2004 CHEVROLET AVEO Recalls, Complaints & Safety

TAKATA RECALL. ON OCTOBER 13TH 2018 I WAS IN A HORRIFIC ACCIDENT WHILE ON THE HIGHWAY WAS AN SINGLE CAR ACCIDENT MY TIRE SHREDDED BUT STILL MAINTAINED AIR AND MY AIRBAGS DIDN'T DEPLOY ON EITHER SIDE AND I GOT A BROKEN NOSE AND A FEW FACIAL FRACTURES. NOW I HAVE SEVERE HEADACHES EVERYDAY SINCE THEN.

Crash 1 injured

TAKATA RECALL. ON OCTOBER 13TH 2018 I WAS IN A HORRIFIC ACCIDENT WHILE ON THE HIGHWAY WAS AN SINGLE CAR ACCIDENT MY TIRE SHREDDED BUT STILL MAINTAINED AIR AND MY AIRBAGS DIDN'T DEPLOY ON EITHER SIDE AND I GOT A BROKEN NOSE AND A FEW FACIAL FRACTURES. NOW I HAVE SEVERE HEADACHES EVERYDAY SINCE THEN.

Crash 1 injured

WHAT'S WITH AVEO'S PASSENGER SIDE WINDSHIELD WIPER? IT SKIDS OFF THE WINDOW AND WIPES THE TRIM. WHEN I FIRST BOUGHT MY CAR I THOUGHT SOMEONE MADE A MISTAKE AND PUT ON THE WRONG SIZE. WHEN THEY NEEDED REPLACED, I REPLACED THE WHOLE ARM WITH A SET MATCHING MAKER SPECIFICATIONS. AND MADE NO IMPROVEMENT AT ALL. THE TIP OF THE PASSENGER SIDE WIPER STILL SWINGS CLEAR OFF THE WINDOW. DID SOMEBODY MAKE OFF WITH THE DESIGNER'S RULER? ANY CHANCE THEY MIGHT GIVE IT BACK? I'D REALLY LIKE A WINDSHIELD WIPER THAT FITS; DON'T REALLY NEED ONE FOR THE TRIM...

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. WHILE DRIVING 45 MPH, SMOKE APPEARED UNDER THE HOOD. THE CONTACT STATED THAT THE COOLANT PUMP HOUSING FRACTURED AND COOLANT LEAKED OUT, WHICH CAUSED THE SMOKE. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT UNDER WARRANTY AND SUGGESTED TAKING THE VEHICLE TO A DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 116,000.

Fire

IGNITION SWITCH IS OVERHEATING. THE LONGER THE CAR IS DRIVEN (10-15 MILES) THE HOTTER IT IS BECOMING. IT HEATS UP SO MUCH THAT THE IGNITION KEY BECOMES QUITE HOT AS WELL...BUT THE SWITCH ITSELF IS EVEN HOTTER. I FEAR THERE WILL BE AN ELECTRICAL FIRE STARTING SOON, AND HAVE ALREADY DECIDED TO STOP AT INTERVALS TO TURN THE IGNITION OFF SO IT COOLS DOWN. IT DOESN'T MAKE ANY DIFFERENCE IF IT'S DRIVEN FAST OR SLOW, DRIVING STILL HEATS UP THE IGNITION SWITCH. THE ONLY ODD OCCURRENCE THAT MIGHT BE SOMEHOW CONNECTED IS THE RIGHT TURN SIGNAL BULB NEEDED REPLACED SINCE THIS STARTED.

