2000 MAZDA B-SERIES TRUCK
3 recalls — 74 complaints — 155 TSBs
07V347000 Aug 7, 2007
VEHICLE SPEED CONTROL
Defect Description
ON CERTAIN TRUCKS EQUIPPED WITH A SPEED CONTROL SYSTEM, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence
THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy
DEALERS WILL INSTALL A FUSED WIRING HARNESS. AN INTERIM NOTICE WAS SENT TO OWNERS ON SEPTEMBER 7, 2007, DIRECTING THEM TO HAVE THE SPEED DEACTIVATION CONTROL SWITCH DISCONNECTED TEMPORARILY. A SECOND NOTIFICATION LETTER TO OWNERS WAS IN FEBRUARY 2008 ADVISING THEM TO RETURN TO DEALERS FOR INSTAL... Read more
00T005000 Aug 21, 2000
TIRES:TREAD/BELT
Defect Description
TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE T... Read more
Consequence
IF THE TREAD SEPARATES FROM THE TIRE, THE DRIVER CAN LOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH CAUSING INJURY OR DEATH.
Remedy
THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON AUGUST 29, 2001. HOWEVER, CUSTOMERS SHOULD CONTACT FIRESTONE CUSTOMER SERVICE AT 1-800-465-1904 FOR POSSIBLE ASSISTANCE.
00V228002 Aug 18, 2000
SEAT BELTS
Defect Description
VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy
DEALERS WILL INSPECT THE BUCKLE ASSEMBLIES TO DETERMINE WHETHER THE BUCKLE ASSEMBLY BUILD DATE CODES ARE WITHIN THE SUSPECT RANGE. THOSE WITHIN THE SUSPECT DATE CODE RANGE WILL BE REPLACED.
Complaint Statistics
74 total complaints
8 crashes 4 fires 5 injuries
Top Reported Components
| Component | Complaints |
|---|---|
| TIRES | 13 |
| POWER TRAIN:AUTOMATIC TRANSMISSION | 7 |
| STRUCTURE:FRAME AND MEMBERS | 3 |
| SUSPENSION:FRONT | 3 |
| POWER TRAIN:DRIVELINE:DRIVESHAFT | 3 |
| TIRES:TREAD/BELT | 2 |
| AIR BAGS:FRONTAL | 2 |
| STEERING:RACK AND PINION | 2 |
| STEERING:HYDRAULIC POWER ASSIST:POWER STEERING FLUID | 2 |
| UNKNOWN OR OTHER | 2 |
STRUCTURE:BODY
Jan 3, 2020
Incident date: Dec 14, 2019
FRAME IS RUSTED OUT DID NOT PASS INSPECTION WAS ADVISED NOT TO DRIVE IT AS THE BED COULD FALL OFF
SUSPENSION
Feb 22, 2016
Incident date: Feb 6, 2016
"TAKATA RECALL" MY SEAT BROKE FROM THE BOTTOM PIECE THEREON THE PART THAT RECLINES THERES A BAR THAT GOES ACROSS NO CANT REALLY SIT ON THERE RIGHT THE VEHICLE WASBNOT IN MOTION AS IT WAS PARKED HAPPEND WHEN I WAS GETTING ON...
SEATS
Feb 22, 2016
Incident date: Feb 6, 2016
"TAKATA RECALL" MY SEAT BROKE FROM THE BOTTOM PIECE THEREON THE PART THAT RECLINES THERES A BAR THAT GOES ACROSS NO CANT REALLY SIT ON THERE RIGHT THE VEHICLE WASBNOT IN MOTION AS IT WAS PARKED HAPPEND WHEN I WAS GETTING ON...
ENGINE
Sep 13, 2013
Incident date: Jun 7, 2013
TL* THE CONTACT OWNS A 2000 MAZDA B3000. THE CONTACT STATED THAT THE VEHICLE UNEXPECTEDLY CAUGHT ON FIRE WHILE IT WAS PARKED IN A RESIDENTIAL DRIVEWAY. THE VEHICLE WAS TOWED TO A SALVAGE YARD AND WAS NOT DIAGNOSED TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE INCIDENT... Read more
Fire
TIRES
Mar 12, 2010
Incident date: Dec 10, 2007
RETARD TIRE(S) SIZES...? B/C FIRE RETARDENT...? DOT:(AAHHMTZ000), (PJC49R1204),(MDUR18HR) SHOULD BE A 16" SIZE RIM... *TR
Crash
Fire
WHEELS
Mar 12, 2010
Incident date: Dec 10, 2007
RETARD TIRE(S) SIZES...? B/C FIRE RETARDENT...? DOT:(AAHHMTZ000), (PJC49R1204),(MDUR18HR) SHOULD BE A 16" SIZE RIM... *TR
Crash
Fire
STRUCTURE:FRAME AND MEMBERS
Feb 27, 2010
Incident date: Sep 1, 2007
FRAME INSPECTION AND TIRE BALANCING? DAMAGED MY FRONT FRAME OF MY PICK-UP. BOUGHT A MICHELIN TIRE(S)... *TR
Fire
STRUCTURE:FRAME AND MEMBERS
Dec 12, 2009
Incident date: Sep 15, 2009
FRAME RUSTED OUT, RUSTED TIRE CARRIER, AND REAR LEAF SPRING MOUNTS. UNSAFE TRUCK UNTIL WE TEMPORARILY FIXED THE PROBLEM BECAUSE MAZDA WOULD NOT. FRAME SHOULD LAST LONGER THAN 8 YEARS AFTER BEING IN HEATED GARAGE. *TR
TIRES
May 31, 2008
Incident date: May 20, 2008
