Technical Service Bulletins
Search 172,063 manufacturer communications covering 879 vehicle makes from 1955 to 2025.
Showing 1,090 bulletins for HINO
LT-0006
Jun 6, 2006
092300 FUEL SYSTEM, OTHER:FUEL FILTER
HINO genuine oil filter replacement is recommended at 6000-20000 miles depending on duty cycle and type of oil used
167-R0601-12
May 31, 2006
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
C0004 This Service Campaign involves the replacement of the snap-ring and the installation of the grommet located on the transmission oil-cooler inlet and outlet lines.
06-002
Apr 1, 2006
030000 BRAKES (PWS)
No throttle response. Once a burnt out tail lamp filament touches a stop lamp filament, the current goes thru the stop lamp circuit causing the ECU to think that the brakes are applied. Therefore stopping acceleration control.
167-T0610-12
Apr 1, 2006
110000 ELECTRICAL SYSTEM
06 - 002 No Throttle Response. Once a burnt out tail lamp filament touches a stop lamp filament, the current goes thru the stop lamp circuit causing the ECU to think that the brakes are applied. Therefore stopping acceleration control.
06-001
Jan 12, 2006
091100 FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY
RUNNING OUT OF FUEL, DUAL TANKS NOT EQUALIZING
167-T0601-12
Jan 12, 2006
090000 FUEL SYSTEM, OTHER
06-001 RUNNING OUT OF FUEL, DUAL TANKS NOT EQUALIZING
05-011
Nov 20, 2005
060000 ENGINE AND ENGINE COOLING
This document is to inform dealers and workshops of the correction to Workshop Manuals for J08 engines listed below.
167-B0501-12
Nov 20, 2005
060000 ENGINE (PWS)
05 - 011 CORRECTIONS TO WORKSHOP MANUALS FOR J08 ENGINES. The standard gap between ends of the second piston ring and the oil ring.
167-B0503-12
Nov 4, 2005
060000 ENGINE (PWS)
SB ? 05 - 010 CORRECTION TO WORKSHOP MANUALS FOR THE J08E ENGINE. a) Resistance between terminals of the air intake pre-heater relay should be 64.0 ? 96.0 Ohms b) Illustration of the air intake pre-heater terminal should be revised. c) R
167-B0505-12
Nov 4, 2005
356000 EQUIPMENT ADAPTIVE/MOBILITY
SB ? 05 - 007 DESIGN CHANGE OF WATER PIPE FOR J08E
167-B0506-12
Nov 4, 2005
060000 ENGINE (PWS)
SB ? 05 - 008 This document is to inform the dealers about the addition of the pressure sensor cover and related part for the J08E engine.
167-B0507-12
Nov 4, 2005
062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
SB ? 05 - 009 This document is to inform dealers of the design change to the upper radiator tank and related parts.
SB 05-010
Nov 4, 2005
060000 ENGINE (PWS)
This document is to inform dealers of the correction to Worshop Manuals for the J08E engines.
SB-05-007
Nov 4, 2005
061550 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:PIPES, HOSES, AND FITTINGS
This document is to inform dealers of the design change on the water pipe for the J08E engine models listed below.
SB-05-008
Nov 4, 2005
060000 ENGINE (PWS)
This document is to inform the dealers about the addition of the pressure sensor cover and related part for the J08E engine.
167-T0501-12
Oct 25, 2005
073100 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL
05-001 LOW POWER COMPLAINT All 2005 & 2006 Hino Trucks with common rail fuel injection
167-B0508-12
Sep 28, 2005
106000 POWER TRAIN:AXLE ASSEMBLY
SB - 05 - 005 PROPER MAINTENANCE PROCEDURES FOR GREASE LUBRICATED FRONT AXLES
167-B0509-12
Sep 28, 2005
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
SB ? 05 - 006 Upon removal of a transmission assembly from the vehicle, inspection is required to confirm the presence and correct installation of the two dowel pins in the rear engine housing. In some rare cases one or both dowel pins may
SB 05-004
Sep 28, 2005
110000 ELECTRICAL SYSTEM
This document is to inform of the procedure to calibrate the Pulse Adjust Module when needed (ex. tire size change, rear carrier ratio change) .