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY SHUT OFF WHEN PRESSING THE ACCELERATOR PEDAL. THE VEHICLE WAS TAKEN TO HALEY AUTOMOTIVE GROUP DEALER LOCATED IN RICHMOND, VA BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 91,000. ...UPDATED 08/31/17 *BF *JS

WHILE BACKING UP MY VEHICLE I SHIFTED THE TRANSMISSION FROM DRIVE TO REVERSE. THE ENGINE IMMEDIATELY ACCELERATED TO APPROXIMATELY 500 RPM. I IMMEDIATELY PUT MY FOOT ON THE BREAK, SHIFTED TO NEUTRAL, AND TURN THE IGNITION TO OFF. I WAS ABLE TO IMMEDIATELY RESTART TO VEHICLE WITH NO PROBLEM. THIS HAS HAPPENED BEFORE TWO OR THREE TIMES. ONETIME WHILE THE VEHICLE WAS IN DRIVE AND I HAD TO PRESS HARD ON THE BREAK AND SHUT OFF IGNITION TO AVOID AN ACCIDENT. I SEEMS LIKE IT MOSTLY HAPPENS WHEN IT IS COLD OUTSIDE ( IN THE 30"S F) . I THINK THIS IS AN UNSAFE SITUATION AND AN ACCIDENT WAITING TO HAPPEN.

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,390. UPDATED 09/22/16*LJ *JS

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO EQUIPPED WITH MILESTAR MS932 (NA) TIRES, SIZE: 185/65/R14 (NA). WHILE DRIVING 65 MPH, THE CONTACT HEARD A LOUD BOOM SOUND AND THE VEHICLE VEERED LEFT WITHOUT WARNING. THE CONTACT WAS ABLE TO PULL THE VEHICLE OVER TO THE SIDE OF THE ROAD AND OBSERVED THAT THE SIDEWALL OF THE REAR DRIVER SIDE TIRE WAS BLOWN OPEN. THE TIRE WAS NOT DIAGNOSED OR REPLACED. THE CONTACT STATED THAT THE DOT NUMBER OF THE TIRE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15T004000 (TIRES). THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE VEHICLE FAILURE MILEAGE WAS 120,000 AND THE TIRE FAILURE MILEAGE WAS 12,000.

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION SWITCH. DUE TO THE FAILURE, THE VEHICLE COULD NOT BE TURNED OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FAILURE MIGHT BE DUE TO A DEFECTIVE GEAR SHAFT OR IGNITION SWITCH. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 71,500.

I AM ON A FIXED INCOME. I BOUGHT THIS CAR USED WITH 22,000 MILES ON IT WHICH I INTENDED TO TAKE CARE OF AND DRIVE FOR YEARS TO COME, IN FACT INTO THE GROUND. THE MANUAL I RECEIVED WITH THE CAR INDICATED THAT THE TIMING BELT SHOULD BE REPLACED AT 100,000. I LIVE IN A RURAL AREA WHERE YOU REALLY NEED A VEHICLE. I HAD DRIVEN TO ANOTHER TOWN FOR A MEDICAL APPOINTMENT. WHILE TRAVELING AT 55 MPH THE CAR JUST DIED IN HEAVY TRAFFIC IN A 55 MPH ZONE. I WAS LUCKY THAT A GOOD SAMARITAN HELPED ME OUT OF THE DANGEROUS CONDITION I WAS IN ON THE ROAD. MY VEHICLE HAD 65,321 MIIES ON IT. I HAD TO HAVE THE CAR TOWED TO A DEALER. IT WAS DETERMINED THE TIMING BELT BROKE CAUSING VALVE DAMAGE. I WAS TOLD IT WOULD COST $5,000 TO REPAIR IT WHICH IS WHAT I PAID FOR THE VEHICLE. I DID NOT HAVING $5,000 SO I JUNKED THE CAR. THIS ORDEAL CAUSED SIGNIFICANT PROBLEMS FOR ME FINANCIALLY, EMOTIONALLY AND PHYSICALLY. I WAS 62 AT THE TIME. THE WEBSITE CARCOMPLAINTS HAS 56 SIMILAR COMPLAINTS RELATED TO 2004 CHEVY AVEOS. ALL OF THE TIMING BELTS FAILED BELOW 100,000 MILES. THERE ARE SIMILAR COMPLAINTS FOR THE 2005 CHEVY AVEO. WHY WASN'T I NOTIFIED ABOUT THIS PROBLEM SO I WOULD NOT LOSE MY SHORTS ON MY VEHICLE. I COULD HAVE BEEN KILLED. THE EVENT WAS TERRIBLY FRIGHTENING. I SUFFER FROM HEART FAILURE. MY NEW CAR PAYMENT IS VERY HARD TO DEAL WITH ON A FIXED INCOME. I TOOK EXCELLENT CARE OF THE CAR. I SHOULD HAVE BEEN CONTACTED ABOUT SUCH DANGEROUS CONDITION. I WOULD LIKE SOME ANSWERS.

