ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
1,003,556 vehicles affected
ENGINE AND ENGINE COOLING:ENGINE
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
1,003,556 vehicles affected
ENGINE AND ENGINE COOLING
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
1,497,516 vehicles affected
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Remedy: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
742 vehicles affected
AIR BAGS:FRONTAL
ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.
272 vehicles affected
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1999 CHEVROLET MONTE CARLO Z34 PASSENGER VEHICLES. THE BRAKING PERFORMANCE IN WET WEATHER OR WET ROAD CONDITIONS IS REDUCED MORE THAN A DRIVER WOULD EXPECT.
Remedy: DEALER WILL MODIFY THE FRONT FENDER LINERS TO REMOVE A PORTION OF THE CLOSEOUT PANELS IN THE FRONT WHEEL WELLS AT NO CHARGE TO THE CONSUMER. THIS SERVICE WILL BE AVAILABLE THROUGH AUGUST 2004.
FAN WANT COOL THE CAR WHEN STOP AT RED BREAKS WHEN FAST STOPING HAS SLOW GRIP TOO THEM
FAN WANT COOL THE CAR WHEN STOP AT RED BREAKS WHEN FAST STOPING HAS SLOW GRIP TOO THEM
NHTSA CAMPAIGN ID NUMBER 14V400000 - I SENT A PRIOR COMPLAINT TODAY REGARDING MY 1999 MONTE CARLO AND I APOLOGIZE FOR MISSTATING A FACT.. I SAID IN THE ORIGINAL COMPLAINT THAT MY MONTE CARLO WAS LISTED ON THE RECALL AT THE YEAR 2000. AND THAT IT WAS SIMILAR TO THE LUMINA, I MEANT TO SAY THAT IT IS SIMILAR TO THE 1999 MALIBU, WHICH IS BEING RECALLED BECAUSE OF THE IGNITION SYSTEM. THE RECALL NUMBER IS 14350. AND MY COMPLAINT NUMBER THAT I SENT EARLIER WHICH DESCRIBES IN DETAIL THE PROBLEM I AM HAVING IS 10916644.. *TR
MY CAR WILL NOT TURN ALL THE WAY OFF TO BE ABLE TO REMOVE THE KEYS FROM THE IGNITION. I UNDERSTAND THERE IS A RECALL ON 2000 MODELS AND UP. AND THERE IS A RECALL FOR THE SAME ISSUE ON THE 1999 LUMINA - BUT NOT ON THE MONTE CARLO, GIVEN THAT THE MC IS SO SIMILAR TO THE LUMINA, I THINK THERE HAS BEEN A MISTAKE NOT INCLUDING THE MC. IT HAS HAPPENED ON SEVERAL DIFFERENT OCCASIONS AND IS GETTING WORSE. I BELIEVE THE 1999 SHOULD BE INCLUDED IN THE RECALL ALSO. PLEASE LET ME KNOW, THANK YOU. IF YOU ARE NOT THE RIGHT PEOPLE PLEASE POINT ME IN THE RIGHT DIRECTION. *TR
TL* THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. AFTER REFUELING THE VEHICLE, THE CONTACT NOTICED FUEL LEAKING UNDERNEATH THE VEHICLE. IN ADDITION, THE FRONT DRIVER AND PASSENGER SIDE POWER WINDOWS AND THE AIR CONDITIONER FAILED TO FUNCTION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED AND THE AIR CONDITIONING UNIT NEEDED TO BE RECHARGED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE WITH THE AIR CONDITIONER RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.
TL* THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. AFTER REFUELING THE VEHICLE, THE CONTACT NOTICED FUEL LEAKING UNDERNEATH THE VEHICLE. IN ADDITION, THE FRONT DRIVER AND PASSENGER SIDE POWER WINDOWS AND THE AIR CONDITIONER FAILED TO FUNCTION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED AND THE AIR CONDITIONING UNIT NEEDED TO BE RECHARGED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE WITH THE AIR CONDITIONER RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.
TL* THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. AFTER REFUELING THE VEHICLE, THE CONTACT NOTICED FUEL LEAKING UNDERNEATH THE VEHICLE. IN ADDITION, THE FRONT DRIVER AND PASSENGER SIDE POWER WINDOWS AND THE AIR CONDITIONER FAILED TO FUNCTION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED AND THE AIR CONDITIONING UNIT NEEDED TO BE RECHARGED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE WITH THE AIR CONDITIONER RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.
