2001 CHEVROLET MONTE CARLO

8 recalls, 417 complaints - 499 TSBs

ENGINE AND ENGINE COOLING:ENGINE

Defect Description

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, ... Read more

Consequence

Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy

The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the ori... Read more

1,003,556 vehicles affected

Manufacturer: General Motors LLC

ELECTRICAL SYSTEM:IGNITION

Defect Description

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agen... Read more

Consequence

If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy

GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

5,877,718 vehicles affected

Manufacturer: General Motors LLC

ENGINE AND ENGINE COOLING

Defect Description

GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROP... Read more

Consequence

IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.

Remedy

DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-... Read more

1,497,516 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

STEERING

Defect Description

DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN... Read more

Consequence

A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.

Remedy

DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.

979 vehicles affected

Manufacturer: DORMAN PRODUCTS, INC.

STEERING

Defect Description

DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DU... Read more

Consequence

IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy

DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.

3,855 vehicles affected

Manufacturer: DORMAN PRODUCTS, INC.

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

Defect Description

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Consequence

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Remedy

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

742 vehicles affected

Manufacturer: DELPHI

AIR BAGS

Defect Description

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.

Consequence

IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.

Remedy

DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.

580 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

SEAT BELTS

Defect Description

VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHI... Read more

Consequence

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.

Remedy

DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.

156,305 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

Complaint Statistics

417 total complaints 20 crashes 47 fires 24 injuries

Top Reported Components

Component	Complaints
ELECTRICAL SYSTEM	59
ENGINE	48
STEERING	18
ENGINE AND ENGINE COOLING	18
AIR BAGS	17
EXTERIOR LIGHTING:TURN SIGNAL	11
FUEL SYSTEM, GASOLINE	10
ENGINE AND ENGINE COOLING:ENGINE	10
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR	10
POWER TRAIN:AUTOMATIC TRANSMISSION	10

Incident date: Sep 1, 2020

LEAKS TIMING AND HEAD GASKETS

Incident date: Mar 28, 2007

MY 2001 MONTECARLO WAS HIT IN FRONT WITH FRONT END DAMAGE AND THE AIR BAGS DIDN'T GO OFF CAUSING MY GIRL FRIEND TO HAVE A BROKEN NOSE ..THE VEHICLE WAS IN MOTION ON A CITY STREET IN THE TURNING LANE *TR

Crash 1 injured

Incident date: Mar 28, 2007

Crash 1 injured

Incident date: Mar 28, 2007

Crash 1 injured

Incident date: Jul 20, 2019

I PURCHASED A 2001 CHEVY MONTE CARLO SS IN 9-01. I DID NOT REALIZE UNTIL RECENTLY THE ENGINE WAS BUILT 2000. I WOULD NOT HAVE PURCHASED. MY CAR HAS HAD MULTIPLE PROBLEMS. THE RECENT OCCURRED JULY 20TH 2019. MY ODOMETER IS 117,166 ORIGINAL MILES. THE INTAKE MANIFOLDS AND UPPER INTAKE MANIFOLD IS ALL ... Read more

Fire 1 injured

Incident date: Jul 20, 2019

Fire 1 injured

Incident date: Jul 2, 2019

CECKING THE FUSES, NONE OF THEM WERE BLOWN. GAUGE WOULD BE READING HOT TEMPERATURE, WOULD CHECK THE HOSES AND RADIATOR NOTHING. FUEL SYSTEM IS DOWN NOW.

Incident date: Jul 2, 2019

CECKING THE FUSES, NONE OF THEM WERE BLOWN. GAUGE WOULD BE READING HOT TEMPERATURE, WOULD CHECK THE HOSES AND RADIATOR NOTHING. FUEL SYSTEM IS DOWN NOW.

Incident date: Jul 2, 2019

CECKING THE FUSES, NONE OF THEM WERE BLOWN. GAUGE WOULD BE READING HOT TEMPERATURE, WOULD CHECK THE HOSES AND RADIATOR NOTHING. FUEL SYSTEM IS DOWN NOW.

