2021 NOVA BUS LFS
22 recalls — 0 complaints — 139 TSBs
26V300000 May 12, 2026
STRUCTURE:INTERIOR PANELS:DOOR
Defect Description
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2020 LFS Artic and 2019-2023 LFS transit buses. The driver's speaker hole door may have been built with the prime glazing manufacturer DOT code mark missing. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVS... Read more
Consequence
A missing DOT code mark may result in the door being replaced with the incorrect type of plastic, reducing visibility and increasing the risk of a crash.
Remedy
Nova Bus will replace the plastic panel door, free of charge. Owner notification letters are expected to be mailed July 11, 2026. Owners may contact Nova Bus customer service at 1-450-472-6410. Nova Bus' number for this recall is CR5884. Vehicle Identification Numbers (VINs) involved in this recall ... Read more
25V822000 Nov 28, 2025
ENGINE AND ENGINE COOLING:COOLING SYSTEM:PUMP
Defect Description
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2021 and 2024-2025 LFS transit buses. The impeller shaft may be loose, causing the cooling pump to fail.
Consequence
A cooling pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy
Nova Bus will inspect and replace the pump as necessary, free of charge. Owner notification letters were mailed February 3, 2026.Owners may contact Nova Bus customer service at 1-450-472-6410. Nova Bus' number for this recall is CR5803. Vehicle Identification Numbers (VINs) involved in this recall w... Read more
25V476000 Jul 22, 2025
STEERING:ELECTRIC POWER ASSIST SYSTEM
Defect Description
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2020-2023 LFS transit buses. The electric power steering system may be missing a check valve, allowing hydraulic pressure to turn the steering wheel without the driver's input.
Consequence
A steering wheel that turns unintentionally increases the risk of a crash or injury.
Remedy
Nova Bus will install a check valve, free of charge. Owner notification letters were mailed September 11, 2025. Owners may contact Nova Bus customer service at 1-450-472-6410. Nova Bus' number for this recall is CR5746.
24V647000 Nov 5, 2024
SEAT BELTS:FRONT
Defect Description
Nova Bus (US) Inc. (Nova) is recalling certain 2010-2020 LFS Artic and 2012-2024 LFS vehicles. The driver's seat belt may not retract properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 209, "Seat Belt Assemblies."
Consequence
A seat belt that does not retract properly may result in a loose seat belt, which can increase the risk of injury in a crash.
Remedy
Nova Bus will install additional seat stoppers to the driver's rear partition, free of charge. Owner notification letters are expected to be mailed July 4, 2025. Nova's number for this recall is CR5635. This recall expands and replaces previous recall number 23V-350. Vehicles that were previously... Read more
24V657000 Sep 9, 2024
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT
Defect Description
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2024 LFS and 2019-2023 LFS Artic buses. The auxiliary heater module may allow contaminants to enter the electronic controller, which can cause an electrical short. Additionally, the auxiliary heater may fail, causing the defrosting system to ... Read more
Consequence
An electrical short circuit can increase the risk of a fire. Additionally, a windshield defrosting system that does not function properly can decrease the driver's visibility, increasing the risk of a crash.
Remedy
Nova Bus will the auxiliary heater air intake, free of charge. Owner notification letters were mailed January 28, 2025. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5637.
24V564000 Jul 26, 2024
VISIBILITY:GLASS, SIDE/REAR
Defect Description
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2023 LFS and 2019-2020 LFS Arctic buses. The glazing used on the glass windows may reduce the driver's visibility. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 205, "Glazing Mate... Read more
Consequence
Reduced visibility while driving can increase the risk of a crash.
Remedy
Nova Bus will inspect the vehicles and replace the driver shield glazing as necessary, free of charge. Owner notification letters were mailed October 10, 2024. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5626.
24V559000 Jul 25, 2024
SERVICE BRAKES, AIR:DISC:CHAMBER
Defect Description
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2021 LFS and 2019 LFS Artic buses. The brake chamber on the rear axle may have been improperly manufactured, which can result in an air leak.
