Vehicle Safety Recalls
Search 29,884 NHTSA recall campaigns covering every vehicle sold in the United States since 1966.
Showing 442 recalls for TOYOTA
12V542000
Nov 23, 2012
Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Penns...
Consequence: Corrosion of the plate could cause it to break, which could result in detachment of the spare tire from the vehicle. Detachment of the spare tire could result in a road hazard which may increase the risk of a vehicle crash.
Remedy: Toyota will notify owners, dealers will inspect the vehicle and replace the spare tire carrier lift plate as necessary, free of charge. The recall began in February 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V536000
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12E046000
Oct 17, 2012
TOYOTA
FJ CRUISER
(2007) —
EQUIPMENT
Toyota is recalling certain Toyota Racing Development (TRD) brake kits, P/N PTR09-35070, and TRD High-Performance brake kits, P/N PTR09-35100, installed by Toyota vehicle processing centers and sold by Toyota dealers as an optional accessory for model year 2007 through 2012 Toyota FJ Cruiser vehicles. The subject TRD brake kit is specifically designed for the front wheels of 2007-2012 model year ...
Consequence: If a brake tube becomes damaged and leaks fluid, it may result in increased stopping distances, and in some cases, loss of vehicle front braking performance, which could increase the risk of a crash.
Remedy: All known owners of 2007-2012 model year FJ Cruiser vehicles will be notified by first class mail. If the vehicle is equipped with one of the TRD brake kits, the brake caliper outer brake tube will be replaced with a newly designed one at no charge. During this service, if necessary, the dealer wi...
12V491000
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this...
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their T...
12V373000
Aug 2, 2012
Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear ti...
Consequence: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota ...
12V305000
Jun 29, 2012
TOYOTA
LAND CRUISER
(2008) —
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Toyota is recalling certain model year 2010 Lexus RX350 and RX450h vehicles, manufactured from November 28, 2008, through September 1, 2010, and model year 2008 through 2011 Toyota Land Cruiser vehicles manufactured from September 1, 2007, through September 5, 2011. In July 2012, Toyota filed a defect report to recall certain model year 2010 Lexus RX350 and RX450h vehicles. In November 2012, Toy...
Consequence: A stuck open accelerator pedal may result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death.
Remedy: Toyota and Lexus will notify owners of affected vehicles and dealers will modify or replace the accelerator pedal and replace any driver's floor mat not specified for the vehicle. Owners of the Lexus vehicles were notified during August 2012. Toyota has not yet provided a notification schedule for...
12V158000
Apr 10, 2012
GULF STATES TOYOTA (GST) IS RECALLING CERTAIN MODEL YEAR 2012 TACOMA TRUCKS. THE TIRE AND LOADING INFORMATION PLACARD ON EACH VEHICLE CONTAINS INACCURATE SPARE TIRE SIZE AND COLD INFLATION PRESSURE INFORMATION. THUS, THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110,TIRE SELECTION AND RIMS.
Consequence: AN INCORRECT PLACARD COULD LEAD TO IMPROPER SPARE TIRE USE OR REPLACEMENT WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: GST WILL NOTIFY OWNERS, AND SEND EACH OWNER A CORRECTED PLACARD, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 5, 2012. OWNERS MAY CONTACT GULF STATES TOYOTA, INC. AT 1-713-744-3465.
12V120000
Mar 23, 2012
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2012 4RUNNER AND SIENNA VEHICLES, EQUIPPED WITH NON-ORIGINAL EQUIPMENT REMOTE ENGINE STARTERS. A MALFUNCTION IN THE AUDIOVOX ELECTRONICS BRAND REMOTE ENGINE STARTER MODULE CAN PREVENT NORMAL COMMUNICATION OF THE VEHICLES CONTROLLER AREA NETWORK (CAN).
Consequence: IF THIS CONDITION OCCURS, ANTILOCK BRAKING AND STABILITY CONTROL MAY BE LOST, INCREASING THE RISK OF A CRASH. DRIVERS SHOULD RECEIVE DASHBOARD WARNING LIGHTS WARNING THEM OF A MALFUNCTION.
