2002 CHEVROLET AVALANCHE

4 recalls, 562 complaints - 298 TSBs

EXTERIOR LIGHTING

Defect Description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

16,270 vehicles affected

Manufacturer: SABERSPORT

FUEL SYSTEM, GASOLINE

Defect Description

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CE... Read more

Consequence

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Remedy

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

88,303 vehicles affected

Manufacturer: HONEYWELL INTERNATIONAL, INC.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

Defect Description

CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAR... Read more

Consequence

THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.

Remedy

DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SI... Read more

1,353,718 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS

Defect Description

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF TH... Read more

Consequence

ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF T... Read more

Remedy

DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT... Read more

3,662,211 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

Complaint Statistics

562 total complaints 52 crashes 45 injuries 12 deaths

Top Reported Components

Component	Complaints
SERVICE BRAKES	53
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	46
SERVICE BRAKES, HYDRAULIC	37
STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS	32
PARKING BRAKE	28
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR	16
ENGINE AND ENGINE COOLING	16
STRUCTURE	14
TIRES	11
AIR BAGS	11

Incident date: Nov 7, 2023

Vehicle keeps having all warning lights and warning messages come on whenever the car starts. Warning lights maintain on constantly and has audible beeping to indicate the warnings. Vehicle would also put itself into park randomly at, as well as disengage collision and lane sensors while driving. Ve... Read more

Incident date: Nov 1, 2020

The contact owns a 2002 Chevrolet Avalanche. The contact stated that while driving at an undisclosed speed, the ABS and oil warning lights illuminated. Additionally, the speedometer, the 4-wheel drive function, parking brake, and headlights failed to operate as needed. The instrument panel light fai... Read more

Incident date: Nov 1, 2020

Incident date: Dec 26, 2015

BRAKE LINES ARE MADE OUT OF DEFECTIVE MATERIALS GM KNOWS THEY HAVE A PROBLEM THE LINES RUST OUT PREMATURELY . THE FIRST ONE BLEW OUT I WAS BACKING IN A PARKING SPACE PEDAL WENT TO THE FLOOR. THE SECOND ONE BLEW AT A TRAFFIC LIGHT PUSHED ON THE BRAKE WENT THRU THE RED LIGHT DODGED TRAFFIC .THE THIRD ... Read more

Incident date: Jul 30, 2015

WHEN TRAVELING AT LOW SPEEDS, >5MPH, THE ABS ACTIVATES AND VEHICLE CONTINUES ON TO THE POINT OF ENTERING TRAFFIC. THIS OCCURS FREQUENTLY AND WITHOUT WARNING, AT STOP SIGNS AND EVEN JUST PULLING OUT OF PRIVATE DRIVEWAY INTO TRAFFIC. MY LOCAL MECHANIC RAN A DIAGNOSTIC TEST AND INDICATED THAT A FRONT S... Read more

Incident date: Aug 3, 2015

WHILE DRIVING AT 65 MPH THE ENGINE CUT OUT. COULD BE THE CRANKSHAFT POSITION SENSOR. THE TRUCK IS A 2500 WITH AN 8.1L ENGINE. SIMILAR ISSUES THAT THE 2001 WAS RECALLED FOR. SAME ENGINE AND CPS AS THE 2001 BUT NOT INCLUDED IN THE ORIGINAL RECALL. THIS HAS HAPPENED SEVERAL TIMES AT VARIOUS SPEEDS... Read more

Incident date: Jan 2, 2015

WHILE DRIVING MY TRUCK AND TOWING A TRAILER, I LOST ALMOST ALL MY BRAKING POWER. HAD TO DOWN SHIFT AND USE THE EMERGENCY BRAKE TO STOP. FOUND THAT A BRAKE LINE FROM THE MASTER CYLINDER TO THE ANTI-LOCK BRAKE MODULE (WHICH IS MOUNTED UNDER THE DRIVERS SEAT, GREAT PLACE) HAD RUSTED THROUGH AND BLEW OU... Read more

Incident date: Nov 21, 2014

BRAKE PEDAL WENT TO THE FLOOR UPON BRAKING. HAD TO DOWNSHIFT TO LOW GEAR AND APPLY WHAT LITTLE BRAKE I HAD LEFT TAKING APPROXIMATELY 200 FEET TO STOP. LUCKILY THERE WAS NO VEHICLE IN FRONT OF ME OR IT WOULD HAVE BEEN A REAR END COLLISION. SLOWLY RETURNED HOME ABOUT A MILE AWAY AND UPON FURTHER INSPE... Read more

Incident date: Oct 1, 2013

APPLIED BRAKES TO STOP AND PEDAL WENT TO FLOOR. UPON INSPECTION FOUND BRAKE LINE RUPTURED DUE TO EXCESSIVE CORROSION. VEHICLE REQUIRED 100% REPLACEMENT OF ALL BRAKE LINES. *TR

Incident date: Oct 8, 2014

CLEAR DRY DAY. ACCIDENT OCCURRED WHEN VEHICLE HIS A SIDE OF A BUILDING. AIR BAGS DID NOT DEPLOY RESULTING IN INJURY. *TR

Crash

Incident date: Jul 10, 2013

THE BRAKE LINE THAT GOES THE LENGTH OF THE TRUCK FROM THE FRONT TO THE REAR BRAKES CORRODED THROUGH AND RESULTED IN THE FAILURE OF THE BRAKES ON MY TRUCK. I HAD TO STEER OFF THE ROAD AND INTO SOME BRUSH AND A DRAINAGE DITCH TO STOP THE VEHICLE AND AVOID HITTING CARS IN FRONT OF ME. *TR

