2003 CHEVROLET MONTE CARLO

9 recalls, 204 complaints - 568 TSBs

ENGINE AND ENGINE COOLING:ENGINE

Defect Description

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, ... Read more

Consequence

Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy

The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the ori... Read more

1,003,556 vehicles affected

Manufacturer: General Motors LLC

ELECTRICAL SYSTEM:IGNITION

Defect Description

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agen... Read more

Consequence

If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy

GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

5,877,718 vehicles affected

Manufacturer: General Motors LLC

ENGINE AND ENGINE COOLING

Defect Description

GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROP... Read more

Consequence

IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.

Remedy

DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-... Read more

1,497,516 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

STEERING

Defect Description

DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN... Read more

Consequence

A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.

Remedy

DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.

979 vehicles affected

Manufacturer: DORMAN PRODUCTS, INC.

STEERING

Defect Description

DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DU... Read more

Consequence

IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy

DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.

3,855 vehicles affected

Manufacturer: DORMAN PRODUCTS, INC.

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

Defect Description

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Consequence

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Remedy

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

742 vehicles affected

Manufacturer: DELPHI

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Defect Description

CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE... Read more

Consequence

THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Remedy

OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CON... Read more

1,707,825 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Defect Description

ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.

Consequence

THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.

Remedy

DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-... Read more

130 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

AIR BAGS:FRONTAL

Defect Description

CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.

Consequence

PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.

Remedy

DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CON... Read more

133,221 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

Complaint Statistics

204 total complaints 15 crashes 24 fires 9 injuries

Top Reported Components

Component	Complaints
ELECTRICAL SYSTEM	43
ENGINE	30
ENGINE AND ENGINE COOLING	14
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR	11
AIR BAGS	8
ENGINE AND ENGINE COOLING:ENGINE	6
SERVICE BRAKES, HYDRAULIC	6
UNKNOWN OR OTHER	6
POWER TRAIN:AUTOMATIC TRANSMISSION	5
EXTERIOR LIGHTING	4

Incident date: Apr 13, 2026

I had to hard brake on a damp roadway at about 50 mph. The truck began to rotate and skid. I had no control over the vehicle until it stopped. The dash lights came on for a failure of the brakes, abs, traction control, and stability control. All of the lights went off then the truck seemed to drive ... Read more

Incident date: Apr 13, 2026

The contact’s father-in-law owns a 2026 Cadillac XT5. The contact stated that while the owner was driving at an undisclosed speed going uphill, he was blinded by the sunlight and started driving onto the grass. The driver released the accelerator pedal, and within a second, the vehicle started rol... Read more

Crash

Incident date: Apr 13, 2026

The paint on my Tesla Model Y is peeling and delaminating along both sides of the rear trunk/hatch seam, adjacent to the rear glass. The issue appears in the same location on both sides in a symmetrical pattern. There has been no accident, impact, or external damage to these areas. The peeling bega... Read more

Incident date: Jan 13, 2023

I had just finished Supercharging my vehicle from 50% to 80% and when I entered the car to drive home two warnings showed up 1. Steering assist was reduced and it might be more difficult to drive; and 2. Lane departure avoidance warning was not working. I did a hard reset twice - (foot on the ... Read more

Incident date: Oct 30, 2021

Vehicle stalls when starting. While driving vehicle may shut off when moving on highway if you are not pushing on gas pedal. May be due to faulty EGR or emissions component

Incident date: Oct 30, 2021

Vehicle stalls when starting. While driving vehicle may shut off when moving on highway if you are not pushing on gas pedal. May be due to faulty EGR or emissions component

Incident date: Oct 30, 2021

Vehicle stalls when starting. While driving vehicle may shut off when moving on highway if you are not pushing on gas pedal. May be due to faulty EGR or emissions component

Incident date: May 15, 2021

I had an engine fire. Complete loss of car.

Fire

Incident date: Dec 7, 2019

OWNED SINCE 2007, NO RECALLS ACTIVE, OLDER RECALL REPLACED INTERMEDIATE STEERING SHAFT, HAVE SAME PROBLEM AGAIN! ALSO ABS/TRACTION CONTROL/SPEED SENSORS ISSUE: HUMMING,GRINDING,TRAC OFF LIGHTS,ABS LIGHTS. COMMON ISSUE WITH THESE CARS YET NO FIX BY G.M ??