Consequence
A brake chamber air leak may cause the brakes to engage unexpectedly, which can overheat the brakes and increase the risk of a fire. Additionally, unexpected braking can increase the risk of a crash.
Remedy
Nova Bus will inspect and replace the brake chamber as necessary, free of charge. Owner notification letters were mailed November 02, 2024. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5620.
24V518000 Jul 8, 2024
PARKING BRAKE:CONVENTIONAL:AIR
Defect Description
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2021-2024 LFS and 2021-2023 LFS Artic buses. An air leak may occur in the parking brake valve and unintentionally engage the parking brake without activating the brake lights.
Consequence
A bus that stops suddenly without activating brake lights increases the risk of a crash.
Remedy
Nova Bus will inspect and tighten the parking brake air line connections, free of charge. Owner notification letters were mailed July 24, 2024. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5615.
24V449000 Jun 17, 2024
LATCHES/LOCKS/LINKAGES:DOORS:LATCH PLATE
Defect Description
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2021 LFS buses. The welds may fail, allowing the rotary plate to separate from the door operator.
Consequence
The separation can allow the passenger door to open while the bus is in motion, increasing the risk of injury.
Remedy
Nova Bus will replace the door operator assembly, free of charge. Owner notification letters were mailed August 12, 2024. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5612.
24V231000 Mar 27, 2024
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
Defect Description
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2020-2024 LFS vehicles. The engine coolant return hose may fail, leaking coolant and causing an engine shutdown.
Consequence
An unexpected engine shutdown can increase the risk of a crash. Additionally, transferring passengers from the disabled bus can increase the risk of injury.
Remedy
Nova Bus will replace the engine coolant return hose, free of charge. Owner notification letters were mailed July 03, 2024. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus number for this recall is CR5577.
24V203000 Mar 17, 2024
ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
Defect Description
Nova Bus (US) Inc. (Nova) is recalling certain 2021-2022 LFS Artic and 2021-2023 LFS buses. The alternator power cable nut may not have been tightened properly.
Consequence
A loose nut can cause electrical arcing, increasing the risk of a fire.
Remedy
Nova will inspect and tighten the power cable nut as necessary, free of charge. Owner notification letters were mailed April 10, 2024. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR5570.
23V762000 Nov 11, 2023
EXTERIOR LIGHTING:TURN SIGNAL
Defect Description
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2021-2023 LFS transit buses equipped with a directional foot switch. The turn signals may intermittently become inoperative.
Consequence
Inoperative turn signals may not notify other drivers of a turning vehicle, increasing the risk of a crash.
Remedy
Nova Bus will inspect and repair the directional foot switch wiring, as necessary, free of charge. Owner notification letters were mailed December 4, 2023. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5507.
23V763000 Nov 11, 2023
EQUIPMENT:APPLIANCE:AIR CONDITIONER
Defect Description
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2020-2023 LFS and LFS Artic transit buses. The brackets retaining the Mobile Climate Control HVAC Unit could fail and allow the unit to detach from the bus.
Consequence
An HVAC unit that detaches from a bus can create a road hazard, increasing the risk of a crash.
Remedy
Nova Bus will inspect the existing brackets and install additional brackets, as necessary, free of charge. Owner notification letters were mailed December 20, 2023. Owners may contact Nova Bus customer service at 1-800-350-6882. Nova Bus's number for this recall is CR5508.
23V607000 Aug 31, 2023
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
Defect Description
Nova Bus (US) Inc. (Nova) is recalling certain 2017-2023 LFS and 2017-2022 LFS Artic transit buses. The 24-volt power cable and grounded mounting fastener that secures the fuse holder may short circuit.
Consequence
An electrical short circuit can overheat the fuse holder and increase the risk of a fire while driving or parked.
