1999 CHEVROLET LUMINA

3 recalls, 132 complaints - 88 TSBs

ENGINE AND ENGINE COOLING:ENGINE

Defect Description

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, ... Read more

Consequence

Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy

The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the ori... Read more

1,003,556 vehicles affected

Manufacturer: General Motors LLC

ENGINE AND ENGINE COOLING

Defect Description

GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROP... Read more

Consequence

IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.

Remedy

DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-... Read more

1,497,516 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

Defect Description

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Consequence

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Remedy

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

742 vehicles affected

Manufacturer: DELPHI

Complaint Statistics

132 total complaints 12 crashes 5 fires 18 injuries 2 deaths

Top Reported Components

Component	Complaints
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE	11
ENGINE AND ENGINE COOLING	9
ENGINE AND ENGINE COOLING:COOLING SYSTEM	9
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	7
ENGINE AND ENGINE COOLING:ENGINE	7
ELECTRICAL SYSTEM	6
STEERING	4
VEHICLE SPEED CONTROL	4
POWER TRAIN:AUTOMATIC TRANSMISSION	4
AIR BAGS:FRONTAL	4

Incident date: Aug 6, 2019

I WAS DRIVING THE CAR HOME AND IT SHUT OFF , NOW IT WON'T TURN BACK ON

Incident date: Nov 13, 2018

1999 CHEVROLET LUMINA LS. CONSUMER WRITES IN REGARDS TO VEHICLE SHUTTING OFF WHILE DRIVING. *LD THE CONSUMER STATED THE PASS-KEY 11 SECURITY SYSTEM ACTIVATED WHILE DRIVING CAUSING THE VEHICLE TO LOSE STEERING AND BRAKING FUNCTIONS WHILE BEING DRIVEN. *JS

Incident date: Oct 8, 2017

MY STEERING WHEEL HAS BEEN LOCKING UP WHILE DRIVING AND I HAVE ALMOST CRASHED INTO OTHER VEHICLES AND BUILDINGS.

Incident date: Apr 4, 2017

I TOOK MY CAR FOR A SERVICE REPAIR. (TUNE UP) ONLY TO DISCOVER ON THE WAYA AWKWARD SMELL AND MISFIRE. UPON ARRIVING I WAS NOTIFIED THAT THE INTERNAL HOOD INSULATION BROKE FREE AND CRUMBLED IN CHUNKS ON TOP OF MY FUEL INJECTOR AND CREATED A HEAT THAT MELTED FOUR OF THE FUEL INJECTOR WIRES COVERS AND... Read more

Fire

Incident date: Jun 12, 2015

TL* THE CONTACT OWNS A 1999 CHEVROLET LUMINA. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING OIL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE VALVE COVER GASKET FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER:... Read more

Incident date: Feb 26, 2015

TL* THE CONTACT OWNS A 1999 CHEVROLET LUMINA. THE CONTACT STATED THAT THE VEHICLE WAS NO LONGER OPERABLE. THE VEHICLE WAS INSPECTED BY A TECHNICIAN WHERE IT WAS DIAGNOSED THAT THE FAILURE WAS DUE TO THE HEAD GASKETS LEAKING WATER INTO THE PISTONS. THE HEAD GASKETS NEEDED TO BE REPLACED. THE CONTACT ... Read more

Incident date: Dec 15, 2015

DRIVING AT 70MPH THERE WAS A THERE WAS A LARGE INCREASE IN NOISE AND VIBRATION FOR A MINUTE FOLLOWED BY A LOUD BANG. INSPECTION REVEALED THAT AN EXPLOSIVE TIRE FAILURE HAD OCCURRED. SEVERAL PLACES ON THE SIDEWALL WERE TORN AND THE TREAD HAD BULGES ON IT. THE DEFECTIVE TIRE WAS REPLACED. 2 MONTHS... Read more

Incident date: Dec 8, 2015

TL* THE CONTACT OWNS A 1999 CHEVROLET LUMINA. THE CONTACT STATED THAT OIL WAS LEAKING ON THE EXHAUST MANIFOLD AND A BURNING ODOR WAS PRESENT. THE CONTACT RECEIVED NOTIFICATION OF NHSTA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CON... Read more