Crash

Incident date: Sep 9, 2014

DRIVING IN SCHOOL PARKING LOT AT 10 MPH WHEN ALL OF A SUDDEN, WITHOUT ANY WARNING OR NOTIFICATION FROM DASH DISPLAY, HAD TO DEPRESS BRAKE PEDAL ALL THE WAY TO THE FLOOR FOR THE VEHICLE TO STOP. BRAKING DISTANCE INCREASED DRAMATICALLY. WENT TO THE DEALERSHIP AND THEY INFORMED ME THAT THE BRAKE LINE A... Read more

Incident date: Sep 15, 2014

IN THIS COLLISION WHERE I WAS A PASSENGER WE FLIPPED OVER 2 AND SLID ON PASSENGER SIDE OF VEHICLE AND NO AIR BAGS DEPLOYED .UNCONSCIOUS DURING FIRST 2 SECONDS OF COLLISION AFTER I REGAINED CONSCIOUSNESS I FELT MY HEAD DRAGGING ON PAVEMENT AND GRABBED MY HEAD AND LIFTED IT UP FROM BEING DRAGGED AS TR... Read more

Crash 2 injured

Incident date: Jul 13, 2013

THE ENGINE WILL DIE AT ANY TIME WITH OUT WARNING. THIS HAPPENS FAIRLY OFTEN. SOMETIMES AFTER TRYING TO RESTART IT WILL RESTART WITH NO DELAY AND OTHER TIMES IT WILL TAKE A FEW MINUTES. THEN IT WILL RUN NORMALLY FOR NO SPECIFIC AMOUNT OF TIME. THEN IT WILL DIE AGAIN. INCIDENCES MAY OCCUR HUNDREDS OF ... Read more

Incident date: Aug 20, 2014

TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE. THE CONTACT STATED WHILE DRIVING 35 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO RESPOND. THE CONTACT HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE DEALER DIAGNOSED THAT THE BRAKE LINE NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED BUT ... Read more

Incident date: Aug 5, 2006

GM HAD REPAIRED THE RUST BRAKE DEFECTS ON MY TYPE OF VEHICLE IN MANY SALT STATES THAT ENDURE COLD WEATHER. BUT BECAUSE THERE WAS NOT ENOUGH OUTRAGE THEY DID NOT REPAIR THIS SAME DEFECT IN MY STATE. THERE IS A PROBLEM WITH THE WHEEL BEARINGS WHERE RUST CAUSES THE ANTI LOCK BRAKING SYSTEM TO NE... Read more

Incident date: Aug 5, 2006

Incident date: Aug 31, 2012

DRIVING THE VEHICLE WHILE TOWING A HORSE TRAILER, WENT TO APPLY THE BRAKES AND DIDN'T HAVE ANY BRAKES THE BRAKE LINES BROKE. *TR

Incident date: Jul 15, 2013

TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE. THE CONTACT STATED THE BRAKE AND FUEL LINES WAS RUSTED AND LEAKING FLUID. IN ADDITION, THE CONTACT STATED THAT THE FRAME WAS RUSTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110... Read more

Incident date: Jul 15, 2013

Incident date: Jul 19, 2014

PULLING BOAT (22 FT ) FROM THE BOAT LAUNCH TO THE MAKE READY AREA. STEPPED ON BRAKES AND PEDDLE SUDDENLY AND WITHOUT WARNING WENT TO THE FLOOR ! UPON INSPECTION OF THE BRAKE LINES, THEY ARE RUSTED AND IN BAD SHAPE. THE BRAKE LINE THAT RUNS ON TOP OF THE FRAME RAIL ON THE DRIVERS SIDE AND GOES TO TH... Read more

Incident date: Jul 18, 2014

TRANSFER CASE FLUID LEAKING FROM A HOLE IN THE CASE CAUSED BY INTERNAL PUMP RUB. ALL THE TRANSFER CASE OIL EXPELLED ONTO THE HOT EXHAUST CAUSING SMOKE AND POSSIBLY A FIRE. *TR

Incident date: Jul 22, 2013

WHEN APPLYING THE BRAKE TO SHIFT FROM PARK THE BRAKE PEDAL GOES TO THE FLOOR. THIS HAPPENED IN JULY AND NOVEMBER 2013, AND AGAIN ABOUT TWO WEEKS AGO. *JS

Incident date: Apr 15, 2013

I'M HAVE BEEN EXPERIENCING SEVERAL TECHNICAL ISSUES WITH MY 2002 AVALANCHE THROUGH YEARS. I CAN REMOVED MY KEY WHEN MY IGNITION TURNED ON TO DRIVE. MY TRUCK ALSO REDUCES ENGINE SPEED WHEN DRIVING AT 45 MPG. IT RESULT FOR ME TO PULL OVER ON THE INTERSTATE TO RESET THE PCM TO DRIVE. THEN MY CHECK ENGI... Read more

