Technical Service Bulletins
Search 172,063 manufacturer communications covering 879 vehicle makes from 1955 to 2025.
Showing 3,689 bulletins for MAZDA
SA-020-18
Apr 25, 2018
220000 SEATS
Some customers may complain that the center of the driver and/or passenger side seat bottom(s) are loose/lifting, as shown below. NOTE: Not all vehicles will have the same color leather seats or have the same amount of looseness/lifting.
07-003-18-3462
Apr 20, 2018
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
Some customers may complain about one or both of the following symptoms: When selecting the "Defroster Vents" position (2) with the Mode Selector Dial (1), the dial does not stay in the "Defroster Vents" position and returns to the "Defrost
02-007-18-3438
Apr 20, 2018
020000 SUSPENSION
Some vehicles may exhibit one or more of the following noises from the front suspension: 1. A creaking noise from under the front of the vehicle (front lower arm bushing) when driving over bumps at approximate 12 - 25 mph (20 - 40 Km/h). Th
07-001-18-3465
Apr 19, 2018
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
Some customers may complain about warm air from the climate control vents when the air conditioner is ON. This may be caused by condenser corrosion, causing a refrigerant leak. The manufacturer of the condenser has been changed and the conf
07-002-18-3432
Apr 16, 2018
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/Cevaporator/cooling unit which is c
SA-019-18
Apr 16, 2018
060000 ENGINE AND ENGINE COOLING
While inspecting turbocharger housings, you may see cracks (fractures) as shown below. The cracks do not affect engine performance or cause any noise, so replacement is NOT necessary.
05-004-18-3466
Apr 16, 2018
060000 ENGINE AND ENGINE COOLING
Some vehicles may experience the check engine light and automatic transaxle warning light ON with one or more of these DTCs stored in the TCM memory (P0842, P0847, P0872, P0877, P0780, P1738). P0842:00 - Oil pressure switch No. 1 (oil press
00-002-18-3463
Apr 13, 2018
350000 EQUIPMENT
In support of the new Mazda6 Signature model, Mazda will make available for loan on a "as-needed" basis, a Special Service Tool (SST) to allow for the aiming of the 360 Degree Camera System. Please follow the aiming instructions on MGSS (36
05-003-18-3460
Apr 12, 2018
100000 POWER TRAIN
Some customers who drive at elevations higher than 3,300 ft (1,000 m) may complain of a shift shock felt when shifting into 3rd, 5th and/or Reverse with no AT related DTCs stored. The symptom can be temporarily repaired using the AT initial
09-008-18-3416a
Apr 10, 2018
110000 ELECTRICAL SYSTEM
Some vehicles may exhibit the active driving display opening/closing improperly as described below: It does not open or close when the ignition is turned ON or OFF. The display operation does not fully open/close. It closes and then opens b
09-020-18-3458
Apr 5, 2018
353000 EQUIPMENT:ELECTRICAL
Some vehicles may exhibit BLUETOOTH? hands-free and/or text messaging related concerns. To improve the handling of BLUETOOTH? hands-free and/or text messaging customer concerns, Mazda created a special service and parts exchange program as
01-004-18-3407a
Apr 5, 2018
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This TSB has been superceded by SSPB5 - 2017 MX-5 - BATTERY DISCHARGING CONCERN.
01-011-18-3456
Apr 5, 2018
350000 EQUIPMENT
The vehicles listed above are equipped with a push button start/stop ignition system. Unlike previous Mazdamodels, there is no key cylinder on the steering column. Therefore, the engine cannot be started with theauxiliary key if the room fu
08-001-18-3457
Apr 5, 2018
140000 AIR BAGS
This information is provided to help address Passenger Airbag Deactivation (PAD) Indicator illumination concerns during vehicle service.
09-021-18-3459
Apr 5, 2018
162700 STRUCTURE:BODY:TRUNK LID
Some vehicles may experience stains appearing on the hood, roof and/or trunk of the vehicle. This concern is most likely to be found in a cold weather areas just after the RAPGARD is removed at PDI. This may be caused by moisture which has
SSPB5
Apr 5, 2018
110000 ELECTRICAL SYSTEM
2017 MX-5 Battery Discharging Concern Special Service Program (SSP) B5 - Mazda Motor Corporation has decided to conduct a Special Service Program (SSP) on certain 2017 MX-5 vehicles equipped with retractable fastback hardtop, and built from
05-001-18-3453
Apr 2, 2018
100000 POWER TRAIN
Always be sure to use the correct automatic transmission fluid when replacing ATF. Using the wrong ATF may cause shift quality complaints or may even damage the transmission. NOTE: ATF M-V (TYPE M5) IS NOT THE SAME FLUID AS MERCON?V OR MERC
04-003-18-3455
Apr 2, 2018
060000 ENGINE AND ENGINE COOLING
Some customers may report a slight clunk/bang/buzz noise or jolt from the front of the vehicle. This concern will most likely occur during the vehicles first forward movement after starting the engine. This is a normal operating noise of th
05-002-18-3454
Apr 2, 2018
100000 POWER TRAIN
The new SKYACTIV-DRIVE FW6A-EL AT uses "Automatic Transmission Fluid (ATF) Type: FZ". Only use"ATF-FZ" to fill or top off the fluid level. ATF-FZ is specially designed for use in the SKYACTIV-DRIVE series AT. It is a low viscosity formula w
01-010-18-3442
Mar 29, 2018
060000 ENGINE (PWS)
Some vehicles may exhibit an engine misfire during acceleration with the check engine light flashing and the following DTC(s). P0302:00 - Cylinder No.2 misfire detected and/or P0303:00 - Cylinder No.3 misfire detected. NOTE: Even if a misfi
SA-017-18
Mar 28, 2018
118000 ELECTRICAL SYSTEM:SOFTWARE
Upgrade your PCs to IDS version 109.00 and 109.01 from the previous version. NOTE: You may see ?Selection not available? on IDS when a selecting ?Programming menu?, 108.07 included a timer extension for Programming menu application that ha
SA-018-18
Mar 28, 2018
353000 EQUIPMENT:ELECTRICAL
The 360 degree View Monitor System is new for i-ACTIVSENSE on the 2018 Mazda6 Signature. During PDI, make sure all 4 cameras (front (1), right side (2), left side (3) and rear (4)) are working and displaying an image on the MAZDA CONNECT sc
MT-004-18
Mar 28, 2018
110000 ELECTRICAL SYSTEM
ELECTRICAL CONCERN AND/OR MULTIPLE DTC'S DUE TO AFTERMARKET DEVICE: If you encounter any type of electrical concern (e.g, dead battery, engine no start, DTC(s) stored...), interview the customer before proceeding with normal Workshop Manual
SA-016-18
Mar 26, 2018
118000 ELECTRICAL SYSTEM:SOFTWARE
If the MAZDA CONNECT Connectivity Master Unit (CMU) is replaced due to failure, the replacement CMU may have a navigation system software error. To resolve this concern, after the installation of the new CMU, check the software version.
01-009-18-3452
Mar 26, 2018
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
The Mazda GR8-1291 is required for all warranty battery testing. If the Mazda GR8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to test