2016 FORD FIESTA

0 recalls, 253 complaints - 172 TSBs - 4/5 safety rating

No recalls found for this vehicle.

Complaint Statistics

253 total complaints 22 crashes 4 fires 21 injuries 3 deaths

Top Reported Components

Component	Complaints
POWER TRAIN	68
ENGINE	40
ELECTRICAL SYSTEM	25
UNKNOWN OR OTHER	24
STEERING	10
FUEL/PROPULSION SYSTEM	10
VEHICLE SPEED CONTROL	9
WHEELS	7
SEAT BELTS	6
SUSPENSION	6

Incident date: Nov 10, 2025

The contact owns a 2017 Mercedes-Benz GLC300. The contact stated that while driving approximately 30 MPH, the first panel of the panoramic sunroof went off track and failed to close as intended. The contact stated that while inspecting the vehicle, the panoramic sunroof glass was pushed down firmly,... Read more

Incident date: Oct 23, 2025

My wife was driving our 2019 Cadillac Escalade to work when the vehicle check engine light came on and started to smoke and shake violently. She avoided injury but the car was not drivable. A local independent service center said that the car's cylinder #1 was full of fuel, the spark plug was wet,... Read more

Incident date: Oct 23, 2025

The contact owns a 2017 Lincoln MKC. The contact stated that while driving at an undisclosed speed, the vehicle jerked. No warning lights were illuminated. The vehicle was taken to a transmission specialty shop and was diagnosed with torque converter failure, which caused transmission failure. The t... Read more

Incident date: Sep 22, 2025

The contact owns a 2022 GMC Terrain. The contact stated while driving approximately 25 MPH, the vehicle stalled, and the contact was unable to pull over to the side of the road. The contact stated that the message "Battery Critically Low" was initially displayed, and then the message "Engine and Tra... Read more

Incident date: Aug 15, 2024

The contact owns a 2024 Ford Bronco Sport equipped with Continental Tires, Tire Line: Cross Contact, Tire Size: 225/65R/17, and DOT Number: [XXX] . The contact stated that while driving at approximately 70 MPH, the contact heard an abnormally loud sound coming from the rear end of the vehicle, and t... Read more

Incident date: Aug 5, 2019

Coolant is being leaked into the #2 cylinder causing the car to misfire. Coolant isn't a lubricant and it causes wear in the cylinder. Also causes a misfire like water in your gas. I have a car that 98% of that this type of car works correctly but the broken 2% will cost $8000 due to the block needi... Read more

Incident date: Aug 5, 2019

RANDOMLY 'SERVICE ADVANCE TRAC', 'PRE-COLLISION ASSIST NOT AVAILABLE', LANE ASSIST NOT AVAILABLE', POWER ASSIST STEERING NOT AVAILABLE', HILL ASSIST NOT AVAILABLE', WARNING LIGHTS APPEAR. WHEN THEY DO I COMPLETELY LOSE POWER STEERING. WHICH IS EXTREMELY DANGEROUS WHILE DRIVING. MOST THE TIME I CAN T... Read more

Incident date: Aug 5, 2019

Service Shifter light came on dash, all gears on shifter , red lights came on. I was driving at 55 mph and could tell the car wasn’t accelerating and was slowing down . That’s when I noticed the Service Shifter light on dash. I was in a lot of traffic and couldn’t safely pull over , I was almo... Read more

Incident date: Jun 16, 2025

My 2022 Hyundai Palisade has repeatedly shut off while coming to a stop. The vehicle stalls unexpectedly, dashboard lights illuminate as if the vehicle is being restarted, and the gear sometimes shifts into neutral. I have to manually restart the car to resume driving. This issue has occurred multi... Read more

Incident date: Jun 16, 2025

After I did the recall several years ago, the problem came back. The key will not come out of the ignition. It's happened many times.

