2007 PETERBILT 320
3 recalls, 0 complaints - 28 TSBs
19V452000 Jun 14, 2019
EXTERIOR LIGHTING:TAIL LIGHTS
Defect Description
PACCAR Incorporated (PACCAR) is recalling certain 1990-2020 Peterbilt 320 and 520 vehicles built with specific amber rear turn signals. The turn signals may also light up with the stop/tail lights when the brakes are applied. As such, these vehicles fail to comply with the requirements of Federal ... Read more
Consequence
Rear Turn signals that illuminate at the same time as the brake lights may create confusion and impair the effectiveness of the brake lights, increasing the risk of a crash.
Remedy
PACCAR will notify owners, and for trucks with rear amber lights, dealers will add a jumper harness between the chassis electrical harness and amber tail lights, free of charge. The recall began August 1, 2019. Owners may contact PACCAR customer service at 1-940-591-4220. PACCAR's number for this... Read more
07V276000 Jun 27, 2007
PARKING BRAKE
Defect Description
CERTAIN TRUCKS EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES. THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.
Consequence
THIS COULD DELAY OR FAILURE IN APPLYING THE PARKING BRAKES POTENTIALLY RESULTING IN A VEHICLE ROLL AWAY.
Remedy
DEALERS WILL INSTALL A CHECK VALVE REPAIR KIT FOR THE AFFECTED SR-7 SPRING BRAKE MODULATING VALVE FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 22, 2007. OWNERS MAY CONTACT PETERBILT AT 940-591-4201.
07V132000 Mar 22, 2007
POWER TRAIN:AXLE ASSEMBLY
Defect Description
ON CERTAIN TRUCKS, THE AXLE HOUSINGS MAY HAVE BEEN MANUFACTURED WITH STEEL THAT WAS OUT OF SPECIFICATION WHICH COULD RESULT IN A FATIGUE FAILURE OVER TIME.
Consequence
IF A FATIGUE FAILURE OCCURS AND IS LEFT UNATTENDED, THE AXLE MAY LOCK UP OR THE END OF THE AXLE COULD COME OFF, WHICH MAY RESULT IN A VEHICLE CRASH.
Remedy
DEALERS WILL INSPECT AND REPLACE THE AXLES FREE OF CHARGE. THE RECALL BEGAN ON MAY 9, 2007. OWNERS MAY CONTACT KENWORTH AT 425-828-5440 AND PETERBILT AT 1-940-591-4196.
No complaints found for this vehicle.
Technical Service Bulletins, 2007 PETERBILT 320
28 manufacturer communications from 17 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 110000 ELECTRICAL SYSTEM | 7 |
| 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM | 2 |
| 350000 EQUIPMENT | 2 |
| 180000 VEHICLE SPEED CONTROL | 2 |
| 160000 STRUCTURE | 2 |
| 062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM | 1 |
| 112000 ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR | 1 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 1 |
02-160
Feb 10, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
Information Only a?? Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
02-160
Feb 10, 2021
350000 EQUIPMENT
Information Only a?? Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
02-160
Feb 10, 2021
136000 VISIBILITY:WINDSHIELD WIPER/WASHER
Information Only a?? Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
02-160
Feb 10, 2021
130000 VISIBILITY
Information Only a?? Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
43-067
Jun 10, 2020
160000 STRUCTURE
Fix as Fail: For all conventional models, except 387/587, equipped with Side-of-Cab (a??SOCa??) exhaust and built from 03/6/2006 to 1/20/2020, the clamps that secure the SOC exhaust stacks may not be tightened properly. This may allow the
43-067
Jun 10, 2020
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Fix as Fail: For all conventional models, except 387/587, equipped with Side-of-Cab (a??SOCa??) exhaust and built from 03/6/2006 to 1/20/2020, the clamps that secure the SOC exhaust stacks may not be tightened properly. This may allow the
32-015
Jun 8, 2020
110000 ELECTRICAL SYSTEM
Information Only: This bulletin provides dealers with a battery warranty quick reference guide to ensure the appropriate tests for battery warranty are performed in order to prevent battery warranty claims filed with incorrect or incomplet
11-001
May 29, 2020
100000 POWER TRAIN
Information only: Hendrickson Softek front axle maintenance intervals and requirements.
32-016
Mar 17, 2020
350000 EQUIPMENT
Information Only: Proper jump-starting voltage will eliminate high voltage related issues and equipment damage.
34-085
Mar 3, 2020
180000 VEHICLE SPEED CONTROL
Information Only a?? Vehicles may have the connector seals on the wheel speed sensor incorrectly installed, which may lead to water intrusion and corrosion in some vehicles.
34-085
Mar 3, 2020
110000 ELECTRICAL SYSTEM
Information Only a?? Vehicles may have the connector seals on the wheel speed sensor incorrectly installed, which may lead to water intrusion and corrosion in some vehicles.
34-085
Feb 28, 2020
180000 VEHICLE SPEED CONTROL
Information Only: Vehicles may have the connector seal on the wheel speed sensor incorrectly installed, which may lead to sensor corrosion.
34-085
Feb 28, 2020
110000 ELECTRICAL SYSTEM
Information Only: Vehicles may have the connector seal on the wheel speed sensor incorrectly installed, which may lead to sensor corrosion.
02-153
Nov 22, 2019
160000 STRUCTURE
Information only: Some model 320 and 520 vehicles built before 3/11/2019 may experience loss or loosening of doghouse insulation. Reference the procedure in the attachment section to properly remove and replace the insulation.
