ELECTRICAL SYSTEM:IGNITION:SWITCH
UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors model and model year vehicles during repair and replacement of the original ignition switch. The weight on the key ring and/or road conditions or some other jarring event may cause the affected ignition switches to move out of the run position, turning off the engine and disabling the air bags.
Remedy: UCI-FRAM Group has notified its purchasers to quarantine and return all inventory. Any switches already installed in vehicles will be replaced by GM dealers as part of NHTSA recall 14V-047, free of charge. UCI-Fram's purchasers should contact UCI-FRAM Group at 1-800-890-2075. GM vehicle owners requiring additional information on that recall campaign should contact GM at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac) or 1-800-553-6000 (Saturn).
14,529 vehicles affected
ELECTRICAL SYSTEM:IGNITION
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
2,191,014 vehicles affected
AIR BAGS
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
2,190,934 vehicles affected
ELECTRICAL SYSTEM:IGNITION:SWITCH
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
2,190,934 vehicles affected
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Remedy: A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
296,422 vehicles affected
AIR BAGS
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Remedy: DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
181,516 vehicles affected
The contact owns a 2008 Chevrolet HHR. The contact stated that while the vehicle was parked and turned off, the contact was informed that the vehicle was leaking gasoline. The vehicle was inspected, and the contact was informed that fuel was leaking from the driver’s side rear wheel well area, near the muffler. While at the residence, the contact observed that fuel was still leaking from the vehicle. The vehicle was taken to an independent mechanic, where it was diagnosed with a rusted fuel line located near the driver’s side rear wheel well, and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to have the vehicle diagnosed by a dealer. The approximate failure mileage was 68,900. The VIN was not available.
The contact owns a 2008 Chevrolet HHR. The contact stated that the key was stuck in the ignition switch and failed to release. Additionally, the TPMS warning light was illuminated. The vehicle was towed to the local dealer, who confirmed that the key was stuck and needed to be broken, and any damages would be at the owner's expense. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 14V171000 (Air Bags, Electrical System). The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 200,000.
The contact owns a 2008 Chevrolet HHR. The contact stated that the key was stuck in the ignition switch and failed to release. Additionally, the TPMS warning light was illuminated. The vehicle was towed to the local dealer, who confirmed that the key was stuck and needed to be broken, and any damages would be at the owner's expense. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 14V171000 (Air Bags, Electrical System). The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 200,000.
The contact owns a 2008 Chevrolet HHR. The contact stated that the key was stuck in the ignition switch and failed to release. Additionally, the TPMS warning light was illuminated. The vehicle was towed to the local dealer, who confirmed that the key was stuck and needed to be broken, and any damages would be at the owner's expense. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 14V171000 (Air Bags, Electrical System). The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 200,000.
The contact owns a 2008 Chevrolet HHR. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 14V047000 (Air Bags, Electrical System); but the vehicle experienced a failure. The contact stated that the key could not be removed from the ignition switch while the key was in the "OFF" position. In addition, the battery was being drained. The contact stated that the battery was previously replaced several months ago. The contact stated that the key was stuck in the ignition switch. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 64,000.
The contact owns a 2008 Chevrolet HHR. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 14V047000 (Air Bags, Electrical System); but the vehicle experienced a failure. The contact stated that the key could not be removed from the ignition switch while the key was in the "OFF" position. In addition, the battery was being drained. The contact stated that the battery was previously replaced several months ago. The contact stated that the key was stuck in the ignition switch. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 64,000.
The contact owns a 2008 Chevrolet HHR. The contact stated while warming up the vehicle, the rear window exploded without warning or impact. There was smoke coming from the front of the vehicle. There was an abnormal burning odor detected. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 56,000. The VIN was not available.
vehicle ecm keeps reporting an error code p2138 that refers to a correlation issue between sensors on the throttle/pedal system, causing the vehicle to enter into reduced power and eventually disables engine. Problem persists even after replacing pedal component. Apparently water enters the compartment where the part is located and corrodes wiring between the ecm and the pedal system. GM is apparently aware but so far has done nothing. Problem is especially hazardous because engine power is reduced during acceleration and happens without warning. Vehicle could be in high density traffic and then suddenly experiences lack of power or total disability, and driver must try to navigate to the side of the road--not always possible or safe to do.
