2002 MAZDA MPV
4 recalls, 143 complaints - 164 TSBs
04V234000 May 19, 2004
VEHICLE SPEED CONTROL:CABLES
Defect Description
ON CERTAIN MINIVANS EQUIPPED WITH CRUISE CONTROL, THE CRUISE CONTROL ACTUATOR CABLE MAY BE BROKEN DUE TO INSUFFICIENT STRENGTH (GROUP 1). ALSO INCLUDED ARE CERTAIN 2000-2001 MINIVANS EQUIPPED WITH CRUISE CONTROL BUILT BETWEEN MARCH 31, 1999 AND MARCH 31, 2001, THAT HAVE HAD THE CRUISE CONTROL REP... Read more
Consequence
IT IS POSSIBLE THAT THE BROKEN ACTUATOR CABLE MAY BE OUT OF POSITION AND COULD INTERFERE WITH THE OPERATION OF THE ACCELERATOR CABLE, PREVENTING A DECREASE IN ENGINE SPEED WHILE DRIVING, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPLACE THE ACTUATOR CABLE. OWNER NOTIFICATION FOR VEHICLES INVOLVED IN GROUP 1 BEGAN ON JULY 7, 2004. OWNER NOTIFICATION FOR VEHICLES INVOLVED IN GROUP 2 BEGAN ON SEPTEMBER 10, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500.
03V206000 Jun 5, 2003
EXTERIOR LIGHTING:FOG LIGHTS
Defect Description
ON CERTAIN MINI VANS AND PASSENGER VEHICLES, THE SOCKET HOLDER IN THE FOG LIGHTS IS INSTALLED IN THE LAMP CASING USING PRESSURE. DURING OPERATION OF THE FOG LIGHT, THE HEAT FROM THE BULB CAN EXPAND THE SOCKET HOLDER. THE EXPANSION CAN FORCE THE SOCKET HOLDER REARWARD. AFTER REPEATEDLY BEING SUBJE... Read more
Consequence
SHOULD THIS OCCUR, THE BULB SOCKET AND THE HARNESS CAN DROP INSIDE THE BUMPER AND POSSIBLY BUT RARELY, THE HEAT GENERATED BY THE BULB CAN CAUSE THE BUMPER TO BURN.
Remedy
DEALERS WILL INSTALL A SPRING TO PREVENT THE SOCKET HOLDER FROM SEPARATING FROM THE LAMP CASE. OWNER NOTIFICATION BEGAN ON JULY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTA... Read more
03V053000 Feb 13, 2003
EXTERIOR LIGHTING:FOG LIGHTS
Defect Description
ON CERTAIN MINI VANS EQUIPPED WITH FRONT FOG LIGHTS,THE FOG LIGHT BULB SOCKET MAY HAVE BEEN INSTALLED IMPROPERLY.
Consequence
IF THE VEHICLE CONTINUES TO BE USED WITH THIS CONDITION, THE BULB SOCKET AND THE WIRING HARNESS MAY SEPARATE FROM THE FOG LIGHT HOUSING IF EXPOSED TO SHOCK AND/OR VIBRATION AND DROP INSIDE THE BUMPER. SHOULD THIS OCCUR, THE OPERATION OF THE FOG LIGHT MAY THEN CAUSE THE BUMPER TO BURN.
Remedy
DEALERS WILL INSPECT THE INSTALLATION CONDITION OF THE FOG LIGHT BULB ASSEMBLY, AND REPAIR IT WHEN NECESSARY. OWNER NOTIFICATION BEGAN MARCH 31, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME ... Read more
02V078000 Mar 20, 2002
EQUIPMENT:OTHER:LABELS
Defect Description
CERTAIN MINI VANS FAIL TO COMPLY TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." AN INCORRECT GROSS AXLE WEIGHT RATING (GAWR) WAS INDICATED ON THE CERTIFICATION LABEL.
Remedy
OWNERS WILL BE MAILED ACCURATE CERTIFICATION LABELS AND INSERTS FOR THE OWNER'S MANUAL. OWNER NOTIFICATION BEGAN JUNE 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MAZDA AT 1... Read more
Complaint Statistics
143 total complaints
5 crashes 5 fires 7 injuries
Top Reported Components
| Component | Complaints |
|---|---|
| POWER TRAIN:AUTOMATIC TRANSMISSION | 53 |
| ENGINE AND ENGINE COOLING:EXHAUST SYSTEM | 9 |
| ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR | 7 |
| POWER TRAIN | 7 |
| ELECTRICAL SYSTEM:IGNITION | 6 |
| ENGINE AND ENGINE COOLING | 4 |
| VEHICLE SPEED CONTROL | 3 |
| POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL) | 2 |
| EXTERIOR LIGHTING:FOG LIGHTS | 2 |
| VEHICLE SPEED CONTROL:ACCELERATOR PEDAL | 2 |
ENGINE
Apr 28, 2015
Incident date: Apr 1, 2015
TL* THE CONTACT OWNS A 2002 MAZDA MPV. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE HESITATED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WOULD ALSO NOT ACCELERATE PROPERLY AND SHOOK WHILE IDLING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE ... Read more
SEAT BELTS
May 20, 2014
Incident date: May 16, 2014
THE DRIVERS SEATBELT CLASP OR BUCKLE REFUSES TO ACCEPT THE STEEL TAB, AND WILL NOT LOCK. *TR
ENGINE
Apr 18, 2014
Incident date: Apr 12, 2014
TL* THE CONTACT OWNS A 2002 MAZDA MPV. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO A DEALER WHO COULD NOT DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 122,000.