Incident date: Dec 7, 2019

Incident date: Dec 5, 2018

TAKATA RECALL. WELL I NOTICED IT DROPPING OIL ONTO THE ENGINE & INTAKE 12/5/2018 AND NOW IT SEEMS LIKE IT'S BEEN GETTING WORSE CUZ IT'S GETS SO HOT IT STARTS SMOKING FROM THE OIL ON THE ENGINE INTAKE I'M STILL DRIVING THE CAR

Incident date: Apr 7, 2019

MY CAR IS A 2003 MONTE CARLO, IF I TRY TO USE THE DIRECTIONAL SIGNALS THEY MAKE A BUZZING SOUND AND THEN THE BRAKE LIGHT AND THE AIR BAG LIGHT COMES ON ALONG WITH THE BATTERY LIGHT, NO SIGNAL WORKS, THE HAZARD LIGHTS WORK , I REPLACED THE HAZARD SWITCH BUT THAT DIDNT SOLVE IT . BATTER IS FINE A... Read more

Incident date: Apr 7, 2019

Incident date: Jul 15, 2018

PROBLEMS WITH THE SUSPENSION, IGNITION SWITCH, TURN SIGNALS NOT WORKING, SECURITY SYSTEM NOT RESETTING. HAD TO REPLACE THE ECM.

Incident date: Jul 15, 2018

PROBLEMS WITH THE SUSPENSION, IGNITION SWITCH, TURN SIGNALS NOT WORKING, SECURITY SYSTEM NOT RESETTING. HAD TO REPLACE THE ECM.

Incident date: Jul 15, 2018

PROBLEMS WITH THE SUSPENSION, IGNITION SWITCH, TURN SIGNALS NOT WORKING, SECURITY SYSTEM NOT RESETTING. HAD TO REPLACE THE ECM.

Incident date: May 1, 2018

TL* THE CONTACT OWNS A 2003 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). WHILE DRIVING AT UNKNOWN SPEEDS, THE KEY FAILED TO STAY IN THE IGNITION. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO CITY CHEVR... Read more

Incident date: Oct 24, 2016

TORQUE CONVERTER FAILURE

Incident date: Oct 21, 2016

THE WHOLE FRONT END OF THE CAR IS MAKING A NOISE AND IT IS WOBBLING ALL OVER. I REPLACED THE STRUTS AND IT DID NOT HELP IT HAS BEEN WELL MAINTAINED SOMETHING IS JUST NOT SAFE UP THERE IN THE FRONT SUSPENSION.I THINK THEY USED AS CHEAP OF PARTS AS THEY COULD GET.IT FEELS AS IF THERE ARE ZERO SHOCKS ... Read more

Incident date: Jun 1, 2016

TL* THE CONTACT OWNS A 2003 CHEVROLET MONTE CARLO. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 143,000.

Incident date: Feb 5, 2018

TL* THE CONTACT OWNS A 2003 CHEVROLET MONTE CARLO. AFTER THE VEHICLE RECEIVED AN OIL CHANGE, OIL WAS SEEN LEAKING FROM THE ENGINE. IN ADDITION, THE VEHICLE OVERHEATED, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED, AND SMOKE EMERGED FROM THE HOOD. THE CONTACT STATED THAT, AFTER REPLACING THE RADIAT... Read more

Fire

Incident date: Feb 5, 2018

Fire

Incident date: Feb 5, 2018

Fire

Incident date: Jun 7, 2017

TL* THE CONTACT OWNS A 2003 CHEVROLET MONTE CARLO. WHEN THE VEHICLE WAS STARTED, IT SHOOK. THE VEHICLE WAS DRIVEN TO THE DEALER (WHITE ALLEN CHEVROLET, 442 N. MAIN ST, DAYTON, OH 45405) FOR DIAGNOSTIC TESTING. THE DEALER AKNOWLEDGED THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCE... Read more

Incident date: Mar 3, 2014

TL* THE CONTACT OWNS A 2003 CHEVROLET MONTE CARLO. WHILE DRIVING VARIOUS SPEEDS, THE CHECK ENGINE, SERVICE TRACTION, AND ABS WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FRONT WHEEL HUB WITH THE ABS SENSOR NEEDED ... Read more