THE VEHICLE HAS SEVERAL SAFETY ISSUES. 1. THE DOOR AJAR LIGHT ON DASH REPEATEDLY COMES ON AS WELL AS INSIDE LIGHT WHILE DRIVING. THIS PROBLEM HAS OCCURRED SINCE VEHICLE WAS NEW AND NEVER REPAIRED CORRECTLY BY MAZDA FACILITY. 2. TRUCK HAS ORIGINAL WILDERNESS HT TIRES FROM FIRESTONE, WITH 2... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
May 31, 2008
Incident date: May 20, 2008
THE VEHICLE HAS SEVERAL SAFETY ISSUES. 1. THE DOOR AJAR LIGHT ON DASH REPEATEDLY COMES ON AS WELL AS INSIDE LIGHT WHILE DRIVING. THIS PROBLEM HAS OCCURRED SINCE VEHICLE WAS NEW AND NEVER REPAIRED CORRECTLY BY MAZDA FACILITY. 2. TRUCK HAS ORIGINAL WILDERNESS HT TIRES FROM FIRESTONE, WITH 2... Read more
STRUCTURE
May 31, 2008
Incident date: May 20, 2008
THE VEHICLE HAS SEVERAL SAFETY ISSUES. 1. THE DOOR AJAR LIGHT ON DASH REPEATEDLY COMES ON AS WELL AS INSIDE LIGHT WHILE DRIVING. THIS PROBLEM HAS OCCURRED SINCE VEHICLE WAS NEW AND NEVER REPAIRED CORRECTLY BY MAZDA FACILITY. 2. TRUCK HAS ORIGINAL WILDERNESS HT TIRES FROM FIRESTONE, WITH 2... Read more
ENGINE AND ENGINE COOLING
May 31, 2008
Incident date: May 20, 2008
THE VEHICLE HAS SEVERAL SAFETY ISSUES. 1. THE DOOR AJAR LIGHT ON DASH REPEATEDLY COMES ON AS WELL AS INSIDE LIGHT WHILE DRIVING. THIS PROBLEM HAS OCCURRED SINCE VEHICLE WAS NEW AND NEVER REPAIRED CORRECTLY BY MAZDA FACILITY. 2. TRUCK HAS ORIGINAL WILDERNESS HT TIRES FROM FIRESTONE, WITH 2... Read more
EXTERIOR LIGHTING:BRAKE LIGHTS
May 31, 2008
Incident date: May 20, 2008
THE VEHICLE HAS SEVERAL SAFETY ISSUES. 1. THE DOOR AJAR LIGHT ON DASH REPEATEDLY COMES ON AS WELL AS INSIDE LIGHT WHILE DRIVING. THIS PROBLEM HAS OCCURRED SINCE VEHICLE WAS NEW AND NEVER REPAIRED CORRECTLY BY MAZDA FACILITY. 2. TRUCK HAS ORIGINAL WILDERNESS HT TIRES FROM FIRESTONE, WITH 2... Read more
INTERIOR LIGHTING
May 31, 2008
Incident date: May 20, 2008
THE VEHICLE HAS SEVERAL SAFETY ISSUES. 1. THE DOOR AJAR LIGHT ON DASH REPEATEDLY COMES ON AS WELL AS INSIDE LIGHT WHILE DRIVING. THIS PROBLEM HAS OCCURRED SINCE VEHICLE WAS NEW AND NEVER REPAIRED CORRECTLY BY MAZDA FACILITY. 2. TRUCK HAS ORIGINAL WILDERNESS HT TIRES FROM FIRESTONE, WITH 2... Read more
TIRES:TREAD/BELT
Oct 24, 2005
Incident date: Jun 29, 2005
DRIVER FELT VIBRATION WILE DRIVING IN FAST LANE, DRIVER THEN LOST CONTROL AND COLLIDED INTO ANOTHER VEHICLE. *TS THE CONSUMER LOST CONTROL OF THE TRUCK DUE TO TIRE TREAD SEPARATION. THE TIRE BRAND WAS FIRESTONE. THE DRIVER OF THE OTHER VEHICLE WAS INJURED. *JB
Crash
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Mar 1, 2005
Incident date: Feb 26, 2005
CONSUMER INSPECTED VEHICLE AFTER HEARING A LOUD SQUEAKY NOISE COMING FROM THE FRONT PASSENGER SIDES. WHEN INSPECTING HE FOUND A LOOSE PREMATURELY RUSTED LOWER BALL JOINT WITH NO LUBRICATION AND REPLACED THE PART. DEALER STATED THERE WAS NEVER ANY TYPE OF GREASE FITTING WHICH CAUSED RUSTING. CONSUMER... Read more
AIR BAGS:FRONTAL
Jan 4, 2005
Incident date: Dec 13, 2004
I WAS INVOLVED IN AN ACCIDENT AND THE AIR BAGS DEPLOYED ON THE FIRST IMPACT, BUT WHEN I WAS REAR ENDED MY HEAD WAS CUT OPEN BY THE PLASTIC COVER FOR THE AIR BAG. WHEN I WAS REAR ENDED A 2ND AND 3RD TIME MY NOSE WAS CUT BY THE SAME PLASTIC COVER.*AK
Crash
1 injured
POWER TRAIN:AUTOMATIC TRANSMISSION
Dec 28, 2004
Incident date: Dec 28, 2004
TRANSMISSION WENT OUT AT 12-28-04 . DEALER TOLD ME I NEEDED A NEW TRANSMISSION AT A COST OF 3800.00 . AT SPEEDS HIGH AND LOW IT WILL NOT SHIFT RIGHT. I TRIED TO GET HELP ON THIS PROBLEM AND MAZDA CORP SAID IT WOULD TAKE A WHILE TO MAYBE SOLVE. *JB
POWER TRAIN:AUTOMATIC TRANSMISSION
Sep 17, 2004
Incident date: Aug 23, 2004
WHILE DRIVING A TLOW SPEEDS AUTOMATIC TRANSMISSION SHIFTED GEARS. DEALERSHIP INFORMED CONSUMER THAT THE PROBLEM PERTAINED TO THE SPEED SENSOR, BUT THE PROBLEM WAS NOT REPAIRED. *AK
VEHICLE SPEED CONTROL
Sep 17, 2004
Incident date: Aug 23, 2004
WHILE DRIVING A TLOW SPEEDS AUTOMATIC TRANSMISSION SHIFTED GEARS. DEALERSHIP INFORMED CONSUMER THAT THE PROBLEM PERTAINED TO THE SPEED SENSOR, BUT THE PROBLEM WAS NOT REPAIRED. *AK
