2002 CHEVROLET VENTURE

6 recalls, 284 complaints - 518 TSBs

STEERING

Defect Description

DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN... Read more

Consequence

A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.

Remedy

DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.

979 vehicles affected

Manufacturer: DORMAN PRODUCTS, INC.

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND A... Read more

Consequence

WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy

K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.

1,921 vehicles affected

Manufacturer: K2 MOTOR CORPORATION

FUEL SYSTEM, GASOLINE:STORAGE

Defect Description

ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).

Consequence

A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy

DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHIC... Read more

20,594 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

Defect Description

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Consequence

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Remedy

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

742 vehicles affected

Manufacturer: DELPHI

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Defect Description

ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.

Consequence

IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.

Remedy

DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT ... Read more

717,302 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

AIR BAGS:FRONTAL

Defect Description

CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.

Consequence

PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.

Remedy

DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CON... Read more

133,221 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

Complaint Statistics

284 total complaints 13 crashes 4 fires 29 injuries 1 deaths

Top Reported Components

Component	Complaints
ENGINE AND ENGINE COOLING	20
ELECTRICAL SYSTEM	14
FUEL SYSTEM, GASOLINE	13
FUEL/PROPULSION SYSTEM	13
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	12
ENGINE AND ENGINE COOLING:COOLING SYSTEM	11
STRUCTURE:BODY:DOOR	11
SERVICE BRAKES, HYDRAULIC	10
LATCHES/LOCKS/LINKAGES:DOORS:LATCH	9
ENGINE AND ENGINE COOLING:ENGINE	8

Incident date: Oct 28, 2021

The contact owns a 2002 Chevrolet Venture. The contact stated that while the vehicle was parked, a fuel odor was detected inside the cabin of the vehicle. Additionally, the vehicle was consuming an excessive amount of fuel. The contact's neighbor, an independent mechanic, diagnosed that there was fu... Read more

Incident date: Oct 23, 2020

BLOWN INTAKE MANIFOLD GASKET. VEHICLE DID NOT HAVE AN OVERHEATING ISSUE, AND HAS BEEN WELL MAINTAINED SINCE I'VE OWNED IT. DROVE ACROSS A STEEP 7 MILE HILL, TEMP GAUGE STARTED MOVING ABOVE NORMAL. I STOPPED AND LET IT COOL DOWN, MOTOR GOT TO ABOUT 245 DEGREES WELL BEFORE ANY WARNING LIGHTS WERE ABLE... Read more

Incident date: Aug 23, 2018

SUDDENLY MY VEHICLE HAD A STRONG GASOLINE ODOR WHEN I WALKED UP ON IT IN THE MORNING I SMELLED IT 3 FEET AWAY FROM MY VEHICLE. IT HAPPENED JUST LIKE THAT ALL OF A SUDDEN. I SCHEDULED MY INSPECTION WITH MY MECHANIC AND I TOLD HIM I SUDDENLY WAS SMELLING A STRONG ODOR OF GAS. MY MECHANIC CALLED AND IN... Read more

Incident date: Sep 8, 2017

FUEL FILLER NECK CRACKED WHERE IT IS ATTACHED TO THE GAS TANK. FUEL LEAKING OUT OF NECK.

Incident date: Dec 17, 2014

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. WHILE THE VEHICLE WAS PARKED, THERE WAS STRONG FUEL ODOR EMITTED IN AND AROUND THE VEHICLE. EACH TIME THE VEHICLE WAS PARKED, A PUDDLE OF FUEL WAS SEEN ON THE GROUND. THE CONTACT'S BROTHER, A CERTIFIED MECHANIC, DIAGNOSED THE VEHICLE AND STATED THAT THE... Read more

Incident date: Sep 9, 2016

TAKATA RECALL I WAS DRIVING AND RAN OFF THE EDGE OF THE ROAD AND OVER CORRECTED MYSELF AN HIT AN EMBANKMENT HEAD ON AND MY FACE WENT INTO THE STEERING WHEEL AND THEN WAS THROWN FOR THE VAN OUT THE BACK PASSENGER WINDOW AND THE VAN THEN LANDED ON MY FOOT BEFORE I HIT THE ROAD DUE TO AIR BAG NEVER DE... Read more