Incident date: Dec 2, 2014

BOUGHT 99 CHEVY LUMINA USED 5-6 MONTHS AGO CHECKED EVERYTHING OUT, FOUND NOTHING SERIOUS WITH CAR JUST MINOR TUNE UP NEEDED AND NEW TIRES. GAVE CAR TO MY SON AS A GOOD FIRST CAR, LAST NIGHT TOOK HIM TO FILL UP GAS TANK AND SMELLED GAS, LOOKED UNDER THE CAR AND SAW A DRIP COMING FROM WHAT APPEARS ... Read more

Incident date: Sep 1, 2014

1999 CHEVROLET LUMINA. CONSUMER WRITES IN REGARDS TO SEVERAL MECHANICAL PROBLEMS AND RECALL ISSUES. *SMD THE CONSUMER STATED THE VEHICLE CUT OFF, WHILE DRIVING ON THE HIGHWAY. IT WAS DETERMINED, THE IGNITION NEEDED TO BE REPLACED. ALSO, THE WIRING HARNESS IN THE STEERING COLUMN WENT OUT, THE EGR... Read more

Incident date: Sep 1, 2014

Incident date: Feb 20, 2013

WHILE DRIVING, MY CAR WILL JUST SUDDENLY CUT OFF AND THIS OCCURS WHETHER STOPPED AT THE LIGHT OR WHILE PRESSING THE ACCELERATOR. THE VOLT LIGHT COMES ON AND THE CAR JUST CUTS OFF AND THE STEERING WHEEL LOCKS UP. MY LOCAL CHEVROLET DEALER (YOUMAN'S CHEVROLET, MACON, GA) TRIED TO FIND OUT WHAT WAS T... Read more

Incident date: Feb 20, 2013

Incident date: Dec 3, 2011

I WAS DRIVING MY HUSBAND'S 1999 LUMINA. I STOPPED AT AN INTERSECTION TO WAIT TO MAKE A LEFT TURN. THE LIGHT CHANGED I PROCEEDED INTO THE INTERSECTION, I TURNED THE STEERING WHEEL, HOWEVER THE CAR PROCEEDED STRAIGHT. THE TIRES WOULD NOT TURN, HOWEVER THE STEERING WHEEL TURNED FREELY BUT THE TIRES WO... Read more

Incident date: Nov 15, 2011

GM SAFETY RECALL COMPLAINT: I BACKED OUT OF MY DRIVEWAY DROVE ABOUT HALF A BLOCK AND SMELLED SMOKE; RETURNED HOME, PARKED AND SAW SMOKE COMING FROM UNDER THE HOOD. RAISED HOOD AND FOUND ENGINE OWN FIRE IN SMALL FLAMES. I PROCEEDED TO POUR A SMALL BUCKET OF WATER ON THE FIRE AND IT WENT OUT. COINCIDE... Read more

Fire

Incident date: Apr 27, 2011

TL* THE CONTACT OWNS A 1999 CHEVROLET LUMINA. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING WATER FROM THE INTAKE MANIFOLD GASKET. A GAS-LIKE FUME WAS COMING FROM THE VENTS AND WOULD SPREAD THROUGHOUT THE VEHICLE CABIN. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSIS OR REPAIRS. THE MANUFACT... Read more

Incident date: Apr 27, 2011

Incident date: Mar 4, 2011

TL*THE CONTACTS OWNS A 1999 CHEVROLET LUMINA. THE CONTACT STATED THAT WHEN THE VEHICLE BEGAN TO SHIFT FROM THIRD TO FOURTH GEAR THE GEARS WOULD STICK AND THE VEHICLE WOULD LUNGE INTO THE NEXT GEAR. THE DEALER INSPECTED THE VEHICLE BUT WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT CO... Read more

Incident date: Sep 11, 2010

I HAVE A 1999 CHEVY LUMINA - THE INTAKE GASKET, STARTED LEAKING, GRADUALLY, NOW IT HAS A BAD LEAK. I READ GM HAS OR HAD A RECALL ON INTAKE GASKETS. *TR

