT AND CUSTOM UPHOLSTERY OF THE DRIVER AND THE PASSENGER HEAD RESTRAINT. *PE

980000 UNKNOWN OR OTHER

GM: INFORMATION ON FIXING MULTIPLE SITUATIONS RIGHT THE FIRST TIME. *RM

060000 ENGINE AND ENGINE COOLING

GM: THE SERVICE ENGINE SOON LIGHT IS ON, THERE IS ALSO A MISFIRE OR ENGINE NOISE. THERE ARE MULTIPLE POSSIBLE CAUSES. *RM

013200 STEERING:GEAR BOX:SHAFT PITMAN

BUICK/CADILLAC/CHEVROLET/GMC/OLDSMOBILE AND HUMMER: INFORMATION ON PITMAN ARM SHAFT SEAL SERVICE KIT. DO NOT REPLACE ENTIRE STEERING GEAR FOR PITMAN SEAL LEAK. TECHNICIANS HAVE BEEN REPLACING ENTIRE STEERING GEARS DUE TO NOT BEING ABLE TO

010000 STEERING

980000 UNKNOWN OR OTHER

SOME CUSTOMERS WHOSE VEHICLES ARE OPERATED IN DUSTY TYPE ENVIRONMENTS, SUCH AS FARMING OR MINING OFF-ROAD TYPE APPLICATIONS, MAY COMMENT ABOUT THE ILLUMINATION OF THE INSTRUMENT PANEL SES LIGHT, WITH DIAGNOSTIC TROUBLE CODE P0446 SET. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

GM: LOSS OF POWER HESITATES ON ACCELERATION. 4.3, 4.8, 5.3, 5.7 AND 6.0 ENGINES COUPLED WITH THE 4L60E OR 4L65E MAY EXPERIENCE A CONDITION OF HESITATES, MISSES OR LOSS OF POWER UNDER ACCELERATION. THE VEHICLE MAY OPERATE AS IF IT IS IN R

036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

ANTILOCK BRAKE (ABS) ACTIVATION AT LOW SPEEDS (CLEAN WHEEL SPEED SENSOR MOUNTING SURFACE). *TT UPDATED 10/23/09. *PE

103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

GMC: FLUID LEAK FROM TRANSMISSION OIL COOLER LINES DUE TO CORROSION. ALL 2000-2006 LIGHT DUTY TRUCKS EQUIPPED WITH THE LIGHT DUTY AUTOMATIC TRANSMISSION. *PE

091200 FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM

GMC: FUEL GAUGE FLUCTUATION IN PARK OR NEUTRAL, CAUSING THE LOW FUEL LIGHT TO ILLUMINATE. *PE

020000 SUSPENSION

SUSPENSION VIBRATION OR FRAME BEAMING AT 40 - 60 MPH. *KB UPDATED 8/25/08. *PE

012000 STEERING:COLUMN

CLUNKING NOISE UNDER HOOD AND CAN BE FELT IN STEERING WHEEL AND/OR STEERING COLUMN (REPLACE UPPER INTERMEDIATE STEERING SHAFT [I-SHAFT] ASSEMBLY). *PE

105500 POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

EATON LOCKING DIFFERENTIAL CHATTER SHUDDER NOISE ON TURNS, EQUIPPED WITH A LOCKING REAR DIFFERENTIAL RPO G80. *NJ UPDATED 7/17/2008. *PE

022000 SUSPENSION:REAR

EATON LOCKING DIFFERENTIAL CHATTER SHUDDER NOISE ON TURNS, EQUIPPED WITH A LOCKING REAR DIFFERENTIAL RPO G80. *NJ UPDATED 7/17/2008. *PE

193000 TIRES:BEAD

TIRE SLOWLY GOES FLAT AND/OR EXCESSIVE WHEEL VIBRATION CAUSED BY BEAD SPLITS (REPLACE WHEELS WITH NEW HEAVY DUTY RIM VERSION) *TT *AR UPDATED 4/11/08. *NJ

