2010 NOVA BUS LFS ARTIC
3 recalls — 0 complaints — 180 TSBs
24V647000 Nov 5, 2024
SEAT BELTS:FRONT
Defect Description
Nova Bus (US) Inc. (Nova) is recalling certain 2010-2020 LFS Artic and 2012-2024 LFS vehicles. The driver's seat belt may not retract properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 209, "Seat Belt Assemblies."
Consequence
A seat belt that does not retract properly may result in a loose seat belt, which can increase the risk of injury in a crash.
Remedy
Nova Bus will install additional seat stoppers to the driver's rear partition, free of charge. Owner notification letters are expected to be mailed July 4, 2025. Nova's number for this recall is CR5635. This recall expands and replaces previous recall number 23V-350. Vehicles that were previously... Read more
22V902000 Dec 7, 2022
EXTERIOR LIGHTING
Defect Description
Nova Bus (US) Inc. (Nova) is recalling certain 2010-2021 LFS and 2009-2012 LFS Artic transit buses. These vehicles are equipped with non-standard color auxiliary lights which may impair the effectiveness of the standard lighting equipment. As such, these vehicles fail to comply with the requiremen... Read more
Consequence
The colorful lighting may cause confusion by distracting other drivers, increasing the risk of a crash.
Remedy
Dealers will remove the non-standard color lights, or replace them with white lights, free of charge. Owner notification letters were mailed January 31, 2023. Owners may contact Nova's customer service at 1-800-350-6682. Nova's number for this recall is CR5350/5351.
16V068000 Feb 5, 2016
ELECTRICAL SYSTEM:WIRING
Defect Description
Nova Bus (Nova) is recalling certain model year 2010-2015 Nova LFS Artic transit buses manufactured from September 1, 2010, through April 30, 2015, and equipped with Allison transmissions. The main power cable within the energy guiding system (EGS) may have been incorrectly routed and, as a result,... Read more
Consequence
If the main power cable disconnects, there will be a loss of power that could disable the vehicle, increasing the risk of a crash.
Remedy
Nova will notify owners, and dealers will inspect the main power cable, re-routing it as necessary, free of charge. The recall began on April 11, 2016. Owners may contact Nova customer service at 1-450-472-6410. Nova's recall number for this campaign is CR3590.
No complaints found for this vehicle.
Technical Service Bulletins — 2010 NOVA BUS LFS ARTIC
180 manufacturer communications from 122 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 29 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 26 |
| 060000 ENGINE (PWS) | 12 |
| 110000 ELECTRICAL SYSTEM | 11 |
| 060000 ENGINE AND ENGINE COOLING | 10 |
| 220000 SEATS | 6 |
| 010000 STEERING | 6 |
| 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER | 6 |
LI5228ER2
Apr 26, 2023
061570 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:SUMP/TANK
DEF GEN4 tank, tank head and sensor will no longer be available in service
LI5170E
Feb 7, 2022
020000 SUSPENSION
New lower shock mount available with an adapter plate better suited for the front and rear axle.
LI5178R1
Jan 11, 2022
030000 SERVICE BRAKES, HYDRAULIC
installation of new pressure regulator for retarder interlock. Obsolete part replacement
LI5180
Oct 28, 2021
040000 SERVICE BRAKES, AIR
Installation of new pressure regulator for interlock retarder. Obsolete part replacement.
FT4720R1
Jun 3, 2021
060000 ENGINE AND ENGINE COOLING
Coolant hose rubbing against bulk head panel edge
FT4389R1
Mar 10, 2021
350000 EQUIPMENT
ITS Box Shelves Loose
LI3978E
Feb 9, 2021
060000 ENGINE AND ENGINE COOLING
Information about the engine coolant. Coolant types should not be mixed in the engine.
LI3978E
Feb 9, 2021
350000 EQUIPMENT
Information about the engine coolant. Coolant types should not be mixed in the engine.
LI3978E
Feb 9, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
Information about the engine coolant. Coolant types should not be mixed in the engine.
LI5011E
Jan 27, 2021
350000 EQUIPMENT
Recommendations on the disinfection of vehicles as well as products and precautions to be taken.