TL* THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING OIL. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) AND STATED THAT THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. PARTS DISTRIBUTION DISCONNECT.
TL* THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) AND STATED THAT THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PART DISTRIBUTION DISCONNECT.
TL* THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THERE WAS A BURNING OIL ODOR EMITTING FROM THE VEHICLE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) AND STATED THAT THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 153,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
TL* THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THERE WAS A LEAK COMING FROM UNDER THE HOOD THAT WAS GETTING PROGRESSIVELY WORST. THE LEAK WOULD CREATE A PUDDLE ON THE FLOOR. THE CONTACT ALSO STATED THAT UPON TURNING THE KEY IN THE VEHICLE, IT STARTED SMOKING. THE VEHICLE WAS INSPECTED BY THE CONTACT WHO NOTICED THAT ENGINE OIL WAS LEAKING ONTO THE EXHAUST MANIFOLD. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE) AND WAS TO SCHEDULE A RECALL REPAIR APPOINTMENT ONCE THE PARTS BECAME AVAILABLE. THE CONTACT WAS UNABLE TO DETERMINE WHEN THE VEHICLE WOULD BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Fire
TL* THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS AN ABNORMAL ODOR COMING INTO THE VEHICLE. IN ADDITION, THE CONTACT NOTICED SMOKE COMING FROM THE ENGINE COMPARTMENT. IT WAS UNKNOWN IF THE VEHICLE WAS DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 178,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Fire
TL* THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT AFTER TURNING THE IGNITION KEY TO START THE ENGINE, AN EXPLOSION OCCURRED UNDER THE HOOD. THE CONTACT DISCOVERED THAT DURING THE INCIDENT THE INTAKE MANIFOLD AND THE TOP OF THE ENGINE WERE SEVERELY DAMAGED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 148,551.
Fire
TL* THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE ENGINE FAILED TO START AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE BATTERY AND ALTERNATOR WAS REPLACED. THE CONTACT MENTIONED THAT THE FAILURE WAS EXPERIENCED MULTIPLE TIMES. THE CONTACT ALSO MENTIONED THAT THE BRAKE LIGHTS AND HEADLIGHTS FAILED TO OPERATE AFTER THE BULBS WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 89,300. UPDATED 06/10/14*LJ
TL* THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE ENGINE FAILED TO START AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE BATTERY AND ALTERNATOR WAS REPLACED. THE CONTACT MENTIONED THAT THE FAILURE WAS EXPERIENCED MULTIPLE TIMES. THE CONTACT ALSO MENTIONED THAT THE BRAKE LIGHTS AND HEADLIGHTS FAILED TO OPERATE AFTER THE BULBS WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 89,300. UPDATED 06/10/14*LJ
I WOULD BE DRIVING DOWN A ROAD AND SUDDENLY THE ENGINE WOULD DIE. I WOULD IMMEDEIATELY HAVE NO POWER STEERING NOR POWER BRAKES. THIS HAPPENED SEVERAL TIMES. I HAVE NOW STOPPED DRIVING THE CAR. NO CODES WOULD SHOW. MY MECHANIC CANNOT FIND ANYTHING. WHEN I TAKE IT TO HIM, IT DID NOT ACT UP. IT IS INTERMITTENT. SOMETIMES IT WOULD START RIGHT BACK UP. OTHER TIMES IT WOULD TAKE HOURS OR MANY HOURS BEFORE IT WOULD FINALLY RESTART. *TR
I WOULD BE DRIVING DOWN A ROAD AND SUDDENLY THE ENGINE WOULD DIE. I WOULD IMMEDEIATELY HAVE NO POWER STEERING NOR POWER BRAKES. THIS HAPPENED SEVERAL TIMES. I HAVE NOW STOPPED DRIVING THE CAR. NO CODES WOULD SHOW. MY MECHANIC CANNOT FIND ANYTHING. WHEN I TAKE IT TO HIM, IT DID NOT ACT UP. IT IS INTERMITTENT. SOMETIMES IT WOULD START RIGHT BACK UP. OTHER TIMES IT WOULD TAKE HOURS OR MANY HOURS BEFORE IT WOULD FINALLY RESTART. *TR
I WOULD BE DRIVING DOWN A ROAD AND SUDDENLY THE ENGINE WOULD DIE. I WOULD IMMEDEIATELY HAVE NO POWER STEERING NOR POWER BRAKES. THIS HAPPENED SEVERAL TIMES. I HAVE NOW STOPPED DRIVING THE CAR. NO CODES WOULD SHOW. MY MECHANIC CANNOT FIND ANYTHING. WHEN I TAKE IT TO HIM, IT DID NOT ACT UP. IT IS INTERMITTENT. SOMETIMES IT WOULD START RIGHT BACK UP. OTHER TIMES IT WOULD TAKE HOURS OR MANY HOURS BEFORE IT WOULD FINALLY RESTART. *TR
TL*THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. WHILE DRIVING APPROXIMATELY 60 MPH, THE REAR BRAKE LIGHTS WERE INOPERATIVE. THE CONTACT WAS ALERTED BY A DRIVER ONCE REACHING HIS DESTINATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY INFORMED THE CONTACT THAT THE FAILURE WAS ATTRIBUTED TO THE BRAKE MULTIFUNCTION SWITCH. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 163,125.