THE VEHICLE WAS MOVING AT A HIGHWAY SPEED OF APPROXIMATELY 65 MPH, WHEN IT GOT INTO A COLLISION WITH ANOTHER VEHICLE. THE OTHER VEHICLE MADE AN ABRUPT STOP ON THE HIGHWAY IN FRONT OF THE 2004 CHEVROLET AVEO, WHICH CAUSED THE AVEO TO HIT THE BACK OF THE SUDDENLY STOPPED VEHICLE. UPON IMPACT, THE AIRBAG DID NOT DEPLOY, WHICH FROM MY UNDERSTANDING SHOULD HAPPEN WHEN TRAVELING AT THAT SPEED. IN FACT IT ESPECIALLY SHOULD HAVE DEPLOYED, DUE TO THE FACT THAT THE IMPACT DAMAGED THE FRONT OF THE VEHICLE. MY CONCERN IS THAT I HAVE BOUGHT TWO OTHER VEHICLES FROM THE SAME MANUFACTURER SINCE MY PURCHASE OF THIS VEHICLE. I WANT TO MAKE SURE THAT MY FAMILY IS SAFE WHEN RIDING IN THESE VEHICLES.

Crash

2004 CHEVROLET AVEO. CONSUMER WRITES IN REGARDS TO SEVERAL VEHICLE REPAIR PROBLEMS. *SMD THE CONSUMER STATED THERE WAS A BURNING ODOR COMING FROM THE VEHICLE. THE DEALER WAS UNABLE TO FIND A PROBLEM. A REPAIR SHOP, REPLACED A FUSE, DUE TO KNOW BATTERY POWER. *JB

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. WHEN STARTING THE VEHICLE, THE FUEL TANK CAUGHT FIRE. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT EXTINGUISHED THE FIRE. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED PNEUMONIA. MEDICAL ATTENTION WAS REQUIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

Fire 1 injured

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. WHEN STARTING THE VEHICLE, THE FUEL TANK CAUGHT FIRE. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT EXTINGUISHED THE FIRE. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED PNEUMONIA. MEDICAL ATTENTION WAS REQUIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

Fire 1 injured

2004 CHEVROLET AVEO. CONSUMER WRITES IN REGARDS TO WARRANTY NOTICE #14093 ISSUES. *SMD THE DEALER INFORMED THE CONSUMER, THE WARRANY HAD EXPIRED. ALSO, THE WATER PUMP AND TIMING BELT WERE REPLACED. *JB

2004 CHEVROLET AVEO. CONSUMER WRITES IN REGARDS TO VEHICLE TIMING BELT FAILURE. *SMD THE CONSUMER STATED THE VEHICLE STOPPED WITH NO WARNING. *JB

BASICALLY I AM WRITING BECAUSE GM ISSUED A RECALL IN JUNE 2014 LETTING ME KNOW THAT MY CAR HAS AN ISSUE WHICH MAY LEAD TO A FIRE IN MY CAR. THE PROBLEM IS THAT A YEAR HAS PASSED AND THE STATUS OF THAT RECALL STILL IS "GENERAL MOTORS WILL PROVIDE ITS PLAN FOR REMEDYING THE DEFECT AS SOON AS IT IS CONFIRMED." I HONESTLY FEEL THEY HAVE FORGOTTEN ALL ABOUT IT. I DON'T THINK THIS SHOULD BE AN ISSUE THAT SHOULD TAKE SUCH A LONG TIME TO GET FIXED.