Incident date: May 28, 2014

WAS DRIVING AROUND THE BLOCK AS I HAD JUST JUMP STARTED THE DEAD BATTERY. AS I APPROACHED A STOP THE BRAKES WERE APPLIED AND THE TRUCK KEPT ROLLING AS THE BRAKES WERE SPONGY. AS I APPLIED MORE PRESSURE THE PEDAL HIT THE FLOOR. I NARROWLY MISSED HITTING A CAR COMING FROM THE SIDE STREET. I COASTED TH... Read more

Incident date: Apr 1, 2014

AS I WAS TRAVELING ON THE HIGHWAY AT 70MPH THE ENGINE SPUTTERED AND STOPPED RUNNING CAUSING ME TO LOSE ALL POWER ASSIST AND TO COAST TO THE SIDE OF THE HIGHWAY. THE VEHICLE WAS TOWED TO MY MECHANIC WHERE IT WAS DISCOVERED THAT THE FUEL LINE HAD RUSTED OUT AND NEEDED TO BE REPLACED AT MY EXPENSE. *... Read more

Incident date: Mar 3, 2014

AS I WAS APPROACHING A STOP LIGHT AT APPROXIMATELY 25 MPH I APPLIED THE BRAKES AND THE BRAKE PEDAL SUDDENLY WENT TO THE FLOOR AND I LOST THE BRAKES CAUSING ME TO ROLL THROUGH THE TRAFFIC LIGHT. FORTUNATELY NO ONE WAS COMING THROUGH FROM THE OTHER DIRECTION. IT WAS TAKEN TO MY MECHANIC WHERE HE DIS... Read more

Incident date: Apr 2, 2014

WHEN APPROACHING A STOP LIGHT CHANGING TO RED, BRAKES WERE APPLIED MODERATELY HARD AND THE PEDAL WENT TO THE FLOOR WITH SEVERELY REDUCED BRAKING RESULTING IN A STOPPING DISTANCE ABOUT 1 CAR LENGTH LONGER THAN NORMAL. NO BRAKE WARNING LIGHT DURING THIS INCIDENT. I CONTINUED ANOTHER MILE TO MY DESTI... Read more

Incident date: Jan 1, 2012

ANTILOCK BRAKE LIGHTS CAME ON...THERE WAS A RECALL FOR "SALT" BELT STATES, HOWEVER, AREAS THAT GET SNOW AND ROADS ARE SALTED AS WELL SUCH AS RENO, NV, TRUCKEE, CA ETC AND OTHER STATES THAT HAVE SIMILAR CONDITIONS TO THOSE THAT WERE ALREADY INCLUDED IN THE PREVIOUS RECALL SHOULD HAVE BEEN INCLUDED AS... Read more

Incident date: Mar 8, 2014

TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE BRAKE PEDAL WAS DEPRESSED AND THE ABS ENGAGED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THERE WAS A RECALL RELATED TO THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER 05V37900... Read more

Incident date: Mar 8, 2014

Incident date: Oct 1, 2013

I WAS DRIVING HOME AROUND 9:30 PM. AS I WAS GOING DOWN A HILL I STEPPED ON MY BRAKES AND THE PEDAL WENT TO THE FLOOR. NO BRAKES AT ALL, NO SAFTEY FEATURES KICKED IN, NO WARNING LIGHTS. JUST A CATASTROPHIC BRAKE FAILURE. LUCKILY FOR ME IT WAS A SMALL HILL AND I WAS ABLE TO STOP BY GOING INTO LOW GEA... Read more

Incident date: Dec 5, 2012

I WAS DRIVING HOME AND ALL OF A SUDDEN IT FELT LIKE NO POWER WAS GETTING TO THE WHEELS. I STEPPED ON THE GAS, THE RPMS WENT UP, BUT THE TRUCK COULDNT GET PAST 30 MPH. MY MECHANIC SAID THAT THE TRANSMISSION BURNT OUT. I BABIED THIS TRUCK. THEIR IS NO REASON FOR A CHEVY TRUCK WITH 60000 MILES OF LIGHT... Read more

Incident date: Feb 14, 2014

SLOWED RAPIDLY FOR A VEHICLE THAT PULLED OUT IN FRONT OF ME. BRAKES WORKED FINE UNTIL SPEED DROPPED TO 15 MPH. THEN BRAKE PEDDLE WENT TO THE FLOOR AND BRAKE LIGHT FLASHED AND WARNING CHIME SOUNDED. LIMPED VEHICLE TO DEALERSHIP AT CLOSING TIME. AWAITING ESTIMATE AND CAUSE. *TR

Incident date: Jul 1, 2012

TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE 2500. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS, THE ABS ENGAGED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN N... Read more

Incident date: Dec 29, 2013

TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE. THE CONTACT STATED THAT A STRONG GASOLINE ODOR WAS INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC FOR INSPECTION, WHO STATED THAT THE FUEL LINES WERE CORRODED AND CAUSED FUEL TO LEAK. THE FUEL LINES WERE REPLACED. THE MANUFACTURER WAS M... Read more

Incident date: Dec 29, 2013

Incident date: Jun 28, 2013

WAS DRIVING ON STREET FROM STORE TO HOME WHEN I NOTICED BRAKE LIGHT ON DASH CAME ON AND THEN PARKED IN DRIVEWAY. MY SON WENT TO USE THE TRUCK THE NEXT DAY AND WHEN HE PULLED OUT OF DRIVEWAY TO STREET, COULD BARELY STOP. SUBSEQUENTLY DISCOVERED BRAKE FLUID ON DRIVEWAY. CHECKED BRAKELINE AND IT WAS RU... Read more

