2005 MAZDA MPV
3 recalls, 45 complaints - 142 TSBs
19V781000 Oct 31, 2019
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Defect Description
Mazda North American Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2004-2005 MPV, 2004 RX-8, and 2006-2007 Mazdaspeed6 vehicles. These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may e... Read more
Consequence
An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy
Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. The recall began December 3, 2019. Owners may contact Mazda customer service at 1-800-222-55... Read more
18V402000 Jun 15, 2018
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Defect Description
Mazda North America Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2006-2007 Mazdaspeed6 and 2004 MPV vehicles nationwide. Mazda is also recalling 2005-2006 MPV vehicles in Alabama, Arizona, Arkansas, California, Delaware, the District of Columbia, Florida, Georgia, Hawaii, Illinois, Ind... Read more
Consequence
An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy
Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. The recall began July 6, 2018. Mailing to the affected RX-8 owners began July 6, 2019. ... Read more
18V404000 Jun 15, 2018
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Defect Description
Mazda North America Operations (Mazda) is recalling certain 2005-2006 Mazda MPV vehicles sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakot... Read more
Consequence
An inflator explosion may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy
Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. The recall began July 6, 2018 for MPV vehicles. The recall began July 9, 2019 for RX-8 vehicles. Owners may contact Mazda customer service at 1-800-222-5500, option ... Read more
Complaint Statistics
45 total complaints
4 crashes 8 injuries
Top Reported Components
| Component | Complaints |
|---|---|
| AIR BAGS | 9 |
| ENGINE | 6 |
| ENGINE AND ENGINE COOLING | 4 |
| SEAT BELTS:FRONT | 3 |
| ELECTRICAL SYSTEM | 3 |
| SUSPENSION | 2 |
| SERVICE BRAKES | 2 |
| STRUCTURE:BODY:DOOR | 2 |
| ENGINE AND ENGINE COOLING:ENGINE | 2 |
| UNKNOWN OR OTHER | 1 |
SUSPENSION
Jan 16, 2024
Incident date: Jul 30, 2023
Drivers side lower control arm was rusted off rear subframe causing vehicle to be inoperable.
AIR BAGS
May 20, 2022
Incident date: Mar 1, 2022
Takata recall. The contact owns a 2005 Mazda MPV. The contact received notification of NHTSA Campaign Number: 18V404000 (Air Bags) however, the nearest dealer location was nearly 5 hours away. The manufacturer was notified of the issue and attempted to send a mechanic from the dealer to the residenc... Read more
SERVICE BRAKES
May 28, 2018
Incident date: May 28, 2018
I WAS COMING HOME FROM WORK DOING THE SPEED LIMIT AND MY CAR WOULD NOT STOP I PRESS THE BRAKE ALL THE WAY TO THE FLOOR AND IT STILL DID NOT STOP I PULLED UP MY EMERGENCY BRAKE AND THAT DID NOT WORK SO FINALLY I GOT THE CAR TO STOP BECAUSE I KEPT PUMPING THE BRAKES AND THE CAR STARTED SLOWING DOWN A... Read more
UNKNOWN OR OTHER
Dec 13, 2017
Incident date: Jun 30, 2016
DOS NOTE TUN ON CHECKLIGHT.ENGINE WENT OUT RUNNING ANDE DOS NOTE GIVE CONDE.TRIED WIHT OTHER ECU ANDE HACE THE DAME.
ENGINE
Dec 6, 2017
Incident date: Dec 6, 2017
ENGINE STALLS OR SHUT DOWN COMPLETELY WHEN AUTO MOVES FROM HIGH SPEED TO LOW SPEED. MAZDA 6 W/ 3.0 LITER ENGINE, WHICH IS THE SAME ENGINE AS THIS UNIT, HAS A SIMILAR ISSUE - SEE HERE: HTTP://WWW.6CREW.COM/FILES/TSB/01-016-06-2135.PDF THIS IS HAPPENING PERSISTENTLY FOR THE LAST 2 YEARS.
STRUCTURE:BODY:DOOR
Sep 12, 2017
Incident date: May 29, 2017
TL* THE CONTACT OWNS A 2005 MAZDA MPV. THE CONTACT STATED THAT THE FRONT PASSENGER AND DRIVER SIDE DOORS FAILED TO OPEN FROM THE INSIDE. THE CONTACT HAD TO OPEN THE WINDOWS TO OPEN THE DOORS FROM THE OUTSIDE HANDLE. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER FOR DIAGNOSTIC TESTIN... Read more
AIR BAGS
Jul 21, 2017
Incident date: Dec 15, 2016
TL* TAKATA RECALL. THE CONTACT OWNS A 2005 MAZDA MPV. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS). THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT SPOKE ... Read more
STRUCTURE:BODY
May 11, 2017
Incident date: Apr 1, 2017
TL* THE CONTACT OWNS A 2005 MAZDA MPV. WHILE THE VEHICLE WAS STATIONARY, THE FRAME OF THE VEHICLE IN FRONT OF THE REAR WHEELS WAS RUSTED AND SEVERELY CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 79,473.
