2003 BUICK LESABRE Recalls, Complaints & Safety

The transmission doesn't shift correctly even after it's warmed up it is erratic and rough while connecting the transmission gears and jerks very hard at most times. The power steering is not working correctly and makes it difficult to drive at all with the combined issues I'm very concerned about my and my family safely

On [XXX] original Steering Rack and Pinion was replaced at 138974 miles by established reputable garage with NAPA part which was remanufactured. That part failed [XXX] at 141443 miles. That part failed [XXX] at 145999 miles and was replaced with NAPA part which was remanufactured. That part failed and was replaced at [XXX] at 157999 miles with another NAPA remanufactured part. That part failed about July 2023 and has not been replaced . The repair garage that had been replacing this rack and pinion stated they will no longer replace it since the outcome would be the same. The problem in all instances is that the hydraulic fluid leaks out of the unit through the rack and pinion which in turn affects the steering. The leak starts slowly and eventually increases to the point where the fluid will leak from the unit even when the car is not in use. I reported the problem to NAPA in writing [XXX] and received a telephonic request for documentation [XXX] which was furnished along with a statement that this matter was being looked into. I am not interested in any monetary refund but am only concerned about the safety of parts sold as "remanufactured" . The automobile repair shop is aware of my concern and supports my complaint. Both the repair shop and myself have documentation. I believe that based upon the number of times this part has failed indicates a potential problem in at the remanufactured automobile parts industry for at least this particular part and possibly others. I am willing to furnish any information I have. Thank you -- [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

215/70R15 98T Tire purchased 10 days prior blew-out , resulting in total loss of vehicle.

Crash 1 injured

The contact owns a 2003 Buick LeSabre. The contact stated that their trunk failed to remain in the open position when needed. The contact had not taken the vehicle to the dealer. The vehicle had not been repaired. The manufacturer was not made aware of the issue. The approximate failure mileage was 60,000.

1 injured

The contact owns a 2003 Buick LeSabre. The contact stated that after his friend drove the vehicle to his residence, there was a burning oil odor detected. The contact opened the hood and there was smoke coming from the engine. The vehicle was diagnosed by an independent mechanic as a valve cover gasket leak. The vehicle was not repaired. The contact was concerned that the failure could lead to an engine compartment fire. The manufacturer was made aware of the failure but informed the contact that the VIN was not included in a recall. The failure mileage was 136,776.

Fire

THE DASH PAD IS CURLING UP FROM THE WINDSHIELD ON THE DRIVER'S SIDE.THERE IS A GAP OF SEVERAL INCHES. MANY PEOPLE ARE EXPERIENCING THIS IN MY RESEARCH. WILL NEED TO REPLACE DASH PAD

TL* THE CONTACT OWNS A 2003 BUICK LESABRE. THE CONTACT STATED THAT WHEN THE VEHICLE WAS TAKEN FOR SERVICE AT AN INDEPENDENT MECHANIC, THE MECHANIC NOTICED ABOVE THE DRIVER SIDE REAR SPRING SUSPENSION WAS CORRODED THROUGH. IN ADDITION DUE TO THE CORROSION ON THE TOP OF THE SPRING, THE VEHICLE DOES NOT HAVE SUPPORT CAUSING THE VEHICLE TO SWERVE BACK AND FORTH. THE VEHICLE WAS TAKEN TO BOB PION BUICK GMC DEALER, (333 MEMORIAL DR, CHICOPEE, MA 01020, (413) 598-8377) WHERE THEY NOTICED THE CORROSION BUT DID NOT RECOMMEND TO REPAIR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE INDEPENDENT MECHANIC ALSO INFORMED THE CONTACT THAT THE RUST UNDERNEATH WERE PRISTINE AND THE SPRING LEANING ON THE FRAME PUSHING THE REAR DRIVER SIDE TIRE. THE CONTACT STATED THAT THE VEHICLE LOST ALL SUPPORT, THE SPRING WAS PRE-FLOATING AT THE TOP. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140.000.

