2013 CAN-AM SPYDER RT Recalls, Complaints & Safety

EXCESS HEAT HAS MELTED THE BRAKE LINE TWICE, MASTER CYL. MELTED, BRAKS GET SOFT AND INHIBIT STOPPING POWER, ELECTRICAL WIRINGIS DEGRADING FROM EXCESS HEAT, GAS TANL GET SO HOT THE GAS STARTS TO BOIL, PANELS ARE MELTING AND WARPING FROM EXCESS HEAT. THE UNIT HAS BEEN DECLARED UN SAFE TO RIDE. BRP REFUSES TO ADDRESS THE SAFETY ISSUES, ALL RECALLS AND UPGRADES HAVE BEEN DONE AND THE PROBLEM IS JUST GETTING WORST, BRP, WILL NOT FIX ONLY OFFERS TO HIDE THE COMETIC DAMAGE

CAN"T STOP AN OIL LEAK. AFRAID IT MIGHT GET HOT AND CATCH ON FIRE!!! *DT

WHILE RIDING ON THE HIGHWAY IN MOTION, DURING A CLEAR DAY ON JULY 16 2016. THE SUBJECT VEHICLE SUFFERED A BLOWN REAR TIRE LEAVING A LARGE CENTER STRIP OF BLENDED STEEL AND RUBBER SHAPED AS A WIDE BELT THAT EXTENDED PAST THE REAR OF THE BIKE. SEE THE MULTIPLE PHOTOS ATTACHED IN (EXHIBIT P). WHILE ATTEMPTING TO BRING THE BIKE TO A SAFE HALT TO THE SIDE OF THE HIGHWAY, THE ROTATION OF THE WHEEL USING THE STATED BELT BEAT THE PLASTIC REAR END OF THE VEHICLE TO A TOTAL DISMEMBERMENT OF CRUCIAL PARTS. WITH THE REAR END OF THE VEHICLE BEING RIPPED AWAY FROM THE VEHICLE, THE ATTACHED PASSENGER'S PLASTIC SEAT MOUNT WAS ALSO DESTROYED. FINELY AS THE VEHICLE WAS BEING BROUGHT DOWN TO A STOP TO THE SIDE OF THE HIGHWAY, SOMEHOW WITH THE VIBRATION OF THE ROTATING BLOW TIRE AND WHEEL, THE RIGHT FRONT WHEEL STABILIZING CAST IRON MECHANISM BROKE DISLODGING THE LOWER BALL JOINT THAT STABILIZED THE HORIZONTAL POSITION OF THE RIGHT FRONT WHEEL. SEE THE MULTIPLE PHOTOS ATTACHED IN (EXHIBIT K). THIS SENT THE VEHICLE IN A VIOLENT CLOCK WISE SPIN THAT FINELY OVERCAME THE RIDER'S GRIP DISLODGING THE SEAT AND RIDER ON TO THE SIDE OF THE HIGHWAY, AND THEN FINELY COMING TO A COMPLETE STOP FACING THE ONCOMING HIGHWAY TRAFFIC. HOWEVER, AT NO TIME DID THE VEHICLE HIT ANY CAR, CURB, WATER, ICE, TRASH, OR WALL DURING THE RIDE OR DISLODGING OF THE RIDER. NOOR DID IT FLIP OR TURN OVER AT ANY TIME, IN FACT THE VEHICLE DURING ITS REDUCTION IN SPEED, AS WELL AS THE CLOCK WISE SPIN EVER LEAVE THE FINAL LANE THAT THE RIDER WAS DISLODGED FROM THE VEHICLE. PLEASE EXCEPT THIS AS A REPLACEMENT AND UPDATE OF THE REMOVED COMPLAINT 11051430.

1 injured

WHILE RIDING ON THE HIGHWAY IN MOTION, DURING A CLEAR DAY ON JULY 16 2016. THE SUBJECT VEHICLE SUFFERED A BLOWN REAR TIRE LEAVING A LARGE CENTER STRIP OF BLENDED STEEL AND RUBBER SHAPED AS A WIDE BELT THAT EXTENDED PAST THE REAR OF THE BIKE. SEE THE MULTIPLE PHOTOS ATTACHED IN (EXHIBIT P). WHILE ATTEMPTING TO BRING THE BIKE TO A SAFE HALT TO THE SIDE OF THE HIGHWAY, THE ROTATION OF THE WHEEL USING THE STATED BELT BEAT THE PLASTIC REAR END OF THE VEHICLE TO A TOTAL DISMEMBERMENT OF CRUCIAL PARTS. WITH THE REAR END OF THE VEHICLE BEING RIPPED AWAY FROM THE VEHICLE, THE ATTACHED PASSENGER'S PLASTIC SEAT MOUNT WAS ALSO DESTROYED. FINELY AS THE VEHICLE WAS BEING BROUGHT DOWN TO A STOP TO THE SIDE OF THE HIGHWAY, SOMEHOW WITH THE VIBRATION OF THE ROTATING BLOW TIRE AND WHEEL, THE RIGHT FRONT WHEEL STABILIZING CAST IRON MECHANISM BROKE DISLODGING THE LOWER BALL JOINT THAT STABILIZED THE HORIZONTAL POSITION OF THE RIGHT FRONT WHEEL. SEE THE MULTIPLE PHOTOS ATTACHED IN (EXHIBIT K). THIS SENT THE VEHICLE IN A VIOLENT CLOCK WISE SPIN THAT FINELY OVERCAME THE RIDER'S GRIP DISLODGING THE SEAT AND RIDER ON TO THE SIDE OF THE HIGHWAY, AND THEN FINELY COMING TO A COMPLETE STOP FACING THE ONCOMING HIGHWAY TRAFFIC. HOWEVER, AT NO TIME DID THE VEHICLE HIT ANY CAR, CURB, WATER, ICE, TRASH, OR WALL DURING THE RIDE OR DISLODGING OF THE RIDER. NOOR DID IT FLIP OR TURN OVER AT ANY TIME, IN FACT THE VEHICLE DURING ITS REDUCTION IN SPEED, AS WELL AS THE CLOCK WISE SPIN EVER LEAVE THE FINAL LANE THAT THE RIDER WAS DISLODGED FROM THE VEHICLE. PLEASE EXCEPT THIS AS A REPLACEMENT AND UPDATE OF THE REMOVED COMPLAINT 11051430.