Incident date: Mar 3, 2014

Incident date: Jun 14, 2017

TL* THE CONTACT OWNS A 2003 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING AND IDLED, THE TEMPERATURE GAUGE INCREASED INDICATING THE VEHICLE WAS OVERHEATING. AS A RESULT, THE CONTACT HAD TO PULL OVER FOR A MOMENT FOR THE ENGINE TO COOL. THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE... Read more

Incident date: May 2, 2017

WHEN I GET IN THE CAR AT TIMES AND POUT KEY IN IGNITION, THERE IS ABSOLUTELY NOTHING. THE ELECTRICAL SYSTEM IS DEAD. I HAVE TO DISCONNECT THE NEGATIVE ON THE BATTERY FOR ABOUT 2 MINUTES TO GET IT TO WORK AGAIN. I ALSO EXPERIENCE FLASHING DOME LIGHT, BRAKE LIGHT ON, IGNITION BELL RINGING WITH NOTHING... Read more

Incident date: Jan 25, 2016

A.C. CLICKS ON AND OFF, LIGHTS BLINK WHILE DRIVING, SOMETIMES DON'T WANT TO START UNLESS IT DISCONNECT BATTERY. LIGHTS ON DASH CLUSTER DON'T WORLAND SECURITY LIGHT ON

Crash

Incident date: Oct 31, 2015

TL* THE CONTACT OWNS A 2003 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER... Read more

Incident date: Dec 30, 2016

RECALL #15757. THE REMEDY IN PART SAYS "THE ENGINE'S PLASTIC 'BEAUTY' COVER AND PLASTIC OIL FILL TUBE EXTENSION WILL BE REMOVED, IF THEY HAVEN'T BEEN ALREADY, ALSO FREE OF CHARGE." IF THEY DO NOT REPLACE THIS PART IT DETRACTS FROM THE APPEARANCE, AND ALSO DEVALUES THE CAR! THE REPAIRS SHOULD BE REQU... Read more

Incident date: Mar 7, 2016

TL* THE CONTACT OWNS A 2003 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE VEHICLE WAS NOT EXPERIENCING ANY FAILURES UNTIL IT WAS TAKEN TO THE DEALER AND REPAIRED PER A RECALL. WITHIN SIX MONTHS OF THE DEALER'S REPAIR THERE WAS AN OIL LEAK PROGRESSING ASSOCIATED WITH THE VALVE COVER ON THE UPPER... Read more

Incident date: Aug 1, 2016

TL* THE CONTACT OWNS A 2003 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE KEY WAS EXTREMELY DIFFICULT TO TURN TO START THE VEHICLE. THE VEHICLE BECAME UNABLE TO START. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MA... Read more

Incident date: Oct 3, 2016

2003 CHEVROLET MONTE CARLO. CONSUMER WRITES IN REGARDS TO REMOVAL OF ENGINE PLASTIC "BEAUTY" COVER AND PLASTIC OIL-FILL-TUBE EXTENSION RECALL NOTICE. *SMD

Incident date: Sep 30, 2016

THE CAR DONT WANT TO START UP BUT IN 5 MINS IT WILL START UP BUT NOW WHEN I TRY TO START THE CAR IT KEEP CRANKING EVEN WHEN I IM NOT TURNING THE KEY.

Incident date: Sep 30, 2016

THE CAR DONT WANT TO START UP BUT IN 5 MINS IT WILL START UP BUT NOW WHEN I TRY TO START THE CAR IT KEEP CRANKING EVEN WHEN I IM NOT TURNING THE KEY.

Incident date: Jul 6, 2016

I TOOK MY 2003 CHEVY MONTE CARLO INTO CIRCLE CHEVROLET IN SHREWSBURY, N.J. BECAUSE MY CAR'S AIR BAG SYMBOL HAD CAME ON ON MY DASH BOARD. IT HAD INITIALLY CAME ON SATURDAY JULY 2 IN THE LATE AFTERNOON. I IMMEDIATELY CAME HOME AND DID NOT DRIVE MY CAR UNTIL JULY 6, 2016 FOR SERVICE.... BECAUS... Read more

Incident date: Jul 6, 2016

TL* THE CONTACT OWNS A 2003 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REPAIR. THE ... Read more

