2024 TOYOTA RAV4 PRIME

2 recalls, 38 complaints - 36 TSBs - 5/5 safety rating

BACK OVER PREVENTION:DISPLAY FUNCTION

Defect Description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2026 Toyota, Lexus, and Subaru Solterra vehicles equipped with a Panoramic View Monitor (PVM) system. Please see the recall report for a complete list of models. A software error may cause the rearview camera to freeze or di... Read more

Consequence

A rearview camera that fails to display an image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy

Dealers will update the parking assist software, free of charge. Owner letters were mailed January 2, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB13 and 25LB06. Subaru's number for this recall is WRE25.

1,024,407 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Defect Description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner ... Read more

Consequence

An instrument panel display that does not show critical information can increase the risk of a crash or injury.

Remedy

Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional let... Read more

591,377 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

Complaint Statistics

38 total complaints 2 crashes 1 injuries

Top Reported Components

Component	Complaints
ENGINE	7
ELECTRICAL SYSTEM	6
STRUCTURE:BODY	4
UNKNOWN OR OTHER	4
POWER TRAIN	3
SERVICE BRAKES	2
FUEL/PROPULSION SYSTEM	2
STEERING	2
VEHICLE SPEED CONTROL	1
SUSPENSION	1

Incident date: Apr 23, 2026

2022 Volvo XC60 T8 Recharge VIN: [XXX] Mileage at time of complaint: ~38,400 Purchased: November 2023 (Certified Preowned) DESCRIPTION OF PROBLEM: The vehicle's infotainment system and backup camera have experienced repeated failures since the time of purchase. The backup camera intermittently fa... Read more

Incident date: Apr 4, 2026

The 12V battery in my 2025 Hyundai Ioniq 5 failed under normal use, causing repeated loss of vehicle function. Voltage measured ~12.3V at rest, dropping to ~12.0V when opening the door, and collapsing to ~11V then ~9V under light load (headlights), resulting in system shutdown. After a failed start... Read more

Incident date: Jan 19, 2026

On January 21, 2026 i was involved in a car accident with a tractor in which the tractor collided with my passenger front side of my car causing me to slide into corn field causing the total destruction of my vehicle. None of my airbags deployed. There were no warning lamps or indicators from the ve... Read more

Crash 1 injured

Incident date: Mar 17, 2026

During acceleration above 25 mph a noticeable whining sound is heard from the transmission. When not acceleration the sound goes away. The vehicle only has 72300 miles

Incident date: Oct 29, 2025

On 2/21/26, while driving approximately 60 mph, my car experienced a sudden loss of propulsion. The vehicle unexpectedly shifted into neutral and began decelerating, displaying a prompt instructing me to press the start button. I was able to coast to the shoulder and avoid a collision, but the incid... Read more

Incident date: Jan 12, 2026

Q: What component or system failed or malfunctioned, and is it available for inspection upon request? A: ICCU failed - Not available for inspection (at least at this time, but willing to try and make it work). Q: How was your safety or the safety of others put at risk? A: The ICCU (Integrated Cha... Read more

Incident date: Jan 12, 2026

Incident date: Feb 10, 2026

My backup camera began malfunctioning in November 2025. Initially, the image became distorted, and shortly after, the screen went completely blank with a message instructing me to contact the dealership. I did so and was informed that my vehicle was not included in the recall and that I would be res... Read more

Incident date: Jan 3, 2026

I believe something is wrong with the electrical system tied into the infotainment system of the car, which displays the radio, heating, cooling, shows the rear camera controllers, as well as some fo the lighting in the sport L is not fully lit, for example where the shift gears is there a light tha... Read more

Incident date: Sep 11, 2025

The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that while driving at 65 MPH, the vehicle vibrated and failed to accelerate as intended while depressing the accelerator pedal. Additionally, the vehicle failed to exceed 40 MPH. The contact was able to pull over into a rest area. ... Read more

Incident date: Dec 17, 2025

Subject: Excessive Engine Oil Consumption – 2016 Hyundai Sonata I am reporting an ongoing and excessive engine oil consumption issue with my 2016 Hyundai Sonata that I believe may represent a safety defect or other significant reliability concern. The engine is burning oil at a rate far beyond n... Read more

