2013 PETERBILT 320
5 recalls, 0 complaints - 35 TSBs
19V452000 Jun 14, 2019
EXTERIOR LIGHTING:TAIL LIGHTS
Defect Description
PACCAR Incorporated (PACCAR) is recalling certain 1990-2020 Peterbilt 320 and 520 vehicles built with specific amber rear turn signals. The turn signals may also light up with the stop/tail lights when the brakes are applied. As such, these vehicles fail to comply with the requirements of Federal ... Read more
Consequence
Rear Turn signals that illuminate at the same time as the brake lights may create confusion and impair the effectiveness of the brake lights, increasing the risk of a crash.
Remedy
PACCAR will notify owners, and for trucks with rear amber lights, dealers will add a jumper harness between the chassis electrical harness and amber tail lights, free of charge. The recall began August 1, 2019. Owners may contact PACCAR customer service at 1-940-591-4220. PACCAR's number for this... Read more
15V309000 May 26, 2015
ENGINE AND ENGINE COOLING:ENGINE
Defect Description
PACCAR Incorporated (PACCAR) is recalling certain model year 2010-2016 Kenworth T440, T800, and W900 trucks manufactured August 31, 2009, to April 20, 2015, and 2008-2015 Peterbilt 320, 337, 348, 365, 382, and 384 trucks manufactured July 27, 2007, to April 28, 2015, and equipped with certain Cummin... Read more
Consequence
If engine oil comes into contact with a hot surface, there is an increased risk of a fire.
Remedy
Cummins will notify owners on behalf of PACCAR, and Cummins service centers will administer the repairs which include securing the ends of the 90-degree elbow and reprogramming the electronic control module (ECM) with software that can adjust the engine output under misfire conditions to limit crank... Read more
15V108000 Feb 24, 2015
STEERING:LINKAGES:TIE ROD ASSEMBLY
Defect Description
PACCAR Incorporated (PACCAR) is recalling certain model year 2009-2015 Peterbilt 320, 365, 367, 388, and 389 trucks manufactured July 21, 2008, to February 28, 2014. The front axle tie rod end clamp bolts may be improperly torqued.
Consequence
Undertorqued tie rod end clamp bolts are susceptible to corrosion, which may cause loose bolts to separate resulting in a loss of vehicle control and an increased risk of a crash.
Remedy
PACCAR will notify owners, and dealers will replace the front axle tie rod assembly on any vehicle where the factory installed assembly has not been previously replaced, free of charge. Owners were mailed interim notices on May 11, 2015. The recall began on April 4, 2016. Owners may contact Peterb... Read more
14V439000 Jul 21, 2014
ELECTRICAL SYSTEM
Defect Description
PACCAR Inc. (PACCAR) is recalling certain model year 2013-2015 Kenworth K300 and Peterbilt 210, 220, and 320 chassis manufactured March 14, 2012 to July 14, 2014. The affected vehicles may have loose fitting electrical connectors on the power distribution module which may cause the engine to shut o... Read more
Consequence
An unexpected engine shut down increases the risk of a crash.
Remedy
PACCAR will notify owners, and dealers will install nylon tie straps to hold the connectors in place until the permanent remedy, a connection position device, becomes available. Both remedies will be provided free of charge. The recall began January 29, 2015. For more information, Peterbilt owner... Read more
12V026000 Jan 30, 2012
SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE
Defect Description
PACCAR IS RECALLING CERTAIN MODEL YEAR 2012-2013 KENWORTH T170, T270, T370, T440, T470, T660, T700, T800, W900, AND PETERBILT 320, 330, 337, 348, 365, 367, 382, 384, 386, 388, 389, AND 587 VEHICLES, MANUFACTURED FROM JANUARY 31, 2011, THROUGH JANUARY 19, 2012, AND EQUIPPED WITH BENDIX ATR-6 ANTILOCK... Read more
Consequence
UNEXPECTED CONTINUOUS BRAKE APPLICATION CAN CAUSE THE BRAKES TO OVERHEAT AND LEAD TO A FIRE. UNEXPECTED CONTINUOUS BRAKE APPLICATION CAN CAUSE THE DRIVER TO LOSE CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH. ALSO, THE BRAKES MAY BE APPLIED WITHOUT ILLUMINATING THE BRAKE LIGHTS, FAILING ... Read more
Remedy
PACCAR WILL NOTIFY OWNERS, AND PROVIDE A TEMPORARY REPAIR UNTIL BENDIX DEVELOPS A PERMANENT REMEDY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 10, 2012. OWNER MAY CONTACT KENWORTH AT 1-425-828-5440 AND PETERBILT AT 1-940-591-4196.