1 injured

WHILE RIDING ON THE HIGHWAY IN MOTION, DURING A CLEAR DAY ON JULY 16 2016. THE SUBJECT VEHICLE SUFFERED A BLOWN REAR TIRE LEAVING A LARGE CENTER STRIP OF BLENDED STEEL AND RUBBER SHAPED AS A WIDE BELT THAT EXTENDED PAST THE REAR OF THE BIKE. SEE THE MULTIPLE PHOTOS ATTACHED IN (EXHIBIT P). WHILE ATTEMPTING TO BRING THE BIKE TO A SAFE HALT TO THE SIDE OF THE HIGHWAY, THE ROTATION OF THE WHEEL USING THE STATED BELT BEAT THE PLASTIC REAR END OF THE VEHICLE TO A TOTAL DISMEMBERMENT OF CRUCIAL PARTS. WITH THE REAR END OF THE VEHICLE BEING RIPPED AWAY FROM THE VEHICLE, THE ATTACHED PASSENGER'S PLASTIC SEAT MOUNT WAS ALSO DESTROYED. FINELY AS THE VEHICLE WAS BEING BROUGHT DOWN TO A STOP TO THE SIDE OF THE HIGHWAY, SOMEHOW WITH THE VIBRATION OF THE ROTATING BLOW TIRE AND WHEEL, THE RIGHT FRONT WHEEL STABILIZING CAST IRON MECHANISM BROKE DISLODGING THE LOWER BALL JOINT THAT STABILIZED THE HORIZONTAL POSITION OF THE RIGHT FRONT WHEEL. SEE THE MULTIPLE PHOTOS ATTACHED IN (EXHIBIT K). THIS SENT THE VEHICLE IN A VIOLENT CLOCK WISE SPIN THAT FINELY OVERCAME THE RIDER'S GRIP DISLODGING THE SEAT AND RIDER ON TO THE SIDE OF THE HIGHWAY, AND THEN FINELY COMING TO A COMPLETE STOP FACING THE ONCOMING HIGHWAY TRAFFIC. HOWEVER, AT NO TIME DID THE VEHICLE HIT ANY CAR, CURB, WATER, ICE, TRASH, OR WALL DURING THE RIDE OR DISLODGING OF THE RIDER. NOOR DID IT FLIP OR TURN OVER AT ANY TIME, IN FACT THE VEHICLE DURING ITS REDUCTION IN SPEED, AS WELL AS THE CLOCK WISE SPIN EVER LEAVE THE FINAL LANE THAT THE RIDER WAS DISLODGED FROM THE VEHICLE. PLEASE EXCEPT THIS AS A REPLACEMENT AND UPDATE OF THE REMOVED COMPLAINT 11051430.

1 injured

SEE THE ATTACH NHTSA_COMPLAINT.PDF THE VEHICLE WAS IN MOTION. CAN AM SPYDER SERIAL/VIN # [XXX], MODEL # 000B9DC00. I HAVE PUT THAT I WAS GOING 75 MILES PER HOUR, NOT SURE OF THE NUMBER AS THIS IS A BIKE. MY GOAL IS TO KEEP UP WITH TRAFFIC. HOWEVER THE SPEED LIMIT ON THE HIGHWAY IS 75 MPH. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

1 injured

SEE THE ATTACH NHTSA_COMPLAINT.PDF THE VEHICLE WAS IN MOTION. CAN AM SPYDER SERIAL/VIN # [XXX], MODEL # 000B9DC00. I HAVE PUT THAT I WAS GOING 75 MILES PER HOUR, NOT SURE OF THE NUMBER AS THIS IS A BIKE. MY GOAL IS TO KEEP UP WITH TRAFFIC. HOWEVER THE SPEED LIMIT ON THE HIGHWAY IS 75 MPH. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

1 injured

SEE THE ATTACH NHTSA_COMPLAINT.PDF THE VEHICLE WAS IN MOTION. CAN AM SPYDER SERIAL/VIN # [XXX], MODEL # 000B9DC00. I HAVE PUT THAT I WAS GOING 75 MILES PER HOUR, NOT SURE OF THE NUMBER AS THIS IS A BIKE. MY GOAL IS TO KEEP UP WITH TRAFFIC. HOWEVER THE SPEED LIMIT ON THE HIGHWAY IS 75 MPH. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

1 injured

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. WHILE DRIVING 70 MPH, A BRAKE WARNING LIGHT ILLUMINATED AND THE VEHICLE REQUIRED A LONGER DISTANCE TO STOP. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND NOTICED BRAKE FLUID LEAKING BENEATH THE VEHICLE. FUMES OF SMOKE WERE SEEN BENEATH THE SEAT. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 13V386000(SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS TAKEN TO THE DEALER AGAIN WHERE IT WAS DIAGNOSED THAT THE BRAKE MASTER CYLINDER AND BRAKE FLUID RESERVOIR WERE MELTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 10,000.