Remedy: GULF STATES TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE REMOTE ENGINE STARTER WITH A NEW ONE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JUNE 4, 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-444-1074.
12V091000
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2009 CAMRY VEHICLES MANUFACTURED FROM JULY 1, 2008, THROUGH FEBRUARY 28, 2009, AND MODEL YEAR 2009-2011 VENZA VEHICLES MANUFACTURED FROM OCTOBER 20, 2008, THROUGH JANUARY 4, 2011. DURING ASSEMBLY OF THE CONTACT-TYPE STOP LAMP SWITCH, SILICONE GREASE MAY HAVE COME IN CONTACT WITH THE SURFACE OF THE SWITCH WHICH COULD CAUSE CONTACT RESISTANCE. IF THIS OCCURS,...
Consequence: INOPERATIVE BRAKE LIGHTS WOULD NOT WARN OTHER DRIVERS THAT THE VEHICLE IS SLOWING OR STOPPING, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE STOP LAMP SWITCH, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 12, 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
12V092000
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
12V029000
Feb 1, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 RAV4 VEHICLES, MANUFACTURED FROM NOVEMBER 24, 2011, THROUGH DECEMBER 19, 2011. IN THE CURTAIN SHIELD AIRBAGS, PROPELLANT WITH THE INCORRECT SPECIFICATION WAS USED FOR THE INITIATOR ASSEMBLED IN THE AIRBAG INFLATOR. IN THIS CONDITION, THE INFLATOR MAY NOT PERFORM PROPERLY, CAUSING ONE OR BOTH CURTAIN SHIELD AIRBAGS TO NOT DEPLOY.
Consequence: IN THE EVENT OF A CRASH, THE AIRBAGS MAY NOT DEPLOY AND WILL NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE VEHICLE IDENTIFICATION NUMBER TO IDENTIFY THE CURTAIN SHIELD ASSEMBLIES AND REPLACE THE ASSEMBLIES AS NECESSARY WITH NEW ONES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 8, 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
11V588000
Dec 14, 2011
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 TUNDRA VEHICLES THAT HAVE AN INACCURATE LOAD CARRYING CAPACITY LABEL. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, TIRE SELECTION AND RIMS.
Consequence: AN INACCURATE LABEL COULD LEAD TO VEHICLE OVERLOADING WHICH COULD RESULT IN TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: GULF STATES TOYOTA WILL NOTIFY OWNERS AND WILL PROVIDE A CORRECTED LABEL FREE OF CHARGE. THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 24, 2012. OWNERS MAY CONTACT GULF STATE TOYOTA AT 1-800-444-1074.
11V560000
Nov 30, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 THROUGH 2012 SIENNA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 110, "TIRE SELECTIONS AND RIMS." THESE VEHICLES DO NOT MEET THE REQUIREMENT FOR DISPLAYING THE CORRECT VEHICLE CAPACITY WEIGHT AS THE RATED LOAD FOR THE COMBINATION OF CARGO AND OCCUPANTS.
Consequence: INCORRECT INFORMATION ON THE VEHICLE PLACARD MAY LEAD TO TIRE OVERLOADING AND POSSIBLY CAUSE TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND WILL PROVIDE A REMEDY WHEN IT IS AVAILABLE. TOYOTA WILL MAIL OUT A CORRECTED PLACARD TO CUSTOMERS ALONG WITH REVISED OWNER MANUAL INFORMATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 27, 2013. OWNERS MAY CONTACT TOYOTA AT 1-80...
11V566000
Nov 22, 2011
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010-2011 COROLLA VEHICLES EQUIPPED WITH A NON-TOYOTA, BLUE TOOTH HANDS FREE DEVICE OR NAVIGATION UNIT AND CERTAIN MODEL YEAR 2011 TOYOTA SIENNA VEHICLES EQUIPPED WITH A NON-TOYOTA, OVERHEAD ENTERTAINMENT SYSTEM AND/OR BLUETOOTH HANDS FREE DEVICE. THERE IS A POSSIBILITY THAT THE FRONT A-PILLAR TRIM PANEL RETENTION CLIP MAY HAVE BEEN DAMAGED DURING...