Incident date: Jun 26, 2025

The check engine light came on in my car. I was waiting for the dealer to call me to fix it for the 3rd time. I was on my way home when every electrical option on the vehicle turned on- wipers, lights, dash lights, brake- which caused the car to brake- then it turned off and I had no brakes, the car... Read more

Crash

Incident date: Jun 26, 2025

Crash

Incident date: Jun 10, 2025

The contact owns a 2023 Mercedes-Benz E450 Convertible equipped with Continental Tires, Tire Line: ProContact GX SSR, Tire Size: 245/40/R19, DOT Number: 16YOF989F4623. The contact stated that while driving at an undisclosed speed over a bumpy road surface, the front driver's side tire experienced a ... Read more

Incident date: Jun 9, 2024

The contact owned a 2024 Honda Civic. The contact stated that while driving at approximately 30 MPH, an abnormal loud explosion sound was coming from the vehicle. The contact managed to pull over to the shoulder of the road, and upon inspection, the dashboard began to emit black smoke. The contact s... Read more

Fire 1 injured

Incident date: Jun 19, 2022

HVAC plug pigtail Blower motor resistor Heater control harness Is available for inspection HVAC electrical plugin was badly burned and melted causing risk of fire Summer months created dangerous interior temperatures Winter months & inclement weather created physical distress- & created dangero... Read more

Incident date: Mar 5, 2025

My system keeps saying my seat needs Serviced for airbag system. Something electric is burning and something is happening with my radio system. It keeps changing to different stations or settings while music is playing

Incident date: Feb 26, 2025

1. My engine failed at 10,000 miles, seized up completely. 2. Safety was a HUGE risk factor as the engine went out while driving 65 mph in a dangerous canyon highway, which made me lose control of being able to drive the vehicle to safety as I was needing to coast to the top of a hill and then coast... Read more

Incident date: Jan 24, 2025

The contact owns a 2018 Honda Accord. The contact stated that while driving at approximately 65 MPH, an "Emission System Failure - Power may be Reduced - See your Dealer" message was displayed, and a red fuel pump warning light illuminated. The vehicle was taken to a dealer and was repaired under NH... Read more

Incident date: Jan 14, 2025

My car burns through approximately 1qt of oil every 500 miles or less. There is a known oil consumption issue and I have left multiple messages with Key Hyundai of Milford CT and do not receive a call back. Additionally today I was driving 25mph and my car was reading 4000rpm and then completely loc... Read more

Incident date: Jan 14, 2025

Incident date: Nov 6, 2024

Husbands car started making a ticking noise and was loosing power while driving, so we brought it into the dealership. It will be $5796.58 to fix the rocker arms and camshaft. The estimate is for rocker arm roller failed damaging the camshaft. We are thankful that it has not caused any major inci... Read more

Incident date: Feb 24, 2024

When accelerating from a stopped position, the throttle is staying stuck wide open. Without my foot on the accelerator, the engine still accelerates wide open. Stepping on the brake, doesn't do anything or make it stop. It has now happened 3 times in the last 2 weeks. I was not taking off at a... Read more

Incident date: May 27, 2024

See attached document for complaint.

Incident date: May 27, 2024

See attached document for complaint.

Incident date: Sep 6, 2023

The contact owns a 2015 Mercedes-Benz GLA250. The contact stated while attempting to accelerate, the vehicle hesitated before accelerating. While driving at various speeds, the vehicle was lagging with a loud rumbling sound coming from the rear of the vehicle. The contact depressed the accelerator p... Read more

Incident date: Feb 15, 2024

The car has less than 100,000 miles and has been diagnosed with coolant intrusion into the engine. This is a known issue and Ford has not recalled this particular model for the same issue it has done recalls for. It is discussed in TSB 19-2208. The only known repair according to Ford is to replace t... Read more

Incident date: Aug 2, 2024

Dorel Juvenile Group has made a significant change to its rules regarding all infant and convertible car seats across our Dorel Juvenile brands, including Maxi-Cosi, Safety 1st, and Cosco Kids. They have been stating for quite some time at Child Passenger Safety Conferences that this rule is retroac... Read more

Incident date: Jul 10, 2024

The contact owns a 2023 Volkswagen ID.4 equipped with Kumho Tires, Tire Line: Crugen HP71, Tire Size: 235/50/R20, DOT Number: (N/A). The contact stated while driving at an undisclosed speed, there was an abnormal sound and vibration coming from the vehicle. The contact stated that the abnormal sound... Read more

Incident date: Jul 10, 2024

Known problem with coolant leaking into cylinders could cause engine to seize at any moment while driving. Can’t afford to replace engine, so I’ll just keep driving it until it causes an issue…