VEHICLE SPEED CONTROL
Apr 16, 2014
Incident date: Mar 30, 2014
TL* THE CONTACT OWNS A 2002 MAZDA MPV. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE ACTUATOR CABLE NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 04V234000 (VEHICLE SPEED CONTROL). THE VEHICL... Read more
POWER TRAIN
Jan 16, 2014
Incident date: Jan 7, 2014
TRANSMISSION FAILED, COMPLETELY DISENGAGED. NO WARNING. HAD TO BE TOWED. REQUIRED A $2500.00 COMPLETE OVERHAUL. VERY LOW MILES ON THIS VEHICLE, ALWAYS PROPERLY MAINTAINED. *TR
AIR BAGS
Aug 19, 2013
Incident date: Aug 1, 2013
2002 MAZDA MPV. CONSUMER WRITES IN REGARDS TO VEHICLE AIR BAG LIGHT BEING ON. *SMD THE CONSUMER WAS INFORMED HIS VEHICLE IDENTIFICATION NUMBER, WAS NOT INCLUDED IN THE RECALL.
POWER TRAIN
Aug 23, 2012
Incident date: Aug 22, 2012
DRIVING ON HIGHWAY WITH MY FAMILY WHEN MY MPV WOULDN'T SHIFT SO I COULD PASS A TRUCK. THEN IT STARTED TO LOSE SPEED. WOULD DEPRESS GAS PEDAL AND THE ENGINE WOULD REV BUT NO SPEED. HAD TO PULL OVER TO BREAKDOWN LANE WHICH BECAME A VERY DANGEROUS SITUATION. WE ARE LUCKY WE DIDN'T CAUSE AN ACCIDENT.... Read more
AIR BAGS
May 24, 2012
Incident date: Apr 22, 2012
TL* THE CONTACT OWNS A 2002 MAZDA MPV. WHILE TRAVELING 45 MPH THE VEHICLE CRASHED INTO THE SIDE OF ANOTHER VEHICLE. NONE OF THE AIRBAGS DEPLOYED. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS NOT INSPECTED FOR THE AIR BAG FAILURE OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 172,000. UPDA... Read more
Crash
POWER TRAIN
Mar 16, 2012
Incident date: Jul 1, 2008
TRANSMISSION FAILED IN 2008, HAD IT REPLACED AND IT FAILED AGAIN IN TWO WEEKS. VAN DROVE FINE UNTIL SUMMER 2011, WHEN I NOTICED TRANSMISSION PROBLEMS AGAIN. TOOK THE VAN TO A DEALERSHIP TO HAVE IT FIXED AGAIN, BUT WAS TOLD THERE WAS NOTHING WRONG WITH IT. FINALLY, ON 14 MARCH 2012, THE TRANSMISSI... Read more
VEHICLE SPEED CONTROL
Mar 13, 2012
Incident date: Mar 10, 2012
WAS DRIVING DOWN THE STREET WITH CRUISE CONTROL ON AND SET. COMING UP TO RED LIGHT. HIT CANCEL ON CRUISE LEVER AND IT DID NOT DISENGAGE. THE TURNED IT OFF WITH THE BUTTON. LIGHT WENT OFF BUT WAS STILL ENGAGED. I ALSO WAS APPLYING THE BRAKES IN A PANIC.....STILL NOT DISENGAGING. PUT CAR IN NEUT... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
Jun 20, 2011
Incident date: Jun 16, 2011
TL* THE CONTACT OWNS A 2002 MAZDA MPB. THE CONTACT STATED THAT HE WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE GEAR SELECTOR LEVER NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINC... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
Apr 4, 2011
Incident date: Apr 4, 2009
TL*THE CONTACT OWNS A 2002 MAZDA MPV. THE CONTACT STATED THAT THE TRANSMISSION HAD BEEN SLIPPING ON AND OFF FOR THE PAST TWO YEARS. THE VEHICLE WAS TAKEN TO A MECHANIC WHO STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAG... Read more
EXTERIOR LIGHTING
Feb 16, 2011
Incident date: Feb 16, 2011
I AM THE OWNER OF A 2002 MAZDA MPV WITH APPROXIMATELY 36,000 MILES . ON THE EVENING OF FEBRUARY 16, 2011 WHILE DRIVING HOME WITH MY DAUGHTER IN THE CAR THE RIGHT FOG LIGHT STARTED A FIRE IN THE BUMPER. THERE WAS A RECALL ISSUED FOR THIS MANY YEARS AGO FOR THIS EXACT PROBLEM. AT THE TIME OF THE RE... Read more
Fire
POWER TRAIN:AUTOMATIC TRANSMISSION
Oct 22, 2010
Incident date: Oct 8, 2010
I WAS DRIVING MY 2002 MAZDA MPV MINIVAN WITH 91,000 MILES ON IT ON THE FREEWAY AND WHEN I TRIED TO ACCELERATE, IT WOULD NOT SHIFT INTO HIGHER GEAR. IT SEEMED TO GO INTO NEUTRAL AND I BEGAN LOOSING SPEED. I HAVE DONE ALL MAINTENANCE AS WAS SUGGESTED IN THE HANDBOOK BY MAZDA. IN FACT, MAZDA HAS DONE A... Read more
EXTERIOR LIGHTING:FOG LIGHTS
Sep 23, 2010
Incident date: Sep 16, 2010
TL*THE CONTACT OWNS A 2002 MAZDA MPV. THE CONTACT STATED THAT WHILE DRIVING 5 MPH A PEDESTRIAN ADVISED THE CONTACT THAT THE LEFT FRONT BUMPER WAS ON FIRE. THE CONTACT PULLED OVER AND CALLED THE FIRE DEPARTMENT. THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE AND THEN TO THE INSURANCE COMPANY. THE DE... Read more
Fire
POWER TRAIN:AUTOMATIC TRANSMISSION
Aug 19, 2010
Incident date: Aug 8, 2010