Fire

I RECEIVED A RECALL NOTICE ABOUT THE ELEVATED TEMPERATURE IN THE ENGINE COMPARTMENT ON FEBRUARY 26, 2015. IN THE SAFETY RECALL NOTICE I WAS ADVISED TO CONTACT BRP DEALERSHIP, WHICH I DID IMMEDIATELY. I WAS TOLD THE PART WAS ON BACK ORDER AND TO CALL BACK IN APRIL I CONTACTED THEM AGAIN IN APRIL, WAS TOLD THE STATES WITH THE HOTTEST TEMPERATURE WAS FIRST CALL BACK IN A MONTH. I CALL IN MAY, WAS TOLD AGAIN, THE PART WAS NOT AVAILABLE. CALLED BACK IN JUNE WAS TOLD THE TOOL TO FIX THE PROBLEM WAS NOT AVAILABLE. MEANWHILE IN OHIO THE SUMMER MONTHS ARE HERE, AND THIS STILL HAS NOT BEEN RESOLVED. I CONTACTED BRP IN CANADA, NO RESPONSE. THIS CAN AM WAS PURCHASED NEW OFF THE SHOW ROOM FLOOR IN 2014, AND I AM ADVISED TO NOT RIDE IT WHEN ITS HOT, OR IN TRAFFIC. I AM NOT A HAPPY CAMPER RIGHT NOW, I PURCHASED THE BIKE TO ENJOY THE SUMMER MONTHS, RIDE WITH THE LEGION RIDERS AND IT SITS IN THE GARAGE.

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE); HOWEVER, THE MANUFACTURER'S REMEDY WAS INCOMPLETE. THE MANUFACTURER STATED THAT THEY WOULD BE REPLACING THE BODY PANEL WITH NEW IMPROVED BODY PANELS AND AN UPGRADED FUEL SYSTEM KIT. THE CONTACT RECEIVED TEMPLATES TO USE TO CUT OUT PIECES OF THE BODY PANEL. THE MANUFACTURER STATED THAT THIS WAS THE ONLY AVAILABLE REPAIR FOR THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN. .. .UPDATED 07/21/15 *BF

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. WHILE DRIVING 55 MPH, THE HEAT EMITTING FROM THE TOP OF THE VEHICLE MEASURED 169 DEGREES FAHRENHEIT. IN ADDITION, THE CONTACT HAD TO CONTINUOUSLY STEER THE VEHICLE IN ORDER TO KEEP IT IN POSITION. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE). THE VEHICLE WAS TAKEN BACK TO THE DEALER; HOWEVER, THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 3,000. MA 08/05/15 UPDATED 9/24/2015 *JS

WHILE RIDING MY CAN AM SPYDER FOR APPROXIMATELY 30 MINUTES, I WAS STOPPED AT A RED LIGHT FOR OVER A MINUTE. I THEN BEGAN TO FEEL EXCESSIVE HEAT FROM THE RIGHT SIDE OF THE BIKE, WHERE MY LOWER THIGH AND KNEE TOUCHES THE PANEL OF THE BIKE. I ALSO BEGAN TO SMELL A STRONG ODOR OF BURNING PLASTIC (SORT OF LIKE WHEN A RESISTER OR COMPUTER CHIP GETS FRIED). I IMMEDIATELY DROVE HOME WHERE I CHECKED THE BIKE FOR BURNT PLASTIC. I DID NOT NOTICE ANY BURNT PLASTIC, HOWEVER I DID NOT REMOVE ANY OF THE PANELS TO CHECK UNDERNEATH THEM. IT WAS APPROXIMATELY 77F WHEN THIS HAPPENED. I AM VERY CONCERNED THAT THE EXCESSIVE HEAT WILL MELT COMPONENTS UNDERNEATH THE PANELS OR START A FIRE. THE PANEL WAS VERY HOT TO THE TOUCH. I DID RECEIVE A VERY SLIGHT BURN TO MY THIGH AREA AFTER THE RIDE.

1 injured

WHILE RIDING MY CAN AM SPYDER FOR APPROXIMATELY 30 MINUTES, I WAS STOPPED AT A RED LIGHT FOR OVER A MINUTE. I THEN BEGAN TO FEEL EXCESSIVE HEAT FROM THE RIGHT SIDE OF THE BIKE, WHERE MY LOWER THIGH AND KNEE TOUCHES THE PANEL OF THE BIKE. I ALSO BEGAN TO SMELL A STRONG ODOR OF BURNING PLASTIC (SORT OF LIKE WHEN A RESISTER OR COMPUTER CHIP GETS FRIED). I IMMEDIATELY DROVE HOME WHERE I CHECKED THE BIKE FOR BURNT PLASTIC. I DID NOT NOTICE ANY BURNT PLASTIC, HOWEVER I DID NOT REMOVE ANY OF THE PANELS TO CHECK UNDERNEATH THEM. IT WAS APPROXIMATELY 77F WHEN THIS HAPPENED. I AM VERY CONCERNED THAT THE EXCESSIVE HEAT WILL MELT COMPONENTS UNDERNEATH THE PANELS OR START A FIRE. THE PANEL WAS VERY HOT TO THE TOUCH. I DID RECEIVE A VERY SLIGHT BURN TO MY THIGH AREA AFTER THE RIDE.

1 injured

WE HAVE BEEN WAITING FOR A RECALL FIX THAT WAS INFORMED BY BRP WOULD BE IN MAY 2015. THROUGH SOCIAL MEDIA WE WERE TOLD BY BRPCARE THAT THE FIX WAS READY AND SUPPLIED PICTURES. WE HAVE SCHEDULED THE WORK BUT AM NOT HAPPY WITH THE FIX AS IT CHANGES THE APPEARANCE OF THE VEHICLE. WHEN I CALLED NHTSA I WAS INFORMED THAT SHE COULD NOT FIND ANY INFORMATION THAT THIS FIX WAS APPROVED. *TR

WE ARE PAYING FOR A MOTORCYCLE WE CANNOT RIDE DUE TO A RECALL AND NO ONE CAN SEEM TO TELL US WHEN IT WILL BE FIXED. RECALL LETTER STATES IT WILL BE RESOLVED BY MAY OF 2015 - 2 DAYS LEFT IN MAY AND STILL NOT NOTIFIED OF HOW IT WILL BE FIXED - WE CANNOT RIDE THIS VEHICLE AS IT COULD CATCH ON FIRE - WE LIVE IN FLORIDA WHERE TEMPERATURES ARE EXTREMELY HOT - CONSEQUENTLY, WE HAVE NOT BEEN ABLE TO RIDE OUR MOTORCYCLE DUE TO THIS RECALL - WE CONTACTED BRP AND THEY ADVISED US NOT TO RIDE THE VEHICLE SO WE ARE MAKING PAYMENTS ON SOMETHING WE CANNOT USE OR SELL DUE TO A RECALL - NOT A HAPPY CONSUMER!

