2017 CHEVROLET EXPRESS
6 recalls, 30 complaints - 1,464 TSBs
19V428000 Jun 11, 2019
EQUIPMENT
Defect Description
Unicell Body Company Inc. (Unicell) is recalling certain 2017-2019 Chevrolet Express and GMC Savanna, 2018-2019 Hino 155, Ford Econoline and Transit and Isuzu NPR, and 2018 Ram ProMaster-based vehicles equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The affe... Read more
Consequence
The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.
Remedy
Unicell will work with ASA Electronics to notify owners and offer a remedy, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics customer service 1-800-384-4400 or Unicell at 1-716-853-8628.
19V387000 May 23, 2019
VISIBILITY:GLASS, SIDE/REAR
Defect Description
General Motors LLC (GM) is recalling certain 2016-2019 Chevrolet Express and GMC Savana vehicles. One or both of the rear-quarter windows may be tempered glass instead of laminated glass. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) ... Read more
Consequence
Tempered glass increases the risk of injury in the event of a side impact or rollover crash.
Remedy
GM will notify owners, and dealers will replace the tempered glass windows with laminated glass windows, as necessary, free of charge. The recall began July 5, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N192218960.
18V655000 Sep 21, 2018
ELECTRICAL SYSTEM
Defect Description
General Motors LLC (GM) is recalling certain 2016-2018 Chevrolet Express and GMC Sierra vehicles equipped with a single, manual, rear climate control module (CCM). If the temperature is set to maximum heat or the mode knob is set to maximum floor vent and an electrical short occurs, components with... Read more
Consequence
If the CCM overheats, there is an increased risk of a fire in the vehicle's headliner.
Remedy
GM will notify owners, and dealers will remove the electrical insulation from a wiring connector within the CCM to remove the fire risk, free of charge. The recall began November 6, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM... Read more
18V295000 May 3, 2018
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
Defect Description
General Motors LLC (GM) is recalling certain 2014-2017 Chevrolet Express and GMC Savana vehicles equipped with power windows. Liquid may leak into the driver's power window switch and cause corrosion, resulting in high electrical resistance.
Consequence
High electrical resistance can increase the risk of a fire.
Remedy
GM will notify owners, and dealers will replace the driver side window switch, free of charge. The recall began August 10, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 18155.
18V267000 Apr 26, 2018
EQUIPMENT
Defect Description
General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pin... Read more
Consequence
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy
GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM... Read more
16V700000 Sep 29, 2016
VISIBILITY:REARVIEW MIRRORS/DEVICES
Defect Description
General Motors LLC (GM) is recalling certain model year 2016-2017 Chevrolet Express manufactured September 25, 2015, to August 22, 2016, and 2016 GMC Savana cargo and cutaway vans manufactured January 28, 2016, to May 18, 2016. The affected vehicles were manufactured without an inside rearview mirr... Read more
Consequence
If the driver does not have a clear unobstructed view to the back of the vehicle, it can increase the risk of a crash.
Remedy
GM will notify owners, and dealers will instal a right-hand flat rearview mirror, free of charge. The recall began on November 8, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16036.
