Technical Service Bulletins
Search 172,063 manufacturer communications covering 879 vehicle makes from 1955 to 2025.
Showing 3,689 bulletins for MAZDA
01-016-18-3522
Sep 6, 2018
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. The odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. Sulfur smell is not a
03-002-18-3505a
Sep 5, 2018
105100 POWER TRAIN:DRIVELINE:UNIVERSAL JOINT
Some vehicles may exhibit a squeak noise from the right front driveshaft at the transaxle when driving. This concern is likely to occur when driving at speeds between 37-50 mph (60-80 km/h) with the ATF at normal operating temperature. The
02-014-18-3503
Sep 4, 2018
021300 SUSPENSION:FRONT:SHOCK ABSORBER
Some vehicles may experience a creaking noise from the front shock absorber when going over bumps. Upon inspection, the coil spring is found to be broken at the lower part without any trace of an accident. It may be found during maintenance
09-034-18-3430
Aug 31, 2018
180000 VEHICLE SPEED CONTROL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to co
CSP02
Aug 27, 2018
350000 EQUIPMENT
CSP02 - Apple CarPlay and Android Auto - Parts and Warranty Information. As previously communicated, Apple CarPlay? and Android Auto? will soon be available as a Genuine Mazda Accessory for the 2018 Mazda6 beginning in early September. For
SA-040-18
Aug 24, 2018
060000 ENGINE (PWS)
Some vehicles may experience a check engine light on and/or failsafe with DTC P061B:00 stored in the PCM. This condition will likely occur as a result of one of the following causes: Engine cranking was interrupted by releasing the brake pe
01-015-18-3513
Aug 22, 2018
031000 SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
Some vehicles may experience a lack of power and the check engine light on with DTC P061B:00 stored in the PCM memory when engine cranking is interrupted. This concern most likely occurs when the brake pedal is released during engine cranki
09-033-18-3506
Aug 17, 2018
110000 ELECTRICAL SYSTEM
Some customers may experience the active driving display (auto flip-up type) does not flip up and no DTC is stored. Due to improper assembly, a deformed bracket may cause a loose mesh between internal gears. To correct this issue, the activ
03-002-18-3505
Aug 17, 2018
105300 POWER TRAIN:DRIVELINE:DRIVESHAFT
Some vehicles may exhibit a squeak noise from the right front driveshaft at the transaxle when driving. This concern is likely to occur when driving at speeds between 37-50 mph (60-80 km/h) with the ATF at normal operating temperature. The
SA-038-18
Aug 15, 2018
063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
Some vehicles may have a check engine light on with a DTC P2004 (Intake Manifold Runner Control Stuck Open) stored in memory. This DTC is set when the IMRC is commanded closed, but the IMRC indicates open.
SA-037-18
Aug 15, 2018
106000 POWER TRAIN:AXLE ASSEMBLY
Service part Automatic Transaxles (ATX) manufactured on or after July, 2018 are shipped with a blank TCM that requires configuration.
09-032-18-3483
Aug 13, 2018
123000 EXTERIOR LIGHTING:TAIL LIGHTS
Some customers may complain of foggy rear combination lights (as shown below) after a car wash or heavy rain. This concern may be caused by water entering into the rear combination lights through the ventilation tubes. To eliminate this fro
00-004-18-3515
Aug 10, 2018
270000 LANE DEPARTURE
In support of the new Mazda MX-5 and CX-3, Mazda will make available for loan on a "as-needed" basis, a Special Service Tool (SST) to allow for the radar aiming of the blind spot monitoring (BSM) system. The(BSM) radar aiming is performed w
09-031-18-3489
Aug 10, 2018
273000 LANE DEPARTURE: BLIND SPOT DETECTION
If it becomes necessary to replace the right-side Blind Spot Monitoring (BSM) control module, the configuration may fail even though the Workshop Manual procedure was performed properly. This may occur when the existing BSM control module h
01-001-18-3419a
Aug 9, 2018
052310 PARKING BRAKE:DRIVELINE:HYDRAULIC:ACTUATOR
After parking the vehicle at temperatures below the freezing, some customers may experience a lack of power with the check engine light on and DTC P0638:00 and/or P2112:00 stored in memory. - P0638:00: Throttle valve actuator control range/
09-030-18-3484
Aug 2, 2018
162300 STRUCTURE:BODY:DOOR
Some customers may complain that the rear door seaming welt (1) comes off when stepping in and/or out of the vehicle. This is caused by the gripping force of the seaming welt being insufficient for frequent usage of the rear seat (vehicle u
07-004-18-3461b
Aug 1, 2018
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
Some vehicles may experience that the A/C does not blow cold air (blows warm air) due to a refrigerant leak. This is caused by a crack in the cooler pipe (HI) A (1) due to engine vibration. To correct this issue, the material and thickness
04-006-18-3496
Jul 30, 2018
030000 SERVICE BRAKES, HYDRAULIC
Some vehicles may exhibit a squeaking noise from the front brakes during light braking. This concern usually occurs when the front brake pads have been worn to certain levels. Also, as the pads wear, the chamfer goes away and the grease bet
SA-036-18
Jul 30, 2018
110000 ELECTRICAL SYSTEM
MAZDA MOBILE START (MMS) APP ERROR MESSAGE INSTALLED ON ANDROID DEVICES: Customers may get an error message "Device no longer has access or service." for the MMS APP installed on android devices starting 8/1/18. Inform the customer that all
01-010-18-3442b
Jul 30, 2018
060000 ENGINE (PWS)
Some vehicles may exhibit an engine misfire during acceleration with the check engine light flashing and the following DTC(s). P0302:00 - Cylinder No.2 misfire detected and/or P0303:00 - Cylinder No.3 misfire detected NOTE: Even if a misfir
02-003-18-3501
Jul 30, 2018
200000 WHEELS
Some vehicles may have aluminum alloy type wheel(s) with one of the following paint damage conditions shown in the sample photos below. The damage extends to the front surface of the aluminum wheel partly or entirely.
MT-007-18
Jul 20, 2018
060000 ENGINE (PWS)
ENGINE NO START AND / OR REAR VIEW MONITOR DISPLAY IS BLURRY DUE TO AFTERMARKET ELECTRICAL DEVICE: Some customers may complain about the following: Engine no start. A blurry rear view monitor display. This may be caused by an aftermarket a
SA-035-18
Jul 20, 2018
110000 ELECTRICAL SYSTEM
MAZDA MOBILE START (MMS) UPDATE INSTRUCTIONS: The current installation instructions for Mazda Mobile Start (MMS) on a 2019 CX-3 are incorrect when inserting the hood switch wire into the C-01 connector. Use the attached supplement sheet whe
MT-008-18
Jul 20, 2018
060000 ENGINE (PWS)
ENGINE NO START (KEY NOT DETECTED): Some customers may complain about the following: Intermittent engine no start, Instrument cluster red security indicator light ON, Engine Start/Start Button Amber indicator light flashing.