1995 FORD F800
5 recalls, 2 complaints - 13 TSBs
95V143000 Aug 2, 1995
VEHICLE SPEED CONTROL
Defect Description
THE HAND THROTTLE CABLE CAN WEAR THE BRASS SWIVEL BLOCK ON THE GOVERNOR LEVER THROUGH WHICH IT PASSES.
Consequence
THIS WEAR CAN RESULT IN THE GOVERNOR JAMMING IN THEDAMAGED SWIVEL AND COULD PREVENT THE GOVERNOR LEVER FROM RETURNING TO THE IDLE POSITION.
Remedy
DEALERS WILL INSTALL A REVISED GOVERNOR LEVER WITH A STAINLESS STEEL SWIVEL. ALSO LETTERS WILL BE SENT TO VEHICLE OWNERS THAT HAVE THE SAME VEHICLES BUT DO NOT HAVE A FORD INSTALLED HAND THROTTLE ADVISING THEM THAT THEY MAY REQUIRE SERVICE IF THEY HAVE HAD AN AFTER MARKET HAND THROTTLE INSTALLED.
95E003008 Jun 13, 1995
SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
Defect Description
AIR SYSTEM BLOCKAGE IN THE AIR DRYER OCCURS DEGRADING THE MOISTURE REMOVING CAPABILITIES OF THE DRYER WHEN THE VEHICLE IS OPERATED IN A COLD ENVIRONMENT AND MOISTURE ACCUMULATES AND FREEZES IN THE AIR DRYER OR IN THE LINE BETWEEN THE DRYER AND THE AIR SYSTEM RESERVOIR. THE AIR DRYER CAN BECOME OVERP... Read more
Consequence
IF THE AIR DRYER SEPARATES FROM THE BASE, THE CARTRIDGE CAN SEPARATE SUFFICIENTLY ENOUGH TO CAUSE PERSONAL INJURY OR PROPERTY DAMAGE.
Remedy
DEALERS WILL EQUIP AIR SYSTEMS WITH A PRESSURE RELIEF VALVE TO BE LOCATED BETWEEN THE COMPRESSOR AND THE AIR DRYER. THIS PRESSURE RELIEF VALVE IS INTENDED TO VENT IF EXCESSIVE PRESSURE DEVELOPS IN THE AIR DRYER.
95V092000 May 9, 1995
ELECTRICAL SYSTEM:WIRING
Defect Description
A CONNECTOR IN THE WIRING WHERE THE TILT HOOD MOUNTED LAMPS ATTACH TO THE VEHICLE WIRING HARNESS WAS BUILT WITHOUT SEALING PLUGS. MOISTURE, ROAD SALT OR OTHER CONTAMINANTS CAN ENTER THE CONNECTION RESULTING IN CROSSED CIRCUITS, SHORTS OR CORROSION OF THE WIRING OF THE CONNECTOR.
Consequence
THE HEADLAMPS OR OTHER FRONT-END LIGHTING SYSTEMS CAN MALFUNCTION AS A RESULT OF THIS CONDITION INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy
DEALERS WILL INSPECT THE CONNECTOR AND INSTALL SEALING PLUGS IN THE OPEN CAVITIES. IF THE INSPECTION REVEALS CORROSION, A NEW CONNECTOR WILL BE INSTALLED.
94V244000 Dec 12, 1994
STEERING:LINKAGES:DRAG:LINK:CONNECTION
Defect Description
THE DRAG LINK INSTALLED CAN CONTACT THE FRONT AXLE I-BEAM UNDER CERTAIN EXTREME CONDITIONS. THIS DRAG LINK WAS NOT INTENDED TO BE INSTALLED ON "LOW PROFILE" VEHICLES.
Consequence
THIS CAN RESULT IN LOSS OF STEERING CONTROL.
Remedy
DEALERS WILL INSTALL THE CORRECT DRAG LINK ON THE VEHICLES.
94V235000 Nov 28, 1994
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
Defect Description
THE VEHICLES WERE MANUFACTURED WITHOUT SEPARATE ABS INDICATOR LAMPS. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS."
Consequence
CONSEQUENCE OF NON-COMPLIANCE: THE BRAKE SYSTEM COULD FAIL AND THE DRIVER WOULD HAVE NO WARNING.
Remedy
DEALERS WILL INSTALL ABS INDICATOR LAMP AND CIRCUITRY.