The contact owns a 2008 Chevrolet HHR. The contact stated that on one occasion after her friend parked the vehicle, the contact observed condensation underneath the rear of the vehicle. The vehicle was inspected by the friend's nephew, and it was determined that the fuel line had a hole and was leaking fuel. The vehicle was then taken to a dealer where it was diagnosed and determined that the fuel line needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
Gas line leaking, leaves puddles and can visibly be seen dripping
The contact owns a 2008 Chevrolet HHR. The contact stated that while parking the vehicle, the contact detected an abnormally strong fuel odor. Upon inspection, the contact noticed a leak coming from underneath the rear driver's side door. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Action Number: PE20011 (Fuel System, Other, Fuel/Propulsion System, Fuel System, Gasoline). The failure mileage was 184,025.
The contact owns a 2008 Chevrolet HHR. The contact stated that after starting the vehicle, the contact became aware of a fuel leak nearby the rear driver’s side wheel. There were no warning lights illuminated. The contact towed the vehicle to an independent mechanic who diagnosed that the fuel line had completely rusted due to being wrapped in heat-reliant tape. The contact was informed that the fuel lines needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and was informed that there was a recall related to the rust failure of the fuel line of another make and model vehicle however, the VIN was not included. The approximate failure mileage was 199,000.
FUEL LINE LEAKING IN TWO PLACES, IN THE REAR AND IN THE FRONT. COMPLETELY RUSTED OUT. MY CAR ONLY HAS 60,800 MILES ON IT. TYPE OF CAR IS A 2008 CHEVY HHR LT 2.4. GAS IS LEAKING ON THE GROUND AND A STRONG SMELL OF GAS IS EMITTED FROM THE CAR. THIS IS VERY DANGEROUS BECAUSE THE CAR COULD CATCH FIRE. I DID NOT THINK THIS WOULD HAPPEN TO MY CAR WITH SO FEW MILES ON THE CAR. I DID NOT KNOW THERE WAS A PROBLEM AND DROVE THE CAR 130 MILES AWAY FROM HOME TO MY DAD'S FUNERAL. THEN I HAD TO DRIVE IT BACK BECAUSE TH E TOW WOULD HAVE BEEN $700. THE MECHANIC WHO INSPECTED THE CAR. BUDDY LLOYD'S LAKEVIEW AUTOMOTIVE AT 4757 SANG RUN ROAD IN MCENRY, MD 21541, SAID IT WOULD COST ABOUT $2,000 TO FIX BECAUSE OF THE EXTENT OF THE CORROSION AND THE CHAEP MATERIALS USED. IN ADDITION, THE FUEL LINES ARE LOCATED UNDERNEATH OTHER MAJOR PARTS AND WOULD HAVE TO BE TAKEN OFF TO GET TO THE FUEL LINES. THE MECHANIC SAID AT ANY MOMENT IF I HIT A BUMP THAT THE GAS COULD EMPTY THE TANK AND POSSIBLY CATCH FIRE!
The contact owns a 2008 Chevrolet HHR. The contact stated while driving at approximately 35 MPH, the air bag warning light illuminated. The service air bag soon message was displayed. The vehicle was taken to the local dealer, where it was diagnosed that two unknown modules were defective and needed to be replaced. The dealer informed the contact that the modules were no longer manufactured. The vehicle was not repaired. The vehicle was taken to an independent mechanic, but no assistance was provided. The manufacturer was contacted and informed the contact that the part had been discontinued. The failure mileage was approximately 80,900.
While driving steering motor just stops working causing hard steering and not steer properly. You try to pull off busy highway. stop put in park shut off car then restart steering works fine just out nowhere you loose steering. its intermitten.,
The contact owns a 2008 Chevrolet HHR. The contact stated that there was fuel leaking from the fuel tank. There was no warning light illuminated. The vehicle was taken to an independent mechanic who replaced the fuel tank however, the failure persisted. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was approximately 6,000.
Corrosion of the metal fuel lines underneath the vehicle towards the rear and in the vicinity of the left rear wheel well.
2008 HHR Chevy LS 4D. Within 10 months of purchasing this car (October, 2017) the smell of gasoline became so strong I took it to the local mechanic. The fuel line had completely rusted out. I was told it could have caught fire! Cost of replacement was $420.00. A huge financial burden for a senior citizen. I have original bill for this amount and receipt of payment.