ELECTRICAL SYSTEM
Mar 13, 2017
Incident date: May 25, 2016
TL* TAKATA RECALL. THE CONTACT OWNS A 2005 MAZDA MPV. THE CONTACT STATED THAT THERE WAS A RANDOM FAILURE AND VARIOUS WARNING INDICATORS FLASHED, INCLUDING THE SERVICE ENGINE AND AIR BAG WARNING INDICATORS. IN ADDITION, THE INTERIOR LIGHTING FAILED TO FUNCTION. THE CONTACT RECEIVED NOTIFICATION OF NH... Read more
AIR BAGS
Mar 13, 2017
Incident date: May 25, 2016
TL* TAKATA RECALL. THE CONTACT OWNS A 2005 MAZDA MPV. THE CONTACT STATED THAT THERE WAS A RANDOM FAILURE AND VARIOUS WARNING INDICATORS FLASHED, INCLUDING THE SERVICE ENGINE AND AIR BAG WARNING INDICATORS. IN ADDITION, THE INTERIOR LIGHTING FAILED TO FUNCTION. THE CONTACT RECEIVED NOTIFICATION OF NH... Read more
ENGINE
Mar 13, 2017
Incident date: May 25, 2016
TL* TAKATA RECALL. THE CONTACT OWNS A 2005 MAZDA MPV. THE CONTACT STATED THAT THERE WAS A RANDOM FAILURE AND VARIOUS WARNING INDICATORS FLASHED, INCLUDING THE SERVICE ENGINE AND AIR BAG WARNING INDICATORS. IN ADDITION, THE INTERIOR LIGHTING FAILED TO FUNCTION. THE CONTACT RECEIVED NOTIFICATION OF NH... Read more
INTERIOR LIGHTING
Mar 13, 2017
Incident date: May 25, 2016
TL* TAKATA RECALL. THE CONTACT OWNS A 2005 MAZDA MPV. THE CONTACT STATED THAT THERE WAS A RANDOM FAILURE AND VARIOUS WARNING INDICATORS FLASHED, INCLUDING THE SERVICE ENGINE AND AIR BAG WARNING INDICATORS. IN ADDITION, THE INTERIOR LIGHTING FAILED TO FUNCTION. THE CONTACT RECEIVED NOTIFICATION OF NH... Read more
AIR BAGS
Feb 9, 2017
Incident date: Oct 31, 2016
IN AUGUST OF 2016 RECEIVED A NOTICE FROM MAZDA STATING MAZDA DECIDED THAT A DEFECT WHICH RELATES TO MOTOR VEHICLE SAFETY EXISTS IN MAZDA 2005 MPV. THE RECALL NOTICE CONTINUES TO STATE DO NOT DRIVE THE VEHICLE BECAUSE HIGH LEVELS OF HUMIDITY CAN CAUSE THE PASSENGER FRONTAL AIR BAG TO RUPTURE AND COUL... Read more
AIR BAGS
Nov 2, 2016
Incident date: May 15, 2016
TAKATA RECALL HAS AFFECTED MY VEHICLE AND AFTER 7 MONTHS THE COMPANY NOR THE LOCAL DEALERSHIP HAS DONE ANYTHING TO ADDRESS THE DEFECTIVE PART. WE HAVE BEEN NOTIFIED TO NOT ALLOW ANYONE TO RIDE IN THE PASSENGER SIDE OF THE VEHICLE AND THIS IS TERRIBLY OBSTRUCTIVE TO OUR TRANSPORTATION NEEDS. I BELIEV... Read more
AIR BAGS
Oct 13, 2016
Incident date: Aug 1, 2016
TL* TAKATA RECALL. THE CONTACT OWNS A 2005 MAZDA MPV. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS). THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTU... Read more
SUSPENSION
Sep 1, 2016
Incident date: Dec 12, 2005
MY VEHICLE IS UNDER NATIONAL RECALL HIGHWAY SAFETY RECALL, DUE TO MANUFACTURING ISSUES. I NEED TO TRADE MY VEHICLE IN AND I'M BEING OVER CHARGED FOR VEHICLES THAT ARE NOT WORRY TO BE ON THE HIGHWAY. I FEEL I SHOULD GET AN MANUFACTURE DISCOUNT ON AN USED/NEW VEHICLE BECAUSE I SHOULD NOT HAVE TO PAY F... Read more
SERVICE BRAKES
Sep 1, 2016
Incident date: Dec 12, 2005
MY VEHICLE IS UNDER NATIONAL RECALL HIGHWAY SAFETY RECALL, DUE TO MANUFACTURING ISSUES. I NEED TO TRADE MY VEHICLE IN AND I'M BEING OVER CHARGED FOR VEHICLES THAT ARE NOT WORRY TO BE ON THE HIGHWAY. I FEEL I SHOULD GET AN MANUFACTURE DISCOUNT ON AN USED/NEW VEHICLE BECAUSE I SHOULD NOT HAVE TO PAY F... Read more
AIR BAGS
Sep 1, 2016
Incident date: Dec 12, 2005
MY VEHICLE IS UNDER NATIONAL RECALL HIGHWAY SAFETY RECALL, DUE TO MANUFACTURING ISSUES. I NEED TO TRADE MY VEHICLE IN AND I'M BEING OVER CHARGED FOR VEHICLES THAT ARE NOT WORRY TO BE ON THE HIGHWAY. I FEEL I SHOULD GET AN MANUFACTURE DISCOUNT ON AN USED/NEW VEHICLE BECAUSE I SHOULD NOT HAVE TO PAY F... Read more
AIR BAGS
Aug 15, 2016
Incident date: May 25, 2016
TL* TAKATA RECALL. THE CONTACT OWNS A 2005 MAZDA MPV. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS). THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTU... Read more
WHEELS