Complaint Statistics
2 total complaints
Top Reported Components
| Component | Complaints |
|---|---|
| POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT | 1 |
| SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS | 1 |
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
Oct 2, 1996
Incident date: Sep 29, 1996
FAILURE OF THE BRAKES, CONSUMER WAS DRIVING AT HIGH SPEED AND THE CONSUMER COULD NOT STOP THE VEHICLE, CAUSING THE CONSUMER TO HAVE A NEAR ACCIDENT.*AK CONSUMER STATES HYDRAULIC RETURN LINE FITTING BRAKES OUT OF HYDRAULIC PUMP HOUSING, DUE TO VIBRATION, WHEN THIS OCCURS ALL FLUID IS DUMPED OUT RESU... Read more
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
Jan 17, 1996
Incident date: Jan 4, 1996
THE FRONT LEFT WHEEL HAS FALLEN OFF DUE TO WRONG SIZE BEARING IN FRONT AXLE. TT
Technical Service Bulletins, 1995 FORD F800
13 manufacturer communications from 12 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 114100 ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD | 2 |
| 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE | 2 |
| 063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE | 2 |
| 101100 POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE) | 2 |
| 107000 POWER TRAIN:AXLE HUBS | 1 |
| 114000 ELECTRICAL SYSTEM:WIRING | 1 |
| 044000 SERVICE BRAKES, AIR:DRUM | 1 |
| 112000 ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR | 1 |
01127
Jun 25, 2001
061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
SOME VEHICLES EQUIPPED WITH 26 INCH DIAMETER FANS MAY EXHIBIT AN ENGINE OVERHEAT CONDITION. *TT
991311
Jun 28, 1999
015300 STEERING:HYDRAULIC POWER ASSIST:POWER STEERING FLUID
CONDITIONS WITH POWER STEERING FLUID LEAKING FROM THE BRAKE PUMP RESERVOIR AT 90 DEGREE ELBOW ON SOME VEHICLES. *TT
98156
Aug 3, 1998
063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE. *AK
4709
Aug 1, 1998
101100 POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
11817
Aug 1, 1998
101100 POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT
962213
Oct 21, 1996
063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE. *TW
951713
Aug 1, 1995
112000 ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
GENERATOR-MOTORCRAFT 95AMP-FRONT BEARING CONCERN-FD1060/1460 ENGINES- VEHICLES BUILT BEFORE 7/3/95. *SD
951714
Aug 1, 1995
061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
ENGINE- 'KNOCKING' NOISE - WHEN OPERATING ENGINE AT 200-2300 RPM - FD1460 ENGINE
951516
Jul 1, 1995
044000 SERVICE BRAKES, AIR:DRUM
BRAKES-REAR-RE-INDEX REAR/REAR BRAKE CHAMBER OR ELIMINATE INTERFERENCE WITH DSO ASPHALT SPREADER OPTION-TANDEM AXLE VEHICLES USED IN ASPHALT SPREADER APPLICATIONS.*SD
BC4284950601
Jun 1, 1995
107000 POWER TRAIN:AXLE HUBS
UNKNOWN
951115
Jun 1, 1995
114000 ELECTRICAL SYSTEM:WIRING
STALL OR NO START - FUEL SHUTDOWN SOLENOID - WIRING CHAFING ON FUEL INJECTOR LINES-VEHICLES BUILT BEFORE 10/19/94 WITH FD1060 ENGINE AND BOSCH P7100 FUEL INJECTION PUMP. *TW
951115
Jun 1, 1995
114100 ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
STALL OR NO START - FUEL SHUTDOWN SOLENOID - WIRING CHAFING ON FUEL INJECTOR LINES-VEHICLES BUILT BEFORE 10/19/94 WITH FD1060 ENGINE AND BOSCH P7100 FUEL INJECTION PUMP. *TW
95723
Apr 1, 1995
114100 ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
THE ENGINE WIRING HARNESS MAY BECOME PINCHED BETWEEN THE CAB AND LEFT HAND FRAME RAIL. *TW
FORD F800 - All Years Overview
Complete safety history for the FORD F800 across all model years (1979, 1998).
28
Total Recalls
24
Total Complaints
0
Investigations
1
Reported Crashes
2
Reported Fires
0
Reported Deaths
FORD F800 - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.