Needless to say, General Motors has dealt with their share of recalls lately and while much of the GM recall news has been devoted to the ignition failures which have forced new CEO Mary Barra to stand before the US Government, this new recall has nothing to do with the ignition cylinder failures. Although the ignition problems can cause a steering issue and some of the vehicles included in the ignition recall are also included in this new recall, this recall pertains specifically to the power steering system. It seems that in the 1.3 million affected vehicles, one or more components of the electric power steering assist system could fail and when that happens, the car will not have the same level of power assist. The General Motors statement announcing this recall is a bit on the vague side in terms of explaining exactly what is causing this loss of power assist, but the automaker has explained that it could be due to a problem with the power steering motor, the steering column assembly, the power steering control unit or a combination of the power steering column and the power steering control unit. Regardless of which of those components fail, it will become much more difficult to steer the car at low speeds, although when driving at higher speeds it may almost be unnoticeable. However, with the increased possibility of accidents, GM isn’t taking any chances so they have made the decision to add these 1.3 million cars to their already lengthy list of recalled models. My 2008 HHR is not listed in any recalls by it's VIN
Needless to say, General Motors has dealt with their share of recalls lately and while much of the GM recall news has been devoted to the ignition failures which have forced new CEO Mary Barra to stand before the US Government, this new recall has nothing to do with the ignition cylinder failures. Although the ignition problems can cause a steering issue and some of the vehicles included in the ignition recall are also included in this new recall, this recall pertains specifically to the power steering system. It seems that in the 1.3 million affected vehicles, one or more components of the electric power steering assist system could fail and when that happens, the car will not have the same level of power assist. The General Motors statement announcing this recall is a bit on the vague side in terms of explaining exactly what is causing this loss of power assist, but the automaker has explained that it could be due to a problem with the power steering motor, the steering column assembly, the power steering control unit or a combination of the power steering column and the power steering control unit. Regardless of which of those components fail, it will become much more difficult to steer the car at low speeds, although when driving at higher speeds it may almost be unnoticeable. However, with the increased possibility of accidents, GM isn’t taking any chances so they have made the decision to add these 1.3 million cars to their already lengthy list of recalled models. My 2008 HHR is not listed in any recalls by it's VIN
Gas leak has started on the driver side in front of the rear tire.
Power steering dashboard light came on. Difficult to steer vehicle. Losing power steering is dangerous. Will report the matter to the Chevrolet dealership. No other inspections were done. The dealership may inspect the vehicle. Trying to find recalls to fix this problem for free, but it looks like Chevrolet has not provided a recall for this problem although there are numerous complaints about the failed power steering in their HHR vehicles.
Purchased vehicle in Sep 2021. After 4 months of purchase, muffler became loose from exhaust after hitting a pothole on highway and, having a mechanical background, I repaired the exhaust by placing a solid stainless steel exhaust sleeve around the weak area and tac welding it. Within a month, I began to smell a rich fuel odor after every trip. I jacked up vehicle and found a fuel leak within insulated area just left of exhaust. I also located another small exhaust leak and repaired it as best as possible with an exhaust wrap, then took it to an exhaust repair shop. I was told fuel leak had to be repaired before exhaust repairs could be done. Mechanic said HHRs we're well known for fuel line corrosion due to poor design and eventually leaking. He said he has turned away many HHRs and Cobalts for this problem over the last 2-3 years.
Steering gets very stiff and sometimes locks up when turning left or right in a curve at highway speeds. Had dealer check it and they said they replaced steering motor. Did not correct problem. Made an appointment to check again but was told I would incur charges. I have had it to several mechanic shops and we cannot find anything loose or failing. In a parked position it locks up completely until you start rolling. Afraid steering is going to lock up in a curve and cause harm to driver and passengers. It is available for inspection. It has not been inspected by the manufacturer, police or insurance. Has no warning lights or messages pertaining to problem. The problem first appeared approximately 6 months ago.
Steering gets very stiff and sometimes locks up when turning left or right in a curve at highway speeds. Had dealer check it and they said they replaced steering motor. Did not correct problem. Made an appointment to check again but was told I would incur charges. I have had it to several mechanic shops and we cannot find anything loose or failing. In a parked position it locks up completely until you start rolling. Afraid steering is going to lock up in a curve and cause harm to driver and passengers. It is available for inspection. It has not been inspected by the manufacturer, police or insurance. Has no warning lights or messages pertaining to problem. The problem first appeared approximately 6 months ago.
Steering gets very stiff and sometimes locks up when turning left or right in a curve at highway speeds. Had dealer check it and they said they replaced steering motor. Did not correct problem. Made an appointment to check again but was told I would incur charges. I have had it to several mechanic shops and we cannot find anything loose or failing. In a parked position it locks up completely until you start rolling. Afraid steering is going to lock up in a curve and cause harm to driver and passengers. It is available for inspection. It has not been inspected by the manufacturer, police or insurance. Has no warning lights or messages pertaining to problem. The problem first appeared approximately 6 months ago.