Jul 27, 2015
Incident date: Jul 23, 2015
WHEN LOOKING AT MY VEHICLE, I NOTICED GREASE STREAKS DRIPPING FROM A LINE ON MY ALLOY WHEEL. AFTER CLEANING THE GREASE OFF, WE NOTICED A CRACK COMPLETELY THROUGH THE SPOKES ON MY RIM. THIS IS THE SECOND TIME THIS HAS OCCURRED TO MY VEHICLE SINCE WE BOUGHT IT BUT I WAS TOLD THERE IS NOT A PATTERN OF ... Read more
AIR BAGS
Nov 12, 2014
Incident date: Nov 3, 2014
MY VEHICLE IS LISTED IN THE OCT 22, 2014 NHTSA PRESS RELEASE AS BEING INCLUDED IN THE TAKATA AIRBAG RECALL. I CONTACTED MAZDA CUSTOMER EXPERIENCE (800) 222-5500 ON OCT 23 BUT, AFTER A FEW DAYS, I WAS TOLD THAT MY VEHICLE IS NOT ON THEIR DATABASE AND THAT I SHOULD CONTACT THE DEALER IN GUAM, TRIPLE J... Read more
ENGINE
May 22, 2014
Incident date: May 21, 2014
VEHICLE IS MANIFESTING ROUGH IDLE WHEN TURNED-ON WITH CHECK ENGINE LIGHT ON AND/OR FLASHING. ENGINE AND VEHICLE IS JERKING INTERMITTENTLY WHEN DRIVING AT ANY SPEED. THE VEHICLE WAS REPAIRED LAST YEAR THROUGH DEALERSHIP BUT THIS KEPT HAPPENING FOR THE THIRD TIME WITHIN A YEAR. DEALERSHIP INDICATED ... Read more
ELECTRICAL SYSTEM
Feb 16, 2013
Incident date: Jun 1, 2009
THE IDLE AIR CONTROL VALVE ON THESE VANS IS SERIOUSLY FLAWED AND IS PRONE TO FAILURE WHICH STALLS THE ENGINE AND PUTS OCCUPANTS IN PERIL AT HIGH RATES OF SPEED WITHOUT POWER BRAKING OR STEERING. ONCE STALLED, THE ENGINE CAN OFTEN FAIL TO RESTART, LEAVING THE DRIVER UNPREPARED AND PARALYZED TO REACT.... Read more
FUEL/PROPULSION SYSTEM
Feb 16, 2013
Incident date: Jun 1, 2009
THE IDLE AIR CONTROL VALVE ON THESE VANS IS SERIOUSLY FLAWED AND IS PRONE TO FAILURE WHICH STALLS THE ENGINE AND PUTS OCCUPANTS IN PERIL AT HIGH RATES OF SPEED WITHOUT POWER BRAKING OR STEERING. ONCE STALLED, THE ENGINE CAN OFTEN FAIL TO RESTART, LEAVING THE DRIVER UNPREPARED AND PARALYZED TO REACT.... Read more
ENGINE
Feb 16, 2013
Incident date: Jun 1, 2009
THE IDLE AIR CONTROL VALVE ON THESE VANS IS SERIOUSLY FLAWED AND IS PRONE TO FAILURE WHICH STALLS THE ENGINE AND PUTS OCCUPANTS IN PERIL AT HIGH RATES OF SPEED WITHOUT POWER BRAKING OR STEERING. ONCE STALLED, THE ENGINE CAN OFTEN FAIL TO RESTART, LEAVING THE DRIVER UNPREPARED AND PARALYZED TO REACT.... Read more
ENGINE
Jun 5, 2012
Incident date: Oct 27, 2011
I WAS WAITING TO MAKE A LEFT TURN INTO MY DRIVE WAY, WAITING TO CLEAR ONCOMING TRAFFIC. WHEN THE ONCOMING TRAFFIC WAS CLEARED, I FOUND A GAP BEFORE THE NEXT CAR COMES MY WAY AND I DECIDED IT WAS SAFE TO MAKE A LEFT TURN. I TURNED THE WHEELS OF MY MAZDA MPV , BUT CAR WENT STALLED, IT WOULD NOT MOVE. ... Read more
ENGINE
Jun 5, 2012
Incident date: Apr 16, 2012
I WAS DRIVING AT A VERY LOW SPEED IN HEAVY TRAFFIC . LANE NEXT TO ME STARTED MOVING, SO I DECIDED TO CHANGE LANE, FIND A EMPTY SPACE BETWEEN 2 VEHICLES AND DECIDED TO MAKE A TURN. MY MAZDA STALLED , AND DID NOT MOVE. I HAD TO PUT IT BACK TO "PARK", STOP THE CAR, AND RESTART, AFTER THAT IT RAN OK. A... Read more
ELECTRICAL SYSTEM
Feb 17, 2012
Incident date: Feb 10, 2009
WE OWN A 2005 MAZDA MPV. FOUR YEARS AFTER PURCHASING, THE VEHICLE STARTED TO SHAKE CONTINUOUSLY AND THE CHECK ENGINE LIGHT TURNED ON. ALSO WHEN GOING UPHILL IT ALMOST CAN' T MAKE IT TO THE TOP. AFTER TAKING IT TO THE MECHANIC IT TURNS OUT THE ENGINE WAS MISFIRING DUE A BAD IGNITION COIL. WE REPLACED... Read more
ENGINE AND ENGINE COOLING
Aug 16, 2010
Incident date: Aug 10, 2008
MY MAZDA 2005 MPV VAN ENGINE SHUTS DOWN COMPLETELY WHEN SLOWING DOWN, SLOWING AROUND CORNERS AND SITTING AT RED LIGHTS. THERE DOES NOT SEEM TO ANY SPUDDERING OR ANYTHING ENGINE RUNS GREAT. LOSS OF STEERING IS THE BIGGEST ISSUE WHEN ENGINE CUTS OFF. I HAVE SEEN A BUNCH OF OTHER COMPLAINTS ABOUT THE S... Read more
ENGINE AND ENGINE COOLING:ENGINE
Jul 13, 2010
Incident date: Jul 13, 2010