Complaint Statistics
30 total complaints
3 crashes
Top Reported Components
| Component | Complaints |
|---|---|
| SERVICE BRAKES | 7 |
| ENGINE | 4 |
| ELECTRICAL SYSTEM | 4 |
| STEERING | 2 |
| AIR BAGS | 2 |
| ENGINE AND ENGINE COOLING | 2 |
| VEHICLE SPEED CONTROL | 1 |
| ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS | 1 |
| EXTERIOR LIGHTING | 1 |
| ELECTRONIC STABILITY CONTROL (ESC) | 1 |
ENGINE
Sep 9, 2024
Incident date: Aug 20, 2024
While driving our 2018 Chevy Volt, dashboard warning message “Propulsion Power Reduced” displayed. Vehicle performance was not otherwise affected. Subsequent diagnosis from our Chevy Dealer was, among other things, a faulty Exhaust Gas Recirculation (EGR) valve. We were informed that our vehi... Read more
POWER TRAIN
Apr 5, 2024
Incident date: Apr 3, 2024
The contact owns a 2013 Nissan Pathfinder. The contact stated while driving at various speeds, the vehicle was shuddering. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the transmission needed to be replaced. The... Read more
SERVICE BRAKES, HYDRAULIC
Apr 1, 2024
Incident date: Mar 29, 2024
The contact owns a 2012 Kia Sorento. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable a... Read more
LANE DEPARTURE: WARNING
Apr 1, 2024
Incident date: Mar 29, 2024
When crossing the border into Mexico the AEB module falsely reports it has malfunctioned due to "geo fence" limitations. At least that is the cause of the issue per the service department. This causes the AEB system to stay offline and inoperable which also affects the Lane Departure Warning Syste... Read more
ELECTRICAL SYSTEM
Apr 1, 2024
Incident date: Mar 6, 2024
When crossing the border into Mexico the AEB module falsely reports it has malfunctioned due to "geo fence" limitations. At least that is the cause of the issue per the service department. This causes the AEB system to stay offline and inoperable which also affects the Lane Departure Warning Syste... Read more
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Apr 1, 2024
Incident date: Mar 6, 2024
Vehicle nearly went off road from ABS prematurely activating. ABS module needed. part number 84055065 unavailable through GM. Parked Van as it is too dangerous to drive.
SERVICE BRAKES
Apr 1, 2024
Incident date: Mar 8, 2024
ABS Module Broken. Needs repair. No part available. Part Number 84055065 needed. Vehicle was on highway slowed on to onramp when ABS went off for no reason. Van Pulled to right drastically.
ENGINE AND ENGINE COOLING
Apr 1, 2024
Incident date: Mar 8, 2024
The contact owns a 2017 Ford Escape. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated on the instrument panel. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified ... Read more
SERVICE BRAKES
Apr 1, 2024
Incident date: Mar 20, 2024
The manufacturer (Hyundai) has been ordered to recall and fix my 2013 Elantra and they are not doing so. On their website it says "Incomplete. Remedy not yet available." This recall was issued LAST YEAR, over 5 months ago! Hyundai has had 5 months to not only fix the issue, but at least notify own... Read more
ELECTRICAL SYSTEM
Apr 1, 2024
Incident date: Mar 20, 2024
The manufacturer (Hyundai) has been ordered to recall and fix my 2013 Elantra and they are not doing so. On their website it says "Incomplete. Remedy not yet available." This recall was issued LAST YEAR, over 5 months ago! Hyundai has had 5 months to not only fix the issue, but at least notify own... Read more
ENGINE AND ENGINE COOLING
Feb 23, 2024
Incident date: Apr 2, 2023
The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall r... Read more
STEERING
Feb 23, 2024
Incident date: Apr 2, 2023
STEERING WENT OUT AND TRUCK ROLLED. VERIFIED PER MECHANIC FAILURE ON RECALLED PART/S
Crash
ENGINE
Jan 11, 2024
Incident date: Oct 5, 2023
A/C failure & Heat Failure which resulted in an accident. Was not the thermostat. ACCEDENT was unable to defrost/defog windows, causing the driver to crash
Crash
SERVICE BRAKES
Aug 29, 2023
Incident date: Sep 10, 2019
while driving brakes become stiff, hard to press pedal down. no lights came on or any other kind of warning. had a close call with vehicle in from of me, had to swerve out of way.