020000 SUSPENSION

TIRE SLOWLY GOES FLAT AND/OR EXCESSIVE WHEEL VIBRATION CAUSED BY BEAD SPLITS (REPLACE WHEELS WITH NEW HEAVY DUTY RIM VERSION) *TT *AR UPDATED 4/11/08. *NJ

022140 SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY

REAR LEAF SPRING SLAP OR CLUNK NOISE (REPLACE SPRING INSERTS) *TT UPDATED 10/18/07. *NJ

020000 SUSPENSION

REAR LEAF SPRING SLAP OR CLUNK NOISE (REPLACE SPRING INSERTS) *TT UPDATED 10/18/07. *NJ

046600 SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT

ABS LIGHT ON, DTC'S C0265, C0201, U1041 SET AND/OR LOSS OF COMMUNICATION WITH BRAKE MODULE. (REGROUND EBCM GROUND). *KB

010000 STEERING

REDUCED STEERING EFFORT (DIAGNOSE/REPLACE STEERING WHEEL POSITION SENSOR). *KB

061000 ENGINE AND ENGINE COOLING:ENGINE

MULTIPLE DRIVEABILITY SYMPTOMS OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE DUE TO CLOGGED FUEL INJECTORS. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

VARIOUS INTERMITTENT DRIVEABILITY CONDITIONS - HESITATION, LACK OF POWER, ETC. *TT

162500 STRUCTURE:BODY:TAILGATE

TAILGATE CABLE SLACK. THIS INCLUDES 1998-2006 CHEVROLET AND GMC FULL AND MID SIZE TRUCKS. *EH UPDATED. *KB

021244 SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY:U-BOLT, LEAF SPRING TO AXLE

LEFT FRONT AXLE SHAFT DIFFICULT TO REMOVE. AXLE DIFFERENTIAL LEAK SEAL SHAFT. *KB

020000 SUSPENSION

RATTLE/SQUEAK FROM FRONT OF VEHICLE. *TT *AR

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

ADVANCE SERVICE INFORMATION - EXHAUST SYSTEM POPPING/SNAPPING NOISE WHEN VEHICLE IS HOT, AT IDLE OR IMMEDIATELY AFTER VEHICLE IS SHUT OFF. *TT BULLETIN 03-06-05-008, DATED 11/01/2003 REPLACED. *TT

036100 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT ON, DIAGNOSTIC TROUBLE CODES (DTCS) C0265, C0201, U1041 SET AND/OR LOSS OF COMMUNICATION WITH BRAKE MODULE. *TT UPDATE. *TT

220000 SEATS

UNWANTED/LOOSE SEAT MOVEMENT. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

THE SERVICE ENGINE SOON LAMP IS ILLUMINATED, NO 3RD AND 4TH GEAR, THE TRANSMISSION DOES NOT SHIFT CORRECTLY, THE TRANSMISSION FEELS LIKE IT SHIFTS TO NEUTRAL OR A LOSS OF DRIVE OCCURS. *TT

046300 SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR

PRODUCT SAFETY RECALL REGARDING FRONT WHEEL SPEED SENSOR CORROSION. *TT

020000 SUSPENSION

REFERENCE GUIDE FOR THE TECHNICIAN TO UPGRADE A VEHICLE FROM FACTORY WHEELS AND TIRES TO 20 INCH WHEELS AND TIRES, WHICH ARE AVAILABLE THROUGH GMSPO. *TT

103400 POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

DIAGNOSIS OF CRACKED OR BROKEN TRANSMISSION CASE. *TT 2006 AND PRIOR CARS AND LIGHT DUTY TRUCKS. *TT

010000 STEERING

CONCERNS THAT CLUNK NOISE CAN BE HEARD COMING FROM UNDER THE HOOD ALSO FELT IN THE STEERING WHEEL. *TT UPDATED *EH GM ADMINISTRATIVE MESSAGE. *TT

