1998 NEW FLYER C35LF
8 recalls — 0 complaints — 7 TSBs
05V045000 Feb 4, 2005
ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER
Defect Description
ON CERTAIN TRANSIT BUSES MANUFACTURED WITH DETROIT DIESEL SERIES 50 ENGINES, THE TURBOCHARGER COMPRESSOR WHEEL CAN BREAK, RESULTING IN SHAFT IMBALANCE AND LUBRICATING OIL PASSES INTO THE EXHAUST SYSTEM.
Consequence
THIS CAN RESULT IN AN ENGINE COMPARTMENT FIRE, POSSIBLY RESULTING IN PERSONAL INJURIES.
Remedy
DETROIT DIESEL IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSTALL AN EXHAUST TEMPERATURE SENSOR AND REPROGRAM THE EMC CALIBRATION FREE OF CHARGE. OWNERS MAY CONTACT DETROIT DIESEL AT 313-592-3708 OR NEW FLYER AT 204-982-8400.
02V112000 May 22, 2002
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
Defect Description
ON CERTAIN LOW FLOOR BUSES, THE POWER STEERING HOSE WAS INCORRECTLY INSTALLED.
Consequence
THE HOSE CAN LEAK, CREATING THE RISK OF AN ENGINE FIRE.
Remedy
DEALERS WILL REPLACE THE HOSE. OWNER NOTIFICATION BEGAN JULY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NEW FLYER AT 1-204-228-8984.
02V059001 Feb 14, 2002
STRUCTURE:BODY:DOOR
Defect Description
ON CERTAIN LOW FLOOR TRANSIT BUSES EQUIPPED WITH ADHESIVELY BONDED ALUMINUM BUS DOOR PANELS, DUE TO AN IMPERFECT BONDING OF THE DOOR PANEL SKIN TO THE PANEL FRAME, ENVIRONMENTAL MOISTURE MAY INFILTRATE REGIONS OF IMPERFECT BONDING AND CAUSE SEPARATION OF THE FRAME AND DOOR PANEL.
Consequence
UNDER THESE CONDITIONS, IF THE PANEL IS SEPARATING OR HAS SEPARATED, A PASSENGER COULD FALL FROM THE BUS ONTO THE ROADWAY, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
Remedy
VAPOR WILL NOTIFY CUSTOMERS TO HAVE THEIR BUSES INSPECTED AND WILL INSTALL MECHANICAL FASTENERS TO ATTACH THE SKINS TO THE FRAME ELEMENTS FREE OF CHARGE. OWNER NOTIFICATION BEGAN DECEMBER 10, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT REC... Read more
01V265000 Aug 22, 2001
STEERING:LINKAGES:TIE ROD ASSEMBLY
Defect Description
VEHICLE DESCRIPTION: TRANSIT BUSES. THE CLAMP NUTS FOR THE CENTER LINK TIE RODS MAY HAVE BEEN INADEQUATELY TIGHTENED.
Consequence
INADEQUATELY TIGHTENED CLAMP NUTS COULD LEAD TO THE TIE RODS SEPARATING FROM THE CENTER LINK POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy
NEW FLYER WILL WILL INSPECT THE TIE ROD END CLAMP LOCK NUTS TO ENSURE THAT THE NUTS ARE PROPERLY TIGHTENED. ANY DAMAGED TIE RODS WILL BE REPLACED. OWNER NOTIFICATION BEGAN SEPTEMBER 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE... Read more
01V160000 May 22, 2001
SUSPENSION
Defect Description
VEHICLE DESCRIPTION: TRANSIT BUSES. THERE COULD BE A CASTING DEFECT IN THE LEFT SIDE SPRING TOWER. THE SPRING TOWERS SUPPORT THE VEHICLE STRUCTURE, AND FAILURE OF A TOWER COULD CAUSE A SUDDEN SHIFT IN THE FRONT AXLE.
Consequence
THIS CONDITION COULD LEAD TO LOSS OF CONTROL OF THE VEHICLE.
Remedy
DEALERS WILL REPLACE THE SPRING TOWER. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NEW FLYER AT 1-204-982-8181.