Crash 1 injured

Incident date: Sep 9, 2016

Crash 1 injured

Incident date: Jun 21, 2012

FUEL LEVEL GAUGE DOES NOT WORK EVER SINCE I HAD THIS VAN AND FUEL PUMP UNEXPECTEDLY WENT BAD AT ABOUT 83000 MILES

Incident date: Jun 24, 2016

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 5 MPH, THE STEERING SNAPPED AND DISENGAGED. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD AND WAS TOWED TO THE CONTACT'S RESIDENCE. BASED UPON THE CONTACT'S EXAMINATION, THE GEAR BOX WAS FRACTURED. THE FAILURE WAS NOT DIAGN... Read more

Incident date: Jun 24, 2016

SOMETHING BROKE INSIDE STEERING COLUMN , RACK & PINON. 100% LOST CONTROL OF STEERING. VEHICLE WAS IN MOTION WHEN ATTEMPT TO TURN.

Incident date: May 9, 2016

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT NOTICED AN ABNORMALLY STRONG FUEL ODOR COMING FROM THE VEHICLE. THE CONTACT OBSERVED FUEL PUDDLES UNDER THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM, GASOL... Read more

Incident date: Sep 21, 2015

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. WHILE THE VEHICLE WAS PARKED, THE DRIVER AND PASSENGER SIDE AIR BAGS SUDDENLY DEPLOYED WITHOUT WARNING. THE CONTACT SUSTAINED INJURIES, BUT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED, BUT THE CAUSE OF THE... Read more

1 injured

Incident date: Sep 21, 2015

1 injured

Incident date: Jun 3, 2013

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT STATED THAT ALL THE FUEL FILLER NECKS WERE FRACTURED, WHICH CAUSED FUEL TO LEAK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 160,000.

Incident date: Jan 1, 2015

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT STATED THAT THERE WAS A FUEL LEAK COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE INLET CHECK VALVE AND THE FUEL TANK NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS... Read more

Incident date: Jul 1, 2014

TEMP GAUGE TRYS GO HOT HAD CHECK NOTHING ENGENE MISFIRE HAD CHECK 7 TIMES NOW. REPLACE MASS AIR TEMP SENSORE TWICE THROTTLE POSITION SENSORS. PLUGS AND WIRES TWICE IN ONE MONTH HAS WIRE SHORTAGE FOR AC AND WE HAVE PAID OUT ALOT OF MONEY FROM DAY 2 OF OWNING THIS WAS GOING SELL BUT I WOULD SELL... Read more

Incident date: Jul 1, 2014

Incident date: Dec 1, 2014

I WAS PULLED OVER DO TO NO REAR BRAKE LIGHT OR TURN SIGNAL ON LEFT SIDE. GOT A TICKET. WENT TO JUNK YARD BOUGHT REPLACEMENT ONLY TO DISCOVER IT WAS ALSO BURNED OUT AND USELESS !!!!!!!!!!!!!! BEEN THROUGH AT LEAST 50 BULBS IN THE LAST YEAR ALONE. I AM SECOND OWNER. ALSO HAVE ANOTHER ELECTRICAL ISSUE ... Read more

Incident date: Dec 1, 2014

Incident date: Sep 25, 2014

ICV (IN LINE CHECK VALVE) HOUSING ON FUEL TANK HAS STARTED CRACKING AND LEAKING FUEL. CHEVROLET SAYS THIS UNIT IS NOT AFFECTED BY RECALL 07V349000. IT APPEARS TO BE THE SAME AS MY OTHER VENTURE WE HAD THE RECALL PERFORMED ON LEAKING AT SAME SPOT. THIS IS A FIRE HAZARD AND GM SHOULD REPAIR THIS ON AL... Read more

Incident date: Sep 1, 2014

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. UPON REFUELING THE VEHICLE, FUEL STARTED LEAKING FROM THE FUEL TANK. THE CONTACT MENTIONED THAT THE FAILURE PROGRESSIVELY WORSENED. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED A SMALL FRACTURE WHICH MAY HAVE ALLOWED FUEL VAPORS AND SMALL DROPLETS ... Read more

Incident date: Jun 26, 2014

ON THE WAY TO TAKING MY SON TO WORK, I NOTICED A LOUD BUZZING SOUND COMING FROM THE REAR PASSENGER SIDE OF MY 2002 CHEVY VENTURE VAN. UPON CHECKING THE DASHBOARD FOR A WARNING SIGNAL, THERE WEREN'T ANY WARNING LIGHT'S DISPLAYED.I JUST RECENTLY HAD REAR BRAKE WORK DONE AND I'M NOT SURE IF THAT IS THE... Read more