TL* THE CONTACT OWNS A 2005 MAZDA MPV. THE CONTACT STATED WHEN TRAVELING AT 15-35 MPH, THE VEHICLE WOULD STALL WITHOUT WARNING. IN ADDITION, THERE WAS AN ABNORMAL KNOCKING SOUND COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER FOUR TIMES WHERE THE ENGINE COIL WAS REPLACED EACH TIME. THE ... Read more
ENGINE AND ENGINE COOLING
May 12, 2010
Incident date: May 6, 2010
WE OWN A 2005 MAZDA MPV. TWO YEARS AFTER PURCHASING THE VEHICLE IT STARTED TO SHAKE AND JERK AS IF IT WANTED TO TURN OFF, AFTER TAKING IT TO THE DEALERSHIP IT TURNS OUT THE ENGINE WAS MISFIRING DUE AN IGNITION COIL GIVING OUT. NINE MONTHS LATER IT HAPPENS AGAIN. THIS TIME THEY REPLACED ALL 6 SIX... Read more
AIR BAGS:FRONTAL
Feb 26, 2010
Incident date: Feb 21, 2010
TL*THE CONTACT OWNS A 2005 MAZDA MPV. THE VEHICLE WAS TRAVELING 40 MPH WHEN THE VEHICLE SLID ON THE ICE AND CRASHED INTO THE MEDIAN ONTO THE HIGHWAY. THE AIR BAGS DID NOT DEPLOY. THIS WAS THE ONLY TIME THAT THE VEHICLE HAD BEEN INVOLVED IN A CRASH. THE MANUFACTURER TOLD THE CONTACT THAT THERE WAS N... Read more
Crash
1 injured
EQUIPMENT:APPLIANCE:AIR CONDITIONER
Sep 28, 2009
Incident date: Sep 21, 2009
TL*THE CONTACT OWNS A 2005 MAZDA MPV. THE CONTACT STATED THAT THE AIR CONDITIONER SYSTEM IMPROPERLY DISTRIBUTES AIR. AS A CONSEQUENCE, AN EXCESSIVE AMOUNT OF AIR OR HEAT WAS CIRCULATED THROUGHOUT THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER, AND A TECHNICIAN WAS IN THE PROCESS OF REPLACING THE ... Read more
ENGINE AND ENGINE COOLING
Aug 20, 2008
Incident date: Jun 16, 2008
AT 38,000 MILES, THE VAN STARTED TO HAVE INTERMITTENT HESITATIONS THAT RANDOMLY OCCURRED. I NEEDED TO REPLACE ALL IGNITION COILS AT A COST IN EXCESS OF $600. *TR
ENGINE AND ENGINE COOLING:ENGINE
Aug 6, 2008
Incident date: Jul 10, 2008
WAS EXITING PARKWAY WEST WESTBOUND EXIT FOR ROUTE 22 IN PITTSBURGH FOR WEIRTON, WV; ENGINE SHUT OFF ON ITS OWN WHEN ENGINE WENT OUT OF OVERDRIVE AND INCREASED ITS RPMS AND I LET OFF OF GAS PEDAL TO BRAKE - LOST POWER STEERING AND BRAKES, MAINTAINED CONTROL, SHIFTED TO NEUTRAL, RESTARTED ENGINE - TRA... Read more
ENGINE AND ENGINE COOLING
Jul 9, 2008
Incident date: Jul 8, 2008
AFTER 60K MILES, MY VAN STARTED STALLING WHEN SLOWING DOWN OR SPEEDING UP. NOT EVERY TIME BUT OFTEN ENOUGH TO CONCERN MY SAFETY AND THE SAFETY OF MY CHILDREN. IT HAPPENED TWICE TODAY WITHIN 10 MILES FROM EACH INCIDENT. *TR
STRUCTURE:BODY:DOOR
Mar 4, 2008
Incident date: Feb 28, 2008
THE DRIVER'S SIDE POWER SLIDING DOOR RARELY WORKS. TYPICALLY IT OPENS 1-3 INCHES THEN STOPS AND BEEPS. IF I MANUALLY OPEN IT A FEW MORE INCHES THEN PRESS THE BUTTON AGAIN IT WORKS ON OCCASION, OTHER TIMES I MUST TURN OFF THE POWER TO MOVE IT AT ALL. IT IS A 2005 MPV WITH ONLY 22,500 MILES. A... Read more
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Mar 4, 2008
Incident date: Feb 28, 2008
THE DRIVER'S SIDE POWER SLIDING DOOR RARELY WORKS. TYPICALLY IT OPENS 1-3 INCHES THEN STOPS AND BEEPS. IF I MANUALLY OPEN IT A FEW MORE INCHES THEN PRESS THE BUTTON AGAIN IT WORKS ON OCCASION, OTHER TIMES I MUST TURN OFF THE POWER TO MOVE IT AT ALL. IT IS A 2005 MPV WITH ONLY 22,500 MILES. A... Read more
SEAT BELTS:FRONT
May 12, 2007
Incident date: Apr 14, 2006
SEAT BELT DID NOT HOLD US WHEN WE WERE HIT FROM BEHIND WHILE WAITING FOR A LEFT HAND TURN LIGHT. *AK
Crash
3 injured
PARKING BRAKE
Apr 16, 2007
Incident date: Mar 15, 2005
TL*THE CONTACT OWNS A 2005 MAZDA MPV. WHILE DRIVING AT ANY SPEED THE CONTACT HEARD A LOUD GRINDING NOISE WHILE DEPRESSING THE BRAKE. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT STATED THAT THE FAILURE OCCURRED SINCE THE VEHICLE WAS PURCHASED. THE GRINDING SOUND INTENSIFIED. THE V... Read more
SERVICE BRAKES, HYDRAULIC
Apr 16, 2007
Incident date: Mar 15, 2005