I OWN A 2002 MAZDA MPV. IT HAS ABOUT 94,000 MILES ON IT. RECENTLY WHILE DRIVING THE CAR, I WAS TRYING TO INCREASE SPEED BUT THE CAR WOULD NOT GO FASTER, INSTEAD THE CAR BEGAN TO REDLINE AND DECREASE IN SPEED. WHEN I APPLIED PRESSURE TO THE GAS PEDAL THE CAR WAS RUNNING BUT DID NOT MOVE. I HAD TO P... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
Aug 12, 2010
Incident date: Aug 9, 2010
2002 MAZDA MPV TRANSMISSION KEPT SLIPPING OUT OF GEAR . *TR
POWER TRAIN:AUTOMATIC TRANSMISSION
Jun 3, 2010
Incident date: Jun 3, 2010
WE HAVE A 2002 MAZDA MPV (FIRST OWNERS) WITH 104K; FOLLOWED ALL MANUFACTURERS RECOMMENDATIONS FOR MAINTENANCE. DIED ON THE WAY TO WORK THIS MORNING, HAD TO BE TOWED TO SHOP. THEY WANT 6000$ TO REPLACE TRANSMISSION (WITH A REBUILT ONE). I'M SHOPPING AROUND. THE CAR ISN'T WORTH 1/2 THAT FOR TRADE-I... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
May 15, 2010
Incident date: Apr 30, 2010
COMPLETE TRANSMISSION FAILURE AT 67,000 MILES IN OUR 2002 MAZDA MPV2. ALL ROUTINE MAINTENANCE HAD BEEN PERFORMED. I WAS DRIVING ON THE HIGHWAY (THANKFULLY CLOSE TO HOME) AT THE START OF RUSH HOUR AND WAS UNABLE TO MAINTAIN 40MPH - THE CAR WOULD NOT SHIFT DOWN, THE REVS INCREASED, BUT I HAD NO ACCELE... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
May 10, 2010
Incident date: May 1, 2010
TRANSMISSION FAILURE WITH NO WARNING, ALL SCHEDULED MAINTENANCE COMPLETED. *TR
POWER TRAIN
Apr 5, 2010
Incident date: Apr 4, 2010
2002 MAZDA MPV WITH 39,000 MILES. TRANSMISSION TOTALLY FAILED ON US55 HALFWAY BETWEEN BLOOMINGTON, IL AND CHICAGO. HAD TO HAVE CAR TOWED BACK TO CHICAGO. TRANSMISSION HAS TO BE REPLACED. THIS IS MY SECOND ONE. WHEN I BOUGHT CAR IN 2002 TRANSMISSION FAILED IN 1ST WEEK OF OWNERSHIP AND HAD TO BE REPLA... Read more
SERVICE BRAKES, HYDRAULIC
Mar 9, 2010
Incident date: Jan 28, 2010
MY WIFE WAS DRIVING MAZDA MPV VAN WHICH IS 2002 MODEL. SHE WAS DRIVING AT ABOUT 20-25 MPH AND TRIED TO APPLY THE BRAKES WHEN SHE SAW ANOTHER CAR APPROACHING THE ROAD; THE BRAKES DID NOT ENGAGE AND SHE STARTED HEARING SOME HEAVY SOUND COMING FROM ENGINE. THE VAN CONTINUED TO ACCELERATE AND SHE HAD TO... Read more
Crash
1 injured
VEHICLE SPEED CONTROL
Mar 9, 2010
Incident date: Jan 28, 2010
MY WIFE WAS DRIVING MAZDA MPV VAN WHICH IS 2002 MODEL. SHE WAS DRIVING AT ABOUT 20-25 MPH AND TRIED TO APPLY THE BRAKES WHEN SHE SAW ANOTHER CAR APPROACHING THE ROAD; THE BRAKES DID NOT ENGAGE AND SHE STARTED HEARING SOME HEAVY SOUND COMING FROM ENGINE. THE VAN CONTINUED TO ACCELERATE AND SHE HAD TO... Read more
Crash
1 injured
POWER TRAIN:AUTOMATIC TRANSMISSION
Feb 8, 2010
Incident date: Feb 6, 2010
TRANSMISSION FAILED IN MY 2002 MAZDA MPV AT 111K MILES. AFTER READING SEVERAL STORIES ONLINE THAT SOUND IDENTICAL TO MINE, I FELT COMPELLED TO FILE A COMPLAINT. I WAS TRAVELLING ON A MAJOR INTERSTATE WITH 5 CUBSCOUTS AND THE TRANSMISSION COMPLETELY FAILED, LEAVING US STRANDED ON THE SIDE OF THE RO... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
Jan 6, 2010
Incident date: Jan 3, 2010
ON THE FREEWAY, MY TRANSMISSION FAILED AND HAS TO BE REPLACED. MY CAR ONLY HAS 42,000 MILES. *TR
POWER TRAIN:AUTOMATIC TRANSMISSION
Dec 2, 2009
Incident date: Oct 13, 2009
THE TRANSMISSION ON MY 2002 MAZDA MPV FAILED WITH JUST 53,000 MILES ON IT. I HAD NOTICED SOME PROBLEMS SHIFTING ON HILLS AND FREEWAYS. THE REPAIR MAN CALLED IT "FLASH SHIFTING" WHEN I TOOK IT IN TO BE CHECKED OUT. DEALER DIAGNOSED THE PROBLEM AND PERFORMED A "REFLASH" OF THE TRANSMISSION CONTROL ... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
Nov 10, 2009
Incident date: Oct 31, 2009
MY HUSBAND AND I OWN A 2002 MAZDA MPV LX. LAST WEEK ON SATURDAY, OCTOBER 31, 2009, THE TRANSMISSION FAILED WHILE MY HUSBAND WAS DRIVING ON THE WALT WHITMAN BRIDGE COMING TO PHILADELPHIA. ALTHOUGH OUR VAN IS 7 YEARS OLD, IT ONLY HAS A LITTLE OVER 40,000 MILES ON IT AND WE KEEP IT IN GREAT CONDITION. ... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
Sep 11, 2009
Incident date: Sep 3, 2009