Incident date: Jun 26, 2014

Incident date: Jan 1, 2014

I BOUGHT THIS CAR USED AND DISCOVERED THAT I COULDN'T FILL THE GAS TANK MORE THAN 1/3 OF THE WAY OR IT WOULD LEAK FROM A CRACK IN THE PLASTIC GAS TANK WHERE THE FILLER PIPE CONNECTS TO THE TANK. I LOOKED IT UP ON THE INTERNET AND DISCOVERED IT WAS A COMMON PROBLEM; HTTP://WWW.ABOUTAUTOMOBILE.COM/CO... Read more

Incident date: Oct 15, 2013

THE VEHICLE RANDOMLY SHUTS DOWN COMPLETELY WHILE DRIVING - ALL ELECTRICAL SYSTEMS GO OFF. AFTERWARD, IT CRANKS BUT DOES NOT START, AFTER IT'S TOWED, IT EVENTUALLY STARTS. NO ERROR CODES SHOW IN DIAGNOSTICS. *JS

Incident date: Jan 3, 2014

WAS DRIVING APPROX 45 MPH AND DRIVERS SIDE SEAT AIRBAG DEPLOYED. THERE WAS NO IMPACT WHAT SO EVER. *TR

Incident date: Dec 19, 2013

I PURCHASED A USED 2002 CHEVY VENTURE WITH ONLY 84,000 AND THE FIRST THING I DID WAS FILL IT WITH GAS FOR THE NEXT DAY OF SCHOOL DROP OFFS AND PICK UPS . I GOT HOME PARKED IT AND THE NEXT DAY A SMALL PUDDLE OF GAS WAS UNDER DRIVERS SIDE SLIDING DOOR. I LOOKED ON LINE AND FOUND A RECALL SO I CALLED T... Read more

Incident date: Feb 10, 2012

VEHICLE WAS SHOWING 'HOT COOLANT TEMPERATURE' AND WAS TAKEN TO THE MECHANIC FOR REPAIRS. AFTER JUST MONTHS THE SAME PROBLEM RETURNED. *TR

Incident date: Jun 20, 2012

I NOTICED FUEL MILEAGE BEING REALLY OFF AND A VERY STRONG GASOLINE SMELL AND HAD IT CHECKED @ OUR LOCAL REPAIR SHOP AND WAS TOLD GAS TANK WELD HAD FAILED; WE WERE ALSO TOLD WE WERE VERY LUCKY THAT WE GOT IT IN AS SOON AS WE DID. VERY DANGEROUS! WAS ALSO TOLD BY MECHANIC THAT THERE HAD BEEN RECALLS O... Read more

Incident date: Jul 10, 2004

THE GAS GAUGE STOPPED WORKING, WENT FROM FULL TO EMPTY IN ABOUT 3 SECONDS. CHEVY REFUSED TO HELP. I HAVE CARRIED A NOTEBOOK IN THE VEHICLE SINCE THAT TIME, WRITING DOWN THE DATE, PLACE OF PURCHASE, MILEAGE, TOTAL COST, COST PER GALLON, AND HOW MANY GALLONS. THIS IS TO MAKE SURE I DON'T RUN DRY, SI... Read more

Incident date: Feb 22, 2011

THE FUEL GAUGE EITHER SHOWS FULL OR EMPTY. IT WILL SHOW FULL WHILE DRIVING, BUT WHEN SITTING STILL, EVEN IF YOU JUST FILLED UP THE LOW FUEL LIGHT WILL COME ON AND THE GAUGE WILL DROP TO EMPTY. OTHER THAN SETTING THE TRIP, YOU HAVE NO WAY OF KNOWING HOW MUCH GAS IS IN THE TANK. WHEN YOU GET TO HAL... Read more

Incident date: May 2, 2012

CHEVY VENTURE 2002 W/83732 MILES. TO WHOM IT MAY CONCERN: ON APRIL 28, 2002 I TOOK VAN TO HAVE IT TEST IT FOR THE EMISSIONS. IT FAILED WITH P0446 CODE, EVAP VENT PERFORMANCE. ON MAY 2, 2002, I TOOK THE VAN TO MY LOCAL DEALERSHIP TO HAVE IT DIAGNOSED FOR SERVICE ENGINE LIGHT AND ABS LIGHT ON.... Read more