TL*THE CONTACT OWNS A 2005 MAZDA MPV. WHILE DRIVING AT ANY SPEED THE CONTACT HEARD A LOUD GRINDING NOISE WHILE DEPRESSING THE BRAKE. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT STATED THAT THE FAILURE OCCURRED SINCE THE VEHICLE WAS PURCHASED. THE GRINDING SOUND INTENSIFIED. THE V... Read more
SEAT BELTS:FRONT
Apr 9, 2007
Incident date: Apr 14, 2006
REFERRAL E-MAIL CONCERNING THE SEAT BELTS WHICH FAILED TO HOLD THEM WHEN THEY WERE STRUCK FROM BEHIND IN THEIR 2005 MAZDA MPV**CC *JB
Crash
2 injured
SEAT BELTS:FRONT
Dec 24, 2006
Incident date: Apr 14, 2006
MY NAME IS [XXX] . MY WIFE AND I WERE IN A CAR ACCIDENT ON 4/14/2006. WE WERE REAR ENDED BY A LADY GOING APPROXIMATELY 35 MPH. WE WERE STOPPED WAITING FOR A LEFT HAND LIGHT TO CHANGE. THE SEAT BELTS, MODEL # TK ABA H800 DID NOT HOLD US. MY WIFE HIT THE STEERING WHEEL AND I HIT THE DASH AND THROWN AR... Read more
Crash
2 injured
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW
Oct 7, 2006
Incident date: Sep 30, 2006
DRIVING 5 MPH ON ROAD, REAR DEFROSTER ON, REAR WINDOW SHATTERS FOR NO APPARENT REASON. CONTACTED THE DEALER, DEALER SAID WOULD CONTACT HEADQUARTERS TO GET APPROVAL TO REPLACE GLASS. DID REPLACE GLASS. FIRST THING THEY MENTIONED ASKED WHEN THEY HEARD THE REAR WINDOW SHATTERED WAS IF THE DEFROSTER HA... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
Apr 29, 2005
Incident date: Apr 23, 2005
TRANSMISSION FAILURE IN A 2002 MAZDA MPV VAN. THERE WAS ALWAYS ERRATIC SHIFTING ESPECIALLY WHEN ENGINE WAS COLD. AFTER IT WARMED UP IT SEEMED OK BUT DURING HIGHWAY DRIVING IF HAVING TO SUDDENLY ACCELERATE IT WOULD FEEL LIKE THE TRANSMISSION WOULD FOR LACK OF A BETTER DESCRIPTION "SLIP" BETWEEN GEAR ... Read more
EPA Fuel Economy, 2005 MAZDA MPV
| Trim / Engine | City MPG | Highway MPG | Combined MPG | Fuel Type | Annual Fuel Cost |
|---|---|---|---|---|---|
| 3.0L 6-cyl, Automatic 5-spd (Front-Wheel Drive) | 16.0 | 23.0 | 19.0 | Regular | $3,300 |
CO2 Emissions: -1.0 g/mile (Minivan - 2WD)
Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.
Technical Service Bulletins, 2005 MAZDA MPV
142 manufacturer communications from 97 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 30 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 12 |
| 110000 ELECTRICAL SYSTEM | 11 |
| 060000 ENGINE AND ENGINE COOLING | 8 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 8 |
| 140000 AIR BAGS | 7 |
| 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY | 5 |
| 100000 POWER TRAIN | 5 |
SA-011-24
Feb 12, 2024
010000 STEERING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
SA-011-24
Feb 12, 2024
030000 SERVICE BRAKES, HYDRAULIC
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
SA-011-24
Feb 12, 2024
060000 ENGINE AND ENGINE COOLING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
SA-011-24
Feb 12, 2024
100000 POWER TRAIN
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
SA-011-24
Feb 12, 2024
190000 TIRES
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
SA-011-24
Feb 12, 2024
200000 WHEELS
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
09-016-23
Feb 28, 2023
110000 ELECTRICAL SYSTEM
Speedometer replacement procedure
09-016-23
Feb 28, 2023
117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
Speedometer replacement procedure
02-004-22a
Nov 18, 2022
020000 SUSPENSION
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
09-024-22
Jul 18, 2022
117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer.
01-006-22
Jun 22, 2022
110000 ELECTRICAL SYSTEM
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in st
02-004-22
May 24, 2022
020000 SUSPENSION
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
SA-014-22
Mar 29, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Accessory instructions can be found on OneMazda under Dealer Resources - Parts & Accessories.