Incident date: Aug 24, 2010

FUMES OF EVAPORATED COOLANT FROM FAULTY GASKET WERE SUCKED INTO VEHICLES VENTILATION SYSTEM. GM NEEDS TO TAKE RESPONSIBILITY. *TR

Incident date: Aug 15, 2009

WE OWN A 1999 CHEVROLET LUMINA LTZ WITH THE NATURALLY ASPIRATED L36 3.8L V6. THE VEHICLE HAS THE PROBLEM THAT IT LEAKS BOTH OIL AND ENGINE COOLANT INTERNALLY. IT HAS BEEN CHECKED OUT BY PROFESSIONALS AND HAS BEEN PROVEN TRUE. THE PROFESSIONAL DISCOVERED THE ENGINE IS LEAKING ALONG ABOUT THREE SEALS,... Read more

Incident date: May 25, 2010

I HAVE A 1999 CHEVY LUMINA, THAT IN 2007 BOTH THE REAR DOOR LATCHES BROKE A FEW MONTHS APART I CONTACTED THE DEALER BOTH TIMEAS AND HAD THE LATCH REPLACED AT A COST OF 2 APPROX. 200.00 EACH I HAD ASKED IF THERE WAS A DEFECT IN THE PART ONCE THE SAME THING HAPPENED TO THE OTHER REAR DOOR THEY REPLIED... Read more

Incident date: May 25, 2010

Incident date: Jun 20, 2007

COOLANT LEAK OFF OF BOTTOM SIDE OF MOTOR. I OWN A 3.1 LITER V6 AND THE COST OF REPLACEMENT IS OUTRAGEOUS CONSIDERING THAT I HAVE BEEN RESEARCHING THIS PROBLEM ON THE INTERNET AND HAVE SEVERAL POSTS THAT HAVE HAD THE SAME PROBLEM. I HAVE A 1999 CHEVY LUMINA, MY COOLANT LEAK STARTED OVER 2 YEARS AGO.... Read more

Incident date: Apr 16, 2009

I BEGAN HAVING PROBLEMS WITH MY CAR OVERHEATING. I CHANGED THE THERMOSTAT AND ALL THE RADIATOR HOSES IN ORDER TO FIX THE PROBLEM. THINKING THAT THIS CORRECTED THE PROBLEM BECAUSE MY MECHANIC COULD NOT FIND A LEAK I CONTINUED TO DRIVE THE CAR. IT WAS NOT UNTIL I HAD TO START USING THE HEATER IN OCT... Read more

Incident date: Jul 29, 2009

TL*THE CONTACT OWNS A 1999 CHEVROLET LUMINA. WHILE DRIVING 25 MPH, THE CONTACT NOTICED SMOKE COMING OUT OF THE VENTS IN THE PASSENGER COMPARTMENT. SHE STOPPED THE VEHICLE, OPENED THE HOOD, AND NOTICED FLAMES COMING FROM THE ENGINE. THE FIRE OCCURRED WITHOUT WARNING. THE FIRE DEPARTMENT WAS CALLE... Read more

Fire

Incident date: Jul 6, 2009

MY LUMINA SUDDENLY BEGAN TO LOOSE REFRIGERANT CAUSING THE CAR TO OVERHEAT. TOOK THE CAR TO SEVERAL SHOPS INCLUDING A DEALERSHIP AND THE DIAGNOSIS WAS A LOWER MANIFOLD GASKET. EACH AND EVERY REPAIR FACILITY SAID THIS IS VERY COMMON IN THE LUMINA. WITH 56000 MILES I AM NOW FACED WITH A VERY EXPENSIVE ... Read more

Incident date: Apr 1, 2009

1999 CHEVY LUMINA IS LEAKING OIL FROM THE VALVE COVER GASKET AS CONFIRMED BY TWO SEPARATE MECHANICS. GM HAS ISSUED A RECALL DUE TO FIRE HAZARD FOR THIS ISSUE BUT ONLY AUTHORIZES DEALERS TO REPLACE THE SPARK PLUG CHANNEL TO PREVENT THE SPREAD OF FIRE. OIL CAN STILL LEAK INTO THE MANIFOLD, WHICH DUE T... Read more