Incident date: May 2, 2012

CHEVY VENTURE 2002 W/83732 MILES. TO WHOM IT MAY CONCERN: ANTI-LOCK-ABS LIGHT, INTERMITTENT ABS INDICATOR LIGHT. STARTED HAVING ISSUES WITH THE ANTI-LOCK BRAKES SYSTEM, WHEN ISSUE STARTED THE ABS LIGHT INDICATOR LIGHT WOULD INTERMITTENTLY FLASH AND THE ABS WOULD BY ITSELF TRIED TO ENGAGED ... Read more

Incident date: Jun 1, 2011

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE BEGAN TO OVERHEAT AND THE CHECK ENGINE WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE OIL PRESSURE SENDING UNIT, WATER PUMP, THERMOSTAT AND RADIATOR CA... Read more

Incident date: Mar 25, 2012

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. WHILE PARKED, THE CONTACT NOTICED THAT COOLANT WAS LEAKING FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR A DIAGNOSTIC TEST. THE MECHANIC STATED THAT THE LOWER INTAKE MANIFOLD WAS LEAKING COOLANT. THE GASKETS FOR THE L... Read more

Incident date: Mar 16, 2012

SUSPENSION--BOTH TIE RODS IN THE FRONT OF THE VEHICLE HAVE HAD TO BE REPLACED--MECHANIC SAID THAT BOTH TIMES IT WAS NEAR CATASTROPHIC FAILURE. OTHER--AIR CONDITIONER CONDENSER CRACKED DUE TO DESIGN FAILURE. 2002 SERVICE BULLETIN TOLD THAT GM WAS AWARE OF THE PROBLEM BUT KEPT QUIET UNTIL THE WARRAN... Read more

Incident date: Mar 16, 2012

Incident date: Jan 4, 2012

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE DRIVER AND PASSENGER SIDE CURTAIN AIR BAGS DEPLOYED WITHOUT WARNING. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND THE CURRENT MILEAGES... Read more

Incident date: Oct 17, 2011

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT SMELLED GASOLINE FUEL FROM THE VEHICLE WHILE PARKED. WHEN HE ATTEMPTED TO REFUEL THE VEHICLE, IT WOULD TAKE THIRTY MINUTES TO ADD TWO GALLONS TO THE TANK. IN ADDITION, THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE DEALER INFORMED TH... Read more

Incident date: Nov 13, 2011

FUEL GAUGE READS ERRATICALLY. *TR

Incident date: Aug 31, 2010

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT STATED THAT UNDER THE VEHICLE WAS COMPLETELY RUSTED AND CORRODED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC FOR A ROUTINE MAINTENANCE WHEN THE CONTACT WAS ADVISED OF THE RUST AND ALSO A HOLE IN THE FRAME. THE MECHANIC THEN ADVISED THAT THE V... Read more

Incident date: May 26, 2011

TL*THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT STATED WHILE MAKING A TURN THE ENGINE FELL ON THE GROUND, THE STEERING COLUMN AND SUB FRAME BROKE. THE INSURANCE COMPANY TOWED THE VEHICLE TO AN AUTO BODY SHOP. THE VEHICLE WAS IN THE PROCESS REPAIRING THE VEHICLE. THE DEALER AND MANUFACTURER... Read more

Incident date: May 26, 2011

Incident date: Aug 15, 2010

TL*THE CONTACT OWNS A 2002 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 25 MPH THE REAR PASSENGER SIDE AUTOMATIC SLIDING DOOR OPENED ON ITS OWN. THE CONTACT NOTICED THE DOOR HAD NOT LATCHED AND HAD RETURNED TO THE OPEN POSITION. THE FAILURE OCCURRED INTERMITTENTLY AND OVER TIME IT WOULD NOT LATCH ... Read more

Incident date: Mar 12, 2011

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT NOTICED ANTI-FREEZE AND WATER ON THE GARAGE FLOOR WHERE THE VEHICLE WAS PARKED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE HEAD GASKET AND INTAKE MANIFOLD WOULD NEED REPLACING. THERE WERE NO RECALLS FOR THE FA... Read more