TL*THE CONTACT OWNS A 2002 MAZDA MVP. THE CONTACT STATED THAT WHILE DRIVING 55 MPH ON AN INCLINE, THE TRANSMISSION FAILED WITHOUT ANY PRIOR WARNINGS. THE CONTACT SHIFTED THE VEHICLE INTO NEUTRAL IN ORDER TO PREVENT HIMSELF FROM BEING REAR-ENDED, HE HAD TO PUSH THE VEHICLE TO A PARKING LOT. THE VEHI... Read more
EQUIPMENT
Mar 24, 2009
Incident date: Mar 10, 2009
THIS COMPLAINT IS ABOUT PART DESIGN DEFECTS FOR 2002 MAZDA MPV. OVER YEARS, I WAS STRUGGLING TO SOLVE ENGINE LIGHT-ON WHICH TOOK PLACE EVERY ONCE WHILE. RECENTLY, THE THING GOT WORSE - ENGINE IDLE ROUGH, ENGINE LACK OF POWER, JERKING AT LOW RPM. AFTER LONG TIME STRUGGLE, I'VE FINALLY FOUND THE PROBL... Read more
POWER TRAIN
Mar 24, 2009
Incident date: Mar 10, 2009
THIS COMPLAINT IS ABOUT PART DESIGN DEFECTS FOR 2002 MAZDA MPV. OVER YEARS, I WAS STRUGGLING TO SOLVE ENGINE LIGHT-ON WHICH TOOK PLACE EVERY ONCE WHILE. RECENTLY, THE THING GOT WORSE - ENGINE IDLE ROUGH, ENGINE LACK OF POWER, JERKING AT LOW RPM. AFTER LONG TIME STRUGGLE, I'VE FINALLY FOUND THE PROBL... Read more
ELECTRICAL SYSTEM:IGNITION
Jan 28, 2009
Incident date: Jan 16, 2009
MY 2002 MPV SUFFERED A COMPLETE TRANSMISSION FAILURE AT ABOUT 75K MILES, STALLING OUT IN MORNING TRAFFIC AND NEEDING TO BE PUSHED FROM THE ROAD. THE TRANSMISSION OCCASIONALLY KICKED WHEN SHIFTING SINCE THE CAR WAS NEW. I CALLED MAZDA, WHICH REFUSED TO PAY ANYTHING TOWARD THE REPAIR, SAYING IT HAD ... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
Jan 28, 2009
Incident date: Jan 16, 2009
MY 2002 MPV SUFFERED A COMPLETE TRANSMISSION FAILURE AT ABOUT 75K MILES, STALLING OUT IN MORNING TRAFFIC AND NEEDING TO BE PUSHED FROM THE ROAD. THE TRANSMISSION OCCASIONALLY KICKED WHEN SHIFTING SINCE THE CAR WAS NEW. I CALLED MAZDA, WHICH REFUSED TO PAY ANYTHING TOWARD THE REPAIR, SAYING IT HAD ... Read more
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
Jan 28, 2009
Incident date: Jan 16, 2009
MY 2002 MPV SUFFERED A COMPLETE TRANSMISSION FAILURE AT ABOUT 75K MILES, STALLING OUT IN MORNING TRAFFIC AND NEEDING TO BE PUSHED FROM THE ROAD. THE TRANSMISSION OCCASIONALLY KICKED WHEN SHIFTING SINCE THE CAR WAS NEW. I CALLED MAZDA, WHICH REFUSED TO PAY ANYTHING TOWARD THE REPAIR, SAYING IT HAD ... Read more
ENGINE AND ENGINE COOLING
Jan 8, 2009
Incident date: Dec 18, 2008
2000-2003 MAZDA MPV MODELS HAVE A COOLANT SEEPAGE FROM REAR HEATER PIPE WHICH CAN CAUSE SEVERE ENGINE FAILURE AND TRAFFIC HAZARD DUE TO NON-DRIVABLE VEHICLE. MAZDA MPV 2002 WAS FOUND TO HAVE A COOLANT LEAK IN REAR HEATER PIPES AND WAS TAKEN TO MAZDA REPAIR CENTER. MAZDA ADVISED A VEHICLE SHOULD N... Read more
Crash
ELECTRICAL SYSTEM
Jan 2, 2009
Incident date: Dec 11, 2008
AT 72K, TRANSMISSION FAILED WHILE DRIVING AT HWY SPEEDS. TRANSMISSION WENT INTO NEUTRAL ON ITS OWN. HAD TO REPLACE TRANSMISSION. ALSO ALL 6 COILS HAVE BEEN REPLACED. 1 FAILED AT APPROX. 38K, 2ND AT 50K, THE REMAINING AT 72K. *TR
POWER TRAIN:AUTOMATIC TRANSMISSION
Jan 2, 2009
Incident date: Dec 11, 2008
AT 72K, TRANSMISSION FAILED WHILE DRIVING AT HWY SPEEDS. TRANSMISSION WENT INTO NEUTRAL ON ITS OWN. HAD TO REPLACE TRANSMISSION. ALSO ALL 6 COILS HAVE BEEN REPLACED. 1 FAILED AT APPROX. 38K, 2ND AT 50K, THE REMAINING AT 72K. *TR
POWER TRAIN:AUTOMATIC TRANSMISSION
Nov 26, 2008
Incident date: Nov 22, 2008
MY VAN STARTED JERKING INTO 2ND GEAR AND IT HAD NO PICKUP, I COULD FEEL IT NOT CATCHING GEARS SO I TOOK IT TO MY MECHANIC AND THEY SAY IT NEEDS A NEW TRANSMISSION. IT WILL COST BETWEEN $2000 AND $4000 TO FIX. *TR
POWER TRAIN:AUTOMATIC TRANSMISSION
Sep 29, 2008
Incident date: Sep 27, 2008
I WAS DRIVING OUR 2002 MAZDA MPV, WITH ONLY 59000 MILES ON IT. WE PURCHASED THE VEHICLE NEW IN 2002. IN THIS INCIDENT, I SUDDENLY FOUND THAT WHILE DRIVING AT ABOUT 38 MPH, I TRIED TO ACCELERATE (TO 40 MPH), AND THE VEHICLE DECELERATED INSTEAD. I REPEATEDLY TRIED THIS, AND THE VEHICLE KEPT SLOWIN... Read more
TIRES
Aug 4, 2008
Incident date: Jul 3, 2008
TIRE VALVE STEMS ALL FOUR ,CAUSED TWO FLAT TIRES AND TWO VALUE STEM CREAKING, 13 MONTHS OLD, SUMITOMO TIRES P21560H16 FROM SEARS. I WAS TOLD IT WAS DRY ROT, I TOLD THE MDG. HE WAS FULL OF B.S. . I HAD MIDAS REPLACE ALL FOUR VALUE STEMS. *TR