LI4967ER1
Oct 19, 2020
350000 EQUIPMENT
Auxiliary heater Thermo 350 is discontinued. The Thermo Plus unit will replace the current unit only if the whole unit needs to be replaced. There is no need to retrofit any buses with the new Thermo Plus units. Replacement parts are availa
BS3667ER2
Sep 4, 2020
160000 STRUCTURE
Vertical beam might crack above front door, second post capping. Weld stiffening plates.
APS4896E
Jun 29, 2020
010000 STEERING
Introduction of a new steering gearbox without the lubrication zerk.
APS4896E
Jun 29, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
Introduction of a new steering gearbox without the lubrication zerk.
LI4432ER1
Jun 26, 2020
010000 STEERING
TRW has eliminated from service procedure TAS-103 the greasing of the steering gearbox output shaft.
LI4673ER1
Jun 3, 2020
110000 ELECTRICAL SYSTEM
Obsolete AIC3 module needs to be replaced by the newer AIC4 module.
LI4673ER1
Jun 3, 2020
350000 EQUIPMENT
Obsolete AIC3 module needs to be replaced by the newer AIC4 module.
LI4673E
Feb 26, 2020
110000 ELECTRICAL SYSTEM
Obsolete AIC3 module needs to be replaced by the newer AIC4 module
FT4586
Jun 11, 2019
350000 EQUIPMENT
Cover the scrap fee of N48035-01 Ref BS1906
LI4577ER1
May 28, 2019
350000 EQUIPMENT
The repair kit parts will require a specific installation procedure. Current stock parts may still be used
APS4531E
Feb 27, 2019
350000 EQUIPMENT
Availability of a dust protection kit to remove the maintenance need to clean the flame sensor sight glass when excessive soot or debris is accumulated on the internal burner head disc.
LI4546E
Jan 14, 2019
980000 UNKNOWN OR OTHER
To avoid the risk of air being trapped which could damage the EGR cooler.
LI4396E
Oct 31, 2018
060000 ENGINE (PWS)
An inadequate assembly sequence of the engine cradle may cause cracks in certain cases.
LI4394E
Oct 31, 2018
350000 EQUIPMENT
A new air dryer inspection procedure will be added to the maintenance and preventive maintenance manual for air dryer system sections,
LI4417E
Oct 5, 2018
080000 FUEL SYSTEM, DIESEL
Maintenance update of the EGR differential pressure sensor and diesel particulate filter which must be cleaned at 5000hrs for Cummins Engine(s) concerning ISL9 CM2250.
LI4417E
Oct 5, 2018
100000 POWER TRAIN
Maintenance update of the EGR differential pressure sensor and diesel particulate filter which must be cleaned at 5000hrs for Cummins Engine(s) concerning ISL9 CM2250.
LI4417E
Oct 5, 2018
060000 ENGINE (PWS)
Maintenance update of the EGR differential pressure sensor and diesel particulate filter which must be cleaned at 5000hrs for Cummins Engine(s) concerning ISL9 CM2250.
BS4370E
Jun 22, 2018
110000 ELECTRICAL SYSTEM
VBEA software logic improved to ensure that rear door fan operates according to actual ambient and engine compartment temperatures.
LI3994ER1
Jun 20, 2018
060000 ENGINE AND ENGINE COOLING
N41269 PAL hydraulic filter head discontinued and replaced by hydraulic filter head N8905938 and filter N8905939
LI4167ER1
Mar 4, 2018
160000 STRUCTURE
New improved stanchion is now available for installation in the articulation section of the vehicle.
LI4167ER2
Feb 5, 2018
350000 EQUIPMENT
New improved stanchion is now available for installation in the articulation section of the vehicle.
LI4167ER2
Feb 5, 2018
356000 EQUIPMENT ADAPTIVE/MOBILITY
New improved stanchion is now available for installation in the articulation section of the vehicle.
LI4167E
Jan 31, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
New improved stanchion is now available for installation in the articulation section of the vehicle.
LI4083E
Nov 14, 2017
350000 EQUIPMENT
N64662 PAL hydraulic filter head discontinued and replaced by hydraulic filter head N8905938 and filter N8905939
LI4059ER1
Oct 11, 2017
062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
In case of replacing the existing radiator, there is an option to either refit the radiator to the existing frame or replace the complete radiator assembly with frame.
