1996 CHEVROLET EXPRESS 1500 Recalls, Complaints & Safety

No recalls found for this vehicle.

Complaint Statistics

4 total complaints

Top Reported Components

Component	Complaints
SERVICE BRAKES	2
STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS	1
POWER TRAIN:AUTOMATIC TRANSMISSION	1

Incident date: Sep 10, 2013

I WAS BRAKING WHILE EXITING THE FREEWAY AND LOST THE REAR BRAKES. AFTER AN INSPECTION, I FOUND THE BRAKE LINE BROKE ABOUT MIDWAY THROUGH THE CHASSE. I ALSO FOUND THAT THE BRAKE LINES WOULD CRACK WHERE EVER YOU BENT THEM. I HAD TO HAVE ALL THE BRAKE SYSTEM REPLACED BECAUSE OF CORROSION AT A COST OF $... Read more

Incident date: Mar 10, 2013

WIFE COMPLAINED OF PULSATING BRAKE PEDAL, TOOK VEHICLE FOR A SHORT TEST DRIVE, ON THE WAY BACK WHILE TRAVELING IN A STRAIGHT LINE AT APPROX. 30 MPH MADE A STOP APPLYING MODERATE PEDAL PRESSURE, BRAKE PEDAL WENT TO FLOOR. CAREFULLY DROVE THE REMAINING 1/8TH MILE HOME AND CRAWLED UNDERNEATH VAN. BRAKE... Read more

Incident date: Dec 18, 2008

TRANSMISSION SLIPS AND I RESEARCHED THE INTERNET AND THE 4L60E TRANSMISSION HAS A PROBLEM WHERE A WELD INSIDE THE TRANSMISSION GOES BAD AND MAKES THE TRANSMISSION FAIL. VAN WAS TAKEN TO A REPAIR SHOP AND REBUILT A FEW TIMES THE MECHANIC SAYS A NEW GM TRANSMISSION MUST BE PURCHASED AT $1,600 DOLLARS.... Read more

Incident date: Apr 10, 2008

96 CHEVY EXPRESS VAN, FAILED SIDE CARGO DOOR HINGES. THESE HINGES, PINS AND BUSHINGS, FAIL, SEIZE UP, AND THE SIDE CARGO DOORS ARE UNABLE TO BE OPENED. THIS MAKES IT UNSAFE FOR EXIT FROM THE VEHICLE FOR ANY PERSONS SITTING IN THE BACK OR REAR SEATS. GM KNOWS OF THIS PROBLEM. THERE ARE 4 SERVICE BUL... Read more

Technical Service Bulletins, 1996 CHEVROLET EXPRESS 1500

2 manufacturer communications from 2 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	1
061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)	1

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules

NHTSA Safety Investigations, CHEVROLET EXPRESS 1500

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2003

Fuel Filler Pipe Corrosion/Leakage

On August 7, 2012 General Motors (GM) notified the Office of Defects Investigation (ODI) that it will conduct a safety related recall for model year (MY) 2003-2004 Chevrolet Express and GMC Savana vehicles.The recall affects vehicles equipped with a left side cargo door and that were originally sold... or currently registered in the corrosion or salt-belt states of Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. Dealers are to install a new fuel filler neck. Consumer notification letters will be sent in early October 2012, when sufficient parts are available. ODI has received 12 complaints alleging unique incidents of fuel leakage during refueling of a subject vehicle. Eleven of the complaints occurred on Chevrolet Express vans, and 1 of the complaints involved a GMC Savana. All vehicles were equipped with the left side cargo door option. For vehicles so equipped, water and road debris can become trapped in the protective conduit that covers the fuel filler pipe and may subsequently cause the pipe to corrode. If the corrosion creates a significant perforation in the pipe, fuel may leak onto the ground while refueling the vehicle. An illuminated Check Engine light (on some vehicles) or the presence of fuel odor may also act as precursors to fuel leakage. Fuel in the presence of an ignition source could cause a fire to occur. In their response to ODI's information request, GM reported 24 owner reports and 1 field report alleging fuel filler pipe failure/corrosion in the subject vehicle population. Six additional records were also provided that included the replacement of the fuel filler pipe, however not enough information existed to determine a relation to the alleged problem. After further review of the reports, ODI determined that a total of 27 individual GM reports were related to filler pipe corrosion. The complaints received from both ODI and GM primarily occurred in the corrosion states. During the investigation, the scope of the subject vehicle population was expanded to include MY 2004 Express vans, and MY 2003 and 2004 GMC Savana vans (with V6 engines) also equipped with left hand side door options, since the Savana vans also utilize the same, or substantially similar fuel filler pipe configuration. GM subsequently modified the design of the fuel filler pipe on vehicles equipped with side doors to correct the corrosion concern, so these vehicles do not have the defect issue.The affected vehicle population shown above reflects the total number of vehicles registered in the salt-belt states listed in GM's defect information report (DIR). Prior to the safety recall announcement, GM had issued a special coverage adjustment for vehicles in these states, during which a total of 771 repairs were made. Accordingly the vehicle population noted in the DIR reflects that of the remaining vehicle population.The investigation is closed based on GM's announcement of safety recall 12V388. The reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10463398, 10459328, 10456403, 10453725, 10445925, 10443143, 10441615, 10413568, 10413214, 10411911, 10353717, 10259377.Read more

CHEVROLET EXPRESS 1500 - All Years Overview

Complete safety history for the CHEVROLET EXPRESS 1500 across all model years (1999, 2011).

10 Total Recalls

133 Total Complaints

1 Investigations

14 Reported Crashes

6 Reported Fires

1 Reported Deaths

CHEVROLET EXPRESS 1500 - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2014	0	15	View
2012	0	3	View
2011	2	3	View
2010	0	4	View
2009	0	6	View
2008	0	10	View
2007	1	6	View
2006	0	6	View
2005	1	10	View
2004	1	15	View
2003	1	21	View
2002	1	10	View
2001	1	5	View
2000	1	10	View
1999	1	5	View
1996 (current)	0	4

Other CHEVROLET Models

Model	Recalls	Complaints
SUBURBAN	246	10,458	View
TAHOE	240	12,622	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

1996 CHEVROLET EXPRESS 1500