WHEN THE VEHICLE GETS WARMER DURING TRANSIT, THE TRANSMISSION BEGINS TO SLIP. IT GETS WORSE AND THE DURATION OF THE SLIP BEGINS TO. LAST LONGER.

BUICK 2003 LESABRE TSB I NEED THE SERVICE BULITONS ON THE TRANSMISSION FOR SHUDDER ,HARSH SHIFTING WHILE DRIVING AND HEATED UP PROPERLY

TRANSMISSION BUMPS SOME TIMES

THE AIRBAG LIGHT STAYS ON AND THE DASH IS SEPARATING FROM THE FIREWALL OF THE MOTOR. THERE IS A GAP BETWEEN THE WINDSHIELD AND THE DASH

IN 2009 THE DASHBOARD BEGAN TO LIFT UP UNDER THE WINDSHIELD. BY 2011 THE DASHBOARD HAD LIFTED UP ALMOST COMPLETELY ACROSS THE DASH ACROSS THE WINDSHIELD, BY ABOUT 2 INCHES. I HAD MY MECHANIC ATTEMPT TO SECURE IT BACK DOWN ON SEVERAL OCCASIONS.

FIRST ELECTRICAL... MY WIPERS STOPPED WORKING DURING BAD RAIN RIGHT AFTER COMING OUT THE TUNNEL IN HEAVY TRAFFIC NO ACCIDENT I KNEW ROAD ENOUGH TO PULL OVER.. GOT FIXED REPLACED WIPER MOTOR 3 TIMES AND THE WIPER SWITCH WIPERS STILL GO WITHOUT BEING TURNED ON... THEN MY DASH KEEPS GETTING DIM AND MY ABS,TRACTION ,AND BRAKE LIGHTSARE ON AND I'VE HAD THAT FIXED STILL KEEPS STAYING LIT.... I GET REGULAR OIL CHANGES AT WALMART EVERY 3000 MILES THERES FLUID LEAKING FROM VALVE COVER THAT I HAD REPLACED ...THINGS I REPLACED ON CAR SHOULD HAVE NEVER BEEN INSPECTED.. MY DASH WAS LIFTED WHEN I PURCHASED VEHICLE USED ALSO SAID IT WAS FINE MVA MADE THEM REINSPECT CAR N ITS STILL LIFTED I ALSO KNOW IT WONT PASS INSPECTION LIFTED

BATTERY GOES DEAD OVER NIGHT, TOOK IT TO A MECHANIC HE SAID THE FUSE BOX UNDERBACK SEAT IS SHORTING OUT

TL* THE CONTACT OWNS A 2003 BUICK LESABRE. THE CONTACT NOTICED THAT THE DASHBOARD HAD INADVERTENTLY BECOME UNGLUED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND CONFIRMED THAT NO RECALL WAS ASSOCIATED WITH HE VIN. THE CONTACT WAS ADVISED TO CALL NHTSA. THE FAILURE MILEAGE WAS UNAVAILABLE.

I HAD TRAVELED ABOUT 2 MILES FROM HOME TO A HOME DEPOT AND WAS DRIVING AT ABOUT 20 MPH AS I WAS ABOUT TO TURN INTO ONE OF THE PARKING LANES. SUDDENLY THE CAR WENT INTO FULL SPEED AS IF I WAS FULL ON THE GAS PEDAL. I NEARLY HIT OTHER CARS TRYING TO GET CONTROL OF MY CAR. I TRIED SHUTTING THE ENGINE OFF AND THEN BACK ON, BUT THAT DID NO GOOD. MY CAR ONLY HAS ABOUT 70,000 ACTUAL MILES ON IT AS I AM RETIRED. CAR IS CURRENTLY IN A GARAGE WAITING FOR REPAIRS.07242013

LETTER FROM CONGRESSWOMAN FOXX ON BEHALF OF CONSTITUENT RE 2003 BUICK LESABRE DEFECT ISSUES. *SMD THE CONSUMER STATED THE DASHBOARD SEPARATED AND RAISED ABOUT TWO INCHES. *JB