Remedy
Nova will insect, remove, and clean the fuse holder and cable lugs as necessary, free of charge. Owner letters were mailed November 7, 2023. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR5445. This recall replaces and expands recall number 22V-416... Read more
23V482000 Jul 12, 2023
POWER TRAIN:DRIVELINE:DRIVESHAFT
Defect Description
Nova Bus (US) Inc. (Nova) is recalling certain 2019-2023 LFS and LFS Artic transit buses. The transmission yoke may separate, resulting in driveshaft separation and a sudden loss of drive power.
Consequence
A sudden loss of drive power can increase the risk of a crash. Additionally, a disabled bus may require an evacuation procedure in an uncontrolled traffic situation, increasing the risk of injury to passengers.
Remedy
Dealers will inspect the output yoke bolts, and if necessary, tighten loose output yoke bolts, free of charge. Phase 1 will include 2019-2023 LFS vehicles. Nova notified dealers on 10/03/2024 and notified Phase 1 owners on 10/27/2024. Phase 2 will include 2019-2020 LFS Artic vehicles. Interim le... Read more
23V350000 May 17, 2023
SEAT BELTS:FRONT
Defect Description
Nova Bus (US) Inc. (Nova) is recalling certain 2012-2022 LFS vehicles. The driver's seat belt may not retract properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 209, "Seat Belt Assemblies."
Consequence
A seat belt that does not retract properly may result in a loose seat belt, which can increase the risk of injury in a crash.
Remedy
Dealers will adjust the recline angle of the seat-back rest, or add a spacer on the driver's seat, as necessary, free of charge. Owner notification letters were mailed July 14, 2023. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR5419.
22V902000 Dec 7, 2022
EXTERIOR LIGHTING
Defect Description
Nova Bus (US) Inc. (Nova) is recalling certain 2010-2021 LFS and 2009-2012 LFS Artic transit buses. These vehicles are equipped with non-standard color auxiliary lights which may impair the effectiveness of the standard lighting equipment. As such, these vehicles fail to comply with the requiremen... Read more
Consequence
The colorful lighting may cause confusion by distracting other drivers, increasing the risk of a crash.
Remedy
Dealers will remove the non-standard color lights, or replace them with white lights, free of charge. Owner notification letters were mailed January 31, 2023. Owners may contact Nova's customer service at 1-800-350-6682. Nova's number for this recall is CR5350/5351.
22V845000 Nov 15, 2022
STEERING:CRITICAL FASTENERS
Defect Description
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2018-2022 LFS and 2018-2021 LFS Artic buses equipped with a Bosch steering gear box. The steering gear box may have an insufficient clamp load, which may allow the mounting plate sub-assembly fasteners to loosen and possibly fall out.
Consequence
Missing fasteners may cause a of a loss of steering, increasing the risk of a crash.
Remedy
Owners are advised not to drive their vehicles until the remedy has been completed. Nova Bus will inspect and tighten the fasteners as an interim remedy. The permanent remedy, consisting of replacing and tightening new fasteners to increase the clamp load, is expected to be available November 30, ... Read more
22V416000 Jun 13, 2022
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
Defect Description
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2021 LFS and 2019-2022 LFS Artic buses. The radiator fan's electrical fuse holder may experience excessive corrosion which can result in an electrical short.
Consequence
An electrical short increases the risk of a fire.
Remedy
Nova Bus will provide the remedy parts and service document instructions, free of charge. Owner notification letters were mailed on June 29, 2022. Owners may contact Nova Bus' customer service at 1-800-350-6682. Nova Bus' number for this recall is CR5259.
21V929000 Nov 26, 2021
STRUCTURE:BODY:DOOR
Defect Description
Nova Bus (US) Inc. (Nova) is recalling certain 2021 LFS buses. The vehicle multiplex software may unexpectedly cause the door system electronic control module (ECM) to open and close the rear passenger door when the bus stops.