Incident date: Jan 1, 2026

68C recall did not fix recurring issue with this vehicle: 12/2/25 – The vehicle was towed to the dealer under Safety Recall 68C (battery fire risk) in an undrivable state “service charging system” message, vehicle would not disengage from Park, no power, battery, charging, service engine ligh... Read more

Incident date: Dec 5, 2025

I was driving my 2001 Dodge Ram 20-30mph and experienced a total power loss, power steering, power brakes and clock reset. My husband was also in the pickup and can attest to issue. I am an older person so had a very hard time stopping the vehicle and attempting to steer it to the side of the road. ... Read more

Incident date: Nov 14, 2025

The Environmental Air Catalyst (EAC) Sensor on my 2016 MINI failed two years ago when I had only 25,000 miles on the car. (The car now has 30,200 miles on it; I do not drive it very much). NHTSA worked with MINI/BMW several years ago, and MINI extended a limited warranty for this sensor to 15 yea... Read more

Incident date: Nov 14, 2025

Brake booster has gone out at 100,000 miles. Brakes do not work when vehicle is first started. Problem was diagnosed by an independent mechanics shop. There was no warning light until after the first incident.

Incident date: Nov 14, 2025

Made a right hand turn and vehicle shut off in traffic barley got into turn lane and vehicle died in the middle of the road, just got lucky a state trooper was behind us to hold traffic off.. would not restart no power, dead battery, put a jumper on the vehicle and it started enough to get out of i... Read more

Incident date: May 13, 2025

The contact owns a 2016 Hyundai Sonata. The contact stated while driving 5 MPH and making a turn into a parking lot, the steering wheel seized, and the vehicle came to a stop. The contact was able to push the vehicle to a parking space with assistance. The vehicle was then pushed on to a tow truck a... Read more

Incident date: May 13, 2025

Incident date: Jun 6, 2025

At about 60,000 miles a VW dealer told me it was normal for VWs to use oil. Now at 80,000 I have a $2,000+ bill b/c the PCV is faulty and the timing cover has failed. I did NOT get a low dngine oil warning, but mechanic says panic wait it was low ( oil change 4,000 miles ago). This could have led to... Read more

Incident date: Jun 6, 2025

When driving at highway speeds, steering feels like it is stuck in particular position. Especially while navigating a slight left turn. Needing to use additional force to bring the steering back to center

Incident date: Jun 13, 2025

2019 ram 1500 big horn rear back lite leak. Anytime it rains it pours from the frame where it has developed two cracks on either side of the power sliding window. Dealer states it needs replaced after resealing the window and the 3rd brake light. Dealer states Ram will not pay for the replacement ev... Read more

Incident date: Jun 13, 2025

Incident date: Feb 28, 2025

Reverse lights no longer illuminate when placing car into reverse. This is a safety issue as cars behind me are not made aware if I am wanting to reverse until they see the car in motion.

Incident date: Jan 7, 2025

When I put my car in park it began to smell as if something was burning. Within a few days, my car began leaking oil. I brought it to my mechanic, who let me know that my oil cooler was leaking. He let me know that this is a very common issue with Jeeps and Jeep is very well aware of it. He let me k... Read more

Incident date: Dec 3, 2024

Second row seat belt buckles come unbuckle while driving. Even with buckle securely fastened and checked upon passenger being seated, later on the seatbelt becomes unbuckled randomly during driving. Extreme safety issue not only since the passenger is unbuckled, but because driver now becomes distra... Read more

Incident date: Dec 14, 2024

I purchased my 2015 Nissan Altima in July, 2022 with 56,530 miles on it. At this date it has approximately 71,500 miles on it. I have driven it 14,970 miles in 2.5 years. On [XXX] I was driving home from Thanksgiving in East Brunswick, NJ to my home in South Philadelphia on [XXX] in New Jersey when... Read more