"DEFECTIVE GASKETS FIRE HAZARD" OIL DRIPPING FROM VALVE COVER CAUGHT FIRE BURNING PLUG WIRES AND 3800 V6 ENGINE SHROUD'. I HAD PARKED THE VEHICLE IN MY DRIVE. I WENT INSIDE HOME FOR 2 MINUTES. I CAME BACK OUTSIDE TO RETRIEVE A SODA WHEN I DISCOVERED SMOKE BILLOWING FROM UNDER HOOD. WHEN I RELEASED HOOD LATCH AND RAISED HOOD FLAMES SHOT OUT DRIVING ME TO THE GROUND. I QUICKLY GOT A WASH BUCKET NEARBY AND WAS ABLE TO PUT OUT FIRE. I DON'T KNOW THE EXTENT OF DAMAGE. I FOUND OUT THAT OVER 1300 GM VEHICLES HAVE CAUGHT FIRE DUE TO THIS PROBLEM. I REPORTED THE INCIDENT TO BUICK AND WAS TOLD A REPRESENTATIVE WOULD CONTACT ME WITHIN 24 HOURS. 2 DAYS PASS NO CALL AND CAR SITS IN DRIVE. I'M LUCKY I CAUGHT IT AS IT COULD HAVE CAUSED A HOUSE FIRE AS WELL.

Fire

TL* THE CONTACT OWNS A 2003 BUICK LESABRE. THE CONTACT STATED THAT THE PASSENGER SIDE DASHBOARD DETACHED, INCLUDING THE AIR BAG HOUSING AREA. THE LOOSENED DASHABOARD DISTORTED THE CONTACT'S VISION WHEN DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

THE DASHBOARD PANEL IS SEPARATING AT THE FRONT WHERE IT MEETS THE DEFROSTER COWLING. THE SEPARATION IS INCREASING ALONG THE FRONT OF THE DASH FROM DRIVER TO PASSENGER SIDE, AND IS STARTING TO CURL UP CONSIDERABLY ON THE DRIVER SIDE. IT IS UNKNOWN HOW MUCH FURTHER THE SEPARATION/CURLING WILL CONTINUE, AND IS BEGINNING TO AFFECT THE VISION OF THE DRIVER JUST ABOVE THE HOOD. I ADDITION, OTHER COMPONENTS UNDER THE DASHBOARD ARE BEGINNING TO BE EXPOSED TO SUNLIGHT. FURTHER INVESTIGATION SUGGESTS THAT THIS IS AN EXTREMELY COMMON FAILURE WITH THIS MODEL VEHICLE, WITH MULTIPLE COMPLAINTS FROM CONSUMERS, RANGING FROM OBSCURED DRIVER VISION, TO POTENTIAL OR POSSIBLE AIRBAG DEPLOYMENT DUE TO EXPOSED COMPONENTS. INVESTIGATION ALSO SUGGESTS THAT GENERAL MOTORS IS NOT ACKNOWLEDGING THE EXISTENCE OF THE PROBLEM, NOR PROVIDING ADEQUATE SOLUTIONS FOR REPAIR DESPITE NUMEROUS CUSTOMER COMPLAINTS AND CONCERNS.

TL* THE CONTACT OWNS A 2003 BUICK LESABRE. WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED; HOWEVER, THE FAILURE RECURRED ON SEVERAL OCCASIONS WHILE DRIVING AT LOW SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE FAILURE WAS UNABLE TO BE DETERMINED; HOWEVER, THE GASKET KIT, A CONNECTOR, AND THE MAF SENSOR WERE REPLACED. THE FAILURE PERSISTED AND THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 71,449.

TL* THE CONTACT OWNS A 2003 BUICK LESABRE. WHILE OPERATING THE VEHICLE, THE AIR BAG SENSOR LIGHT ILLUMINATED INDICATING THAT THE AIR SYSTEM WAS FAULTY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 200,000.