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD EXPERIENCED A FAILURE.

THIS IS JUST ONE PROBLEM...THE CAR HAD MAJOR PROBLEMS IN THE PAST LIKE DYING TOTALLY ON A HIGHWAY BUT THAT'S NOT MY CONCERN RIGHT NOW. THE BACK SEAT BELT IS LOCKED UP & IT WILL NOT RETRACT. I HAVE A CHILD SO IT'S REALLY INCONVENIENT.

TIMING BELT SNAPPED AT 73K MILES WHILE DRIVING 70MPH ON THE HIGHWAY. TOTAL LOSS OF POWER: STEERING, BRAKES, AND GAS PEDAL ALL NOT RESPONDING. MANUALLY MANAGED TO COAST TO A STOP ON THE HIGHWAY SHOULDER WITH MY EMERGENCY LIGHTS ON, AND WITHOUT HITTING OR BEING HIT BY ANYTHING ELSE. I'M ALIVE AND SO IS MY PASSENGER, BUT I FEAR WE COULD HAVE DIED ON THAT DAY. RELATED TSBS AND NHTSA BELOW TO AUGMENT REPORTING THIS PROBLEM. ---- TSB #3936 / NHTSA ID #10020573 STATES THAT THIS CAN HAPPEN PRIOR TO 60K MILES TO OTHERS AS FAR BACK AS 2006; TOTAL ENGINE LOSS DUE TO DAMAGE FROM THE BELT AT HIGH SPEED NOT REPORTED OR FIXED. SUGGESTED MAINTENANCE ALSO IS NOT ACCEPTABLE FOR THIS PART: # TSB #060601021 -- TIMING BELT INSPECTION, MAINTENANCE, WORN, WEAR.*KB (NHTSA ID #10020843, OCTOBER 01 2006)

I HAVE A 2004 CHEVY AVEO AND A 2005 CHEVY COBALT MY IGNITION SWITCH ON MY AVEO DOES THE SAME THING AS COBALT BUT AVEO NOT RECALLED ITOOK COBALT IN DEALER REPLACED IGNITION SWTICH TOOK AVEO IN FOR RECALL FOR DRL SWITCH DEALER WANTS OVER 300.OO DOLLORS TO REPLACE IGNITION SWITCH I WILL BE DRIVING ALONG AT DIFFERENT SPEEDS CAR WILL SHUT OFF STARTS BACK UP WHEN I PUT KEY IN HAVE TO MOVE KEY SEVERAL TIMES TO START CAR DEALER SAYS NO RECALL ON THE AVEO FOR IGNITION SWITCH BUT IT IS DOING THE SAME THING AS MY COBALT DID IS THIS A DIFFERENT SWITCH THE AVEO HAS DONE THIS SEVERAL TIMES OVER THE LAST YEAR OR SO.

