2007 BMW 530I Recalls, Complaints & Safety

BMW 530I headlights have faulty wiring. Insulation is crumbling an severly degraded leaving bare wires exposed to short circuits. Discovered the faulty wire when I went to replace the parking / angel eye lights. I have attempted to solve the problem short term with electrical tape. As soon as you touch the wire to put electrical tape on it, more of the faulty insulation comes off. Wire has essentially lost all insulation.

I purchased my BMW & got inside to drive off jumping on 275 freeway & the whole car just started smoking out nowhere the whole car was scorching hot & smoking other cars had to literally pull over because of so much white smoke I took it to several certified car doctors & they all refused to touch it because of the PVC recall valve

Well was driving fine one day then the next it didn't do nothing an still hasn't done or moved since found that the module in the truck were the spare was got wet an melted then I got another put it in an still nothing changed starter still nothing an found out a recall was found called bmw but they wasn't willing to have it towed to a service provider

The contact owns a 2007 BMW 530I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). The contact stated that while driving at approximately 65 MPH, there was smoke coming from the hood. The "transmission overheating" message was displayed. The vehicle was inoperable. The vehicle was towed to an independent mechanic, where it was diagnosed that the PCV valve and transmission needed to be replaced. The vehicle remained with the independent mechanic awaiting the repair. The manufacturer was made aware of the failure. The approximate failure mileage was 170,000. The VIN was not available.

The contact owns a 2007 BMW 530I. The contact stated while driving at various speeds, there was an abnormal burning odor coming from the A/C vents. The contact also noticed the burning odor whenever opening the hood. The message "Service Engine Soon" was displayed. The contact later received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). However, the parts to do the recall repair were not yet available. The local dealer was not contacted. The contact stated while driving 65-70 MPH, he noticed smoke coming out from underneath the hood of the vehicle. The contact veered to the side of the road for a moment and then opened the hood. The contact was able to continue driving. The contact stated that the failure had reoccurred on two different occasions. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 175,000. VIN tool confirms parts not available.

The contact owns a 2007 BMW 530i. The contact stated while driving at various speeds, the brakes would not engage when the brake pedal was depressed. The contact also stated that he had to use additional force on the brake pedal to stop the vehicle. The contact stated no warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed with the vacuum hose and the brake booster needing to be replaced. The vehicle was not repaired. The contact was relating the failure to NHTSA campaign number: 10V446000 (Service Brakes, Hydraulic). The manufacturer had been informed of the failure and referred the contact to the local dealer. The failure mileage was approximately 137,745.

ELECTRICAL PROBLEMS AND TRANSMISSION REPAIR ISSUES

BRAKE PRESSURE LOSS, UNABLE TO STOP VEHICLE IN A SAFE MANNER. BRAKE PEDAL WENT TO THE FLOOR. CHECKED BRAKE FLUID RESERVOIR & FLUID LEVEL LOW. DEEPER INSPECTION REVEALED CORRODED REAR BRAKE HARD LINE. VERY COMMON ON E60 & PREVIOUS GENERATION E39 BMW'S.

Crash

MY CAR WAS IN MY DRIVEWAY. MY COMPLAINT IS I JUST BOUGHT THE CAR FROM A FRIEND OF OUR FAMILY AND EVERYTHING WAS. ABOUT A MONTH LATER WHEN I START THE CAR I GET THIS ERROR" FAULT IN PASSENGER RESTRAINT SYSTEM EFFECTING AIRBAG-BELT TENSIONER OR BELT FOR DELIMITER. SO I CALL BMWUSA TO SEE IF THIS WAS RECALLED. THE MAN I SPOKE WITH SAID YES IT WAS BUT I LET ME HAVE YOUR VIN# OH NO I'M SORRY NOT FOR YOUR VIN " I WAS SHOCKED TO THINK IT WOULD BE A RECALL ON ONE BUT NOT ANOTHER. IF IT IS EFFECTING MY AIR BAG U WOULD THINK. IT WOULD BE A SAFETY ISSUE FOR ALL CARS THAT GET THAT ERROR. OR WAS THAT CAR BUILT KNOWING IT WAS EVENTUALLY GOING TO GO OUT AND WE THE CUSTOMERS ARE GOING TO HAVE TO PAY FOR IT. I WOULD RATHER NOT HAVE THAT AT ALL. IT MAKES NO SENSE. ESPECIALLY IF YOUR OK TO FIX SOME CARS AND NOT ALL OF THEM AFTER ALL WHY WOULD WE WANT SOMETHING IN THE CAR IF WE KNOW ONE ITS JUST GOING TO GO OUT AND WE HAVE TO PAY FOR IT. AND FOR THE SAFETY PART . IT EVEN SOUNDS MORE CRAZY THAT SOMETHING LIKE THAT COULD MALFUNCTION AND I NOT EVEN SURE IF ANYBODY SHOULD RIDE IN MY PASSENGER SEAT. WELL IT'S [XXX] AT [XXX] IF YOU HAVE ANY QUESTIONS THANK YOU FOR YOUR TIME AND HAVE A WONDERFUL DAY. GOOD BLESS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC *TR