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. WHILE DRIVING APPROXIMATELY 15 MPH, THE MOTORCYCLE BEGAN TO OVERHEAT AND STALLED WITHOUT WARNING. THE MOTORCYCLE WAS ABLE TO RESTART HOWEVER, THE FAILURE RECURRED ON TWO OTHER OCCASIONS. THE MOTORCYCLE WAS TAKEN TO THE DEALER WHERE IT WAS INFORMED THAT THE CONTACT WAS DRIVING TO SLOW WHICH CAUSED THE MOTORCYCLE TO OVERHEAT. THE COMPUTER WAS REPROGRAMMED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE), HOWEVER THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 900.

WE WERE PART OF A NATIONAL BIKE CLUB RIDE TO A BEACH RESORT ACCOMPANIED BY APPROXIMATELY 300 RIDERS. WHEN WE DEPARTED ABOUT 7 AM, TEMPERATURES WERE IN THE LOW 70'S. THE ROUTE WAS MOSTLY DOWNHILL AND WE MAINTAINED AN AVERAGE SPEED OF ABOUT 50, 60 MPH. AFTER JUST OVER ONE HOUR WE ARRIVED AT THE RESORT WHERE WE ALL MOVED TO A LARGE GRAVEL PARKING AREA NEAR THE BEACH. WITHIN SECONDS AFTER I SHUT DOWN AND DISMOUNTED, GREY SMOKE STARTED SEEPING UP BETWEEN THE BODY PANELS WHICH QUICKLY TURNED INTO BLACK SMOKE SMELLING STRONGLY OF BURNING INSULATION. IN LESS THAN A MINUTE FIRE BROKE OUT FROM THE FRONT TOP VENTS AND BURNED THROUGH THE UPPER PLASTIC BODY PANELS EXTENDING MORE THAN 3 FEET INTO THE AIR. A FAST THINKING MEMBER RUSHED UP WITH A CO2 FIRE EXTINGUISHER AND STARTED EXTINGUISHING THE FIRE THAT BY THEN FLOWED OUT FROM UNDER THE BIKE AN THREATENED BIKES PARKED NEARBY. FORTUNATELY, THE FIRE WAS PUT OUT WITHIN 2 OR 3 MINUTES WITH NO DAMAGE TO OTHER PROPERTY OR ANY INJURIES. AT NO TIME DURING THE RIDE OR AT ANY OTHER TIME, EVEN WHEN AMBIENT TEMPERATURES WERE OVER 80 DID THE TEMPERATURE GAUGE REGISTER MORE THAN NORMAL. IT WASN'T UNTIL THE DAY AFTER THE INCIDENT THAT A FRIEND INFORMED ME THAT THERE HAD BEEN A RECALL ON THE YEAR & MODEL WARNING OF POSSIBLE FIRE HAZARD. ALSO, UPON CLOSE INSPECTION IT WAS NOTED THAT ONE OF THE FUEL LINES WAS BURNED, AND WAS LEAKING. *TR

Fire

WE WERE PART OF A NATIONAL BIKE CLUB RIDE TO A BEACH RESORT ACCOMPANIED BY APPROXIMATELY 300 RIDERS. WHEN WE DEPARTED ABOUT 7 AM, TEMPERATURES WERE IN THE LOW 70'S. THE ROUTE WAS MOSTLY DOWNHILL AND WE MAINTAINED AN AVERAGE SPEED OF ABOUT 50, 60 MPH. AFTER JUST OVER ONE HOUR WE ARRIVED AT THE RESORT WHERE WE ALL MOVED TO A LARGE GRAVEL PARKING AREA NEAR THE BEACH. WITHIN SECONDS AFTER I SHUT DOWN AND DISMOUNTED, GREY SMOKE STARTED SEEPING UP BETWEEN THE BODY PANELS WHICH QUICKLY TURNED INTO BLACK SMOKE SMELLING STRONGLY OF BURNING INSULATION. IN LESS THAN A MINUTE FIRE BROKE OUT FROM THE FRONT TOP VENTS AND BURNED THROUGH THE UPPER PLASTIC BODY PANELS EXTENDING MORE THAN 3 FEET INTO THE AIR. A FAST THINKING MEMBER RUSHED UP WITH A CO2 FIRE EXTINGUISHER AND STARTED EXTINGUISHING THE FIRE THAT BY THEN FLOWED OUT FROM UNDER THE BIKE AN THREATENED BIKES PARKED NEARBY. FORTUNATELY, THE FIRE WAS PUT OUT WITHIN 2 OR 3 MINUTES WITH NO DAMAGE TO OTHER PROPERTY OR ANY INJURIES. AT NO TIME DURING THE RIDE OR AT ANY OTHER TIME, EVEN WHEN AMBIENT TEMPERATURES WERE OVER 80 DID THE TEMPERATURE GAUGE REGISTER MORE THAN NORMAL. IT WASN'T UNTIL THE DAY AFTER THE INCIDENT THAT A FRIEND INFORMED ME THAT THERE HAD BEEN A RECALL ON THE YEAR & MODEL WARNING OF POSSIBLE FIRE HAZARD. ALSO, UPON CLOSE INSPECTION IT WAS NOTED THAT ONE OF THE FUEL LINES WAS BURNED, AND WAS LEAKING. *TR

