2014 BMW 328D

The fuel system has failed. The car shut off in the Baltimore harbor tunnel twice completely stopping traffic and creating a very hazard situation. One of those two times the semi truck behind me had to slam its brakes. When the car shuts off you must come to a complete stop and turn the car completely off. After restarting the car is in limp mode with reduced power. The incident has happened about 6 other times. Every time it happens I have feared my safety, especially if there is no shoulder to coast the car in to park. Independent service center has replaced three sensors related to fuel pressure system which did not fix. The vehicle and component has not been inspected by manufacture, police, insurance representatives or others. The manufacture claims there are no recalls on the fuel system of the vehicle. The vehicle has a rebuilt title from a small accident because no parts were available during covid so the insurance wrote the car off. The car was inspected by the state of North Carolina and deemed safe for the road. There is no indication that the car is going to shut off. It just cuts power and shuts off. After restarting the car, it will show a check engine light on the cluster and a drivetrain error on the infotainment screen . The error code p0087 Fuel/rail system Pressure - too low bank 1

Vehicle experienced sudden engine failure while driving due to timing chain failure on N47 diesel engine, a known defect. Loss of propulsion occurred without warning, creating a safety risk.

Vehicle experienced sudden engine failure while driving due to timing chain failure on N47 diesel engine, a known defect. Loss of propulsion occurred without warning, creating a safety risk.

I am reporting an emissions-related malfunction that occurred a very short time after BMW performed the EGR cooler recall and updated the DDE software on my vehicle. Shortly after the recall work, the vehicle began showing DDE fault code 2BB300 – Particulate Sensor Measuring Electrode, Self-Diagnosis, which triggered the MIL. This issue did not exist at any point before the recall. Although my vehicle is now older than 10 years, the critical concern is that this emissions-related failure appeared soon after the recall intervention, indicating a potential recall-associated defect rather than normal age-related wear. The fault was diagnosed at BMW West Houston, where it was confirmed; however, I was told no warranty or goodwill support could be provided due to vehicle age, despite the timing suggesting a recall-related cause. BMW’s emissions warranty extension bulletin (NHTSA TSB ID: MC-10160282-9999) lists particulate sensor failures (2BB700–2BA200) as known issues. Many BMW diesel owners have reported similar particulate sensor faults shortly after the EGR cooler recall and related software changes, suggesting a broader pattern. If the EGR recall or subsequent software calibration is leading to particulate sensor failures and MIL activation, this may represent a post-recall emissions defect affecting compliance. I request that NHTSA evaluate whether the EGR recall may be contributing to widespread particulate sensor failures. Vehicle Information: – 2014 BMW Diesel – Fault Code: 2BB300 – Failure occurred a short time after the EGR cooler recall & software update – Diagnosed at: BMW West Houston Thank you for your attention.

The primary failure involves the EGR cooler system covered under Recall 21V-907, with consequential damage to the intake system, including intake air leaks, charge pipe failure, displaced turbo-to-DPF V-band clamp, brittle/cracked fuel lines, and intake system integrity loss. Yes — the vehicle and all affected components are available for inspection upon request The EGR cooler internal leak defect and intake system failures create risk of engine overheating, thermal degradation, loss of engine power under boost, exhaust gas leakage, and potential fire hazard, which can cause unsafe driving conditions and sudden loss of vehicle performance The vehicle was presented to a BMW dealership, and the recall defect was acknowledged. The dealer confirmed that any decisions regarding inspection and repair must come from BMW corporate. The dealership refused to inspect or evaluate the recall-related failures pending corporate authorization. No. BMW of North America has not authorized inspection or evaluation. The dealership also refused to inspect the vehicle pending corporate direction. Yes. Symptoms included audible air leaks, intake pressure loss under boost, performance degradation, and component failures occurring both before and after recall repair attempts. These symptoms developed during the period when the vehicle was operating under a known recall-defect condition and continued after recall repair.