No complaints found for this vehicle.
Technical Service Bulletins, 2013 PETERBILT 320
35 manufacturer communications from 23 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 110000 ELECTRICAL SYSTEM | 6 |
| 118000 ELECTRICAL SYSTEM:SOFTWARE | 3 |
| 350000 EQUIPMENT | 3 |
| 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM | 3 |
| 061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL | 2 |
| 160000 STRUCTURE | 2 |
| 130000 VISIBILITY | 2 |
| 060000 ENGINE AND ENGINE COOLING | 2 |
02-160
Feb 10, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
Information Only a?? Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
02-160
Feb 10, 2021
350000 EQUIPMENT
Information Only a?? Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
02-160
Feb 10, 2021
136000 VISIBILITY:WINDSHIELD WIPER/WASHER
Information Only a?? Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
02-160
Feb 10, 2021
130000 VISIBILITY
Information Only a?? Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
43-067
Jun 10, 2020
160000 STRUCTURE
Fix as Fail: For all conventional models, except 387/587, equipped with Side-of-Cab (a??SOCa??) exhaust and built from 03/6/2006 to 1/20/2020, the clamps that secure the SOC exhaust stacks may not be tightened properly. This may allow the
43-067
Jun 10, 2020
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Fix as Fail: For all conventional models, except 387/587, equipped with Side-of-Cab (a??SOCa??) exhaust and built from 03/6/2006 to 1/20/2020, the clamps that secure the SOC exhaust stacks may not be tightened properly. This may allow the
32-015
Jun 8, 2020
110000 ELECTRICAL SYSTEM
Information Only: This bulletin provides dealers with a battery warranty quick reference guide to ensure the appropriate tests for battery warranty are performed in order to prevent battery warranty claims filed with incorrect or incomplet
11-001
May 29, 2020
100000 POWER TRAIN
Information only: Hendrickson Softek front axle maintenance intervals and requirements.
32-016
Mar 17, 2020
350000 EQUIPMENT
Information Only: Proper jump-starting voltage will eliminate high voltage related issues and equipment damage.
34-085
Mar 3, 2020
180000 VEHICLE SPEED CONTROL
Information Only a?? Vehicles may have the connector seals on the wheel speed sensor incorrectly installed, which may lead to water intrusion and corrosion in some vehicles.
34-085
Mar 3, 2020
110000 ELECTRICAL SYSTEM
Information Only a?? Vehicles may have the connector seals on the wheel speed sensor incorrectly installed, which may lead to water intrusion and corrosion in some vehicles.
34-085
Feb 28, 2020
180000 VEHICLE SPEED CONTROL
Information Only: Vehicles may have the connector seal on the wheel speed sensor incorrectly installed, which may lead to sensor corrosion.
34-085
Feb 28, 2020
110000 ELECTRICAL SYSTEM
Information Only: Vehicles may have the connector seal on the wheel speed sensor incorrectly installed, which may lead to sensor corrosion.
03-071
Dec 18, 2019
118000 ELECTRICAL SYSTEM:SOFTWARE
Information Only - Vehicles built with NAMUX software from 2013 to present may experience accuracy issues with the tachometer. The issue can be temporarily resolved using any one of the included procedures.