Fire

WE WERE PART OF A NATIONAL BIKE CLUB RIDE TO A BEACH RESORT ACCOMPANIED BY APPROXIMATELY 300 RIDERS. WHEN WE DEPARTED ABOUT 7 AM, TEMPERATURES WERE IN THE LOW 70'S. THE ROUTE WAS MOSTLY DOWNHILL AND WE MAINTAINED AN AVERAGE SPEED OF ABOUT 50, 60 MPH. AFTER JUST OVER ONE HOUR WE ARRIVED AT THE RESORT WHERE WE ALL MOVED TO A LARGE GRAVEL PARKING AREA NEAR THE BEACH. WITHIN SECONDS AFTER I SHUT DOWN AND DISMOUNTED, GREY SMOKE STARTED SEEPING UP BETWEEN THE BODY PANELS WHICH QUICKLY TURNED INTO BLACK SMOKE SMELLING STRONGLY OF BURNING INSULATION. IN LESS THAN A MINUTE FIRE BROKE OUT FROM THE FRONT TOP VENTS AND BURNED THROUGH THE UPPER PLASTIC BODY PANELS EXTENDING MORE THAN 3 FEET INTO THE AIR. A FAST THINKING MEMBER RUSHED UP WITH A CO2 FIRE EXTINGUISHER AND STARTED EXTINGUISHING THE FIRE THAT BY THEN FLOWED OUT FROM UNDER THE BIKE AN THREATENED BIKES PARKED NEARBY. FORTUNATELY, THE FIRE WAS PUT OUT WITHIN 2 OR 3 MINUTES WITH NO DAMAGE TO OTHER PROPERTY OR ANY INJURIES. AT NO TIME DURING THE RIDE OR AT ANY OTHER TIME, EVEN WHEN AMBIENT TEMPERATURES WERE OVER 80 DID THE TEMPERATURE GAUGE REGISTER MORE THAN NORMAL. IT WASN'T UNTIL THE DAY AFTER THE INCIDENT THAT A FRIEND INFORMED ME THAT THERE HAD BEEN A RECALL ON THE YEAR & MODEL WARNING OF POSSIBLE FIRE HAZARD. ALSO, UPON CLOSE INSPECTION IT WAS NOTED THAT ONE OF THE FUEL LINES WAS BURNED, AND WAS LEAKING. *TR

Fire

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER ROADSTER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS UNAVAILABLE.

2013 CAN AM SPYDER RT. CONSUMER WRITES IN REGARDS TO RECALL RECEIVED REGARDING ELEVATED TEMPERATURE IN THE ENGINE COMPARTMENT. *SMD THE CONSUMER IS CURRENTLY WAITING FOR THE BIKE TO BE REPAIRED. *JB UPDATED 12/17/15 *JB

ON 26 MARCH 2015 I RODE HOME AFTER WORK OF APPROXIMATELY 30 MILES. THE OUTSIDE AIR TEMPERATURE THIS DAY WAS APPROXIMATELY 85 DEGREES AS A HIGH THAT DAY. UPON ARRIVING HOME, I LEFT MY 2013 CAN AM SPYDER RT SE-5 OUT SIDE THE GARAGE AS DIRECTED BY THE INTERIM RECALL NOTICE. I GOT OFF MY SPYDER AND NOTICED A STRANGE SOUND COMING FROM UNDER THE SEAT. I REMOVED MY HELMET AND LIFTED THE SEAT. THE SOUND WAS COMING FROM THE GAS TANK. I REMOVED THE GAS CAP AND COULD SEE GAS BOILING IN THE TANK. I HAVE NOTICED STRONG GAS SMELLS AND REPORTED THAT EARLY, BUT NEVER HAVE I HAD GAS BOILING IN THE TANK. I PUT THE GAS CAP BACK ON AND PUT MY HELMET IN THE GARAGE. I REOPENED THE GAS CAP IT WAS STILL BOILING AND WAS GOING TO FILM THIS, BUT WAS FEARFUL SOMETHING MIGHT HAPPEN. I CONTACTED MY DEALER WHO RETURNED MY CALL THE NEXT DAY. HE RELATED THEY HAD EXPERIENCED THAT BEFORE DURING THE SUMMER MONTHS. THEY SAID IT WAS STILL SAFE TO RIDE AND TAKE THE APPROPRIATE PRECAUTIONS AND WE WOULD HAVE TO SEE HOW THE RECALL DESIGN DISSIPATES THE HEAT. I CONTACTED A SECOND DEALER WHO RELATED THEY CONTACTED BRP AND NO ONE HAS REPORTED OR DEALT WITH ISSUES LIKE THIS? THEY RECOMMENDED I TRANSPORT THE UNIT TO THEM APPROXIMATELY 3 HOURS AWAY. I CALLED A THIRD DEALER AND WAS ADVISED OF THE PENDING RECALL. BOILING GAS IS SCARY IN MY BOOK, SINCE WHEN YOU ARE RIDING THE SPYDER YOU ARE RIDING VIRTUALLY ON TOP OF THE GAS TANK. THIS IS A BIT DISCOURAGING FOR THE AMOUNT OF MONEY TO PURCHASE THIS UNIT. *TR

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE) AND STATED THAT THE PARTS WERE NOT AVAILABLE UNTIL MID MAY 2015. THIS WAS AN UNREASONABLE TIMEFRAME BECAUSE THE DEALER AND THE MANUFACTURER HAD NO INTERIM REPAIR TO APPROVE FOR THE AUTHORIZED DEALER. THE DEALER DID NOT PROVIDE A SPECIFIC DATE WHEN THE PART WOULD BECOME AVAILABLE TO REPAIR THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE VEHICLE WOULD RECEIVE THE RECALL REPAIRS. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL*THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THERE WAS A BURNING FUEL ODOR AS WELL AS EXCESSIVE HEAT COMING FROM THE PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER MULTIPLE TIMES. THE TECHNICIAN WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE) HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 700.

Fire

TL*THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THERE WAS A BURNING FUEL ODOR AS WELL AS EXCESSIVE HEAT COMING FROM THE PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER MULTIPLE TIMES. THE TECHNICIAN WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE) HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 700.