Incident date: Jun 21, 2024

The contact owns a 2015 Toyota Tacoma equipped with Toyo Tires, Tire Line: Open Country A/T II, Tire Size: 265/70/R16, DOT Number: CXLJ17M2318. The contact stated that there were cracks between the treads on all four tires. The tires were replacement tires. The tires were not replaced. The manufactu... Read more

Incident date: May 21, 2024

What component or system failed or malfunctioned, and is it available for inspection upon request? - The transmission was jerking forward and taking a long time to shift. Including not shifting out of 3rd gear and almost locking tires when coming to a stop. How was your safety or the safety of othe... Read more

Incident date: Apr 30, 2024

•What component or system failed or malfunctioned, and is it available for inspection upon request? The engine shut off and I lost the ability to accelerate. The issue only resolved when I turned off the vehicle and opened my car door while on the highway and had oncoming cars driving next to me a... Read more

Incident date: Mar 5, 2024

See attached document for complaint

Incident date: Mar 4, 2024

The contact owns a 2023 Toyota Venza. The contact stated that while at a complete stop, the vehicle accelerated without warning as the accelerator pedal was released. As a result of the failure, the contact crashed into the rear end of another vehicle. The air bags did not deploy upon impact. A poli... Read more

Crash

Incident date: Mar 4, 2024

As a result of service on this vehicle that was provided by Nissan of McKinney in McKinney, Texas the vehicle was intentionally returned to the owner after servicing in an unsafe condition. The service included removal of a trailer hitch receiver and electrical harness that had been installed earli... Read more

Incident date: Oct 16, 2023

wife was driving in rush hour traffic about 8am , noticed the warning light low engine oil pressure light on the dash, from the left lane she made her way to the right of the 4 lane highway to the breakdown lane due, to the traffic it took her a couple of mins to make it to the right at which time... Read more

Incident date: Oct 16, 2023

Incident date: Dec 29, 2023

The vehicle experienced a breakdown due to the drive train coupler failed, a part that has an active recall notice (Ford 19S38 ) (NHTSA Safety recall 17V-408) and the failure of the recalled part caused significant damage to other mechanical parts of the vehicle. The Manufacturer has agreed to pay ... Read more

Incident date: Dec 29, 2023

Incident date: Sep 1, 2023

The contact owns a 2020 Mercedes-Benz E350. The contact stated while his wife was driving and stopped at a traffic signal, the gasoline saving START/STOP feature turned off the vehicle however, upon depressing the accelerator pedal, the vehicle failed to restart. The contact stated that the failure ... Read more

Incident date: Sep 1, 2023

Rear glass window shattered while driving. No debris hit it, basically it exploded.

Incident date: Dec 5, 2023

9/13/2022 I took my vehicle in to the dealer stating the vehicle felt like it was going to stall. I was told there was no code found so they couldn't do anything, passed off as nothing wrong. On 4/1/2023 the vehicle stalled while pulling into a parking lot and a car behind me had to honk because it ... Read more

Incident date: Nov 1, 2023

The frame on this truck broke. The frame tore in a manner that the lower control arm became disconnected from the vehicle. I recognize that l live in an area where rust issues are real, however l am also very experienced with metal working and fabrication and can reliably assure that corrosion is no... Read more

Incident date: Nov 29, 2023

The contact owns a 2019 Hyundai Elantra GT. The contact stated that after receiving the vehicle and following service updates with the dealer, he became aware that the tire pressure monitoring system was not functioning properly and was indicating incorrect tire pressure readings. The contact also s... Read more

Incident date: Oct 24, 2023

The contact owns a 2014 Chrysler 300C. The contact stated while driving 50 MPH, the vehicle lost motive power. The check engine warning light was illuminated. The vehicle was towed to the residence. An independent mechanic replaced the fuel pump and the fuel pump relays at the residence and informed... Read more

Incident date: Oct 10, 2023

Brake felt like it was sticking. Dealership looked at it and changed rubber piece. 10/16/2023 accident occurred. Air bags did not deplore. Car was totalled.