Consequence: A DAMAGED A-PILLAR TRIM PANEL RETENTION CLIP MAY ALLOW THE TRIM PANEL TO COME LOOSE AND INJURE AN OCCUPANT IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE A-PILLAR TRIM PANEL RETENTION CLIP AND REPLACE IT IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 30, 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
11V539000
Nov 9, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RU...
Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1...
11V342000
Jun 29, 2011
TOYOTA
HIGHLANDER HYBRID
(2006) —
ELECTRICAL SYSTEM
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006-2007 HIGHLANDER HYBRID AND LEXUS RX400H PASSENGER CARS MANUFACTURED FROM FEBRUARY 16, 2005, THROUGH AUGUST 30, 2006. A MODULE INSIDE THE INVERTER MODULE MAY CONTAIN INADEQUATELY SOLDERED TRANSISTORS THAT DURING HIGH-LOAD DRIVING, MAY BE DAMAGED BY HEAT CAUSED BY THE LARGE CURRENT. IF THIS OCCURS, VARIOUS WARNING LAMPS, INCLUDING THE MALFUNCTION INDICATO...
Consequence: THE VEHICLE MAY ENTER A FAIL-SAFE/LIMP-HOME MODE THAT LIMITS THE DRIVABILITY OF THE VEHICLE. IT IS POSSIBLE THAT THE HYBRID SYSTEM WILL SHUT DOWN WHILE THE VEHICLE IS BEING DRIVEN, CAUSING THE VEHICLE TO STALL UNEXPECTEDLY, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA/LEXUS MAILED AN INTERIM OWNER NOTIFICATION ON JULY 19, 2011 TO ADVISE OWNERS OF THIS RECALL AND THE FACT THAT THEY WILL RECEIVE A FUTURE NOTICE WHEN PARTS BECOME AVAILABLE TO COMPLETE REPAIRS. TOYOTA DEALERS WILL INSPECT THE HYBRID INVERTER PRODUCTION NUMBER TO DETERMINE WHETHER THE INVERTER...
11V304000
Jun 1, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2001 THROUGH 2003 PRIUS PASSENGER CARS MANUFACTURED FROM JANUARY 28, 2000, THROUGH MAY 30, 2003. THE STEERING LINKAGE MAY LOOSEN, RESULTING IN REDUCED ELECTRIC STEERING ASSISTANCE WHEN MAKING A LEFT TURN.
Consequence: LOSS OF POWER STEERING, PARTICULARLY WHEN AN OPERATOR IS ACTIVELY INTENDING TO STEER THE VEHICLE, MAY INCREASE THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE NUTS IN THE STEERING LINKAGE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 8, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
11V306000
Jun 1, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 VENZA AND SIENNA PASSENGER CARS MANUFACTURED FROM MARCH 7, THROUGH MARCH 10, 2011. THERE IS A POSSIBILITY THAT THE FRONT, RIGHT, DRIVE SHAFT MAY BREAK DUE TO INSUFFICIENT HEAT TREATMENT.
Consequence: SHOULD THE DRIVE SHAFT BREAK DURING VEHICLE OPERATION, THE VEHICLE WILL LOSE POWER WITHOUT PRIOR WARNING. LOSS OF MOTIVE POWER WITHOUT WARNING MAY INCREASE THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE DRIVE SHAFT, AND, IF THE DRIVE SHAFT IS IDENTIFIED AS ONE THAT MAY NOT HAVE BEEN CORRECTLY MANUFACTURED, IT WILL BE REPLACED WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL BEGAN ON JUNE 22, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
11V278000
May 12, 2011
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2007-2011 TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEMS." THE TPMS ON SOME VEHICLES MAY NOT HAVE BEEN PROPERLY CALIBRATED AND AS A RESULT THE LOW TIRE PRESSURE WARNING LAMP MAY NOT ILLUMINATE SHOULD THE INFLATION PRESSURE IN ONE OR MORE OF THE VEHICLE'...