Fire

TO BRP CAN AM SPYDER 2013 CAN AM SPYDER RT LIMITED 9-29-2014 I HAVE A BRAND NEW CAN AM SPYDER RT LIMITED STOPPED ON ME 2 TIMES IN FIRST GEAR WITH 120 MILES. NEXT THIS BIKE STOPPED ON ME AGAIN 11 TIMES OVER THE WEEKEND. THIS BIKE SHUTS OFF AT EVERY LIGHT I STOP AT. WHICH IS DANGEROUS. I WAS ALMOST REAR ENDED AT LEAST 2 TIMES .. I TOLD MY SALESMAN THAT I HAVE A STRONG GAS SMELL IN MY GARAGE .I TOOK BIKE AND DEALERSHIP TOLD ME TO LEAVE OVERNIGHT DUE TO STRONG GAS SMELL AND SHUTTING OFF. MY BIKE WAS READY FOR PICK UP THE NEXT DAY. I WAS TOLD THE CANISTER WAS OK AND THE LOUD FUEL SMELL SHOULD BE GONE .I WAS ADVISED THAT ALL RECALLS FOR THIS MODEL HAVE BE DONE. I WAS TOLD DEALER DID A GAS TREATMENT AND WAS ADVISED BIKE IS A 2013 MODEL WHICH HAD GAS SITTING IN TANK FOR A LONG TIME . I WAS ASK IF I TOP OFF GAS AND I TOLD THE DEALER NO! I READ ALL THE BOOKLET AND WATCH VIDEO PERTAINING TO THIS BIKE ALONG WITH SIGNING UP FOR SPYDERLOVER.COM. . I KNOW ALL BIKE HAVE BREAK IN PERIODS, BUT THIS IS TOTALLY UNACCEPTABLE AND SURELY NOT SAFE. I WAS INFORMED TO JUST RIDE MY BIKE AND TO REV THE ENGINE WHEN IT SEEMS LIKE IT'S GOING TO SHUT OFF. NOW WITH 500 MILES THE FUEL SMELL IS EVEN STRONGER AND I HAVE LOST COUNT ON HOW MANY TIMES IT SHUTS OFF IN 1ST GEAR AT A LIGHT OR JUST SITTING IN THE GARAGE. I CALL THE DEALER AGAIN. THEY INFORMED ME THAT AFTER 1,000 TO 1,500 MILES THESE ISSUES SHOULD GO AWAY AFTER THE 600 SERVICE. NOW, . THE REASON FOR THIS LETTER IS THAT THIS BIKE IS NOT SAFE BECAUSE OF THE STRONG FUEL SMELL AND I DON'T WANT TO BE REAR ENDED DUE TO BIKE SHUTTING OFF AT EVERY LIGHT. I AM ADDRESSING THIS ISSUE TO PREVENT THE ISSUE OF A POSSIBLE ACCIDENT OR A FIRE. NOW WITH 1,300 MILES AND SERVICED AT THE DEALER THE GAS SMELL HAS GOTTEN WORSE. IM TRYING TO PREVENT A FIRE OR BAD ACCIDENT FROM HAPPENING. SPYDER WEBSITE HAVE SEVERAL COMPLAINTS ONTHIS ISSUE WITH THE GAS. *TR

VEHICLE IS EXTREMELY HOT. RIGHT FOOT GETS UNBEARABLE HEAT. GAS FUMES PRESENT AT EVERY STOP. GAS FUMES FILL GARAGE WHEN BIKE IS HOT AND PARKED. CAN AM REFUSES TO DISCUSS THE DANGER OF GAS FUMES WHICH ARE EXTREMELY DANGEROUS IN A CLOSED ENVIRONMENT.THIS SAFETY ISSUE MUST BE ADDRESSED AS INDIVIDUAL OWNERS ARE POWERLESS TO GET CAN AM TO RESPOND TO THIS DANGEROUS SITUATION. PLEASE HELP *TR

I BOUGHT MY 2013 CAN AM SPYDER RT NEW IN FEB 2014. OVER THE YEAR THAT I HAVE OWNED THE BIKE, I HAVE NOTICED EXCESSIVE HEAT UNDER THE SEAT ALONG WITH A GAS SMELL. I HAD TALKED WITH VENDOR ON SEVERAL OCCASIONS AND HEARD VARIOUS OTHER EXPLANATIONS. I DID NOT GIVE IT TOO MUCH THOUGHT UNTIL I READ THE FORUMS AND SAW THIS WAS A COMMON SEVERE ISSUE. UNTIL RECENTLY THE CAN AM WAS KEPT IN AN OPEN AIR CARPORT, SO I NEVER NOTICED THE ODOR AFTER A RIDE. I HAD EXPERIENCED GAS FUMES AND SMELLS ON RIDES AND JUST DIDN'T THINK IT WAS A DEAL WHEN THE VENDOR KEPT TELLING ME NOT TO OVER FILL THE TANK. I DON'T OVER FILL THE TANK AND STOP AFTER THE FIRST CLICK WHICH THEN CAUSES THE TANK NOT TO BECOME FULL AND HAVING TO STOP MORE OFTEN TO REFUEL ON LONG RIDES. WHEN WE MOVED INTO OUR NEW HOUSE WE NOW HAVE A TWO CAR GARAGE AND AFTER THE LAST FEW RIDES, I GAS UP BEFORE COMING HOME AND NOTICE A STRONG GAS ODOR AND LEAVE THE GARAGE DOOR OPEN FOR AN HOUR OR UNTIL THE FUMES DISSIPATE. NOW READING OF THE MAJOR HEAT AND FUME ISSUES IS EXTREMELY SCARY TO ME AND CAUSES SOME CONCERN IF THE MANUFACTURE NEW OF THIS ISSUE WHEN THE UNIT WAS SOLD TO ME IN FEB 2014. I WILL HAVE TO PAY ATTENTION THE NEXT TIME ON A RIDE AND SEE IF THE GAS IS BOILING AS REPORTED ON OTHER UNITS. I HAVE READ ON THE FORUMS AND FACEBOOK A RECALL IS PENDING TO RESOLVE THE HEAT ISSUE WHICH HOPEFULLY WILL RESOLVE THE GAS FUME ISSUE AS WELL. *TR