ENGINE AND ENGINE COOLING
Jul 14, 2008
Incident date: Jul 11, 2008
SINCE NEW, HESITATES BETWEEN 40-50 MPH, CAUSING SUDDEN LOSS OF POWER, HIGH RPMS BUT NO ACCELERATION. REMOVING FOOT FROM GAS VAN SOMETIMES RECOVERS. HAS HAD TRANSMISSION CONTROL MODULE REPLACED AS A RESULT, THEN IGNITION COILS WERE BLAMED AND THOSE WERE REPLACED ONE BY ONE, SOMETIMES MORE THAN ONCE... Read more
FUEL SYSTEM, GASOLINE
Jul 14, 2008
Incident date: Jul 11, 2008
SINCE NEW, HESITATES BETWEEN 40-50 MPH, CAUSING SUDDEN LOSS OF POWER, HIGH RPMS BUT NO ACCELERATION. REMOVING FOOT FROM GAS VAN SOMETIMES RECOVERS. HAS HAD TRANSMISSION CONTROL MODULE REPLACED AS A RESULT, THEN IGNITION COILS WERE BLAMED AND THOSE WERE REPLACED ONE BY ONE, SOMETIMES MORE THAN ONCE... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
Jul 14, 2008
Incident date: Jul 11, 2008
SINCE NEW, HESITATES BETWEEN 40-50 MPH, CAUSING SUDDEN LOSS OF POWER, HIGH RPMS BUT NO ACCELERATION. REMOVING FOOT FROM GAS VAN SOMETIMES RECOVERS. HAS HAD TRANSMISSION CONTROL MODULE REPLACED AS A RESULT, THEN IGNITION COILS WERE BLAMED AND THOSE WERE REPLACED ONE BY ONE, SOMETIMES MORE THAN ONCE... Read more
POWER TRAIN
Jul 9, 2008
Incident date: Jun 3, 2008
THIS COMPLAINT MAY NOT BE ABOUT A SAFETY ISSUE OF MY 2002 MAZDA MPV VAN. HOWEVER, IT'S DEFINITELY ABOUT PART DESIGN DEFECTS. OVER YEARS, I WAS STRUGGLING TO SOLVE ENGINE LIGHT-ON WHICH TOOK PLACE EVERY ONCE WHILE. RECENTLY, THE THING GOT WORSE - ENGINE IDLE ROUGH, ENGINE LACK OF POWER, JERKING AT S... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
Jun 17, 2008
Incident date: Jun 16, 2008
WE HAVE SENT IN OUR MAZDA MPV 2002 VAN INTO 3 DIFFERENT DEALERSHIPS SIX TIMES FOR THE SAME TRANSMISSION ISSUES. EVERYONE EXCEPT ONE GAVE US A COULD NOT REPLICATE PROBLEM ANSWER. HOWEVER, THE ONE DEALERSHIP THAT COULD REPLICATE THE PROBLEM SAID IT WAS THE MECHANICS OF THE TRANSMISSION AND WE SHOULD... Read more
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
May 15, 2008
Incident date: Aug 27, 2007
LOUD TAPPING NOISE EXISTED FOR SEVERAL MONTHS, SOUNDED LIKE A VALVE TAPPING. PROBLEM WAS A CRACKED EXHAUST MANIFOLD. DEALER FOUND CRACKED MANIFOLD AND A STRIPPED ATTACHING BOLT. BOTH WERE REPLACED. MANUFACTURER SUBSEQUENTLY REPAID ME FOR COST OF PARTS. I PAID LABOR. *TR
AIR BAGS:SIDE/WINDOW
Apr 28, 2008
Incident date: Apr 24, 2008
I WAS JUST SETTING IN MY 2002 MAZDA MPV ES AND WITH THE KEY TURNED TO ON SPOT NOT TO START THE VEHICLE SO THAT I COULD PUT DOWN MY WINDOW. AFTER A MINUTE OR SO MY SRS AIRBAGS IN MY DRIVER SEAT AND PASSENGER SEAT DEPLOYED WITHOUT ANY WARNING. INJURY TO MYSELF WAS MODERATE. MY BIGGEST DISAPPOINTMEN... Read more
1 injured
POWER TRAIN:AUTOMATIC TRANSMISSION
Apr 6, 2008
Incident date: Apr 4, 2008
O/D LIGHT FLASHING AND HARSH SHIFT. MY FAMILY AND I WAS PLANNING TO TAKE A TRIP TO WILLIAMSBURG VA, AND WHEN I START THE VAN, I DISCOVERED THE O/D (OVER DRIVE) LIGHT IS FLASHING AND HARSH SHIFTS. I TOOK THE VAN TO AMOCO AND ASK TO CHECK MY TRANSMISSION. THE SERVICE TECH TOLD ME EVERYTHING IS NORMAL,... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
Feb 22, 2008
Incident date: Feb 21, 2008
WE HAVE 83000 MILES ON OUR VEHICLE. WE HAVE TAKEN OUR VEHICLE IN FOR THE REQUIRED CHECK UPS AT 20K, 30K,,FOR ISSUES CONCERNING AIR SENSORS. WE HAD NOT RECEIVED ANY CAUTION BY THE DEALER THAT WE MAY HAVE ISSUES WITH ANY PART DEALING WITH THE POWERTRAIN EVEN AFTER THE DEALER "26 POINT INSPECTION" TH... Read more
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Feb 19, 2008
Incident date: Feb 17, 2008
DRIVER'S SIDE SEAT BELT LATCH WILL NOT READILY ENGAGE. REQUIRES MULTIPLE AND FORCEFUL ATTEMPTS TO GET THE SEAT BELT LOCKED. *TR
POWER TRAIN
Feb 11, 2008
Incident date: Jul 2, 2007
TL*THE CONTACT OWNS A 2002 MAZDA MPV. AS SOON AS THE WARRANTY EXPIRED, THE CONTACT EXPERIENCED FAILURES WITH HER VEHICLE. THE DEALER STATED THAT THE VEHICLE HAD MAJOR ENGINE FAILURE. SINCE THE SUMMER OF 2007, THE ENTIRE VEHICLE VIBRATES WHEN DRIVING 40-50 MPH AND STALLS WHEN APPROACHING A STOP. ... Read more
Showing 50 of 143 complaints.