TL* THE CONTACT OWNS A 2003 BUICK LESABRE. THE CONTACT STATED THAT THE DASH PANEL SEPARATED FROM THE GLOVE COMPARTMENT WHERE THE AIR BAG WAS HOUSED. THE VEHICLE WAS NOT TAKEN TO THE DEALER NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

TL* THE CONTACT OWNS A 2003 BUICK LESABRE. THE CONTACT STATED THAT THE DASHBOARD WAS PEELING WHERE THE PASSENGER SIDE AIR BAG WAS LOCATED. THE VEHICLE WAS TAKEN TO A MECHANIC WHERE IT WAS DIAGNOSED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 96,000.

WE BOUGHT THE CAR DECEMBER 29,2015, THE CAR HAD 102,0215, AND DROVE IT TO THE DOCTOR ON OUR WAY BACK, THE WOULD MAKE A "CLUNKING" SOUND FROM TRANS-AXLES, AND WE NOTICE THAT THE DASH BOARD CAME UP AND IT HAS HARDWARE SCREWS ACROSS THE DASH AS IF TO HOLD IT DOWN. *TR

TL* THE CONTACT OWNS A 2003 BUCK LESABRE. WHILE DRIVING 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART UNTIL THE NEXT DAY AND HAD TO BE TOWED TO THE CONTACT'S RESIDENCE. THE DEALER STATED THAT THE BATTERY MIGHT HAVE CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 2,000.

THE DASH COVER HAS STARTED TO BUCKLE IN FRONT OF THE STEERING WHEEL TOWARD THE PASSENGER SIDE OF THE VEHICLE. *TR

AUTOATICE TRANSMISSION SLIPS

TL* THE CONTACT OWNED A 2003 BUICK LESABRE. AFTER CRASHING INTO A TREE STUMP, THE CONTACT ATTEMPTED TO REVERSE AND MOVE THE VEHICLE FORWARD WHEN IT SUDDENLY ACCELERATED INDEPENDENTLY, CAUSING THE CONTACT TO CRASH INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED A CONCUSSION, FOOT, CHEST, NECK, BACK AND KNEE INJURIES WHICH REQUIRED MEDICAL ATTENTION. THE MIDDLE REAR PASSENGER SUSTAINED BRAIN AND KNEE INJURIES WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

Crash 2 injured

2003 BUICK LESABRE DASH PAD DASH PAD IS BUCKLING FROM THE FRONT, AT THE WINDSHIELD EDGE OF THE PAD. *TR

TL* THE CONTACT OWNS A 2003 BUICK LESABRE. THE CONTACT STATED THAT THE DASHBOARD BEGAN SEPARATING AND EXPANDING DOWN TO THE PASSENGERS SIDE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

RECALL

BRAKE LINE WAS RUSTED & WAS REPLACED. *TR

THE DASH PAD HAS SEPARATED FROM THE DASHBOARD. *TR

WHEN THE LESABRE WAS RELIABLE; IT WAS RELIABLE. HOWEVER, WHEN ISSUES STARTED TO OCCUR, THEY WERE MASSIVE. AT APPROX 90K MILES THE TRANSMISSION WENT WITH NO WARMING AND WAS INSTANTLY. AFTER THAT THE CAR STILL HAD ISSUES WITH THE DRIVE, TRANSMISSION AND GEARS. THE FUEL PUMP AND INTAKE MANIFOLDS HAVE BEEN REPLACED. AS OF 2014 I CONTINUE TO HAVE ISSUES WITH THIS VEHICLE. IT CURRENTLY RUNS VERY HARD AND WHEN IDLE AND IN TRAFFIC (VERY SCARY) WILL RANDOMLY CUT OFF WITH ZERO WARNING OR EVEN BEGIN TO SMOKE. THERE IS THE CORRECT AMOUNT OF OIL AND ANTIFREEZE. THE CAR WILL RANDOMLY SMOKE AS WELL. I HAVE BEEN TO THE MECHANIC SEVERAL TIMES TRYING TO FIGURE OUT THE MAIN ISSUE SO THAT IT CAN BE REPAIRED. THIS IS EXTREMELY FRUSTRATING. ANYONE HAVE ANY SOLUTIONS? I KEEP READING PLENTY OF OWNERS WITH THE SAME ISSUE(S) SO I FIND IT HARD TO BELIEVE THAT GM/BUICK HAS NOT DONE A RECALL ON PARTS FOR THE ENGINE, TRANSMISSION, ETC. *TR