Consequence: DRIVERS WILL NOT RECEIVE A WARNING FROM THE TIRE PRESSURE MONITOR THAT ONE OR MORE TIRES ARE UNDERINFLATED, INCREASING THE RISK THAT THE VEHICLE WILL BE DRIVEN WITH ONE OR MORE UNDERINFLATED TIRES, INCREASING THE RISK OF A TIRE FAILURE THAT MAY LEAD TO A CRASH.
Remedy: DEALERS WILL RECALIBRATE THE TIRE PRESSURE MONITORING SYSTEM IN ACCORDANCE WITH THE REGULATION FREE OF CHARGE. THE SAFETY RECALL BEGAN DURING JULY 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA CUSTOMER ASSISTANCE CENTER TOLL FREE AT 1-800-301-6859, MONDAY THROUGH FRIDAY, 8:30 AM TO 5:00 PM, EASTERN ST...
11V254000
Apr 26, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 TUNDRA VEHICLES EQUIPPED WITH A 3-JOINT TYPE PROPELLER SHAFT. DUE TO IMPROPER CASTING OF THE SLIP YOKES, THERE IS A POSSIBILITY THAT THE SLIP YOKE MAY BREAK, CAUSING THE PROPELLER SHAFT TO SEPARATE AT THE JOINT AND COME INTO CONTACT WITH THE ROAD SURFACE.
Consequence: THE DRIVER COULD EXPERIENCE LOSS OF MOTIVE POWER AND VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND INSPECT THE PROPELLER SHAFT AND, IF NECESSARY, REPLACE IT FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
11V245000
Apr 21, 2011
TOYOTA
HIGHLANDER
(2007) —
AIR BAGS
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SY...
Consequence: INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
Remedy: TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331...
11V185000
Mar 16, 2011
TOYOTA
FJ CRUISER
(2009) —
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 FJ CRUISER AND MODEL YEAR 2009-2011 TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEMS." THE TPMS ON SOME VEHICLES MAY NOT HAVE BEEN PROPERLY CALIBRATED AND AS A RESULT THE LOW TIRE PRESSURE WARNING LAMP MAY NOT ILLUMINATE SHOULD THE INFLATION PRESSUR...
Consequence: DRIVERS WILL NOT RECEIVE A WARNING FROM THE TIRE PRESSURING MONITOR THAT ONE OR MORE TIRES ARE UNDERINFLATED INCREASING THE RISK THAT A VEHICLE WILL BE DRIVEN WITH ONE OR MORE UNDERINFLATED TIRES AND INCREASING THE RISK OF A TIRE FAILURE THAT MAY LEAD TO A CRASH.
Remedy: DEALERS WILL RECALIBRATE THE TIRE PRESSURE MONITORING SYSTEM IN ACCORDANCE WITH THE REGULATION FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT GULF STATE TOYOTA CUSTOMER ASSISTANCE CENTER TOLL FREE AT 1-800-444-1074 MONDAY THROUGH THURSDAY, 8:30 AM TO 5:...
11V148000
Mar 4, 2011
TOYOTA
FJ CRUISER
(2008) —
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FJ CRUISER, LAND CRUISER, TACOMA, SEQUOIA AND TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." WHEN FACTORY-INSTALLED WHEELS AND TIRES WERE REPLACED WITH TOYOTA AUTHORIZED ACCESSORY WHEELS AND LT TIRES PRIOR TO FIRST SALE, THE TIRE PRESSU...
Consequence: FAILURE TO WARN OF TIRE DEFLATIONS IS A NON-COMPLIANCE WITH FMVSS 138 AND COULD LEAD TO TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: FOR THE LAND CRUISER, SEQUOIA, TACOMA AND TUNDRA VEHICLES, THE DEALER WILL RE-CALIBRATE THE TIRE PRESSURE MONITORING SYSTEM ON AFFECTED VEHICLES AND INSTALL AN UPDATED TIRE AND LOADING INFORMATION LABEL AT NO CHARGE. FOR THE FJ CRUISER VEHICLES, THE TPMS CANNOT BE RESET SO THE ELECTRONIC CONTROL UN...