IN MID-FEBRUARY AFTER ONE OF OUR MANY BLIZZARDS, MY WIFE WAS DRIVING HER SEDAN HOME. THERE WAS A PILE OF SNOW ON OUR STREET THAT HAD HARDENED OVER. I GUESS SHE MISCALCULATED ITS HEIGHT (AND HARDNESS) AND WHEN SHE WENT OVER IT, THE CAR LURCHED UP AND SHE HEARD A LOUD GRINDING SOUND AGAINST THE UNDERCARRIAGE. THE ENGINE STARTED SHAKING IMMEDIATELY AND WITHIN SECONDS DIED. SHE CALLED ME OUT AND I TOOK A LOOK AT THE CAR. IT WAS DEAD. I WALKED OVER TO THE ICE AND IT WAS ROCK HARD, SO I TRIED TO TAKE A SHOVEL TO IT AND IMMEDIATELY EMAILED MY NEIGHBORS TO BE CAREFUL OF IT. I AM NOT MECHANICALLY-INCLINED, SO WHEN I GOOGLED WHAT MIGHT'VE HAPPENED, I SAW SEVERAL COMMENTS THAT IT COULD BE AS MINOR AS A DAMAGED OIL PAN THAT CAUSES THE ENGINE TO SHUT DOWN. FIGURING IT MIGHT BE SOMETHING MINOR, I CALLED AAA (HAD TO WAIT A FEW DAYS SINCE THEIR LINES WERE DOWN) AND HAD THE CAR TOWED DOWN THE STREET TO A SERVICE STATION. I WAS NOT EXPECTING THE ASSESSMENT FROM THE MECHANIC: APPARENTLY DURING THE COLLISION, THE TIMING BELT SLIPPED AND CAUSED THE PISTONS TO BEND. THIS WOULD COST SEVERAL THOUSAND TO FIX. UNFORTUNATELY, THIS CAR HAS AN "INTERFERENCE" DESIGN WHICH IS PRONE TO EXTENSIVE DAMAGE WHEN THIS HAPPENS. MANY AVEO OWNERS HAVE COMPLAINED ABOUT THIS ONLINE. THE WORST PART ABOUT ALL OF THIS IS THAT EVEN THOUGH IT HAPPENED DURING A COLLISION, OUR INSURANCE CHALKED THIS UP TO "WEAR AND TEAR" AND WE WERE FORCED TO JUNK THE CAR. OUR CAR HAD LESS THAN 60K MILES ON IT AND WE KEPT IT IN GOOD CONDITION. THIS SHOULD NOT HAVE HAPPENED. THIS SHOULD HAVE EITHER BEEN HANDLED THROUGH A MANUFACTURER RECALL OR MY INSURANCE SHOULD HAVE TREATED IT AS THE COLLISION IT WAS AND COVERED IT.

Crash

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE CONTACT CALLED THE AUTHORIZED DEALER SEVERAL TIMES FOR MONTHS AND THEY INDICATED THAT THE PART WAS NOT AVAILABLE AND THAT THE REPAIR WAS NOT URGENT. UPON STARTING THE VEHICLE, GRAY SMOKE STARTED TO EMIT FROM UNDER THE HOOD INTO THE INTERIOR OF THE VEHICLE. THE CONTACT RELEASED THE HOOD LATCH QUICKLY AND HAD A PASSENGER DISCONNECT THE BATTERY. HOWEVER, A FIRE ERUPTED NEAR THE FRONT OF THE VEHICLE AS SMOKE FILLED THE VEHICLE CAUSING POOR VISIBILITY THAT IMPACTED THE CONTACT'S BREATHING. THE CONTACT AND THE DRIVER WERE ABLE TO QUICKLY EXIT THE VEHICLE. THE CONTACT WAS ABLE TO EXTINGUISH THE FLAMES WITH A FIRE EXTINGUISHER. A POLICE REPORT WAS NOT FILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND WAS PARKED AT THE CONTACT'S RESIDENCE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

Fire

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT EXPERIENCED AN INTERMITTENT FAILURE WITH THE EXTERIOR LIGHTING. THE FAILURE MILEAGE WAS UNKNOWN.

RECEIVED A RECALL NOTICE FOR DRL FIRE HAZARD. CALLED 3 DEALERSHIPS IN THE DALLAS AREA TO HAVE THE MOSFET REPAIRED. ALL 3 DEALERSHIP DENY ANY KNOWLEDGE OF THE RECALL AND DO NOT HAVE THE PARTS IN STOCK EVEN IF I DID BRING THE RECALL NOTICE IN. CHEVY HAS SENT 2 E-MAILS BUT THEY ARE THE DO NOT REPLY. I HAVE ATTEMPTED NUMEROUS TIMES TO CONTACT CHEVY CUSTOMER SERVICE AND CANT GET ANYONE TO RESPOND. THIS IS A FIRE HAZARD, PLEASE HELP ME TO GET THIS FIXED. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT HEARD AN ABNORMAL NOISE AND THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE TIMING BELT FRACTURED AND THE ENGINE WAS RUINED. THE VEHICLE WAS UNABLE TO BE REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000. UPDATED 5/4/15*CN UPDATED 05/12/15*JB