Incident date: Jul 20, 2019

TL* THE CONTACT OWNS A 2001 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHEN SHE STARTED HER VEHICLE, SHE HEARD A LOUD BOOM FROM UNDER THE HOOD. THE IGNITION WAS TURNED OFF AND THERE WAS SMOKE COMING FROM THE HOOD. THE HOOD WAS OPENED AND A FIRE WAS DISCOVERED. THE CONTACT GOT A FIRE EXTINGUISHER... Read more

Fire

Incident date: Feb 6, 2019

ENGINE FIRE CLAIM# [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

Fire

Incident date: Mar 9, 2016

2001 MONTE CARLO SS. CONSUMER WRITES IN REGARDS TO LEAKING VALVE COVER GASKET. *LD *TR THE CONSUMER STATED THE VEHICLE WAS REPAIRED UNDER RECALL, BUT THE FAILURE RECURRED. *JS

Incident date: Feb 16, 2019

ENGINE BACKFIRED AND EXPLODED UPON IGNITION AFTER SITTING FOR A WEEK. ENGINE WAS COLD AND IN COLD WEATHER. 3 FOOT FLAMES, MINOR BURNS AND INJURIES SUSTAINED ER VISIT FOR SMOKE INHALATION WHILE EXTINGUISHING FIRE. VEHICLE WAS PARKED ON PRIVATE PROPERTY. A NEIGHBOR'S CAR THE SAME MAKE AND MODEL SIMI... Read more

Fire 1 injured

Incident date: Feb 16, 2019

Fire 1 injured

Incident date: Aug 6, 2013

2001 CHEVROLET MONTE CARLO. CONSUMER REQUESTS REIMBURSEMENT FOR REPAIRS. *SMD UPDATED 07/13/2017*JS

Incident date: Jul 3, 2017

THE DEALER YEARS AGO JUST PUT AN INSERT INTO THE KEY. NOW THE IGNITION DOES NOT PROPERLY WORK. YOU HAVE TO WIGGLE THE KEY FOR OPERATION. SOMETIMES THE CAR WON'T START,OTHER TIMES THE COMPONENTS WON'T WORK UNLESS I WIGGLE THE KEY. CAR HAS 57,000 MILES. WAS PART OF THE ORIGINAL RECALL FOR IGNITION P... Read more

Incident date: May 20, 2017

I WENT TO A DEALERSHIP TO DEAL WITH A KEY IGNITION RECALL 2 MONTHS AGO. NOW MY CAR IS STALLING IN THE MIDDLE OF THE ROAD WHICH NEVER HAPPENED BEFORE THE RECALL..

Incident date: May 20, 2017

I WENT TO A DEALERSHIP TO DEAL WITH A KEY IGNITION RECALL 2 MONTHS AGO. NOW MY CAR IS STALLING IN THE MIDDLE OF THE ROAD WHICH NEVER HAPPENED BEFORE THE RECALL..

Incident date: May 20, 2017

I WENT TO A DEALERSHIP TO DEAL WITH A KEY IGNITION RECALL 2 MONTHS AGO. NOW MY CAR IS STALLING IN THE MIDDLE OF THE ROAD WHICH NEVER HAPPENED BEFORE THE RECALL..

Incident date: Apr 9, 2017

TL* THE CONTACT OWNED A 2001 CHEVROLET MONTE CARLO. WHILE DRIVING 35 MPH, ANOTHER MOTORIST INFORMED THE CONTACT THAT FLAMES WERE COMING FROM THE FRONT OF HER VEHICLE. WHILE PULLING OFF THE ROADWAY THE STEERING WHEEL LOCKED AND ALL POWER WAS LOST. THERE WERE NO WARNING INDICATORS ILLUMINATED. TWO WEE... Read more

Fire 1 injured

Incident date: Apr 9, 2017

Fire 1 injured

Incident date: Apr 9, 2017

Fire 1 injured

Incident date: Apr 11, 2017

INTAKE MANIFOLD EXPLOSION RESULTING IN DAMAGE TO NEARBY VEHICLE. ATTEMPTING TO START THE VEHICLE ONE CRANK FOLLOWED BY LOUD EXPLOSION FROM UNDER THE HOOD. UPON INSPECTION, THE INTAKE MANIFOLD HAD BEEN BLOWN APART INTO 15 - 20 PIECES. A SMALL FIRE ERUPTED. WAS ABLE TO EXTINGUISH THE FIRE QUICKLY ONE ... Read more

Fire

Incident date: Nov 20, 2016

AFTER CHARGING THE BATTERY L THEN STARTED THE CAR AN HAD A BACK FIRE. WHEN THE CAR BACK FIRED IT BLEW OUT THE INTAKE MANIFOLD AN THERE WAS A LOT OF SMOKE . WAS WONDERING IF THER WAS A RECALL ON THE FUEL PUMP PRESSURE REGULATER . WHICH COULD BE THE CAUSE OF IT .