Crash

Incident date: Oct 19, 2023

The passenger restraint malfunction continues to alarm and the dealership states that it is a seat-pad sensor and want over $2000.00 to replace. From a number of BMW forums, it appears that this was a common problem with earlier models and a subsequent 15-year warranty extension was granted because... Read more

Incident date: Aug 21, 2023

The contact owns a 2017 Winnebago Fuse RV built on a 2016 Ford Transit chassis and equipped with Hankook Tires, Tire Line: Dynapro HT, Tire Size: 195/75/R16, DOT Number: T7W7HUH. The contact stated that while inspecting the RV it was discovered that all four tires had developed cracks that extended ... Read more

Incident date: Oct 19, 2021

I am having severe transmission issues. Gears are 'unavailable' and will switch me into D1, D2, and so on, all the way up to D8. I can feel the gears shifting (not in a good way), and if the brake is applied too suddenly it will fall out of gear and the service engine light is on, the car will not m... Read more

Incident date: Oct 19, 2021

The contact owns a 2016 Hyundai Sonata. The contact stated while driving at 55 MPH, other drivers started beeping the horn and shouting that the vehicle was on fire. The contact immediately veered to the side of the road. The contact then noticed flames under the front end of the vehicle, near the e... Read more

Fire

Showing 50 of 253 complaints.

NHTSA Safety Ratings, 2016 FORD FIESTA

2016 Ford Fiesta 5 HB FWD

Category	Rating
Overall Rating	4 / 5 ★★★★☆
Frontal Crash	4 / 5 ★★★★☆
Frontal Crash, Driver	5 / 5 ★★★★★
Frontal Crash, Passenger	4 / 5 ★★★★☆
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	4 / 5 ★★★★☆
Rollover Risk	14.3%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	No
Lane Departure Warning	No

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

Technical Service Bulletins, 2016 FORD FIESTA

172 manufacturer communications from 96 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
110000 ELECTRICAL SYSTEM	36
350000 EQUIPMENT	22
100000 POWER TRAIN	10
060000 ENGINE AND ENGINE COOLING	9
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER	9
060000 ENGINE (PWS)	8
118000 ELECTRICAL SYSTEM:SOFTWARE	8
353000 EQUIPMENT:ELECTRICAL	8

350000 EQUIPMENT

All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during ini

060000 ENGINE AND ENGINE COOLING

For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbocharg

160000 STRUCTURE

For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification numbe

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

Some 2016-2021 Ford and Lincoln vehicles equipped with SYNC 3 may exhibit a condition where the navigation voice prompts are inoperative after a SYNC map update. This may be due to an incomplete installation of the SYNC map software. If pos

118000 ELECTRICAL SYSTEM:SOFTWARE

110000 ELECTRICAL SYSTEM

Some 2015-2021 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTC) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. This may be due to small debris causing th

110000 ELECTRICAL SYSTEM

Some 2016-2021 Ford or Lincoln vehicles equipped with SYNC 3 or SYNC 4 may exhibit a blank screen or other various SYNC symptoms only when the vehicle is in transport mode. This is considered normal due to the power saving features enabled

110000 ELECTRICAL SYSTEM

Some 2016 MKS, 2016-2017 Navigator, 2016-2018 F-150/Focus/C-MAX/Edge/Fiesta/MKX/Transit Connect/Mustang, 2017-2018 Continental/Fusion/MKZ, 2017-2019 Explorer, 2016-2019 Escape/MKC/Flex/MKT/Taurus/Transit/Expedition/F-Super Duty, and 2018-20

060000 ENGINE AND ENGINE COOLING

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

060000 ENGINE AND ENGINE COOLING

Some 2009-2020 Ford and Lincoln vehicles equipped with turbochargers may exhibit an oil leak from the turbocharger oil supply or return tubes, O-rings or 6.7L pedestal gasket. Although oil may collect on the turbocharger, it is very rare fo

110000 ELECTRICAL SYSTEM

Some 2011-2019 Fiesta vehicles may exhibit various concerns following IPC replacement. Symptoms may include: no crank, 'Contact Hotline message', odometer displaying incorrect English or Metric units and/or diagnostic trouble code (DTC) U21

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

118000 ELECTRICAL SYSTEM:SOFTWARE

Some 2016 MKS, 2016-2017 Navigator, 2016-2018 F150/Focus/CMAX/Edge/Fiesta/MKX/ Transit Connect/Mustang, 2017-2018 Continental/Fusion/MKZ, 2017-2019 Explorer, 2016-2019 Escape/MKC/Flex/MKT/Taurus/Transit/Expedition/F-Super Duty, and 2018-201