THE HEADLIGHT WENT OUT - REPLACED BULBS AND STILL NOT WORKING. REMOVED THE HEADLIGHT ASSEMBLY AND NOTICED EVERY WIRE WAS BARE WITH BARELY ANY COATING LEFT TO PROTECT THE WIRES- AT LEAST 15 WIRES. HEADLIGHT REPLACEMENT COST IS OVER $650.00.!! THIS IS AN ELECTRICAL HAZARD AND COULD CAUSE SHORTING OUT AND A DANGEROUS DRIVING SITUATION IN THE LEAST.

CAR VIBRATES WHEN AC IS ON. PASSENGER SEAT BELT BUZZES WHEN NO ONE IS IN THE SEAT AS WELL AS SEAT BELT TIGHTEN WHILE DRIVING. TRANSMISSION HESITANT AT TIMES. ( TRANSMISSION WARNING LIGHT COME ON AT TIMES, WHEN CAR HAS ALREADY BEEN SERVICE).

INSULATION ON ELECTRICAL WIRING INSIDE HEADLIGHT ASSEMBLY IS CRUMBLING APART. THIS LETS BARE WIRE TOUCH EACH OTHER AND SHORTS OUT HEADLIGHT, LEADING TO MALFUNCTIONING / VERY UNPREDICTABLE AND DANGEROUS LIGHTING. OTHER DRIVERS MAY NOT SEE YOU COMING

I WAS SITTING STILL AND THE STEERING WHEEL LOCK CAME ON. IT STATED THAT THE CAR MAY NOT BE ABLE TO START. I AM TIRED OF PUTTING MONEY IN THIS. THEY WANY $130.OO JUST TO DIAGNOSIS IT BEFORE THEY EVEN WANT TO FIX IT. PLEASE MAKE THIS A RECALL. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

THE FRONT PASSENGER SEAT OCCUPANT DETECTION LIGHT IS ON DUE TO THE MAT CUSHION FAILURE. THIS IS VERY COMMON ON BMW AND MOST OF THEM HAVE A RECALL ISSUED, BUT NOT FOR MY 2007. PLEASE ADVISE AS THE DEALERSHIP WANTS $1800 FOR A NEW ONE. PASSENGER AIRBAG WILL NOT WORK UNLESS REPLACED

MY MESSAGE DISPLAY IS STATING THAT THE AIRBAG ON THE FRONT PASSENGER SEAT OCCUPANT MAY NOT DEPLOY IN A CRASH DUE TO CRACKS AND FATIGUE WHICH COULD LEAD TO A SYSTEM FAILURE, THIS LOOKS LIKE IT COULD HAVE BEEN A RECALL ISSUE THAT I WASN'T NOTIFIED ABOUT

THE PASSENGER SEAT OCCUPANCY MAT SENSOR HAS FAILED AND IT HAS TRIGGERED THE SEAT BELT AND AIRBAG LIGHT SENSOR FOR MY BMW. BMW SAYS IT IS NOT UNDER RECALL, BUT THEY HAVE RECALLED THE 2006 BMW E60 (MINE IS A 2007) FOR THE SAME PROBLEM.