EPA Fuel Economy, 2002 MAZDA MPV
| Trim / Engine | City MPG | Highway MPG | Combined MPG | Fuel Type | Annual Fuel Cost |
|---|---|---|---|---|---|
| 3.0L 6-cyl, Automatic 5-spd (Front-Wheel Drive) | 16.0 | 23.0 | 18.0 | Regular | $3,450 |
CO2 Emissions: -1.0 g/mile (Minivan - 2WD)
Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.
Technical Service Bulletins, 2002 MAZDA MPV
164 manufacturer communications from 120 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 28 |
| 110000 ELECTRICAL SYSTEM | 13 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 13 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 8 |
| 060000 ENGINE AND ENGINE COOLING | 8 |
| 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY | 6 |
| 980000 UNKNOWN OR OTHER | 5 |
| 061000 ENGINE AND ENGINE COOLING:ENGINE | 5 |
SA-011-24
Feb 12, 2024
010000 STEERING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
SA-011-24
Feb 12, 2024
030000 SERVICE BRAKES, HYDRAULIC
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
SA-011-24
Feb 12, 2024
060000 ENGINE AND ENGINE COOLING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
SA-011-24
Feb 12, 2024
100000 POWER TRAIN
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
SA-011-24
Feb 12, 2024
190000 TIRES
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
SA-011-24
Feb 12, 2024
200000 WHEELS
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
09-016-23
Feb 28, 2023
110000 ELECTRICAL SYSTEM
Speedometer replacement procedure
09-016-23
Feb 28, 2023
117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
Speedometer replacement procedure
02-004-22a
Nov 18, 2022
020000 SUSPENSION
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
09-037-22
Sep 16, 2022
110000 ELECTRICAL SYSTEM
Mazda can no longer support the replacement of immobilizer units LC62-67-5G2* or DC69-67-5G2* because the supplier is no longer in existence.
09-024-22
Jul 18, 2022
117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer.
01-006-22
Jun 22, 2022
110000 ELECTRICAL SYSTEM
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in st
02-004-22
May 24, 2022
020000 SUSPENSION
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
SA-014-22
Mar 29, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Accessory instructions can be found on OneMazda under Dealer Resources - Parts & Accessories.
01-003/22
Mar 17, 2022
110000 ELECTRICAL SYSTEM
The Mazda DCA-8000 is required for all warranty battery testing. If the Mazda DCA-8000 is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to test
01-003/22
Mar 17, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
The Mazda DCA-8000 is required for all warranty battery testing. If the Mazda DCA-8000 is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to test
00-001-22
Feb 23, 2022
010000 STEERING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
00-001-22
Feb 23, 2022
030000 SERVICE BRAKES, HYDRAULIC
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
00-001-22
Feb 23, 2022
060000 ENGINE AND ENGINE COOLING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
00-001-22
Feb 23, 2022
100000 POWER TRAIN
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
01-006-21-3779b
Dec 21, 2021
110000 ELECTRICAL SYSTEM
Battery Maintenance: This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost.
05-002-21-3854
Dec 8, 2021
100000 POWER TRAIN
Automatic Transmission/Transaxle Cooler and Lines Flushing Procedure: Automatic Transaxle/Transmission (A/T) oil cooler and lines must be power flushed completely before an overhauled or replacement A/T is installed (except SKYACTIV-DRIVE)
01-006-21-3779a
Aug 24, 2021
060000 ENGINE AND ENGINE COOLING
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in sto
01-006-21-3779a
Aug 24, 2021
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in sto
09-025-21-3824
Aug 17, 2021
350000 EQUIPMENT
This service bulletin provides information regarding the proper use of the driver??A?A?s floor mat to avoid any potential interference with the foot pedals. The following are possible causes of floor mat interference, which can be avoided w
SA-041-21
Jun 9, 2021
350000 EQUIPMENT
Accessory instructions can be found on OneMazda under Dealer Resources - Parts & Accessories. The links provided below can be used for quick access: For 2016 models and newer: NOTE: Instructions are found under the "Attachments" section onc
0900116
Mar 16, 2021
350000 EQUIPMENT
Service Parts changed for immobilizer unit
01-005-21-3778
Feb 8, 2021
110000 ELECTRICAL SYSTEM
The Mazda DCA-8000PM is required for all warranty battery testing. If the Mazda DCA-8000PM is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to t
01-006-21-3779
Feb 8, 2021
110000 ELECTRICAL SYSTEM
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in sto
07-001-21-3775
Jan 26, 2021
350000 EQUIPMENT
A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/C evaporator/cooling unit which is
00-001-21-3768
Jan 21, 2021
010000 STEERING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-21-3768
Jan 21, 2021
060000 ENGINE AND ENGINE COOLING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-21-3768
Jan 21, 2021
100000 POWER TRAIN
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-21-3768
Jan 21, 2021
200000 WHEELS
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
09-002-21-3770
Jan 21, 2021
110000 ELECTRICAL SYSTEM
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
09-002-21-3770
Jan 21, 2021
180000 VEHICLE SPEED CONTROL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
09-002-21-3770
Jan 21, 2021
350000 EQUIPMENT
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
MT-002-20
Aug 3, 2020
199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
New CARB regulation regarding mandatory checking and documenting of tire pressure whenever a vehicle is in for service work. This applies to all service shops (including Mazda dealerships) in California effective September 1, 2010.