110000 ELECTRICAL SYSTEM

Some 2016-2020 Ford and Lincoln vehicles equipped with a SYNC 3 Touchscreen may experience the volume control unresponsive from the Front Control Interface Module (FCIM) and steering volume controls when using Apple Car Play. When the Apple

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

SSM 48619 - Various Vehicles - Perimeter Alarm Armed And Original Vehicle Keys Cannot Be Accessed to Enter Vehicle - CAN Protection Strategy Some 2013-2016 Model Year Vehicles may exhibit a concern in which the Perimeter Alarm is active

980000 UNKNOWN OR OTHER

110000 ELECTRICAL SYSTEM

Some 2014-2018 Fiesta vehicles may exhibit a clicking noise from the driver side dash panel while operating the air distribution control. This may be due to a damaged door actuator and/or contact between the instrument panel (IP) ground and

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

100000 POWER TRAIN

Some 2015-2020 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. This may be due to small debris causing t

110000 ELECTRICAL SYSTEM

Some 2016-2019 vehicles equipped with SYNC 3 may experience a map displayed on the left half of the SYNC screen with no other information/soft buttons present after updating to the latest version of V3.0 software. This issue occurs when the

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

Some 2013-2020 vehicles equipped with an EVDC air conditioning (A/C) compressor may exhibit poor A/C performance/improper climate function. To support the proper diagnosis of this compressor, the EVDC control valve tester has been provided

130000 VISIBILITY

Some 2010-2020 vehicles may exhibit distorted glass with a subtle orange peel pattern or streaking etched into the surface. This is caused by hydrofluoric acid which is used in some car wash solutions as a cleaning agent. Hydrofluoric acid

132000 VISIBILITY:GLASS, SIDE/REAR

100000 POWER TRAIN

Short-Term DPS6 Dealer Customer Handling Direction

110000 ELECTRICAL SYSTEM

Some 2016-2019 Ford and Lincoln vehicles equipped with SYNC 3 not at the latest software level may exhibit Various Performance Related concerns such as Display Operation, Navigation, Voice Recognition, Phone Pairing, Applink, Travel Link, S

100000 POWER TRAIN

On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Also verify that the engine/tran

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

Some 2013-2019 vehicles equipped with a EVDC air conditioning (A/C) compressor may exhibit poor A/C performance/improper climate function and/or a diagnostic trouble code (DTC) P06A0 in the powertrain control module (PCM). To support the pr

110000 ELECTRICAL SYSTEM

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

060000 ENGINE AND ENGINE COOLING

Some 2016-2019 Fiesta vehicles built on or before 19-Feb-2019 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P0128 stored in the powertrain control module (PCM). This may be due to some PCM so

110000 ELECTRICAL SYSTEM

SSM 47927 - 2017 F-Super Duty, 2016-2017 Expedition/Navigator, 2016-2018 Focus/Fiesta - Radio Reverting To AM Or FM After Vehicle Shut Down and Start Up Some 2017 F-Super Duty, 2016-2017 Expedition/Navigator and 2016-2018 Focus/Fiesta vehi

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

110000 ELECTRICAL SYSTEM

Some 2017 F-Super Duty and 2016-2018 Fiesta vehicles may exhibit a concern where the radio will revert to an AM or FM station after the vehicle's ignition has been turned off and turned back on. To address this condition, reprogram the audi

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

110000 ELECTRICAL SYSTEM

Some 2015-2017 vehicles may experience a no crank concern due to a security access key table error. When attempting to program keys or perform a parameter reset, the procedure may fail and the Integrated Diagnostic System (IDS) scan tool ma

110000 ELECTRICAL SYSTEM

350000 EQUIPMENT

Some 2012-2019 Vehicles may require repairs to the Smartlink system. Smartlink is a Ford Licensed Accessory which has a warranty provided by the accessory manufacturer. Warranty replacement parts for Smartlink that are ordered through Ford

110000 ELECTRICAL SYSTEM

Some 2016-2019 Ford and Lincoln vehicles equipped with SYNC 3 and a 6, 8 or 10 inch screen may show a pop-up message every key cycle that states 'SYNC can check for updates when connected to a WiFi network'. To remove the inconvenience of t