01-075
Nov 6, 2019
060000 ENGINE AND ENGINE COOLING
Information Only: This bulletin provides guidance for repairing an air-conditioning system after internal failure of the A/C compressor.
19PBC
Jul 19, 2019
120000 EXTERIOR LIGHTING
Safety Recall: Vehicles fail to confirm with FMVSS/CMVSS No 108 Table 1-a requirements which requires 2 red stop lamps. Vehicles were equipped with additional amber stop lamps which may illuminate when the brake is applied, and may confus
19PBC
Jul 19, 2019
110000 ELECTRICAL SYSTEM
Safety Recall: Vehicles fail to confirm with FMVSS/CMVSS No 108 Table 1-a requirements which requires 2 red stop lamps. Vehicles were equipped with additional amber stop lamps which may illuminate when the brake is applied, and may confus
34-066
Jun 10, 2019
110000 ELECTRICAL SYSTEM
Information Only - Quick Reference Guide for Electric harness damage repairs.
34-077
Apr 8, 2019
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Information Only: Proper instructions for closure of power distribution box cover to prevent corrosion.
34-077
Apr 8, 2019
353000 EQUIPMENT:ELECTRICAL
Information Only: Proper instructions for closure of power distribution box cover to prevent corrosion.
13-049
Jan 4, 2019
118000 ELECTRICAL SYSTEM:SOFTWARE
Information: Bendix ACOM Software version 6.16.5.0 for diagnostics may introduce an unrecoverable error. Notice to dealers to replace this version with older software version until Bendix introduces new version.
03-064
Jul 23, 2018
110000 ELECTRICAL SYSTEM
Information - Recommended Practices for Updating ESA Software
15-16
Sep 27, 2017
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Fix-As-Fail: Repair for horizontal exhaust diffuser configurations with broken brackets or cracked diffuser.
8110
Aug 1, 2010
061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL
CUMMINS ISX, OR CUMMINS ISM ENGINES EXPERIENCING A PREMATURE FAILURE OF THE FAN HUB BEARINGS. *KB
8110
Aug 1, 2010
061000 ENGINE AND ENGINE COOLING:ENGINE
CUMMINS ISX, OR CUMMINS ISM ENGINES EXPERIENCING A PREMATURE FAILURE OF THE FAN HUB BEARINGS. *KB
FRN-808-1
Oct 17, 2008
112000 ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
PETERBILT TRUCKS: THE ELECTRICAL SYSTEM MAY SHUT DOWN DUE TO A POWER SURGE. WHEN THIS OCCURS, THE GREEN LIGHT ON THE COMFORTCLASS CONTROL PANEL TURNS TO RED. *PE
FRN-808-1
Oct 17, 2008
110000 ELECTRICAL SYSTEM
PETERBILT TRUCKS: THE ELECTRICAL SYSTEM MAY SHUT DOWN DUE TO A POWER SURGE. WHEN THIS OCCURS, THE GREEN LIGHT ON THE COMFORTCLASS CONTROL PANEL TURNS TO RED. *PE
408-2
May 14, 2008
062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM
PETERBILT SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. MODEL 320 LOW COOLANT SENSOR. THIS FIELD REPAIR NOTICE IS APPLICABLE TO CERTAIN PETERBILT MODEL 320 VEHICLES BUILT BETWEEN OCTOBER 4, 2007 AND JANUARY 24, 2008 WITH C
NHTSA Safety Investigations, PETERBILT 320
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE88099
Opened: Sep 1, 1988 , Closed: Dec 29, 1988
BRAKE CHAMBER MOUNTING
There is no summary currently available
PETERBILT 320 - All Years Overview
Complete safety history for the PETERBILT 320 across all model years (1987, 2023).
111
Total Recalls
7
Total Complaints
1
Investigations
2
Reported Crashes
2
Reported Fires
2
Reported Deaths
PETERBILT 320 - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2023 | 1 | 0 | View |
| 2022 | 1 | 0 | View |
| 2021 | 2 | 0 | View |
| 2020 | 4 | 0 | View |
| 2019 | 4 | 0 | View |
| 2018 | 4 | 0 | View |
| 2017 | 6 | 0 | View |
| 2016 | 5 | 0 | View |
| 2015 | 9 | 0 | View |
| 2014 | 6 | 2 | View |
| 2013 | 5 | 0 | View |
| 2012 | 5 | 1 | View |
| 2011 | 3 | 0 | View |
| 2010 | 4 | 1 | View |
| 2009 | 4 | 0 | View |
| 2008 | 8 | 0 | View |
| 2007 (current) | 3 | 0 | |
| 2006 | 1 | 0 | View |
| 2005 | 2 | 0 | View |
| 2004 | 1 | 0 | View |
| 2003 | 2 | 0 | View |
| 2002 | 2 | 0 | View |
| 2001 | 2 | 0 | View |
| 2000 | 6 | 0 | View |
| 1999 | 6 | 0 | View |
| 1998 | 1 | 0 | View |
| 1997 | 1 | 0 | View |
| 1996 | 1 | 0 | View |
| 1995 | 1 | 0 | View |
| 1994 | 1 | 0 | View |
| 1993 | 1 | 0 | View |
| 1992 | 1 | 0 | View |
| 1991 | 1 | 0 | View |
| 1990 | 1 | 0 | View |
| 1989 | 3 | 1 | View |
| 1988 | 2 | 0 | View |
| 1987 | 1 | 0 | View |