11V112000
Feb 24, 2011
TOYOTA
HIGHLANDER
(2004) —
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
11V113000
Feb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
10V620000
Dec 13, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 SIENNA VEHICLES. THE BRAKE STOP LAMP SWITCH IS MOUNTED ON A SMALL BRACKET WELDED ON THE LEFT SIDE OF THE SERVICE BRAKE PEDAL SUPPORT ASSEMBLY. DUE TO ITS PROXIMITY TO THE PARKING BRAKE PEDAL, IN LIMITED CIRCUMSTANCES THE STOP LAMP SWITCH BRACKET COULD BE DAMAGED BY THE OPERATOR'S FOOT DURING PARKING BRAKE APPLICATION.
Consequence: THIS COULD RESULT IN BRAKE DRAG WITH ASSOCIATED BRAKE NOISE, VIBRATION, AND/OR ILLUMINATION OF THE BRAKE WARNING LIGHT. BRAKING EFFECTIVENESS COULD BE REDUCED INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BRACKET ASSEMBLY FREE OF CHARGE. TOYOTA PLANS TO MAIL AN INTERIM OWNER NOTIFICATION IN THE MIDDLE OF JANUARY 2011, TO ADVISE OWNERS OF THE RECALL. A SECOND LETTER WILL BE MAILED WHEN PARTS ARE AVAILABLE TO COMPLETE REPAIRS. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
10V499000
Oct 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER ...
Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
10E043000
Sep 3, 2010
TOYOTA
FJ CRUISER
(2008) —
EQUIPMENT
MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE SEAT COVERS ARE MADE OF HEAVIER THREAD AND ARE NOT COMPATIBLE WITH SEATS CONTAINING SIDE AIRBAGS. THE HEAVIER SEAT COVER COULD INTERFERE WITH FULL DEPLOYMENT OF THE AIRBAG IN THE EVENT...
Consequence: AN IMPROPERLY DEPLOYED AIRBAG COULD RESULT IN SERIOUS INJURY.
Remedy: MARATHON WILL NOTIFY OWNERS OF RECORD AND REPLACE THE SEAT COVER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 14, 2010. OWNERS MAY CONTACT MARATHON AT 1-800-735-2769.
10V384000
Aug 26, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2008 COROLLA AND COROLLA MATRIX VEHICLES. THE ENGINE CONTROL MODULE (ECM) FOR THE SUBJECT MODELS EQUIPPED WITH THE 1ZZ-FE ENGINE AND TWO-WHEEL DRIVE MAY HAVE BEEN IMPROPERLY MANUFACTURED. THERE IS A POSSIBILITY THAT A CRACK MAY DEVELOP AT CERTAIN SOLDER POINTS OR ON VARISTORS ON THE CIRCUIT BOARD.
Consequence: THERE ARE A VARIETY OF WARNINGS AND CONSEQUENCES ASSOCIATED WITH THE DEFECT. THE ENGINE WARNING LAMP COULD BE ILLUMINATED, HARSH SHIFTING COULD RESULT, THE ENGINE MAY NOT START, OR THE ENGINE COULD SHUT OFF WHILE THE VEHICLE IS BEING DRIVEN. AN ENGINE SHUTOFF WHILE THE VEHICLE IS BEING DRIVEN INCR...
Remedy: DEALERS WILL INSPECT THE PRODUCTION NUMBER OF THE ECM AND REPLACE THE ECM IF NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. TOYOTA WILL MAIL AN INTERIM OWNER NOTIFICATION THE MIDDLE OF SEPTEMBER 2010 TO ADVISE OWNERS OF THIS DEFECT AND RECALL. THIS INTERIM NOTIFICATION WILL INFORM OWNE...
10V345000
Jul 29, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2000-2004 AVALON VEHICLES. DUE TO IMPROPER CASTING OF THE STEERING LOCK BAR, THERE IS A POSSIBILITY THAT A MINUTE CRACK MAY DEVELOP ON THE SURFACE OF THE LOCK BAR. SUCH A CRACK MAY EXPAND OVER A LONG PERIOD OF REPEATED LOCK AND UNLOCK OPERATIONS, AND EVENTUALLY THE LOCK BAR COULD BREAK.