Consequence
A passenger may exit the bus in an unsafe location if the rear passenger door opens unexpectedly, increasing the risk of injury. Additionally, the doors may unexpectedly close on an exiting passenger, increasing the risk of injury.
Remedy
Nova Bus will provide instructions for how to update the vehicle multiplex and door system ECM software, and install a hardware dedicated wire kit, free of charge. Owner notification letters were mailed December 15, 2021. Owners may contact Nova customer service at 1-800-350-6682. Nova's number f... Read more
21V151000 Mar 9, 2021
EXTERIOR LIGHTING:TAIL LIGHTS
Defect Description
Nova Bus (Nova) is recalling certain 2008-2021 LFS Buses. The center-line height of the brake lights and tail lights is too high, exceeding the maximum height standard. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps,... Read more
Consequence
Reduced visibility of the brake and tail lights can increase the risk of a crash.
Remedy
Nova will notify owners, and provide instructions for interchanging the positions of the brake light and tail light components with the turn signal light components, free of charge. The recall is expected to begin May 2021. Owners may contact Nova customer service at 1-800-350-6682.
20V568000 Sep 21, 2020
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
Defect Description
Nova Bus (Nova) is recalling certain 2020 Nova Bus LFS transit buses. Certain power steering pipes from the rear engine bay to the front gear box may separate at the connection joint. This may cause a power steering assist lost and power steering fluid may leak from the ceiling into the passenger ... Read more
Consequence
A loss of power steering assist may increase the risk of a crash. A power steering fluid leak into the passenger cabin may increase the risk of a passenger injury.
Remedy
Nova Bus will notify owners, provide instructions for inspecting and replacing the power steering pipes, free of charge. The recall began October 7, 2020. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR4963.
No complaints found for this vehicle.
Technical Service Bulletins — 2021 NOVA BUS LFS
139 manufacturer communications from 96 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 110000 ELECTRICAL SYSTEM | 41 |
| 350000 EQUIPMENT | 22 |
| 060000 ENGINE AND ENGINE COOLING | 17 |
| 010000 STEERING | 9 |
| 170000 LATCHES/LOCKS/LINKAGES | 8 |
| 160000 STRUCTURE | 5 |
| 100000 POWER TRAIN | 5 |
| 080000 FUEL SYSTEM, DIESEL | 3 |
BS5580E
Apr 23, 2024
060000 ENGINE AND ENGINE COOLING
One fire suppression system pipe may be installed backwards and interfere with an alternator cable, creating friction that could damage one or both components.
BS5580E
Apr 23, 2024
110000 ELECTRICAL SYSTEM
One fire suppression system pipe may be installed backwards and interfere with an alternator cable, creating friction that could damage one or both components.
FT5567
Mar 15, 2024
110000 ELECTRICAL SYSTEM
Battery Unbalanced Light Logic with AGM Battery.
FT5550
Mar 12, 2024
110000 ELECTRICAL SYSTEM
The Parker PHD70 display might freeze or not work properly.
FT5554
Feb 26, 2024
060000 ENGINE AND ENGINE COOLING
The Cabin Coolant Level Sensors for the LOW and HIGH levels are swapped.
BS5495E
Feb 9, 2024
130000 VISIBILITY
HVAC coolant pipe leaks from various solder locations.
BS5495E
Feb 9, 2024
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
HVAC coolant pipe leaks from various solder locations.
BS5540E
Feb 6, 2024
100000 POWER TRAIN
P-clamps holding the transmission coolant pipes can break.
BS5543E
Feb 5, 2024
110000 ELECTRICAL SYSTEM
Battery tray structure cracks due to thin sheet metal.
FT5534
Jan 31, 2024
110000 ELECTRICAL SYSTEM
The ground of the IVN unit (Intelligent Vehicle Network) could be connected to the wrong place.
BS5468E
Dec 29, 2023
160000 STRUCTURE
Driver barrier door stanchion hardware loose, missing, or broken.