MT-002-20
Aug 3, 2020
200000 WHEELS
New CARB regulation regarding mandatory checking and documenting of tire pressure whenever a vehicle is in for service work. This applies to all service shops (including Mazda dealerships) in California effective September 1, 2010.
09-006-20-3673a
Jul 20, 2020
350000 EQUIPMENT
When encountering a vehicle with paint damage, refer to the "Mazda Paint Warranty Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
00-001-20-3689
Mar 12, 2020
030000 SERVICE BRAKES, HYDRAULIC
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-20-3689
Mar 12, 2020
060000 ENGINE AND ENGINE COOLING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-20-3689
Mar 12, 2020
100000 POWER TRAIN
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-20-3689
Mar 12, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
09-006-20-3673
Jan 13, 2020
350000 EQUIPMENT
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable). Copies of the Mazda Pocket Paint Guide are available for order on Mazda e-
02-002-20-3651
Jan 9, 2020
020000 SUSPENSION
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
02-002-20-3651
Jan 9, 2020
350000 EQUIPMENT
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
02-002-20-3651
Jan 9, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
09-003-20-3671
Jan 9, 2020
110000 ELECTRICAL SYSTEM
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer??A?A?s responsibility
09-003-20-3671
Jan 9, 2020
350000 EQUIPMENT
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer??A?A?s responsibility
07-002-19-3616a
Dec 17, 2019
350000 EQUIPMENT
A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/C evaporator/cooling unit which is
07-002-19-3616a
Dec 17, 2019
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/C evaporator/cooling unit which is
07-002-19-3616a
Dec 17, 2019
356000 EQUIPMENT ADAPTIVE/MOBILITY
A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/C evaporator/cooling unit which is
07-002-19-3616
Jul 16, 2019
350000 EQUIPMENT
A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/C evaporator/cooling unit which is
07-002-19-3616
Jul 16, 2019
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/C evaporator/cooling unit which is
00-001-19-3560
Jan 14, 2019
350000 EQUIPMENT
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle- specific workshop manual or owner's man
00-002-19-3561
Jan 14, 2019
030000 BRAKES (PWS)
Mazda North American Operations has approved an additional on-car brake lathe as an option for MNAO authorized equipment. The Pro-Cut On-Car Brake Lathe has been added to the MNAO authorized equipment program. NOTE: Accu-turn is still an ap
09-005-19-3562
Jan 14, 2019
350000 EQUIPMENT
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable). Copies of the Mazda Pocket Paint Guide are available for order on Mazda e-
09-009-19-3566
Jan 14, 2019
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to co
01-004-19-3558
Jan 9, 2019
060000 ENGINE AND ENGINE COOLING
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. The odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. Sulfur smell is not a
09-002-19-3554
Jan 3, 2019
356000 EQUIPMENT ADAPTIVE/MOBILITY
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid anypotential interference with the foot pedals. The following are possible causes of floor mat interference,which can be avoided with pro
01-001-19-3551
Jan 2, 2019
110000 ELECTRICAL SYSTEM
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in sto
01-002-19-3552
Jan 2, 2019
110000 ELECTRICAL SYSTEM
The Mazda GR8-1291 is required for all warranty battery testing. If the Mazda GR8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to test
02-001-19-3550
Jan 2, 2019
020000 SUSPENSION
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
MT-012-18
Dec 11, 2018
010000 STEERING
If a vehicle has body vibration or steering wheel shimmy while driving and the root cause is determined to be tire balance, re-balance the tires using a Hunter GSP9700 or equivalent balance machine. If your dealer does not have a GSP9700 or
MT-012-18
Dec 11, 2018
162000 STRUCTURE:BODY
If a vehicle has body vibration or steering wheel shimmy while driving and the root cause is determined to be tire balance, re-balance the tires using a Hunter GSP9700 or equivalent balance machine. If your dealer does not have a GSP9700 or
00-001-18-3446a
Oct 10, 2018
350000 EQUIPMENT
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle- specific workshop manual or owner's man
00-001-18-3446a
Oct 10, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle- specific workshop manual or owner's man
00-003-18-3480a
Oct 10, 2018
030000 SERVICE BRAKES, HYDRAULIC
Mazda North American Operations has approved an additional on-car brake lathe as an option for MNAO authorized equipment. The Pro-Cut On-Car Brake Lathe has been added to the MNAO authorized equipment program. NOTE: Accu-turn is still an ap
00-003-18-3480a
Oct 10, 2018
350000 EQUIPMENT
Mazda North American Operations has approved an additional on-car brake lathe as an option for MNAO authorized equipment. The Pro-Cut On-Car Brake Lathe has been added to the MNAO authorized equipment program. NOTE: Accu-turn is still an ap
09-014-18-3443a
Oct 10, 2018
160000 STRUCTURE
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable). Copies of the Mazda Pocket Paint Guide are available for order on Mazda e-
09-014-18-3443a
Oct 10, 2018
350000 EQUIPMENT
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable). Copies of the Mazda Pocket Paint Guide are available for order on Mazda e-
09-034-18-3430a
Oct 10, 2018
180000 VEHICLE SPEED CONTROL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to co
09-034-18-3430a