Incident date: Nov 22, 2016

PASSENGER SEAT BELT COMES UNBUCKLED FOR NO REASON. IT ALSO WONT LOCK ALL THE WAY WHEN YOU PLUG IT IN. RELEASE BUTTON SOME TIMES STAYS IN WHEN YOU PUSH IT TO TAKE THE SEAT BELT OFF. SCARED TO RIDE IN PASSENGER SEAT BECAUSE THE SEAT BELT DOES NOT WORK PROPERLY. NO RESTRAINT NOTHING. RIDING 45-50 MPH I... Read more

Incident date: Jun 19, 2015

DID A REPORT WITH THE DEALER 3 MONTHS AGO AND HAVEN'T HAD A CALL BACK YET ABOUT BRINGING MY CAR IN TO FIX THE PROBLEM WONDERING HOW LONG WILL IT TAKE TO BE CALLED IN ABOUT THIS PROBLEM

Incident date: Sep 19, 2016

PROBLEM 1: DRIVING NEAR MY HOME AND VEHICLE QUIT ON ME. GAS GAUGE SHOWED FULL BUT COME TO FIND OUT, I WAS OUT OF GAS. GOOD THING I WASN'T TRAVELING AT A HIGH RATE OF SPEED, LIKE INTERSTATE DRIVING. PROBLEM 2: VEHICLE WOULDN'T START, I'M BEING TOLD IT IS THE PASSLOCK SYSTEM. SECURITY LIGHT HA... Read more

Incident date: Sep 19, 2016

Incident date: Dec 30, 2009

I WAS DRIVING HOME ON HIWAY IN CRAWFORD COUNTY WI IT STARTED SNOWING MY BACK PASSENGER TIRE HIT A SLICK SPOT AND MY CAR SPUN OUT OF CONTROL CAUSING MY CAR TO TURN AROUND LIKE I WAS GOING BACK TO WHERE I CAME FROM ANOTHER CAR WAS COMING UP BEHIND ME DIDN'T SEE ME HIT ME SMASHED MY WHOLE BACK END THE ... Read more

Crash 2 injured

Incident date: Jul 29, 2016

IN LATE 2015, AND AGAIN IN JANUARY 2016, WE RECEIVED NOTICE FROM GM THAT THE FOLLOWING RECALL APPLIED TO OUR VEHICLE: NHTSA RECALL NUMBER: 15V701, MANUFACTURER RECALL NUMBER: N150757 THIS IS A RECALL TO REMEDY LEAKING VALVE COVER GASKETS. WE CONTACTED THE LOCAL CHEVROLET DEALER FROM WHOM WE PURC... Read more

Incident date: Aug 5, 2016

I WAS DRIVING AT HIGHWAY SPEEDS AND THE TEMP GAUGE DROPPEF TO ZERO, AIR CONDITIONING STOPPED WORKING, AND CAR BEGAN TO STRUGGLE. I PULLED THE CAR OFF THE HIGHWAY TO SEE IF WAS DUMPING COOLANT PUT. TOOK THE VEHICLE TO THE SHOP AND HE NEW WHAT WAS WRONG BECAUSE A LOT OF THESE CARS COME IN WITH THE PRO... Read more

Incident date: Aug 5, 2016

Incident date: Apr 6, 2016

TL* THE CONTACT OWNS A 2001 CHEVROLET MONTE CARLO. WHILE DRIVING 60 MPH, THE TEMPERATURE AND FUEL GAUGES DISPLAYED INCORRECT READINGS. IN ADDITION, THE LOW COOLANT WARNING LIGHT ILLUMINATED EVEN THOUGH THERE WAS COOLANT IN THE VEHICLE. THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGN... Read more

Incident date: Apr 6, 2016

Incident date: Dec 12, 2015

TL* THE CONTACT OWNS A 2001 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAI... Read more