Fuel tank assembly developed a fuel leak at or around its integrated tank vents creating a strong fuel smell inside and outside the vehicle. THIS IS NOT A RUSTED FUEL LINE PROBLEM. This poses a fire hazard if the vehicle were to come into contact with any spark or flames. This also poses a health hazard from exposure to toxic fumes inside and outside the vehicle. This condition did not trigger any warning messages from the onboard vehicle computer. The seal between the tank vents and fuel tank is made by the manufacturer and is unserviceable. I attempted to seal the leaks with adhesive but was unsuccessful. I then purchased a used replacement fuel tank from an auto recycler and discovered it also has this issue. I believe this to be a design defect that will lead to an unsafe condition in these vehicles. I can make these components available for inspection. I have not had the issue inspected by any other parties as that would involve further costs.
The contact owns a 2008 Chevrolet HHR. The contact stated that her father noticed that the vehicle was leaking fuel. Upon inspection, the contact became aware that the fuel lines had rusted and had started leaking. The vehicle was not taken to a dealer to be inspected. The manufacturer was not informed of the failure. The failure mileage was 141,802. Consumer stated mechanic had to take off the fiberglass mat heat barrier because it was soaked in fuel, and was rubbing the exhaust, so we could see the damage.
The contact owns a 2008 Chevrolet HHR. The contact stated that while the vehicle was parked, she noticed there was a puddle on the ground located on the rear driver's side. Upon inspection, the contact detected a fuel odor and noticed there was a fuel leak coming from the fuel lines. The dealer was made aware of the failure and scheduled an upcoming appointment for diagnosis. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Action Number: PE20011 (Fuel System, Other). The failure mileage was approximately 113,000.
My Fuel line is pouring gas out . The gas fumes are filling the cabin of the car waiting for a repair.
Around 6 months ago I started to notice a fuel smell and upon inspection at the local shop it was diagnosed that my fuel line had rusted through and they informed me there are other cases of this exact issue on the Chevrolet hhr and cobalt vehicles with this engine and fuel setup it has started to leak into the exhaust but has not caught fire.
I noticed a strong odor of gasoline and took the HHR to my local mechanic. He diagnosed it as a rusted fuel line caused by the proximity of a heat shield that traps water.. He was able to repir it by splicing in a section of the line. A bout a yer later the line was leaking again and this time there is not enough line left to splice that isn;t rusted. Obviously this is a danger ranging from leaking gasoline hitting a hot exhaust to a passerby discarding a lit cigarette near the leak and blowing themselves and my car to Kingdome Come. A Check engine light comes on periodically, but is only partially indicative of the gas leak as a possibility. This is a safety issue for both the owner and anyone who might happen by with a lit object
Fuel lines leaking in front of drivers side rear tire. Lines run inside of a channel that has a protective wrap over them, but is very close to part of the exhaust pipe. Fuel line had corroded inside of protective wrap. Only leaks when the engine is running and fuel system under pressure. Fuel could have hit hot exhaust pipe and caused a fire or explosion. Apparently this is a common problem with the Chevy HHR with multiple cases having already been reported. Had the car repair at our local Chevy dealer. Cost of removing and replacing the fuel lines was $1,307.00. The only indications of the problem was the smell of fuel near the rear tire and a puddle of fuel under the car when engine was shut off. Frame cross member was also wet from fuel shooting out of end of protective wrap.
While driving down the interstate the power steering light flashed and locked the power steering to the point I was unable to steer in any direction. It has done this on multiple occasions to the point it has almost caused several accidents. This is a serious issue!
Power steering went out completely causing me to swerve on the highway to side of road. The steering locked up and it was raining and I would of crashed had anyone else been on the highway. I was going about 55 mph at the time. I then proceeded to CAREFULLY at about 30 mph force my car to drive another half mile to nearest exit ramp. The entire time I was driving in the middle of the lanes and a huge liability as far as safety is concerned. Thankfully I made it with no harm to myself vehicle or anyone else. I pulled over to side of road and slept in car till the rain stopped. Prior to this I backed into a fence when the steering failed backing into a carport resulting in body damage to front end under left headlight. Months before I had asked the Chevy dealership to diagnose issue and they found nothing wrong as in the beginning the car would still steer at its own leisure. The light didn't come on when they looked at it. After the night in the rain I have taken the fuse outta the power steering part and just manually steer. This should be replaced as it is a common issue to ALL HHR. Mine isn't covered as it is an SS but clearly it should be covered by a recall. Hopefully I don't die before this is taken care of.
Crash
The contact owns a 2008 Chevrolet HHR. The contact stated while driving 30 mph, he started to smell gasoline fumes inside the vehicle. The contact stated that there was no warning light illuminated. The contact stated after parking his vehicle, a bystander informed him that the vehicle had a fuel leak. The contact took the vehicle to the local dealer to be diagnosed. The contact was informed that the fuel line needed to be replaced. The vehicle was not yet repaired but was pending repairs. The manufacturer had not been informed of the failure. The failure mileage was approximately 147,240.