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

Some 2017 F-Super Duty, 2016-2017 Expedition/Navigator and 2016-2018 Focus/Fiesta vehicles may exhibit a concern where the radio reverts to an AM or FM station after shutting the vehicle off, leaving it off for at least 20 minutes, and then

060000 ENGINE AND ENGINE COOLING

2014-2017 Fiesta, 2015-2018 Focus, 2018-2019 Ecosport vehicles equipped with a 1.0L EcoBoost engine may exhibit coolant consumption,white smoke and/or a runs rough condition. Refer to the extended coolant pressure test in Workshop Manual (W

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

Some 2016-2018 Ford and Lincoln vehicles equipped with SYNC 3 may exhibit the Android Auto Preference menu selection is not present after an update to version 3.0 software. In prior versions of SYNC 3 software this menu was present, however

110000 ELECTRICAL SYSTEM

Some 2016-2018 Ford and Lincoln vehicles equipped with SYNC 3 not at the latest software level may exhibit Various Performance Related concerns such as Display Operation, Navigation, Voice Recognition, Phone Pairing, Applink, Travel Link, S

110000 ELECTRICAL SYSTEM

Some 2011-2018 Fiesta vehicles may exhibit various concerns following IPC replacement. Symptoms may include: no crank, Contact Hotline message, odometer displaying incorrect English or Metric units and/or diagnostic trouble code (DTC) U21

060000 ENGINE AND ENGINE COOLING

This article supersedes TSB 18-2024 to update the model years. Some 2011-2018 Fiesta vehicles may exhibit a lack of heat resulting from a frozen blower motor. This may be caused by snow entering through the cowl panel grille and screen asse

110000 ELECTRICAL SYSTEM

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

110000 ELECTRICAL SYSTEM

Various 2016-2018 vehicles with SYNC 3 may experience a touch screen that does not respond to any input. Using the Professional Technician Society (PTS) website > OASIS tab > SYNC version, verify the vehicle SYNC software version. If the ve

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

Some 2016-2018 Ford and Lincoln vehicles with SYNC 3 may exhibit an intermittent blue or black screen. Check for SYNC software update under the OASIS Tab SYNC selection. If update is available refer to WSM, Section 415-00 and update APIM so

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

118000 ELECTRICAL SYSTEM:SOFTWARE

Some 2016-2017 Ford and Lincoln vehicles equipped with SYNC 3 version 2.2 software may exhibit a blank screen after attempting to exit Valet mode. SYNC software updates are now available under the OASIS Tab SYNC selection. If update is avai

350000 EQUIPMENT

Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or Linco

110000 ELECTRICAL SYSTEM

Various 2016-2017 vehicles with SYNC 3 may experience a touch screen that does not respond to any input. Using the Professional Technician Society (PTS) website > OASIS tab > SYNC version, verify the vehicle SYNC software version. If the ve

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

2010-2018 various vehicles equipped with SYNC or SYNC 3 may not function when attempting to find or use the Spotify app via AppLink. As of an update released on 1/15/2018 Spotify will no longer be supporting their AppLink integration. No re

350000 EQUIPMENT

The procedure in video has not changed. The new screen (D2BZ-18D395-A) installation is the same as the previous level part used in the video. The video is located under GSB G0000060.

353000 EQUIPMENT:ELECTRICAL

110000 ELECTRICAL SYSTEM

350000 EQUIPMENT

353000 EQUIPMENT:ELECTRICAL

118000 ELECTRICAL SYSTEM:SOFTWARE

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

Some 2011-2017 Fiesta vehicles may exhibit a lack of heat resulting from a frozen blower motor. This may be caused by snow entering through the cowl panel grille and prior screen assemblies. Snow may melt in the heating, ventilation and air

350000 EQUIPMENT

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

060000 ENGINE (PWS)

118000 ELECTRICAL SYSTEM:SOFTWARE

Some 2011-2017 Fiesta vehicles may exhibit various concerns following IPC replacement including odometer displaying incorrect English or Metric units and/or diagnostic trouble code (DTC) U2101 in multiple modules. If Programmable Module Ins

353000 EQUIPMENT:ELECTRICAL

The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts a

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

350000 EQUIPMENT

353000 EQUIPMENT:ELECTRICAL

110000 ELECTRICAL SYSTEM

Some 2016-2017 Ford and Lincoln vehicles with SYNC 3 may intermittently display an overhead image of a vehicle in the center of the SYNC touchscreen with no obstacle detection grids or warning chimes. SYNC may appear unresponsive when the o