ENGINE
May 22, 2023
Incident date: May 22, 2023
Just had oil changed, and accelerating onto highway when the check engine light came on and a loud knocking in the engine, with no acceleration. A semi truck had to swerve to miss me due to lack of acceleration. Took it to my mechanic who said there were 6 recalls on this vehicle, one of which was a... Read more
VISIBILITY
Feb 18, 2022
Incident date: Mar 23, 2018
The contact owns a 2017 Chevrolet Express. The contact stated while driving approximately 65 MPH, the driver's side exterior split mirror failed to operate correctly and the contact was unable to see the lane to his left, nor to the rear of the vehicle. The contact took the vehicle to the local deal... Read more
ELECTRONIC STABILITY CONTROL (ESC)
May 21, 2020
Incident date: May 19, 2020
SERVICE AIRBAG, SERVICE TRACTION CONTROL AND SERVICE STABILITRAC POP UP ON THE DRIVER INFORMATION CENTER SCREEN RANDOMLY AND GO AWAY RANDOMLY. I HAVE NOTICED THE AIRBAG WARNING HAPPENS MORE FREQUENTLY WHEN THE ROADS ARE WET. VEHICLE WAS JUST AT DEALER FOR SERVICE AND THEY COULDN'T FIND THE PROBLEM. ... Read more
AIR BAGS
May 21, 2020
Incident date: May 19, 2020
SERVICE AIRBAG, SERVICE TRACTION CONTROL AND SERVICE STABILITRAC POP UP ON THE DRIVER INFORMATION CENTER SCREEN RANDOMLY AND GO AWAY RANDOMLY. I HAVE NOTICED THE AIRBAG WARNING HAPPENS MORE FREQUENTLY WHEN THE ROADS ARE WET. VEHICLE WAS JUST AT DEALER FOR SERVICE AND THEY COULDN'T FIND THE PROBLEM. ... Read more
AIR BAGS
May 20, 2020
Incident date: May 20, 2020
AIR BAG SENSOR HAS GONE BAD IT'S IN THE LEFT DOOR. *TR
EXTERIOR LIGHTING
Oct 25, 2019
Incident date: Aug 1, 2018
TL* THE CONTACT OWNS A 2017 CHEVROLET EXPRESS G-3500. WHILE OPERATING THE VEHICLE, THE TAIL LIGHTS AND DAYTIME RUNNING LAMPS ON BOTH THE PASSENGER AND DRIVER SIDES WOULD NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO CHEVROLET OF WAYZATA (16200 WAYZATA BLVD, WAYZATA, MN) WHERE THE LIGHTS WERE REPLACED, BU... Read more
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
Oct 25, 2019
Incident date: Aug 1, 2018
TL* THE CONTACT OWNS A 2017 CHEVROLET EXPRESS G-3500. WHILE OPERATING THE VEHICLE, THE TAIL LIGHTS AND DAYTIME RUNNING LAMPS ON BOTH THE PASSENGER AND DRIVER SIDES WOULD NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO CHEVROLET OF WAYZATA (16200 WAYZATA BLVD, WAYZATA, MN) WHERE THE LIGHTS WERE REPLACED, BU... Read more
ELECTRICAL SYSTEM
Oct 25, 2019
Incident date: Aug 1, 2018
TL* THE CONTACT OWNS A 2017 CHEVROLET EXPRESS G-3500. WHILE OPERATING THE VEHICLE, THE TAIL LIGHTS AND DAYTIME RUNNING LAMPS ON BOTH THE PASSENGER AND DRIVER SIDES WOULD NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO CHEVROLET OF WAYZATA (16200 WAYZATA BLVD, WAYZATA, MN) WHERE THE LIGHTS WERE REPLACED, BU... Read more
ELECTRICAL SYSTEM
Oct 16, 2019
Incident date: May 8, 2019
TL- THE CONTACT SENT THE COMPLAINT VIA EMAIL TO BE USED: ON 5/08/19 AFTER SEVERAL COMPLAINTS FROM OUR DRIVER THAT THE ELECTRICAL SYSTEM IN OUR 2017 EXPRESS CHEVY SHUTDOWN WHEN HITTING A BUMP OR SLAMMING THE DRIVER DOOR WE DECIDED IT WAS TIME TO GET IT CHECKED OUT VAN WAS NOT PURCHASED FROM AUTO NATI... Read more
Crash
SERVICE BRAKES
Sep 17, 2019
Incident date: Sep 1, 2019
TL* THE CONTACT OWNS A 2017 CHEVROLET EXPRESS 3500. WHILE DRIVING 35 MPH, THE BRAKE LIGHT AND ABS STABILIZED TRACK LIGHT ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO INSPECTED THE VEHICLE AND STATED THAT THE BRAKE STABILIZER SYSTEM FAILED AND THE BRAKE PUMP MOTOR NEEDED T... Read more
SERVICE BRAKES
May 7, 2019
Incident date: May 1, 2019
MY EMPLOYER HAS THREE ON A LEASE WITH BAD MASTER CYLINDER REAR SECTION PROPORTIONING VALVE NOT ALLOWING COLD DRIVING REAR BRAKES UNLESS PUMPING BRAKE PEDAL HARD.