BS5511E
Dec 22, 2023
060000 ENGINE AND ENGINE COOLING
The EGR cooling hose N95062-48 is not rated for the engine compartment temperature. Under certain conditions the EGR cooling hose may crack and cause coolant leak.
FT5536
Dec 20, 2023
110000 ELECTRICAL SYSTEM
Battery Tray Structure Cracks. Battery hold downs may slip between batteries.
BS5503E
Nov 29, 2023
110000 ELECTRICAL SYSTEM
The WHA11 harness has a potential chafing issue.
FT5514
Nov 23, 2023
160000 STRUCTURE
Upper door shaft nut may get loose.
FT5514
Nov 23, 2023
162300 STRUCTURE:BODY:DOOR
Upper door shaft nut may get loose.
FT5510E
Nov 15, 2023
160000 STRUCTURE
Lower door shaft nut may get loose.
BS5447E
Oct 31, 2023
010000 STEERING
Rework allied motion e-Steering motor. 24V e-steering power supply threads length tolerances are not respect to standard.
BS5447E
Oct 31, 2023
060000 ENGINE AND ENGINE COOLING
Rework allied motion e-Steering motor. 24V e-steering power supply threads length tolerances are not respect to standard.
FT5448
Oct 31, 2023
010000 STEERING
Rework allied motion e-Steering motor. 24V e-steering power supply threads length tolerances might not be respecting to the drawing specifications.
FT5448
Oct 31, 2023
060000 ENGINE AND ENGINE COOLING
Rework allied motion e-Steering motor. 24V e-steering power supply threads length tolerances might not be respecting to the drawing specifications.
LI5485E
Oct 27, 2023
120000 EXTERIOR LIGHTING
Introduction of headlight N109645 to replace N71373. The new headlight is interchangeable and offers better protection against water intrusion. It is possible to replace only one headlight if necessary.
FT5409
Oct 20, 2023
100000 POWER TRAIN
A bad connection at the ZF transmission connector may cause the transmission to jerk when shifting or show the fault code 188.
FT5455
Sep 5, 2023
130000 VISIBILITY
Brass fitting (N79131) leaks found at BL2 and BL4 two-way valve, repairs were performed not per AVT0029.
FT5314R1
Jul 13, 2023
100000 POWER TRAIN
P-Clamp failure on Transmission cooling pipes. P-Clamp cannot withstand the load of the cooling pipes. Thicker P-clamp as a containment solution.
FT5404E
Jul 7, 2023
010000 STEERING
There is a potential restriction of fluid due to an improperly placed clamp which could cause the power steering system to not operate has intended.
FT5405
Jul 7, 2023
010000 STEERING
Power steering lines chaffing the rear shell.
FT5437
Jun 15, 2023
110000 ELECTRICAL SYSTEM
The supplier Lift-U recommends the addition of a detection delay to prevent wrong fault code in the AVM.
BS5380E
Mar 15, 2023
060000 ENGINE AND ENGINE COOLING
Fire light coming on in the dash, Fire detection system.
BS5380E
Mar 15, 2023
110000 ELECTRICAL SYSTEM
Fire light coming on in the dash, Fire detection system.
BS5320ER1
Mar 15, 2023
060000 ENGINE AND ENGINE COOLING
Fire light coming on in the dash, Fire detection system
BS5320ER1
Mar 15, 2023
110000 ELECTRICAL SYSTEM
Fire light coming on in the dash, Fire detection system
BS5356E
Mar 15, 2023
350000 EQUIPMENT
Lexan panels cracking at mounting holes. Need to change the attachment of Lexan panels due to apparent cracks.
FT5361
Mar 15, 2023
060000 ENGINE AND ENGINE COOLING
Coolant pipe assy failing. The adaptor on the Coolant pipe assembly between the engine and circulation pump broke in service at the beginning of the copper thread.