TL* THE CONTACT OWNED A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V2610000 (EXTERIOR LIGHTING). WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT'S VEHICLE TAPPED ANOTHER VEHICLE. THE CONTACT NOTICED FLAMES UNDER THE HOOD OF THE VEHICLE. THE VEHICLE BECAME ENGULFED IN FLAMES AND WAS DESTROYED. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

Crash Fire

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNED A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V2610000 (EXTERIOR LIGHTING). WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT'S VEHICLE TAPPED ANOTHER VEHICLE. THE CONTACT NOTICED FLAMES UNDER THE HOOD OF THE VEHICLE. THE VEHICLE BECAME ENGULFED IN FLAMES AND WAS DESTROYED. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

Crash Fire

TL*THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT THE SERVICE ENGINE WARNING LAMP ILLUMINATED SEVERAL TIMES AND THEN TURNED OFF. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 30 MPH, THE VEHICLE WAS SHAKING VIOLENTLY AND STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND UPON PULLING OVER, THE CONTACT NOTICED FLAMES AND SMOKE WAS EMITTING FROM UNDER THE HOOD NEAR THE FRONT PASSENGER SIDE. THE DRIVER AND THE FRONT PASSENGER EXIT THE VEHICLE. THE FIRE WAS ABLE TO BE EXTINGUISHED BY THE FIRE DEPARTMENT. A POLICE REPORT WAS FILED. THE DRIVER AND FRONT PASSENGER DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 14V261000 (EXTERIOR LIGHTING). THE VEHICLE WAS NOT INSPECTED OR DIAGNOSED. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

Fire

TL*THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT THE SERVICE ENGINE WARNING LAMP ILLUMINATED SEVERAL TIMES AND THEN TURNED OFF. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 30 MPH, THE VEHICLE WAS SHAKING VIOLENTLY AND STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND UPON PULLING OVER, THE CONTACT NOTICED FLAMES AND SMOKE WAS EMITTING FROM UNDER THE HOOD NEAR THE FRONT PASSENGER SIDE. THE DRIVER AND THE FRONT PASSENGER EXIT THE VEHICLE. THE FIRE WAS ABLE TO BE EXTINGUISHED BY THE FIRE DEPARTMENT. A POLICE REPORT WAS FILED. THE DRIVER AND FRONT PASSENGER DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 14V261000 (EXTERIOR LIGHTING). THE VEHICLE WAS NOT INSPECTED OR DIAGNOSED. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

Fire

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. WHILE STARTING THE VEHICLE, SMOKE EMITTED FROM THE VENTS AND CD PLAYER WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 88,000. UPDATED 5/5/15*CN UPDATED 10/23/2015 *JS

Fire

I WAS DRIVING AND THE CAR JUST STOPPED .. IF I WAS DRIVING ANY FASTER OR IF THERE WAS A CAR BEHIND ME I WOULD HAVE BEEN KILLED!!!!RESULT WAS THE TIMING BELT. THE CAR ONLY HAD 52000 MILES. I CONTACTED CHEVY AND ALL THEY COULD OFFER ME WAS A LOYALTY DISCOUNT ON A NEW CAR... WHICH I PROBABLY WOULD BE ENTITLED TO ANYWAY .. I JUST FOUND A LETTER FROM GM INDICATED THAT THE REQUIRED REPLACEMENT OF THE TIMING BELT WAS AT 60K MILES... WELL MY CAR DIDN'T MAKE IT TO 60K .....SO THEY KNOW THAT THERE IS A PROBLEM AND CONTINUE TO DENY IT!! *JS

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VEHICLE SAT AT THE DEALER FOR TEN MONTHS, DUE TO LACK OF PARTS. UPDATED 06/10/15.*JB

