2020 BMW 530I

5 recalls, 15 complaints - 360 TSBs

ELECTRICAL SYSTEM:STARTER ASSEMBLY:RELAY

Defect Description

BMW of North America, LLC (BMW) is recalling certain 2019-2021 BMW 330i, 2019-2022 BMW Z4, 2020-2022 BMW 530i, X3, X4, Toyota Supra, 2021-2022 BMW 430i, 430i Convertible, and 2022 BMW 230i vehicles. The engine starter relay may corrode, causing the relay to overheat and short circuit.

Consequence

A short circuit in the starter relay may increase the risk of a fire.

Remedy

Owners are advised to park their vehicles outside and away from structures until the remedy is complete. Dealers will replace the engine starter, free of charge. Owner notification letters were mailed February 6, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identificatio... Read more

199,674 vehicles affected

Manufacturer: BMW of North America, LLC

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Defect Description

BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Co... Read more

Consequence

If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.

Remedy

BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.

13,858 vehicles affected

Manufacturer: BMW of North America, LLC

POWER TRAIN:DRIVELINE:DRIVESHAFT

Defect Description

BMW of North America, LLC (BMW) is recalling certain 2020-2021 530i xDrive, 540i xDrive and 2021 740Li xDrive vehicles. The output shafts (left/right) which transfer power from the driveshaft to the rear wheels may break due to a heat treatment error during supplier production.

Consequence

A broken output shaft can lead to a loss of drive power or a rollaway condition in a parked vehicle (if the parking brake is not engaged), increasing the risk of a crash.

Remedy

BMW will notify owners, and dealers will replace the output shaft(s), free of charge. The recall began March 24, 2021. Owners may contact BMW customer service at 1-800-525-7417.

28 vehicles affected

Manufacturer: BMW of North America, LLC

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Defect Description

BMW of North America, LLC (BMW) is recalling certain 2020-2021 X3 sDrive 30i, X3 xDrive 30i, X3M 40i, X3 xDrive 30e, X4 xDrive 30i, X4M 40i, 530i, 540i, 540i xDrive, M550i xDrive, M5, 550e, 550e xDrive, and 550e iPerformance vehicles. A small portion of the rearview image may be slightly obscured. ... Read more

Consequence

If the driver relies on only the rearview camera image, the reduced rearview image view can increase the risk of a crash or injury.

Remedy

BMW will notify owners, and dealers will inspect and, if necessary, program the rearview camera with updated software. The recall began November 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.

312 vehicles affected

Manufacturer: BMW of North America, LLC

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Defect Description

BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Con... Read more

Consequence

The lack of an image in the back-up camera display increases the risk of a crash.

Remedy

BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.

257,473 vehicles affected

Manufacturer: BMW of North America, LLC

Complaint Statistics

15 total complaints

Top Reported Components

Component	Complaints
ENGINE	4
ELECTRICAL SYSTEM	3
SERVICE BRAKES	2
UNKNOWN OR OTHER	2
EXTERIOR LIGHTING	1
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING	1
SEATS	1
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL	1

Incident date: Apr 17, 2024

These are two separate incidents. The first one is the seat moves to the left or to the right given the direction of the vehicle. The other incident was when I was reversing into a parking spot. The gear shifted out of reverse and just was in a floating stage. I then had to put it back into reverse... Read more

Incident date: Apr 17, 2024

Component/System: Engine — 1.5L EcoBoost short block coolant intrusion leading to catastrophic engine failure. Vehicle is available for inspection upon request. Safety Risk: Vehicle overheated while in operation, creating risk of engine fire, loss of vehicle control, and stranding of occupant on a... Read more

Incident date: Apr 17, 2024

The contact owns a 2019 Jeep Wrangler. The contact stated that while starting the vehicle, the instrument panel became inoperable, turning on and then shutting off. The contact stated that while driving, the instrument panel was blank. The vehicle was taken to the dealer, where it was diagnosed, and... Read more

Incident date: Mar 13, 2026

Vehicle has 28,000 miles and auto shop states that the engine is blow, it's knocking and vibrating throughout the engine.