FT5386
Mar 14, 2023
080000 FUEL SYSTEM, DIESEL
Loose fuel tank due to improperly torqued hardware and missing hardware.
FT5386
Mar 14, 2023
350000 EQUIPMENT
Loose fuel tank due to improperly torqued hardware and missing hardware.
FT5391
Mar 13, 2023
220000 SEATS
American seating lower bracket hardware missing. Seating lower bracket hardware is missing due to insufficient torque and sealant.
FT5391
Mar 13, 2023
350000 EQUIPMENT
American seating lower bracket hardware missing. Seating lower bracket hardware is missing due to insufficient torque and sealant.
FT5385
Mar 13, 2023
220000 SEATS
American seating lower bracket hardware missing. Seating lower bracket hardware is missing due to insufficient torque and sealant.
FT5385
Mar 13, 2023
350000 EQUIPMENT
American seating lower bracket hardware missing. Seating lower bracket hardware is missing due to insufficient torque and sealant.
BS5383E
Feb 27, 2023
110000 ELECTRICAL SYSTEM
Heating system cannot reach the required temperature level in cold weather.
FT5348
Feb 2, 2023
350000 EQUIPMENT
Wheelchair ramp deploy switch hardware loose.
FT5294E
Jan 31, 2023
110000 ELECTRICAL SYSTEM
Secure wiring and add wiring protection to avoid chafing/abrasion of wiring harness of the E-compressor.
FT5145R1
Jan 24, 2023
160000 STRUCTURE
Due to the lack of bonding surface between the two large roof top panels, when thermal expansion and contraction occur these panels separate and leave an opening
FT5360
Jan 18, 2023
040000 SERVICE BRAKES, AIR
Reposition Electrical Air Compressor cooling hose to avoid chafing/abrasion.
FT5194
Jan 12, 2023
120000 EXTERIOR LIGHTING
Destination sign controllers were failing at a high rate. Water intrusion causing signs to fail cracks on lights
FT5321
Jan 11, 2023
060000 ENGINE AND ENGINE COOLING
The anchor bolt of one of the auxiliary heater high voltage cable retaining collar may come into contact with one of the coolant pipes under certain conditions.
FT5321
Jan 11, 2023
110000 ELECTRICAL SYSTEM
The anchor bolt of one of the auxiliary heater high voltage cable retaining collar may come into contact with one of the coolant pipes under certain conditions.
FT5321
Jan 11, 2023
160000 STRUCTURE
The anchor bolt of one of the auxiliary heater high voltage cable retaining collar may come into contact with one of the coolant pipes under certain conditions.
FT5328
Dec 14, 2022
020000 SUSPENSION
Leveling valve N92260 found out of adjustment
FT5329
Dec 14, 2022
020000 SUSPENSION
Leveling valve N92260 found out of adjustment with damaged sway bar bushing bracket
FT5291R1
Dec 13, 2022
110000 ELECTRICAL SYSTEM
Some batteries temperature sensor may have an too high internal resistance and give an erroneous battery temparature reading causing F202 light battery to turn On, on dashboard
FT5347
Dec 2, 2022
110000 ELECTRICAL SYSTEM
Bus survey for CAN communication issues
BS5320E
Nov 28, 2022
110000 ELECTRICAL SYSTEM
Fire light coming on in the dash. Addition of a bracket so water wona??t drip on temperature sensor.
FT5338
Nov 11, 2022
110000 ELECTRICAL SYSTEM
Fire button pin incorrect orientation. Pin orientation not to the spec, found pin at 9 oa??clock position.
FT5314
Nov 3, 2022
100000 POWER TRAIN
P-clamp cannot withstand the load of the cooling pipes. Thicker P-clamp as a containment solution.
LI5315E
Oct 26, 2022
110000 ELECTRICAL SYSTEM
On the Thermo King HVAC roof unit, after replacing the actuator N8897109, some customers could see the error code 36.