The primary failure involves the EGR cooler system covered under Recall 21V-907, with consequential damage to the intake system, including intake air leaks, charge pipe failure, displaced turbo-to-DPF V-band clamp, brittle/cracked fuel lines, and intake system integrity loss. Yes — the vehicle and all affected components are available for inspection upon request The EGR cooler internal leak defect and intake system failures create risk of engine overheating, thermal degradation, loss of engine power under boost, exhaust gas leakage, and potential fire hazard, which can cause unsafe driving conditions and sudden loss of vehicle performance The vehicle was presented to a BMW dealership, and the recall defect was acknowledged. The dealer confirmed that any decisions regarding inspection and repair must come from BMW corporate. The dealership refused to inspect or evaluate the recall-related failures pending corporate authorization. No. BMW of North America has not authorized inspection or evaluation. The dealership also refused to inspect the vehicle pending corporate direction. Yes. Symptoms included audible air leaks, intake pressure loss under boost, performance degradation, and component failures occurring both before and after recall repair attempts. These symptoms developed during the period when the vehicle was operating under a known recall-defect condition and continued after recall repair.

The primary failure involves the EGR cooler system covered under Recall 21V-907, with consequential damage to the intake system, including intake air leaks, charge pipe failure, displaced turbo-to-DPF V-band clamp, brittle/cracked fuel lines, and intake system integrity loss. Yes — the vehicle and all affected components are available for inspection upon request The EGR cooler internal leak defect and intake system failures create risk of engine overheating, thermal degradation, loss of engine power under boost, exhaust gas leakage, and potential fire hazard, which can cause unsafe driving conditions and sudden loss of vehicle performance The vehicle was presented to a BMW dealership, and the recall defect was acknowledged. The dealer confirmed that any decisions regarding inspection and repair must come from BMW corporate. The dealership refused to inspect or evaluate the recall-related failures pending corporate authorization. No. BMW of North America has not authorized inspection or evaluation. The dealership also refused to inspect the vehicle pending corporate direction. Yes. Symptoms included audible air leaks, intake pressure loss under boost, performance degradation, and component failures occurring both before and after recall repair attempts. These symptoms developed during the period when the vehicle was operating under a known recall-defect condition and continued after recall repair.

The contact owns a 2014 BMW 328D. The contact stated that while driving at various speeds, the vehicle entered LIMP Mode with the message "Engine Malfunction" displayed on the instrument panel. The contact used a scanner and retrieved a DTC for the high-pressure fuel pump failure. Upon investigation, the contact discovered NHTSA Campaign Number: 21V586000 (Fuel System, Diesel); and associated the failure with the recall. The manufacturer was notified of the failure, and the contact was informed that the VIN was not included in the recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 86,000.

The contact owns a 2014 BMW 328D. The contact stated while driving 55 MPH, the vehicle lost motive power. There was no warning light illuminated. The vehicle was towed to the contact’s parents’ residence. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The dealer also informed the contact that the VIN was not included in NHTSA Campaign Number: 21V586000 (Fuel System, Diesel); and referred the contact to the manufacturer for further assistance. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The approximate failure mileage was 91,000.

The contact owns a 2014 BMW 328D. The contact stated that while attempting to start the vehicle, the vehicle failed to start. No warning lights were illuminated. The vehicle was towed to the dealer, where it was diagnosed with a failed high-pressure fuel pump and assembly. The contact was informed that the high-pressure fuel pump and assembly needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 21V586000 (Fuel System, Diesel); however, the VIN was not included in the recall. The manufacturer was made aware of the failure, and a case was filed. The contact stated that the case was denied because of the age of the vehicle. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 177,010.