Incident date: Oct 10, 2008

VEHICLE KILLS WHILE ACCELERATING FROM A STOP. NOT EVERY TIME BUT I'VE BEEN STUCK IN THE MIDDLE OF AN INTERSECTION TRYING TO RESTART IT FROM A STOP LIGHT. *TR

Incident date: May 3, 2009

TL*THE CONTACT OWNS A 1999 CHEVROLET LUMINA. THE CONTACT STATED THAT HIS VEHICLE WAS EXPERIENCING FAILURES SIMILAR TO THOSE LISTED IN NHTSA CAMPAIGN ID NUMBER 09V116000. A MECHANIC NOTICED THE FAILURE AND STATED THAT IT WOULD COST MONEY TO REPAIR. CHEVROLET STATED THAT THE VIN WAS NOT INCLUDED IN... Read more

Incident date: Mar 3, 2009

TURN SIGNAL SWITCH CAUSES REAR BRAKE LIGHTS NOT TO WORK. I DIDN'T FIND OUT ABOUT IT UNTIL A POLICE OFFICER PULLED ME OVER FOR THE BRAKE LIGHTS NOT COMING ON. I WAS LET OFF WITH A WARNING. I DID A SEARCH ONLINE AND FOUND THAT THERE IS A LOT OF PEOPLE WITH THE SAME PROBLEM AS ME WITH THE SAME MODEL VE... Read more

Incident date: Mar 3, 2009

Incident date: May 1, 2005

1999 CHEVROLET LUMINA STALLED WITHOUT WARNING. CONSUMER STATES THAT THE VEHICLE STALLED A SECOND TIME AND WAS RESTARTED. DEALER HAS STATED THEY COULD NOT FIND ANYTHING WRONG WITH THE VEHICLE. HE STATES HE CAN ONLY DRIVE IT SHORT DISTANCES. *KB

Incident date: Feb 7, 2008

CAR CAUGHT FIRE IN MY DRIVEWAY 10 MINUTES AFTER I RETURNED HOME. LUCKILY NO ONE WAS INJURED AND FIRE DEPT. WAS ABLE TO PUT OUT FIRE BEFORE IT SPREAD TO MY HOME. FIRE INSPECTOR SAID IT LOOKED LIKE IT WAS CAUSED BY THE FUEL INJECTORS. *TR

Fire

Incident date: Feb 7, 2008

Fire

Incident date: Jan 11, 2008

I HAVE A 1999 CHEVY LUMINA PURCHASE NEW IN 1999. THE INTAKE GASKET HAS BEN SERVICED ON 3/14/03 AT $216, ON 12/15/03 CAR SMOKING AND FLUID LEAKING AGAIN AND THIS WAS $737. NOW I HAVE BEEN FACED WITH THE SAME PROBLEMS. FOR SEVERAL WEEKS I WAS ADDING COOLANT ON A WEEKLY BASIS UNTIL IT STARTED TO BE ... Read more

Incident date: Aug 1, 2007

TL*THE CONTACT OWNS A 1999 CHEVROLET LUMINA. WHEN THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR SCHEDULED MAINTENANCE, SHE WAS INFORMED THAT THE INTAKE GASKET NEEDED TO BE REPLACED. THE REPAIR WILL COST $1,000. THE CURRENT AND FAILURE MILEAGES WERE 51,000.

Incident date: Jan 1, 1901

1999 LUMINA CUSTOMER STATES THAT HE HAD TO REPLACE THE RIGHT OUTER TIE ROD BECAUSE IT WAS ABOUT TO FALL OFF**CC THE CONSUMER STATED WHEN THE JOINTS WERE SEALED AT THE MANUFACTURING PLANT, THEY SHOULD HAVE PROPERLY LUBRICATED THE PART. *JB

Incident date: Feb 25, 2007

VEHICLE WAS RUNNING HOT. TOOK IT TO MIDAS, MIDAS WHO SAID IT WAS A INTAKE MANIFOLD PROBLEM WITH THE PLASTIC CAP AND NEEDED TO REPLACE IT FOR TOTAL OF 700.00. MIDAS SAID THEY HAVE HAD A LOT OF CUSTOMERS WITH SAME PROBLEM DUE TO ANTIFREEZE STRENGTH THE DEALERSHIP WAS REQUIRED TO PUT INTO VEHICLE. ... Read more