200000 WHEELS

HANDLING CHARACTERISTICS OF VEHICLES WITH 20 INCH WHEEL/TIRE ASSEMBLIES INSTALLED. *TT

050000 PARKING BRAKE

LOW EFFORT PARKING BRAKE APPLY SYSTEM. *TT

135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

OUTSIDE REARVIEW MIRROR HOUSINGS COME LOOSE FROM BASE. *TT

020000 SUSPENSION

REVISED FRONT CASTER AND CAMBER ADJUSTMENT PROCEDURE. ORIGINAL NOT YET RECEIVED. *TT

060000 ENGINE AND ENGINE COOLING

REPLACEMENT OF CONNECTOR WHEN REPLACING FUEL TANK MODULE/FUEL PUMP MODULE. *TT

162000 STRUCTURE:BODY

PICKUP BOX SHEET METAL FRACTURE / DAMAGE WITH AFTERMARKET ACCESSORIES INSTALLED. *TT

015000 STEERING:HYDRAULIC POWER ASSIST SYSTEM

HYDRAULIC PUMP DRIVESHAFT THAT CAN FRACTURE RESULTING IN AN IMMEDIATE LOSS OF HYDRAULIC POWER STEERING ASSIST. MESSAGE TO CHEVROLET AND GMC DEALERS ABOUT UPCOMING CUSTOMER SATISFACTION PROGRAM 05001. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

CLUNK, BUMP OR SQUAWK WHEN VEHICLE COMES TO A COMPLETE STOP OR ACCELERATION FROM COMPLETE STOP. *YH UPDATE. *TT

050000 PARKING BRAKE

REAR PARKING BRAKE SHOE RETAINING SPRING CLIP SERVICE KIT FOR DRUM-IN-HAT (DIH) EQUIPPED VEHICLES. *TT UPDATE. *TT

040000 SERVICE BRAKES, AIR

REAR PARKING BRAKE SHOE RETAINING SPRING CLIP SERVICE KIT FOR DRUM-IN-HAT (DIH) EQUIPPED VEHICLES. *TT UPDATE. *TT

190000 TIRES

SPARE TIRE IS DIFFERENT SIZE THAN OTHER TIRES. THIS SERVICE BULLETIN REPLACES 020310001. *EH UPDATE. *TT

162500 STRUCTURE:BODY:TAILGATE

TAILGATE SUPPORT CABLE. RECALL 04007A. GM PARTS BULLETINS & INFORMATION. *TT UPDATED *EH

030000 SERVICE BRAKES, HYDRAULIC

LOW BRAKE PEDAL, RED BRAKE LIGHT ON, BRAKE SYSTEM WARNING MESSAGE ON. *TT UPDATED *EH

162500 STRUCTURE:BODY:TAILGATE

TAILGATE SUPPORT CABLE. *EH

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

DIAGNOSTIC INFORMATION TO ACCURATELY DIAGNOSE A/C LOW PRESSURE SWITCH USING NEW KENT MOORE SPECIAL TOOL GE-47742. *TT

010000 STEERING

CLUNKING NOISE UNDER HOOD AND CAN BE FELT IN STEERING WHEEL. THIS BULLETIN REPLACES PREVIOUS BULLETIN 00-02-35-003E. *TT

030000 SERVICE BRAKES, HYDRAULIC

AVAILABILITY OF REAR WHEEL MUD FLAPS TO REDUCE DEBRIS BUILD-UP ON REAR BRAKE CALIPERS AND/OR REAR WHEELS. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

IDLE INSTABILITY, LOW OR ROUGH IDLE WITH ELECTRONIC THROTTLE CONTROL. *TT

190000 TIRES

USE OF CORRECT INSTALLATION PROCEDURE FOR LOOSE HUBCAP ASSEMBLY. THIS SERVICE BULLETIN REPLACES 030310002. *EH

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

LOSS OF HEATING VENTILATION AIR CONDITIONING. SYSTEM MODE AND OR TEMPERATURE CONTROL. *EH

131000 VISIBILITY:WINDSHIELD

WINDRUSH AROUND WINDSHIELD. *TT

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

FLEXIBLE SPARE TIRE HOIST TOOL. *EH

021000 SUSPENSION:FRONT

FRONT SUSPENSION COIL SPRING NOISE. *TT

010000 STEERING

CLUNKING NOISE UNDER HOOD AND CAN BE FELT IN THE STEERING WHEEL. *TT

020000 SUSPENSION

NEW FLEXIBLE SPARE TIRE HOIST TOOL AVAILABLE TO ASSIST IN LOWERING/REMOVING SPARE TIRE. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