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE HEADLIGHTS FLICKERED INTERMITTENTLY. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 15,000. THE CONSUMER STATED THE RECALL STILL HAS NOT BEEN ADDRESSED. UPDATED 08/24/15*JB

I WAS DRIVING DOWN THE INTERSTATE ON MY WAY HOME TO KNOXVILLE FROM ATHENS, TN, AND I HEARD MY CAR MAKE A FUNNY NOISE, AND THEN I HEARD A LOUD NOISE, AND THE ENGINE BEGAN TO SMOKE, I PULLED OVER OFF OF THE INTERSTATE ONTO AN EXIT AND THEN THE CAR BASICALLY DIED WHEN I MADE IT TO THE SIDE OF THE ROAD. THE SMOKE WAS WHITE AT FIRST, BUT THEN IT TURNED BLACK SO WE RAN FROM THE CAR. THE CAR PROCEEDED TO CATCH ON FIRE AND BY THE TIME THE FIRE DEPARTMENT ARRIVED IT WAS TOO LATE. I HAD A LOT OF CLOTHING AND PERSONAL ITEMS IN MY CAR, AND MY BOYFRIEND'S LAPTOP AND REALLY EXPENSIVE TEXTBOOKS WERE IN THE CAR AS WELL. THE CAR IS COMPLETELY BURNED EXCEPT FOR PARTS OF THE TRUNK AND THERE WAS NOTHING THAT WAS SALVAGEABLE. I WAS LOOKING ONLINE AND FOUND OUT THAT MY CAR HAS BEEN RECALLED BECAUSE OF FIRES, BUT I HAD NO IDEA BECAUSE I BOUGHT THE CAR TWO MONTHS AFTER THE RECALL WAS ANNOUNCED. IT DOESN'T REALLY MATTER THOUGH, BECAUSE THERE IS NO REMEDY FOR THE PROBLEM. I NOW HAVE NO CAR AND I AM A COLLEGE STUDENT AND I NEED A CAR SO I DON'T KNOW WHAT TO DO. I'M NOT SURE HOW TO GO ABOUT CONTACTING THE MANUFACTURER ABOUT MY PROBLEM. I AM VERY UPSET THAT THIS HAS HAPPENED, AND IT WOULD BE REALLY NICE IF SOMEONE COULD HELP ME FIX THIS. *TR

Fire

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO REPAIR THE VEHICLE. THE DEALER WAS UNABLE TO INFORM WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

GM RECALL #14093 2004 CHEVROLET AVEO GM MAILED A LETTER IN JULY REGARDING THIS RECALL. THERE HAS BEEN NO FOLLOW REGARDING REPAIRING THE DEFECTIVE EQUIPMENT. WHEN GM WAS CONTACTED, THEY ADVISED TO CONTACT THE LOCAL DEALERSHIP. THE DEALERSHIP ADVISED THEY HAVE NOT RECEIVED THE PARTS OR INSTRUCTION FROM GM ON HOW TO REPAIR THE DEFECTIVE EQUIPMENT. I HAVE A CHEVROLET AVEO WITH INOPERABLE TAIL LIGHTS, FRONT PARKING LIGHTS AND INSTRUMENT PANEL LIGHTS. I AM UNABLE TO OPERATE THE VEHICLE AT NIGHT. CAN NHTSA ASSIST WITH GETTING GM TO REPAIR THE VEHICLES? *TR

WHEN WILL THE DRL MODULE REPLACEMENT BE AVAILABLE? IT'S BEEN OVER 4 MONTHS SINCE THIS CAME TO LIGHT! DO I HAVE TO WAIT UNTIL MY CAR CATCHES ON FIRE? GM RECALLS JUST SAYS NOT AVAILABLE YET! DO YOU HAVE MORE POWER NOW SINCE THE IGNITION RECALLS? *TR

2004 CHEVROLET AVEO. CONSUMER WRITES IN REGARDS TO HEADLAMP SWITCH MODULE RECALL NOTICE. *SMD THE CONSUMER WAS INFORMED THE PARTS WERE NOT AVAILABLE. *JB