Incident date: Nov 20, 2024

The abs module has failed on the 2016 Ram 1500. It has illuminated the brake light, abs light, and traction light on my dash permanently. It is disabling abs, cruise control, and now I will not know if any other problems arise in my brake system because the lights stay on permanently. I have been... Read more

Incident date: Aug 13, 2024

The contact owns a 2021 Chrysler 300. The contact received notification of NHTSA Campaign Number: 24V198000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of tim... Read more

Incident date: Aug 1, 2024

I was turning right into a parking space when the vehicle suddenly accelerated and did not stop when I removed my foot from the accelerator and tried to brake. The car continued to accelerate through a low cinder block wall and did not stop until it dropped 3-4 feet off the side of the parking lot i... Read more

Crash

Incident date: Aug 5, 2024

On multiple occasions now, the passenger side door has randomly opened, which sets off the door ajar warning, and I have to pull over and close the door. In addition, again randomly, the passenger side door locks will unlock, then relock, usually several times in rapid succession. Both situations se... Read more

Incident date: Aug 5, 2024

It is very common problem with 2018-2023 honda odyssey. Water leaks inside from the seam crack under roof drip trim. This water is dripping right on the tailgate control electronic module. And module is short circuit and dead. Now tailgate is either stays locked or stays open all the time as the lat... Read more

Incident date: Aug 5, 2024

Incident date: Jul 29, 2024

A week ago, I went to my local garage that I trust for a completely different reason than I ended up leaving with. I have a 2018 Jeep Cherokee. I have less than 62,500 miles on this vehicle. I do not tow anything. I do not go off road. I do not ride down trails or do anything out of the ordinary. I ... Read more

Incident date: Apr 6, 2024

Signs of frame flex/failure Lag boats through frame beam into exterior walls, are protruding and coming out. Countertop and cabinet, rubbing against the walls, lots of cracks in the Front Cap. The RV as less then 5000 miles on it and only used maybe once a month during summer months. Per my researc... Read more

Incident date: Jan 17, 2024

Antilock braking and traction control system failed. I was driving on a snow/ice covered road and hit the brakes with no anti lock control and truck slid in road side ditch. Truck has not been repaired. This is a known problem that Dodge is well aware of. This could have caused serious injury or dea... Read more

Incident date: Jan 17, 2024

Water leaking into interior of vehicle and to the trunk of the vehicle. Noticed significant water entered and entering into the trunk of the Audi after a recent rain. Also tested the drainage of water when the moonroof is opened and noticed water leaking into the interior. The audi e-tron is an e... Read more

NHTSA Safety Ratings, 2024 TOYOTA RAV4 PRIME

2024 Toyota RAV4 PRIME SUV AWD

Category	Rating
Overall Rating	5 / 5 ★★★★★
Frontal Crash	4 / 5 ★★★★☆
Frontal Crash, Driver	4 / 5 ★★★★☆
Frontal Crash, Passenger	4 / 5 ★★★★☆
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	4 / 5 ★★★★☆
Rollover Risk	13.3%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	Standard
Lane Departure Warning	Standard

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

Technical Service Bulletins, 2024 TOYOTA RAV4 PRIME

36 manufacturer communications from 23 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	8
116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER	8
980000 UNKNOWN OR OTHER	3
200000 WHEELS	2
110000 ELECTRICAL SYSTEM	2
061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)	1
138500 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REFRIGERANT HOSES AND FITTINGS	1
346000 COMMUNICATION:MANUFACTURER TELEMATICS	1

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

TI: TECHNICAL INSTRUCTIONS FOR 23TJ01 Second Key Delivery Program Multiple Models and Model Years

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

RL: The supply of Smart Keys available for Toyota vehicles has been temporarily limited to one (1) on select models since October 2022 due to global semiconductor shortages impacting certain microchips. Affected vehicles have been delivered

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

DP: The subject vehicles were delivered with only one (1) Smart Key on select models since October 2022 due to a global semiconductor shortage impacting certain microchips. The affected vehicles were delivered with one (1) Smart Key and a s

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

The table describes the phases currently planned for the Second Key Delivery Program and the estimated timing of announcement. This table will be updated during each phase launch and as more details become available.