ENGINE
Apr 15, 2019
Incident date: Sep 27, 2018
WE'VE HAD 4 INSTANCES OF "ENGINE POWER REDUCED" AND CHECK ENGINE LIGHT, WITH NO PRIOR WARNING OF ISSUE ON THE DASH DISPLAY. I BELIEVE THIS IS DUE TO AN ISSUE WITH THE DIESEL PARTICULATE FILTER SOOT LOAD TRACKING. THE FIRST 3 OCCURRED ON RURAL HIGHWAY AND THE 4TH ON A LOCAL HIGHWAY AT SPEED. THE POW... Read more
VEHICLE SPEED CONTROL
Feb 3, 2019
Incident date: Nov 21, 2018
ABS WARNING LIGHT RANDOMLY ILLUMINATES, YOU CAN STOP, THEN RESTART THE ENGINE, AND IT WILL SOMETIMES GO OUT. CRUISE CONTROL RANDOMLY WILL NOT WORK
SERVICE BRAKES
Feb 3, 2019
Incident date: Nov 21, 2018
ABS WARNING LIGHT RANDOMLY ILLUMINATES, YOU CAN STOP, THEN RESTART THE ENGINE, AND IT WILL SOMETIMES GO OUT. CRUISE CONTROL RANDOMLY WILL NOT WORK
SERVICE BRAKES
Oct 5, 2017
Incident date: Oct 2, 2017
MY COMPANY JUST RECENTLY PURCHASED DOZENS OF 2017 CHEVY EXPRESS VANS. ONE OF THESE NEW VANS (16 MILES ON ODOMETER) EXPERIENCED A FAULTY BRAKE BOOSTER MECHANICAL ISSUE WHICH CAUSED THE BRAKES TO ENGAGE WHILE TURNING THE STEERING WHEEL. THE DESIGN OF THE BRAKE BOOSTER INTEGRATION WITH THE POWE... Read more
STEERING
Oct 5, 2017
Incident date: Oct 2, 2017
MY COMPANY JUST RECENTLY PURCHASED DOZENS OF 2017 CHEVY EXPRESS VANS. ONE OF THESE NEW VANS (16 MILES ON ODOMETER) EXPERIENCED A FAULTY BRAKE BOOSTER MECHANICAL ISSUE WHICH CAUSED THE BRAKES TO ENGAGE WHILE TURNING THE STEERING WHEEL. THE DESIGN OF THE BRAKE BOOSTER INTEGRATION WITH THE POWE... Read more
Technical Service Bulletins, 2017 CHEVROLET EXPRESS
1,464 manufacturer communications from 824 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 250 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 140 |
| 060000 ENGINE AND ENGINE COOLING | 118 |
| 110000 ELECTRICAL SYSTEM | 109 |
| 100000 POWER TRAIN | 102 |
| 060000 ENGINE (PWS) | 74 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 64 |
| 200000 WHEELS | 43 |
00-03-10-006P
Apr 18, 2024
200000 WHEELS
This service bulletin provides information for dealers/technicians on Tire Radial Force Variation (RFV).