TIRES
Jul 16, 2004
Incident date: Mar 12, 2004
TYPE OF CAR: 2000 MAZDA B4000 TRUCK . I WAS DRIVING DOWN THE ROAD AT ABOUT 30MPH, MADE A RIGHT HAND TURN INTO A PARKING LOT. MOMENTS LATER I NOTICED IN MY REAR VIEW MIRROR A TIRE LYING IN THE ROAD. TURNS OUT MY SPARE TIRE FELL OUT FROM UNDERNEATH MY TRUCK. THE SPARE TIRE CARRIER CABLE HAD SNAPP... Read more
ENGINE AND ENGINE COOLING
Jul 3, 2004
Incident date: Feb 2, 2001
THE OIL PRESSURE GAUGE STICKS UNTILL TRUCK IS WARMED UP. USUALLY TAKES ANYWHEWRE FROM A FEW SECONDS TO AS MUCH AS 10 MINUTES TO REGISTER. *AK
ELECTRICAL SYSTEM
Jul 1, 2004
Incident date: Jul 1, 2004
WHILE PLACING THE KEY INSIDE OF THE IGNITION, THE ANTI THEFT ALARM SYSTEM WOULD COME ON AND STAY ON. THIS CAUSED THE VEHICLE TO NOT START. THE DRIVER HAS CONTACTED THE DEALER FOR A APPOINTMENT FOR INSPECTION OF THE VEHICLE. PLEASE FILL IN ADDITIONAL INFORMATION. *JB
SEATS
Jun 16, 2004
Incident date: Jun 16, 2004
THE METAL SPRING IS POKING THROUGHOUT THE FRONT PASSENGER SIDE SEAT.*AK
FUEL SYSTEM, GASOLINE:STORAGE
Apr 24, 2004
Incident date: Apr 23, 2004
I WENT TO A GAS STATION TO FUEL MY TRUCK. FUEL STARTED POURING FROM THE BOTTOM MIDDLE OF THE TRUCK JUST AS THE TANK REACHED ITS FULLEST CAPACITY. THERE WAS NO PRIOR INCIDENT OF FUEL LEAKING BEFORE THE TANK REACHED ITS FULLEST CAPACITY. NOR WAS THERE ANY PRIOR SIMILAR EXPERIENCE BEFORE THIS DATE WHEN... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
Apr 7, 2004
Incident date: Apr 2, 2004
THE TRANSMISSION HAD TO BE REPLACED AT 53,000 MILES. *AK
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Mar 3, 2004
WHILE DRIVING GEAR SHIFT POPPED OUT OF GEAR INTO NEUTRAL. THIS OCCURRED WHEN THE VEHICLE WAS SLOWING DOWN IN FIRST OR THIRD GEARS. DEALERSHIP WAS NOT ABLE TO RESOLVE THE PROBLEM. *AK
STEERING
Jan 23, 2004
Incident date: Jan 12, 2004
WHILE DRIVING, THE STEERING WHEEL JERKED AWAY FROM THE CONSUMER. *JB
POWER TRAIN:AUTOMATIC TRANSMISSION
Dec 4, 2003
Incident date: Dec 1, 2003
WHILE DRIVING UP A HILL AT ANY SPEED,THE ENGINE REVS UP HIGH, BUT THE VEHICLE LOOSES POWER. THE CONSUMER DROVE THE VEHICLE TO A MECHANIC, WHO INFORMED HER THAT THERE WAS SLUDGE ACCUMULATION INSIDE THE TRANSMISSION. A NEW TRANSMISSION IS NEEDED AT THIS TIME. THE MANUFACTURER AND THE DEALER ARE AW... Read more
TIRES
Oct 28, 2003
Incident date: Oct 29, 2003
FIRESTONE WILDERNESS TIRES --VIBATION , CUPING , ALSO PROBLEMS WITH OIL GAUGES --DONT WORK UNTILL TRUCK WARMS UP. *AK
SEATS:FRONT ASSEMBLY:RECLINER
Aug 13, 2003
Incident date: Jul 14, 2003
DRIVER SEATBACK RECLINER ATTACHMENT FAILED WHILE DRIVING. SOUNDS EXACTLY LIKE WHAT WAS GOING ON WITH THE FORD EXPLORER IN ACTION # PE03-020, EXCEPT MY VEHICLE IS A MAZDA B4000 TRUCK, YEAR 2000. THE EXPLORER IS ALSO ON A TRUCK CHASIS. BOTH VEHICLES BASICALLY COME FROM FORD, RIGHT? MAZDA MADETHE REPA... Read more
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Jun 9, 2003
Incident date: Jun 6, 2003
DOOR LATCH SENSOR FAILS IN HIGH TEMP (>75 DEG F). THIS GIVES DOOR UNLATCHED ALARM, AND KEY IN IGNITION ALARM. HAPPENS WHENEVER IT SITS IN SUNLIGHT AND DOOR HEATS UP. WILL TEMPORARILY FIX ITSELF IF A/C RUNS INSIDE FOR >20 MINS. THIS HAS ALSO HAPPENED IN A B3000 2002 MODEL A FRIEND HAS. FORD ALSO SUPP... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
May 20, 2003
Incident date: May 20, 2003
TRANSMISSION FAILED AT 71000. DEALERSHIP STATED THAT I WOULD NEED NEW TRANSMISSION AT A COST OF $3100.00. THE TRUCK HAS HAD TRANSMISSION FLUID CHANGED AT THE RECOMMENDED 30,000. *NLM
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
Jan 27, 2003
Incident date: Jun 21, 2002
BRITTLE METAL FAILURE IN REAR AXLE CAUSED A SHEAR NEAR THE LEFT REAR TIRE. THE LEFT REAR TIRE SEPARATED FROM THE VEHICLE WHILE THE VEHICLE WAS ON THE HIGHWAY AT 50-55 MPH, CAUSING THE VEHICLE TO ROLL SEVERAL TIMES.