MY SPYDER HAS BEEN LEAKING OIL SINCE THE DAY I BOUGHT IT NEW. I HAVE OWNED IT FOR 6 MONTHS, HAS BEEN IN THE SHOP SEVERAL TIMES. STILL LEAKING. GAS FUMES SO BAD COMING FROM THE ENGINE AFTER RIDING I CAN NOT CLOSE THE GARAGE DOOR FOR AT LEAST AN HOUR/. SMELLS OF GAS REALLY STRONG EVERY TIME I AM ON THE BIKE. GAS CAP SO HOT I CAN HARDLY TOUCH IT WHEN I NEED TO GET GAS. *TR

PURCHASED MY 2013 CAN-AM SPYDER ON 03/05/14, IN SPRINGFIELD, MI. MY HOME ADDRESS IS NEW IBERIA, LA. I DROVE THE BIKE BACK HOME. MY FIRST FUEL STOP I WAS OVERWHELMED BY THE STRONG SMELL OF GASOLINE AND I CAN SMELL GAS FUMES EVERY TIME I FUEL UP. AT EVERY FUELING I HAVE TO USE GLOVES OR A RAG TO PUT OVER THE GAS CAP TO UNSCREW IT BECAUSE IT IS SO HOT. THEN WHEN I TRY TO UNSCREW THE CAP IT JUST RATCHETS WITH OUT UNSCREWING IT. I HAVE SPENT AT LEAST 30 TO 45 MINUTES TRYING TO UNSCREW THE CAP AND AFTER TANK COOLS OFF THE GAS CAP RELEASES, THEN YOU CAN FUEL UP. ON SEVERAL OCCASIONS I HAVE HAD TO PRY THE GAS CAP WITH A SCREW DRIVER TO REMOVE IT AND THEN YOU CAN HEAR THE FUEL BOILING IN THE TANK. I HAD 3 GAS CAPS FROM ANOTHER RECALL AND TRIED ALL 3 CAPS AND THEY DID THE SAME THING, JUST RATCHET AND NOT UNSCREW. WHILE TRAVELING I WAS IN PENSACOLA, FL AND COULD NOT REMOVE THE GAS CAP AND WENT TO THE DEALERSHIP THERE AND THEY REPLACED THE GAS CAP AFTER IT COOLED OFF. THE NEXT DAY I HAD TO RE-FUEL AND THE CAP THEY JUST PUT ON WOULD NOT UNSCREW. THURSDAY OCTOBER 30, 2014, I HAD TO REFUEL AND COULD NOT OPEN THE FUEL TANK AND HAD TO PRY IT OPEN WITH A SCREW DRIVER TO PUT FUEL TO GET HOME. WHILE DOING SO THE CAP WAS SO TIGHT THAT THE TOP PORTION BROKE OFF LEAVING THE BOTTOM PORTION IN THE FUEL TANK NECK. IT GETS SO HOT MY RIGHT FOOT ACTUALLY BURNS FROM THE ENGINE HEAT. WHEN I WANT TO CRANK THE BIKE AFTER FUELING THE BIKE DOES NOT WANT TO CRANK. IT SPINS THE ENGINE FOR A LONG TIME BEFORE IT CRANKS AND THEN IT RUNS SO BAD, MISSING ETC., AND DIES OUT 2 OR 3 TIMES BEFORE I CAN TRAVEL. THEN WHEN I GET TO PLACES I HAVE TO STOP THE BIKE ENGINE DIES OUT WHILE COASTING OR TAKING OFF, LEAVING YOU IN AN INTERSECTION WITH NO POWER. I ASKED THE DEALERSHIP TECH IN PENSACOLA WHAT CAUSED THAT AND HE ADVISED CAN-AM HASN'T FIGURED OUT WHY THAT HAPPENS JUST YET. *TR

1 injured

THE BIKE GETS VERY HOT. I HAVE ALREADY HAD THE EXAUST WRAPPED BUT IT IS STILL VERY HOT TO RIDE. *TR

600 MILE SERVICE COMPLAINED TO DEALER OF EXTREME FUEL SMELL AFTER RIDES. WAS TOLD THAT THE PURGE VALVE WAS BAD AND THEY REPLACED IT UNDER WARRANTY. RODE HOME AND NOTICED THAT THE FUEL SMELL WAS THE SAME. WHEN I CHECKED UNDER THE ROADSTER I FOUND FUEL DRIPPING FROM THE BOTTOM OF THE ROADSTER. I CALLED DEALER AND WAS TOLD TO TOP OFF THE FUEL TANK BEFORE PUTTING VEHICLE IN GARAGE. DEALER SAID THAT THIS WAS NORMAL. 4600 MILE SERVICE AGAIN COMPLAINED OF EXTREME FUEL SMELL AFTER RIDES. ASKED DEALER ABOUT HOT HOT RIGHT FOOT WAS TOLD BY DEALER THIS WAS NORMAL AND THE ROADSTER WAS OPERATING NORMALLY. 9200 MILE SERVICE COMPLAINED OF EXTREME FUEL SMELL AND HEAT ON RIGHT FOOT, NO HEAT LEFT HAND GRIP, AND INTERMITTENT HEAT ON RIGHT HAND GRIP, WARPED RIGHT HAND CENTER BODY PANEL. WHEN SERVICE WAS COMPLETE I ASKED ABOUT NO HEAT ON HAND GRIPS. TECHNICIAN FOUND LOOSE CONNECTORS AT BOTH HAND GRIPS AND THAT THE CONNECTIONS COULD BE A PROBLEM IF THERE WERE GAS FUMES IN THE AREA. BODY PANEL ORDERED AND REPLACED UNDER WARRANTY. TOLD BY DEALER THAT THE PANEL WAS BENT FROM FACTORY NOT HEAT. TECHNICIAN AND SERVICE MANAGER DID NOT AGREE AND BOTH SAID IT WAS CAUSED BY EXCESSIVE HEAT. *TR