J'AI UN CHEVROLET MONTE-CARLO 1999 AVEC LE MOTEUR 3.8 V6 ,EN LA DMARRANT UNE EXPLOSION S'EST PRODUITE ET LE MOTEUR A PRIS EN FEU .J'AI CONTACTER G.M QUI ME DISE QU'IL N'Y A PAS DE RAPPEL CONCERNANT LES INCENDIES EN RAPPORT AVEC LE COLLECTEUR D'ADMISSION EN PLASTIQUE ,ET JE SAIS QUE C'EST UNE DFECTUOSIT DE FABRICATION .J'AIMERAIS AVOIR VOS CONSEILS AFIN DE RGLER MON PROBLME ,MERCI.
Fire
J'AI UN CHEVROLET MONTE-CARLO 1999 AVEC LE MOTEUR 3.8 V6 ,EN LA DMARRANT UNE EXPLOSION S'EST PRODUITE ET LE MOTEUR A PRIS EN FEU .J'AI CONTACTER G.M QUI ME DISE QU'IL N'Y A PAS DE RAPPEL CONCERNANT LES INCENDIES EN RAPPORT AVEC LE COLLECTEUR D'ADMISSION EN PLASTIQUE ,ET JE SAIS QUE C'EST UNE DFECTUOSIT DE FABRICATION .J'AIMERAIS AVOIR VOS CONSEILS AFIN DE RGLER MON PROBLME ,MERCI.
Fire
TL*THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. FOR THE PAST TWO YEARS, THE VEHICLE WOULD DECELERATE ON ITS OWN INTERMITTENTLY. THE CONTACT HEARD A LOUD NOISE AND THE VEHICLE BEGAN SMOKING UNDER THE HOOD WHILE DRIVING BETWEEN 45-55 MPH. THE VEHICLE WAS DRIVEN TO THE DEALER FOR DIAGNOSTIC TESTING AND THEY DUPLICATED THE FAILURE. THE MECHANIC STATED THAT THE ENGINE WOULD NEED TO BE DISASSEMBLED IN ORDER TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER STATED THAT THEY WERE NOT LIABLE FOR THE REPAIRS. THE CURRENT MILEAGE WAS 16,500 AND FAILURE MILEAGE WAS 15,000. UPDATED 11/04/09. *LJ UPDATED 11/05/09.*JB
I STARTED TO HEAR A SLIGHT CLICKING SOUND WHEN I PRESSED ON MY BRAKES, ONLY EVERY ONCE IN A WHILE, LIKE THE SOUND I WOULD HEAR WHEN I WOULD HIT A POT HOLE IN THE ROAD WHILE I WAS BRAKING AND MY "LOW TRACTION" LIGHT WOULD COME ON. IT PROGRESSIVELY HAD STARTED TO GET WORSE OVER THE COURSE OF THE MONTH. I HAVE HAD TWO GARAGES LOOK AT MY CAR, AND THEY CANNOT FIGURE OUT WHAT IS MAKING THE REPEATED AND VERY EVIDENT CLICKING SOUND EVERYTIME THE BRAKES ARE TOUCHED. I HAVE HAD A DIAGNOSTIC TEST DONE ON THE CAR AND NO CODES ARE SHOWING UP. THEY SAY IT COULD BE THE ABS MODULE, BUT THEY ARE NOT SURE, AND THAT I WOULD HAVE TO BRING IT TO THE DEALERSHIP TO HAVE IT INVESTIGATED FURTHER. THEY WERE (THE GARAGES) BOTH PUZZLED AT WHAT THIS SOUND WOULD BE CAUSED BY. *TR
I WAS AT A FRIENDS FOR SEVERAL HOURS PROCEEDING INCIDENT. I DROVE MY 1999 CHEVY MONTE CARLO Z34 ABOUT 1 MILE FROM MY FRIENDS TO TACO BELL. THE CAR HAD BEEN RUNNING GREAT. I WENT INSIDE TO ORDER I WAS IN THEIR 10-15 MINUTES. WHEN I CAME OUT SMOKE WAS COMING FROM UNDER THE HOOD. I OPENED THE HOOD AND THE TOP OF THE ENGINE WAS ON FIRE. TACO BELL EMPLOYEES CALLED 911 AND THEN PROVIDED A FIRE EXTINGUISHER. THE FIRE WAS PUT OUT BY THE EXTINGUISHER AND THEY CANCELLED THE 911 CALL. I CALLED A TOW COMPANY AND HAD THE CAR TOWED HOME DUE TO THE HOUR AND MY ENGINE BEING MELTED. *TR