Incident date: Feb 25, 2007

Incident date: Aug 1, 2006

BRAKE LIGHTS NOT WORKING OR WORKING ON/OFF. FOUND THE CAUSE TO BE THE TURN SIGNAL SWITCH AFTER REPLACING THE STOP LIGHT SWITCH SEVERAL TIMES. THIS PROBLEM IS VERY DANGEROUS AND SHOULD BE REPAIRED BY THE MANUFACTURER AT NO COST TO THE OWNERS OF THE CARS. *JB

Incident date: Aug 1, 2006

Incident date: Aug 11, 2006

BRAKE LIGHTS DO NOT WORK. THIRD BRAKE LIGHT IN BACK DASH WORKS. THE BRAKE LIGHTS WORK SOMETIMES WHEN THE TURN SIGNAL SWITCH IS USED. BULBS AND FUSES ARE O.K. *JB

Incident date: Feb 23, 2006

DT*: THE CONTACT STATED THE PASSENGER COMPARTMENT INTERMITTENTLY FILLS WITH FUMES AFTER THE ENGINE HAS BEEN RUNNING FOR 30 MINUTES. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER ON THREE OCCASIONS, BUT THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM BECAUSE THE FUMES WERE NEVER PRESENT AT THE TIME OF... Read more

Showing 50 of 132 complaints.

Technical Service Bulletins, 1999 CHEVROLET LUMINA

88 manufacturer communications from 62 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	9
356000 EQUIPMENT ADAPTIVE/MOBILITY	5
110000 ELECTRICAL SYSTEM	5
061000 ENGINE AND ENGINE COOLING:ENGINE	5
061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	4
090000 FUEL SYSTEM, OTHER	4
100000 POWER TRAIN	4
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	4

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and

030000 SERVICE BRAKES, HYDRAULIC

110000 ELECTRICAL SYSTEM

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.

350000 EQUIPMENT

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock ce

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

350000 EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

350000 EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock c

356000 EQUIPMENT ADAPTIVE/MOBILITY

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock c

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock c

118000 ELECTRICAL SYSTEM:SOFTWARE

350000 EQUIPMENT

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

070000 FUEL SYSTEM, GASOLINE

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides policy information with the field action courtesy transportation policy.

118000 ELECTRICAL SYSTEM:SOFTWARE

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT A CONDITION OF THE REAR ENTERTAINMENT SYSTEM NOT OPERATING AS INTENDED IN COLDER AMBIENT TEMPERATURE AREAS DUE TO CALIBR

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about cooler line fittings that come with the 4T65E General Motors remanufactured transmission may not be the same as Original equipment manufacturer quick co

103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

100000 POWER TRAIN

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Vehicle Recalls

070000 FUEL SYSTEM, GASOLINE

This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle.

100000 POWER TRAIN

This preliminary bulletin provides a way to aid the technician in diagnosing transmission fluid leaking from the trans breather vent.

200000 WHEELS

Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the whe

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

200000 WHEELS

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

161100 STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS

Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle's underbody components are showing some fo

356000 EQUIPMENT ADAPTIVE/MOBILITY

161100 STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS

356000 EQUIPMENT ADAPTIVE/MOBILITY

110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that have a Supplemental Inflatable Restraint lamp, Service Vehicle Soon lamp on and/or radio locked, possibly after module replacement. Techni

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE

118000 ELECTRICAL SYSTEM:SOFTWARE

GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE

110000 ELECTRICAL SYSTEM

GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

BUICK\CHEVROLET\GMC SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. CSC LETTER WAS RECEIVED. *PE

353000 EQUIPMENT:ELECTRICAL

BUICK\CADILLAC\CHEVROLET\GMC\HUMMER\OLDSMOBILE\PONTIAC\SAAB\SATURN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. FCC RULED IN 2002 WIRELESS CARRIERS WOULD NO LONGER R