N232428780-01
Apr 17, 2024
100000 POWER TRAIN
Certain vehicles may have a condition in which the transmission Control Valve Body Ball Check Valves can wear prematurely resulting in the possibility for them to become stuck or pass through the Control Valve Body Spacer Plate. The custome
N232428780-01
Apr 17, 2024
060000 ENGINE AND ENGINE COOLING
Certain vehicles may have a condition in which the transmission Control Valve Body Ball Check Valves can wear prematurely resulting in the possibility for them to become stuck or pass through the Control Valve Body Spacer Plate. The custome
20-NA-132
Apr 10, 2024
350000 EQUIPMENT
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Apr 10, 2024
110000 ELECTRICAL SYSTEM
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
17-NA-052
Apr 8, 2024
350000 EQUIPMENT
This bulletin updates the position of General Motors on refinishing aluminum wheels. GM has determined that wheel refinishing under warranty will no longer be performed.
17-NA-052
Apr 8, 2024
200000 WHEELS
This bulletin updates the position of General Motors on refinishing aluminum wheels. GM has determined that wheel refinishing under warranty will no longer be performed.
10-08-45-001H
Mar 28, 2024
110000 ELECTRICAL SYSTEM
This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
19-NA-255
Mar 27, 2024
160000 STRUCTURE
This preliminary informational bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only).
20-NA-132
Mar 26, 2024
118000 ELECTRICAL SYSTEM:SOFTWARE
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Mar 26, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Mar 26, 2024
350000 EQUIPMENT
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Mar 26, 2024
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Mar 26, 2024
110000 ELECTRICAL SYSTEM
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
19-NA-255
Mar 21, 2024
160000 STRUCTURE
This preliminary informational bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only).
23-NA-103
Mar 21, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on submitting quality Photos of Various Vehicle Concerns to the GM Technical Assistance Center (TAC).
16-NA-383
Mar 13, 2024
060000 ENGINE AND ENGINE COOLING
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
07-00-89-037S
Mar 11, 2024
350000 EQUIPMENT
This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.
11-00-89-005X
Mar 10, 2024
350000 EQUIPMENT
This Warranty Administration bulletin provides information on Dealer Empowerment for Goodwill, Customer Enthusiasm and Policy (U.S. Only).
PIP5596A
Mar 4, 2024
030000 BRAKES (PWS)
This Preliminary information communicates that when removing the fuel line jumper hose care should be taken to be sure the line is reinstalled correctly to avoid a no/low fuel pressure situation.
PIP5596A
Mar 4, 2024
070000 FUEL SYSTEM, GASOLINE
This Preliminary information communicates that when removing the fuel line jumper hose care should be taken to be sure the line is reinstalled correctly to avoid a no/low fuel pressure situation.
24-NA-040
Mar 4, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on All hazmat parts being returned to the Warranty Parts Center (WPC) must be shipped using Central Transport. Hazardous materials should never be sent by air transportation to the WPC.
17-NA-073
Mar 1, 2024
980000 UNKNOWN OR OTHER
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
PIP5968
Feb 27, 2024
100000 POWER TRAIN
This Preliminary information communicates to have the dealer contact TAC with the transmission TUN number prior to transmission installation.
PIP5966
Feb 23, 2024
100000 POWER TRAIN
This Preliminary information communicates Diagnostic aids for a no start or DTC'S following a transmission replacement
22-NA-074
Feb 22, 2024
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
16-NA-222
Feb 7, 2024
060000 ENGINE AND ENGINE COOLING
This bulletin provides information on Engine Concerns that could result from lack of scheduled maintenance, improper service or aftermarket calibrations.
19-NA-044
Feb 7, 2024
070000 FUEL SYSTEM, GASOLINE
This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.
19-NA-044
Feb 7, 2024
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.
