2001 NEW FLYER C35LF
5 recalls — 0 complaints — 7 TSBs
07V068000 Feb 23, 2007
EXTERIOR LIGHTING
Defect Description
CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES.
Consequence
THE STANDARD REQUIRES THAT THE DECELERATION LAMP IS A SOLID LIGHT RATHER THAN A FLASHING LIGHT.
Remedy
DEALERS WILL REWIRE THE ELECTRICAL SYSTEM TO REMOVE THE FLASHING FUNCTION OR INSTALL A NEW PROGRAMMABLE LOGIC CONTROLLER (PLC) WHICH WILL MAKE THE LAMPS BURN STEADY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 5, 2007. OWNERS MAY CONTACT NEW FLYER AT 204-934-4874.
03V182000 May 16, 2003
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Defect Description
ON CERTAIN TRANSIT BUSES EQUIPPED WITH CUMMINS WESTPORT B GAS PLUS OR C GAS PLUS 6 CYLINDER ENGINES, THE ELECTRONIC CONTROL MODULE CALIBRATION MAY NOT CORRECTLY DETECT A THROTTLE PLATE ACTUATOR FAILURE THAT COULD RESULT IN AN UNCOMMANDED OPEN THROTTLE CONDITION.
Consequence
IF THIS EVENT OCCURS, THE VEHICLE OPERATOR WILL NOT HAVE CONTROL OF THE ENGINE SPEED WHICH COULD POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy
DEALERS WILL REPLACE THE ELECTRONIC CONTROL MODULE CALIBRATION FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CUMMINS CUSTOMER ASSISTANCE CENTER AT 1-800-343-7357 OR NEW... Read more
02V112000 May 22, 2002
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
Defect Description
ON CERTAIN LOW FLOOR BUSES, THE POWER STEERING HOSE WAS INCORRECTLY INSTALLED.
Consequence
THE HOSE CAN LEAK, CREATING THE RISK OF AN ENGINE FIRE.
Remedy
DEALERS WILL REPLACE THE HOSE. OWNER NOTIFICATION BEGAN JULY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NEW FLYER AT 1-204-228-8984.
02V004008 May 16, 2002
VEHICLE SPEED CONTROL
Defect Description
ON CERTAIN BUSES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES, THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.
Consequence
IF THE CLEVIS SEPARATED FROM THE PLATE WHILE THE VEHICLE WAS IN USE, THE VEHICLE WOULD RETURN TO IDLE, INCREASING THE RISK OF A CRASH.
Remedy
WILLIAMS CONTROLS IS HANDLING THE REPLACEMENT OF THIS PEDAL. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WILLIAMS CONTROL AT 1-503-684-8600 OR NEW FLYER AT 204-982-8181.
01V265000 Aug 22, 2001
STEERING:LINKAGES:TIE ROD ASSEMBLY
Defect Description
VEHICLE DESCRIPTION: TRANSIT BUSES. THE CLAMP NUTS FOR THE CENTER LINK TIE RODS MAY HAVE BEEN INADEQUATELY TIGHTENED.
Consequence
INADEQUATELY TIGHTENED CLAMP NUTS COULD LEAD TO THE TIE RODS SEPARATING FROM THE CENTER LINK POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy
NEW FLYER WILL WILL INSPECT THE TIE ROD END CLAMP LOCK NUTS TO ENSURE THAT THE NUTS ARE PROPERLY TIGHTENED. ANY DAMAGED TIE RODS WILL BE REPLACED. OWNER NOTIFICATION BEGAN SEPTEMBER 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE... Read more
No complaints found for this vehicle.
Technical Service Bulletins — 2001 NEW FLYER C35LF
7 manufacturer communications from 5 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 2 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 2 |
| 062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM | 1 |
| 060000 ENGINE AND ENGINE COOLING | 1 |
| 060000 ENGINE (PWS) | 1 |
SMB191
May 6, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Service Manual Bulletin - Changes to Cummins ISLG and L9N engine oil specifications and oil change intervals.
SMB191
May 6, 2020
060000 ENGINE (PWS)
Service Manual Bulletin - Changes to Cummins ISLG and L9N engine oil specifications and oil change intervals.
TSIB 20-01
Apr 3, 2020
060000 ENGINE AND ENGINE COOLING
Technical Service Information Bulletin describing changes to the Cummins ISLG, L9N, ISB6.7G and B6.7N engine oil specifications.
PMB049
Jan 5, 2018
350000 EQUIPMENT
This Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg brake and accelerator assembly on specifically equipped vehicles.
SMB178
Jan 5, 2018
350000 EQUIPMENT
This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
SMB178
Jan 5, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
1571A
Jul 11, 2001
062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM
SUBJECT REGARDING ADDITIONAL NEWFLYER SERVICE MANUAL MAINTENANCE INSTRUCTIONS FOR SERVICING THE HYDRAULIC FAN DRIVE PUMP (PERMCO) AND POWER STEERING PUMP (VICKERS) ON A D30LF, D35LF, D40LF, C30LF, C35LF, C40LF COACHES WITH A CUMMINS 8.3 ENG
NEW FLYER C35LF — All Years Overview
Complete safety history for the NEW FLYER C35LF across all model years (1996–2009).
44
Total Recalls
0
Total Complaints
0
Investigations
0
Reported Crashes
0
Reported Fires
0
Reported Deaths
NEW FLYER C35LF — Year by Year
Compare recalls and complaints across model years. Click any year to see full details.