061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE OIL OR COOLANT LEAK. *TT GM REMINDER. *TT INSTALL NEW LOWER INTAKE MANIFOLD GASKET. UPDATED 7/18/08 *PE

062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

ENGINE COOLANT CONSUMPTION OR COOLANT LEAK (INSPECT FOR MATERIAL DEGRADATION/REPLACE INTAKE MANIFOLDS) *TT UPDATED 11/02/07 *NJ

046300 SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR

REVISED FRONT WHEEL SPEED SENSOR REPLACEMENT PROCEDURE. *TT

180000 VEHICLE SPEED CONTROL

INTERMITTENT CHUGGLE OR FISHBITE ON LIGHT ACCELERATION OR A HIGHWAY SPEEDS WITH NO DIAGNOSTIC TROUBLE CODES (DTCS). *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME OWNERS MAY COMMENT ON A TRANSMISSION OIL LEAK. *TT UPDATED *EH

061000 ENGINE AND ENGINE COOLING:ENGINE

NEW REAR MAIN SEAL AND SPECIAL TOOL FOR INSTALLATION. *TT

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

NEW UPPER INTAKE MANIFOLD AND GASKET KITS. *TT

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

ENGINE INTAKE MANIFOLD COOLANT LEAK. *SC

100000 POWER TRAIN

NO TCC APPLY, MALFUNCTION INDICATOR LAMP (MIL) ON, TCC SURGE, POSSIBLE P0740, P1870, OR 39 AFTER INSTALLATION OF A REMAN (SRTA) 4T60/4T60E. *TT

110000 ELECTRICAL SYSTEM

DIAGNOSTIC TROUBLE CODE B1000. *MR

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

THE 4T65E AUTOMATIC TRANSMISSION MAY EXHIBIT A CONDITION OF A HARSH GARAGE SHIFT INTO REVERSE OR DRIVE ON A COLD START. *TT

114000 ELECTRICAL SYSTEM:WIRING

WIRE HARNESS MAY BE STRETCHED, OR THE PCS MAY NOT BE ORIENTED IN THE SAME POSITION, AFTER INSTALLING A SERVICE REPLACEMENT VALVE BODY ASSEMBLY. GM TECH LINK. *TT

060000 ENGINE AND ENGINE COOLING

ENGINE OIL OR COOLANT LEAK. *TT

140000 AIR BAGS

SOME VEHICLES HAVE A PASSENGER AIRBAG THAT WAS MANUFACTURED WITHOUT A CHECK PIN. AN AIRBAG WITHOUT THE CHECK PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIRBAG DEPLOYMENT AND REDUCE PRESSURE AFTERWARDS. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

REVISED PISTON PIN REMOVAL / INSTALLATION PROCEDURE. *TT

980000 UNKNOWN OR OTHER

INFORMATION ON SERVICING 4T65-E TRANSAXLE SPACER PLATE AND GASKETS FOR VARIOUS MODELS FROM 1997 THROUGH 2002. *TT

102000 POWER TRAIN:MANUAL TRANSMISSION

CONCERNS WITH SLIPS, HARSH UPSHIFT OR GARAGE SHIFTS, LAUNCH SHUDDERS, FLARES, ERRATIC SHIFTS AND INTERMITTENT CONCERNS, DIAGNOSTIC TROUBLE CODE P1811 OR P0748 SET. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

SOME OWNERS MAY COMMENT ON A REPEAT ENGINE OIL PAN LEAK. *TT

980000 UNKNOWN OR OTHER

INFORMATION ON SERVICING 4T65E TRANSAXLE SPACER PLATE AND GASKETS. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SUBJECT REGARDING REVISED LOWER INTAKE MANIFOLD INSTALLATION. *TT

100000 POWER TRAIN

SUBJECT REGARDING WHINE NOISE IN PARK OR NEUTRAL, SERVICE ENGINE SOON OR SERVICE VEHICLE SOON LAMP ILLUMINATION. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SUBJECT REGARDING POLYMER SERVICE PISTONS. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME OWNERS MAY COMMENT ON DRIVEABILITY SYMPTONS OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE DUE TO CLOGGED FUEL INJECTORS. *TT

