Technical Service Bulletins
Search 172,063 manufacturer communications covering 879 vehicle makes from 1955 to 2025.
Showing 495 bulletins for TESLA
SB-21-12-005
Oct 22, 2021
160000 STRUCTURE
For some Model X vehicles built before May 2018, should water seep into the printed circuit board of the rear door cladding sensor, an alert might be displayed on the touchscreen.
SB-19-15-002 R1
Oct 7, 2021
350000 EQUIPMENT
Some Model 3 vehicles were manufactured with triple camera windshield brackets that were not properly secured to the windshield. Autopilot is designed to deactivate if errors occur, but as a precaution, Autopilot features have been disabled
SB2139001R1
Sep 21, 2021
010000 STEERING
Some versions of Model S and X front drive unit halfshafts might cause excessive vibrations during hard acceleration at higher ride height settings. This is exclusively an NVH issue and does not otherwise affect steering functionality, brak
SB2115006
Sep 11, 2021
350000 EQUIPMENT
Some Model S Palladium vehicles were manufactured with center console decor lid latch pins too short to reliably secure the decor lid open.
SB-21-18-002 R3
Jul 10, 2021
062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM
Certain Model 3 and Model Y vehicles may be equipped with refrigerant pressure/temperature (P/T) sensors in the heat pump that can fault over time.
SB-20-31-006 R3
Jul 2, 2021
010000 STEERING
On certain Model 3, Model Y, and Model X vehicles, there may be a water ingress path to both front upper control arm ball joints that, over time, could possibly lead to surface corrosion of these ball joints. This may result in a creaking s
SB-20-31-006 R2
Jul 1, 2021
020000 SUSPENSION
On certain Model 3, Model Y, and Model X vehicles, there may be a water ingress path to both front upper control arm ball joints that, over time, could possibly lead to surface corrosion of these ball joints. This may result in a creaking s
SB 21 31 002
Jun 24, 2021
020000 SUSPENSION
Certain Model S Palladium vehicles have an incorrect air suspension fill valve installed, resulting in the inability to fill the air suspension reservoir.
SB-18-15-008 R1
Apr 23, 2021
118620 ELECTRICAL SYSTEM:ADAS:HUD:CAMERA/SENSOR
Certain Model X vehicles were manufactured with triple camera windshield brackets that were not properly secured to the windshield. The bracket may look uneven and/or move when manipulated. However, there is no effect on Autopilot functiona
SB-21-12-003
Apr 23, 2021
130000 VISIBILITY
Some Model Y vehicles equipped with auto-dimming door mirror glass have difficulty adjusting the LH door mirror to extreme vertical angles.
SB-21-17-003
Apr 19, 2021
123000 EXTERIOR LIGHTING:TAIL LIGHTS
On some Model Y vehicles, the color of the red band that surrounds the LH and RH taillights do not match because the vehicle has Revision D for the LH taillight (Figure 1) which has a darker tint, and the right side has Revision C (Figure 2
SB-21-18-001 R1
Mar 5, 2021
070000 FUEL SYSTEM, GASOLINE
Certain Model 3 and Model Y vehicles may be equipped with refrigerant pressure/temperature (P/T) sensors in the heat pump that can fault over time.
SB-21-18-002 R1
Mar 5, 2021
070000 FUEL SYSTEM, GASOLINE
Certain Model 3 and Model Y vehicles may be equipped with refrigerant pressure/temperature (P/T) sensors in the heat pump that can fault over time.
SB-21-18-002
Mar 1, 2021
070000 FUEL SYSTEM, GASOLINE
Certain Model 3 and Model Y vehicles may be equipped with refrigerant pressure/temperature (P/T) sensors in the heat pump that can fault over time.
SB-21-18-001
Feb 5, 2021
060000 ENGINE AND ENGINE COOLING
Some Model 3 and Model Y vehicles may be equipped with refrigerant pressure/temperature (P/T) sensors in the heat pump that can fault over time.
SB-21-17-002
Feb 4, 2021
160000 STRUCTURE
The grounding path conductivity for some Model Y front body controller modules might cause the vehicle touchscreen to display an erroneous ?Hood latch sensor requires service? message. This condition will not affect any functions of the fru
SB-21-11-001
Jan 22, 2021
160000 STRUCTURE
On some Model 3 vehicles, the body joint sealant on the outer rear quarter panels are missing or were not properly applied, causing water ingress to the trunk compartment.
SB-21-12-001
Jan 6, 2021
350000 EQUIPMENT
On certain Model Y vehicles, the front and/or mid aero shield panel(s) may not have been installed at the factory. In addition, if one or both panels are missing, a four wheel alignment may have not been performed.
SB-20-33-002
Dec 22, 2020
050000 PARKING BRAKE
Certain Model 3 vehicles may have sustained damage to the Electric Park Brake (EPB) housing during the vehicle assembly process.
SB-20-21-002 R3
Dec 5, 2020
350000 EQUIPMENT
For some Model S and Model X vehicles built before March 2018, an 8GB embedded MultiMediaCard (?8GB eMMC?) in the Media Control Unit (MCU) might malfunction due to accumulated wear. This could result in a blank or intermittently blank touch
SB-20-21-002 R2
Nov 23, 2020
350000 EQUIPMENT
For some Model S and Model X vehicles built before March 2018, an 8GB embedded MultiMediaCard (?8GB eMMC?) in the Media Control Unit (MCU) might malfunction due to accumulated wear. This could result in a blank or intermittently blank touch
SB-20-31-012
Nov 12, 2020
010000 STEERING
On certain Model Y vehicles, the Front Upper Control Arm (FUCA) to steering knuckle fastener for both LH and RH sides of the front suspension might be loose, or the FUCA to steering knuckle nut(s) might be missing altogether.
SB-20-21-002 R1
Nov 11, 2020
350000 EQUIPMENT
For some Model S and Model X vehicles built before March 2018, an 8GB embedded MultiMediaCard (?8GB eMMC?) in the Media Control Unit (MCU) might malfunction due to accumulated wear. This could result in a blank or intermittently blank touch
SB-20-21-002
Nov 9, 2020
350000 EQUIPMENT
For some Model S and Model X vehicles built before March 2018, an 8GB embedded MultiMediaCard (?8GB eMMC?) in the Media Control Unit (MCU) might malfunction due to accumulated wear. This could result in a blank or intermittently blank touch
SB-20-17-010 R1
Nov 3, 2020
110000 ELECTRICAL SYSTEM
On certain Model 3 vehicles, an open electrical circuit or short to ground near connectors X950 or X952 may display a restart alert on the touchscreen, or prevent the vehicle from starting altogether.