Incident date: Dec 27, 2013

WAS DRIVING ON NY STATE THRUWAY WITH WIFE AND THREE SMALL CHILDREN. WOMEN CUT IN FRONT OF ME. I PUSHED ON BRAKES AND PEDAL WENT TO FLOOR. I SWERVED OUT OF THE WAY AND WENT OFF THE ROAD. LUCKILY IT HAPPENED NEAR A CLEARING OTHERWISE WE WOULD HAVE HIT SOMETHING AND BEEN SERIOUSLY HURT AND/OR KILLED.... Read more

Incident date: Oct 14, 2012

1. FIRST INCIDENT: 10/14/12. CATASTROPHIC BRAKELINE RUPTURE DUE TO CORROSION NEAR REAR LEFT TIRE RESULTING IN COMPLETE LOSS OF BRAKES 2. SECOND INCIDENT: 10/19/13. CATASTROPHIC BRAKELINE RUPTURE DUE TO CORROSION ON SIDE OF FRAME NEAR DRIVER SIDE DOOR RESULTING IN COMPLETE LOSS OF BRAKES. *TR

Incident date: Oct 23, 2013

WHEN LEAVING THE HIGHWAY I APPLIED THE BRAKES AND THEY IMMEDIATELY WENT TO THE FLOOR, ALMOST REAR ENDING THE TRUCK AHEAD OF ME. I WAS ABLE TO LIMP THE VEHICLE HOME USING LOW GEAR AND WHAT I FOUND OUT WERE THE REAR BRAKES. AFTER GETTING HOME I LOOKED UNDERNEATH THE FRONT END AND NOTICED BRAKE FLUID... Read more

Incident date: Sep 17, 2013

COMING UP TO A TRAFFIC LIGHT AT 45MPH THE LIGHT TURNED RED ,I STEPPED ON THE BRAKE AND IT WENT TO THE FLOOR. I PUMPED THE BRAKE AND USED THE EMERGENCY BRAKE TO STOP THE TRUCK BUT NOT IT DID NOT STOP UNTIL I WAS THROUGH THE INTERSECTION . LUCKILY THERE WAS NO CRASH. THE BRAKE LINE TO THE REAR BRAKES ... Read more

Incident date: Sep 21, 2013

WHILE BACKING UP TO CONNECT TO A TRAVEL TRAILER BRAKE PEDAL WENT TO FLOOR AND FLUID LEAK DEVELOPED FROM UNDERSIDE TRUCK. LIMPED TRUCK TO REPAIR STATION AND HAVE BEEN QUOTED A PRICE OF $1,300 TO REPLACE ALL BRAKE LINES. ACCORDING TO SHOP OWNER, ALL OF THE BRAKE LINES APPEARED TO BE COMPROMISED DUE... Read more

Incident date: Sep 16, 2013

SITTING AT RED LIGHT ALL OF A SUDDEN BRAKES SEEMED TO LET GO CAR STARTED TO ROLL BACK A BIT HAD TO PUSH BRAKE PEDAL TO THE FLOOR. *TR

Incident date: Oct 29, 2009

10/2009: AS I WAS DRIVING AND APPROACHING A RED LIGHT MY BRAKES WENT TO THE FLOOR. ALMOST GOING THROUGH A BUSY INTERSECTION I WAS ABLE TO MANEUVER AROUND TRAFFIC UNTIL I CAME TO A STOP. 8/2013: AS I WAS APPROACHING A RED LIGHT MY BRAKES WENT TO THE FLOOR. MY BRAKE LINES ARE SO BADLY CORRODED AND R... Read more

Incident date: Oct 29, 2009

Incident date: Aug 26, 2013

EXHAUST LEAK IN THE ENGINE FOUND MANIFOLD BOLTS WERE BROKE. *TR

Showing 50 of 562 complaints.

Technical Service Bulletins, 2002 CHEVROLET AVALANCHE

298 manufacturer communications from 252 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
162000 STRUCTURE:BODY	32
061000 ENGINE AND ENGINE COOLING:ENGINE	21
980000 UNKNOWN OR OTHER	12
353000 EQUIPMENT:ELECTRICAL	12
060000 ENGINE AND ENGINE COOLING	12
010000 STEERING	10
100000 POWER TRAIN	9
106000 POWER TRAIN:AXLE ASSEMBLY	9

353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician about vehicles that may have an issue when using Bluetooth voice recognition with an iPhone. Technician should work with the customer to insure the phone cont

350000 EQUIPMENT

THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT FINDING NEEDLE BEARINGS DURING AN OIL CHANGE. TECHNICIAN WILL GAIN ACCESS TO THE ROLLER ROCKERS TO INSPECT THEM. ONLY REPLACE THE ROLLER ROCKER THAT IS

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This informational bulletin provides information on Part Restriction and Ordering Process Information for OnStar Vehicle Communication Interface Modules (VCIM) (GMNA Only)

353000 EQUIPMENT:ELECTRICAL

This informational bulletin provides information on Part Restriction and Ordering Process Information for OnStar Vehicle Communication Interface Modules (VCIM) (GMNA Only)

063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

This Preliminary Information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. It is recommended to inspe

151400 SEAT BELTS:FRONT:BUCKLE ASSEMBLY

This informational bulletin provides information to advise dealers about seat belt buckles not operating and/or seat belt warning light illumination, as well as difficulty latching and unlatching the buckle or the buckle release button stic

150000 SEAT BELTS

090000 FUEL SYSTEM, OTHER

This informational bulletin provides dealership personnel with information on flexible fuel vehicles (FFVs) and the usage of E85 fuel in GM vehicles.