N232428780
Feb 5, 2024
100000 POWER TRAIN
Customer Satisfaction Program - Certain vehicles may have a condition in which the transmission Control Valve Body Ball Check Valves can wear prematurely resulting in the possibility for them to become stuck or pass through the Control Valv
N232428780
Feb 5, 2024
060000 ENGINE AND ENGINE COOLING
Customer Satisfaction Program - Certain vehicles may have a condition in which the transmission Control Valve Body Ball Check Valves can wear prematurely resulting in the possibility for them to become stuck or pass through the Control Valv
16-NA-338
Feb 2, 2024
100000 POWER TRAIN
This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle
16-NA-338
Feb 2, 2024
060000 ENGINE AND ENGINE COOLING
This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle
PIT6122
Jan 31, 2024
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
This Preliminary information communicates to dealers of a known issue with failed map update
19-NA-255
Jan 18, 2024
160000 STRUCTURE
This preliminary informational bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only).
PI0281K
Jan 18, 2024
160000 STRUCTURE
This preliminary informational (PI) bulletin provides information to dealership personnel which may be helpful when addressing underbody component corrosion with customers.
22-NA-246
Jan 18, 2024
100000 POWER TRAIN
This service bulletin advises the technician that the possible cause may not be from a faulty clutch piston or extension housing and to perform testing on transmission for other possible issues, but it still may be possible on high mileage
18-NA-099
Jan 16, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
PI1394B
Jan 12, 2024
100000 POWER TRAIN
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
PI1394B
Jan 12, 2024
060000 ENGINE AND ENGINE COOLING
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
02-08-42-001J
Jan 12, 2024
120000 EXTERIOR LIGHTING
This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.
PIP5601B
Jan 12, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di
PI0592I
Jan 8, 2024
110000 ELECTRICAL SYSTEM
This preliminary information (PI) provides information om Service Programming System (SPS) Error Codes (E4398, E4399, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491 or E6961).
16-NA-361
Dec 20, 2023
350000 EQUIPMENT
This service bulletin provides service /diagnostic information to aid with a Transmission Harsh 1-2 Shift Upon First Start Up/Shift of the Day Under Light Throttle.
16-NA-361
Dec 20, 2023
100000 POWER TRAIN
This service bulletin provides service /diagnostic information to aid with a Transmission Harsh 1-2 Shift Upon First Start Up/Shift of the Day Under Light Throttle.
PIT5074P
Dec 18, 2023
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking
PIT5962A
Dec 15, 2023
110220 ELECTRICAL SYSTEM:HAND HEATER:WIRING HARNESS
This Preliminary information communicates a GM part number for reflective high temperature heat or insulating tape when repairing wiring harnesses.
PIT5962A
Dec 15, 2023
980000 UNKNOWN OR OTHER
This Preliminary information communicates a GM part number for reflective high temperature heat or insulating tape when repairing wiring harnesses.
23-NA-219
Dec 12, 2023
350000 EQUIPMENT
This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
23-NA-219
Dec 12, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
20-NA-132
Dec 8, 2023
060000 ENGINE AND ENGINE COOLING
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Dec 8, 2023
110000 ELECTRICAL SYSTEM
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Dec 8, 2023
350000 EQUIPMENT
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
PIP5700E
Nov 27, 2023
110000 ELECTRICAL SYSTEM
This Preliminary information communicates to the dealer technician that the part numbers for the internal wiring harnesses for the 8 speed RWD transmissions are not listed in the Electronic Parts Catalog. Technicians are to refer to the inf
PIT5214F
Nov 14, 2023
020000 SUSPENSION
This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts that are being performed on customer?s vehicles that exhibit vibration conditions without utilizing the
03-00-91-001I
Nov 6, 2023
200000 WHEELS
This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.
03-00-91-001I
Nov 6, 2023
100000 POWER TRAIN
This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.
03-00-91-001I
Nov 6, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.
03-00-91-001I
Nov 6, 2023
020000 SUSPENSION
This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.
03-00-91-001I
Nov 6, 2023
010000 STEERING
This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.
20-NA-159
Oct 30, 2023
200000 WHEELS
This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).