RATTLE NOISE IN ENGINE. *TT

105300 POWER TRAIN:DRIVELINE:DRIVESHAFT

REVISED WHEEL DRIVE SHAFT NUT TORQUE SPECIFICATION. *TT

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

POWER WINDOW MOTOR NOW AVAILABLE SEPARATELY FROM THE POWER WINDOW REGULATORY ASSEMBLY. *TT UPDATED *EH

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

EXHAUST MOAN/VIBRATION. *TT UPDATE. *TT

060000 ENGINE AND ENGINE COOLING

DIAGNOSTIC INFORMATION FOR INTERMITTENT VEHICLE NO CRANK DEAD BATTERY. *EH

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

BULLETIN 04-08-64-003, FRONT DOOR POWER WINDOW MOTOR ASSEMBLIES - WARRANTY REPAIR INFORMATION. *TT

010000 STEERING

INTERMEDIATE STEERING SHAFT SERVICE KIT. SERVICE VME. *TT

021000 SUSPENSION:FRONT

LEFT FRONT OF VEHICLE SITS LOW. SIT BULLETIN 1454860. *TT

Showing 100 of 275 bulletins.

NHTSA Safety Investigations, GMC SIERRA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

DP, Closed , Model Year: 1979

FLEX FAN FAILURE

JOSEPH E. WALLEN OF AMDURSKY, PELKY, FENNELL & WALLEN, P.C., REPRESENTING MR. BRADFORD BUTLER, PETITIONED THE AGENCY TO INVESTIGATE WHETHER THE FLEX FAN BLADES (PART NUMBER 336032) MANUFACTURED BY CANADIAN FRAM ARE ALLEGED DEFECTIVE WITHIN THE MEANING OF 49 U.S.C. CHAPTER 301.MR. BUTLER WAS SERIOUS ... Read more

GMC SIERRA - All Years Overview

Complete safety history for the GMC SIERRA across all model years (1988, 2016).

130 Total Recalls

4,904 Total Complaints

1 Investigations

344 Reported Crashes

81 Reported Fires

28 Reported Deaths

GMC SIERRA - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2017	0	77	View
2016	2	8	View
2015	6	67	View
2014	12	132	View
2013	3	46	View
2012	2	46	View
2011	2	67	View
2010	1	43	View
2009	1	48	View
2008	2	84	View
2007	2	71	View
2006	6	65	View
2005	11	152	View
2004	10	224	View
2003	9	248	View
2002	7	291	View
2001	7	333	View
2000 (current)	12	557
1999	9	721	View
1998	0	230	View
1997	0	302	View
1996	2	310	View
1995	6	327	View
1994	3	221	View
1993	3	109	View
1992	4	33	View
1991	2	12	View
1990	2	30	View
1989	2	22	View
1988	2	6	View
1987	0	2	View
1983	0	5	View
1982	0	1	View
1977	0	4	View
1976	0	2	View

Other GMC Models

Model	Recalls	Complaints
SIERRA 1500	233	10,607	View
YUKON	224	6,198	View
SIERRA 2500	169	2,217	View
SIERRA 3500	161	730	View
YUKON XL	157	2,899	View
SAVANA	142	448	View
ACADIA	84	7,520	View
JIMMY	71	3,791	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2000 GMC SIERRA

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2000 GMC SIERRA

Most Affected Components

NHTSA Safety Investigations, GMC SIERRA

GMC SIERRA - All Years Overview

GMC SIERRA - Year by Year

Other GMC Models