Incident date: Oct 5, 2025

My vehicle was taken in to shop due to recall recommendation I received in GM app for fuel pump control module . After repair was done my engine begin ticking the same day and failed a week later . I documented the whole thing and filed a claim with GM however the dealership that did the repair are... Read more

Incident date: Oct 5, 2025

The vehicle is experiencing a suspected brake actuator / brake booster failure. Multiple warning lights appeared simultaneously, including ABS, Brake, Traction Control, and Master Warning lights. The vehicle produces a frequent buzzing noise from the brake system, especially at low speeds or when s... Read more

Incident date: Oct 5, 2025

My kia Sorento shocks are really bad seems like it bounces Alot More than normal and heard a squeak coming from the shocks also hard to get the to turn when Im park and electric seems to glitch with bulbs going out faster and radio acting like it shorting out since the wiring was replaced it does th... Read more

Incident date: Nov 18, 2025

On 11/01/2025, while traveling on the highway traveling at a speed of 80mph, my vehicle suddenly would not accelerate beyond 60 mph. I managed to exit safely, but this created a dangerous situation for both me, my daughter and other motorists . The next day, Firestone inspected the vehicle and info... Read more

Incident date: Jul 25, 2025

The MMI system, which is the display in the car, keeps rebooting every few minutes. It is extremely distracting while driving. Also during parking or back up the parking assistance and backup camera would suddenly disappear because the system reboots. The rear cross traffic warning stops working dur... Read more

Incident date: Dec 4, 2023

Appears to be an issue with the Dual Clutch Transmission. Makes the suv jolt after starting, waiting in traffic/red light and/or randomly driving around. Speed is not a determine factor in causing this “jolt”, for it happens at any rate of speed. Fear is the suv will randomly just stall and/or c... Read more

Incident date: Oct 21, 2021

When I hit a bump my ABS warning light and my traction control light come on on the dash. My cruise control stops working. Had it scanned and there is an error code C0020-01-ABS PUMP MOTOR CONTROL - motor pump (open recirculation test). - internal electronic failure. It comes on and off more often w... Read more

Incident date: Oct 21, 2021

When I am driving with my headlights on auto, every time I use my turn signal (and sometimes spontaneously) my headlights flicker. Sometimes it’s just for a second, but other times it has lasted more than 3 seconds which can be very dangerous while driving at night. It is also dangerous because ot... Read more

Incident date: Mar 29, 2023

While traveling at highway speeds from Colorado to Texas and from Texas back to Colorado my car continuously slammed on the brakes without warning while the autopilot(cruise control) was engaged. There was no visible evidence or object in common for each event. What made this dangerous is any unti... Read more

Incident date: Jan 24, 2022

There is a light sensor in the digital instrument cluster that dims the brightness during the day that it makes the instrument cluster un-readable.

EPA Fuel Economy, 2020 BMW 530I

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
2.0L 4-cyl, Automatic (S8) (Rear-Wheel Drive)	25.0	33.0	28.0	Premium	$2,750

CO2 Emissions: 316.0 g/mile (Midsize Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2020 BMW 530I

360 manufacturer communications from 163 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
110000 ELECTRICAL SYSTEM	77
350000 EQUIPMENT	50
060000 ENGINE AND ENGINE COOLING	22
353000 EQUIPMENT:ELECTRICAL	19
118000 ELECTRICAL SYSTEM:SOFTWARE	19
356000 EQUIPMENT ADAPTIVE/MOBILITY	17
010000 STEERING	15
060000 ENGINE (PWS)	13

120000 EXTERIOR LIGHTING

One or more of the LED daytime running lights are dim or discolored.

060000 ENGINE AND ENGINE COOLING

Check Control message (CCM) indicates: (ID 213): Stop, exercising due care. Voltage supply The Service Engine Soon light is on with the following DME Fault Code: 21B209 - Starter alternator / belt for 48V system (OSA_RIEMEN_RISS): Belt b

350000 EQUIPMENT

The functionality of the left rear SRR sensor could be reduced which would display the Driving Assistance Check Control Message.

110000 ELECTRICAL SYSTEM

The functionality of the left rear SRR sensor could be reduced which would display the Driving Assistance Check Control Message.

350000 EQUIPMENT

The functionality of the right rear SRR sensor could be reduced which would display the "Driving Assistance"- Check Control Message.

110000 ELECTRICAL SYSTEM

The functionality of the right rear SRR sensor could be reduced which would display the "Driving Assistance"- Check Control Message.

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

The basic conditions for initializing the power windows are not met.

110000 ELECTRICAL SYSTEM

The basic conditions for initializing the power windows are not met.

110000 ELECTRICAL SYSTEM

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on ho

010000 STEERING

At low outside temperatures (below 40 degrees F) and slow driving speeds (i.e. when parking, maneuvering)with a large steering angle, the front end can be slightly axially misaligned. This can be felt (jerking)/ heard via an acoustic ackno

353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT

The Central Information Display goes black intermittently due to resets of the Head Unit (HU-H3). FaultB7F8F9 ??A???A???A???A???A???A? ??A???A???A???A???A???A?HU-H: Reset??A???A???A???A???A???A? will be stored in the HU-H3.