The contact owns a 2014 BMW 328D. The contact stated that the vehicle was taken to an unknown dealer, where the oil filter housing was replaced due to an oil leak. After the repair, the contact drove to the residence and the vehicle was not driven the following few days. The dealer called the contact to inquire updates on the vehicle after the service. The contact stated that the check engine warning light was illuminated. The vehicle was taken back to the dealer, where a diagnostic trouble code for the fuel rail sensor was retrieved. Upon inspection, the mechanic discovered metal inside the fuel system due to the high-pressure fuel pump failure. Upon investigation, the contact related the failure to NHTSA Campaign Number: 21V586000 (Fuel System, Diesel); however, the VIN was not included in the recall. The vehicle was not repaired and remained at the dealer. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 140,000.

While operating a normal speed and tempature, the low pressure fuel retuen lone burst. Fuel sprayed throughout the engine bay to include the exhaust manifold. Had this been a gasoline car a fire could have ensued.

I was driving to work when my engine started sputtering acting like it was about to turn off. I quickly pulled off to the side of the road and as soon as I did, the engine stalled and turned off. I'm lucky that I pulled off the road because if it turned off while on the road I could have caused an accident. The car is no longer able to turn on. I had to get it towed to my work where I had a mechanic look at it. They said they believe the high-pressure fuel pump failed. I researched this online and saw that there is an open NHTSA campaign for it (#21V586000). My car is a 2014 BMW 328D with the N47 engine. It seems that my car would fall under this recall but when I put in my VIN it says it does not have a match for it. How is it possible for my vehicle to be accepted into this recall.

a check engine light came on codes say it's the EGR valve and cooler dealer states since recalls are vin related there was not much they can do recall states its based by manufactured day not vin

Check engine light came on and codes suggest it's the egr valve and cooler may be leaking

The contact owns a 2014 BMW 328D. The contact stated that after parking and turning off the vehicle on the slightly inclined driveway, the contact exited the vehicle and walked to the front door of the residence. The contact then noticed that the vehicle was rolling backward. The contact stated that the vehicle rolled back onto the street and stopped independently. The contact was able to drive the vehicle back into the driveway. The contact stated that upon shifting to park(P), the failure recurred. The contact engaged the electric parking brake, and the vehicle responded as needed. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 20V185000 (Power Train); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 170,000.

The contact owns a 2014 BMW 328D. The contact stated that upon taking the vehicle to the dealer to be repaired under NHTSA Campaign Number: 21V907000 (Fuel System, Diesel). The contact stated that the dealer charged a fee for the replacement of the intake manifold. The contact declined to pay the fee and informed the dealer that the intake manifold needed to be replaced as necessary free of charge, per the recall instructions. The dealer declined to honor the recall and marked the recall as complete. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 180,000.

Due to its diesel related scandals, BMW has agreed to extend its diesel emission related components' warranty to 10 years or 120k miles. My 2014 BMW 328d's nox sensor failed in 2022 and i submitted my repair bill for replacing the nox sensor to bmw recently. BMW denied my reimbursement claiming the warranty expired despite the documents i submitted was for a repair done in 2022 with credit card receipts and repair shop copy of work done.

Faulty fuel injectors , that are known to prematurely fail. The same injectors are covered by BMW for model years 2015-2018 Under NHTSA SIB 01 09 19. My complaint is my 2014 has the same fuel injectors as the 2015-2018 that are known to be faulty and yet it is deliberately excluded from the same “limited warranty extension “

While driving our 2014 BMW 328d the engine misfired then stalled on the highway. This was a very dangerous and frightening scenario trying to push it off of the roadway while my wife and children were inside the car while highway traffic on the I-15 interstate rushes by. I was not able to restart, so we had it towed to our local BMW shop. Diagnosed as High Pressure Fuel Pump complete failure. Metallic debris throughout the entire fuel system, lines, tank filter, injectors, pumps. No check engine light or any prior warning. Many of the components have already been disassembled to determine the extent of damage, and all the components are currently with the vehicle, and available for inspection. The vehicle has been at the shop since the end of June. Some parts were initially ordered then all repairs put on hold while awaiting direction/ recall approval from BMW of North America. 5 months later we are being told this vin does not qualify for the safety recall. We can not afford the cost of the repairs and they will likely exceed the value of the car. We also need to remove it from storage at the shop it was towed to, and take it somewhere else while this is sorted out.