Incident date: Feb 20, 2011

I WAS DRIVING AND NOTICE THE VAN SLOWING DOWN ON ME AND THEN IT STOPPED SUDDENLY. I TOOK IT TO A MECHANIC AND WAS TOLD IT NEEDED GAS. TWO WEEKS AFTER I NOTICE THE ODOMETER WOULD JUMP FROM EMPTY TO FULL BACK AND FORTH. THEN I NOTICE WHENEVER I TRY TO FILL IT UP WITH GAS IT WOULD NOT TAKE MORE THAN... Read more

Incident date: Aug 10, 2010

JANUARY 4,2011 PHILADELPHIA, PA. I FIRST NOTICE IN AUG 2010 THAT MY 2002 CHEVY VENTURE WAS MAKING NOISE AND OVERHEATING WAS TOLD BY A MECHANIC IT WAS MY WHEEL BEARINGS AND MY THERMOSTAT GOT THAT REPAIRED THAT COST ABOUT $425.00 THEN THE VAN KEPT OVERHEATING AND CUTTING OFF WENT BACK TO THE MECHAN... Read more

Incident date: Sep 12, 2010

2002 CHEVROLET VENTURE, EXPERIENCED AN ELECTRICAL FIRE IN DASHBOARD. THE CONSUMER PULLED TO BERM AND THE VEHICLE BECAME COMPLETELY ENGULFED IN FIRE. *BF ACCORDING TO THE POLICE REPORT, A FUSE HAD BEEN CHANGED IN THE CIGARETTE LIGHTER OF THE DASHBOARD. THE CONSUMER STATED THAT WAS THE AREA SHE FIR... Read more

Fire

Showing 50 of 284 complaints.

Technical Service Bulletins, 2002 CHEVROLET VENTURE

518 manufacturer communications from 386 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	69
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	41
110000 ELECTRICAL SYSTEM	39
060000 ENGINE AND ENGINE COOLING	31
353000 EQUIPMENT:ELECTRICAL	24
356000 EQUIPMENT ADAPTIVE/MOBILITY	23
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.	21
162000 STRUCTURE:BODY	19

110000 ELECTRICAL SYSTEM

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

060000 ENGINE AND ENGINE COOLING

This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

100000 POWER TRAIN

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

060000 ENGINE AND ENGINE COOLING

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

120000 EXTERIOR LIGHTING

This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

350000 EQUIPMENT

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

100000 POWER TRAIN

The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

060000 ENGINE AND ENGINE COOLING

This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

060000 ENGINE AND ENGINE COOLING

This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

353720 EQUIPMENT:ELECTRICAL:ACCESSORY GENERATOR:OUTLETS/RECEPTACLE

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

138220 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component

060000 ENGINE AND ENGINE COOLING

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

This service bulletin provides information on Module Harvesting.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

980000 UNKNOWN OR OTHER

This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Handling Requests for Modifications to Permanently Import/Export Vehicles Between the U.S. and Canada.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

100000 POWER TRAIN

This diagnostic tip advises the tech not to separate the flexplate from the torque convertor or damage my occur if the engine is started while diagnosing for noise from the engine or transmission.

100000 POWER TRAIN

This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on tools available to find an intake vacuum leak or exhaust leak to correct a condition of MIL Illuminated with Multiple Fuel Trim and/or Oxygen Sensor Codes Set.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

160000 STRUCTURE

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and

030000 SERVICE BRAKES, HYDRAULIC

061520 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technician

356000 EQUIPMENT ADAPTIVE/MOBILITY

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

350000 EQUIPMENT

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

071410 FUEL SYSTEM, GASOLINE:STORAGE:EVAPORATIVE EMISSIONS:CANISTER

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

110000 ELECTRICAL SYSTEM

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

350000 EQUIPMENT

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

350000 EQUIPMENT

160000 STRUCTURE

200000 WHEELS

350000 EQUIPMENT

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo

061560 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:PRESSURE/TEMPERATURE SENSOR

350000 EQUIPMENT

This Preliminary information communicates the use of Winter grade fuel during the warm months of 2020 and the potential rivability issues that it can cause. The ongoing Coronavirus (COVID-19) pandemic has caused significant reductions in

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is

350000 EQUIPMENT

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

355100 EQUIPMENT:OTHER:LABELS

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

060000 ENGINE (PWS)

356000 EQUIPMENT ADAPTIVE/MOBILITY

073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

070000 FUEL SYSTEM, GASOLINE

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels

356000 EQUIPMENT ADAPTIVE/MOBILITY

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides information on key code security rules and information on GM keycode look-up applications.