OVERALL, AN EXCELLENT SMALL CAR! MY CAR HAS A BRAKE PROBLEM WHEN FIRST STARTED IN THE MORNING OCCASIONALLY. THERE ARE NO POWER BRAKES AND YOU HAVE TO PUT BOTH FEET ON THE PEDAL TO STOP THE CAR! KNOWING THIS(THE PEDAL IS SUPER HARD WHEN YOU PUT YOUR FOOT ON THE BRAKE TO PUT IT IN GEAR) I HAVE BEEN ABLE TO GIVE MYSELF PLENTY OF ROOM TO STOP AND THE CONDITION HAS NOT CAUSED AN ACCIDENT! THIS CONDITION USUALLY GOES AWAY AFTER A FEW MILES AND THE BRAKES RETURN TO NORMAL! BY THE TIME I CAN GET TO A GARAGE, EVERYTHING IS FINE AND IT DOESN'T DO IT CONSISTENTLY! WEATHER DOES NOT SEEM TO BE A FACTOR AND IT ONLY DOES IT ON STARTUP AFTER IT SITS OVERNIGHT! *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT THE TURNING SIGNAL LIGHTS ILLUMINATED INTERMITTENTLY. THE CONTACT MENTIONED THAT THE VEHICLE WAS EXHIBITING THE FAILURE SPECIFIED IN RECALL NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING).THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 50,000. UPDATED 8/11/4*CN

MY 19 YEAR OLD DAUGHTER JUST ARRIVED AT HER MOTHERS HOUSE, PARKED THE CAR AND CAME INSIDE. WHEN WE STARTED SEEING, AND SMELLING SMOKE. SO WE WENT OUTSIDE TO INVESTIGATE THE PROBLEM AND SAW SMOKE POURING OUT FROM UNDER THE HOOD AS IF THERE WAS A FIRE CONTAINED UNDER THE HOOD. SO WE CALLED 911 AND SUDDENLY WE HEARD A LOUD POP AND SAW FLAMES ON THE HOOD. WE PROCEEDED TO GET A WATER HOSE TO POUR WATER ON THE CAR UNTIL FINALLY THE FIREMEN ARRIVED. THE CAR STILL REMAINS IN FRONT OF HER MOTHERS HOUSE, IF ANYONE WOULD LIKE TO TAKE A LOOK AT THE CAR. THE FIREMEN DEEMED IT TO BE A TOTAL LOSS. I WOULD LIKE ANY INFORMATION FOR RECALLS ON THIS MAKE AND MODEL. *TR

Fire

MY 19 YEAR OLD DAUGHTER JUST ARRIVED AT HER MOTHERS HOUSE, PARKED THE CAR AND CAME INSIDE. WHEN WE STARTED SEEING, AND SMELLING SMOKE. SO WE WENT OUTSIDE TO INVESTIGATE THE PROBLEM AND SAW SMOKE POURING OUT FROM UNDER THE HOOD AS IF THERE WAS A FIRE CONTAINED UNDER THE HOOD. SO WE CALLED 911 AND SUDDENLY WE HEARD A LOUD POP AND SAW FLAMES ON THE HOOD. WE PROCEEDED TO GET A WATER HOSE TO POUR WATER ON THE CAR UNTIL FINALLY THE FIREMEN ARRIVED. THE CAR STILL REMAINS IN FRONT OF HER MOTHERS HOUSE, IF ANYONE WOULD LIKE TO TAKE A LOOK AT THE CAR. THE FIREMEN DEEMED IT TO BE A TOTAL LOSS. I WOULD LIKE ANY INFORMATION FOR RECALLS ON THIS MAKE AND MODEL. *TR

Fire

TL* THE CONTACT OWNS A 2004 CHEVROLET AVEO. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE FLOOR MAT SENSOR AND CLOCK SPRING NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 72,950.