Crash
1 injured
AIR BAGS:FRONTAL
Dec 3, 2002
Incident date: Nov 29, 2002
CONSUMER WAS STRUCK FROM THE REAR BY ANOTHER VEHICLE WHILE IDLING BEHIND A TRACTOR TRAILER. THE COLLISION CAUSED THE MAZDA TO STRIKE REAR OF TRACTOR AND FLIP OVER ON IT'S SIDE. THE DRIVER'S SIDE AIR BAG DID NOT DEPLOY.TS
Crash
POWER TRAIN:AUTOMATIC TRANSMISSION
Sep 30, 2002
Incident date: Jul 30, 2002
CONSUMER STATES THAT WHILE DRIVING VEHICLE WILL NOT CHANGE GEARS LIKE IT SHOULD. HAD VEHICLE SERVICED.THE PART IN THE TRANSMISSION WAS BAD, HAD PART REPLACED, PROBLEM REACCURED. NLM
POWER TRAIN:DRIVELINE:DRIVESHAFT
Sep 30, 2002
Incident date: May 30, 2002
CONSUMER STATES THAT WHILE REVERSING VEHICLE, HEARD A LOUD CLICKING NOISE. HAD VEHICLE SERVICED.THE DRIVE SHAFT FAILED.REPLACED PART, PROBLEM REACCURED. NLM
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
Jun 25, 2002
Incident date: May 7, 2001
ON 5/7/01,THE TRUCK WAS RETURNED TO MAZDA DUE TO SHIMMYING/VIBRATION WHEN BRAKES APPLIED. ROTORS HAD WARPED.TRUCK HAD 22177 MILES AT THIS TIME. ON JUNE 14,2002,TRUCK WAS RETURNED AGAIN FOR SAME PROBLEM. TRUCK HAD 34387 MILES. THE SECOND SET HAD FAILED AFTER ONLY 12210 MILES AND MAZDA CLAIMS IT IS DU... Read more
VISIBILITY:WINDSHIELD WIPER/WASHER
Jun 3, 2002
WINDSHIELD WIPERS COME ON ANY TIME AND WHEN PUT ON TURN SIGNAL,PASSENGER AIRBAG LIGHT DONT COME ON OR WORK WENT TO DEALER WHEN I RECEIVED RECALL LETTER THEY SAID THEY WOULD CALL ME ON PART IT BEEN OVER A YEAR AND THE PROBLEM GETS WORSE WITH EVERYTHING.TOOK IT TO ANOTHER DEALER LAST WEEK THEY WANTED... Read more
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
Apr 2, 2002
Incident date: Nov 15, 2001
FRONT WHEELS WOULD LOCK UP INTERMITTENTLY WHEN BRAKES WERE APPLIED ON COOL AND WET ROAD CONDITIONS . VEHICLE BEEN TO DEALER ON TWO OCCASIONS, AND PROBLEM REOCCURRING. *AK *YH
AIR BAGS
Sep 17, 2001
Incident date: Aug 28, 2001
CONSUMER IS CONCERNED BECAUSE AIRBAG LIGHT CAME ON DASHBOARD. DEALERSHIP IS AWARE OF PROBLEM. *AK
SEAT BELTS
Sep 12, 2001
Incident date: Aug 26, 2001
ACCELERATING FROM A STOP DRIVER'S SIDE SEAT BELT SUDDENLY DISCHARGED AND VEHICLE FILLED WITH SMOKE. SEAT BELT HANKED THE CONSUMER DOWN INTO THE SEAT. THE DEALER TOOK A LOOK AND HAS NEVER SEEN ANYTHING LIKE IT. THE VEHICLE WAS ONLY 4-5 WEEKS OLD.*AK
POWER TRAIN:DRIVELINE:DRIVESHAFT
Jul 18, 2001
FAILURE STARTED AT 7000,9000,10000,12000 MILES, DEALERSHIP REFUSING TO FIX NOW,VERY VERY FRUSTRATED AT THIS POINT WITH MAZDA AND SERVICE. NO SAFETY DEFEC TLISTED. *AK
TIRES
Jun 19, 2001
Incident date: Jun 7, 2001
TIRE WENT FLAT FROM WHAT APPEARS TO BE BELT AND TREAD SEPARATION. *AK (DOT NUMBER: W2UU TIRESIZE: P225/70R15)
UNKNOWN OR OTHER
May 24, 2001
Incident date: May 4, 2001
THE OIL PRESSURE GUAGE HAS JUST QUIT WORKING PROPERLY, IT WILL NOT REGISTER WHEN THE TRUCK IS STARTED, BUT IF I HIT A BUMP OR STOP THE TRUCK AND TURN IT BACK ON, OR DRIVE FOR TWO MILES THE OIL GUAGE WILL POP INTO NORMAL RANGE. THE WINDSHIELD WIPERS COME ON BY THEMSELVES WHEN SWITCH IS OFF, EVERY TI... Read more
TIRES
May 24, 2001
Incident date: May 4, 2001
THE OIL PRESSURE GUAGE HAS JUST QUIT WORKING PROPERLY, IT WILL NOT REGISTER WHEN THE TRUCK IS STARTED, BUT IF I HIT A BUMP OR STOP THE TRUCK AND TURN IT BACK ON, OR DRIVE FOR TWO MILES THE OIL GUAGE WILL POP INTO NORMAL RANGE. THE WINDSHIELD WIPERS COME ON BY THEMSELVES WHEN SWITCH IS OFF, EVERY TI... Read more
VISIBILITY:WINDSHIELD WIPER/WASHER:SWITCH/WIRING
May 24, 2001
Incident date: May 4, 2001
THE OIL PRESSURE GUAGE HAS JUST QUIT WORKING PROPERLY, IT WILL NOT REGISTER WHEN THE TRUCK IS STARTED, BUT IF I HIT A BUMP OR STOP THE TRUCK AND TURN IT BACK ON, OR DRIVE FOR TWO MILES THE OIL GUAGE WILL POP INTO NORMAL RANGE. THE WINDSHIELD WIPERS COME ON BY THEMSELVES WHEN SWITCH IS OFF, EVERY TI... Read more
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
May 16, 2001
Incident date: Nov 25, 2000