Consequence: SHOULD THE STEERING LOCK BAR BREAK, THE STEERING WHEEL WOULD LOCK AND THE DRIVER WOULD LOSE THE ABILITY TO STEER THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE STEERING INTERLOCK DEVICE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 7, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
10V270000
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
10V176000
Apr 30, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2003 SEQUOIA PASSENGER VEHICLES MANUFACTURED FROM APRIL 1, 2002 THROUGH APRIL 17, 2003. THE CENTER POSITION OF THE STEERING ANGLE SENSOR (SAS) MAY NOT BE STORED CORRECTLY DUE TO IMPROPER LOGIC OF THE SKID CONTROL ECU PROGRAMMING. THE VEHICLE STABILITY CONTROL (VSC) SYSTEM COULD ACTIVATE AT LOW SPEED FOR A FEW SECONDS DURING ACCELERATION FROM A STOPPED POSIT...
Consequence: SHOULD THIS OCCUR, THE VEHICLE MAY NOT ACCELERATE AS QUICKLY AS THE DRIVER EXPECTS, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL REFLASH THE ECU. IF THE REFLASH CANNOT BE COMPLETED ON A PARTICULAR VEHICLE, THE ECU WILL BE REPLACED WITH A NEW ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
10V160000
Apr 20, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUM...
Consequence: THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. ...
10V091000
Mar 10, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TUNDRA VEHICLES WITH FOUR WHEEL DRIVE, THERE IS A POSSIBILITY THAT AN IMPROPER WELD EXISTS AT THE UNION OF THE PROPELLER SHAFT AND YOKE. DUE TO THIS IMPROPER WELD, THIS JOINT MAY SEPARATE AND THE SEPARATED SHAFT MAY COME INTO CONTACT WITH THE ROAD SURFACE.
Consequence: THIS MAY RESULT IN A LOSS OF VEHICLE CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT PROPELLER SHAFT FREE OR CHARGE. THE SAFETY RECALL BEGAN ON MARCH 19, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
10V042000
Feb 18, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA TACOMA PICKUP TRUCKS. THE PROPELLER SHAFT MAY DEVELOP CRACKS DURING THE MANUFACTURING PROCESS. OVER TIME, THE CRACKS MAY EVENTUALLY LEAD TO THE SEPARATION OF THE PROPELLER SHAFT.
Consequence: THIS MAY RESULT IN A LOSS OF VEHICLE CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE FRONT PROPELLER SHAFT ON AFFECTED VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
10E002000
Feb 11, 2010
RIDE CONTROL IS RECALLING CERTAIN FRONT STRUT MOUNTS BRANDED AS GABRIEL RIDE CONTROL OR ARVINMERITOR, P/NOS. 142435, 142193, 142305, 142303, SOLD AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE AFFECTED FRONT STRUT MOUNTS DID NOT CONTAIN A WELD JOINT BETWEEN THE BEARING HOUSING AND THE RATE PLATE.
Consequence: THE ABSENCE OF THE WELD CAN ALLOW THE STRUT TO COME OUT OF ITS MOUNTING POSITION UNDER CERTAIN EXTREME DRIVING CONDITIONS WHICH COULD CAUSE DAMAGE TO SURROUNDING VEHICLE COMPONENTS INCREASING THE RISK OF A CRASH.
Remedy: RIDE CONTROL WILL NOTIFY OWNERS OF RECORD AND REPLACE THE AFFECTED PARTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 15, 2010. OWNERS MAY CONTACT RIDE CONTROL AT 1-248-458-1396.
10V039000
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
Consequence: VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
10V040000
Feb 9, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 CAMRYS. THE LENGTH OF THE POWER STEERING PRESSURE HOSE ON VEHICLES EQUIPPED WITH THE 4-CYLINDER (2AR-FE) ENGINE MAY BE INSUFFICIENT, SUCH THAT THE GAP BETWEEN THE CRIMP ON THE PRESSURE HOSE AND THE BRAKE TUBE FOR THE LEFT REAR BRAKE MAY BE INSUFFICIENT. UNDER THESE CIRCUMSTANCES THE BRAKE TUBE MAY INTERFERE WITH THE CRIMP AND MAY WEAR AND THEN PERFORAT...