[XXX] - Purchase vehicle, odometer 109,803. 11/2019 - Car went into limp mode while driving on highway. Towed to BMW dealership and was advised needed new engine, at the time it only had 123,661 miles on it. Towed to EurAuto Shop for installation of replacement engine. 02/2020- The shop replaced the ceased OEM engine with a 2015 engine, with only 60,000 miles on it. EurAuto Shop tore down OEM engine and confirmed the timing chain guide broke, resulting in jumped timing and caused valve to hit piston. Total cost for engine replacement $6,641.49. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

12/2023 - Sewell BMW replaced EGR, all H/P fuel lines at injectors due to corrosion, injector harness due to heat damage to the wire jackets, cracked coolant pipe. At 145,976 that's an additional 22,315 miles on the 60,000 mile 2015 replacement engine. Total repair costs $3,939.45. 08/23/2024 - Passed inspection, odometer 149,701. 09/09/2024- Only 2 weeks later an estimate of 4,000 miles after replacing injector harness and H/P fuel lines, engine went up in flames, reason unknown. Pictures attached, vehicle was a total loss.

[XXX] - Purchase vehicle, odometer 109,803. 11/2019 - Car went into limp mode while driving on highway. Towed to BMW dealership and was advised needed new engine, at the time it only had 123,661 miles on it. Towed to EurAuto Shop for installation of replacement engine. 02/2020- The shop replaced the ceased OEM engine with a 2015 engine, with only 60,000 miles on it. EurAuto Shop tore down OEM engine and confirmed the timing chain guide broke, resulting in jumped timing and caused valve to hit piston. Total cost for engine replacement $6,641.49. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

12/2023 - Sewell BMW replaced EGR, all H/P fuel lines at injectors due to corrosion, injector harness due to heat damage to the wire jackets, cracked coolant pipe. At 145,976 that's an additional 22,315 miles on the 60,000 mile 2015 replacement engine. Total repair costs $3,939.45. 08/23/2024 - Passed inspection, odometer 149,701. 09/09/2024- Only 2 weeks later an estimate of 4,000 miles after replacing injector harness and H/P fuel lines, engine went up in flames, reason unknown. Pictures attached, vehicle was a total loss.

12/2023 - Sewell BMW replaced EGR, all H/P fuel lines at injectors due to corrosion, injector harness due to heat damage to the wire jackets, cracked coolant pipe. At 145,976 that's an additional 22,315 miles on the 60,000 mile 2015 replacement engine. Total repair costs $3,939.45. 08/23/2024 - Passed inspection, odometer 149,701. 09/09/2024- Only 2 weeks later an estimate of 4,000 miles after replacing injector harness and H/P fuel lines, engine went up in flames, reason unknown. Pictures attached, vehicle was a total loss.

[XXX] - Purchase vehicle, odometer 109,803. 11/2019 - Car went into limp mode while driving on highway. Towed to BMW dealership and was advised needed new engine, at the time it only had 123,661 miles on it. Towed to EurAuto Shop for installation of replacement engine. 02/2020- The shop replaced the ceased OEM engine with a 2015 engine, with only 60,000 miles on it. EurAuto Shop tore down OEM engine and confirmed the timing chain guide broke, resulting in jumped timing and caused valve to hit piston. Total cost for engine replacement $6,641.49. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

After a drive from Denver to Breckenridge on snowy roads the car was parked in an unplowed parking space. When the car was moved 1 hr later the car had no ABS--flashing on dash, no traction control--flashing on dash and steering was ineffective. Car was only drivable by backing into a space. 20 hrs later the car was to be moved again...again, everything flashed on dash...no ABS, no traction control, drive train failure and car just slid. Steering was totally ineffective. Car was pushed by people on both sides until dry pavement was reached. Car was restarted and I resumed driving on dry pavement back to Denver. Had car "read" by my mechanic and then again by a BMW certified mechanic. No codes were available! The speculation was that my wheel sensors froze. If my Xdrive can't be driven in snow, what's going on. There were two drivers involved in this and both of us reported a total lack of control of the vehicle.