350000 EQUIPMENT

270000 LANE DEPARTURE

280000 BACK OVER PREVENTION

110000 ELECTRICAL SYSTEM

Some owners of 2016-2017 Ford and Lincoln vehicles equipped with SYNC 3 may experience inoperative mobile device navigation applications. Mobile device navigation via AppLink requires SYNC 3 version 2.3 or higher for Apple iOS users. Mobile

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

110000 ELECTRICAL SYSTEM

350000 EQUIPMENT

100000 POWER TRAIN

Some 2016-2017 Fiesta ST vehicles may exhibit a clunk noise while shifting from 1st to 2nd gear. To correct this condition replace the front left C1BZ-3B437-A and right C1BZ-3B436-A half shafts. Refer to Workshop Manual (WSM), Section 205-0

350000 EQUIPMENT

353000 EQUIPMENT:ELECTRICAL

Some 2016-2018 Ford or Lincoln vehicles equipped with SYNC 3 may exhibit a blank screen or other various SYNC symptoms only when the vehicle is in transport mode. This is due to the power saving features enabled while in transport mode and

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (MIL) and a DTC P161A after PCM replacement. This may be due to the parameter reset procedure not being properly completed. To clear this DTC, use

110000 ELECTRICAL SYSTEM

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

353000 EQUIPMENT:ELECTRICAL

118000 ELECTRICAL SYSTEM:SOFTWARE

Some 2016-2017 Ford and Lincoln vehicles with SYNC 3 may exhibit an intermittent blue or black screen. Check for SYNC software update under the OASIS Tab SYNC selection. If update is available refer to WSM, Section 415-00 and update APIM so

118000 ELECTRICAL SYSTEM:SOFTWARE

Some 2016-2017 Ford and Lincoln vehicles equipped with SYNC 3 version 2.2 software may exhibit a blank screen after attempting to exit Valet mode. To recover the screen, perform a complete ignition cycle (key off, open and close the driver'

353000 EQUIPMENT:ELECTRICAL

Some 2016-2017 Edge, Escape, Expedition, Fiesta, Flex, MKC, MKT, MKX, Mustang, Navigator and Taurus or 2017 Explorer and Super Duty vehicles equipped with SYNC 3 and built on 1-Jul-2015 and through 31-Dec-2016 may exhibit a SYNC display mes

284000 BACK OVER PREVENTION: CAMERA SYSTEM

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

SOME 2016-2017 FORD OR LINCOLN VEHICLES EQUIPPED WITH SYNC 3 MAY EXHIBIT A BLANK SCREEN OR OTHER VARIOUS SYNC SYMPTOMS ONLY WHEN THE VEHICLE IS IN TRANSPORT MODE. THIS IS CONSIDERED NORMAL DUE TO THE POWER SAVING FEATURES ENABLED WHILE IN T

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

SOME 2016 FIESTA VEHICLES EQUIPPED WITH EATC MAY EXHIBIT A LACK OF HEAT IN SETTINGS OTHER THAN HIGH AUTO. REPROGRAM THE HEATING VENTILATION AND AIR CONDITIONING (HVAC) MODULE TO LATEST CALIBRATION USING THE INTEGRATED DIAGNOSTIC SYSTEM (IDS

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

2011-2017 FIESTA AND 2012-2017 FOCUS SERVICE PIGTAIL FOR TRANSMISSION CONTROL MODULE CONNECTOR C1750A IS AVAILABLE. IF REPAIRS ARE NEEDED USE PART NUMBER FU2Z-14S411-VA. REPLACEMENT OF WIRING HARNESS 12A581 IS NO LONGER REQUIRED WHEN THIS C

356000 EQUIPMENT ADAPTIVE/MOBILITY

2013-2016 FIESTA, ESCAPE, TRANSIT CONNECT AND 2013 FUSION VEHICLES WITH A 1.6L GASOLINE TURBOCHARGED DIRECT INJECTION (GTDI) ENGINE MAY EXHIBIT AN ENGINE OIL LEVEL READING THAT IS UP TO 8 MM ABOVE THE MAXIMUM MARK ON THE ENGINE OIL DIPSTICK

060000 ENGINE (PWS)

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

SOME 2016-2017 FIESTA VEHICLES EQUIPPED WITH A 1.0L GASOLINE TURBO DIRECT INJECTION (GDTI) ENGINE AND BUILT ON OR BEFORE 6-JAN-2017 MAY EXHIBIT AN ILLUMINATED MIL WITH DTC P04DB (CRANKCASE VENTILATION SYSTEM DISCONNECTED) STORED IN POWERTRA

Showing 100 of 172 bulletins.