Oct 10, 2018
350000 EQUIPMENT
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to co
RF-18-03
Sep 11, 2018
060000 ENGINE AND ENGINE COOLING
EXHAUST PIPE GASKET OPEN END: There has been some concern with the open end of hoop design being considered a defect in the gasket for P/N AJ17-40-305. The end of this ?hoop? is intentionally modified to press fix the gasket on the exhaust
RF-18-03
Sep 11, 2018
063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
EXHAUST PIPE GASKET OPEN END: There has been some concern with the open end of hoop design being considered a defect in the gasket for P/N AJ17-40-305. The end of this ?hoop? is intentionally modified to press fix the gasket on the exhaust
01-016-18-3522
Sep 6, 2018
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. The odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. Sulfur smell is not a
09-034-18-3430
Aug 31, 2018
180000 VEHICLE SPEED CONTROL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to co
00-003-18-3480
May 11, 2018
030000 BRAKES (PWS)
Mazda North American Operations has approved an additional on-car brake lathe as an option for MNAOauthorized equipment. The Pro-Cut On-Car Brake Lathe has been added to the MNAO authorizedequipment program.NOTE: Accu-turn is still an appro
07-002-18-3432
Apr 16, 2018
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. This odor is the result of mold growth in the A/Cevaporator/cooling unit which is c
09-019-18-3450
Mar 26, 2018
356000 EQUIPMENT ADAPTIVE/MOBILITY
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. The following are possible causes of floor mat interference, which can be avoided with p
01-008-18-3451
Mar 26, 2018
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in sto
01-009-18-3452
Mar 26, 2018
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
The Mazda GR8-1291 is required for all warranty battery testing. If the Mazda GR8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to test
02-006-18-3449
Mar 26, 2018
021300 SUSPENSION:FRONT:SHOCK ABSORBER
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
02-006-18-3449
Mar 26, 2018
022400 SUSPENSION:REAR:SHOCK ABSORBER
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
00-001-18-3446
Mar 22, 2018
350000 EQUIPMENT
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
09-014-18-3443
Mar 22, 2018
160000 STRUCTURE
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
09-035-17-3080
Aug 7, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer?s responsibility to co
09-035-17-3080
Aug 7, 2017
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer?s responsibility to co
SA-061-17
Jul 12, 2017
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
In an effort to achieve a higher level of Customer Experience and retain the value of Mazda's vehicles, MNAO Warranty Operations is? 2017 Mazda North American Operations, U.S.A. allowing all Mazda dealers to utilize a third party, SPECMO En
00-004-16-3237
Aug 11, 2016
350000 EQUIPMENT
RAISING A VEHICLE WITH A JACK CAN BE DANGEROUS IF NOT DONE PROPERLY. THE VEHICLE CAN SLIP OFF THE JACK AND SERI-OUSLY INJURE SOMEONE. IN THIS SERVICE INFORMATION, SOME IMPORTANT WARNINGS AND CAUTIONS HAVE BEEN TAKEN FROM THE OWNER?S MANUAL.
0000216
Feb 26, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Mazda guidelines for factory scheduled maintenance
0901216
Feb 26, 2016
350000 EQUIPMENT
Paint damage Mazda pocket paint guide
0900716
Feb 17, 2016
117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
Speedometer replacement procedure
0100316
Feb 15, 2016
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
SULFUR SMELL FROM EXHAUST SYSTEM.
0100316
Feb 15, 2016
356000 EQUIPMENT ADAPTIVE/MOBILITY
SULFUR SMELL FROM EXHAUST SYSTEM.
0100416
Feb 15, 2016
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Battery Maintenance
0100416
Feb 15, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Battery Maintenance
0100516
Feb 15, 2016
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Battery test procedure requirements using the GR81291
0100516
Feb 15, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Battery test procedure requirements using the GR81291
Showing 100 of 164 bulletins.
NHTSA Safety Investigations, MAZDA MPV
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
EA96031
Opened: Dec 20, 1996 , Closed: Mar 31, 1998
FUEL LIQUID-VAPOR SEPARATOR
EVAPORATIVE EMISSIONS CONTROL SYSTEM LIQUID-VAPOR SEPARATOR MAY FAIL AT NIPPLE FOR FUEL TANK HOSE CONNECTION RESULTING IN FUEL LEAKAGE IN THE AREA BEHIND THE RIGHT REAR TRIM PANEL.
PE96055
Opened: Sep 13, 1996 , Closed: Dec 20, 1996
FUEL LIQUID-VAPOR SEPARATOR FAILURE
RATORS AREEVAPORATIVE EMISSIONS CONTROL SYSTEM LIQUID-VAPOR SEPARATORS ARE ALLEGEDLY FAILING AND LEAKING FUEL LIQUID/VAPOR.
EA92008
Opened: Feb 3, 1992 , Closed: Mar 16, 1992
INCONSIST.BRK PERFORMANCE
There is no summary currently available
PE91134
Opened: Oct 1, 1991 , Closed: Feb 3, 1992
INCONSISTENT BRAKE PERFORM
===
MAZDA MPV - All Years Overview
Complete safety history for the MAZDA MPV across all model years (1989, 2006).
44
Total Recalls
1,157
Total Complaints
4
Investigations
129
Reported Crashes
27
Reported Fires
0
Reported Deaths
MAZDA MPV - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2006 | 2 | 16 | View |
| 2005 | 3 | 45 | View |
| 2004 | 5 | 84 | View |
| 2003 | 4 | 141 | View |
| 2002 (current) | 4 | 143 | |
| 2001 | 3 | 82 | View |
| 2000 | 5 | 184 | View |
| 1999 | 0 | 2 | View |
| 1998 | 1 | 26 | View |
| 1997 | 1 | 27 | View |
| 1996 | 1 | 21 | View |
| 1995 | 1 | 21 | View |
| 1994 | 1 | 41 | View |
| 1993 | 1 | 65 | View |
| 1992 | 1 | 95 | View |
| 1991 | 3 | 81 | View |
| 1990 | 3 | 55 | View |
| 1989 | 5 | 27 | View |