02-151
Dec 11, 2019
130000 VISIBILITY
Fix as Fail: Peterbilt has initiated an improvement to the Model 320/520 power window module. A vapor barrier will be installed over the module to prevent moisture.
02-153
Nov 22, 2019
160000 STRUCTURE
Information only: Some model 320 and 520 vehicles built before 3/11/2019 may experience loss or loosening of doghouse insulation. Reference the procedure in the attachment section to properly remove and replace the insulation.
01-075
Nov 6, 2019
060000 ENGINE AND ENGINE COOLING
Information Only: This bulletin provides guidance for repairing an air-conditioning system after internal failure of the A/C compressor.
TIB43-062
Sep 27, 2019
350000 EQUIPMENT
Information Only ??A?A? This bulletin provides information about the California Air Resources Board (CARB) Periodic Smoke Inspection Program (PSIP) and Heavy Duty Vehicle Inspection Program (HDVIP).
TIB43-062
Sep 27, 2019
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Information Only ??A?A? This bulletin provides information about the California Air Resources Board (CARB) Periodic Smoke Inspection Program (PSIP) and Heavy Duty Vehicle Inspection Program (HDVIP).
42-058
Aug 23, 2019
060000 ENGINE AND ENGINE COOLING
Fix-As-Fail: Two separate causes have been identified as root cause of intermittent low coolant indicator illumination.
19PBC
Jul 19, 2019
120000 EXTERIOR LIGHTING
Safety Recall: Vehicles fail to confirm with FMVSS/CMVSS No 108 Table 1-a requirements which requires 2 red stop lamps. Vehicles were equipped with additional amber stop lamps which may illuminate when the brake is applied, and may confus
19PBC
Jul 19, 2019
110000 ELECTRICAL SYSTEM
Safety Recall: Vehicles fail to confirm with FMVSS/CMVSS No 108 Table 1-a requirements which requires 2 red stop lamps. Vehicles were equipped with additional amber stop lamps which may illuminate when the brake is applied, and may confus
34-066
Jun 10, 2019
110000 ELECTRICAL SYSTEM
Information Only - Quick Reference Guide for Electric harness damage repairs.
34-077
Apr 8, 2019
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Information Only: Proper instructions for closure of power distribution box cover to prevent corrosion.
34-077
Apr 8, 2019
353000 EQUIPMENT:ELECTRICAL
Information Only: Proper instructions for closure of power distribution box cover to prevent corrosion.
13-049
Jan 4, 2019
118000 ELECTRICAL SYSTEM:SOFTWARE
Information: Bendix ACOM Software version 6.16.5.0 for diagnostics may introduce an unrecoverable error. Notice to dealers to replace this version with older software version until Bendix introduces new version.
03-064
Jul 23, 2018
110000 ELECTRICAL SYSTEM
Information - Recommended Practices for Updating ESA Software
15-16
Sep 27, 2017
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Fix-As-Fail: Repair for horizontal exhaust diffuser configurations with broken brackets or cracked diffuser.
