Technical Service Bulletins
Search 172,063 manufacturer communications covering 879 vehicle makes from 1955 to 2025.
Showing 3,689 bulletins for MAZDA
MT-012-18
Dec 11, 2018
010000 STEERING
If a vehicle has body vibration or steering wheel shimmy while driving and the root cause is determined to be tire balance, re-balance the tires using a Hunter GSP9700 or equivalent balance machine. If your dealer does not have a GSP9700 or
SA-041-18
Dec 6, 2018
060000 ENGINE (PWS)
If you receive a customer complain of lack of power, rough idle, engine noise with stored DTC's P0340:00, P0304:00, P3400:00, P349B:00, and/or P3498:00, perform the following.
09-043-18-3441
Dec 6, 2018
130000 VISIBILITY
Some vehicles may exhibit the cushion tape (1) attached to the front end of dashboard coming off and showing at the base of the windshield.This is caused by the cushion tape peeling off from the end(s) due to interference with the windshiel
09-010-18-3440b
Dec 5, 2018
350000 EQUIPMENT
All Mazda Connect vehicles in new car inventory must be updated to the software version listed below in this TSB as part of the New Car Ready Step 3 process. Make sure the new vehicle specialist receives a copy of this bulletin.Some vehicle
15-002-18-3502a
Dec 5, 2018
110000 ELECTRICAL SYSTEM
Some customers may complain about one or more warning lights ON when they start the vehicle during hot weather. The following DTC is stored in memory: U3000:98 - Forward sensing camera (FSC) stops functioning due to temporary high temperatu
02-015-18-3499a
Nov 30, 2018
022110 SUSPENSION:REAR:SPRINGS:COIL SPRINGS
Some vehicles may exhibit a knocking noise from the rear coil spring and/or the vehicle body sits lower in the rear. These symptoms may be caused by a broken rear coil spring at its lower side. This is caused by corrosion from dust between
09-042-18-3536
Nov 30, 2018
162200 STRUCTURE:BODY:BUMPERS
Some customers may notice cracks at one or both ends of the front bumper near the front fender / front combination light. This may be caused when driving over bumps. The bumper fascia may receive higher than expected forces, depending on dr
MT-010-18
Nov 27, 2018
110000 ELECTRICAL SYSTEM
Some vehicles (with MAZDA CONNECT) may exhibit a condition where DTC U0323(PCM) / U0423(ABS) /U3000(IC) CANNOT be deleted when the TPMS warning light flashes and/or the TCS/DSC indicator lights are illuminated. This can happen if the igniti
MT-011-18
Nov 27, 2018
110000 ELECTRICAL SYSTEM
SMS (Short Message Service) messages received by paired phones (Android and iPhone 5 iOS 7.0 or higher) can be downloaded, displayed, and played (text to voice) on vehicles equipped with MAZDA CONNECT. When parked, new messages can be displ
MT-009-18
Nov 20, 2018
060000 ENGINE AND ENGINE COOLING
If an oil pressure inspection is needed on a SKYACTIV-G engine, use the Special Service Tool (SST) set shown below and refer to the instructions on MGSS online: CX-3: (OIL PRESSURE INSPECTION [SKYACTIV-G 2.0] ), MX-3: (OIL PRESSURE INSPECTI
09-041-18-3533
Nov 13, 2018
121000 EXTERIOR LIGHTING:HEADLIGHTS
Some customers may notice water entry into the front combination lights. This is due to poor sealing where rain or other water can enter inside the light. To eliminate this concern, the shape of the front combination light has been changed
15-004-18-3539
Nov 9, 2018
273000 LANE DEPARTURE: BLIND SPOT DETECTION
Some customers may experience a Blind Spot Monitoring (BSM) system that does not detect a vehicle in the BSM alert area. The BSM indicator light on the outer door mirror glass will not illuminate and no DTC's are stored. The BSM system may
09-040-18-3537
Nov 9, 2018
162000 STRUCTURE:BODY
Some customers may notice the flock finishing on the door sash molding is peeled off when opening the frozen door. This concern may be caused by insufficient durability due to an improper production process of the door sash moldings. To eli
01-022-18-3528a
Nov 9, 2018
060000 ENGINE (PWS)
Some vehicles may exhibit an excessive body vibration/unusual noise when idling or driving after parking inextremely cold temperatures (-25?C/-13?F). NOTE: This excessive vibration does not occur if the engine mount rubber No.1 is over -25?
SA-049-18
Nov 8, 2018
350000 EQUIPMENT
SiriusXM Traffic Plus and Travel Link are displayed with Mazda in-vehicle factory navigation systems. Both of these services provide information in the U.S. & Canada. NOTE: SiriusXM Traffic Plus and Travel Link subscription is free of charg
SA-048-18
Nov 7, 2018
353000 EQUIPMENT:ELECTRICAL
Some vehicles may crank but not start due to a PCM/Immobilizer malfunction. If this happens, check the status of Recall 3505H. If Recall 3505H has NOT yet been completed, perform the following steps: a. Perform and close recall 3505H. b. O
SA-047-18
Nov 6, 2018
110000 ELECTRICAL SYSTEM
Some customers may complain about a MAZDA CONNECT system reboot or blank screen. Use the flowchart below to repair the vehicle.
DRW16
Nov 5, 2018
022142 SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY:HANGER/BRACKET
Dealer Rework (DRW) 16 ? 2019 CX-5 (KF) Interference of Silencer Hanger: We are writing to inform you that certain 2019MY CX-5 vehicles, may be affected by the concern mentioned below. Vehicles affected by this DRW will be visible in eMDCS
02-017-18-3511
Nov 2, 2018
021300 SUSPENSION:FRONT:SHOCK ABSORBER
Some vehicles may experience one or both of the following noises from the front shock absorber. A knocking/popping noise occurs when passing over speed bumps. A squeaking noise occurs when turning the steering wheel with vehicle at a stands
09-039-18-3520
Nov 1, 2018
161100 STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
Some customers may notice the floor under cover No. 2 falling off at the bolt (1) location after driving through snow and/or ice. This may be caused by snow and/or ice accumulation under cover No. 2. This concern is caused because the bolt
15-003-18-3532
Oct 26, 2018
110000 ELECTRICAL SYSTEM
Some customers may complain that the Blind Spot Monitoring (BSM) system indicates that there is a vehicle in the right or left side blind spot area after the vehicle passes and is no longer there. This may becaused by the BSM control module
09-038-18-3527
Oct 26, 2018
130000 VISIBILITY
Some vehicles may experience a rattle noise from the front door glass when driving with the window open approx. 1/2 to 4 inches (1 - 10 cm). The rattle noise may be caused by insufficient holding force of the glass run channel. To increase
09-037-18-3534a
Oct 25, 2018
060000 ENGINE (PWS)
Some vehicles equipped with MAZDA CONNECT may exhibit the following oil maintenance monitor concerns on the center display: The wrench light (Oil Change Due message) cannot be cleared using MAZDA CONNECT/Applications/Vehicle Status Monitor/
SA-046-18
Oct 24, 2018
353000 EQUIPMENT:ELECTRICAL
APPLE CARPLAY? / ANDROID AUTO? FREQUENTLY ASKED QUESTIONS (FAQ)
01-015-18-3513a
Oct 23, 2018
060000 ENGINE (PWS)
Some vehicles may experience a lack of power and the check engine light on with DTC P061B:00 and U0401:00 stored in the PCM memory when engine cranking is interrupted and on A/T vehicles, DTC U0442:00 is also stored. This concern most likel