2006 BMW 530I Recalls, Complaints & Safety

The contact owned 2006 BMW 530I. The contact received unknown recall notifications and requested to be removed from the recall distribution list because he no longer owns the vehicle. The dealer and the manufacturer were contacted. The manufacturer referred the contact to the NHTSA Hotline for assistance. The VIN was unavailable.

The vehicle caught fire on the highway / interstate. Completely burnt down. The incident has been reported to the insurance company. But still haven't had any feedback . The vehicle is located at the tow place. It is not drivable it's completely burnt. Pierce the fire started in the engine.

Fire

The contact owns a 2006 BMW 530I. The contact received notification of the NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was notified of the issue and confirmed that parts were not yet available. The contact stated that on multiple occasions while the vehicle was idling, the vehicle lunged forward with the check engine warning light intermittently illuminated. The contact stated that a certified mechanic inspected the vehicle and determined that an O2 sensor, coil, and other unknown failures were affected by the recall. Additionally, the contact stated that she had to add a quart of oil every 400 miles. The contact also noticed a burning odor throughout the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 156,000.

My serpentine belt broke causing my car to shut down. Apparently only BMW’s have a terrible design that the belt gets sucked into the engine and then the engine is gone. No other cars have this design. There are thousands of this model vehicle that are dead cars being sold online. This seems to be a problem

The contact owns a 2006 BMW 530I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2006 BMW 530i. The contact stated that while driving, the engine temperature was extremely hot. While the vehicle was parked inside the garage, the cooling fan continued to run. There were no warning lights illuminated. The vehicle was taken to an independent mechanic where the heat pump and thermostat were placed. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. VIN tool confirms parts not available. The failure mileage was approximately 43,000.

The contact owns a 2006 BMW 530i. The contact received notification of NHTSA Campaign Number: 19V273000 (Engine and Engine Cooling) and 22V119000 (Engine and Engine Cooling) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact stated that air bag and seat belt warning lights were illuminated. the contact took the vehicle to the dealer and was informed that air bag and seat belt needed to be repaired. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage 100,000. VIN tool confirms parts not available.

The contact owns a 2006 BMW 530i. The contact stated upon coming to a complete stop, the vehicle would shudder significantly. Additionally, the contact stated that the engine was misfiring while driving. The transmission warning light and another unknown warning light illuminated. The contact stated that upon parking the vehicle in the driveway, he smelled a strong burning plastic odor. The contact turned off the vehicle. The vehicle was not diagnosed or repaired. The contact later received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 217,000. VIN tool confirms parts not available.

2006 BMW 5 SERIES. CONSUMER WITES SEEKING REIMBURSEMENT FOR VEHICLE REPAIRS RELATED TO SAFTEY RECALL 22V-119.

The contact owns a 2006 BMW 530i. The contact stated while driving approximately 35 MPH, the vehicle was smoking and came to a complete stop. The contact stated that several unknown warning lights were illuminated. The vehicle was towed to the residence and then to a local dealer. The dealer diagnosed the vehicle with engine and transmission failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact related the failure to NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). The failure mileage was unknown.

The contact owns a 2006 BMW 530i. The contact stated while driving at approximately 65 MPH, the contact observed an unspecified "yellow" warning light on the dash and heard a small explosion sound issue from the engine compartment. The contact stated that smoke began to come out from under the hood. The contact turned the vehicle off and set the transmission to "neutral" coasted off the roadway onto the left shoulder and stopped. The vehicle was on fire in the engine compartment. The contact extinguished the flames with a fire extinguisher. The contact had the vehicle towed to his residence. The contact had not taken the vehicle to a dealer or an independent mechanic. The contact received a recall letter and related the failure to NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 150,000.

Fire

The contact owns a 2006 BMW 530i. The contact stated while driving approximately 15 MPH, the vehicle started smoking from the engine and steering wheel. There was no fire in the vehicle. The check engine light illuminated on the instrument panel. The contact pulled over safely to the side of the road. The vehicle was cooled down and then was driven to an independent mechanic who was unable to determine the cause of the failure. The vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was not notified of the failure. The approximate failure mileage was 2,000.