Fire
I WAS AT A FRIENDS FOR SEVERAL HOURS PROCEEDING INCIDENT. I DROVE MY 1999 CHEVY MONTE CARLO Z34 ABOUT 1 MILE FROM MY FRIENDS TO TACO BELL. THE CAR HAD BEEN RUNNING GREAT. I WENT INSIDE TO ORDER I WAS IN THEIR 10-15 MINUTES. WHEN I CAME OUT SMOKE WAS COMING FROM UNDER THE HOOD. I OPENED THE HOOD AND THE TOP OF THE ENGINE WAS ON FIRE. TACO BELL EMPLOYEES CALLED 911 AND THEN PROVIDED A FIRE EXTINGUISHER. THE FIRE WAS PUT OUT BY THE EXTINGUISHER AND THEY CANCELLED THE 911 CALL. I CALLED A TOW COMPANY AND HAD THE CAR TOWED HOME DUE TO THE HOUR AND MY ENGINE BEING MELTED. *TR
Fire
I WAS AT A FRIENDS FOR SEVERAL HOURS PROCEEDING INCIDENT. I DROVE MY 1999 CHEVY MONTE CARLO Z34 ABOUT 1 MILE FROM MY FRIENDS TO TACO BELL. THE CAR HAD BEEN RUNNING GREAT. I WENT INSIDE TO ORDER I WAS IN THEIR 10-15 MINUTES. WHEN I CAME OUT SMOKE WAS COMING FROM UNDER THE HOOD. I OPENED THE HOOD AND THE TOP OF THE ENGINE WAS ON FIRE. TACO BELL EMPLOYEES CALLED 911 AND THEN PROVIDED A FIRE EXTINGUISHER. THE FIRE WAS PUT OUT BY THE EXTINGUISHER AND THEY CANCELLED THE 911 CALL. I CALLED A TOW COMPANY AND HAD THE CAR TOWED HOME DUE TO THE HOUR AND MY ENGINE BEING MELTED. *TR
Fire
DT*: THE CONTACT STATED THERE WAS AN ODOR COMING FROM THE VEHICLE. UPON INSPECTION THE DEALER AND INDEPENDENT REPAIR SHOP DETERMINED THE VEHICLE WAS LEAKING ANTI-FREEZE. THE PLASTIC INTAKE MANIFOLD GASKET WAS CRACKED DUE TO HEAT FROM THE ENGINE AND NEEDS REPLACED WITH A METAL GASKET. WHILE DRIVING 40 MPH, AFTER THE VEHICLE WAS INSPECTED THE ENGINE STALLED. THE VEHICLE WAS RESTARTED AFTER COOLING FOR AN HOUR. THE VEHICLE WAS NOT RETURNED TO THE DEALER OR MECHANIC. UPDATED 06/07/2006. *AK *TS
I HAVE JUST FOUND OUT THAT MY 3.1 LITRE ALSO HAS HAD THE INTAKE MANIFOLD GASKET GO BAD. THE CAR ONLY HAS 57,000 MILES. LIKE OTHERS HERE IT IS GOING TO COST ME $450 TO GET IT FIXED. GM NEEDS TO STEP UP AND CREATE A RECALL OR AT LEAST PAY TO HAVE A NEW GASKET INSTALLED. IT IS MY BELIEF THAT IT ALL STEMS FROM DEXCOOL. I HAVE KNOWN SEVERAL PEOPLE THAT HAVE HAD OR ARE HAVING THE SAME PROBLEM. *JB
I HAVE A 1999 MONTE CARLO THAT REPEATEDLY HAS ENGAGED THE ABS BRAKE SYSTEM FOR NO APPARENT REASON AT LOW SPEEDS ONLY, OFTEN DECREASING THE ABILITY TO STOP THE CAR. I HAVE SEEN MANY PUBLISHED REPORTS OF THIS PROBLEM IN GM TRUCKS AND WOULD LIKE IT KNOWN ITS NOT LIMITED TO TRUCKS/SUV'S.*JB