After a drive from Denver to Breckenridge on snowy roads the car was parked in an unplowed parking space. When the car was moved 1 hr later the car had no ABS--flashing on dash, no traction control--flashing on dash and steering was ineffective. Car was only drivable by backing into a space. 20 hrs later the car was to be moved again...again, everything flashed on dash...no ABS, no traction control, drive train failure and car just slid. Steering was totally ineffective. Car was pushed by people on both sides until dry pavement was reached. Car was restarted and I resumed driving on dry pavement back to Denver. Had car "read" by my mechanic and then again by a BMW certified mechanic. No codes were available! The speculation was that my wheel sensors froze. If my Xdrive can't be driven in snow, what's going on. There were two drivers involved in this and both of us reported a total lack of control of the vehicle.

After a drive from Denver to Breckenridge on snowy roads the car was parked in an unplowed parking space. When the car was moved 1 hr later the car had no ABS--flashing on dash, no traction control--flashing on dash and steering was ineffective. Car was only drivable by backing into a space. 20 hrs later the car was to be moved again...again, everything flashed on dash...no ABS, no traction control, drive train failure and car just slid. Steering was totally ineffective. Car was pushed by people on both sides until dry pavement was reached. Car was restarted and I resumed driving on dry pavement back to Denver. Had car "read" by my mechanic and then again by a BMW certified mechanic. No codes were available! The speculation was that my wheel sensors froze. If my Xdrive can't be driven in snow, what's going on. There were two drivers involved in this and both of us reported a total lack of control of the vehicle.

While driving my 328 XDrive, I went to make a left turn and hear a loud bang like I ran over a boulder or large object. Lost almost all power to the wheels and had to cost the car into a gas station. After which I had the car towed to BMW and was determined to be a failed transfer case at 123k on the OD. This seems to be happening to the older BMWs with the old transfer case. BMW knows this as they have since upgraded the transfer case and no longer sell the old one. This should without question be a recall for any 328d XDrive from this era.

The contact owns a 2014 BMW 328D. The contact stated that there was oil leaking near the front driver's side tire. While driving at various speeds there was a cloud of smoke and burning odor coming from the area of the leaking. The smoke dissipated while the vehicle was idling. The vehicle was jerking from the front driver’s side wheel. The vehicle was taken to an independent mechanic where it was diagnosed that the CV Joint needed to be replaced. The brakes had been replaced; however, the CV Joint had not been replaced. The mechanic informed the contact that the failure was related to NHTSA Campaign Number: 20V185000 (Power Train). The manufacturer was made aware of the failure, and it was confirmed that the VIN was not included in the recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 133,000.

The contact owns a 2014 BMW 328D. The contact stated while driving at an undisclosed speed, the vehicle made an abnormal sound, and an unknown warning light illuminated. The contact stated that the vehicle was able to be restarted but the contact had the vehicle towed to a dealer. The vehicle was towed to a dealer to be diagnosed. The contact was informed that there were metal shavings in the fuel pump. The contact was informed that the fuel pump needed to be replaced. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 52,000.

The driver side door lock mechanism failed completely while the driver was in the vehicle, making it impossible to open the driver side door or exit the vehicle normally. Neither the interior door handle, nor the central power lock/unlock control, nor the remote key fob, nor the physical key inserted into the door lock from the outside can unlock the door. The driver was forced to exit the vehicle by moving the driver seat to an extreme aft position, then climbing over the center console into the passenger seat, to exit via the passenger door. If the power seat adjustment had been inoperable, egress would have bee significantly more difficult. If the driver had been involved in a collision, or otherwise needed to exit the vehicle very quickly, they would have been severely hindered from doing so. Inability to operate the driver side door represents a safety hazard to the driver. No warning messages or lamps were present in the vehicle before or after the door lock mechanism failure. The driver side door remains inoperable after completely switching off the vehicle ignition and turning it back on.