01V033006 Apr 30, 2001
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Defect Description
VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH VANNER 60 SERIES BATTERY EQUALIZERS. THE EQUALIZER COULD FAIL TO OPERATE PROPERLY AND CAUSE MALFUNCTION OF THE BATTERY CHARGING SYSTEM.
Consequence
WITHOUT FUSING, THE EQUALIZER MAY MELT, BURN, OR SMOKE, POSSIBLY RESULTING IN A FIRE OR A SMOKE FILLED BUS, THUS NECESSITATING A PASSENGER EVACUATION OF THE BUS. THE FAILURE MODE CAN CAUSE OPERATOR DISTRACTION, AND/OR POSSIBLE PERSONAL INJURY.
Remedy
DEALERS WILL INSPECT THE BUSES FOR CERTAIN EQUALIZERS BY THE DATE CODE. THE AFFECTED EQUALIZERS WILL BE REPLACED BY VANNER. NEW FLYER IS CONDUCTING THE OWNER NOTIFICATION FOR THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE T... Read more
00V275000 Sep 15, 2000
SERVICE BRAKES, AIR
Defect Description
VEHICLE DESCRIPTION: CERTAIN TRANSIT BUSES EQUIPPED WITH ABS FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." THE REAR BRAKE RELEASE TIME CAN EXCEED THE REQUIREMENTS.
Consequence
A SLOW BRAKE RELEASE CAN CAUSE PREMATURE BRAKE WEAR, INCREASING THE RISK OF A CRASH.
Remedy
THE REPAIR WILL INVOLVE INSTALLING A QUICK RELEASE VALVE OR INCREASING THE SIZE OF THE REAR BRAKE CONTROL LINE.
99V077000 Apr 13, 1999
SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
Defect Description
VEHICLE DESCRIPTION: TRANSIT BUSES. THE REAR BRAKE RELEASE TIME CAN EXCEED THE REQUIREMENTS OF FMVSS NO. 121.
Consequence
A SLOW BRAKE RELEASE CAN CAUSE PREMATURE BRAKE WEAR WHICH IF LEFT UNCHECKED COULD LEAD TO BRAKE FAILURE AND VEHICLE CRASH.
Remedy
DEALERS WILL INCREASE THE REAR BRAKE DELIVERY LINES AND THE REAR BRAKE SIGNAL LINE.
No complaints found for this vehicle.
Technical Service Bulletins — 1998 NEW FLYER C35LF
7 manufacturer communications from 5 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 2 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 2 |
| 062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM | 1 |
| 060000 ENGINE AND ENGINE COOLING | 1 |
| 060000 ENGINE (PWS) | 1 |
SMB191
May 6, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Service Manual Bulletin - Changes to Cummins ISLG and L9N engine oil specifications and oil change intervals.
SMB191
May 6, 2020
060000 ENGINE (PWS)
Service Manual Bulletin - Changes to Cummins ISLG and L9N engine oil specifications and oil change intervals.
TSIB 20-01
Apr 3, 2020
060000 ENGINE AND ENGINE COOLING
Technical Service Information Bulletin describing changes to the Cummins ISLG, L9N, ISB6.7G and B6.7N engine oil specifications.
PMB049
Jan 5, 2018
350000 EQUIPMENT
This Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg brake and accelerator assembly on specifically equipped vehicles.
SMB178
Jan 5, 2018
350000 EQUIPMENT
This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
SMB178
Jan 5, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
1571A
Jul 11, 2001
062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM
SUBJECT REGARDING ADDITIONAL NEWFLYER SERVICE MANUAL MAINTENANCE INSTRUCTIONS FOR SERVICING THE HYDRAULIC FAN DRIVE PUMP (PERMCO) AND POWER STEERING PUMP (VICKERS) ON A D30LF, D35LF, D40LF, C30LF, C35LF, C40LF COACHES WITH A CUMMINS 8.3 ENG
NEW FLYER C35LF — All Years Overview
Complete safety history for the NEW FLYER C35LF across all model years (1996–2009).
44
Total Recalls
0
Total Complaints
0
Investigations
0
Reported Crashes
0
Reported Fires
0
Reported Deaths
NEW FLYER C35LF — Year by Year
Compare recalls and complaints across model years. Click any year to see full details.