THE HEADLIGHT ASSEMBLY HAD A HALO LIGHT THAT BURNT OUT. I WENT TO THE DEALER AND BOUGHT A REPLACEMENT BULB. WHEN I UNSCREWED THE LIGHT BULB, THE WIRING INSULATION FELL OFF AND EXPOSED ALL OF THE COPPER WIRING IN THE HEADLIGHT WIRING HARNESS. THEY DO NOT SELL A REPLACEMENT WIRING HARNESS AND NOW I'M REQUIRED TO BUY A NEW HEADLIGHT ASSEMBLY FOR THE PASSENGERS SIDE WHICH COSTS APPROX $1700+ AT MY LOCAL DEALERSHIP. DUE TO THE HIGH COSTS OF THE HEADLIGHT ASSEMBLY, I'M NOT ABLE TO AFFORD IT AND NOW MY CAR WILL NOT PASS INSPECTION WHICH HAS PREVENTED ME FROM DRIVING IT. I CAN ONLY IMAGINE THAT THE OTHER HEADLIGHT HAS THE SAME ISSUE FROM READING 100'S OF OTHER FORUM POSTS ON THE INTERNET ABOUT THIS SAME ISSUE WITH THEIR VEHICLES. I'VE ATTEMPTED TO FIX THIS ISSUE MYSELF USING ELECTRICAL TAPE BUT THAT DIDN'T WORK FOR LONG. I'VE CONTACTED REPAIR SHOPS AND THEY WON'T TAKE THE HEADLIGHT ASSEMBLY APART DUE TO THE AGE OF IT. THE VEHICLE WAS IN MOTION WHEN THE LIGHT BULB BURNT OUT. THIS ISSUE HAPPENED IN 2015 AND I DECIDED TO DRIVE WITH THE HALO LIGHT BULB BURNT OUT BUT THEN THE LOW BEAM BULB BURNT OUT. NOW MY CAR WON'T PASS INSPECTION TO CONTINUE DRIVING IT IN TEXAS.

WIRING ON HEADLIGHTS FLAKING APART LEAVING BEAR EXPOSE WIRES !!!

MY CAR AUTOMATICALLY SHUT OFF AND I SMELLED A BURNING PLASTIC ODOR COMING FROM THE ENGINE. I TOOK MY CAR TO THE BMW LICENSED MECHANIC THAT I NORMALLY SEE WHO REPAIRED THE ISSUE THAT WAS DEEMED TO BE THE PCV VALVE HEATER. THIS HAPPENED AT THE END OF MAY. THEN AT THE END OF JUNE, I RECEIVED A LOWER FROM BMW ANNOUNCING RECALL # 17V-683: PCV VALVE HEATER. BMW TOLD ME TODAY THAT THEY CAN NOT REFUND ME FOR THE REPAIRS THAT I HAD DONE BECAUSE THESE REPAIRS HAD TO BE PERFORMED AT A BMW DEALERSHIP. I HAVE ALL MY RECEIPTS. TOTAL REPAIRS COST $2626.91 + RENTAL CAR EXPENSES OF $204.16 AND $76.71. * (RECALL RELATED INCIDENT) TS

Fire

MY CAR AUTOMATICALLY SHUT OFF AND I SMELLED A BURNING PLASTIC ODOR COMING FROM THE ENGINE. I TOOK MY CAR TO THE BMW LICENSED MECHANIC THAT I NORMALLY SEE WHO REPAIRED THE ISSUE THAT WAS DEEMED TO BE THE PCV VALVE HEATER. THIS HAPPENED AT THE END OF MAY. THEN AT THE END OF JUNE, I RECEIVED A LOWER FROM BMW ANNOUNCING RECALL # 17V-683: PCV VALVE HEATER. BMW TOLD ME TODAY THAT THEY CAN NOT REFUND ME FOR THE REPAIRS THAT I HAD DONE BECAUSE THESE REPAIRS HAD TO BE PERFORMED AT A BMW DEALERSHIP. I HAVE ALL MY RECEIPTS. TOTAL REPAIRS COST $2626.91 + RENTAL CAR EXPENSES OF $204.16 AND $76.71. * (RECALL RELATED INCIDENT) TS

Fire

THERE'S A RECALL FOR MY CAR'S PCV AND BMW STILL HASN'T DEVELOPED A REMEDY TO FIX THE ISSUE....GOING ON 9 MONTHS NOW. HOW LONG ARE BMW DRIVERS WITH RECALLS SUPPOSED TO WAIT TO FIX THEIR CARS. I CAN'T BELIEVE THAT THE COMPANY WOULD LEAVE THEIR CUSTOMERS STANDING IDLE ON THIS ISSUE FOR SO LONG.