The driver side door lock mechanism failed completely while the driver was in the vehicle, making it impossible to open the driver side door or exit the vehicle normally. Neither the interior door handle, nor the central power lock/unlock control, nor the remote key fob, nor the physical key inserted into the door lock from the outside can unlock the door. The driver was forced to exit the vehicle by moving the driver seat to an extreme aft position, then climbing over the center console into the passenger seat, to exit via the passenger door. If the power seat adjustment had been inoperable, egress would have bee significantly more difficult. If the driver had been involved in a collision, or otherwise needed to exit the vehicle very quickly, they would have been severely hindered from doing so. Inability to operate the driver side door represents a safety hazard to the driver. No warning messages or lamps were present in the vehicle before or after the door lock mechanism failure. The driver side door remains inoperable after completely switching off the vehicle ignition and turning it back on.

The contact owns a 2014 BMW 328D. The contact stated that while driving approximately 70–75 MPH, the vehicle shuddered and then lost motive power. An unknown message was displayed. The contact pulled over to the shoulder, and the vehicle failed to restart. The vehicle was towed to the dealer, where it was diagnosed that the high-pressure fuel pump needed to be replaced due to metal shavings in the fuel injectors. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V586000 (Fuel System, Diesel); however, the VIN was not included in the recall. The manufacturer was made aware of the failure. The failure mileage was 108,859.

There was a recall to replace EGR cooler on this car. Dealer replaced with same defective design EGR cooler. BMW is not putting any effort in redesigning EGR cooler and install that one in customer's cars. We are again risking our lives with new but defective design EGR cooler.

High pressure fuel pump failed while underway causing vehicle to immediately stall in traffic and lock in "Park" making it unable to move. Mechanic (Werner's European Auto) confirmed diagnosis of catastrophic failure of the pump. Part is available for inspection. This part for the gasoline version of the 2014 328 series car is subject to a recall notice but for some reason the notice does not apply to the diesel version of this model. Repair cost is estimated at $11,000 to replace entire fuel system due to metal particles released when the pump broke

Subject: Urgent Complaint Regarding Potential Safety Hazard in 2014 BMW 328D Fuel Injector I am writing to report a serious safety concern regarding my 2014 BMW 328D. On about August of 2023, while operating my vehicle, I experienced a sudden and alarming issue that poses a significant risk to both myself and other motorists. As I came to a routine stop, smoke began pouring out from under the hood of the vehicle, obscuring my vision through the windshield. Simultaneously, a strong odor of diesel permeated the interior of the passenger compartment. Concerned for my safety, I immediately investigated and discovered that the fuel injector area was drenched with diesel fuel. Upon further inspection by a qualified mechanic, it was determined that a crack had developed in the fuel injector, causing the leak. This defect not only poses a serious fire hazard but also exposes occupants to toxic diesel fumes, creating an immediate and grave risk to safety. My concern is exacerbated by the fact that this incident appears to be part of a larger pattern of failures in BMW diesel automobiles. I have conducted research and found numerous recalls related to faulty fuel injectors in various BMW models over different years. However, to my astonishment, the 2014 BMW 328D, including mine, has not been included in any such recall despite the clear evidence of a recurring issue with fuel injectors. Given the severity of the situation and the potential danger it poses to myself and others on the road, I urge the National Highway Traffic Safety Administration (NHTSA) to thoroughly investigate this matter. It is imperative that immediate action be taken to address this safety hazard, including the consideration of a recall for the affected vehicles. I kindly request a prompt response regarding the steps being taken to address this issue and ensure the safety of all BMW 328D owners.

stall/loss of power while entering highway on ramp. Engine died and would not restart. After inspecting car found the gas tank to be filled with metal shavings which is indicative of a failed high pressure fuel pump. My year make and model vehicle has a recall on the HPFP for the same reason but my VIN was supposedly not affected.

stall/loss of power while entering highway on ramp. Engine died and would not restart. After inspecting car found the gas tank to be filled with metal shavings which is indicative of a failed high pressure fuel pump. My year make and model vehicle has a recall on the HPFP for the same reason but my VIN was supposedly not affected.