LI4059ER1
Oct 11, 2017
160000 STRUCTURE
In case of replacing the existing radiator, there is an option to either refit the radiator to the existing frame or replace the complete radiator assembly with frame.
LI3402ER3
Sep 29, 2017
062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM
Low coolant level sensor warning
LI4113E
Aug 31, 2017
356000 EQUIPMENT ADAPTIVE/MOBILITY
Procedure and tooling to remove the articulation cylinder pin is inadequate.
BS3873E
Jul 14, 2017
060000 ENGINE (PWS)
Engine compartment may have high temperature issues due to inadequate heat dissipation.
BS3735ER2
May 17, 2017
063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
Flexible bellows N79197 and N79198 may have an exhaust leak near the rigid exhaust pipe.
LI3720E
May 5, 2017
350000 EQUIPMENT
Introduction of optimized hub carrier kit for ZF AVN-132 middle axle on 60' vehicles
LI3720E
May 5, 2017
356000 EQUIPMENT ADAPTIVE/MOBILITY
Introduction of optimized hub carrier kit for ZF AVN-132 middle axle on 60' vehicles
LI3948E
May 5, 2017
036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
In case of replacing the existing ZF ABS sensor of AV-132, there is an option to refit the ABS sensor in accordance with AV-132 II
LI3948E
May 5, 2017
046000 SERVICE BRAKES, AIR:ANTILOCK
In case of replacing the existing ZF ABS sensor of AV-132, there is an option to refit the ABS sensor in accordance with AV-132 II
LI3753E
Mar 16, 2017
161000 STRUCTURE:FRAME AND MEMBERS
Vertical beam might crack above front door, second post capping.
BS3046ER1
Feb 24, 2017
110000 ELECTRICAL SYSTEM
N22759 protective cable sheathing. The protective sheathing may be damaged and cause error codes on the diagnostic network.
LI1911ER1
Feb 13, 2017
350000 EQUIPMENT
ZF wheel head suspension. ZF introduced an optimized axial roller bearing. Replace the axial roller bearing and lower seal ring with an optimized roller bearing.
LI1911ER1
Feb 13, 2017
356000 EQUIPMENT ADAPTIVE/MOBILITY
ZF wheel head suspension. ZF introduced an optimized axial roller bearing. Replace the axial roller bearing and lower seal ring with an optimized roller bearing.
BS3853ER1
Dec 9, 2016
354000 EQUIPMENT:MECHANICAL
Installation of a new and improved Energy Guidance System (EGS)
BS3853ER1
Dec 9, 2016
356000 EQUIPMENT ADAPTIVE/MOBILITY
Installation of a new and improved Energy Guidance System (EGS)
LI3478E
Dec 5, 2016
110000 ELECTRICAL SYSTEM
THIS COMMUNICATION IS A LETTER OF INFORMATION CONCERNING A FAULT THAT MAY APPEAR ON THE ACTIA GAUGE IF AN INCORRECT PROGRAM VERSION IS USED.
LI3478E
Dec 5, 2016
118000 ELECTRICAL SYSTEM:SOFTWARE
THIS COMMUNICATION IS A LETTER OF INFORMATION CONCERNING A FAULT THAT MAY APPEAR ON THE ACTIA GAUGE IF AN INCORRECT PROGRAM VERSION IS USED.
BS3853E
Nov 30, 2016
110000 ELECTRICAL SYSTEM
INSTALLATION OF A NEW AND IMPROVED EGS.
bs3853e
Nov 30, 2016
350000 EQUIPMENT
Installation of a new and improved EGS.
LI3446ER5
Nov 1, 2016
010000 STEERING
INTRODUCING NEW HARDWARE AND INSTALLATION PROCEDURE FOR PITMAN ARM. (R5 UPDATED THE TORQUE VALUE IN PROCEDURE LINE 1.9)
LI3446ER5
Nov 1, 2016
020000 SUSPENSION
INTRODUCING NEW HARDWARE AND INSTALLATION PROCEDURE FOR PITMAN ARM. (R5 UPDATED THE TORQUE VALUE IN PROCEDURE LINE 1.9)
li3446er5
Oct 5, 2016
013200 STEERING:GEAR BOX:SHAFT PITMAN
Introducing new hardware and installation procedure for Pitman arm. (R5 updated the torque value in procedure line 1.9)
LI3770E
Sep 27, 2016
060000 ENGINE (PWS)
NO ACCESS TO SUSPEND #6 LIFTER. CUT HOLE FOR ACCESS TO #6 CYLINDER EXHAUST LIFTER.