ALL RUBBER TUBING HAS FALLEN OFF OF LIGHTS CREATING A MAJOR FIRE HAZARD.WIRING IS CURRENTLY DOWN TO COPPER, WITH MULTIPLE WIRES TOUCHING EACH OTHER WHICH HAS CAUSED MY LIGHTS TO NO LONGER WORK.

HEADLIGHTS INTERNAL WIRING GETA SO HOT IT MELTS AND CRACKS AND DETERIORATES AND CAUSES SHORT CIRCUIT EVENTUALLY LEADING TO BOTH OR SINGLE HIGH BEAM MALFUNCTION.

LAST YEAR I COULD HEAR A SOUND OF WATER THROUGH MY SUNROOF AND WOULD HAVE WATER THROWN AT ME THROUGH MY AC. MY STEREO AND DASH STOPPED WORKING AND SUDDENLY STARTED WORKING AFTER A COUPLE OF MONTHS. I TOOK IT TO 2 DIFFERENT LOCATIONS AND THEY WOULD TELL ME THERE WAS NO SHORT IN A FUSE. YESTERDAY MY CAR WOULD NOT START IT WAS STATIONED IN FRONT OF MY HOME. I WENT TO A MECHANIC AND FOUND THAT MY BATTERY WAS SITTING IN WATER. THE CAR WILL NOT START EVEN AFTER WATER WAS DRAINED AND THE BATTERY WAS REPLACED. I CALLED BMW BUT THEY WANT TO CHARGE ME $385 JUST FOR A DIAGNOSTIC. I HAVE CHANGED MY BATTERY LIKE 4 TIME IN THE LAST 2 YEARS WHICH IS JUST A HEADACHE IN ITSELF. MY VEHICLE WONT START.

MY 2007 BMW 530I HAS A MESSAGE IN THE DASH WITH A RED STEERING WHEEL SAYING "STEERING WHEEL LOCK MALFUNCTION!" "STEERING WHEEL MAY STAY LOCKED/UNLOCKED AND VEHICLE MAY NOT START"..... I HAVE CALLED THE BMW MANUFACTURING COMPANY IN SOUTH CAROLINA AND THEY TOLD ME THAT THERE WAS NOTHING THEY COULD DO ABOUT THIS ISSUE STATING THAT THE VEHICLE WAS 11 YRS OLD AND PROBLEMS WILL ACCRUE WITH THAT AGE ON ANY VEHICLE. YES THAT MAY BE TRUE BUT THIS IS A SAFETY ISSUE BECAUSE THE STEERING WHEEL COULD LOCK WHILE DRIVING DOWN THE RD AND CAUSE AN ACCIDENT. I ALSO CALLED THE LOCAL BMW DEALERSHIP TO SEE HOW MUCH IT WOULD COST TO RESOLVE THIS ISSUE ON MY OWN AND THE SAID THAT THE PART ITSELF WAS AROUND $600!!! THEN ADD ON 4HRS OF LABOR TO THAT WITH A LABOR RATE OF $145 AND HE! THAT ADDS UP TO ALMOST $1200.00, HOW CAN A STEERING WHEEL LOCK COST SO MUCH! AND US CUSTOMERS BE FORCED TO PAY THIS AMOUNT BECAUSE IF WE DON'T WE MAY END UP ON THE INTERSTATE AT 70MPH AND THE STEERING LOCKUP AND HAVE MAJOR ACCIDENT. SOMEONE PLEASE HELP WITH THIS ISSUE!

TL* THE CONTACT OWNS A 2007 BMW 530I. WHILE ATTEMPTING TO DRIVE THE VEHICLE, THERE WAS A TICKING NOISE COMING FROM THE ENGINE, A BURNING ODOR, AND SMOKE EMITTED THROUGH THE VENTS. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 17V683000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 179,688.

Fire

TL* THE CONTACT OWNS A 2007 BMW 530I. ON SEVERAL OCCASIONS, WHILE THE FRONT PASSENGER SEAT BELT WAS CONNECTED, THE SAFETY SEAT AIR BAG INDICATOR ILLUMINATED. THE MESSAGE INDICATED THAT THE FRONT PASSENGER SEAT OCCUPANT DETECTION MAT WAS FAULTY. THE VEHICLE WAS TAKEN TO FERMAN BMW (31400 US HWY 19 N, PALM HARBOR, FL 34684 AT (727) 785-3900) WHERE IT WAS DIAGNOSED THAT THE SEAT BELT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT DID NOT OFFER ANY ASSISTANCE. THE CONTACT WAS ADVISED TO CALL NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 101,000.