The contact owns a 2006 BMW 530i. The contact stated upon taking the vehicle to an independent mechanic to be serviced, he was informed that the VIN was included in NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the vehicle had experienced excessive oil consumption. The manufacturer was not made aware of the failure. The low engine oil pressure warning light was illuminated. The failure mileage was approximately 8,000. VIN tool confirms parts not available.

The contact owns a 2006 BMW 530i. The contact stated that upon starting the vehicle, the passenger’s side air bag warning light illuminated, and remained illuminated. Additionally, the check engine and brake warning lights also illuminated. The contact had not taken the vehicle to a dealer to be diagnosed. The failure was intermittent. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 127,000.

The contact owns a 2006 BMW 530i. The contact stated that the battery drained quickly, which caused the contact to frequently replace the battery. The vehicle was taken to an independent mechanic however, the mechanic could not duplicate the failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

Approximately two months ago (March 2021) the instrument panel airbag and seat belt warning lights had begun to remain on. The BMW dealer determined it was a faulty front passenger air bag occupancy sensor mat which was then replaced and repaired at the owner's expense. This defect was specifically covered in a Service Information bulletin SB-10056703-9690, dated September 2014, which superseded SI B01 09 14, dated August 2014, which extended BMW's limited warranty to 15 years, without mileage limitation, if the warning light came on within the extended 15 year period. Unfortunately, BMW corporate determined this defect was not within the 15 year period based on the vehicle's in-service date. Said BMW is an original owner vehicle with less than 45,000 miles or driven an average of 3,000 miles per year.

HEADLIGHTS WOULD TAKE TURNS RANDOMLY WORKING, THEN ONE NIGHT BOTH HEADLIGHTS TURNED OFF WHILE I WAS GOING AROUND A CORNER AT 55MPH. THIS WAS IN THE COUNTRY NO STREET LIGHTS. JUST AS I CAME TO A BLIND STOP THERE BOTH KICKED BACK ON. AFTER GETTING HOME I TOOK APART TO FIND SOME WIRES WERE ROTTING OTHER ALREADY BARE, AND OTHERS CRACKING. I PRAY THIS DOESNT HAPPEN TO ANYONE ELSE BECAUSE IF THIS PROBLEM ISN'T FIXED SOMEONE'S GOING TO DIE. ALSO IF SOMEONE DOES CRASH I PRAY TO GOD THEY CAN QUICKLY GET OUT OF CAR BEFORE ALL THOSE BARE WIRES BEHIND HEADLIGHT GET SMASHED TOGETHER AND THE FIRE STARTS.

I WAS DRIVING ON THE STREET WITH MY MUSIC IN LOW WHEN I NOTICED THE DRIVER CAR SEAT GETTING HOT. I HADN'T TURNED ON THE HEATED SEATS AND I TOUCHED THE PASSENGERS SEAT AND IT WAS COOL. IT WAS TO HIT FOR ME TO DRIVE I HAD TO SIT COWARD SO MY BACK WOULDN'T TOUCH THE SEAT. IT WAS SO UNCOMFORTABLE AND DANGEROUS. I'VE READ A LOT OF COMMENTS OF PEOPLE HAVING THIS HAPPEN TO THEM. I HAVE A 2006 BMW 530I

1 injured

CAR GAVE A PASSENGER RESTRAINT SYSTEM MALFUNCTION ERROR THAT HAS BEEN IDENTIFIED IN TWO PRIOR NHTSA RECALL CAMPAIGNS THAT INCLUDE THE THE 2006 BMW 530I.