SB-E-097
Jun 27, 2014
060000 ENGINE (PWS)
PETERBILT: THE MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATES DUE TO AN ENGINE CONTROL UNIT (ECU) SOFTWARE ISSUE, REAR NOX SENSOR, OPERATING CORRECTLY. *PE
SB-E-097
Jun 27, 2014
118000 ELECTRICAL SYSTEM:SOFTWARE
PETERBILT: THE MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATES DUE TO AN ENGINE CONTROL UNIT (ECU) SOFTWARE ISSUE, REAR NOX SENSOR, OPERATING CORRECTLY. *PE
SB-11-13
Jan 31, 2014
061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL
PETERBILT: AN ACTIVE FAULT CODE 3911, AMMONIA SENSOR COMMUNICATION, MAY BE DISPLAYED AND A REPAIR STRATEGY IS BEING PROVIDED. MODEL 320. *PE
TSB-130155
Oct 22, 2013
114000 ELECTRICAL SYSTEM:WIRING
CUMMINS: THE RELAYS AND FUSES OF AFTERTREATMENT SYSTEMS, IN WIRING HARNESS, IS POTENTIALLY NOT ADEQUATELY SECURED VIA ORIGINAL EQUIPMENT MANUFACTURE (OEM) AND HAVE WIRE RUBBING POINTS, RELAY DAMAGE OR RUB POINTS. *PE
TSB-130155
Oct 22, 2013
113200 ELECTRICAL SYSTEM:STARTER ASSEMBLY:RELAY
CUMMINS: THE RELAYS AND FUSES OF AFTERTREATMENT SYSTEMS, IN WIRING HARNESS, IS POTENTIALLY NOT ADEQUATELY SECURED VIA ORIGINAL EQUIPMENT MANUFACTURE (OEM) AND HAVE WIRE RUBBING POINTS, RELAY DAMAGE OR RUB POINTS. *PE
TSB-130140
Oct 2, 2013
061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL
CUMMINS: THE FAULT CODE 3911 AND CHECK ENGINE LAMPS ILLUMINATES DUE TO VOLTAGE TO AMMONIUM HYDROXIDE NH3 SENSOR AND IS DIPPING BELOW 9 VOLT SPECIFICATION FOR SENSOR. *PE
RN-413-1
Jun 4, 2013
114400 ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
PETERBILT: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CERTAIN TRUCKS, WITH CUMMINS ENGINE, HAVE EXPERIENCE LOSS OF POWER TO AFTER TREATMENT COMPONENTS AND NEED TO SWITCH THE FUSES FROM 5 AMP TO 10 AMP. MODELS 320, 587, CONVENTIONAL.
NHTSA Safety Investigations, PETERBILT 320
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE88099
Opened: Sep 1, 1988 , Closed: Dec 29, 1988
BRAKE CHAMBER MOUNTING
There is no summary currently available
PETERBILT 320 - All Years Overview
Complete safety history for the PETERBILT 320 across all model years (1987, 2023).
111
Total Recalls
7
Total Complaints
1
Investigations
2
Reported Crashes
2
Reported Fires
2
Reported Deaths
PETERBILT 320 - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2023 | 1 | 0 | View |
| 2022 | 1 | 0 | View |
| 2021 | 2 | 0 | View |
| 2020 | 4 | 0 | View |
| 2019 | 4 | 0 | View |
| 2018 | 4 | 0 | View |
| 2017 | 6 | 0 | View |
| 2016 | 5 | 0 | View |
| 2015 | 9 | 0 | View |
| 2014 | 6 | 2 | View |
| 2013 (current) | 5 | 0 | |
| 2012 | 5 | 1 | View |
| 2011 | 3 | 0 | View |
| 2010 | 4 | 1 | View |
| 2009 | 4 | 0 | View |
| 2008 | 8 | 0 | View |
| 2007 | 3 | 0 | View |
| 2006 | 1 | 0 | View |
| 2005 | 2 | 0 | View |
| 2004 | 1 | 0 | View |
| 2003 | 2 | 0 | View |
| 2002 | 2 | 0 | View |
| 2001 | 2 | 0 | View |
| 2000 | 6 | 0 | View |
| 1999 | 6 | 0 | View |
| 1998 | 1 | 0 | View |
| 1997 | 1 | 0 | View |
| 1996 | 1 | 0 | View |
| 1995 | 1 | 0 | View |
| 1994 | 1 | 0 | View |
| 1993 | 1 | 0 | View |
| 1992 | 1 | 0 | View |
| 1991 | 1 | 0 | View |
| 1990 | 1 | 0 | View |
| 1989 | 3 | 1 | View |
| 1988 | 2 | 0 | View |
| 1987 | 1 | 0 | View |