DEFROSTER FAILED TO OPERATE PROPERLY WHILE DRIVING IN COLD/SNOWY/ICY CONDITI WINDSHIELD WILL ICE UP WHILE DRIVING, AND WHEN DEFROSTER IS ON "HIGH", IT FAILS TO CLEAR WINDSHIELD. DEALERSHIP HAD EXAMINED VEHICLE, AND CLAIMED THAT THEY HAVE REPAIRED THE DEFECT. PLEASE PROVIDE ANY ADDITIONAL INFOR... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
Apr 30, 2001
Incident date: Sep 12, 2000
WHILE DRIVING DOWN A HILL TRANSFER CASE DID NOT ENGAGE. CONSUMER TRIED TO ENGAGE AT BOTTOM OF HILL.*AK GEARS DID ENGAGE AT THE BOTTOM OF THE HILL. THE LACK OF 4''-LOW ENGAGEMENT CAUSED THE VEHICLE TO SPEED DANGEROUSLY. *YH
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Apr 25, 2001
Incident date: Dec 1, 2000
CONSUMER RECEIVED A RECALL 00V228002/ MANUFACTURER'S RECALL 11294 NOTICE FOR SEATBELT BUCKLES IN DECEMBER. HAS TAKEN VEHICLE TO DEALER ON SIX DIFFERENT OCCASIONS, AND DEALER STILL HAS NOT BEEN ABLE TO MAKE REPAIRS FOR VARIOUS REASONS. DEALER IS MAZDA IN STOCKTON,CA. *AK
Showing 50 of 74 complaints.
Technical Service Bulletins — 2000 MAZDA B-SERIES TRUCK
155 manufacturer communications from 112 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 22 |
| 110000 ELECTRICAL SYSTEM | 12 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 10 |
| 100000 POWER TRAIN | 9 |
| 060000 ENGINE AND ENGINE COOLING | 8 |
| 020000 SUSPENSION | 6 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 6 |
| 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY | 5 |
SA-011-24
Feb 12, 2024
010000 STEERING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
SA-011-24
Feb 12, 2024
030000 SERVICE BRAKES, HYDRAULIC
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
SA-011-24
Feb 12, 2024
060000 ENGINE AND ENGINE COOLING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
SA-011-24
Feb 12, 2024
100000 POWER TRAIN
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
SA-011-24
Feb 12, 2024
190000 TIRES
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
SA-011-24
Feb 12, 2024
200000 WHEELS
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
09-016-23
Feb 28, 2023
110000 ELECTRICAL SYSTEM
Speedometer replacement procedure
09-016-23
Feb 28, 2023
117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
Speedometer replacement procedure
02-004-22a
Nov 18, 2022
020000 SUSPENSION
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
01-010-22
Sep 26, 2022
100000 POWER TRAIN
Some customers may experience a squeaking noise may be heard from the exhaust manifold when the idle speed drops from fast idle to normal idle speed during cold start. This is caused by a variable valve being stuck in the closed position. W
09-024-22
Jul 18, 2022
117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer.
01-006-22
Jun 22, 2022
110000 ELECTRICAL SYSTEM
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in st
02-004-22
May 24, 2022
020000 SUSPENSION
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
SA-014-22
Mar 29, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Accessory instructions can be found on OneMazda under Dealer Resources - Parts & Accessories.
01-003/22
Mar 17, 2022
110000 ELECTRICAL SYSTEM
The Mazda DCA-8000 is required for all warranty battery testing. If the Mazda DCA-8000 is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to test
01-003/22
Mar 17, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
The Mazda DCA-8000 is required for all warranty battery testing. If the Mazda DCA-8000 is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to test
00-001-22
Feb 23, 2022
010000 STEERING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
00-001-22
Feb 23, 2022
030000 SERVICE BRAKES, HYDRAULIC
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
00-001-22
Feb 23, 2022
060000 ENGINE AND ENGINE COOLING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
00-001-22
Feb 23, 2022
100000 POWER TRAIN
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
01-006-21-3779b
Dec 21, 2021
110000 ELECTRICAL SYSTEM
Battery Maintenance: This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost.