16-NA-361
Oct 19, 2023
100000 POWER TRAIN
This service bulletin provides service /diagnostic information to aid with a Transmission Harsh 1-2 Shift Upon First Start Up/Shift of the Day Under Light Throttle.
PIP5943
Oct 19, 2023
354800 EQUIPMENT:MECHANICAL:POWER TAKE-OFF (PTO)
This Preliminary Information communication advises the technician on diagnostic aids to help with the diagnosis and repair of 8 Speed Transmissions
PIP5943
Oct 19, 2023
100000 POWER TRAIN
This Preliminary Information communication advises the technician on diagnostic aids to help with the diagnosis and repair of 8 Speed Transmissions
22-NA-225
Oct 17, 2023
100000 POWER TRAIN
This information bulletin advises the technician the difference between a welch cap leak and the output seal of the t-case or transmission leaking ATF, causing the customer concern of a Red Fluid Leak from Center of Vehicle Located by Rear
22-NA-225
Oct 17, 2023
350000 EQUIPMENT
This information bulletin advises the technician the difference between a welch cap leak and the output seal of the t-case or transmission leaking ATF, causing the customer concern of a Red Fluid Leak from Center of Vehicle Located by Rear
23-NA-065
Oct 16, 2023
110000 ELECTRICAL SYSTEM
This service bulletin provides repair information to correct a customer concern of OnStar Inoperative after Importing Vehicle from Canada to the United States.
23-NA-065
Oct 16, 2023
350000 EQUIPMENT
This service bulletin provides repair information to correct a customer concern of OnStar Inoperative after Importing Vehicle from Canada to the United States.
05-00-89-029F
Oct 11, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on General Motors Dealership Critical Equipment Requirements and Recommendations.
01-06-01-011O
Oct 6, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
17-NA-170
Oct 6, 2023
200000 WHEELS
This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
99-00-89-019Y
Oct 3, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Warranty Administration bulletin provides information on the Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program.
20-NA-159
Sep 28, 2023
190000 TIRES
This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).
20-NA-159
Sep 28, 2023
200000 WHEELS
This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).
PIT5099G
Sep 26, 2023
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi
PIT5698D
Sep 26, 2023
110000 ELECTRICAL SYSTEM
This Preliminary information communicates additional information on how a LIN bus operates and diagnostic tips when working on a LIN bus.
02-00-89-002W
Sep 26, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).
10-00-89-006J
Sep 26, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
23-NA-154
Sep 21, 2023
350000 EQUIPMENT
This bulletin provides information on Warranty Administration a?? Required Operating Procedures - 8 Points (U.S. Only).
07-08-49-020R
Sep 21, 2023
117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
07-08-49-020R
Sep 21, 2023
350000 EQUIPMENT
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
07-08-49-020R
Sep 21, 2023
110000 ELECTRICAL SYSTEM
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
23-NA-142
Sep 15, 2023
100000 POWER TRAIN
This technical bulletin provides a procedure for the techs to replace the forward check ball and separator plate if found the cause of the customer's concern.
20-NA-142
Sep 13, 2023
100000 POWER TRAIN
This Technical bulletin provides a repair to correct a condition of Shudder/Surging While Driving.
17-NA-157
Sep 8, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin explains the difference in oil filters for gas engines with new oil pump control systems and the possibilities of what may happen using the incorrect filter.
23-NA-154
Sep 5, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information on Warranty Administration a?? Required Operating Procedures - 8 Points (U.S. Only).
PIP4112T
Sep 1, 2023
100000 POWER TRAIN
This Preliminary Information communication provides information to the technician of a complaint of a sag or hesitation when accelerating. The concern is present when coasting at low speeds of less than 15 miles per hour and then aggressive
23-NA-153
Sep 1, 2023
100000 POWER TRAIN
The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.
23-NA-153
Sep 1, 2023
060000 ENGINE AND ENGINE COOLING
The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.
18-NA-306
Sep 1, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Warranty Administration service bulletin provides information for dealers/Service advisors on when and how to submit a Pre-Repair Authorization (PRA).