THE CONSUMERS SON WAS DRIVING, WHEN AL L OF A SUDDEN THE BRAKES LOCKED UP AND DID NOT RELEASE. *JB
1. ANTI-LOCK BRAKING SYSTEM - WARNING LIGHT CAME ON - MECHANIC CHECKED SYSTEM DETERMINED THE SYSTEM SHUT DOWN DUE TO CORROSION OF THE ABS RELAY IN THE FUSE BLOCK --- 2. BRAKE SYSTEM WORKED, ABS DID NOT ----- 3. REPLACED ABS RELAY SWITCH, FUSES, AND FUSE BLOCK
WE WERE PREPARING TO TAKE A LONG TRIP AND TOOK OUR 1999 MONTE CARLO INTO OUR MECHANIC FOR A PRE-TRIP ONCE-OVER. HE JUST CALLED AND INFORMED US THAT THE RADIATOR WAS ALMOST EMPTY AND THAT THERE IS A LEAK IN THE INTAKE MANIFOLD GASKET, IT CAN (AND WILL) BE FIXED FOR A COST OF $750.00. OUR MECHANIC HAS A SMALL SHOP AND HE HAS FIXED THE SAME PROBLEM AT LEAST ONCE A MONTH ON GM PRODUCTS WITH A 3.1 LITER ENGINE, HE JUST HAD A BUICK LAST WEEK WITH THE IDENTICAL PROBLEM. DOESN'T ANYBODY ELSE SEE THIS AS AN ISSUE THAT GM NEEDS TO TAKE SOME KIND OF ACTION ABOUT?? WE WOULD HAVE BEEN LIVID IF THIS CAR HAD BROKEN DOWN IN THE DESERT ON THE WAY TO LAS VEGAS!! WE WERE REALLY HAPPY WITH THIS VEHICLE, BUT NOW PLAN TO SELL IT AND WE WILL BE LOOKING FOR SOMETHING WITOUT A RECURRING PROBLEM OF THIS MAGNITUDE! *AK
REAR BRAKE LIGHTS WILL OCCASIONALLY NOT FUNCTION PROPERLY. AT TIMES ONLY THE CENTER SAFETY LIFT WILL BE FUNCTIONAL WHILE THE TWO REAR BRAKE LIGHTS WILL NOT WORK. I AM TOLD THAT THE PROBLEM IS IN THE MULTI-FUNCTION SWITCH. THIS WEEK I ALSO SEEN A CHEVROLET TRAIL BLAZER WITH THE SAME PROBLEM. I HAVE NOT HAD THE PROBLEM FIXED, YET. *NM
THERE IS A FLUID CALLED DEX/COOL WHICH IS LIKE ANTI-FREEZE. HOWEVER, IT EATS AWAY AT THE GASKET. CONSUMER HAS HAD TO HAVE THE GASKET REPLACED. *AK THE CONSUMER STATED THAT THE INTAKE GASKET WAS LEAKING. LOSS OF RADIATION FLUID AT 77000 MILES. *TC
MY 1999 MONTE CARLO STATED LEAKING ANTIFREEZE DIPS AT A TIME. THEN THE NEXT THING I KNOW THERE WAS PUDDLES OF ANTI-FREEZE UNDER MY CAR. I TOOK THE CAR TO A SHOP AND THE MECHANIC SAID I NEEDED A INTAKE MANIFOLD GASKET AND THAT'S GOING TO BE $450.00. I DIDN'T HAVE THE MONEY SO I HAD THE CAR PUSHED HOME AND NOW I AM WAITING TO GET THE CAR FIXED WHEN I CAN COME UP WITH THE MONEY. *JB
INTAKE GASKET LEAKING COOLANT. *AK
IN WET WEATHER YOU CAN'T STOP CAR, ON THE HIGHWAY IF YOU STEP ON THE BRAKE PEDAL IT IS VERY HARD. OFTEN CAR WILL GO 200 YARDS OR MORE WITHOUT ANY BRAKES BEFORE THEY ENGAGE. THERE IS A SPECIAL POLICY ON THIS BUT DIDN'T HELP.*AK