05-002-21-3854
Dec 8, 2021
100000 POWER TRAIN
Automatic Transmission/Transaxle Cooler and Lines Flushing Procedure: Automatic Transaxle/Transmission (A/T) oil cooler and lines must be power flushed completely before an overhauled or replacement A/T is installed (except SKYACTIV-DRIVE)
01-006-21-3779a
Aug 24, 2021
060000 ENGINE AND ENGINE COOLING
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in sto
01-006-21-3779a
Aug 24, 2021
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in sto
09-025-21-3824
Aug 17, 2021
350000 EQUIPMENT
This service bulletin provides information regarding the proper use of the driver??A?A?s floor mat to avoid any potential interference with the foot pedals. The following are possible causes of floor mat interference, which can be avoided w
SA-041-21
Jun 9, 2021
350000 EQUIPMENT
Accessory instructions can be found on OneMazda under Dealer Resources - Parts & Accessories. The links provided below can be used for quick access: For 2016 models and newer: NOTE: Instructions are found under the "Attachments" section onc
01-005-21-3778
Feb 8, 2021
110000 ELECTRICAL SYSTEM
The Mazda DCA-8000PM is required for all warranty battery testing. If the Mazda DCA-8000PM is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to t
01-006-21-3779
Feb 8, 2021
110000 ELECTRICAL SYSTEM
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in sto
00-001-21-3768
Jan 21, 2021
010000 STEERING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-21-3768
Jan 21, 2021
060000 ENGINE AND ENGINE COOLING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-21-3768
Jan 21, 2021
100000 POWER TRAIN
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-21-3768
Jan 21, 2021
200000 WHEELS
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
09-002-21-3770
Jan 21, 2021
110000 ELECTRICAL SYSTEM
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
09-002-21-3770
Jan 21, 2021
180000 VEHICLE SPEED CONTROL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
09-002-21-3770
Jan 21, 2021
350000 EQUIPMENT
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
MT-002-20
Aug 3, 2020
199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
New CARB regulation regarding mandatory checking and documenting of tire pressure whenever a vehicle is in for service work. This applies to all service shops (including Mazda dealerships) in California effective September 1, 2010.
MT-002-20
Aug 3, 2020
200000 WHEELS
New CARB regulation regarding mandatory checking and documenting of tire pressure whenever a vehicle is in for service work. This applies to all service shops (including Mazda dealerships) in California effective September 1, 2010.
09-006-20-3673a
Jul 20, 2020
350000 EQUIPMENT
When encountering a vehicle with paint damage, refer to the "Mazda Paint Warranty Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
00-001-20-3689
Mar 12, 2020
030000 SERVICE BRAKES, HYDRAULIC
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-20-3689
Mar 12, 2020
060000 ENGINE AND ENGINE COOLING
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-20-3689
Mar 12, 2020
100000 POWER TRAIN
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
00-001-20-3689
Mar 12, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle specific workshop manual or owner's manu
09-006-20-3673
Jan 13, 2020
350000 EQUIPMENT
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable). Copies of the Mazda Pocket Paint Guide are available for order on Mazda e-
02-002-20-3651
Jan 9, 2020
020000 SUSPENSION
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
02-002-20-3651
Jan 9, 2020
350000 EQUIPMENT
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
02-002-20-3651
Jan 9, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
09-003-20-3671
Jan 9, 2020
110000 ELECTRICAL SYSTEM
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer??A?A?s responsibility
09-003-20-3671
Jan 9, 2020
350000 EQUIPMENT
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer??A?A?s responsibility
00-003-19-3583
Mar 20, 2019
060000 ENGINE AND ENGINE COOLING
In support of the new MRT distribution, Mazda will ship to dealers a new Dual Purpose Diagnostic Leak Detector beginning March, 2019. Training videos will be posted to MGSS shortly and Workshop Manual procedures will be revised gradually.
00-003-19-3583
Mar 20, 2019
070000 FUEL SYSTEM, GASOLINE
In support of the new MRT distribution, Mazda will ship to dealers a new Dual Purpose Diagnostic Leak Detector beginning March, 2019. Training videos will be posted to MGSS shortly and Workshop Manual procedures will be revised gradually.
00-003-19-3583
Mar 20, 2019
081100 FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
In support of the new MRT distribution, Mazda will ship to dealers a new Dual Purpose Diagnostic Leak Detector beginning March, 2019. Training videos will be posted to MGSS shortly and Workshop Manual procedures will be revised gradually.
00-003-19-3583
Mar 20, 2019
350000 EQUIPMENT
In support of the new MRT distribution, Mazda will ship to dealers a new Dual Purpose Diagnostic Leak Detector beginning March, 2019. Training videos will be posted to MGSS shortly and Workshop Manual procedures will be revised gradually.
00-001-19-3560
Jan 14, 2019
350000 EQUIPMENT
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle- specific workshop manual or owner's man
00-002-19-3561
Jan 14, 2019
030000 BRAKES (PWS)
Mazda North American Operations has approved an additional on-car brake lathe as an option for MNAO authorized equipment. The Pro-Cut On-Car Brake Lathe has been added to the MNAO authorized equipment program. NOTE: Accu-turn is still an ap