350000 EQUIPMENT

This informational bulletin provides information on key code security rules and information on GM keycode look-up applications.

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock ce

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

120000 LIGHTING (PWS)

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

350000 EQUIPMENT

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides information for dealers how to submit a product information report (PIR) (Canada Only).

060000 ENGINE (PWS)

110000 ELECTRICAL SYSTEM

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides information on key code security and information on GM key code look up applications.

350000 EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

350000 EQUIPMENT

353000 EQUIPMENT:ELECTRICAL

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

This informational bulletin advises of a new fuel injection kit used for decarbonizing the intake valves, and explains how toptier fuels should be used to reduce carbon build up.

060000 ENGINE (PWS)

350000 EQUIPMENT

Showing 100 of 518 bulletins.

NHTSA Safety Investigations, CHEVROLET VENTURE

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 1998

POWER-SLIDING DOOR

SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITIO... Read more

DP, Closed , Model Year: 1997

RACK AND PINION STEERING UNIT FAILURE

MR. DENNIS FIKE OF ELKRIDGE, MD, SUBMITTED A PETITION TO NHTSA BY LETTER DATED JANUARY 13, 2004, ALLEGING THAT A GM DEALER INFORMED HIM THAT HIS VAN WAS NOT INCLUDED IN SAFETY RECALL 02V286 AND CHARGED HIM FOR THE REPLACEMENT OF THE STEERING RACK AND PINION UNIT.MR. FIKE BELIEVES THAT HIS VAN SHOULD... Read more

EA, Closed , Model Year: 1997

SAFETY BELT ASSEMBLY FAILURE

ODI IDENTIFIED 59 REPORTS WITH THE ALLEGED DEFECT.ODI WAS ABLE TO CONTACT 44 OF THE 59 CONSUMERS IN ORDER TO DETERMINE THE SPECIFIC CAUSE OF THE LATCH PROBLEMS.OF THE 44 OWNERS CONTACTED, ODI DETERMINED THAT FOUR FAILURES WERE DUE TO AN OUT-OF-TOLERANCE LATCH PLATE, AND THAT 23 FAILURES WERE DUE TO ... Read more

PE, Closed , Model Year: 1998

REAR AXLE TRAILING ARM FAILURE

ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJE... Read more

PE, Closed , Model Year: 1997

SHOULDER HARNESS CLIP

PE, Closed , Model Year: 1998

AIR BAG TEAR DURING DEPLOYMENT

SQ, Closed , Model Year: 1997

UNEXPECTED OPENING OF SLIDING DOOR

There is no summary currently available

PE, Closed , Model Year: 1997

FINGER CUTTING/PINCHING

ODI HAS RECEIVED THREE REPORTS INDICATING INJURIES OCCURRED TO CONSUMERS WHILE THEY WER FOLDING A SECOND ROW SEAT TO GAIN ACCES TO THE REAR OR THIRD ROW SEATS.WHEN FOLDING THE SEAT A PORTION OF THE SEAT FRAME MOVES IN A SCISSOR ACTION.TWO OF THE CONSUMERS SEVERED THE END OF THEIR FINGER AND THE THI... Read more

CHEVROLET VENTURE - All Years Overview

Complete safety history for the CHEVROLET VENTURE across all model years (1997, 2005).

68 Total Recalls

3,078 Total Complaints

8 Investigations

174 Reported Crashes

49 Reported Fires

12 Reported Deaths

CHEVROLET VENTURE - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2005	3	59	View
2004	5	146	View
2003	8	231	View
2002 (current)	6	284
2001	12	284	View
2000	8	464	View
1999	7	467	View
1998	10	518	View
1997	9	612	View
1996	0	3	View
1988	0	1	View

Other CHEVROLET Models

Model	Recalls	Complaints
SUBURBAN	246	10,458	View
TAHOE	240	12,622	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2002 CHEVROLET VENTURE

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2002 CHEVROLET VENTURE

Most Affected Components

NHTSA Safety Investigations, CHEVROLET VENTURE

CHEVROLET VENTURE - All Years Overview

CHEVROLET VENTURE - Year by Year

Other CHEVROLET Models