THIS COMPLAINT IS FOR THE 1999 CHEVROLET MONTE CARLO. A PULSATION WAS BEING FELT WHEN THE BRAKES WERE APPLIED (EVEN ON DRY PAVEMENT). THE FEAR IS THAT THIS DEFECT MAY CAUSE A FUTURE CRASH. WHAT I EVENTUALLY DISCOVERED IS THAT THE RINGED GEARS THE WHEEL SPEED SENSORS DETECT VEHICLE SPEED WITH HAD CRACKED. FIRST THE LEFT SIDE NEAR 50000 MILES; LATER THE RIGHT SIDE NEAR 68000 MILES. THE GAP FROM THE CRACK IS SENDING THE ABS COMPUTER FALSE SPEED SIGNALS. THE ABS COMPUTER DOES NOT GIVE A WARNING CODE FOR THIS. IT "ACTS" AS IF TRYING TO STOP ON ICE, EVEN THOUGH THE PAVEMENT IS DRY (I.E. PULSATIONS IN PEDAL). MY TEMPORARY FIX FOR THE MOMENT WAS TO DISCONNECT A CONNECTOR FOR THE ABS SYSTEM TO CAUSE THE ABS TO SHUT DOWN AND ALLOW NON-ABS BRAKING. SINCE THE FIX WILL BE IN THE HUNDREDS OF DOLLARS, I'M HOPING FOR A SAFETY RECALL. THE RINGED GEAR IS CLEARLY A DEFECTIVE PART.*AK
INTAKE MANIFOLD COOLANT LEAK ON 3.1 ENGINE, WITH A COST OF $ 650.00 FOR THIS REPAIR. SEEMS TO BE A COMMON OCCURENCE WITH ALL THE 3.1 LITER ENGINES. MAYBE IT'S TIME GM STEPPED UP TO THE PLATE, AND TOOK A LOOK AT THIS PROBLEM. NO WONDER IMPORTS ARE BECOMING MORE POPULAR!!!*AK
WHEN DRIVING AT AN UNDETERMINED SPEED CONSUMER HEARD A KNOCKING NOISE COMING FROM THE ENGINE. CONSUMER TOOK THE VEHICLE TO THE DEALERSHIP FOR INSPECTION, AND MECHANIC DETERMINED THAT THE ENGINE FAILED. *AK
INTAKE MANIFOLD COOLANT LEAK, HAPPENED TO MY 3.1 ENGINE, AND TO SEVERAL OF MY FRIENDS, EACH WITH THE 3.1 ENGINE. EACH STATED A COST OF $ 650.00 FOR THIS REPAIR, SEEMS THIS HAPPENS TO ALL THE 3.1 LITER ENGINES, SHOULDN'T CHEVROLET OWN UP TO THIS PROBLEM? WHEN IT HAPPENS TO A SELECT FEW THATS ONE THING, WHEN IT HAPPENS TO ALL OF THEN IS IT NOT A DESIGN FLAW?*AK
3.1 ENGINE INTAKE MANIFOLD GASKET LEAK. THIS PROBLEM STARTED JUST OUT OF WARRANTY AND WAS ABLE TO KEEP THE CAR GOING TILL NOW WITH STOP LEAK. I TOOK THE MANIFOLD OFF AND THE GASKET LOOKS TO BE BROKEN IN FOUR PLACES. A FRIEND OF MINE PAID ALMOST 500 DOLLARS TO FIX THE LEAK ON HIS 3.1 LAST WEEK. CHEVY SAYS THERE IS NO PROBLEM. JUST LOOK ON THE NET THERE"S THOUSANDS OF PEOPLE LIKE US .CHEVY CASE #1-12-2500234 STARTED ABOUT 38000 MILES USED STOP LEAK TO KEEP IT GOING TILL 80000 MILES REPLACEING GASKETS AT THIS TIME CHEVY SAYS THERE IS NO PROBLEM YA RIGHT
THE PAINT ON THE PASSENGER-SIDE REAR QUARTER PANEL BEGAN TO TURN NOTICEABLY YELLOW SEVERAL MONTHS AGO. NOW THE PAINT HAS BEGUN TO BLISTER, SPLIT AND PEEL.