PIP4112T
Sep 1, 2023
060000 ENGINE AND ENGINE COOLING
This Preliminary Information communication provides information to the technician of a complaint of a sag or hesitation when accelerating. The concern is present when coasting at low speeds of less than 15 miles per hour and then aggressive
18-NA-073
Aug 24, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
PIP5621D
Aug 24, 2023
100000 POWER TRAIN
This Preliminary information communicates to the dealer technician that TAC recommends the utilization of the GDS2 software to aid in diagnosing automatic transmission concerns. TAC is requesting the GDS2 session logs be sent in before the
18-NA-306
Aug 18, 2023
350000 EQUIPMENT
This Warranty Administration service bulletin provides information for dealers/Service advisors on when and how to submit a Pre-Repair Authorization (PRA).
23-NA-144
Aug 18, 2023
030000 BRAKES (PWS)
This technical bulletin provides information and a solution to a condition of Brake Pedal Moves or Self Applies at Full Turns.
09-00-89-016H
Aug 15, 2023
350000 EQUIPMENT
This Warranty Administration bulletin provides information on the proper use of the labor operation 0600014.
23-NA-065
Aug 14, 2023
110000 ELECTRICAL SYSTEM
This service bulletin provides repair information to correct a customer concern of OnStar Inoperative after Importing Vehicle from Canada to the United States.
23-NA-065
Aug 14, 2023
350000 EQUIPMENT
This service bulletin provides repair information to correct a customer concern of OnStar Inoperative after Importing Vehicle from Canada to the United States.
PIP5628G
Aug 10, 2023
060000 ENGINE (PWS)
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
23-NA-141
Aug 10, 2023
060000 ENGINE AND ENGINE COOLING
This informational bulletin advised the technician that the engine and related parts will be debited if found that the tech didn't properly prepare the engine block from dirt and debris in bolt holes or if found that the block was damaged b
Showing 100 of 1,464 bulletins.
NHTSA Safety Investigations, CHEVROLET EXPRESS
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
AQ18006
Opened: Dec 1, 2018
Sale of noncompliant school bus
NHTSA's Office of Chief Counsel received a report from a private attorney representing the estate of a child passenger in a 15 passenger van who died in a crash allegedly occurring when the van was being employed by a school district for student transportation. The attorney provided the agency with ... Read more
CHEVROLET EXPRESS - All Years Overview
Complete safety history for the CHEVROLET EXPRESS across all model years (1996, 2026).
144
Total Recalls
851
Total Complaints
1
Investigations
26
Reported Crashes
37
Reported Fires
0
Reported Deaths
CHEVROLET EXPRESS - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2026 | 3 | 0 | View |
| 2025 | 4 | 0 | View |
| 2024 | 0 | 3 | View |
| 2023 | 1 | 5 | View |
| 2022 | 1 | 6 | View |
| 2021 | 2 | 18 | View |
| 2020 | 1 | 20 | View |
| 2019 | 4 | 8 | View |
| 2018 | 6 | 17 | View |
| 2017 (current) | 6 | 30 | |
| 2016 | 6 | 20 | View |
| 2015 | 3 | 12 | View |
| 2014 | 7 | 19 | View |
| 2013 | 8 | 31 | View |
| 2012 | 6 | 18 | View |
| 2011 | 5 | 17 | View |
| 2010 | 5 | 23 | View |
| 2009 | 7 | 11 | View |
| 2008 | 10 | 19 | View |
| 2007 | 4 | 18 | View |
| 2006 | 16 | 17 | View |
| 2005 | 9 | 33 | View |
| 2004 | 7 | 26 | View |
| 2003 | 11 | 75 | View |
| 2002 | 0 | 77 | View |
| 2001 | 2 | 60 | View |
| 2000 | 1 | 103 | View |
| 1999 | 2 | 82 | View |
| 1998 | 2 | 27 | View |
| 1997 | 2 | 35 | View |
| 1996 | 3 | 20 | View |
| 1995 | 0 | 1 | View |