THIS SEEMS TO HAPPEN WHEN THE WEATHER IS HOT AND IN MAJOR TRAFFIC OR WHEN I AM OUT ON THE OPEN HWY DRIVING FOR ABOUT 1 TO 2HRS ON A HOT DAY. THE CAR WILL AUTOMATICALLY CUT OFF WITHOUT WARNING. NO ALARM OR IDIOT LIGHT INDICATOR. THE PROBLEM IS YOU CAN BE DRIVING 60 TO 75 MILES PER HOUR ON THE INTERSTATE AND LOOSE CONTROL OF YOUR POWER STEERING AND ABILITY TO MANEUVER THE CAR TO A SAFE STOPPING POINT. IT WILL NOT START BACK UP UNTIL 15 TO 20 MINUTE LATER AS IF THE CAR NEEDS TO COOL DOWN. ONCE TIME PERIOD HAS ELAPSE THE CAR WILL RUN AS NORMAL. THIS HAS HAPPEN SEVERAL TIMES. DRIVING HOME FROM WORK IN TRAFFIC AND WE ONLY GOING 45 MPH BUT ITS HOT OUTSIDE AND THE CAR WILL CUT OFF WITHOUT WARNING. I NOTICE ON THE BMW FORUM THIS IS PROBLEM THAT IS ACROSS THE BOARD WITH OTHER VEHICLES. THE CAR WILL CUT OFF AT A LIGHT AFTER DRIVING FOR LONG PERIOD OF TIME IN HOT WEATHER IN THE CITY LIMITS BUT ALSO ON THE HWY AFTER LONG PERIOD OF DRIVING.

TL* THE CONTACT OWNS A 2007 (NA) BMW 535I. WHILE REVERSING OUT OF A PARKING SPACE AT 4 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO ENGAGE. THE CONTACT APPLIED PRESSURE AND THE BRAKE PEDAL TRAVELED TO THE FLOOR WHEN IT FINALLY ENGAGED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT'S VEHICLE CRASHED INTO A PARKED VEHICLE. THERE WERE NO INJURIES. THE POLICE WERE NOTIFIED, BUT NO REPORT WAS FILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED, THE MECHANIC INFORMED THE CONTACT OF NHTSA CAMPAIGN NUMBER: 10V446000 (SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.

Crash

THE LEFT FRONT PARKING BULB WAS NO WORKING, TOOK THE VEHICLE TO BMW DEALERSHIP IN COLUMBIA, S.C. TO HAVE BULB REPLACED. UPON PICKING UP THE VEHICLE, THE WARNING INDICATOR FOR THE SAME BULB AND THE LEFT FRONT HIGH BEAM WARNING BOTH LIGHTS WERE NOT FUNCTIONING CORRECTLY APPEARED. I RETURNED TO THE SERVICE DEPARTMENT TO INQUIRE WHY THE WARNING WAS ON, WHICH THEY STATED IT WAS PROBABLY LEFT LOOSE. THE SERVICE ADVISER RETURNED TO BRING ME INTO THE SHOP TO SHOW ME THE WIRING FOR THE LIGHT ASSEMBLY WAS CRACKING AND FALLING OFF, EXPOSING BARE WIRE CAUSING THE SHORT AND BLOWING THE BULBS. THE SERVICE DEPARTMENT AT BMW STATED A NEW ASSEMBLY WOULD BE REQUIRED WHICH WOULD BE ABOUT $1500 EACH FOR THE PARTS. AFTER REPLACEMENT OF THE BULB WHILE IN THE SERVICE DEPARTMENT, THERE WAS ANOTHER ELECTRICAL SHORT CAUSING THE BULBS TO BLOW IMMEDIATELY. I HAVE READ THE WIRING WAS COATED WITH A SOY BASED PRODUCT, WHICH IS WHY THE WIRING COATING IS PREMATURELY CRACKING AND EXPOSING BARE COPPER WIRE, CREATING AN ELECTRICAL AND FIRE HAZARD. DUE TO THE INADEQUATE MATERIAL UTILIZED BY THE MANUFACTURER, IT SHOULD BE RECTIFIED BY THE MANUFACTURER PRIOR TO SERIOUS INJURY OR DEATH.