Have been waiting since March to get Safety Recall No. 21V-907:EGR Cooler completed. BMW of Henderson is the dealership. I called BMW customer relations and they told me each dealer is independently owned and they can’t do anything for me. This dealership is notorious for poor service.

Driving vehicle home from work and it completely lost power and died. ""Drivetrain Malfunction" error popped up on the screen. Vehicle would crank but not start. Towed to repair shop. High Pressure Fuel Pump issue is on the radar for 2014 BMW 328D, BMW has recalled less than 12000 cars. My vehicle is not currently on the recall list.

The contact owns a 2014 BMW 328D. The contact stated while driving at an undisclosed speed, there was exhaust fumes inside the cabin of the vehicle. The vehicle was taken to the dealer, where the engine was flushed; however, the failure recurred. The contact related the failure to NHTSA Campaign Number: 21V907000 (Fuel System, Diesel). The manufacturer was not made aware of the failure. The failure mileage was approximately 121,000.

The contact owns a 2014 BMW 328D. The contact stated while driving at an undisclosed speed, there was exhaust fumes inside the cabin of the vehicle. The vehicle was taken to the dealer, where the engine was flushed; however, the failure recurred. The contact related the failure to NHTSA Campaign Number: 21V907000 (Fuel System, Diesel). The manufacturer was not made aware of the failure. The failure mileage was approximately 121,000.

While driving on the freeway at a high rate of speed in Pensacola, FL, my 2014 BMW 328d broke down. After several attempts to restart, the car was started in "limp mode" and we took it to a certified independent BMW mechanic, but could only drive at about 20mph in traffic with hazard lights flashing. Multiple error codes / mechanic inspection diagnosed a malfunction of the exhaust system overheating, which was melting the intake manifold. We towed the car the BMW dealership in Fort Walton Beach, FL. The service technician confirmed the problem in writing, "The tech did find the intake melted." Also, the vehicle had been losing coolant for several weeks, but the coolant was not dripping onto the ground, indicating a leak within the system. Here is where my problems begin. There are several recalls and an extended warranty that would would fix the issue, as the independent mechanic told me. They are: 1) Recall Campaign 18V-755: Exhaust Gas Recirculation (EGR) Cooler Inspection; 2) Recall 21V-907: Exhaust Gas Recirculation (EGR) Cooler N57T High Temperature; 3) SIB 01 05 20: N47T/N57T EGR Cooler Ltd Wty Extension to 10 years without mileage limit. My car was built to US spec, and sold via U.S. Military sales in Germany (I'm Active Duty USAF). I was relocated to Florida, and brought the car with me. When this happened, I was told to register my car with BMW North America to get into their warranty validation system, and I did so. However, my car does not show up as needing any recalls or warranty work, likely because it was sold in Europe. As such, the dealer wants me to pay in excess of $3,000 to fix the problem. Both an independent mechanic and dealer technician have identified the previously-known safety problems as the cause of my car's breakdown on the freeway. I am in desperate need of help to get this fixed, as I've had to rent a car for weeks, and multiple calls to BMW North America and dealership visits have produced zero progress.

DEF SCR Active Tank Fluid Level sensor fails. BMW requires entire replacement of the Active Tank for $1200 parts + $1500 for labor. This is a ridiculous repair since Volkswagen sells a repair kit for the Active Tank fluid sensor for just ~$300 in their diesel. Given the high failure rates of the Active Tank fluid sensor present throughout BMW diesel line-up in the USA, BMW should instead provide a repair kit to avoid such an expensive repair. The 335d and X5d had such high failure rates of the active tanks, that the extended warranties were provided to owners 120K/10years.