110000 ELECTRICAL SYSTEM

010000 STEERING

SITUATION Unusual noises occur only when operating the steering column in the axial direction. 1. A one-time thump sound at the start of movement Shortly after the steering column starts moving, retracting, or extending, a one-time thump

070000 FUEL SYSTEM, GASOLINE

Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pre

060000 ENGINE AND ENGINE COOLING

350000 EQUIPMENT

Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicle??A?A?s equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) i

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

PRESSURE CONTROL VALVE (PCV) EXTENDED LTD WTY 15 YEARS/150,000 MILES

060000 ENGINE AND ENGINE COOLING

220000 SEATS

?The front seat will not calibrate/initialize, and the stored faults cannot be deleted.

010000 STEERING

?Unusual noises occur only when operating the steering column in the axial direction.

100000 POWER TRAIN

?A software error may cause an unwanted pressure pulsation in the transmission during a "Remote Engine Start."

060000 ENGINE AND ENGINE COOLING

?A software error may cause an unwanted pressure pulsation in the transmission during a "Remote Engine Start."

162900 STRUCTURE:BODY:ROOF AND PILLARS

?The sunroof will not operate in either direction.

134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY

?The sunroof will not operate in either direction.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

The air conditioning cycles from cold to warm air while driving or while at a stand still. The vent outlet temperatures vary by 25 degrees Fahrenheit or more (38 F to 60 F +) without changing any climate control settings.

118000 ELECTRICAL SYSTEM:SOFTWARE

With the introduction of the BMW Remote Software Upgrade, all Service Pack 18 vehicles and partial Service Pack 15 vehicles may receive new functionality or modifications in their features.

010000 STEERING

A groaning type noise is heard during the height adjustment.

120000 EXTERIOR LIGHTING

Headlight check control (CC) message 128 "High beam headlight failure" is displayed. The following fault codes are stored during a vehicle test: 80419A - Left high-beam headlight: Short circuit and/or 8041A5 - light outputs: Number of permi

110000 ELECTRICAL SYSTEM

118000 ELECTRICAL SYSTEM:SOFTWARE

BMW AG has issued an Emissions Recall (effective March 17, 2023) on a certain Model Year 2021 - 2023 BMW vehicles that were produced between June 16, 2020, and December 13, 2022. Due to a software failure, there is the possibility that the

100000 POWER TRAIN

070000 FUEL SYSTEM, GASOLINE

A vehicle arrives at your center to be diagnosed for a micro-leak in the fuel evaporative (EVAP) system (NVLD natural vacuum leak detection). For this condition, the following fault is stored in the DME: 190302 - fuel tank ventilation and s

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

BMW AG has issued a Delivery Stop effective June 6, 2023 on certain Model Year 2023 - 2024 BMW vehicles that were produced between October 26, 2022 and May 8, 2023.

110000 ELECTRICAL SYSTEM

After programming the head unit (HU-H2), activating the FSC (German word Freischaltcode) Enabling Codes repeatedly fails.

110000 ELECTRICAL SYSTEM

Due to a software error, the vehicle sporadically does not achieve sleep mode. As a result, the 12-volt battery becomes discharged and may cause a no-start condition.

162500 STRUCTURE:BODY:TAILGATE

Upon opening and closing the tailgate, a creaking/groaning sound can be heard from tailgate actuator.

118620 ELECTRICAL SYSTEM:ADAS:HUD:CAMERA/SENSOR

Issues with the various functions of the camera-based driver assistance systems (KAFAS system) can possibly lead to following customer complaints: KAFAS camera system deactivates itself, due to system restrictions that are not clear to the

118320 ELECTRICAL SYSTEM:ADAS:DRIVER MONITORING:CAMERA/SENSOR

350000 EQUIPMENT

The 3G network in the US has been shut down. This means that only the 4G network will be available. In the 4G network, voice calls will be transferred via the Voice over LTE (VoLTE) function. For this purpose, the SIM card must perform an I

110000 ELECTRICAL SYSTEM

120000 EXTERIOR LIGHTING

One or more of the LED daytime running lights are dim or discolored.

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

Customer states there is no audio playback (telephony, navigation, radio) and system sounds (PDC, turn indicators, acoustic signals) may also have failed.

110000 ELECTRICAL SYSTEM

Due to a software error, the vehicle sporadically does not achieve sleep mode. As a result, the 12-volt battery becomes discharged and may cause a no-start condition.