BS3419E
Sep 22, 2016
136200 VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
The wiper motor cannot be stopped by the driver.
BS3531ER3
Aug 25, 2016
100000 POWER TRAIN
"FAILURE OF P-CLAMPS ON THE TRANSMISSION COOLING PIPES MAY FORCE THE PIPE TO COME IN CONTACT WITH STARTER SOLENOID TERMINAL. DOCUMENT REVISED TO REMOVE ONE VEHICLE FROM HOUSTON."
LI3732E
Aug 9, 2016
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
PROCEDURE TO FOLLOW WHEN REPLACING A PLASTIC MOTORIZE VALVE BY A METAL MOTORIZE VALVE. FOR THE DRIVER'S COMPARTMENT DEFROSTER VALVE.
LI3732E
Aug 9, 2016
060000 ENGINE (PWS)
PROCEDURE TO FOLLOW WHEN REPLACING A PLASTIC MOTORIZE VALVE BY A METAL MOTORIZE VALVE. FOR THE DRIVER'S COMPARTMENT DEFROSTER VALVE.
BS3046E
Jul 22, 2016
356000 EQUIPMENT ADAPTIVE/MOBILITY
THE PROTECTIVE SHEATHING MAY BE DAMAGED AND CAUSE ERROR CODES ON THE DIAGNOSTIC NETWORK
BS3047E
Jul 22, 2016
350000 EQUIPMENT
THE PROTECTIVE SHEATHING MAY BE DAMAGED AND CAUSE ERROR CODES ON THE DIAGNOSTIC NETWORK
BS3531ER2
Jul 12, 2016
100000 POWER TRAIN
FAILURE OF P-CLAMPS ON THE TRANSMISSION COOLING PIPES MAY FORCE THE PIPE TO COME IN CONTACT WITH STARTER SOLENOID TERMINAL.
LI3446ER4
Apr 12, 2016
010000 STEERING
INTRODUCING NEW HARDWARE AND INSTALLATION PROCEDURE FOR PITMAN ARM.
LI3446ER3
Apr 5, 2016
010000 STEERING
INTRODUCING NEW HARDWARE AND INSTALLATION PROCEDURE FOR PITMAN ARM.
BS3457E
Dec 11, 2015
060000 ENGINE AND ENGINE COOLING
COOLANT SUPPLY TO MK2 RADIATOR MIGHT BE ERRATIC AND CREATE AIR POCKET IN RADIATOR
BS2030E
Dec 4, 2015
060000 ENGINE AND ENGINE COOLING
RUBBER SUPPORT BREAKS ON THE HORIZONTAL CAC PIPE.
LI3486E
Nov 16, 2015
021600 SUSPENSION:FRONT:WHEEL BEARING
Lubrication schedule for the bearing articulation. Additional greasing intervals promote extended durability of articulation joint main bearing when exposed to harsh environments. These severe environments may include, but not limited to, d
BS3465E
Nov 16, 2015
353000 EQUIPMENT:ELECTRICAL
Articulation solenoid circuit may cause an error code in ACU
LI3499E
Nov 11, 2015
353000 EQUIPMENT:ELECTRICAL
Hubner articulation with ACU III control unit.The red artic tell tale ligths: 1- for an <Error 2 Plausibility 2> code generated for no reason, 2- when no code is logged in the ACU (ghost code).
LI3499E
Nov 11, 2015
356000 EQUIPMENT ADAPTIVE/MOBILITY
Hubner articulation with ACU III control unit.The red artic tell tale ligths: 1- for an <Error 2 Plausibility 2> code generated for no reason, 2- when no code is logged in the ACU (ghost code).
