FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.
Remedy: FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.
34,000 vehicles affected
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
VEHICLES ARE SUBJECT TO EXCESSIVE UNDERHOOD TEMPERATURES AND FUEL SYSTEM PRESSURES IN SEVERE DUTY APPLICATIONS.
Remedy: INSTALL MODIFICATION KITS TO MINIMIZE POSSIBILITY OF FUEL EXPULSION AND TO SHIELD UNDERBODY COMPONENTS FROM EXHAUST SYSTEM HEAT.
188,000 vehicles affected
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
EXPULSION OF FUEL DUE TO OVERPRESSURIZATION.
Remedy: MODIFICATION OF THE BASE FUEL VENTING AND EMISSION CONTROL SYSTEM TO REDUCE OPERATING TEMPERATURES AND FUEL SYSTEM PRESSURES.
16,000 vehicles affected
FUEL SYSTEM, DIESEL
WHEN FRONTALLY IMPACTED INTO A FIXED BARRIER AT 30 MPH, AS SPECIFIED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 301, THE LEFT FRAME RAILS OF SUCH VEHICLES MAY DISPLACE INBOARD, PINCHING THE FUEL/WATER SEPARATOR CANISTER BETWEEN THE FRAME RAIL AND ENGINE SUFFICIENTLY TO DISPLACE THE FUEL/WATER SEPARATOR DRAIN ROD, ALLOWING THE CONTENTS OF THE CANISTER TO DRAIN. CONSEQUENCE OF DEFECT: FUEL LEAK DURING OR AFTER A CRASH INCREASES THE POSSIBILITY OF A FIRE.
Remedy: INSTALL A CANISTER SHIELD, A REVISED DESIGN DRAIN ROD SHIELD, AND MODIFY FUEL/WATER SEPARATOR MOUNTING BRACKET.
8,500 vehicles affected
POWER TRAIN:AUTOMATIC TRANSMISSION
THE PARKING GEAR MAY NOT ENGAGE, EVEN THOUGH THE GEAR SHIFT LEVER IS PLACED IN THE "PARK" POSITION. THIS OCCURS IF THE LINKAGE INSIDE THE TRANSMISSION THAT ACTUATES THE PARK GEAR WAS IMPROPERLY MANUFACTURED. A PIN THAT RETAINS COMPONENTS ON A LINKAGE (ACTUATING) ROD COULD BREAK AND THE LINKAGE MAY NOT ENGAGE THE PARKING GEAR.
Remedy: DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE PARKING PAWL ACTUATING ROD ASSEMBLY.
98,162 vehicles affected
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
SOME OF THE INVOLVED VEHICLES MAY HAVE A DIODE IN THE ELECTRICAL FUEL PUMP CIRCUIT THAT MAY SHORT DURING ENGINE STARTING DUE TO INADEQUATE CAPACITY TO WITHSTAND CURRENT DRAW. A SHORT CIRCUIT WOULD RESULT IN NORMAL ENGINE STARTING, BUT THE PUMP WILL NOT CONTINUE TO SUPPLY THE ENGINE WITH FUEL.
Remedy: THE DEALER WILL REPLACE DEFECTIVE ELEMENT IN THE ELECTRICAL FUEL PUMP CIRCUIT WITH A NEW RELAY FEED WIRING ASSEMBLY WHICH CONTAINS A LARGER CAPACITY DIODE, FREE OF CHARGE.
650 vehicles affected
TL* THE CONTACT OWNS A 1983 FORD ECONOLINE VAN, EQUIPPED WITH COOPER LIFELINER CLASSIC II TIRES, SIZE 255/70/R15. THE CONTACT STATED THAT THERE WERE CRACKS AND BLISTERS IN THE SIDEWALL OF THE FOUR TIRES. THE CONTACT WAS ABLE TO SEE THE METAL INSIDE THE TIRE. THE FAILURE WAS REPORTED TO THE MANUFACTURER, WHO REFUSED TO PROVIDE ASSISTANCE. THE FAILURE MILEAGE WAS 5,000. THE CURRENT VEHICLE MILEAGE WAS 110,000. KMJ UPDATED 8/26/13 *CN THE CONSUMER DISCOVERED CRACKS IN THE TIRE EXPOSING THE INSIDE WIRES.
VAN WAS BOUGHT USED FROM DEALER BUT I KNEW PREVIOUS OWNER. VAN HAD 4 LIKE NEW TIRES. VAN WAS IN NEAR MINT CONDITION DESPITE AGE AND MILEAGE. WHILE ON VACATION, RIGHT REAR TIRE BLEW OUT. BIG HOLE, STEEL BELT SHREDDED. WAS ABLE TO CHANGE SPARE DESPITE VERY HAZARDOUS LOCATION. MADE IT INTO DOUGLAS GEORGIA, EVERYTHING CLOSED EXCEPT WAL-MART. REPLACED TIRE WITH GOODYEAR TIRE. ABOUT 1 MONTH LATER WAS NEAR DOTHAN ALABAMA AND ABOUT 45 MILES FROM HOME WHEN I NOTICED SAME SYMPTOMS OTHER TIRE HAD DISPLAYED BEFORE BLOWING OUT. TRIED TO MAKE IT HOME BUT TIRE BLEW OUT EXACTLY LIKE FIRST ONE ON THE CHOCTAWHATCHEE RIVER BRIDGE. TIRE WAS AGAIN REPLACE AT WAL-MART. ABOUT 2 WEEKS LATER I NOTICED TREAD ON RIGHT FRONT WAS SHOWING STEEL BELT THROUGH BREAK IN TREAD. I PHONED FIRESTONE HEADQUARTERS AND ASKED IF THERE WAS A PROBLEM WITH TIRES. WAS TOLD NO BUT THEY WOULD GIVE ME AN ADJUSTMETN ON THE 2 WHICH WERE STILL ON VEHICLE. I TOOK VAN TO RON'S FIRESTONE IN GENEVEA, ALA. RONS HAD SOD TIRES ORIGINALLY AND WAS VERY FAMILIAR WITH VAN AS HE HAD DONE ALL MAINTENANCE ON IT. RONS REPLACED BOTH TIRES ALTHOUGH THE ADJUSTMENT WAS SO POOR THAT I COULD HAVE JUST GONE TO WAL-MART AND BOUGHT 2 NEW COMPARABLE OR BETTER TIRES FOR SAME PRICE. WHEN NEWS OF LATEST RECALL CAME OUT I PHONED FIRESTONE TOLL FREE NUMBER. WAS TOLD TO CALL ANOTHER NUMBER. DID SO AND WAS TOLD THEY WOULD CALL ME BACK. THEY NEVER DID. HAVE ATTEMPTED SEVERAL TIMES TO CALL THEIR CUSTOMER SERVICE NUMBER AND HAVE BEEN PUT ON HOLD EACH TIME FOR OVER AND HOUR (YES THAT'S RIGHT) AND STILL DIDN'T GET THROUGH. TRIED TO PHONE REGULAR CORPORATE NUMBER BUT THEY REFUSED TO PUT ME THROUGH TO ANYONE. IT APPEARS FIRESTONE HAS ERECTED A TOTAL WALL AROUND COMPANY EXCEPT FOR ONE TOLL FREE NUMBER WHICH CAN ONLY GIVE ADVICE ABOUT CERTAIN THINGS AND ARE NOT ALLOWED TO BE DISCUSSED. FRANKLY AM FED UP WITH THE COMPANY AND THEIR REFUSAL TO DEAL WITH PROBLEM.( DOT NUMBER: UNKNOWN TIRE SIZE: 235 75R15 )