CAR SHUT OFF MIDDLE OF HIGHWAY VERY DANGEROUS AND DEADLY ALL BECAUSE KEY LOST CODE...HOW IF IT'S IN THE IGNITION AND I'VE BEEN DRIVING OVER SEVERAL MILES

MY AIRBAG LIGHT CAME ON FOR NO REASON ONE DAY AND WILL NOT GO OFF I INITIALLY GOT A RECALL PAPER FOR IT BUT WAS UNABLE TO TAKE IT TO THE SHOP I VAN NO LONGER FIND THE PAPER BUT THE TRANSMISSION IS TRASH

MANUFACTURES RECALL VEHICLE WAS RELOCATED AND NOW UNKNOWN

PASSENGER SEAT SENSOR FAULTY, AIRBAG DISABLED. FAULTS ARE SHOWING, AND WARNING LIGHTS ARE ON. I HAVE CALLED THE DEALER AND BMW USA, BOTH ACKNOWLEDGE AN ISSUE BUT INSIST MY CAR IS NOT COVERED. THE VIN IS NOT ON THEIR ROSTER. BMW RECALLED 200,000 CARS FOR THIS PROBLEM, IN THE SAME YEAR AND MODEL. I NOW HAVE THE ISSUE, AND IT IS A CLEAR SAFETY CONCERN FOR ANY WHO MIGHT RIDE IN THE CAR.

TL* THE CONTACT OWNS A 2006 BMW 530I. THE CONTACT STATED THAT THE BRAKE VACUUM PUMP WAS LEAKING OIL INTO THE POWER BRAKE BOOSTER. THE DIAGNOSIS WAS COMPLETED BY AN INDEPENDENT MECHANIC WHO SPECIALIZED IN BMW VEHICLES. THE DEALER (GLOBAL IMPORTS BMW, 500 INTERSTATE N PKWY, ATLANTA, GA 30339, (800) 294-1853) WAS CALLED AND THE CONTACT WAS WAITING TO HEAR BACK. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 140,000.

MY AIRBAG LIGHT IS ON AND MY TRANSMISSION HAS AN ISSUE AS IF IT NEEDS TO BE REPLACED AFTER RESEARCH I FOUND OUT THAT MECHATRONICS AND OTHER COMPONENTS TO BE AN ISSUE FOR INSTANCE IF YOUR TRYING TO PASS YOUR CAR STALLS AND SAYS TRANSMISSION FAILURE AFTER SHUTOFF MESSAGE DISAPPEARS CAR WILL GO IN LIMP MODE AND CAR STARTS OUT IN 2ND GEAR INSTEAD OF 1ST AND 1ST GEAR WILL ALSO LOCK ITSELF.....THIS IS DANGEROUS FOR A SUPPOSED HIGH END WELL BUILT PERFORMANCE VEHICLE. TRANNY HAS NO ISSUES COMPUTER DOES THAT CAUSES SHUTTER AND STALL LIMP MODE NEARLY COULD HAVE DIED

"TAKATA RECALL" THE CAR OVERHEAT, THE DASHBOARD SHOW SAFETY BELT MALFUNCTION, WHEN PUSH THE GAS PEDAL SOMETIMES JUMP, THE CAR SMELL GASOLINE ALL HE TIME, ALL THE TIME SHOW LOW LIMITS OF OIL BUT THE LEVEL OF OIL IS CORRECT.

I'VE BEEN TOLD BY TWO EUROPEAN CAR REPAIR COMPANIES THAT 2006 BMWS ARE FREQUENTLY NEEDING THE AIRBAG CONTROL MODULAR REPLACED. THERE IS AN INTERNAL ERROR ON THE AIRBAG CONTROL UNIT- CODE 93D7. THIS PART HAS NOT BEEN RECALLED, AND BECAUSE OF THE EXORBITANT PRICE, I WAS TOLD THAT MANY DRIVERS CHOOSE TO DISCONNECT THE AIRBAGS. THIS SHOULD NOT BE HAPPENING! IS BMW REPORTING THIS ISSUE? I CALLED THE CORPORATE OFFICE AND THEY SEEMED COMPLETELY UNINTERESTED AND/OR UNWILLING TO DOCUMENT MY COMPLAINT. MY VEHICLE WAS STATIONARY AT THE TIME THE WARNING WAS DISPLAYED.