LI3446ER2
Nov 10, 2015
013200 STEERING:GEAR BOX:SHAFT PITMAN
Introducing new hardware and installation procedure for Pitman arm. (R2 revision is for: Road number and VIN has been updated for L860 TTC)
LI3446ER2
Nov 10, 2015
350000 EQUIPMENT
Introducing new hardware and installation procedure for Pitman arm. (R2 revision is for: Road number and VIN has been updated for L860 TTC)
Bs3199er2
Oct 5, 2015
356000 EQUIPMENT ADAPTIVE/MOBILITY
The center hoop support bolt may be loose
LI3402ER2
Sep 16, 2015
060000 ENGINE AND ENGINE COOLING
Low coolant level sensor warning
LI3402ER1
Sep 9, 2015
060000 ENGINE AND ENGINE COOLING
Low coolant level sensor warning
LI3402E
Jul 14, 2015
060000 ENGINE AND ENGINE COOLING
Low coolant level sensor warning
BS3080ER1
Jul 13, 2015
110000 ELECTRICAL SYSTEM
CECM could be replace with a MCM module to reduce download time
LI1953E
Jun 15, 2015
015000 STEERING:HYDRAULIC POWER ASSIST SYSTEM
Moisture may accumulate in the space under the driver's seat and cause corrosion of the power steering hydraulic fittings and piping.
LI1953E
Jun 15, 2015
220000 SEATS
Moisture may accumulate in the space under the driver's seat and cause corrosion of the power steering hydraulic fittings and piping.
BS3218E
Apr 27, 2015
062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
The engine air intake hose could rub against the air conditioning compressor components
BS3218E
Apr 27, 2015
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
The engine air intake hose could rub against the air conditioning compressor components
BS3359E
Apr 9, 2015
060000 ENGINE (PWS)
Cummins ISL10 engine does not have the confi guration to support fault code 2448
BS3282ER1
Mar 12, 2015
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
A/C compressor belts may split down the center.
LI3227E
Jan 22, 2015
350000 EQUIPMENT
New Potentiometer available in service
LI3227E
Jan 22, 2015
353000 EQUIPMENT:ELECTRICAL
New Potentiometer available in service
LI1643ER1
Dec 4, 2014
350000 EQUIPMENT
The crystallization of urea creates leaks and venting odors, and dirt may enter the reservoir.
LI1643ER1
Dec 4, 2014
980000 UNKNOWN OR OTHER
The crystallization of urea creates leaks and venting odors, and dirt may enter the reservoir.
LI1643ER1
Dec 4, 2014
356000 EQUIPMENT ADAPTIVE/MOBILITY
The crystallization of urea creates leaks and venting odors, and dirt may enter the reservoir.
LI3193
Jul 18, 2014
162800 STRUCTURE:BODY:HOOD
The rear engine access door may not close properly
LI3193
Jul 18, 2014
176100 LATCHES/LOCKS/LINKAGES:HOOD:LATCH
The rear engine access door may not close properly
BS3070
Jul 18, 2014
034200 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Possible chafing between the brake hoses and surrounding components.
BS3070
Jul 18, 2014
042600 SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
Possible chafing between the brake hoses and surrounding components.
LI3188
Jul 4, 2014
020000 SUSPENSION
A new radius rod bolt torque is now in effect.
BS3139E
Jun 27, 2014
035000 SERVICE BRAKES, HYDRAULIC:FLUID
Possible hydraulic manifold leakage.
LI3187
Jun 12, 2014
010000 STEERING
The power steering hydraulic lines may be loose in the radiator compartment
LI3187
Jun 12, 2014
015200 STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
The power steering hydraulic lines may be loose in the radiator compartment
LI2072E
Apr 24, 2014
040000 SERVICE BRAKES, AIR
Service-relevant changes to the adjuster of the air disc brakes.
Showing 100 of 180 bulletins.
NOVA BUS LFS ARTIC — All Years Overview
Complete safety history for the NOVA BUS LFS ARTIC across all model years (2009–2024).
122
Total Recalls
0
Total Complaints
0
Investigations
0
Reported Crashes
0
Reported Fires
0
Reported Deaths
NOVA BUS LFS ARTIC — Year by Year
Compare recalls and complaints across model years. Click any year to see full details.