01-003/22
Mar 17, 2022
110000 ELECTRICAL SYSTEM
The Mazda DCA-8000 is required for all warranty battery testing. If the Mazda DCA-8000 is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to test
01-003/22
Mar 17, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
The Mazda DCA-8000 is required for all warranty battery testing. If the Mazda DCA-8000 is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to test
00-001-22
Feb 23, 2022
010000 STEERING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
00-001-22
Feb 23, 2022
030000 SERVICE BRAKES, HYDRAULIC
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
00-001-22
Feb 23, 2022
060000 ENGINE AND ENGINE COOLING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
00-001-22
Feb 23, 2022
100000 POWER TRAIN
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
01-006-21-3779b
Dec 21, 2021
110000 ELECTRICAL SYSTEM
Battery Maintenance: This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost.
05-002-21-3854
Dec 8, 2021
100000 POWER TRAIN
Automatic Transmission/Transaxle Cooler and Lines Flushing Procedure: Automatic Transaxle/Transmission (A/T) oil cooler and lines must be power flushed completely before an overhauled or replacement A/T is installed (except SKYACTIV-DRIVE)
01-006-21-3779a
Aug 24, 2021
060000 ENGINE AND ENGINE COOLING
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in sto
01-006-21-3779a
Aug 24, 2021
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in sto
09-025-21-3824
Aug 17, 2021
350000 EQUIPMENT
This service bulletin provides information regarding the proper use of the driver??A?A?s floor mat to avoid any potential interference with the foot pedals. The following are possible causes of floor mat interference, which can be avoided w
SA-041-21
Jun 9, 2021
350000 EQUIPMENT
Accessory instructions can be found on OneMazda under Dealer Resources - Parts & Accessories. The links provided below can be used for quick access: For 2016 models and newer: NOTE: Instructions are found under the "Attachments" section onc
SSPB3
May 5, 2021
140000 AIR BAGS
Subject: ** UPDATE** - Takata Inflator Special Service Program (Extended Warranty) Special Service Program SSPB3: In December 2017 Special Service Program SSPB3 - Takata Inflator Extended Warranty was announced. The extended warranty was a
01-005-21-3778
Feb 8, 2021
110000 ELECTRICAL SYSTEM
The Mazda DCA-8000PM is required for all warranty battery testing. If the Mazda DCA-8000PM is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to t
01-006-21-3779
Feb 8, 2021
110000 ELECTRICAL SYSTEM
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in sto
07-001-21-3775
Jan 26, 2021
350000 EQUIPMENT
A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/C evaporator/cooling unit which is
00-001-21-3768
Jan 21, 2021
010000 STEERING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-21-3768
Jan 21, 2021
060000 ENGINE AND ENGINE COOLING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-21-3768
Jan 21, 2021
100000 POWER TRAIN
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-21-3768
Jan 21, 2021
200000 WHEELS
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
09-002-21-3770
Jan 21, 2021
110000 ELECTRICAL SYSTEM
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
09-002-21-3770
Jan 21, 2021
180000 VEHICLE SPEED CONTROL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
09-002-21-3770
Jan 21, 2021
350000 EQUIPMENT
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
MT-002-20
Aug 3, 2020
199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
New CARB regulation regarding mandatory checking and documenting of tire pressure whenever a vehicle is in for service work. This applies to all service shops (including Mazda dealerships) in California effective September 1, 2010.
MT-002-20
Aug 3, 2020
200000 WHEELS
New CARB regulation regarding mandatory checking and documenting of tire pressure whenever a vehicle is in for service work. This applies to all service shops (including Mazda dealerships) in California effective September 1, 2010.
09-006-20-3673a
Jul 20, 2020
350000 EQUIPMENT
When encountering a vehicle with paint damage, refer to the "Mazda Paint Warranty Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
00-001-20-3689
Mar 12, 2020
030000 SERVICE BRAKES, HYDRAULIC
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-20-3689
Mar 12, 2020
060000 ENGINE AND ENGINE COOLING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-20-3689
Mar 12, 2020
100000 POWER TRAIN
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-20-3689
Mar 12, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
09-006-20-3673
Jan 13, 2020
350000 EQUIPMENT
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable). Copies of the Mazda Pocket Paint Guide are available for order on Mazda e-
02-002-20-3651
Jan 9, 2020
020000 SUSPENSION
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
02-002-20-3651
Jan 9, 2020
350000 EQUIPMENT
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
02-002-20-3651
Jan 9, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
09-003-20-3671
Jan 9, 2020
110000 ELECTRICAL SYSTEM
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer??A?A?s responsibility
09-003-20-3671
Jan 9, 2020
350000 EQUIPMENT
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer??A?A?s responsibility
07-002-19-3616a
Dec 17, 2019
350000 EQUIPMENT
A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/C evaporator/cooling unit which is
07-002-19-3616a
Dec 17, 2019
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/C evaporator/cooling unit which is
07-002-19-3616a
Dec 17, 2019
356000 EQUIPMENT ADAPTIVE/MOBILITY
A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/C evaporator/cooling unit which is
07-002-19-3616
Jul 16, 2019
350000 EQUIPMENT
A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/C evaporator/cooling unit which is
07-002-19-3616
Jul 16, 2019
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/C evaporator/cooling unit which is
SA-013-19
Apr 1, 2019
350000 EQUIPMENT
MAZDA IDS INOPERATIVE WITH VCM-II LICENSE EXPIRATION MESSAGE - If you encounter an IDS inoperative problem with VCM-II license expiration message, follow the instructions below: 1. CLICK HERE to download the resetting tool to your PC deskto
00-003-19-3583
Mar 20, 2019
060000 ENGINE AND ENGINE COOLING
In support of the new MRT distribution, Mazda will ship to dealers a new Dual Purpose Diagnostic Leak Detector beginning March, 2019. Training videos will be posted to MGSS shortly and Workshop Manual procedures will be revised gradually.