010000 STEERING

A groaning type noise is heard during the height adjustment.

274300 LANE DEPARTURE:LANE KEEP:NAVIGATION SYSTEM/SOFTWARE

Customer is shown an incorrect GPS location in the vehicle (i.e., Nav Map, coordinates).

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

Customer is shown an incorrect GPS location in the vehicle (i.e., Nav Map, coordinates).

060000 ENGINE AND ENGINE COOLING

There is a howling or whistling noise from under the vehicle at 30 -37 mph (50 -60 km/h) when driving after a cold start, when the outside temperature is 32 F (0 C) or lower.

100000 POWER TRAIN

BMW AG has issued a Delivery Stop: Due to a software failure, there is the possibility that the transmission does not go into "sleep mode" if the car is turned off.

060000 ENGINE (PWS)

Engine Variants Updated.

100000 POWER TRAIN

There is a howling or whistling noise from under the vehicle at 30 -37 mph (50 -60 km/h) when driving after a cold start, when the outside temperature is 32 F (0 C) or lower. The noise goes away as the vehicle/driveline reaches operating te

060000 ENGINE AND ENGINE COOLING

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

Customer is shown an incorrect GPS location in the vehicle (i.e., Nav Map, coordinates).

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Due to a software error, Remote Software Upgrade (RSU) and Remote Support are currently not possible. Additionally, the Integrated Owner's Handbook cannot be displayed.

010000 STEERING

The saved steering column positions, vertical and horizontal, are not stored long term.

060000 ENGINE AND ENGINE COOLING

There is a howling or whistling noise from under the vehicle at 30 -37 mph (50 -60 km/h) when driving after a cold start, when the outside temperature is 32F (0C) or lower.

160000 STRUCTURE

A cracking, metallic noise from under the center of the vehicle.

060000 ENGINE AND ENGINE COOLING

Coolant leaking from the engine compartment. Traces of coolant leaking from the expansion tank of the low temperature cooling system.

134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY

The sunroof will not operate in either direction. There are NO faults stored related to the sunroof. If the vehicle has any faults stored related to the sunroof, this bulletin does not apply.

118000 ELECTRICAL SYSTEM:SOFTWARE

After programming, the customer may complain that the Sport Mode display is not fully displayed in the instrument cluster. Instead of a red background in sport mode, the background is displayed in blue (like ECO PRO mode).

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

980000 UNKNOWN OR OTHER

130000 VISIBILITY

After opening the vehicle with the radio remote control and changing the profile, the exterior mirror settings are lost.

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

The customer complains that the radio stations change by themselves.

280000 BACK OVER PREVENTION

According to the customer, the airbag warning light was on, but it may not be illuminated when the vehicle arrives in the workshop. 1. ACSM fault code "930A60 - Seat occupancy detection, front passenger; malfunction" is stored. The fault ma

270000 LANE DEPARTURE

220100 SEATS:BARRIERS

980000 UNKNOWN OR OTHER

140000 AIR BAGS

353000 EQUIPMENT:ELECTRICAL

Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column.

353000 EQUIPMENT:ELECTRICAL

The sound output intermittently drops out entirely. This can be reproduced with all audio sources as well as telephone and voice output.

350000 EQUIPMENT

Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column. Note: Opening, closing and starting via the BMW Digital Key or the Digi

110000 ELECTRICAL SYSTEM

061610 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE

BMW offers a new special ISTA Installation made available for Roadside Assistance / Mobile Service technicians. The new ISTA Version is also able to be used in case of a Remote Software Upgrade (RSU) programming failure to get the customer

118000 ELECTRICAL SYSTEM:SOFTWARE

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Note: Before performing a repair and submitting a claim, first confirm that the vehicle has the above Notice of Limited Warranty Extension in the DCSnet Warranty Inquiry Vehicle Comments section. If you have Extended Limited Warranty (ELW)

118000 ELECTRICAL SYSTEM:ADAS

The functionality of the right rear SRR sensor could be reduced which would display the "Driving Assistance" Check Control Message.

110000 ELECTRICAL SYSTEM

The Headunit High (HU-H), also called NBT, began replacing the Car Information Computer (CIC) on certain MY2013 vehicles with option 609 (as of 7/2012 production). This uses map North America NEXT. The Headunit High 2 (HU-H2), also called N

353000 EQUIPMENT:ELECTRICAL

When using the Key Reader to retrieve information from the customer's key, no current vehicle data is available.

353000 EQUIPMENT:ELECTRICAL

Check Control Message (CCM) displays "Vehicle key missing" after engine start.