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This informational bulletin provides information on a GM of Canada OnStar? cellular communication upgrade.

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This informational bulletin provides information on a GM of Canada OnStar? cellular communication upgrade.

353000 EQUIPMENT:ELECTRICAL

This informational bulletin provides information on a GM of Canada OnStar? cellular communication upgrade.

353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician about connectivity concerns when connecting an Apple device via USB cord. Technician should insure the customer is using an original equipment manufacturer Ap

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Tech

110000 ELECTRICAL SYSTEM

353000 EQUIPMENT:ELECTRICAL

This informational bulletin provides information on communication with OnStar? module after Canadian cellular upgrade.

353000 EQUIPMENT:ELECTRICAL

This informational bulletin provides information on a GM of Canada OnStar? cellular communication upgrade.

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary Information communication provides information to the technician about vehicles that are travelling from Canada to the United States. While in the United States they are unable to receive Turn-by-Turn directions. Due to the

353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the cu

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

353000 EQUIPMENT:ELECTRICAL

034200 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

CHEVROLET/GMC/CADILLAC: ANYTIME HYDRAULIC BRAKE PIPES ASSEMBLY NEED REPLACING, PRE-FORMED AND PRE-FLARED BRAKE PIPES ARE AVAILABLE, EXCEPT REAR AXLE CROSSOVER PIPE. MODEL 1999-2007 SILVERADO, SIERRA, 2000-2006 ESCALADE MODELS, AVALANCHE,

034100 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

060000 ENGINE AND ENGINE COOLING

This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo

162510 STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS

This Preliminary Information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables. Technician should not replace any parts for this concern. Please communicate to the customer

162500 STRUCTURE:BODY:TAILGATE

353000 EQUIPMENT:ELECTRICAL

131000 VISIBILITY:WINDSHIELD

This Preliminary Information communication provides information to the technician about the percentage of UV protection or tint offered by the windshield or side glass. Technician should be advised Windshield reduces UV rays down to 4% or l

020000 SUSPENSION

GM: IF THE SERVICE SUSPENSION SYSTEM IS DISPLAYED ON THE DIC, THE TRIM HEIGHT MAY BE INCORRECT, LOOSE COMPRESSOR INLET HOSE, OR THE COMPRESSOR SELF TEST MAY BE INOPERATIVE. ALSO INCLUDED SUBURBAN LD MY 2001-2013, YUKON DENALI XL MY 2013, Y

171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

GM: THE FRONT OR REAR DOOR MAY NOT OPEN FROM THE INSIDE OR OUTSIDE HANDLE, THE DOOR WILL NOT UNLOCK WITH ANY METHOD. THE PROBABLY CAUSE AN INCORRECT INSTALLATION OF A HANDLE COMPONENT. *RM UPDATED ON 7/26/2013. ALL 2014 AND PRIOR GM PASS

354000 EQUIPMENT:MECHANICAL

This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp on, engine misfire, and/or engine noise. Technician may find Diagnostic Trouble Code

100000 POWER TRAIN

356000 EQUIPMENT ADAPTIVE/MOBILITY

This warranty administration bulletin provides information on the Clarification of Use for Dealer Empowerment Labor Operations and Customer Enthusiasm

100000 POWER TRAIN

This Preliminary Information communication provides information to the technician about vehicles that may have a planetary gear whine noise in first and second gear. Technician should compare the noise to a like vehicle. Technician will nee

200000 WHEELS

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

190000 TIRES

106000 POWER TRAIN:AXLE ASSEMBLY

This Preliminary Information communication provides information to the technician with the axel setup information from American Axle Manufacturing. Technician should be advised that the maximum pinion shim to be used or stacked behind the p

030000 BRAKES (PWS)

This Preliminary Information communication advises the technician that the Hydro-Boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.

030000 SERVICE BRAKES, HYDRAULIC

This Preliminary Information communication advises the technician that the Hydro-Boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.

110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that have slip in forward ranges immediately after replacing the input housing. Technician will inspect the 3-4 clutches and the forward clutch

101000 POWER TRAIN:CLUTCH ASSEMBLY

151600 SEAT BELTS:FRONT:WARNING LIGHT/DEVICES

GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. *RM UPDATED 4/

150000 SEAT BELTS

221300 SEATS:FRONT ASSEMBLY:HEAD RESTRAINT

GENERAL MOTORS: INFORMATION PROVIDED BY BULLETIN FOR ALL 2012 AND PRIOR GENERAL MOTOR TRUCKS AND PASSENGER VEHICLES REGARDING THE ADJUSTABLE COMFORT AND CUSTOM UPHOLSTERY OF THE DRIVER AND THE PASSENGER HEAD RESTRAINT. *PE