VEHICLE HAS A 3.1L V6 ENGINE THAT WAS LEAKING COOLANT AS A RESULT OF A CRACKED INTAKE MANIFOLD GASKET. I WAS TOLD BY MY MECHANIC THAT THEY ARE REPLACING THIS GASKET ON AT LEAST ONE VEHICLE A WEEK. AND THEY ARE JUST A SMALL SHOP. THE FIRST PROBLEM I NOTICED WITH THIS VEHICLE WAS A SLOW LEAK IN THE COOLING SYSTEM. THIS OCCURRED IN THE SUMMER OF 2002. LATER IN THE YEAR, I NOTICED COOLANT ON THE GARAGE FLOOR AND THOUGHT PERHAPS THE RADIATOR WAS LEAKING. WHEN I TOOK THE CAR IN TO BE REPAIRED ON DECEMBER 16, 2002, IT HAD 51,223 MILES ON IT. THE COST OF JUST REPAIRING THE INTAKE MANIFOLD GASKET WAS $482.21 PLUS TAX, FOR A TOTAL OF $512.35.
IT IS TERRIBLE THAT MY CAR IS ONLY 4 YEARS OLD AND THE PAINT IS PEELING OFF ALREADY, I'M VERY DIS SATISFIED WITH THE CAR. I WANT SOMETHING DONE ABOUT THIS PROBLEM.
1999 CHEVROLET MONTECARLO. E XPERIENCING "GRINDING NOISES" WITH LEFT TURNS AT ALL SPEEDS. AT LOW SPEED, CAR APPEARS TO WANT TO LOSE POWER WHEN MAKING LEFT TURNS. HAVE NOT EXPERIENCED POWER LOSS WITH RIGHT TURNS OR PROCEEDING STRAIGHT AFTER STOP. *AK
AT 31K INTAKE MANIFOLD GASKET AND TRANS PAN GASKET ARE LEAKING ACCORDING TO CHEVROLET DEALERSHIP. AUTO HAS THE 3.1 L. ENGINE. DEALERSHIP NOT OVERLY CONCERNED AND THIS APPEARS TO BE NORMAL FOR A MONTE CARLO. INITIALLY THE TRANS PAN GASKET REPAIR WAS CONSIDERED AN OWNER MAINTENANCE RESPONSIBILITY RATHER THAN A COVERED EXTENDED WARRANTY ITEM. AFTER SPEAKING WITH DEALERSHIP AND ADVANTAGE A 2ND TIME, IT WAS DETERMINED THAT THE REPAIR WAS TO BE COVERED THROUGH THE WARRANTY. IN MY OPINION, CHEVROLET DOESN'T WANT TO STAND BEHIND ITS PRODUCT. I AM VERY DISAPPOINTED AND WILL DEFINITELY NEVER BUY ANOTHER GM PRODUCT. *JB
AT 31K INTAKE MANIFOLD GASKET AND TRANS PAN GASKET ARE LEAKING ACCORDING TO CHEVROLET DEALERSHIP. AUTO HAS THE 3.1 L. ENGINE. DEALERSHIP NOT OVERLY CONCERNED AND THIS APPEARS TO BE NORMAL FOR A MONTE CARLO. INITIALLY THE TRANS PAN GASKET REPAIR WAS CONSIDERED AN OWNER MAINTENANCE RESPONSIBILITY RATHER THAN A COVERED EXTENDED WARRANTY ITEM. AFTER SPEAKING WITH DEALERSHIP AND ADVANTAGE A 2ND TIME, IT WAS DETERMINED THAT THE REPAIR WAS TO BE COVERED THROUGH THE WARRANTY. IN MY OPINION, CHEVROLET DOESN'T WANT TO STAND BEHIND ITS PRODUCT. I AM VERY DISAPPOINTED AND WILL DEFINITELY NEVER BUY ANOTHER GM PRODUCT. *JB