110000 ELECTRICAL SYSTEM

BMW AG is conducting a Voluntary Service Action on certain Model Year 2019-2020 BMW Plug-In HybridElectric (PHEV) vehicles that were produced between March 25, 2019, and October 17, 2020. Analyses of transmitted teleservice data indicate

118000 ELECTRICAL SYSTEM:SOFTWARE

Sport mode is not displayed correctly in the instrument cluster. Instead of a red background in sport mode, the background is displayed in blue (like in Eco Pro mode). Software in the instrument cluster (Kombi).

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

Check Control message (CCM) displays "Vehicle key missing" after engine start.

353000 EQUIPMENT:ELECTRICAL

48 V battery may become totally discharged, and possible replacement needed.

120000 EXTERIOR LIGHTING

The customer complains that under moderate throttle application or on deceleration after throttle application, a Malfunction Indicator Lamp (MIL) is displayed in the instrument cluster.

350000 EQUIPMENT

Information updated about engine oil filter cap drain plug. When performing an engine oil service on vehicles equipped with a N63M, N63B or S63M engines; the ETK states to use "Set oil filter element" P/N 11 42 5 A33 C42 or P/N 11 42 5 A33

070000 FUEL SYSTEM, GASOLINE

The belt pulley on the mechanical coolant pump may fracture allowing the engine drive belt to come off the coolant pump and alternator.

060000 ENGINE AND ENGINE COOLING

The belt pulley on the mechanical coolant pump may fracture allowing the engine drive belt to come off the coolant pump and alternator.

350000 EQUIPMENT

No heater output in passenger area.

353800 EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER

No heater output in passenger area.

010000 STEERING

The steering intervention for Lane Departure Warning (LDW) is too strong (severe), which can create an uncomfortable feeling for the driver. Background: Steering intervention helps keep the vehicle in the lane if the system detects that a

270000 LANE DEPARTURE

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

BMW AG has issued a Delivery Stop (effective June 9, 2021) on certain Model Year 2021 BMW vehicles that were produced between May 7, 2021 and May 21, 2021. The Receiver Audio Module (RAM) will need to be added to the affected vehicles.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

BMW AG is conducting a Voluntary Service Action on certain Model Year 2019-2020 BMW Plug-In Hybrid-Electric (PHEV) vehicles that were produced between March 25, 2019, and October 17, 2020.

280100 BACK OVER PREVENTION:SOFTWARE

In some rare cases a customer vehicle might be excluded from one or more Remote Software Upgrade(RSU) campaigns. This SIB gives an overview how to identify these vehicles and how to proceed in case of a customer complaint.

060000 ENGINE AND ENGINE COOLING

The belt pulley on the mechanical coolant pump may fracture allowing the engine drive belt to come off the coolant pump and alternator.

070000 FUEL SYSTEM, GASOLINE

The belt pulley on the mechanical coolant pump may fracture allowing the engine drive belt to come off the coolant pump and alternator.

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Temporary black screen in the instrument cluster.

353000 EQUIPMENT:ELECTRICAL

Temporary black screen in the instrument cluster.

Showing 100 of 360 bulletins.

BMW 530I - All Years Overview

Complete safety history for the BMW 530I across all model years (1978, 2025).

59 Total Recalls

807 Total Complaints

0 Investigations

45 Reported Crashes

57 Reported Fires

0 Reported Deaths

BMW 530I - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2025	3	3	View
2024	5	27	View
2023	1	3	View
2022	3	10	View
2021	7	20	View
2020 (current)	5	15
2019	1	28	View
2018	2	38	View
2017	1	25	View
2011	1	0	View
2010	1	0	View
2009	1	0	View
2008	1	0	View
2007	2	109	View
2006	3	128	View
2005	0	84	View
2004	0	175	View
2003	2	61	View
2002	4	32	View
2001	4	29	View
2000	1	0	View
1995	2	7	View
1994	3	12	View
1993	1	0	View
1992	1	0	View
1991	1	0	View
1990	1	0	View
1989	1	0	View
1978	1	0	View

Other BMW Models

Model	Recalls	Complaints
X5	223	4,349	View
X3	155	2,661	View
330I	122	1,050	View
X6	110	293	View
328I	108	3,743	View
M3	95	550	View
Z4	83	1,439	View
325I	83	1,809	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2020 BMW 530I

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 2020 BMW 530I

Technical Service Bulletins, 2020 BMW 530I

Most Affected Components

BMW 530I - All Years Overview

BMW 530I - Year by Year

Other BMW Models