980000 UNKNOWN OR OTHER

GM: INFORMATION ON FIXING MULTIPLE SITUATIONS RIGHT THE FIRST TIME. *RM

060000 ENGINE AND ENGINE COOLING

GM: THE SERVICE ENGINE SOON LIGHT IS ON, THERE IS ALSO A MISFIRE OR ENGINE NOISE. THERE ARE MULTIPLE POSSIBLE CAUSES. *RM

013200 STEERING:GEAR BOX:SHAFT PITMAN

BUICK/CADILLAC/CHEVROLET/GMC/OLDSMOBILE AND HUMMER: INFORMATION ON PITMAN ARM SHAFT SEAL SERVICE KIT. DO NOT REPLACE ENTIRE STEERING GEAR FOR PITMAN SEAL LEAK. TECHNICIANS HAVE BEEN REPLACING ENTIRE STEERING GEARS DUE TO NOT BEING ABLE TO

010000 STEERING

036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

ANTILOCK BRAKE (ABS) ACTIVATION AT LOW SPEEDS (CLEAN WHEEL SPEED SENSOR MOUNTING SURFACE). *TT UPDATED 10/23/09. *PE

118000 ELECTRICAL SYSTEM:SOFTWARE

GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE

110000 ELECTRICAL SYSTEM

GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE

103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

GMC: FLUID LEAK FROM TRANSMISSION OIL COOLER LINES DUE TO CORROSION. ALL 2000-2006 LIGHT DUTY TRUCKS EQUIPPED WITH THE LIGHT DUTY AUTOMATIC TRANSMISSION. *PE

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

BUICK\CHEVROLET\GMC SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. CSC LETTER WAS RECEIVED. *PE

091200 FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM

GMC: FUEL GAUGE FLUCTUATION IN PARK OR NEUTRAL, CAUSING THE LOW FUEL LIGHT TO ILLUMINATE. *PE

353000 EQUIPMENT:ELECTRICAL

BUICK\CADILLAC\CHEVROLET\GMC\HUMMER\OLDSMOBILE\PONTIAC\SAAB\SATURN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. FCC RULED IN 2002 WIRELESS CARRIERS WOULD NO LONGER R

105500 POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

EATON LOCKING DIFFERENTIAL CHATTER SHUDDER NOISE ON TURNS, EQUIPPED WITH A LOCKING REAR DIFFERENTIAL RPO G80. *NJ UPDATED 7/17/2008. *PE

022000 SUSPENSION:REAR

EATON LOCKING DIFFERENTIAL CHATTER SHUDDER NOISE ON TURNS, EQUIPPED WITH A LOCKING REAR DIFFERENTIAL RPO G80. *NJ UPDATED 7/17/2008. *PE

063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)

POSSIBLE ENGINE OIL LEAK DUE TO PCV FREEZE-UP, EQUIPPED WITH THE 4.8, 5.3, 6.0, AND 6.2 V-8 ENGINES. *NJ

022140 SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY

REAR LEAF SPRING SLAP OR CLUNK NOISE (REPLACE SPRING INSERTS) *TT UPDATED 10/18/07. *NJ

020000 SUSPENSION

REAR LEAF SPRING SLAP OR CLUNK NOISE (REPLACE SPRING INSERTS) *TT UPDATED 10/18/07. *NJ

046600 SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT

ABS LIGHT ON, DTC'S C0265, C0201, U1041 SET AND/OR LOSS OF COMMUNICATION WITH BRAKE MODULE. (REGROUND EBCM GROUND). *KB

061000 ENGINE AND ENGINE COOLING:ENGINE

MULTIPLE DRIVEABILITY SYMPTOMS OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE DUE TO CLOGGED FUEL INJECTORS. *TT

010000 STEERING

CLUNKING NOISE UNDER HOOD AND CAN BE FELT IN STEERING WHEEL. *EH UPDATED *EH UPDATED. *KB

162500 STRUCTURE:BODY:TAILGATE

TAILGATE CABLE SLACK. THIS INCLUDES 1998-2006 CHEVROLET AND GMC FULL AND MID SIZE TRUCKS. *EH UPDATED. *KB

021244 SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY:U-BOLT, LEAF SPRING TO AXLE

LEFT FRONT AXLE SHAFT DIFFICULT TO REMOVE. AXLE DIFFERENTIAL LEAK SEAL SHAFT. *KB

020000 SUSPENSION

RATTLE/SQUEAK FROM FRONT OF VEHICLE. *TT *AR

036100 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT ON, DIAGNOSTIC TROUBLE CODES (DTCS) C0265, C0201, U1041 SET AND/OR LOSS OF COMMUNICATION WITH BRAKE MODULE. *TT UPDATE. *TT

020000 SUSPENSION

20 INCH WHEELS AND TIRES AVAILABLE THROUGH GMSPO. *TT UPDATED. *NM

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

ADVANCE SERVICE INFORMATION - EXHAUST SYSTEM POPPING/SNAPPING NOISE WHEN VEHICLE IS HOT, AT IDLE OR IMMEDIATELY AFTER VEHICLE IS SHUT OFF. *TT BULLETIN 03-06-05-008, DATED 11/01/2003 REPLACED. *TT

220000 SEATS

UNWANTED/LOOSE SEAT MOVEMENT. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