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

060000 ENGINE AND ENGINE COOLING

This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the Toyota Complete Maintenance Care (TCMC) website.

061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION

110000 ELECTRICAL SYSTEM

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased and can never be reused. Another feature,

980000 UNKNOWN OR OTHER

190000 TIRES

TSB: During the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. If the wheels are replaced or refinished before vehicle delivery, it is important that the tires

350000 EQUIPMENT

TSB: Long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. The following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage cond

081100 FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY

TSB: Hybrid vehicles (HV) and battery electric vehicles (BEV) are equipped with two types of batteries: ?Hybrid vehicle (HV) battery. ?Auxiliary (12V) battery. If a hybrid or battery electric vehicle is put into storage, the State-O

110000 ELECTRICAL SYSTEM

TSB: Some 2018 ? 2024 model year Toyota vehicles equipped with an A25A-FKS, A25A-FXS, M20A-FKS, or M20A-FXS engine may exhibit one or more of the following conditions: ?Milky/discolored engine oil. ?An ?Oil Pressure Low? warning message

062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

030000 SERVICE BRAKES, HYDRAULIC

270000 LANE DEPARTURE

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TSB: A battery in a stored vehicle is subject to conditions that can reduce its performance and service life. These conditions include storage period, temperature, parasitic drain, and battery load. Because of these factors, battery inspect

350000 EQUIPMENT

355100 EQUIPMENT:OTHER:LABELS

350000 EQUIPMENT

TSB: 2024 model year Toyota vehicles are equipped with driver side floor mat retainers to secure the floor mat in the correct position. In addition, some models may also utilize retainers for passenger side and rear seat floor mats. During

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

350000 EQUIPMENT

200000 WHEELS

350000 EQUIPMENT

138500 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REFRIGERANT HOSES AND FITTINGS

TSB: The air conditioning dye injection tool kit has been developed to aid in identifying the location of air conditioning refrigerant leaks. Follow the procedures outlined in this service bulletin to aid in locating, inspecting, and repair

346000 COMMUNICATION:MANUFACTURER TELEMATICS

TT: A very small percentage of customers experience operational difficulties with some telematics features which they cannot resolve on their own. These resources, in conjunction with the Repair Manual, are for dealership personnel to assis

980000 UNKNOWN OR OTHER

061610 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE

TSB: Flash reprogramming allows the Electronic Control Unit (ECU) software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Serv

200000 WHEELS

TSB: Some 2023 ? 2024 model year Toyota vehicles use hub bolts in place of studs/nuts to fasten the wheels to the vehicle. If non-compatible wheels or hub bolts/nuts are installed, there is increased risk that the wheel(s) could come off re

350000 EQUIPMENT

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

TT: After jump-starting, the vehicle may experience a no-start condition and multiple DTCs including U010087. Upon investigation, it is found that the engine ECU has been damaged and needs to be replaced. In several cases, it was found that

TOYOTA RAV4 PRIME - All Years Overview

Complete safety history for the TOYOTA RAV4 PRIME across all model years (2021, 2024).

11 Total Recalls

298 Total Complaints

0 Investigations

18 Reported Crashes

6 Reported Fires

0 Reported Deaths

TOYOTA RAV4 PRIME - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2024 (current)	2	38
2023	2	94	View
2022	3	28	View
2021	4	138	View

Other TOYOTA Models

Model	Recalls	Complaints
TUNDRA	787	9,074	View
HIGHLANDER	677	6,756	View
RAV4	669	11,842	View
CROWN	548	141	View
TACOMA	406	10,562	View
VENZA	404	969	View
GRAND HIGHLANDER	388	332	View
PRIUS	365	15,456	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2024 TOYOTA RAV4 PRIME

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2024 TOYOTA RAV4 PRIME

Safety Technology

Technical Service Bulletins, 2024 TOYOTA RAV4 PRIME

Most Affected Components

TOYOTA RAV4 PRIME - All Years Overview

TOYOTA RAV4 PRIME - Year by Year

Other TOYOTA Models