HAVE OWNED RT LIMITED FOR LESS THAN ONE YEAR WITH HEAT ISSUES. WHILE RETURNING FROM EVENT IN NORTH CAROLINA BIKE RAN FINE IN THE COOLER TEMPERATURES. AS SOON AS RETURNED TO THE SOUTH, ENGINE BEGAN TO RUN HOT AND CHECK ENGINE LIGHT ON AND OFF AS WELL AS BIKE CHUGGING AND RUNNING ROUGHLY. BIKE SHUTTING DOWN AND HAD TO LET COOL OFF BEFORE WOULD RESTART. HAVE HAD EXTREME HEAT ISSUES SINCE PURCHASING BIKE ESPECIALLY IN HOTTER MONTHS HERE IN HOUSTON AREA. HAVE HAD UPDATES DONE PER BRP RECOMMENDATIONS TO NO SUCCESS. BIKE IS NOT SAFE AND FEAR RIDING ANY LENGTH OF TIME OR PROLONGED DISTANCE. WHEN PARKED IN GARAGE AFTER RIDING FIND THERE IS A STRONG GAS SMELL IN THE GARAGE. FOR THIS REASON USUALLY LEAVE BIKE IN YARD FOR UPTO 30 MINUTES PRIOR TO PUTTING GARAGE FOR FEAR OF FIRE CONSUMING HOME. NOT SURE WHAT THIS REPORT WILL DO BUT FEEL LIKE SOMEONE SHOULD BE MADE AWARE OF HOW UNSAFE AND POTENTIALLY DANGEROUS THESE VEHICLES ARE. DEALERS ARE AT A LOSS FOR WHAT TO DO AS I HAVE EXPERIENCED SAME PROBLEMS WITH A 2013 ST LIMITED MODEL THAT WAS TRADED DUE TO BRAKE FAILURE AND EXTREME HEAT ISSUE MELTING PARTS. THOUGHT THE RT MODEL WOULD BE BETTER BUT FIND MYSELF IN SAME SITUATION. *TR

SMELL GAS VAPORS IN THE GARAGE AND HOUSEBAFTER DRIVING IT. SEAT FRONT TOP WHERE IT MEETS THE BODY(STORAGE COMPARTMENT) TO HOT TO TOUCH OR SIT ON WITHOUT A SHEEPSKIN PAD AND STILL VERY UNCOMFORTABLE AND LIKELY DANGEROUS. RIGHT FOOT GETS SO HOT FROM THE MOTOR YOUR CAN'T KEEP YOUR FOOT IN PLACE. HAVE TO WEAR HEAVY BOOTS. HAVE HAD THE RECALL AND ELECTRONIC UPDATES. *TR

VEHICLE GIVES OFF SUCH A STRONG FUEL ODOR AFTER A RIDE, WE NOW PARK THE VEHICLE OUTSIDE OUR ENCLOSED GARAGE FOR A FEW HOURS SO THE ODOR WILL NOT BE OVERWHELMING IN OUR GARAGE. ALSO, THE VEHICLE'S FUEL TANK IS VERY HOT TO THE TOUCH WHEN RE-FILLING WITH GAS. VEHICLE WAS TAKEN TO AN AUTHORIZED BMP DEALERSHIP ABOUT THE STRONG FUEL ODOR AND THEY DID NOT FIND ANYTHING WRONG. *TR

I PURCHASED A CAN AM SPYDER RT 2013 ON AUGUST 23, 2013. FROM DAY ONE I'VE HAD EXCESSIVE FUEL SMELLS AFTER RIDES,ALSO GAS BOILING IN FUEL TANK AFTER RIDES. YOU CAN ACTUALLY HEAR AND SEE THE GAS BOILING IN THE TANK. THERE IS EXCESSIVE HEAT COMING OUT FROM AROUND THE GLOVE BOX AREA AND ALSO AROUND THE PASSENGER RIGHT FOOT REST. NEEDLESS TO SAY ALL THIS HEAT MAKES FOR AN EXTREMELY UNCOMFORTABLE RIDE. I HAVE HAD ALL RECALLS AND UPDATES DONE TO DATE. SEPTEMBER 2013 TOLD MY DEALER OF EXCESSIVE FUEL SMELLS WHILE THE BIKE WAS IN HAVING THE HEAT SHIELDING RECALL WORK PERFORMED. HE SAID THAT HE DID NOT SMELL THE FUEL COMING FROM THE BIKE. I WENT BACK A WEEK LATER TO HAVE WORK DONE TO THE AIR RIDE SUSPENSION THAT WAS BROKEN UPON RECEIVING MY NEW BIKE. WHILE HE WAS WORKING ON THE BIKE REPAIRING THE AIR RIDE SUSPENSION HE NOTICED THE SMELL AND REPLACED MY EVAP.CANISTER. THIS WAS AFTER I HAD THE RECALL DONE. HE HAD TO REMOVE THE RECALL WORK AND REPLACE MY EVAP CANISTER AND THEN REINSTALL THE RECALL WRAPPING. TODAY OCTOBER 28, 2014 WENT FOR A RIDE FUELED UP ON THE WAY HOME.I RODE HOME APPROXIMATELY 20 MINUTES. WHEN I PARKED THE BIKE I COULD HEAR THE FUEL BOILING AND COULD SEE IT IN THE TANK. OBVIOUSLY ALL THE UPDATES AND RECALLS ARE NOT HELPING. I ALSO HAD HANDLING ISSUES WITH THE BIKE FROM BRAND-NEW. THAT I HAD TO HAVE CORRECTED WITH MY OWN MONEY SPENT. *TR