Incident date: May 6, 2016

I OWN A PRISTINE 2003 MONTE SS, STORED EVERY WINTER AND MAINTAINED BY MY MECHANIC HUSBAND. I HAVE 2 ISSUES WITH THE CAR. FIRST, I NEVER USE MY BRIGHT LIGHTS BECAUSE MY HEADLIGHTS GO OUT IF I DO. SECOND I AM HAVING BRAKE ISSUES. I HAVE HAD THE SAME THING WITH A SILVERADO TRUCK BEFORE. ABS WOULD ... Read more

Incident date: May 6, 2016

Incident date: May 13, 2016

ENGINE FIRE ENGULFED THE WHOLE FRONT END. THERE WAS A RECALL BY GM #15757. RECEIVED A LETTER INDICATING POSSIBLE ENGINE COMPARTMENT FIRE. CALLED DEALERSHIP SEVERAL TIMES AND INFORMED THAT NEEDED PART WAS NOT AVAILABLE. WHILE DRIVING VEHICLE HOME ON CITY STREET THE ENGINE COMPARTMENT WENT UP IN FLAM... Read more

Fire

Incident date: Jan 1, 2016

TL* THE CONTACT OWNED A 2003 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE THE VEHICLE WAS IN PARK, THE VEHICLE CAUGHT ON FIRE. THE CONTACT STATED THAT THE FLAMES ENGULFED FROM UNDER THE HOOD. THE CONTACT EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED. THE FIRE DEPARTMENT WAS NOT NOTIFIED A... Read more

Fire

Incident date: Dec 1, 2015

TL* THE CONTACT OWNS A 2003 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING OIL AND HAD AN ABNORMAL BURNING ODOR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS CONFIRMED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE AS NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE A... Read more

Fire

Incident date: Oct 12, 2015

TL* THE CONTACT OWNS A 2003 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR.... Read more

Incident date: Mar 9, 2016

TL* THE CONTACT OWNS A 2003 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE BEAUTY COVER WAS REMOVED AS A REMEDY FOR NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING), WHICH LEFT ALL THE ENGINE WIRES EXPOSED. THE CONTACT BELIEVED THAT THE REMEDY PRESENTED A SAFETY RISK. THE DEALER STAT... Read more

Incident date: Dec 15, 2014

TL* THE CONTACT OWNS A 2003 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE, ENGINE COOLANT) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NO... Read more

Incident date: Dec 15, 2014

Incident date: Mar 7, 2016

DRIVER'S SIDE SEATBELT RETRACTOR DOES NOT RETRACT THE SEATBELT PROPERLY. ONCE I PARK THE CAR AND RELEASE THE SEATBELT, I MANUALLY HAVE TO PULL THE SEATBELT UP TO THE RETRACTOR. OTHERWISE, THE SEATBELT WILL JUST HANG THERE.

Showing 50 of 204 complaints.

EPA Fuel Economy, 2003 CHEVROLET MONTE CARLO

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
3.4L 6-cyl, Automatic 4-spd (Front-Wheel Drive)	19.0	29.0	22.0	Regular	$2,800
3.8L 6-cyl, Automatic 4-spd (Front-Wheel Drive)	17.0	27.0	20.0	Regular	$3,100

CO2 Emissions: -1.0 g/mile (Midsize Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2003 CHEVROLET MONTE CARLO

568 manufacturer communications from 410 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	73
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	61
110000 ELECTRICAL SYSTEM	54
060000 ENGINE AND ENGINE COOLING	34
353000 EQUIPMENT:ELECTRICAL	27
356000 EQUIPMENT ADAPTIVE/MOBILITY	25
060000 ENGINE (PWS)	21
118000 ELECTRICAL SYSTEM:SOFTWARE	20

110000 ELECTRICAL SYSTEM

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

060000 ENGINE AND ENGINE COOLING

This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

100000 POWER TRAIN

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

060000 ENGINE AND ENGINE COOLING

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

120000 EXTERIOR LIGHTING

This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

350000 EQUIPMENT

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

350000 EQUIPMENT

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

110000 ELECTRICAL SYSTEM

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

100000 POWER TRAIN

The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

060000 ENGINE AND ENGINE COOLING

This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.

060000 ENGINE AND ENGINE COOLING

This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

353720 EQUIPMENT:ELECTRICAL:ACCESSORY GENERATOR:OUTLETS/RECEPTACLE

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.

