SUSPENSION:FRONT:HUB
ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.
Remedy: DEALERS WILL REPLACE BOTH FRONT HUBS. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON OR BEFORE SEPTEMBER 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
5,716 vehicles affected
PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE
ON CERTAIN TRUCKS EQUIPPED WITH MERITOR BRAND 12" X 4" DCM DRUM PARKING BRAKE, THE BOLTS USED TO ATTACH THE PARKING BRAKE ASSEMBLY TO THE FLANGE YOKE ARE TOO LARGE AND CAN INTERFERE WITH THE PROPER ENGAGEMENT OF THE BRAKING SYSTEM AND POSSIBLY DISENGAGE.
Remedy: DEALERS WILL REPLACE THE ATTACHING BOLTS WITH THE CORRECT SIZE BOLTS FREE OF CHARGE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING OCTOBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
548 vehicles affected
SERVICE BRAKES, AIR:CONTROLS, PEDALS AND LINKAGES
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THE BRAKE PEDAL PUSH ROD THAT ACTIVATES THE SERVICE BRAKES COULD FRACTURE.
Remedy: DEALERS WILL REPLACE THE BRAKE PEDAL PUSH ROD.
105,000 vehicles affected
SERVICE BRAKES, AIR:ANTILOCK
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND SCHOOL BUS CHASSIS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
Remedy: DEALERS WILL REPLACE THE ABS ECU.
35,405 vehicles affected
SUSPENSION:REAR:SPRINGS:AIR SUSPENSION SYSTEM
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS BUILT WITH DUAL LEAF SPRING TYPE AIR RIDE SUSPENSIONS AND VEHICLES BUILT WITH SINGLE LEAF SPRING TYPE AIR RIDE SUSPENSIONS. REAR SUSPENSION SPRINGS CAN FRACTURE THROUGH THE CENTER BOLT HOLE AFTER VEHICLE ASSEMBLY.
Remedy: FOR VEHICLES EQUIPPED WITH SINGLE LEAF SPRINGS, DEALERS WILL REMOVE AND REPLACE ALL SPRINGS. FOR VEHICLES EQUIPPED WITH DUAL LEAF SPRINGS, DEALERS WILL INSPECT FOR CRACKED SPRINGS AND REPLACE IF CRACKED.
13,545 vehicles affected
BRAKE SYSTEM LOCKING UP INTERMITTENTLY, AND ABS LIGHT WOULD MOMENTARILY STAY ON. ALSO, ENGINE STALLS WHENEVER ON A DEEP INCLINE; VEHICLE BEEN INTO DEALER SHOP ON FIVE OCCASIONS, AND PROBLEMS STILL REOCCURRING. *AK CONSUMER STATES VEHICLE DOES NOT HAVE TO BE ON AN INCLINE FOR IT TO STALL, IT JUST LOSES POWER. CONSUMER STATES CAB IS NOISY. CLUTCH HAS BEEN REPLACED 3 TIMES AND NEEDS REPLACED AGAIN. *SLC
BRAKE SYSTEM LOCKING UP INTERMITTENTLY, AND ABS LIGHT WOULD MOMENTARILY STAY ON. ALSO, ENGINE STALLS WHENEVER ON A DEEP INCLINE; VEHICLE BEEN INTO DEALER SHOP ON FIVE OCCASIONS, AND PROBLEMS STILL REOCCURRING. *AK CONSUMER STATES VEHICLE DOES NOT HAVE TO BE ON AN INCLINE FOR IT TO STALL, IT JUST LOSES POWER. CONSUMER STATES CAB IS NOISY. CLUTCH HAS BEEN REPLACED 3 TIMES AND NEEDS REPLACED AGAIN. *SLC
BRAKE SYSTEM LOCKING UP INTERMITTENTLY, AND ABS LIGHT WOULD MOMENTARILY STAY ON. ALSO, ENGINE STALLS WHENEVER ON A DEEP INCLINE; VEHICLE BEEN INTO DEALER SHOP ON FIVE OCCASIONS, AND PROBLEMS STILL REOCCURRING. *AK CONSUMER STATES VEHICLE DOES NOT HAVE TO BE ON AN INCLINE FOR IT TO STALL, IT JUST LOSES POWER. CONSUMER STATES CAB IS NOISY. CLUTCH HAS BEEN REPLACED 3 TIMES AND NEEDS REPLACED AGAIN. *SLC
BRAKE SYSTEM LOCKING UP INTERMITTENTLY, AND ABS LIGHT WOULD MOMENTARILY STAY ON. ALSO, ENGINE STALLS WHENEVER ON A DEEP INCLINE; VEHICLE BEEN INTO DEALER SHOP ON FIVE OCCASIONS, AND PROBLEMS STILL REOCCURRING. *AK CONSUMER STATES VEHICLE DOES NOT HAVE TO BE ON AN INCLINE FOR IT TO STALL, IT JUST LOSES POWER. CONSUMER STATES CAB IS NOISY. CLUTCH HAS BEEN REPLACED 3 TIMES AND NEEDS REPLACED AGAIN. *SLC