00-003-19-3583
Mar 20, 2019
070000 FUEL SYSTEM, GASOLINE
In support of the new MRT distribution, Mazda will ship to dealers a new Dual Purpose Diagnostic Leak Detector beginning March, 2019. Training videos will be posted to MGSS shortly and Workshop Manual procedures will be revised gradually.
00-003-19-3583
Mar 20, 2019
081100 FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
In support of the new MRT distribution, Mazda will ship to dealers a new Dual Purpose Diagnostic Leak Detector beginning March, 2019. Training videos will be posted to MGSS shortly and Workshop Manual procedures will be revised gradually.
00-003-19-3583
Mar 20, 2019
350000 EQUIPMENT
In support of the new MRT distribution, Mazda will ship to dealers a new Dual Purpose Diagnostic Leak Detector beginning March, 2019. Training videos will be posted to MGSS shortly and Workshop Manual procedures will be revised gradually.
00-001-19-3560
Jan 14, 2019
350000 EQUIPMENT
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle- specific workshop manual or owner's man
00-002-19-3561
Jan 14, 2019
030000 BRAKES (PWS)
Mazda North American Operations has approved an additional on-car brake lathe as an option for MNAO authorized equipment. The Pro-Cut On-Car Brake Lathe has been added to the MNAO authorized equipment program. NOTE: Accu-turn is still an ap
09-005-19-3562
Jan 14, 2019
350000 EQUIPMENT
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable). Copies of the Mazda Pocket Paint Guide are available for order on Mazda e-
09-009-19-3566
Jan 14, 2019
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to co
08-001-19-3544
Jan 10, 2019
140000 AIR BAGS
This information is provided to help address Passenger Airbag Deactivation (PAD) Indicator illumination concerns during vehicle service.
09-004-19-3543
Jan 10, 2019
350000 EQUIPMENT
Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. Some components require prior authorization before ordering as exchange. Refer to DAG Exchange Central (MXConne
01-004-19-3558
Jan 9, 2019
060000 ENGINE AND ENGINE COOLING
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. The odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. Sulfur smell is not a
09-002-19-3554
Jan 3, 2019
356000 EQUIPMENT ADAPTIVE/MOBILITY
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid anypotential interference with the foot pedals. The following are possible causes of floor mat interference,which can be avoided with pro
01-001-19-3551
Jan 2, 2019
110000 ELECTRICAL SYSTEM
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in sto
01-002-19-3552
Jan 2, 2019
110000 ELECTRICAL SYSTEM
The Mazda GR8-1291 is required for all warranty battery testing. If the Mazda GR8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to test
02-001-19-3550
Jan 2, 2019
020000 SUSPENSION
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
MT-012-18
Dec 11, 2018
010000 STEERING
If a vehicle has body vibration or steering wheel shimmy while driving and the root cause is determined to be tire balance, re-balance the tires using a Hunter GSP9700 or equivalent balance machine. If your dealer does not have a GSP9700 or
MT-012-18
Dec 11, 2018
162000 STRUCTURE:BODY
If a vehicle has body vibration or steering wheel shimmy while driving and the root cause is determined to be tire balance, re-balance the tires using a Hunter GSP9700 or equivalent balance machine. If your dealer does not have a GSP9700 or
00-001-18-3446a
Oct 10, 2018
350000 EQUIPMENT
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle- specific workshop manual or owner's man
00-001-18-3446a
Oct 10, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle- specific workshop manual or owner's man
00-003-18-3480a
Oct 10, 2018
030000 SERVICE BRAKES, HYDRAULIC
Mazda North American Operations has approved an additional on-car brake lathe as an option for MNAO authorized equipment. The Pro-Cut On-Car Brake Lathe has been added to the MNAO authorized equipment program. NOTE: Accu-turn is still an ap
00-003-18-3480a
Oct 10, 2018
350000 EQUIPMENT
Mazda North American Operations has approved an additional on-car brake lathe as an option for MNAO authorized equipment. The Pro-Cut On-Car Brake Lathe has been added to the MNAO authorized equipment program. NOTE: Accu-turn is still an ap
09-014-18-3443a
Oct 10, 2018
160000 STRUCTURE
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable). Copies of the Mazda Pocket Paint Guide are available for order on Mazda e-
09-014-18-3443a
Oct 10, 2018
350000 EQUIPMENT
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable). Copies of the Mazda Pocket Paint Guide are available for order on Mazda e-
09-034-18-3430a
Oct 10, 2018
180000 VEHICLE SPEED CONTROL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to co
09-034-18-3430a
Oct 10, 2018
350000 EQUIPMENT
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to co
01-016-18-3522
Sep 6, 2018
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. The odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. Sulfur smell is not a
09-034-18-3430
Aug 31, 2018
180000 VEHICLE SPEED CONTROL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to co
00-003-18-3480
May 11, 2018
030000 BRAKES (PWS)
Mazda North American Operations has approved an additional on-car brake lathe as an option for MNAOauthorized equipment. The Pro-Cut On-Car Brake Lathe has been added to the MNAO authorizedequipment program.NOTE: Accu-turn is still an appro
09-025-18-3479
May 11, 2018
350000 EQUIPMENT
Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. Some components require prior authorization before ordering as exchange. Refer to DAG Exchange Central (MXConne
09-025-18-3479
May 11, 2018
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
Mazda infotainment systems require contacting the proper source for diagnostic support, parts authorization, and parts exchange. Some components require prior authorization before ordering as exchange. Refer to DAG Exchange Central (MXConne
07-002-18-3432
Apr 16, 2018
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/Cevaporator/cooling unit which is c
08-001-18-3457
Apr 5, 2018
140000 AIR BAGS
This information is provided to help address Passenger Airbag Deactivation (PAD) Indicator illumination concerns during vehicle service.