Fuel lines leaking under left rear of 2008 HHR. According to Google internet investigations this seems to be a problem in the design and placement of insulation material over the fuel line. I almost had a explosive concern, not knowing where the smell of fuel was coming from, a alert gentleman smoking a cigarette counseled me on a dripping fuel on the parking lot. He said smokers will throw their cigarette down and unintentionally possibly causing a fire/explosion.
My power steering unexpectedly has gone out. When it first happened I was on the freeway in the rain and it locked up. Thankfully there were no others cars near me or I would of had an accident. I called the dealership and they said there WAS a recall but too much time has passed! This makes no sense. If it's bad it's bad, what the heck! So now I have taken the fuse out and it at least keeps it from locking up it it is VERY difficult to steer and I fear not being able to respond quickly in an emergency. Then I was noticing that when I add gas it had trouble turning over. Only when I added gas. Gas mileage began getting worse and then I felt the motor having difficulty while again on the freeway. I could smell gas and pulled over. There was smoke under the hood and I could see gas puddling up under my car. Now I am scared of my car. I called GMC and they said they couldn't help me with either of these issues to contact my dealership. I haven't done this because I already know they are gonna say they can not help me. This is absurd. I have had this car a year and NOTHING but problems for me.
My power steering unexpectedly has gone out. When it first happened I was on the freeway in the rain and it locked up. Thankfully there were no others cars near me or I would of had an accident. I called the dealership and they said there WAS a recall but too much time has passed! This makes no sense. If it's bad it's bad, what the heck! So now I have taken the fuse out and it at least keeps it from locking up it it is VERY difficult to steer and I fear not being able to respond quickly in an emergency. Then I was noticing that when I add gas it had trouble turning over. Only when I added gas. Gas mileage began getting worse and then I felt the motor having difficulty while again on the freeway. I could smell gas and pulled over. There was smoke under the hood and I could see gas puddling up under my car. Now I am scared of my car. I called GMC and they said they couldn't help me with either of these issues to contact my dealership. I haven't done this because I already know they are gonna say they can not help me. This is absurd. I have had this car a year and NOTHING but problems for me.
Engine cuts out , loses power ar random times. Especially when the air is humid. Constant smell of leaking gasoline.
Engine cuts out , loses power ar random times. Especially when the air is humid. Constant smell of leaking gasoline.
ALL FOUR OF THE TIRES I BOUGHT DEVELOPED NUMEROUS CRACKS IN LESS THAT 18 MONTHS OF USE, AND LESS THAN 10,000 MILES OF USE. UNIROYAL WILL NOT STATE IF THE TIRES ARE SAFE OR NOT.
gas leaking..over left rear wheel well where the silver insulation is ..line has rusted thru the insulation is because the exhaust runs close to that side of the vehicle but unfortunately there in no way or takes too long for moisture to evaporate poor design ....
THE POER STEERING WARNING MESSAGE KEEPS COMEING ON
The contact owns a 2008 Chevrolet HHR. The contact stated that there was an abnormal fuel odor at the rear of the vehicle. The vehicle was taken to the dealer to be diagnosed. The dealer informed the contact that the fuel lines located at the rear driver’s side wheel were leaking and that the wheel was corroded. The vehicle was not repaired. The manufacturer was contacted and informed of the failure. The failure mileage was 93,368.
My gas lines are leaking. It appears that several other owners of HHR's are having the same issue.
Metal fuel lines rusted thru under the left rear door area where they are wrapped in insulation with no ability tor drain or dry out. The car is unsafe to drive I need to have it fixed now. I will try to safe defective parts. Fuel leak under the car near exhaust and almost undrivable, safety factor is obvious and currently under investigation. Will be calling dealer today. Noticed delayed start and heavy gas smell and then saw puddle under car. Removed insulation wrap and found heavy deposit of road dirt and rust.
TWO ISSUES: KEY WON'T REMOVE FROM IGNITION, SEARCHED GOOGLE AND GOT KEYS OUT. SECOND ; POWER LOCKS ,CAR WON'T UNLOCK, NOT EVEN WITH KEYS. SO FAR, THIS HAS COST ME $150.00
TWO ISSUES: KEY WON'T REMOVE FROM IGNITION, SEARCHED GOOGLE AND GOT KEYS OUT. SECOND ; POWER LOCKS ,CAR WON'T UNLOCK, NOT EVEN WITH KEYS. SO FAR, THIS HAS COST ME $150.00