The contact owns a 2014 BMW 328D. The contact stated that on several occasions while driving at various speeds, the vehicle stalled and lost motive power. The vehicle failed to restart. The vehicle was towed to a local dealer, where it was diagnosed that the high-pressure fuel pump needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to a local dealer, where it was diagnosed that the high-pressure fuel pump needed to be replaced again. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer to be serviced under NHTSA Campaign Number: 21V907000 (Fuel System, Diesel). The vehicle was repaired; however, the contact stated that the failure reoccurred while driving at an undisclosed speed, and the check engine warning light was illuminated. The vehicle was taken back to the dealer, where it was diagnosed that further inspection of the high-pressure fuel pump was required. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 92,000.

The contact owns a 2014 BMW 328D. The contact stated that on several occasions while driving at various speeds, the vehicle stalled and lost motive power. The vehicle failed to restart. The vehicle was towed to a local dealer, where it was diagnosed that the high-pressure fuel pump needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to a local dealer, where it was diagnosed that the high-pressure fuel pump needed to be replaced again. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer to be serviced under NHTSA Campaign Number: 21V907000 (Fuel System, Diesel). The vehicle was repaired; however, the contact stated that the failure reoccurred while driving at an undisclosed speed, and the check engine warning light was illuminated. The vehicle was taken back to the dealer, where it was diagnosed that further inspection of the high-pressure fuel pump was required. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 92,000.

I recently got the EGR cooler replaced as part of the recall campaign safety issue, after my repair, a very strong smell of fuel and exhaust was coming into my car cabin, when I reported to BMW they said it should burn off - that it wasn’t an issue. I took it a master technician to diagnose and inspect my car and he found that the turbo waster gate was leaking caused by all of the buildup of carbon and soot from a faulty EGR cooler. I brought this up to the dealership, and they said unfortunately this problem is not covered. I’m escalating this issue because this is a majority safety and health risk, and BMW is not taking responsibility to fix the problem.

From purchasing this vehicle form Autohaus of Orlando, there was no such mention of this open safety recall at all. In fact, I believe the Check Engine Light had been tampered with, as it was not on, but immediately came on a couple days later. On the CARFAX, it is listed as a Manufacturer Safety Recall on 11/19/2021: "- Recall #21V-907:404 - EXHAUST GAS RECIRCULATION (EGR) COOLER - Status: Remedy Not Available - Need more information about this recall? Find an authorized BMW dealer, email [email protected], or call 1-800- 525-7417" 200 miles from the car dealership, the car broke down as it was rapidly leaking engine coolant, it was inoperable and ran very hot, creating the potential cause of a fire. I had to take it to the nearest BMW dealership, which was BMW of Albany in Albany, GA. They fixed the coolant leak hose, which appears to be related to the open recall, and made note of the open recall. But did nothing to fix it. It was one day after the service from their shop where the check engine light came on, and I asked them about it, and Caroline from BMW Albany said: "Spoke to the technician, it says it is probably related to the recall for your vehicle that there isn't a fix for (the open recall you and I had discussed on the vehicle)- he says you could clear the code but it would probably just come back on with time. He says its also difficult to tell from that fault code --Caroline Eva BMW of Albany" I asked "what should I do about it" and got no response back. Message even says "read" On 8/31/2022, I took it into Fields BMW in Daytona Beach, FL for a separate service, and they did not fix this issue either. On NHTSA.gov, it states the following: "If the manufacturer has failed or is unable to remedy this safety recall for your vehicle in a timely manner, please contact the NHTSA Vehicle Safety Hotline at: 1-888-327-4236 or TTY: 1-800-424-9153 or file an online complaint with NHTSA." There has been no remedy in over a year and a half.