WHINE NOISE FROM REAR AXLE. *TT UPDATE. *TT

046300 SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR

PRODUCT SAFETY RECALL REGARDING FRONT WHEEL SPEED SENSOR CORROSION. *TT

162000 STRUCTURE:BODY

REAR FLOOR CARPET WET WITH DIRTY WATER. *TT

103400 POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

DIAGNOSIS OF CRACKED OR BROKEN TRANSMISSION CASE. *TT 2006 AND PRIOR CARS AND LIGHT DUTY TRUCKS. *TT

134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY

SUNROOF JAMS WHEN CLOSING. *TT

200000 WHEELS

HANDLING CHARACTERISTICS OF VEHICLES WITH 20 INCH WHEEL/TIRE ASSEMBLIES INSTALLED. *TT

020000 SUSPENSION

REVISED FRONT CASTER AND CAMBER ADJUSTMENT PROCEDURE. ORIGINAL NOT YET RECEIVED. *TT

350000 EQUIPMENT

PROPER ONSTAR CELLULAR ANTENNA MAST USAGE. *TT

060000 ENGINE AND ENGINE COOLING

REVISED DIAGNOSTIC TROUBLE CODE (DTC) P1172 AND DTC P2636. *TT

135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

OUTSIDE REARVIEW MIRROR HOUSINGS COME LOOSE FROM BASE. *TT

190000 TIRES

SPARE TIRE IS DIFFERENT SIZE THAN OTHER TIRES. THIS SERVICE BULLETIN REPLACES 020310001. *EH UPDATE. *TT

050000 PARKING BRAKE

REAR PARKING BRAKE SHOE RETAINING SPRING CLIP SERVICE KIT FOR DRUM-IN-HAT (DIH) EQUIPPED VEHICLES. *TT UPDATE. *TT

040000 SERVICE BRAKES, AIR

REAR PARKING BRAKE SHOE RETAINING SPRING CLIP SERVICE KIT FOR DRUM-IN-HAT (DIH) EQUIPPED VEHICLES. *TT UPDATE. *TT

010000 STEERING

REVISED STEERING WHEEL REPLACEMENT PROCEDURE. *TT

162500 STRUCTURE:BODY:TAILGATE

TAILGATE SUPPORT CABLE. RECALL 04007A. GM PARTS BULLETINS & INFORMATION. *TT UPDATED *EH

030000 SERVICE BRAKES, HYDRAULIC

LOW BRAKE PEDAL, RED BRAKE LIGHT ON, BRAKE SYSTEM WARNING MESSAGE ON. *TT UPDATED *EH

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

UNDERHOOD AIR CONDITIONER RATTLE NOISE HEARD ON ACCELERATION OR A SUDDEN LOSS OF AIR CONDITIONER SYSTEM PERFORMANCE. *TT THIS BULLETIN REPLACES 03-01-38-019 DATED 11-01-2003. TO INCLUDE VARIOUS MODLES INCLUDING 2002-2004 COMMERCIAL UP

106000 POWER TRAIN:AXLE ASSEMBLY

USE OF SYNTHETIC FRONT AXLE LUBRICANT FOR 4WD VEHICLES SOLD IN COLD WEATHER CLIMATES. *TT THIS BULLETIN REPLACED PREVIOUS BULLETIN DATED 10/01/2003. *TT

162000 STRUCTURE:BODY

WATER INTRUSION INTO CAB AT MIDGATE. *TT

010000 STEERING

CLUNKING NOISE UNDER HOOD AND CAN BE FELT IN STEERING WHEEL. THIS BULLETIN REPLACES PREVIOUS BULLETIN 00-02-35-003E. *TT

034520 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

REVISED BRAKE PADS REPLACEMENT-REAR. *TT

162000 STRUCTURE:BODY

RUNNING BOARD COVER IS LOOSE. *EH

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

DIAGNOSTIC INFORMATION TO ACCURATELY DIAGNOSE A/C LOW PRESSURE SWITCH USING NEW KENT MOORE SPECIAL TOOL GE-47742. *TT

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

OIL LIFE SYSTEM RESET PROCEDURES-TRUCKS. BUICK TERAZZA 2005, GMC SIERRA DENALI 2002-2003, GMC B7 CHASSIS MEDIUM DUTY 2003-2005 AND GMC 560 C-SERIES 2003-2005 *SC

162000 STRUCTURE:BODY

STOWAGE BOX LID STRAP BREAKING. *TT

150000 SEAT BELTS

REPAIRING NAPPED SEAT FABRIC. *EH

162000 STRUCTURE:BODY

CARGO COVERS AND/OR BODY CLADDING DISCOLORED (CHALKY). *TT THIS BULLETIN REPLACED PREVIOUS BULLETIN 04-08-111-001, DATED 01/01/2004. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

INFORMATION ON REVISED DESIGN OF INTAKE GASKET AND RELATED BOLTS FOR 2004 MID-YEAR ENHANCEMENT AND PRIOR YEAR SERVICE USAGE. *TT

131000 VISIBILITY:WINDSHIELD

WINDRUSH AROUND WINDSHIELD. *TT

Showing 100 of 298 bulletins.

