2027 CHEVROLET BOLT EV

1 recalls, 8 complaints

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Defect Description

General Motors has decided that certain 2027 Chevrolet Bolt EV, 2025-2026 Cadillac OPTIQ, Chevrolet Colorado, Equinox EV, GMC Canyon, 2026 Buick Enclave, Envision, Cadillac CT5, Escalade, Escalade ESV, Escalade IQ, Escalade IQL, LYRIQ, VISTIQ, Chevrolet Blazer EV, Corvette Convertible, Corvette Coup... Read more

Consequence

Without an owner's manual to consult, owners may not know how to safely use and operate the vehicle, increasing the risk of injury in a crash.

Remedy

Dealers will reset the vehicle radio, which will facilitate automatic download of the electronic owner’s manual, free of charge. Owner notification letters were mailed April 16, 2026. Owners may contact GM customer service at 1-866-467-9700, Chevrolet customer service at 1-800-222-1020 or Cadillac... Read more

5,861 vehicles affected

Manufacturer: General Motors, LLC

Complaint Statistics

8 total complaints

Top Reported Components

Component	Complaints
ENGINE	2
ELECTRICAL SYSTEM	1
BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING	1
ENGINE AND ENGINE COOLING:ENGINE:CRANK/CAMSHAFT POSITION SENSOR	1
SERVICE BRAKES	1
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL	1
LANE DEPARTURE: ASSIST	1

Incident date: Aug 26, 2026

The brake pedal can easily become disconnected from the electronic brake booster behind the firewall. When this happens, it stops all driver aids. The safety issue is it can happen while driving, and if using adaptive cruise control, or GM super cruise, if one pedal driving is on, it can without war... Read more

Incident date: Aug 26, 2026

Incident date: Jul 28, 2026

The contact owns a 2020 Chevrolet Colorado. The contact stated that while reversing out of the driveway, the check engine warning light illuminated. The failure recurred while driving 65 MPH. The vehicle was taken to AutoZone, where DTCs P0024 and P0014 were retrieved, indicating exhaust camshaft po... Read more

Incident date: Jul 28, 2026

Fuel Leak: I can smell heavy gas fumes inside the vehicle cabin. Fire Hazard: The vehicle is unsafe to drive due to an imminent risk of a fuel fire. Corporate Refusal: Kia Corporate refused to generate a case number and my local dealership refused to service the vehicle leaving a dangerous safety d... Read more

Incident date: Jul 1, 2026

I have reported safety issues on this vehicle before, but a new one has arisen which is related to the same. It is the computer shorting out. While in the past I have reported lack of backup camera, lane keeping, cruise control, collision avoidance, now intermittently the power steering fails. I ... Read more

Incident date: Jul 14, 2026

2020 Ford Expedition MAX. Ford issued Safety Recall 26S48 / NHTSA 26V402 confirming a transmission park pawl defect causing potential rollaway and crash risk. Remedy not available until Q2 2027. Vehicle has experienced the exact defect symptoms since at least November 2025 including stuck-in-park di... Read more

NHTSA Safety Investigations, CHEVROLET BOLT EV

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2018

Electrical arcing and thermal events, potentially leading to fires, while utilizing Enel X Way USA, LLC's JuiceBox residential charger.

On October 3, 2024, the Office of Defects Investigations (ODI) opened PE24028 to investigate alleged failures of Enel X Way's JuiceBox Level 2 residential EV chargers. The allegations were described as thermal incidents and electrical malfunctions, which could trip the circuit breakers in Juicebox o... Read more

PE, Closed , Model Year: 2017

Electric Vehicle Battery Fires

In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2... Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800Read more

CHEVROLET BOLT EV - All Years Overview

Complete safety history for the CHEVROLET BOLT EV across all model years (2017, 2027).

39 Total Recalls

1,372 Total Complaints

2 Investigations

57 Reported Crashes

28 Reported Fires

0 Reported Deaths

CHEVROLET BOLT EV - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2027 (current)	1	8
2023	3	95	View
2022	7	94	View
2021	5	97	View
2020	8	246	View
2019	6	241	View
2018	5	119	View
2017	4	472	View

Other CHEVROLET Models

Model	Recalls	Complaints
SUBURBAN	246	10,458	View
TAHOE	240	12,622	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health