TL* THE CONTACT OWNS A 2003 BUICK LESABRE. THE CONTACT STATED THAT THE CENTER DASHBOARD COVERING SEPARATED AND EXTENDED TO THE PASSENGER'S SIDE AIR BAG HOUSING. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

TL * THE CONTACT OWNS A 2003 BUICK LESABRE. THE CONTACT STATED THAT WHEN THE REAR DRIVERS DOOR WAS CLOSED, THE GLASS WINDOW FELL INTO THE DOOR PANEL. THE VEHICLE WAS TAKEN TO A DEALER AND WAS REPAIRED. THE REPAIRS WERE UNKNOWN. ADDITIONALLY, THE FAILURE RECURRED WITH THE FRONT AND REAR PASSENGER SIDE DOOR WINDOWS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 71,000.

2003 BUICK LE SABRE. DASHBOARD IS PULLING AWAY FROM THE FIREWALL. ELECTRONIC PARTS ARE EXPOSED. AS A RESULT, AIRBAG AND OTHER SAFETY SENSORS AND WIRING IS EXPOSED. THERE HAVE BEEN REPORTS OF AIRBAG DEPLOYMENT. THE DASH IS PULLING AWAY TOWARD THE PASSENGER SIDE WHERE THE AIRBAG IS HOUSED. THERE ARE MANY REPORTS OF ISSUES ON THE INTERNET. THE DASH HAS PULLED AWAY OVER 2" IN THE CENTER. IT IS DISTRACTING WHILE DRIVING AND IF THE AIR BAG DEPLOYS, IT WILL CREATE AN ACCIDENT. AT THIS POINT, I WOULD BE HAPPY WITH A FIX, IT DOES NOT HAVE TO BE A REPLACEMENT. *TR

WELL I'VE ALREADY PUT IN ONE COMPLAINT SO HERE'S ANOTHER..NOW I HAVE TO REPLACE ANOTHER VALVE COVER GASKET,,THIS WILL B THE SECOND ONE WITHIN A YR..ITS DRIPPING ALL MY OIL OUT&ACTUALLY CAUGHT FIRE. IM SCARED OF THE CAR NOW..I WAS ALREADY SCARED BECAUSE OF THE DASHBOARD IS FALLING IN OR COMING APART...YALL MIGHT NOT DEAL ITS SERIOUS,, BUT I DO LAST TIME YALL WANTED ME TO PAY FOR BUICK TO LOOK AT MY CAR&I FEEL THAT IS WRONG.. I SERIOUSLY NEED SOMEONE TO GET IN CONTACT WITH ME ABOUT THIS MATTER... *TR

Fire

I NOTICED THE DASHBOARD WAS COMING APART FROM THE WINDSHIELD TOWARDS THE DRIVERSIDE..I ALSO STARTED EXPERIENCING MY CAR CUTTING OFF,,&A WEIRD NOISE WHEN I PRESS MY BRAKES..MY CAR ALSO GETS HOT&SMELLS LIKE SOMETHINGS BURNING..I'VE REPLACED NUMEROUS THINGS,,BUT YET TO COME TO A RESOLUTION..I REALLY NEED HELP BECAUSE THIS IS SCARY..I'VE TALKED TO BUICK&YOU ALL WANNA CHARGE ME JUST TO LOOK AT MY CAR??THAT'S NOT HELP AT ALL... *TR