NHTSA Safety Investigations, CHEVROLET AVALANCHE

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 1999

Brake line corrosion failure

The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Ev... aluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.Read more

PE, Closed , Model Year: 2002

CRANK POSITION SENSOR FAILURE - STALL

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE06-016) ON MAY 4, 2006 BASED ON ELEVEN VEHICLE OWNER QUESTIONNAIRES (VOQS) AND EARLY WARNING (EWR) DATA ALLEGING SUDDEN ENGINE SHUTDOWN WHILE DRIVING AS A RESULT OF CRANK POSITION SENSOR FAILURES IN MY 2001-2002 GENERAL MOT... ORS C/K PLATFORM VEHICLES EQUIPPED WITH 8.1L ENGINES.IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY ODI, GENERAL MOTORS (GM) PROVIDED OWNER COMPLAINT INFORMATION, FIELD REPORTS AND WARRANTY CLAIM DATA BASED ON A POPULATION OF 108,338 VEHICLES. THE DATA WAS CATEGORIZED BY ENGINE STALLS WHILE DRIVING, ENGINE STALLS WITH AN UNKNOWN DRIVING CONDITION, NO START CONDITIONS AND CLAIMS WHERE IT WAS INDETERMINATE IF AN ENGINE STALL OCCURRED WHILE DRIVING.GENERAL MOTOR'S RESPONSE INCLUDED 1,213 OWNER COMPLAINTS AND FIELD REPORTS OF WHICH 289 WERE CATEGORIZED AS ENGINE STALLS WHILE DRIVING ALLEGEDLY CAUSED BY CRANK POSITION SENSOR FAILURES. GENERAL MOTORS ALSO SUBMITTED WARRANTY CLAIMS FROM ITS REGULAR WARRANTY (5 YEARS/50,000 MILES) AND FROM ITS EXTENDED WARRANTY DATABASE. FROM THE REGULAR WARRANTY DATABASE THERE WERE 3,140 CLAIMS OF CRANK POSITION SENSOR REPLACEMENT OF WHICH 147 CLAIMS WERE FROM CONSUMERS ALLEGING ENGINE STALL WHILE DRIVING.GM STATED THAT 2,841 OF THE CLAIMS WERE INDETERMINATE IF AN ENGINE STALL OCCURRED WHILE DRIVING.FROM ITS EXTENDED WARRANTY DATABASE, GM SUBMITTED 1,561 CLAIMS OF CRANK POSITION SENSOR FAILURE THAT IT ALSO STATED WERE INDETERMINATE AS TO WHETHER AN ENGINE STALL OCCURRED WHILE DRIVING.IN TOTAL, GM REPORTS 4,701 CLAIMS OF CRANK POSITION SENSOR FAILURE COMBINING REGULAR WARRANTY AND EXTENDED WARRANTY.SIMILAR TO GM'S STATISTICAL ANALYSIS, ODI'S ANALYSIS SHOWED THAT THE FAILURE RATE FOR WARRANTY CLAIMS OF ENGINE STALL WHILE DRIVING AT THREE YEARS IN SERVICE IS LOW (LESS THAN 1%).HOWEVER, FURTHER ANALYSIS DETERMINED THAT THE MY 2001 VEHICLE BUILD PERIOD FROM MAY 2000 THROUGH OCTOBER 2000 HAD SIGNIFICANTLY HIGHER (MORE THAN FOUR TIMES) CRANK POSITION FAILURE RATES IN BOTH CONSUMER COMPLAINT DATA AND WARRANTY CLAIM DATA THAN IN THE BUILD PERIOD FROM NOVEMBER 2000 THROUGH JULY 2001.ADDING THE CLAIMS OF KNOWN ENGINE STALL WHILE DRIVING AND CLAIMS WHERE ENGINE STALL WAS INDETERMINATE, THE FAILURE RATE AT THREE YEARS IN SERVICE FOR THIS POPULATION IS OVER 6%.AN ENGINEERING ANALYSIS (EA06-016) HAS BEEN OPENED TO FURTHER ASSESS THE FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT IN VEHICLES BUILT FROM MAY 2000 THROUGH OCTOBER 2000.Read more

DP, Closed , Model Year: 2000

PARKING BRAKE FAILURE

ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD ... Read more

EA, Closed , Model Year: 2000

HYDRAULIC PUMP FAILRES

GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECT... Read more

CHEVROLET AVALANCHE - All Years Overview

Complete safety history for the CHEVROLET AVALANCHE across all model years (2002, 2013).

45 Total Recalls

2,474 Total Complaints

4 Investigations

109 Reported Crashes

21 Reported Fires

12 Reported Deaths

CHEVROLET AVALANCHE - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2013	2	105	View
2012	3	43	View
2011	3	161	View
2010	4	147	View
2009	5	96	View
2008	4	323	View
2007	4	493	View
2006	1	14	View
2005	3	85	View
2004	6	202	View
2003	6	238	View
2002 (current)	4	562
2001	0	2	View
2000	0	2	View

Other CHEVROLET Models

Model	Recalls	Complaints
SUBURBAN	246	10,458	View
TAHOE	240	12,622	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2002 CHEVROLET AVALANCHE

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2002 CHEVROLET AVALANCHE

Most Affected Components

NHTSA Safety Investigations, CHEVROLET AVALANCHE

CHEVROLET AVALANCHE - All Years Overview

CHEVROLET AVALANCHE - Year by Year

Other CHEVROLET Models