TL* THE CONTACT OWNS A 2006 BMW 530I. WHILE DRIVING 40 MPH, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE AIR BAG CONTROL MODULE NEEDED REPLACEMENT. THE VEHICLE WAS REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT MENTION ANY RECALLS FOR THE AIR BAG FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

ENGINE OIL FROM THE BRAKE VACUUM PUMP MAY ENTER THE BRAKE VACUUM LINE, POSSIBLY ALLOWING OIL TO ENTER THE BRAKE BOOSTER. IF ENGINE OIL ENTERS THE BRAKE BOOSTER, IT MAY DAMAGE THE INTERNAL RUBBER MEMBRANE, CAUSING IT TO DEVELOP LEAKS AND POSSIBLY IMPAIR THE BRAKE POWER ASSISTANCE SYSTEM. THE BRAKES WILL THEN ONLY FUNCTION WITH INCREASED BRAKE PEDAL PRESSURE.

SPEEDOMETER, OTHER ELECTRONIC AND SOUND INDICATORS, AND RADIO RANDOMLY TURN OFF AND ON WHILE DRIVING. AFTER TAKING IT TO SEVERAL AUTO REPAIR SHOPS, A CORRODED COMPUTER COMPONENT UNDER THE SPARE TIRE WAS FOUND TO BE CORRODED DUE TO WATER INTRUSION. REPLACING THE PART MADE THE PROBLEM MOSTLY GO AWAY, BUT OCCASIONALLY GET ENGINE AND COOLANT PROBLEM INDICATORS.

THE IDRIVE NAVIGATION SCREEN GOES OUT AND KEEPS FLASHING. AT NIGHT IT'S A BIG DISTRACTION - AS IF A FLASHLIGHT HITS YOUR PERIPHERAL VISION INTERMITTENTLY. THERE ARE MANY WHO HAVE FACED THIS ISSUE OR ARE FACING THE SAME PROBLEM. THIS IS A MANUFACTURING DEFECT IN MY VIEW. I THINK IT'S ABOUT TIME THAT WE, AMERICANS HAVE A SHARP BITE AS FAR AS FOREIGN CAR MAKERS CREATE EXPENSIVE REPAIRS DUE TO ITS OWN FAILURES. THE MAIN ISSUE IS THAT IDRIVE CONTROL - AC - RADIO - NAVIGATION AND VERY IMPORTANTLY HEAT AND WARNING MESSAGES. WITHOUT IT WORKING YOU CAN'T KNOW WHAT'S WRONG UP TO A GREATER EXTENT. MOST OF THE CARS IMPORTANT ASPECTS ARE CONTROLLED BY THIS COMPUTER BASED SYSTEM.

MY CAR HAS BEEN LEAKING ENGINE OIL FOR ABOUT THREE MONTHS. AFTER I HAD IT CHECKED, I WAS TOLD THAT ONE BOLT ON THE ENGINE WAS BROKEN. I FOUND THAT THE SAME PROBLEM HAPPENED COMMON. I THINK BMW SHOULD SOLVE THIS PROBLEM THROUGH RECALL, BECAUSE THIS PROBLEM IS A MANUFACTURE DEFECT.

FAULT IN PASS RESTRAIN SYSTEM AFECTING AIRBAG BELT TENSIONER OR BELT FORCE LIMITER

INSULATION AROUND THE WIRING IN THE HEADLIGHTS HAS COMPLETELY CRUMBLED OFF AND BARE WIRE IS EXPOSED, COULD POSSIBLE TOUCH AND CAUSE A FIRE. PASSENGER AIR BAG SENSOR IN THE SEAT IS FAULTY AND I RECIEVED A RECALL NOTICE BUT BMW SAYS THERE IS NO RECALL ON MY CAR AND REFUSES TO FIX.

TL* THE CONTACT OWNS A 2006 BMW 530I. THE CONTACT STATED THAT WHEN THE BRAKE PEDAL WAS APPLIED, IT WAS DIFFICULT TO DEPRESS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

THE PASSENGER AIG BAG/SEAT BELT RESTRAINT ERROR AIR BACK WILL NOT DEPLOY BECAUSE IT THINKS THERE IS NO ONE IN THE PASSENGER SEAT