Incident date: Jun 3, 2016

TL* THE CONTACT OWNS A 2001 CHEVROLET MONTE CARLO. WHILE DRIVING 60 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. IN ADDITION, A CLANKING NOISE WAS HEARD COMING FROM THE RECALL REPAIR SPOT. THE VEHICLE WAS SERVICED PER ... Read more

Incident date: Jun 20, 2016

TAKATA RECALL. I SPOKE TO A REPRESENTATIVE AT GM ASKING ABOUT THE RECALL OF MY VEHICLE AND SAID MY WARRANTY WAS EXPIRED. I JUST RECENTLY BOUGHT THE CAR FROM ANOTHER PERSON SO HOW I WAS SUPPOSE TO KNOW ABOUT THE CARS RECALL. THE PROBLEM WITH THE CAR IS THE IGNITION SWITCH WHENEVER I ROTATE IT TO T... Read more

Incident date: Jun 20, 2016

Incident date: Jun 24, 2016

TL* THE CONTACT OWNS A 2001 CHEVROLET MONTE CARLO. AFTER THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING), SMOKE APPEARED FROM THE MANIFOLD AND UNDER THE HOOD, WHICH PENETRATED INTO THE VEHICLE. THE DEALER STATED THAT THE SMOKE WAS NOT DUE TO THE REPAIR. THE ... Read more

Fire

Incident date: Feb 16, 2016

2001 CHEVROLET MONTE CARLO. CONSUMER WRITES IN REGARDS TO REPLACEMENT PARTS NOT AVAILABLE TO REPAIR FRONT VALVE COVER AND GASKET RECALL NOTICE. *SMD THE CONSUMER REFERENCED RECALL # 15V701000. *JB

Incident date: Oct 26, 2015

Incident date: Apr 16, 2016

TL* THE CONTACT OWNS A 2001 CHEVROLET MONTE CARLO. WHILE ATTEMPTING TO START THE VEHICLE, THE CONTACT HEARD AN EXPLODING NOISE COMING FROM THE ENGINE COMPARTMENT. UPON FURTHER INSPECTION, THE CONTACT NOTICED SMOKE AND REALIZED THAT THE INTAKE MANIFOLD HAD EXPLODED. THERE WERE NO INJURIES AND A POLI... Read more

Fire

Incident date: Apr 16, 2016

Fire

Incident date: Oct 30, 2015

Incident date: Mar 22, 2016

TL* THE CONTACT OWNS A 2001 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REP... Read more

Showing 50 of 417 complaints.

EPA Fuel Economy, 2001 CHEVROLET MONTE CARLO

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
3.4L 6-cyl, Automatic 4-spd (Front-Wheel Drive)	19.0	29.0	22.0	Regular	$2,800
3.8L 6-cyl, Automatic 4-spd (Front-Wheel Drive)	17.0	28.0	21.0	Regular	$2,950

CO2 Emissions: -1.0 g/mile (Midsize Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2001 CHEVROLET MONTE CARLO

499 manufacturer communications from 375 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	51
110000 ELECTRICAL SYSTEM	40
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	36
060000 ENGINE AND ENGINE COOLING	30
353000 EQUIPMENT:ELECTRICAL	24
061000 ENGINE AND ENGINE COOLING:ENGINE	23
060000 ENGINE (PWS)	18
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)	17

060000 ENGINE AND ENGINE COOLING

This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

100000 POWER TRAIN

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

060000 ENGINE AND ENGINE COOLING

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

120000 EXTERIOR LIGHTING

This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

350000 EQUIPMENT

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

100000 POWER TRAIN

The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

353720 EQUIPMENT:ELECTRICAL:ACCESSORY GENERATOR:OUTLETS/RECEPTACLE

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

138220 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component

060000 ENGINE AND ENGINE COOLING

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

This service bulletin provides information on Module Harvesting.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

980000 UNKNOWN OR OTHER

This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Handling Requests for Modifications to Permanently Import/Export Vehicles Between the U.S. and Canada.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

100000 POWER TRAIN

This diagnostic tip advises the tech not to separate the flexplate from the torque convertor or damage my occur if the engine is started while diagnosing for noise from the engine or transmission.