090000 FUEL SYSTEM, OTHER

A CONDITION MAY EXIST IN WHICH THE FUEL GAUGE READS INCORRECTLY / FLUCTUATES, LOW FUEL CHIME SOUNDS PREMATURELY. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

OWNERS OF SOME VEHICLES EQUIPPED WITH HYDRA-MATIC 3T40, 4T60, 4T60-E OR 4T65-E TRANSAXLES MAY COMMENT ON A GRINDING AND / OR GROWLING NOISE THAT IS NOTICEABLE WHEN STANDING IN PARK ON A HILL OR SLOPE WITH THE ENGINE RUNNING AND THE PARKING

061000 ENGINE AND ENGINE COOLING:ENGINE

SOME OWNERS MAY COMMENT ON A REPEAT ENGINE OIL PAN LEAK. *TT

980000 UNKNOWN OR OTHER

INFORMATION REGARDING EXTRA CLIPS IN THE 4T65E TRANSMISSION. *SLC

135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

SOME CUSTOMERS MAY COMMENT THAT THE BLACK PLASTIC HOUSING AROUND THE OUTSIDE REAR VIEW MIRROR TURNS CHALKY OR IS DULL IN COLOR. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

SOME OWNERS OF VEHICLES WITH A HYDRA-MATIC 4T65-E TRANSAXLE MAY COMMENT ON HARSH UPSHIFTS OR HARSH GARAGE SHIFTS, SOFT SHIFTS, SHUDDERS ON HARD ACCELERATION, OR SHIFTS ERRATIC. *TT

090000 FUEL SYSTEM, OTHER

SOME CUSTOMERS MAY COMMENT ON THE FOLLOWING CONDITIONS: 1) THE FUEL GAUGE READING INCORRECTLY. 2) LOW FUEL CHIME SOUNDS PREMATURELY. 3) FUEL GAUGE MAY FLUCTUATE FROM FULL TO EMPTY. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

SOME VEHICLES EQUIPPED WITH HYDRA-MATIC 3T40, 4T60 OR 4T60-E TRANSXALES MAY COMMENT ON A GRINDING AND / OR GROWLING NOISE THAT IS NOTICEABLE WHEN IN PARK ON INCLINE. *TT

090000 FUEL SYSTEM, OTHER

CONDITIONS WITH INACCURATE FUEL GAUGE / FLUCTUATES, PREMATURE LOW FUEL CHIME. *TT

090000 FUEL SYSTEM, OTHER

SOME CUSTOMERS MAY COMMENT THAT THE FUEL GAUGE READS INCORRECTLY / FLUCTUATES, AND THE LOW FUEL CHIME SOUNDS PREMATURELY. *TT

355100 EQUIPMENT:OTHER:LABELS

SUBJECT ON 98067-PRODUCT EMISSION CAMPAIGN EMISSION LABEL ERROR. *MJS

355100 EQUIPMENT:OTHER:LABELS

PRODUCT EMISSION CAMPAIGN REGARDING EMISSION LABEL ERROR. *TT

355100 EQUIPMENT:OTHER:LABELS

PRODUCT EMISSION CAMPAIGN INFORMATION REGARDING EMISSION LABEL ERROR. *TT

160000 STRUCTURE

SUBJECT REGARDING CUSTOMER SATISFACTION CAMPAIGN - INCORRECT INVOICE, PRICE LABEL AND BODY EMBLEM. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SUBJECT ON ENGINE MISFIRE - INSPECT/ REPLACE IGNITION CONTROL MODULE. *YC

121000 EXTERIOR LIGHTING:HEADLIGHTS

IPC, INTERIOR LIGHTS AND/OR HEADLAMPS FLICKER. *AK FB2

330000 INTERIOR LIGHTING

IPC, INTERIOR LIGHTS AND/OR HEADLAMPS FLICKER. *AK FB2

040000 SERVICE BRAKES, AIR

ABS PUMP RUNNING WHEN NOT NEEDED. *NJ

NHTSA Safety Investigations, CHEVROLET LUMINA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 1996

INAPPROPRIATE AIR BAG DEPLOYMENT