09-005-19-3562
Jan 14, 2019
350000 EQUIPMENT
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable). Copies of the Mazda Pocket Paint Guide are available for order on Mazda e-
09-009-19-3566
Jan 14, 2019
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to co
01-004-19-3558
Jan 9, 2019
060000 ENGINE AND ENGINE COOLING
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. The odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. Sulfur smell is not a
09-002-19-3554
Jan 3, 2019
356000 EQUIPMENT ADAPTIVE/MOBILITY
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid anypotential interference with the foot pedals. The following are possible causes of floor mat interference,which can be avoided with pro
01-001-19-3551
Jan 2, 2019
110000 ELECTRICAL SYSTEM
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in sto
01-002-19-3552
Jan 2, 2019
110000 ELECTRICAL SYSTEM
The Mazda GR8-1291 is required for all warranty battery testing. If the Mazda GR8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to test
02-001-19-3550
Jan 2, 2019
020000 SUSPENSION
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
00-001-18-3446a
Oct 10, 2018
350000 EQUIPMENT
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle- specific workshop manual or owner's man
00-001-18-3446a
Oct 10, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle- specific workshop manual or owner's man
00-003-18-3480a
Oct 10, 2018
030000 SERVICE BRAKES, HYDRAULIC
Mazda North American Operations has approved an additional on-car brake lathe as an option for MNAO authorized equipment. The Pro-Cut On-Car Brake Lathe has been added to the MNAO authorized equipment program. NOTE: Accu-turn is still an ap
00-003-18-3480a
Oct 10, 2018
350000 EQUIPMENT
Mazda North American Operations has approved an additional on-car brake lathe as an option for MNAO authorized equipment. The Pro-Cut On-Car Brake Lathe has been added to the MNAO authorized equipment program. NOTE: Accu-turn is still an ap
09-014-18-3443a
Oct 10, 2018
160000 STRUCTURE
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable). Copies of the Mazda Pocket Paint Guide are available for order on Mazda e-
09-014-18-3443a
Oct 10, 2018
350000 EQUIPMENT
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable). Copies of the Mazda Pocket Paint Guide are available for order on Mazda e-
09-034-18-3430a
Oct 10, 2018
180000 VEHICLE SPEED CONTROL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to co
09-034-18-3430a
Oct 10, 2018
350000 EQUIPMENT
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to co
01-016-18-3522
Sep 6, 2018
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. The odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. Sulfur smell is not a
09-034-18-3430
Aug 31, 2018
180000 VEHICLE SPEED CONTROL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer's responsibility to co
00-003-18-3480
May 11, 2018
030000 BRAKES (PWS)
Mazda North American Operations has approved an additional on-car brake lathe as an option for MNAOauthorized equipment. The Pro-Cut On-Car Brake Lathe has been added to the MNAO authorizedequipment program.NOTE: Accu-turn is still an appro
05-001-18-3453
Apr 2, 2018
100000 POWER TRAIN
Always be sure to use the correct automatic transmission fluid when replacing ATF. Using the wrong ATF may cause shift quality complaints or may even damage the transmission. NOTE: ATF M-V (TYPE M5) IS NOT THE SAME FLUID AS MERCON?V OR MERC
05-001-18-3453
Apr 2, 2018
350000 EQUIPMENT
Always be sure to use the correct automatic transmission fluid when replacing ATF. Using the wrong ATF may cause shift quality complaints or may even damage the transmission. NOTE: ATF M-V (TYPE M5) IS NOT THE SAME FLUID AS MERCON?V OR MERC
09-019-18-3450
Mar 26, 2018
356000 EQUIPMENT ADAPTIVE/MOBILITY
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. The following are possible causes of floor mat interference, which can be avoided with p
01-008-18-3451
Mar 26, 2018
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in sto
01-009-18-3452
Mar 26, 2018
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
The Mazda GR8-1291 is required for all warranty battery testing. If the Mazda GR8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. Use the following test procedures in this Service Bulletin to test
02-006-18-3449
Mar 26, 2018
021300 SUSPENSION:FRONT:SHOCK ABSORBER
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
02-006-18-3449
Mar 26, 2018
022400 SUSPENSION:REAR:SHOCK ABSORBER
Some customers may complain of signs of oil on the struts or shock absorbers. In most cases the oil that is present is normal, and a result of the oil that remains on the shaft during the normal sweeping process of the shaft seal. Follow th
00-001-18-3446
Mar 22, 2018
350000 EQUIPMENT
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Mazda recommends dealers follow the scheduled maintenance tables as cited in the vehicle-specific workshop manual or owner's manu
09-014-18-3443
Mar 22, 2018
160000 STRUCTURE
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable).
09-035-17-3080
Aug 7, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer?s responsibility to co
09-035-17-3080
Aug 7, 2017
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. It is the dealer?s responsibility to co
SA-061-17
Jul 12, 2017
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