LI5315E
Oct 26, 2022
350000 EQUIPMENT
On the Thermo King HVAC roof unit, after replacing the actuator N8897109, some customers could see the error code 36.
BS5300E
Sep 29, 2022
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
HVAC deflectors are breaking at the folded attachment points. The brackets broke right at the bending due to a sharp curve
BS5300E
Sep 29, 2022
350000 EQUIPMENT
HVAC deflectors are breaking at the folded attachment points. The brackets broke right at the bending due to a sharp curve
BS5301E
Sep 29, 2022
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
HVAC deflectors are breaking at the folded attachment points. The brackets broke right at the bending due to a sharp curve
BS5301E
Sep 29, 2022
350000 EQUIPMENT
HVAC deflectors are breaking at the folded attachment points. The brackets broke right at the bending due to a sharp curve
FT5237R2
Aug 25, 2022
060000 ENGINE AND ENGINE COOLING
Difficulty in removing the engine air filter housing cover affecting ease of serviceability of the filter.
FT5260R1
Aug 23, 2022
350000 EQUIPMENT
Need to change the attachment of Lexan panels due to apparent cracks observed in production.
FT5291
Aug 2, 2022
110000 ELECTRICAL SYSTEM
Some batteries temperature sensor may have an too high internal resistance and give an erroneous battery temparature reading causing F202 light battery to turn On, on dashboard
LI5280E
Jun 27, 2022
100000 POWER TRAIN
Transmission
FT5272
Jun 15, 2022
150000 SEAT BELTS
Driver seat belt routing improvement
FT5272
Jun 15, 2022
220000 SEATS
Driver seat belt routing improvement
FT5275
Jun 9, 2022
110000 ELECTRICAL SYSTEM
Parker Screen Software Update
FT5273
Jun 6, 2022
060000 ENGINE AND ENGINE COOLING
Bitzer AC compressor electrical failure
FT5273
Jun 6, 2022
110000 ELECTRICAL SYSTEM
Bitzer AC compressor electrical failure
FT5271R1
May 18, 2022
350000 EQUIPMENT
Loose drivers stanchion
FT5264
May 12, 2022
110000 ELECTRICAL SYSTEM
Door code 105 is being logged on electric doors
FT5264
May 12, 2022
170000 LATCHES/LOCKS/LINKAGES
Door code 105 is being logged on electric doors
FT5261
Apr 26, 2022
110000 ELECTRICAL SYSTEM
Door code 105 is being logged on electric doors
FT5261
Apr 26, 2022
162300 STRUCTURE:BODY:DOOR
Door code 105 is being logged on electric doors
FT5261
Apr 26, 2022
170000 LATCHES/LOCKS/LINKAGES
Door code 105 is being logged on electric doors
FT5245R1
Apr 22, 2022
110000 ELECTRICAL SYSTEM
ITS Moxy switch. The port 13 CAT6 cable of the NYCT Moxy switch is for a future option and should never be plugged in. Plugging this cable will cause malfunctions to the Infotainment screens and could cause damage
FT5245R1
Apr 22, 2022
353620 EQUIPMENT:ELECTRICAL:INFOTAINMENT:VIDEO (TOUCH)SCREEN/MONITOR/UNIT
ITS Moxy switch. The port 13 CAT6 cable of the NYCT Moxy switch is for a future option and should never be plugged in. Plugging this cable will cause malfunctions to the Infotainment screens and could cause damage
FT5254
Apr 12, 2022
110000 ELECTRICAL SYSTEM
Turn Signal Foot Switch Failures
FT5254
Apr 12, 2022
120000 EXTERIOR LIGHTING
Turn Signal Foot Switch Failures
FT5198R2
Mar 30, 2022
110000 ELECTRICAL SYSTEM
Water infiltration inside roof fuse box
FT5198R2
Mar 30, 2022
350000 EQUIPMENT
Water infiltration inside roof fuse box
LI5164E
Mar 24, 2022
110000 ELECTRICAL SYSTEM
MCC Driver's Display Electrical Terminal Failure. Bracket installation to add a strain relief on the MCC display screen wires.
