Technical Service Bulletins
Search 172,063 manufacturer communications covering 879 vehicle makes from 1955 to 2025.
Showing 3,689 bulletins for MAZDA
09-019-18-3450
Mar 26, 2018
356000 EQUIPMENT ADAPTIVE/MOBILITY
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. The following are possible causes of floor mat interference, which can be avoided with p
01-008-18-3451
Mar 26, 2018
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in sto
SA-016-18
Mar 26, 2018
118000 ELECTRICAL SYSTEM:SOFTWARE
If the MAZDA CONNECT Connectivity Master Unit (CMU) is replaced due to failure, the replacement CMU may have a navigation system software error. To resolve this concern, after the installation of the new CMU, check the software version.
09-016-18-3428
Mar 26, 2018
221600 SEATS:FRONT ASSEMBLY:POWER ADJUST
Some customers may complain that the driver's seat does not automatically move to the programmed position when unlocking the driver's door with the remote transmitter unlock button (1), unless the button is pressed repeatedly (more than two
02-006-18-3449
Mar 26, 2018
021300 SUSPENSION:FRONT:SHOCK ABSORBER
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
09-018-18-3447
Mar 26, 2018
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
Some customers may complain about spider web-like cracking (as shown below) appearing in the corner(s)of the MAZDA CONNECT center display. The cracks are internal and cannot be felt by touch. This concern may be caused by a lack of glue bet
09-015-18-3445
Mar 22, 2018
220000 SEATS
At PDI or when new vehicle is delivered, some customers may complain about wrinkles on the leather seat cushion and/or seat back surface.
09-014-18-3443
Mar 22, 2018
160000 STRUCTURE
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
09-011-18-3448
Mar 22, 2018
121000 EXTERIOR LIGHTING:HEADLIGHTS
Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear (taillamp/taillight) combination lights. The recent new models have been fitted with a clear lens which can cause the symptom to be more noticeabl
02-005-18-3444
Mar 22, 2018
020000 SUSPENSION
Beginning with the CX-5, grip type front and rear stabilizer bushings have been incorporated for noise prevention purposes. If any type of grease or lubrication is applied to the bushings, it may create noise due to bushing slippage.
SA-015-18
Mar 22, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
A tapping/rattling noise may be noticed from the valve train area. This condition usually occurs after the engine has been turned off at normal operating temperature and then not warmed up to full operating temperature during the next serie
09-013-18-3434
Mar 22, 2018
220000 SEATS
Some customers may complain about the driver and/or passenger rear side seat cushion trim (1) coming off the seat cushion frame. The front seat cushion trim (bottom rear) is attached to the seat cushion frame using a hook. The hook may slip
09-012-18-3433
Mar 22, 2018
121000 EXTERIOR LIGHTING:HEADLIGHTS
When the LED headlight auto leveling system initialization has been performed using Mazda Modular Diagnostic System (M-MDS), the LED headlight warning light continues flashing and DTC C0061:54 is stored after unloading the vehicle from a tr
00-001-18-3446
Mar 22, 2018
350000 EQUIPMENT
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
09-007-18-3422a
Mar 22, 2018
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
Some customers may experience a navigation system screen that shows the wrong location. This concern is due to poor reception of the GPS signals. To eliminate this concern, the CMU hardware has been modified.
01-007-18-3408
Mar 21, 2018
060000 ENGINE (PWS)
Some vehicles may experience a condition where the engine does not start using the normal starting procedure and the doors will not lock/unlock when using a request switch. The engine will start if you touch the backside of the remote (1) t
RF-18-01
Mar 20, 2018
355100 EQUIPMENT:OTHER:LABELS
If one of the blind spot monitoring (BSM) control modules has to be replaced on a 2017-2018 CX-5, inspect the labels (1) and (2) on the modules (P/N KB8C-67Y30E). Modules that have an ?A9? label cannot be used with modules that have an ?A8?
RF-16-03R1
Mar 20, 2018
092300 FUEL SYSTEM, OTHER:FUEL FILTER
The SKYACTIV?-G 2.5T engine requires a unique oil filter (PY8W-14-302) which is NOT interchangeable with other SKYACTIV? oil filters. The unique oil filter can be identified with two white bands as shown below.
09-010-18-3440
Mar 19, 2018
118000 ELECTRICAL SYSTEM:SOFTWARE
Some vehicles may experience the symptoms mentioned below, which can be fixed with the latest software update (Version 59.00.504 or later). NOTE: For 2016 CX-9 with version earlier than 59.00.441, the tachometer function will be removed fro
DRW13
Mar 15, 2018
118000 ELECTRICAL SYSTEM:SOFTWARE
Dealer Rework (DRW) 13 - Mazda Connect Navigation Concern. As you may know, DRW13 was launched in March of 2018. This notice is to advise all dealers that DRW13 will be ending August 16th 2018 and all claims must be submitted by this date.
09-009-18-3439
Mar 14, 2018
220000 SEATS
On some vehicles, the second-row seat back does not fold (B) or slide (C) forward when the walk-in lever (A) is pulled up to access to the 3rd row seats. Also, the recliner lever knob (D) may not operate on some vehicles. These concerns may
SSPB4
Mar 9, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Mazda Motor Corporation has decided to conduct a Special Service Program (SSP) on certain 2014 Mazda3 vehicles. Certain vehicles which were previously inspected / repaired under SSPB0 need to be re-inspected under this new SSPB4 for the sam
04-002-18-3435
Mar 9, 2018
030000 SERVICE BRAKES, HYDRAULIC
Some vehicles may exhibit a squeak type noise from the rear brakes when driving at approximately 6- 12 mph (10-20 km/h) with or without light braking. The noise usually occurs when driving immediately after the parking brake is released, an
01-006-18-3429
Mar 9, 2018
060000 ENGINE (PWS)
When the engine is started for the first time after parking the vehicle overnight in cold conditions (below 32 degrees Fahrenheit / 0 degrees Celsius), some vehicles may exhibit a rough idle and/or the check engine light on with any of the
SA-014-18
Mar 7, 2018
264100 FORWARD COLLISION AVOIDANCE: SENSING SYSTEM: CAMERA
Some customers may complain about the following message displayed in the Multi-Information Display: In the following cases, the MRCC with Stop & Go function system is canceled when the vehicle is traveling at 19 mph (30 km/h) or less: The F