100000 POWER TRAIN

This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on tools available to find an intake vacuum leak or exhaust leak to correct a condition of MIL Illuminated with Multiple Fuel Trim and/or Oxygen Sensor Codes Set.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

160000 STRUCTURE

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and

030000 SERVICE BRAKES, HYDRAULIC

061520 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technician

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

350000 EQUIPMENT

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

110000 ELECTRICAL SYSTEM

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

071410 FUEL SYSTEM, GASOLINE:STORAGE:EVAPORATIVE EMISSIONS:CANISTER

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

350000 EQUIPMENT

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

350000 EQUIPMENT

160000 STRUCTURE

200000 WHEELS

350000 EQUIPMENT

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo

061560 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:PRESSURE/TEMPERATURE SENSOR

350000 EQUIPMENT

This Preliminary information communicates the use of Winter grade fuel during the warm months of 2020 and the potential rivability issues that it can cause. The ongoing Coronavirus (COVID-19) pandemic has caused significant reductions in

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is

350000 EQUIPMENT

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

355100 EQUIPMENT:OTHER:LABELS

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

070000 FUEL SYSTEM, GASOLINE

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels

350000 EQUIPMENT

073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

350000 EQUIPMENT

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.

110000 ELECTRICAL SYSTEM

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock ce

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

120000 LIGHTING (PWS)

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

350000 EQUIPMENT

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides information for dealers how to submit a product information report (PIR) (Canada Only).

060000 ENGINE (PWS)

110000 ELECTRICAL SYSTEM

350000 EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

118000 ELECTRICAL SYSTEM:SOFTWARE

This informational bulletin provides information for the GM of Canada OnStar Cellular Communication Upgrade to 3G/4G LTE for vehicles that may need an upgrade.

350000 EQUIPMENT

353000 EQUIPMENT:ELECTRICAL

350000 EQUIPMENT

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

This informational bulletin advises of a new fuel injection kit used for decarbonizing the intake valves, and explains how toptier fuels should be used to reduce carbon build up.

060000 ENGINE (PWS)

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

350000 EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

120000 EXTERIOR LIGHTING

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

060000 ENGINE AND ENGINE COOLING

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

This preliminary information document communicates a tip on the way to diagnose possible induction or exhaust air leaks using the evaporative emission cart smoke machine and ultrasonic leak detector tools.

350000 EQUIPMENT

This Preliminary information communicates

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

Showing 100 of 499 bulletins.

NHTSA Safety Investigations, CHEVROLET MONTE CARLO

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

EA, Closed , Model Year: 1995

DEGRADED BRAKING PERFORMANCE

There is no summary currently available

PE, Closed , Model Year: 1996

DEGRADED BRAKING PERFORMANCE

DP, Closed , Model Year: 1982

STALLING

CHEVROLET MONTE CARLO - All Years Overview

Complete safety history for the CHEVROLET MONTE CARLO across all model years (1970, 2007).

121 Total Recalls

2,965 Total Complaints

3 Investigations

204 Reported Crashes

204 Reported Fires

24 Reported Deaths

CHEVROLET MONTE CARLO - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2010	0	6	View
2008	0	3	View
2007	2	54	View
2006	2	146	View
2005	4	155	View
2004	7	275	View
2003	9	204	View
2002	7	319	View
2001 (current)	8	417
2000	8	332	View
1999	5	170	View
1998	5	129	View
1997	3	218	View
1996	3	255	View
1995	5	244	View
1991	1	1	View
1990	1	0	View
1988	2	5	View
1987	3	9	View
1986	4	6	View
1985	2	7	View
1984	3	3	View
1983	2	1	View
1982	2	2	View
1981	2	2	View
1980	4	0	View
1979	5	0	View
1978	8	0	View
1977	3	0	View
1976	4	0	View
1975	2	0	View
1974	3	1	View
1973	1	0	View
1970	1	0	View

Other CHEVROLET Models

Model	Recalls	Complaints
SUBURBAN	246	10,458	View
TAHOE	240	12,622	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2001 CHEVROLET MONTE CARLO

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 2001 CHEVROLET MONTE CARLO

Technical Service Bulletins, 2001 CHEVROLET MONTE CARLO

Most Affected Components

NHTSA Safety Investigations, CHEVROLET MONTE CARLO

CHEVROLET MONTE CARLO - All Years Overview

CHEVROLET MONTE CARLO - Year by Year

Other CHEVROLET Models