138220 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component

060000 ENGINE AND ENGINE COOLING

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

190000 TIRES

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

200000 WHEELS

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

This service bulletin provides information on Module Harvesting.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

980000 UNKNOWN OR OTHER

This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Handling Requests for Modifications to Permanently Import/Export Vehicles Between the U.S. and Canada.

100000 POWER TRAIN

This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

100000 POWER TRAIN

This diagnostic tip advises the tech not to separate the flexplate from the torque convertor or damage my occur if the engine is started while diagnosing for noise from the engine or transmission.

100000 POWER TRAIN

This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on tools available to find an intake vacuum leak or exhaust leak to correct a condition of MIL Illuminated with Multiple Fuel Trim and/or Oxygen Sensor Codes Set.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

160000 STRUCTURE

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

060000 ENGINE (PWS)

This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).

353000 EQUIPMENT:ELECTRICAL

This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

200000 WHEELS

190000 TIRES

200000 WHEELS

190000 TIRES

030000 SERVICE BRAKES, HYDRAULIC

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and

070000 FUEL SYSTEM, GASOLINE

061520 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

This service bulletin provides information for accurate tire pressures that ensure the safe handling and appropriate ride characteristics of GM cars and trucks.

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technician

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

350000 EQUIPMENT

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

110000 ELECTRICAL SYSTEM

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

071410 FUEL SYSTEM, GASOLINE:STORAGE:EVAPORATIVE EMISSIONS:CANISTER

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

350000 EQUIPMENT

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

160000 STRUCTURE

350000 EQUIPMENT

200000 WHEELS

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo

350000 EQUIPMENT

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

061560 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:PRESSURE/TEMPERATURE SENSOR

350000 EQUIPMENT

This Preliminary information communicates the use of Winter grade fuel during the warm months of 2020 and the potential rivability issues that it can cause. The ongoing Coronavirus (COVID-19) pandemic has caused significant reductions in

200000 WHEELS

190000 TIRES

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is

350000 EQUIPMENT

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

355100 EQUIPMENT:OTHER:LABELS

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

110000 ELECTRICAL SYSTEM

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

070000 FUEL SYSTEM, GASOLINE

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

350000 EQUIPMENT

This informational bulletin provides information on key code security rules and information on GM keycode look-up applications.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides information on key code security rules and information on GM keycode look-up applications.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

046000 SERVICE BRAKES, AIR:ANTILOCK

200000 WHEELS

Showing 100 of 568 bulletins.

NHTSA Safety Investigations, CHEVROLET MONTE CARLO

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

EA, Closed , Model Year: 1995

DEGRADED BRAKING PERFORMANCE

There is no summary currently available

PE, Closed , Model Year: 1996

DEGRADED BRAKING PERFORMANCE

DP, Closed , Model Year: 1982

STALLING

CHEVROLET MONTE CARLO - All Years Overview

Complete safety history for the CHEVROLET MONTE CARLO across all model years (1970, 2007).

121 Total Recalls

2,965 Total Complaints

3 Investigations

204 Reported Crashes

204 Reported Fires

24 Reported Deaths

CHEVROLET MONTE CARLO - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2010	0	6	View
2008	0	3	View
2007	2	54	View
2006	2	146	View
2005	4	155	View
2004	7	275	View
2003 (current)	9	204
2002	7	319	View
2001	8	417	View
2000	8	332	View
1999	5	170	View
1998	5	129	View
1997	3	218	View
1996	3	255	View
1995	5	244	View
1991	1	1	View
1990	1	0	View
1988	2	5	View
1987	3	9	View
1986	4	6	View
1985	2	7	View
1984	3	3	View
1983	2	1	View
1982	2	2	View
1981	2	2	View
1980	4	0	View
1979	5	0	View
1978	8	0	View
1977	3	0	View
1976	4	0	View
1975	2	0	View
1974	3	1	View
1973	1	0	View
1970	1	0	View

Other CHEVROLET Models

Model	Recalls	Complaints
SUBURBAN	246	10,458	View
TAHOE	240	12,622	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2003 CHEVROLET MONTE CARLO

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 2003 CHEVROLET MONTE CARLO

Technical Service Bulletins, 2003 CHEVROLET MONTE CARLO

Most Affected Components

NHTSA Safety Investigations, CHEVROLET MONTE CARLO

CHEVROLET MONTE CARLO - All Years Overview

CHEVROLET MONTE CARLO - Year by Year

Other CHEVROLET Models