EXTERIOR LIGHTING:BRAKE LIGHTS
CERTAIN VANS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." WHEN THE BRAKES ARE APPLIED, THE STOP LAMPS WILL ILLUMINATE. WHEN THE BRAKE PEDAL IS RELEASED, THE STOP LAMPS ARE NO LONGER ILLUMINATED BUT THE REAR BRAKES MAY STILL BE APPLIED. THE BRAKE MAY RELEASE AFTER A FEW SECONDS OR AFTER THE NEXT FIRM BRAKE PEDAL APPLICATION.
Remedy: DEALERS WILL REPROGRAM THE ABS SYSTEM MODULE. THE RECALL BEGAN ON SEPTEMBER 28, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9643.
10,113 vehicles affected
TL* THE CONTACT OWNS A 2007 CHEVROLET EXPRESS 1500. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOOR BOARD. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT AND OTHER DRIVER SUSTAINED WHIP LASH. NO MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC BRAKE LINE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT ALSO MENTIONED THAT HE FELT LIKE THE INSTALLATION OF THE BRAKE LINING WAS FAULTY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 58,000. UPDATED 04/08/16*LJ UPDATED 05/10/18 *JB *TR
Crash
2 injured
TL* THE CONTACT OWNS A 2007 CHEVROLET EXPRESS 1500. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOOR BOARD. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT AND OTHER DRIVER SUSTAINED WHIP LASH. NO MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC BRAKE LINE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT ALSO MENTIONED THAT HE FELT LIKE THE INSTALLATION OF THE BRAKE LINING WAS FAULTY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 58,000. UPDATED 04/08/16*LJ UPDATED 05/10/18 *JB *TR
Crash
2 injured
RADIATOR HOSE GETS DAMAGED WHEN RADIATOR FAN SHROUD TOUCHES IT REPEATEDLY THROUGH MOTOR VIBRATIONS. WE HAVE SEEN THIS ON TWO DIFFERENT VEHICLES (2007 AND 2010 MODELS) OF CHEVY EXPRESS VANS. 2010 VAN IS VIN #[XXX]. OUR MECHANIC EXPLAINED THIS TO US AND TOOK PHOTOS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
REAR SIDE DOORS ON MY CHEVROLET EXPRESS VAN HAVE CORRODED TO THE POINT THEY WILL NOT OPEN. *TR
TL*THE CONTACT OWNS A 2007 CHEVROLET EXPRESS 1500. THE CONTACT STATED THAT THE AIR BAGS WERE DEFECTIVE. HIS VEHICLE WAS STRUCK FROM THE REAR WHILE IT WAS PARKED AND THE AIR BAGS FAILED TO DEPLOY. THE DRIVER WHO CRASHED INTO HIM WAS KILLED. FOUR PEOPLE WERE INJURED IN THE CONTACT'S VEHICLE AND FOUR PEOPLE WERE INJURED IN THE OTHER VEHICLE. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE MANUFACTURER ISSUED THE CONTACT A CASE NUMBER, HOWEVER, THEY DID NOT EXPLAIN WHY THE AIR BAGS DID NOT DEPLOY AND IF THE VEHICLE WAS INCLUDED IN ANY RECALLS. THE SPEED OF THE OTHER VEHICLE AT THE TIME OF THE CRASH WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 2,800.
Crash
8 injured
1 deaths
TL*THE CONTACT OWNS A 2007 CHEVROLET EXPRESS 1500. ON A DRY DAY THE CONTACT HEARD METAL SCRAPING THE ROAD WHILE DRIVING 65 MPH. THE VEHICLE WAS PULLED OVER, AND THE CONTACT DISCOVERED THAT SPARKS WERE IGNITING FROM UNDERNEATH THE VEHICLE. THE CONTACT DIALED 911, AND THE VEHICLE WAS TOWED TO THE DEALER, (PATRICK CHEVROLET, WHERE IT REMAINED. THE FAILURE WAS DIAGNOSED AS THE TRANSMISSION. THE CONTACT CALLED THE MANUFACTURER, AND FILED A COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE 2,300.*AK
Fire