NHTSA Safety Investigations, FORD FIESTA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Open , Model Year: 2014

Timing Belt Failure

The Office of Defects Investigation (ODI) has received 44 complaints alleging loss of motive power in model year (MY) 2015-2017 Ford Fiesta and MY 2015-2018 Ford Focus vehicles manufactured by Ford Motor Company. These vehicles are equipped with a 1.0L engine and manual transmission. Some consumers ... Read more

EA, Closed , Model Year: 2011

Door Latch Failure

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2011-2013 Ford Fiesta, MY 2013 Ford Fusion and MY 2013 Lincoln MKZ vehicles. All of the affected vehicles share the same door latc... h design.ODI has received 281 unique reports related to the alleged problem, with over 100 claiming that the door(s) opened inadvertently while the vehicle was in motion. There were no crashes reported however three separate injuries were indicated, all caused by a rebounding door striking a consumer after they attempted to close it. In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 1,102 unique reports related to the alleged problem. There were no injury claims but there were two claims of low speed accidents occurring involving the door opening while driving and damaging property. Ford also submitted 10,883 warranty claims related to door latch failures.Many customers indicated that the door would not latch at all and accordingly they decided to restrain the door by other means (looping the seatbelt through the door, or using rope or tape) in order to drive the vehicle.Some customers also reported multiple door latch failures occurring on the same vehicle on different doors occurring months apart.On April 23rd, 2015 Ford notified ODI that it would conduct a safety recall (15V-246) to remedy door latches failures on certain MY 2011-2014 Ford Fiesta and MY 2013-2014 Ford Fusion and Lincoln MKZ vehicles.According to Ford, the pawl spring tab located within the door latch can break off, or separate and result in a ?door will not close condition.The recalled vehicles include Fiesta vehiclesmanufactured from the start of the MY 2011 to May 2013 and Fusion and MKZ vehicles manufactured from the start of the MY 2013 year until May 2013.In May 2013 Ford reports that it made a manufacturing quality control change, specific to the spring tab, to improve the performance of the existing part.The door latch spring tab was redesigned and the new latch was phased into production in December 2014 with a new part number.Ford will replace all four door latches on the affected vehicles with the new latch design currently in production.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.Read more

PE, Closed , Model Year: 2011

Door Latch Failure

On September 11, 2014 the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE14-028) to investigate claims of doors failing to latch and/or inadvertently opening on model year (MY) 2011-2013 Ford Fiesta vehicles. ODI has received 207 unique reports related to the alleged proble... Read more

FORD FIESTA - All Years Overview

Complete safety history for the FORD FIESTA across all model years (1978, 2019).

26 Total Recalls

4,333 Total Complaints

3 Investigations

195 Reported Crashes

46 Reported Fires

13 Reported Deaths

FORD FIESTA - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2019	3	113	View
2018	0	46	View
2017	0	104	View
2016 (current)	0	253
2015	4	367	View
2014	7	652	View
2013	3	917	View
2012	3	833	View
2011	3	1,039	View
2002	0	1	View
2001	0	1	View
1991	0	3	View
1989	0	1	View
1988	0	1	View
1978	3	0	View

Other FORD Models

Model	Recalls	Complaints
MUSTANG	1,104	11,600	View
RANGER	928	10,371	View
F-350 SD	776	2,363	View
F-450 SD	692	624	View
F-150	692	46,142	View
F-250 SD	638	3,635	View
EXPLORER	624	42,549	View
F-550 SD	578	603	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2016 FORD FIESTA

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2016 FORD FIESTA

Safety Technology

Technical Service Bulletins, 2016 FORD FIESTA

Most Affected Components

NHTSA Safety Investigations, FORD FIESTA

FORD FIESTA - All Years Overview

FORD FIESTA - Year by Year

Other FORD Models