LI5164E
Mar 24, 2022
350000 EQUIPMENT
MCC Driver's Display Electrical Terminal Failure. Bracket installation to add a strain relief on the MCC display screen wires.
LI5164E
Mar 24, 2022
356000 EQUIPMENT ADAPTIVE/MOBILITY
MCC Driver's Display Electrical Terminal Failure. Bracket installation to add a strain relief on the MCC display screen wires.
BS5210ER1
Mar 22, 2022
110000 ELECTRICAL SYSTEM
Horn may fail due to the low internal high heat resistance.
BS5210ER1
Mar 22, 2022
350000 EQUIPMENT
Horn may fail due to the low internal high heat resistance.
FT5245
Mar 17, 2022
110000 ELECTRICAL SYSTEM
ITS Moxy switch. The port 13 CAT6 cable of the NYCT Moxy switch is for a future option and should never be plugged in.Plugging this cable will cause malfunctions to the Infotainment screens and could cause damage.
FT5245
Mar 17, 2022
350000 EQUIPMENT
ITS Moxy switch. The port 13 CAT6 cable of the NYCT Moxy switch is for a future option and should never be plugged in.Plugging this cable will cause malfunctions to the Infotainment screens and could cause damage.
FT5237
Mar 10, 2022
060000 ENGINE AND ENGINE COOLING
Difficulty in removing the engine air filter housing cover
FT5237
Mar 10, 2022
350000 EQUIPMENT
Difficulty in removing the engine air filter housing cover
FT5240
Mar 10, 2022
080000 FUEL SYSTEM, DIESEL
Filler Neck Valve Issue
FT5240
Mar 10, 2022
350000 EQUIPMENT
Filler Neck Valve Issue
FT5240
Mar 10, 2022
356000 EQUIPMENT ADAPTIVE/MOBILITY
Filler Neck Valve Issue
FT5199R2
Mar 2, 2022
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Gasket N55895 not installed in production (exhaust system)
FT5199R2
Mar 2, 2022
061530 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:SEALS/GASKETS
Gasket N55895 not installed in production (exhaust system)
FT5198R1
Feb 2, 2022
110000 ELECTRICAL SYSTEM
Water Inside Roof Fuse Box
FT5199R1
Feb 2, 2022
060000 ENGINE AND ENGINE COOLING
Missing gasket at flexible joint below
FT5232
Feb 2, 2022
060000 ENGINE AND ENGINE COOLING
Engine temperature too low. Engine code 3243
Showing 100 of 139 bulletins.
NOVA BUS LFS — All Years Overview
Complete safety history for the NOVA BUS LFS across all model years (2005–2025).
246
Total Recalls
2
Total Complaints
0
Investigations
0
Reported Crashes
0
Reported Fires
0
Reported Deaths
NOVA BUS LFS — Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2025 | 3 | 0 | View |
| 2024 | 9 | 0 | View |
| 2023 | 30 | 2 | View |
| 2022 | 31 | 0 | View |
| 2021 (current) | 22 | 0 | |
| 2020 | 20 | 0 | View |
| 2019 | 21 | 0 | View |
| 2018 | 15 | 0 | View |
| 2017 | 17 | 0 | View |
| 2016 | 16 | 0 | View |
| 2015 | 13 | 0 | View |
| 2014 | 13 | 0 | View |
| 2013 | 15 | 0 | View |
| 2012 | 8 | 0 | View |
| 2011 | 4 | 0 | View |
| 2010 | 3 | 0 | View |
| 2009 | 1 | 0 | View |
| 2008 | 2 | 0 | View |
| 2007 | 1 | 0 | View |
| 2006 | 1 | 0 | View |
| 2005 | 1 | 0 | View |