In an effort to achieve a higher level of Customer Experience and retain the value of Mazda's vehicles, MNAO Warranty Operations is? 2017 Mazda North American Operations, U.S.A. allowing all Mazda dealers to utilize a third party, SPECMO En
0901216
Feb 26, 2016
350000 EQUIPMENT
Paint damage Mazda pocket paint guide
0100516
Feb 15, 2016
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Battery test procedure requirements using the GR81291
0100516
Feb 15, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Battery test procedure requirements using the GR81291
0900416
Feb 2, 2016
351420 EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:MATERIALS:FLOORING
PROPER USAGE OF DRIVER'S FLOOR MAT.
09-034-14-2956
Aug 15, 2014
356000 EQUIPMENT ADAPTIVE/MOBILITY
IN ACCORDANCE WITH FEDERAL REGULATIONS, FOLLOW THE PROCEDURE LISTED BELOW WHEN REPLACING A SPEEDOMETER.NOTE:?MAZDA VEHICLES ARE MANUFACTURED WITH TAMPER-PROOF SPEEDOMETERS.?WHEN A SPEEDOMETER IS REPLACED, THE NEW SPEEDOMETER WILL READ ZERO
00-002-14-2936
Jun 10, 2014
350000 EQUIPMENT
MAZDA NORTH AMERICAN OPERATIONS RECEIVED MANY REQUESTS FROM OUR DEALERS ASKING US TO APPROVE ADDITIONAL ON-CAR BRAKE LATHES AS AN OPTION FOR MNAO AUTHORIZED EQUIPMENT. DUE TO YOUR FEEDBACK AND AFTER EVALUATING A FEW ON-CAR BRAKE LATHES, WE
09-027-14-2935
Jun 10, 2014
356000 EQUIPMENT ADAPTIVE/MOBILITY
THIS SERVICE BULLETIN PROVIDES INFORMATION REGARDING THE PROPER USE OF THE DRIVER?S FLOOR MAT TO AVOID ANY POTENTIAL INTERFERENCE WITH THE FOOT PEDALS. THE FOLLOWING ARE POSSIBLE CAUSES OF FLOOR MAT INTERFERENCE, WHICH CAN BE AVOIDED WITH P
00-001-13-2748A
Apr 17, 2013
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
MAZDA HAS DEVELOPED FACTORY RECOMMENDED SCHEDULED MAINTENANCE SERVICES THAT SUPPORT ALL MAJOR VEHICLE SYSTEMS. MAZDA RECOMMENDS DEALERS FOLLOW THE SCHEDULED MAINTENANCE TABLES AS CITED IN THE VEHICLE-SPECIFIC WORKSHOP MANUAL OR OWNER?S MANU
SB-09-005-13
Mar 11, 2013
350000 EQUIPMENT
MAZDA: ON SOME VEHICLES, TO AVOID POTENTIAL INTERFERENCE OF FOOT PLACED ON PEDALS, INFORMATION IS PROVIDED REGARDING PROPER USE, AND PLACEMENT, OF DRIVER'S FLOOR MAT. VARIOUS MODELS AND MODEL YEARS. *PE
SB-09-005-13
Mar 11, 2013
356000 EQUIPMENT ADAPTIVE/MOBILITY
MAZDA: ON SOME VEHICLES, TO AVOID POTENTIAL INTERFERENCE OF FOOT PLACED ON PEDALS, INFORMATION IS PROVIDED REGARDING PROPER USE, AND PLACEMENT, OF DRIVER'S FLOOR MAT. VARIOUS MODELS AND MODEL YEARS. *PE
09-005-13-2781
Mar 11, 2013
350000 EQUIPMENT
THIS SERVICE BULLETIN PROVIDES INFORMATION REGARDING THE PROPER USE OF THE DRIVER?S FLOOR MAT TO AVOID ANY POTEN-TIAL INTERFERENCE WITH THE FOOT PEDALS. THE FOLLOWING ARE POSSIBLE CAUSES OF FLOOR MAT INTERFERENCE, WHICH CAN BE AVOIDED WITH
05-002-13-2777A
Mar 11, 2013
102400 POWER TRAIN:MANUAL TRANSMISSION:LUBRICANT
ALWAYS BE SURE TO USE THE CORRECT AUTOMATIC TRANSMISSION FLUID WHEN REPLACING ATF. USING THE WRONG ATF MAY CAUSE SHIFT QUALITY COMPLAINTS OR MAY EVEN DAMAGE THE TRANSMISSION.NOTE:?ATF M-V (TYPE M5) IS NOT THE SAME FLUID AS MERCON?V OR MERCO
05-002-13-2777
Mar 4, 2013
102400 POWER TRAIN:MANUAL TRANSMISSION:LUBRICANT
ALWAYS BE SURE TO USE THE CORRECT AUTOMATIC TRANSMISSION FLUID WHEN REPLACING ATF. USING THE WRONG ATF MAY CAUSE SHIFT QUALITY COMPLAINTS OR MAY EVEN DAMAGE THE TRANSMISSION.NOTE:?ATF M-V (TYPE M5) IS NOT THE SAME FLUID AS MERCON?V OR MERCO
05-002-13-2777
Mar 4, 2013
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
ALWAYS BE SURE TO USE THE CORRECT AUTOMATIC TRANSMISSION FLUID WHEN REPLACING ATF. USING THE WRONG ATF MAY CAUSE SHIFT QUALITY COMPLAINTS OR MAY EVEN DAMAGE THE TRANSMISSION.NOTE:?ATF M-V (TYPE M5) IS NOT THE SAME FLUID AS MERCON?V OR MERCO
00-001-13-2748
Jan 15, 2013
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
MAZDA HAS DEVELOPED FACTORY RECOMMENDED SCHEDULED MAINTENANCE SERVICES THAT SUPPORT ALL MAJOR VEHICLE SYSTEMS. MAZDA RECOMMENDS DEALERS FOLLOW THE SCHEDULED MAINTENANCE TABLES AS CITED IN THE VEHICLE-SPECIFIC WORKSHOP MANUAL OR OWNER?S MANU
02-001-13-2752
Jan 14, 2013
350000 EQUIPMENT
SOME CUSTOMERS MAY COMPLAIN OF SIGNS OF OIL ON THE STRUTS OR SHOCK ABSORBERS. IN MOST CASES THE OIL THAT IS PRESENT IS NORMAL, AND A RESULT OF THE OIL THAT REMAINS ON THE SHAFT DURING THE NORMAL SWEEPING PROCESS OF THE SHAFT SEAL. FOLLOW TH
Showing 100 of 155 bulletins.
NHTSA Safety Investigations — MAZDA B-SERIES TRUCK
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
EA96004
Opened: Apr 16, 1996 — Closed: Apr 9, 1997
REAR BRAKE LOCKUP
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF ... Read more
DP96001
Opened: Jan 3, 1996 — Closed: Apr 23, 1996
REAR ANTI-LOCK BRAKES LOCK UP
PETITIONER: ROGER YOUNG NHTSA#: ES95120208 ODI # 490741
PE92068
Opened: Jul 29, 1992 — Closed: Sep 30, 1992
WHEEL CRACKING
There is no summary currently available
MAZDA B-SERIES TRUCK — All Years Overview
Complete safety history for the MAZDA B-SERIES TRUCK across all model years (1990–2009).
65
Total Recalls
888
Total Complaints
3
Investigations
88
Reported Crashes
20
Reported Fires
34
Reported Deaths
MAZDA B-SERIES TRUCK — Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2009 | 5 | 4 | View |
| 2008 | 3 | 11 | View |
| 2007 | 3 | 37 | View |
| 2006 | 6 | 14 | View |
| 2005 | 3 | 17 | View |
| 2004 | 3 | 26 | View |
| 2003 | 1 | 25 | View |
| 2002 | 2 | 31 | View |
| 2001 | 3 | 55 | View |
| 2000 (current) | 3 | 74 | |
| 1999 | 4 | 96 | View |
| 1998 | 5 | 81 | View |
| 1997 | 2 | 64 | View |
| 1996 | 2 | 73 | View |
| 1995 | 2 | 54 | View |
| 1994 | 6 | 157 | View |
| 1993 | 2 | 18 | View |
| 1992 | 3 | 14 | View |
| 1991 | 4 | 15 | View |
| 1990 | 3 | 22 | View |