09-019-18-3450
Mar 26, 2018
356000 EQUIPMENT ADAPTIVE/MOBILITY
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. The following are possible causes of floor mat interference, which can be avoided with p
01-008-18-3451
Mar 26, 2018
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in sto
01-009-18-3452
Mar 26, 2018
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
The Mazda GR8-1291 is required for all warranty battery testing. If the Mazda GR8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to test
02-006-18-3449
Mar 26, 2018
021300 SUSPENSION:FRONT:SHOCK ABSORBER
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
02-006-18-3449
Mar 26, 2018
022400 SUSPENSION:REAR:SHOCK ABSORBER
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
00-001-18-3446
Mar 22, 2018
350000 EQUIPMENT
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
09-014-18-3443
Mar 22, 2018
160000 STRUCTURE
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
SA-068-17
Sep 12, 2017
140000 AIR BAGS
STOPPER PLATES FOR AIR BAG MODULE CONNECTORS HAVE BEEN ESTABLISHED AS NEW SERVICE PARTS. When removing the connector (1) to the air bag module (2), make sure to first lift the stopper plate (3) carefully using a flathead screwdriver (but do
09-035-17-3080
Aug 7, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer?s responsibility to co
09-035-17-3080
Aug 7, 2017
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer?s responsibility to co
SA-061-17
Jul 12, 2017
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
In an effort to achieve a higher level of Customer Experience and retain the value of Mazda's vehicles, MNAO Warranty Operations is? 2017 Mazda North American Operations, U.S.A. allowing all Mazda dealers to utilize a third party, SPECMO En
00-004-16-3237
Aug 11, 2016
350000 EQUIPMENT
RAISING A VEHICLE WITH A JACK CAN BE DANGEROUS IF NOT DONE PROPERLY. THE VEHICLE CAN SLIP OFF THE JACK AND SERI-OUSLY INJURE SOMEONE. IN THIS SERVICE INFORMATION, SOME IMPORTANT WARNINGS AND CAUTIONS HAVE BEEN TAKEN FROM THE OWNER?S MANUAL.
SA327
Jul 28, 2016
140000 AIR BAGS
TAKATA RECALLS GENERAL INFORMATION PURPOSE: THIS PAGE WAS CREATED TO ASSIST WITH HANDLING TAKATA AIR BAG RECALLS. PROCESSES: PLEASE USE THESE PROCESS FLOWCHARTS TO PROPERLY HANDLE VEHICLES SUBJECT TO THE TAKATA AIR BAG RECALL. RECALL 82
Showing 100 of 142 bulletins.
NHTSA Safety Investigations, MAZDA MPV
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
EA96031
Opened: Dec 20, 1996 , Closed: Mar 31, 1998
FUEL LIQUID-VAPOR SEPARATOR
EVAPORATIVE EMISSIONS CONTROL SYSTEM LIQUID-VAPOR SEPARATOR MAY FAIL AT NIPPLE FOR FUEL TANK HOSE CONNECTION RESULTING IN FUEL LEAKAGE IN THE AREA BEHIND THE RIGHT REAR TRIM PANEL.
PE96055
Opened: Sep 13, 1996 , Closed: Dec 20, 1996
FUEL LIQUID-VAPOR SEPARATOR FAILURE
RATORS AREEVAPORATIVE EMISSIONS CONTROL SYSTEM LIQUID-VAPOR SEPARATORS ARE ALLEGEDLY FAILING AND LEAKING FUEL LIQUID/VAPOR.
EA92008
Opened: Feb 3, 1992 , Closed: Mar 16, 1992
INCONSIST.BRK PERFORMANCE
There is no summary currently available
PE91134
Opened: Oct 1, 1991 , Closed: Feb 3, 1992
INCONSISTENT BRAKE PERFORM
===
MAZDA MPV - All Years Overview
Complete safety history for the MAZDA MPV across all model years (1989, 2006).
44
Total Recalls
1,157
Total Complaints
4
Investigations
129
Reported Crashes
27
Reported Fires
0
Reported Deaths
MAZDA MPV - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2006 | 2 | 16 | View |
| 2005 (current) | 3 | 45 | |
| 2004 | 5 | 84 | View |
| 2003 | 4 | 141 | View |
| 2002 | 4 | 143 | View |
| 2001 | 3 | 82 | View |
| 2000 | 5 | 184 | View |
| 1999 | 0 | 2 | View |
| 1998 | 1 | 26 | View |
| 1997 | 1 | 27 | View |
| 1996 | 1 | 21 | View |
| 1995 | 1 | 21 | View |
| 1994 | 1 | 41 | View |
| 1993 | 1 | 65 | View |
| 1992 | 1 | 95 | View |
| 1991 | 3 | 81 | View |
| 1990 | 3 | 55 | View |
| 1989 | 5 | 27 | View |