Consequence: A BRAKE TUBE PERFORATION MAY RESULT IN BRAKE FLUID LEAKAGE. A LEAK IN BRAKE FLUID MAY IMPACT BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND, IF NECESSARY, DEALERS WILL REPLACE OR ADJUST THE BRAKE TUBE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 4, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
10V036000
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
10V035000
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V023000
Jan 27, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS ...
10V017000
Jan 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF...
Consequence: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE CO...
09V444000
Nov 18, 2009
TOYOTA IS RECALLING MODEL YEAR 2000-2003 TUNDRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA. EXCESSIVE CORROSION OF T...
Consequence: SEPARATION OF THE SPARE TIRE AND DIMINISHED BRAKE CAPACITY COULD INCREASE THE RISK OF A CRASH.
Remedy: TOYOTA IS ASKING OWNERS OF THE AFFECTED VEHICLES TO REMOVE THE SPARE TIRE FROM UNDER THE VEHICLE UNTIL A REMEDY CAN BE OBTAINED. DEALERS WILL INSPECT THE REAR CROSS MEMBER AND RELATED COMPONENTS, INCLUDING THE BRAKE LINES, AND REPLACE THEM IF NECESSARY. IF THE CROSS MEMBER DOES NOT NEED TO BE REPL...
09V434000
Nov 13, 2009
TOYOTA
LAND CRUISER
(2009) —
EQUIPMENT:APPLIANCE:AIR CONDITIONER
E-N-G MOBILE SYSTEM IS RECALLING CERTAIN MODEL YEAR 2008 CHEVROLET W5500, MODEL YEAR 2007-2009 DODGE 3500, MODEL YEAR 2009 MIGHTY MOVER, MODEL YEAR 2006-2009 FORD E-250, E-350 AND E-450, MODEL YEAR 2008-2009 GMC W4500, MODEL YEAR 2007 INTERNATIONAL 4300, MODEL YEAR 2009 TOYOTA LAND CRUISER VEHICLES EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. TH...
Consequence: THIS DEFECT COULD RESULT IN A FIRE.
Remedy: E-N-G MOBILE SYSTEM WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2009. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR E-N-G MOBILE SYSTEM AT 1-925-798-4060.
09V388000
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED A...
09V338000
Aug 27, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2009 SCION XD AND MY 2009-2010 COROLLA, AND COROLLA MATRIX VEHICLES EQUIPPED WITH 1.8L ENGINE AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, IDAHO, ILLINOIS, IOWA, KANSAS, MAINE, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WHEN DR...
Consequence: THIS COULD LEAD TO AN INCREASE IN VEHICLE STOPPING DISTANCE AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEWLY DESIGNED INTAKE AIR CONNECTOR WHICH WILL RELOCATE THE BRAKE SYSTEM VACUUM PORT. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 21, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
09V332000
Aug 19, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 COROLLA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE AIR BAG LABEL INSTALLED ON THE DRIVER SIDE SUN VISOR CAN SEPARATE FROM THE SURFACE OF THE VISOR.
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL INSPECT THE LABEL AND EXCHANGE THE DRIVER'S SIDE SUN VISOR FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 3, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
09V234000
Jun 25, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORIZED THROUGH VEHICLE PROCESSING CENTERS AND HAD ACCESSORIES INSTALLED THAT CAUSED THE VEHICLE TO EXCEED THE GVWR VALUE. ...
Consequence: THE GVWR IS INSUFFICIENT FOR THE LOAD CARRYING CAPACITY OF THE VEHICLES.
Remedy: TOYOTA WILL NOTIFY OWNERS INSTRUCTING THEM TO RETURN THEIR VEHICLE TO A TOYOTA OR LEXUS DEALER FOR AN EXCHANGE OF THE CERTIFICATION LABEL AND THE TIRE AND LOADING INFORMATION LABEL, AN INSTALLATION OF THE LOAD CARRYING CAPACITY MODIFICATION LABEL, IF NECESSARY, AND A CORRECTION TO THE OWNER'S MANUAL...
09V223000
Jun 15, 2009
TOYOTA
FJ CRUISER
(2005) —
EQUIPMENT:OTHER:LABELS
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.